2004 CHEVROLET SILVERADO Recalls (15)

Campaign:
04V045000 on 02/05/2004
Component:
Service brakes, hydraulic
Manufactured:
04/30/2003 - 06/29/2003
Affected:
68,875
Defect:
Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Consequence:
Consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
Correction:
Dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
Notes:
Gm recall no. 04004.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V129000 on 03/21/2004
Component:
Structure:body:tailgate:hinge and attachments
Manufactured:
02/28/2003 - 11/29/2003
Affected:
3,662,211
Defect:
On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Consequence:
Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
Correction:
Dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Notes:
Gm recall no. 04007.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04E022000 on 03/29/2004
Component:
Equipment
Affected:
8,000
Defect:
Aftermarket pickup truck over-the-rail bedliners manufactured for installation on 1999-2004 chevrolet silverado and gmc sierra pickup trucks. the toggle wing assembly used to attach the bedliner to the truck bed is not engaging fully in the stake pocket of the pickup truck.
Consequence:
The bedliner can become detached from the pickup while it is motion, possibly endangering following motorists or pedestrians.
Correction:
Durakon will issue a press release in attempt to notify customers that could have purchased the defective bedliner. if you purchased either a durakon allstar of patriot overrail bedliner since august 1, 2003, for 1999 to 2004 chevrolet silverado or gmc sierra trucks, or purchased one of these pickup trucks with either brand bedliner already installed, you should return to an authorized durakon dealer so that the bedliner can be inspected and, if necessary, repaired with a newly designed toggle wing fastening system, or if required, replaced with a new bedliner free of charge. please call the durakon hotline at 1-800-933-4200 to find the nearest authorized durakon dealer.
Notes:
This recall only pertains to aftermarket overrail bedliners and has no relation to any original equipment installed on chevrolet silverado and gmc sierra pickup trucks by general motors.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V225000 on 05/11/2004
Component:
Seat belts:front:anchorage
Manufactured:
07/31/2003 - 03/30/2004
Affected:
736
Defect:
Certain extended and regular cab pickup trucks and cargo vans converted to compressed natural gas (cng) fail to conform to the requirements of federal motor vehicle safety standard no. 225, 'child restraint anchorage systems.' these vehicles have one seating position, the center rear seat, equipped with child restraint lower anchorages.
Consequence:
The standard requires child seat lower anchorages in two seating positions for vehicles with three rear seating positions. the standard cab and cargo van vehicles, which only have front seating positions, have an air bag off switch to disable the front passenger air bag and do not have child restraint lower anchorages in the passenger seat. the standard requires passenger seat child seat lower anchorages in vehicles with an air bag off switch. however, the standard does not require vehicles with only front seating positions to have lower anchorage provisions if the vehicle is not equipped with an air bag off switch.
Correction:
To bring the standard cab and cargo van vehicles into compliance, dealers will inject epoxy into the air bag off switch to prevent air bag activation, relocate the switch behind the instrument panel and then install a cover over the resulting opening. the sun visor label and owner's manual will also be changed. the correction for the extended cab vehicle will consist of changing the front passenger seat to a seat that has child restraint lower anchorages. the recall began on september 9, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 04038.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V043000 on 02/07/2005
Component:
Service brakes, hydraulic
Manufactured:
01/31/2004 - 08/30/2004
Affected:
77,411
Defect:
Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
Consequence:
If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
Correction:
Dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493.
Notes:
Gm recall no. 05006.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V161000 on 04/21/2005
Component:
Parking brake
Manufactured:
03/31/2003 - 08/30/2004
Affected:
90,242
Defect:
On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Consequence:
If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
Correction:
Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 05042.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V163000 on 04/21/2005
Component:
Seat belts:rear
Manufactured:
04/07/2003 - 08/03/2004
Affected:
1,359,824
Defect:
On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
Consequence:
A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
Correction:
Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Notes:
Gm recall no. 05037.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E023000 on 03/13/2006
Component:
Exterior lighting:headlights
Affected:
292,000
Defect:
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Correction:
Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
Notes:
This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E060000 on 06/28/2006
Component:
Exterior lighting
Affected:
87,745
Defect:
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Correction:
Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
Notes:
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E064000 on 07/16/2006
Component:
Exterior lighting
Affected:
4,029
Defect:
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:
This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06V289000 on 08/02/2006
Component:
Engine and engine cooling
Manufactured:
02/28/2003 - 08/30/2004
Affected:
38,439
Defect:
On certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper.
Consequence:
If the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire.
Correction:
Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463.
Notes:
Gm recall no. 06080.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06V417000 on 10/31/2006
Component:
Air bags:frontal
Manufactured:
08/31/2003 - 01/30/2004
Affected:
794
Defect:
Certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction.
Consequence:
If the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. in either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be increased.
Correction:
Because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (gm) will repurchase these vehicles in accordance with the terms stated in gm's letter to owners. the recall began on november 6, 2006. owners should contact gm at 1-877-477-1022 to begin the process of repurchasing their vehicle.
Notes:
Gm recall no. 06102.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E106000 on 12/18/2007
Component:
Wheels:cap/cover/hub
Affected:
130,000
Defect:
Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. the inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence:
Wheel separation can result in a vehicle crash.
Correction:
Federal-mogul will notify customers and will replace the hub assembly free of charge. the recall began on february 7, 2008. owners can contact federal-mogul toll-free at 877-489-6659.
Notes:
This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

2004 CHEVROLET SILVERADO TSBs (578)

Bulletin:
990308002A
Component:
021000 suspension:front
Summary:
Front suspension coil spring noise. *tt
Bulletin:
010310010C
Component:
020000 suspension
Summary:
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. bulletin 01-03-10-010b not received. *tt
Bulletin:
020730004
Component:
103000 power train:automatic transmission
Summary:
New product information, grade brake feature of allison 1000 series transmission. *slc this bulletin replaces 02-07-30-004. *tt
Bulletin:
020601027
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on higher than expected oil consumption. nlm
Bulletin:
020730024A
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
Bulletin:
020941002
Component:
140000 air bags
Summary:
Air bag lamp on, passenger air bag indicator always reads off, diagnostic trouble code (dtc) b0092 set. *tt
Bulletin:
030604030
Component:
061000 engine and engine cooling:engine
Summary:
Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
030139008
Component:
353600 equipment:air conditioner
Summary:
Changes in air conditioning compessor on/off instrument panel display symbol from 2003 to 2004 model year and synchronizing the driver and passenger set temperatures. *tt
Bulletin:
990730022A
Component:
100000 power train
Summary:
Shift stabilization and tow/haul mode feature for hydra-matic 4l60-e/4l65-e and 4l80-e/4l85-e transmissions. *tt
Bulletin:
020605003C
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust moan/vibration. *tt update. *tt
Bulletin:
030864022
Component:
162300 structure:body:door
Summary:
Information on removing the front door trim panel during switch removal to avoid breakage. *tt
Bulletin:
020846010E
Component:
980000 unknown or other
Summary:
Programming onstar module for canadian french voice recognition. *tt update. *tt updated *eh
Bulletin:
052103
Component:
100000 power train
Summary:
Essential tools for servicing the allison transmission. these tools include a four-wheel drive spanner nut wrench, rear bearing puller legs, digital depth micrometer and a rear bearing installer. these tools are required to replace a cr
Bulletin:
080403
Component:
100000 power train
Summary:
This vme message applies to the valve body for the allison series 1000 transmission revised for the 2004 model year to add modulated main pressure control. this revision will provide additional transmission oil cooler flow and reduce pump
Bulletin:
080603
Component:
204000 wheels:cap/cover/hub
Summary:
Difficulty when installing wheel center caps to 17-inch aluminum wheels. vme message. *tt
Bulletin:
01267A
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light on, the 4wd is inoperative and no codes besides u1000 codes. service vme. *tt
Bulletin:
01332
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Dic message that the fuel cap is not on tight. service vme. *tt
Bulletin:
01329
Component:
980000 unknown or other
Summary:
2004 new model product changes. service vme. *tt
Bulletin:
01339
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Hvac blower motor fan stays on in the high blower position. service vme. *tt
Bulletin:
01343
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 diagnostic trouble code (dtc) p0700 and no communication with the tech 2. *tt
Bulletin:
00843C
Component:
350000 equipment
Summary:
Replacement (rke) transmitter is inoperative - service vme. *tt
Bulletin:
00634A
Component:
061000 engine and engine cooling:engine
Summary:
Gen iii engine noise after hot soak restart. *tt
Bulletin:
01129A
Component:
100000 power train
Summary:
Allison lct1000 serviceability. *tt
Bulletin:
00938B
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Allison lct1000 repeat transmission control module (tcm) failures with possible multiple diagnostic trouble codes (dtcs). *tt
Bulletin:
01275C
Component:
061000 engine and engine cooling:engine
Summary:
Some owners of 03 g-vans or 04 c/k trucks driving at high altitude with warm ambient temperatures may complain of a stall and or lack of power or running rough condition until the vehicle cools down. *tt
Bulletin:
00557B
Component:
103000 power train:automatic transmission
Summary:
The allison lct1000 transmissions may experience a leak from oil pump area. *tt
Bulletin:
01390
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm radio must be tuned to channel 1 through 66 during activation attempt. 2004 chevrolet canyon, gmc denali, gmc colorado also included. *tt
Bulletin:
01267B
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light on no codes besides u1000 codes. service vme. *tt
Bulletin:
01400
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
6.6l duramax lb7 engines with turbocharger system whine noise. *tt
Bulletin:
01457
Component:
350000 equipment
Summary:
Front license plate bracket. service vme. *tt
Bulletin:
01473
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Allison lct1000 diagnostic trouble code (dtc) p0700 unable to communicate with the transmission control module (tcm) using the tech 2. *tt
Bulletin:
030138015
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Hvac blower motor may run continuously after vehicle is turned off. *tt
Bulletin:
030603001A
Component:
061000 engine and engine cooling:engine
Summary:
Starter cranks after key is released (normal condition). *tt
Bulletin:
030604045
Component:
061000 engine and engine cooling:engine
Summary:
Revised diagnostic trouble code (dtc) p0093 or dtc p1093 diagnostic tables. *tt
Bulletin:
030604046
Component:
061000 engine and engine cooling:engine
Summary:
Revised engine cranks but does not run diagnostic. *tt
Bulletin:
030604047
Component:
090000 fuel system, other
Summary:
Revised fuel system diagnosis-high pressure side. *tt
Bulletin:
030604048
Component:
090000 fuel system, other
Summary:
Revised fuel system diagnosis cab chassis. *tt
Bulletin:
030525007
Component:
036000 service brakes, hydraulic:antilock
Summary:
Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
Bulletin:
030604049
Component:
070000 fuel system, gasoline
Summary:
Revised fuel system diagnosis pickup. *tt
Bulletin:
030604053
Component:
061000 engine and engine cooling:engine
Summary:
Revised fuel injector balance test with tech 2 (manual transmission). *tt
Bulletin:
030604054
Component:
061000 engine and engine cooling:engine
Summary:
Revised fuel injector balance test with tech 2 (automatic transmission). various models including 2003-2004 chevrolet kodiak and gmc topkick. *tt
Bulletin:
030693001A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt
Bulletin:
030730044
Component:
103000 power train:automatic transmission
Summary:
Information on allison transmission service repairs - full service of internal components. *tt
Bulletin:
030844018A
Component:
350000 equipment
Summary:
Rear seat audio (rsa) and/or rear hvac inoperative. *tt update. *tt
Bulletin:
030852005
Component:
350000 equipment
Summary:
Diagnostic information for replacement remote keyless entry (rke) transmitter inoperative - unable to synchronize. *tt
Bulletin:
990089015C
Component:
980000 unknown or other
Summary:
Light service support vehicle lssv (formerly commercial utility cargo vehicle - cucv ii and iii) service. *tt
Bulletin:
020421006C
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Inoperative 4wd/awd lamps, inoperative 4wd/awd system. *tt
Bulletin:
030601023
Component:
061000 engine and engine cooling:engine
Summary:
Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt
Bulletin:
030603007
Component:
061000 engine and engine cooling:engine
Summary:
Availability of starter motor solenoid if damaged during service. 2004 chevrolet kodiak c4500/5500 and gmc topkick c4500/5500 included. *tt
Bulletin:
030603008
Component:
061000 engine and engine cooling:engine
Summary:
Avoiding oil level sensor harness damage during lower oil pan installation. *tt
Bulletin:
030730031D
Component:
103000 power train:automatic transmission
Summary:
Transmission leaks, slips, vehicle will not move. *tt
Bulletin:
030850014
Component:
110000 electrical system
Summary:
Intermittent no start, service stability message, anti-lock brake system (abs) light illuminated, multiple diagnostic trouble codes (dtcs), dic shows unknown driver, various electrical related conditions. includes escalade esv and ext mod
Bulletin:
030864028
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Availability of replacement parts for wide load outside rearview mirrors. *tt
Bulletin:
030864029
Component:
162300 structure:body:door
Summary:
Information on removing front door trim panel to avoid breakage. *tt
Bulletin:
00908C
Component:
102000 power train:manual transmission
Summary:
6.6l and manual transmission growl noise while engaging or disengaging clutch. these are c/k models. *tt
Bulletin:
01444
Component:
980000 unknown or other
Summary:
Xm dealer assistance line information. *tt
Bulletin:
01470
Component:
180000 vehicle speed control
Summary:
Erratic idle, idle surge, rough run, or near stall. *tt
Bulletin:
000235003C
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
030419001A
Component:
106000 power train:axle assembly
Summary:
Use of synthetic front axle lubricant for 4wd vehicles sold in cold weather climates. *tt this bulletin replaced previous bulletin dated 10/01/2003. *tt
Bulletin:
030604060
Component:
061000 engine and engine cooling:engine
Summary:
Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt
Bulletin:
020601022C
Component:
061000 engine and engine cooling:engine
Summary:
Information on engine ticking. including 2004 chevrolet kodiak c45/c5500 series and 2004 gmc topkick c4500/c5500 series. *tt update. *tt
Bulletin:
030730054
Component:
100000 power train
Summary:
Transmission fluid leaks out of vent when truck is started after a cold soak. *tt
Bulletin:
030730053
Component:
103000 power train:automatic transmission
Summary:
Allison automatic transmission valve body hardware changes. *tt
Bulletin:
030234001A
Component:
017500 steering:linkages:tie rod assembly
Summary:
Inner tie rod released for service. *tt
Bulletin:
100803
Component:
061000 engine and engine cooling:engine
Summary:
The engine diagnostic fuel leaks inside of the engine. gm voicemail log. this includes 2000 - 2004 chevroand gmc c4500 and 5500 trucks. *tt
Bulletin:
100803
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Excessive duramax turbocharger whine noise or possibly a performance or a fuel economy complaint. gm voicemail log. this includes 2003-2004 4500 and 5500 trucks. *tt
Bulletin:
100903
Component:
061000 engine and engine cooling:engine
Summary:
Duramax diesel fuel in oil diagnostics revisited. gm voicemail log. this includes c4500 and 5500 trucks. *tt
Bulletin:
010730038B
Component:
103000 power train:automatic transmission
Summary:
The service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt
Bulletin:
030861002B
Component:
162000 structure:body
Summary:
Snap/popping type noise coming from front of vehicle. *tt 03-08-61-002b, dated 05/01/2004 replaced. *tt
Bulletin:
030309002
Component:
020000 suspension
Summary:
Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
Bulletin:
01555
Component:
020000 suspension
Summary:
D height specification missing from si. sit bulletin 1410632. *tt
Bulletin:
01561
Component:
353600 equipment:air conditioner
Summary:
Sizzle noise after vehicle shut off. service vme. sit bulletin 1410828. *tt
Bulletin:
01564
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Inside rearview mirror compass inoperative. service vme. sit bulletin 1411219. *tt
Bulletin:
01567
Component:
010000 steering
Summary:
Quadrasteer service update. sit bulletin 1411394. *tt
Bulletin:
01332A
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Tighten fuel cap message on the dic. sit bulletin 1411567. *tt
Bulletin:
01568
Component:
081100 fuel system, diesel:storage:tank assembly
Summary:
Hard to fill fuel tank at high volume diesel pumps. sit bulletin 1411583. *tt
Bulletin:
01588
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Change in gas cap tether attachment point. service vme. sit bulletin 1414321. *tt
Bulletin:
01592
Component:
110000 electrical system
Summary:
2003-2004 generation 5 onstar steering wheel control function explanation. sit bulletin 1416474. *tt
Bulletin:
00908D
Component:
102000 power train:manual transmission
Summary:
6.6l and manual transmission growl noise while engaging or disengaging clutch. *tt *mj
Bulletin:
01485A
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain tensioner breakpoints for service kit or production fix for vehicle exhibiting rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. sit bulletin 1408407. *tt
Bulletin:
01531
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust moan vibration. sit bulletin 1408514. *tt
Bulletin:
00574A
Component:
110000 electrical system
Summary:
Allison lct1000 no shift, speedometer erratic/inoperative, diagnostic trouble codes (dtcs) p0721, c0237 possible anti-lock brake system (abs) lamp on. si bulletin 1408789. *tt
Bulletin:
01512
Component:
061200 engine and engine cooling:engine:diesel
Summary:
6.6 liter duramax diesel engine fuel knock noise. various models including the 2004 gmc c4500 and c5500. sit bulletin 1406247. *tt
Bulletin:
01516
Component:
021300 suspension:front:shock absorber
Summary:
Squeak noise emanating from the front shock area. sit bulletin 1404925. *tt
Bulletin:
01159A
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirrors memory operation. sit bulletin 1404207. *tt
Bulletin:
00702
Component:
103000 power train:automatic transmission
Summary:
Slip condition in 2nd, 3rd or 4th damaged 2-4 band 3-4 clutch on the 4l60e/4l65e automatic transmission. *tt *mj
Bulletin:
01499
Component:
061000 engine and engine cooling:engine
Summary:
2004 6.6l duramax lb7 engines with extended crank during hot engine restart. diagnostic trouble code (dtc) p0193 may or may not be set. sit bulletin 1402202. *tt
Bulletin:
01496
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
6.6l lb7 duramax diesel turbocharger noises or fuel economy complaint. service vme. sit bulletin 1401355. *tt
Bulletin:
01483
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Vehicle has no pcm (power train control module) communication with tech 2. sit bulletin 1400427. *tt
Bulletin:
01493
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 prndl flash and/or will not move with p0721, p0731, p0732, p0733, p0734, p0743, p0746, p0747, p0776, p0777, p1720, p1721, p1723 and p1724. *tt
Bulletin:
01495
Component:
080000 fuel system, diesel
Summary:
Duramax diesel fuel in oil diagnostics. service vme. lb7 6.6l engine. sit bulletin 1401353. various models including 2003 and 2004 gmc c4500 and 5500 trucks. *tt
Bulletin:
001496A
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
This message is in regard to duramax turbocharger noises or possibly a performance or fuel economy complaint. service vme. 6.6 lb7 diesel engine. p0102, p0103, p0236. *tt
Bulletin:
3259C
Component:
103000 power train:automatic transmission
Summary:
4l80e, 4l85e whine noise in first and second gear. *tt
Bulletin:
030138019
Component:
353600 equipment:air conditioner
Summary:
Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
Bulletin:
030308003
Component:
020000 suspension
Summary:
Squeak noise coming from the front of the vehicle. *tt
Bulletin:
030310006
Component:
020000 suspension
Summary:
Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin:
030730056
Component:
103000 power train:automatic transmission
Summary:
4l60-e automatic transmission oil pump first and second design identification. *tt
Bulletin:
030605008B
Component:
063000 engine and engine cooling:exhaust system
Summary:
Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt
Bulletin:
030730057
Component:
103000 power train:automatic transmission
Summary:
Transmission fluid leak from front of transmission - torque converter housing/pump area. 2500/3500 series models. *tt
Bulletin:
030864037
Component:
133000 visibility:power window devices and controls
Summary:
Front power window noisy or inoperative on vehicles located in michigan only. *tt
Bulletin:
01791
Component:
222000 seats:mid/rear assembly
Summary:
Rear seat does not fold down into the stowed position.*mr
Bulletin:
01804
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Service vme- outside mirror glass falls out.*mr
Bulletin:
01766
Component:
138000 visibility:defroster/defogger system
Summary:
Fogging of windows in the defrost mode. also including models: 2003-2004 gmc yukon xl, denali xl, 2003-2004 sierra denali. *mr
Bulletin:
01716
Component:
100000 power train
Summary:
Allison lct1000 transmission prndl inoperative and no communication with the tech 2 scan tool. sit bulletin 1455451. *tt
Bulletin:
01717
Component:
980000 unknown or other
Summary:
6.6l lb7 engine - fuel rail pressure regulator harness connector servicing. *tt
Bulletin:
01774
Component:
061000 engine and engine cooling:engine
Summary:
6.6l lb7 repeat engine oil leak (left side) #2 main bearing cross bolt. *mr
Bulletin:
01242A
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
6.6l lb7 lly diesel engine drive belt chirping on shut down. sit bulletin 1460352. *tt
Bulletin:
01790
Component:
170000 latches/locks/linkages
Summary:
Rear quarter glass hinge (latch) loose. *mr
Bulletin:
00778A
Component:
160000 structure
Summary:
Business trip and/or personal trip odometer inoperative. sit bulletin 1460572. *tt
Bulletin:
01759
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm rapid activation utilization. *mr
Bulletin:
01747
Component:
070000 fuel system, gasoline
Summary:
Locking gas cap availability. *mr
Bulletin:
01736
Component:
010000 steering
Summary:
Service 4 wheel steer message with diagnostic trouble code (dtc) c0455. sit bulletin 1459978. *tt
Bulletin:
01737
Component:
110000 electrical system
Summary:
Poor ground connection causing diagnostic trouble code (dtc) c0265. sit bulletin 1460187. *tt
Bulletin:
01761
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge diverts to empty after idling on incline. sit bulletin 1459166. *tt
Bulletin:
01698
Component:
131000 visibility:windshield
Summary:
Windshield reveal molding flutering. service vme. sit bulletin 1450940. *tt
Bulletin:
01701
Component:
061000 engine and engine cooling:engine
Summary:
4.8 5.3 lm4 lm7 lr4 engine - with o2 sensor codes p0135, p0141, p0155, p0161. sit bulletin 1452753. *tt
Bulletin:
01704
Component:
353600 equipment:air conditioner
Summary:
Programming control heads - hvac ac. *tt
Bulletin:
01712
Component:
021000 suspension:front
Summary:
Left front of vehicle sits low. sit bulletin 1454860. *tt
Bulletin:
01897
Component:
010000 steering
Summary:
Lack of steering assist or shudder during parking lot type maneuvers. *mr
Bulletin:
1146
Component:
980000 unknown or other
Summary:
Stop delivery order on certain vehicles with 4l80e or 4l8e automatic transmission. this also includes 2004 gmc, chevrolet w-medium duty and isuzu w series. *tt
Bulletin:
01935
Component:
353000 equipment:electrical
Summary:
Product information on rear slider. *mr
Bulletin:
01901
Component:
200000 wheels
Summary:
Excessive tire spin setting diagnostic trouble code (dtc) co542. also including 2002, 2003 sierra denali. *mr
Bulletin:
01896
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
6.6 lly duramax diesel engine turbocharger learn procedure. *mr
Bulletin:
01932
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 dark or discolored transmission fluid with no loss of performance. *mr
Bulletin:
01946
Component:
127000 exterior lighting:hazard flashing warning lights
Summary:
Hazard light flashes when turn signal applied. *mr
Bulletin:
01924
Component:
021530 suspension:front:control arm:lower arm
Summary:
Front lower control arm change. *mr
Bulletin:
01939
Component:
061000 engine and engine cooling:engine
Summary:
4.3 4.8 5.3 6.0 lr4 lu3 lm7 l59 lq4 lq9 engines- evap code p0442. *mr
Bulletin:
10012003
Component:
062000 engine and engine cooling:cooling system
Summary:
Blueheat coolant heater thermo top c. webasto. *mr
Bulletin:
01850
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Drivers or passengers heated seats turn on by themselves. *mr
Bulletin:
1158
Component:
980000 unknown or other
Summary:
Stop delivery order inspection claim submission. also including 2004 isuzu w-series. *mr
Bulletin:
1148
Component:
980000 unknown or other
Summary:
Stop delivery order (chevrolet bac 113611-114593). *mr
Bulletin:
01862
Component:
220000 seats
Summary:
Driver personalization regarding memory seats. *mr
Bulletin:
01864
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio cd skips/ejects or clock resets to 12:00. *mr *tt
Bulletin:
01863
Component:
016000 steering:electric power assist system
Summary:
Lack of steering assist when stopped or during parking lot type maneuvers. *mr
Bulletin:
01824
Component:
110000 electrical system
Summary:
6.6l lly engine - diagnostic trouble code (dtc) u0106 resets or will not clear. *mr
Bulletin:
01849
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Vehicles equipped with xm do not have audio, am, fm work correctly. *mr
Bulletin:
01856
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Allison lct1000 will not shift from park due to ice, snow or mud build-up on shift linkage. *mr
Bulletin:
01822
Component:
160000 structure
Summary:
Front door frame contacts the windshield reveal molding. *mr
Bulletin:
01919
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Replacement radio reads cal error, has no audio or will not program. *tt
Bulletin:
04019
Component:
100000 power train
Summary:
4l80e / 4l85e transmission may have a condition in which the transmission overdrive gear set may fail due to inadequate lubrication as a result of a transmission casting change. customer satisfaction program bulletin. also to include 2004
Bulletin:
01966
Component:
353600 equipment:air conditioner
Summary:
Inoperative air conditioner system or lack of cooling. *mr
Bulletin:
01953
Component:
110000 electrical system
Summary:
Abs and red brake malfunction indicator light on with no diagnostic trouble codes. *mr
Bulletin:
02029
Component:
061000 engine and engine cooling:engine
Summary:
Inaccurate fuel gauge readings and/or engine stall. *mr
Bulletin:
01958
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Product information regarding radio personalization. *mr
Bulletin:
01999
Component:
110000 electrical system
Summary:
Diagnostic trouble code tips- lct1000 transmission. *mr
Bulletin:
01989
Component:
080000 fuel system, diesel
Summary:
6.6l lly diesel engine fuelinjector compression leak noise or soot around the injector body.*mr
Bulletin:
02007
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Power folding mirrors will not fold inward.*mr
Bulletin:
01955
Component:
170000 latches/locks/linkages
Summary:
Passenger door module lock up.*mr
Bulletin:
02013
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant leak from head cup plugs on gen iii engines. *mr
Bulletin:
01640
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Electronic brake control module part restriction.*mr *mj
Bulletin:
01605
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 intermittent no reverse cold only.*mr
Bulletin:
01601
Component:
136300 visibility:windshield wiper/washer:linkages
Summary:
Windshield wiper arm loose.*mr
Bulletin:
01619
Component:
061000 engine and engine cooling:engine
Summary:
6.6 lly engine glow plugs are not interchangeable with the current 6.6 lb7 glow plugs.*mr
Bulletin:
01761B
Component:
072000 fuel system, gasoline:delivery
Summary:
Fuel gauge diverts to empty after idling on incline or refueling. *nm
Bulletin:
01634
Component:
010000 steering
Summary:
Intermediate steering shaft service kit. service vme. *tt
Bulletin:
01654
Component:
103000 power train:automatic transmission
Summary:
Squawk or grunt noise that occurs on the 2-3 upshift on vehicles with 4l60e - m30, 4l60e m32 transmission. *tt
Bulletin:
01599
Component:
100000 power train
Summary:
4l60e, 4l65e forward and low reverse waved steel clutch plate appearance change. *tt
Bulletin:
01678
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
6.6 lly duramax diesel engines have an issue with the high pressure fuel lines that prevent them from achieving the proper torque upon reinstallation after a repair. *tt
Bulletin:
01662
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm error on a radio display. *tt
Bulletin:
00764B
Component:
061000 engine and engine cooling:engine
Summary:
6.6l diesel engine rough idle, clatter, stall and/or diagnostic trouble code (dtc) p1223. *tt
Bulletin:
01485B
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt
Bulletin:
01919A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Replacement radio reads cal error, has no audio or will not program. *tt
Bulletin:
01634A
Component:
010000 steering
Summary:
Supplement to 00-02-35-003d - clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
01222A
Component:
107000 power train:axle hubs
Summary:
Repeat rear axle hub seal leak. *tt
Bulletin:
01588A
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Fuel cap tether strap too short. *tt
Bulletin:
00678B
Component:
061000 engine and engine cooling:engine
Summary:
Engine overheats on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin:
00372D
Component:
353000 equipment:electrical
Summary:
Onstar system is attempting and/or completing phone calls which the operator of the vehicle did not initiate. *tt
Bulletin:
00442A
Component:
140000 air bags
Summary:
Dual stage air bag used in single stage application. *tt
Bulletin:
01737A
Component:
110000 electrical system
Summary:
Poor ground connection causing diagnostic trouble code (dtc) c0265. *tt
Bulletin:
02116
Component:
105000 power train:driveline
Summary:
Highway speed vibration on k2500hd 4wd vehicles equipped with a 4l80e automatic transmission. *tt
Bulletin:
02113
Component:
100000 power train
Summary:
Intermittent no forward or reverse with possibly either a flashing prndl display or a range shift inhibited message. *tt
Bulletin:
00844
Component:
136000 visibility:windshield wiper/washer
Summary:
Front windshield wiper arm does not remain upright position as it did on prior models and as a result, customer may inadvertently brake the wiper arm trying to extend the blade. *mj
Bulletin:
00609B
Component:
061000 engine and engine cooling:engine
Summary:
Low power, will not go over 2300 rpms. 6.6l lb7 engine. *tt
Bulletin:
00968A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
6.6l lb7 lly diesel engine with rough, unstable, low idle speed or stall. *tt
Bulletin:
01845
Component:
061000 engine and engine cooling:engine
Summary:
Normal engine operating noise characteristics. *tt
Bulletin:
01119A
Component:
061000 engine and engine cooling:engine
Summary:
Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt
Bulletin:
01977
Component:
100000 power train
Summary:
Allison lct1000 prndl flash and/or will not move. *tt
Bulletin:
01972
Component:
061000 engine and engine cooling:engine
Summary:
Erratic oil pressure gmt 610 or gmt800 with codes p0522 or p0523. *tt 01972a replaced and updated 01/01/04. *sc
Bulletin:
00700A
Component:
061000 engine and engine cooling:engine
Summary:
4.3l l35 engine wide open throttle diagnostic trouble code (dtc) p0335, p0336, p0339. *tt *mj
Bulletin:
00266
Component:
061000 engine and engine cooling:engine
Summary:
Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt
Bulletin:
01330
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 buzz, moan noise at 1400 rpm with the 8.1 l18 gas engine. *tt
Bulletin:
00573
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Low audio output from speakers. *mj
Bulletin:
01267F
Component:
110000 electrical system
Summary:
Service 4wd light on no codes besides u1000 codes or c0550. *mj
Bulletin:
01217B
Component:
110000 electrical system
Summary:
Allison lct1000 diagnostic trouble codes (dtc) p1711, p0872 after completing repairs. *mj
Bulletin:
01060A
Component:
111000 electrical system:battery
Summary:
Roof beacon switch left on causing battery draw. gmc gmt 800. *mj 2005 models added. *tt
Bulletin:
00677
Component:
980000 unknown or other
Summary:
Snow plow prep package information - service vme. *mj
Bulletin:
00786
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Buzz noise and virbation in the accelerator pedal at approx. 10 mph on start up. *mj
Bulletin:
02051
Component:
061000 engine and engine cooling:engine
Summary:
Intermittent service engine soon (ses) light comes on and code p0700 along with diagnostic trouble code p0742 stored. *tt
Bulletin:
02052
Component:
160000 structure
Summary:
Noise coming from instrument panel cluster or tachometer. *tt
Bulletin:
02053
Component:
030000 service brakes, hydraulic
Summary:
Information on resurfacing the park brake portion of the rear brake rotor. *tt
Bulletin:
02054
Component:
060000 engine and engine cooling
Summary:
Elimination of low coolant message from dic. service vme. *tt
Bulletin:
02055
Component:
060000 engine and engine cooling
Summary:
Engine oil in the turbo charge air cooler pipes and hoses. *tt
Bulletin:
02092
Component:
060000 engine and engine cooling
Summary:
Gurgle noise may be heard from the engine coolant compartment on trucks built with rpo hp2 parallel hybrid system. *tt
Bulletin:
02069
Component:
100000 power train
Summary:
Allison lct1000 range inhibit and/or will not move. *tt
Bulletin:
02086
Component:
100000 power train
Summary:
4l60e, 4l65e intermittent neutral from a stop or steady speed. *tt
Bulletin:
02089
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Inaccurate fuel gauge readings and/or engine stall. service vme. *tt
Bulletin:
00856
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 oil pump whine, buzz on cold start. *tt
Bulletin:
00993
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirror glass may crack. *tt
Bulletin:
01936
Component:
162000 structure:body
Summary:
Painted body side moldings dimple (raised surface). service vme. *tt
Bulletin:
01927
Component:
110000 electrical system
Summary:
A no charge condition with diagnostic trouble code (dtc) p0380, p0621. *tt
Bulletin:
01188A
Component:
127100 exterior lighting:hazard flashing warning lights:unit
Summary:
Unable to locate emergency light relay and/or blunt cut wires. *tt
Bulletin:
04039
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. special policy adjustment - injectors - replace. *mj updated 2/21/08. *nj csc letter was received. updated 3/5/10. *pe
Bulletin:
01250C
Component:
111000 electrical system:battery
Summary:
Battery or charge indicator light remains on for up to 30 seconds after a cold start and engine running. *tt
Bulletin:
00872A
Component:
061000 engine and engine cooling:engine
Summary:
Oil pan or oil cooler line leak on gen iii v-8 engines equipped with an oil cooler. *tt
Bulletin:
01353
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire due to injector fretting corrosion. *tt
Bulletin:
00823A
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Power steering fluid leaking at hydraulic brake booster. *tt
Bulletin:
040604007
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin:
040089020A
Component:
980000 unknown or other
Summary:
Pre-delivery and service guide - parallel hybrid truck. *tt updated *eh
Bulletin:
0408111002
Component:
162000 structure:body
Summary:
Raised surface, dimple in body side molding. *mj this bulletin replaced previous bulletin 04-08-111-002, dated 05/01/2004. *tt
Bulletin:
030864010
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirrors may blow in at highway speeds or power folding feature appears inoperative. also to include 2005 models. *tt
Bulletin:
040495001
Component:
105300 power train:driveline:driveshaft
Summary:
Revised wheel drive shaft nut torque specification. *tt
Bulletin:
040525002B
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
Bulletin:
040850007
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Service information for front heated seat inoperative/cold. *mj
Bulletin:
3011
Component:
061000 engine and engine cooling:engine
Summary:
Repeat engine oil leak at main bearing side bolt. *tt
Bulletin:
3015
Component:
061000 engine and engine cooling:engine
Summary:
6.0l lq4 vin u engine restriction. *tt
Bulletin:
1531156
Component:
080000 fuel system, diesel
Summary:
Parts showing no stock or not available. *mj
Bulletin:
1530076
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles and hummer h2 with a high altitude stall. *mj
Bulletin:
3014
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Fuel sender information on trucks with 6.6l diesel. *tt
Bulletin:
3015
Component:
020000 suspension
Summary:
Wheel alignment specs for spring special and texas truck. *tt
Bulletin:
3025
Component:
220000 seats
Summary:
Repairing cloth seats with napped fabric. *mj
Bulletin:
3028
Component:
022000 suspension:rear
Summary:
Replacement tailgate cables bind at shoulder bolt. *mj
Bulletin:
3002
Component:
100000 power train
Summary:
4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
Bulletin:
3018
Component:
061000 engine and engine cooling:engine
Summary:
Engine cylinder head cup plug coolant leak. *mj
Bulletin:
3010
Component:
110000 electrical system
Summary:
Glow plug control module loss of communication, possible diagnostic trouble code (dtc) u0106 set, and dtc will not clear. *tt
Bulletin:
3025
Component:
061000 engine and engine cooling:engine
Summary:
04 model year 4.8.5.3.7.6.0 gen iii engine piston pin information. *mj
Bulletin:
3009A
Component:
020000 suspension
Summary:
Suspension vibration or frame beaming at 40 -60 mph. *mj
Bulletin:
00313
Component:
020000 suspension
Summary:
Squeak or creak noise from underbody over bumps. *mj
Bulletin:
3001
Component:
106000 power train:axle assembly
Summary:
The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
Bulletin:
3004
Component:
061000 engine and engine cooling:engine
Summary:
4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj
Bulletin:
3000
Component:
162300 structure:body:door
Summary:
Service vme - 03 - 04 full size truck, utilities and hummer h2 passenger door module inoperative. *mj
Bulletin:
3002
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Service vme - switching mirrors from power folding to power extending. *mj
Bulletin:
3001
Component:
110000 electrical system
Summary:
No communication with any modules, multipe u-diagnostic trouble codes (dtcs), instrument panel cluster (ipc) warning indicators. 03-04 chevrolet all full size trucks and utilities and 03-04 gmc all full size trucks and utilities and 03-04
Bulletin:
3000A
Component:
022000 suspension:rear
Summary:
Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin:
02172004
Component:
132000 visibility:glass, side/rear
Summary:
Latch on the rear quarter glass is loose or has become detached from the window glass. gm voicemail express. *tt
Bulletin:
04222004
Component:
103000 power train:automatic transmission
Summary:
Rattle type noise due to a cracked flex plate. gm voicemail express. *tt
Bulletin:
3067
Component:
162900 structure:body:roof and pillars
Summary:
Tinny rattle type noise from the roof at highway speeds. *tt
Bulletin:
3045
Component:
200000 wheels
Summary:
Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
Bulletin:
3051
Component:
185000 vehicle speed control:cruise control
Summary:
Cruise control and/or the power take off unit (pto) may be inoperative. *tt
Bulletin:
3048
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Timing chain tensioner breakpoints for service kit or production kit. supplement to 03-06-01-024b. *tt
Bulletin:
3083
Component:
100000 power train
Summary:
M74 allison lct1000 pto gear applications. *tt
Bulletin:
3086
Component:
353600 equipment:air conditioner
Summary:
Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
Bulletin:
3084
Component:
113000 electrical system:starter assembly
Summary:
Starter grinding noise during cranking on vehicles equipped with the allison automatic transmission. *tt
Bulletin:
3086
Component:
061000 engine and engine cooling:engine
Summary:
Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt
Bulletin:
3087
Component:
061000 engine and engine cooling:engine
Summary:
Crank no start with no cranking rpm spark or injector pulse. *tt
Bulletin:
3087
Component:
090000 fuel system, other
Summary:
Updated part number for bulletin 04-08-49-019 stall, inaccurate/incorrect fuel gauge reading. *tt
Bulletin:
3089
Component:
162000 structure:body
Summary:
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. *tt
Bulletin:
3089
Component:
110000 electrical system
Summary:
Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt
Bulletin:
3073
Component:
185000 vehicle speed control:cruise control
Summary:
Downhill cruise control surge. *tt
Bulletin:
3075B
Component:
110000 electrical system
Summary:
Blown mbec 1 or lbec 1 fuse. *tt
Bulletin:
3076
Component:
353600 equipment:air conditioner
Summary:
Repeat hvac blower motor failure. *tt
Bulletin:
3068
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb
Bulletin:
3022A
Component:
061000 engine and engine cooling:engine
Summary:
04 full size trucks and utilities with vin g, n, t, v and u engines may have a high altitude, high ambient temperature stall. *tt
Bulletin:
3078
Component:
021600 suspension:front:wheel bearing
Summary:
Grease leak from front hub bearing. *tt update. *tt
Bulletin:
3072
Component:
062000 engine and engine cooling:cooling system
Summary:
The engine coolant temperature or intake air temperature sensor may read -40 degrees when monitored with tech 2. *tt
Bulletin:
3050A
Component:
350000 equipment
Summary:
02-05 onstar equipped vehicles emitting beeping noise before connecting to onstar. *tt
Bulletin:
3038
Component:
061000 engine and engine cooling:engine
Summary:
Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt
Bulletin:
3057
Component:
010000 steering
Summary:
Intermittent concern of the service 4 wheel steer message being displayed on the dic. *tt
Bulletin:
3054
Component:
100000 power train
Summary:
Replacement flexplate may have larger bolt holes than the original flexplate. *tt
Bulletin:
3055
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
Bulletin:
3062
Component:
980000 unknown or other
Summary:
Additional part numbers for bulletin 02-01-38-007b. *tt
Bulletin:
3063
Component:
982000 other:school bus stop arm assembly
Summary:
Performance package rpo pcx. *tt
Bulletin:
30559
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 diagnostic trouble code p1711, p0872 after completing repairs. *tt
Bulletin:
3128
Component:
160000 structure
Summary:
All full size trucks pick up box sheet metal fracture/damage with aftermarket accessories installed. *sc
Bulletin:
3109
Component:
060000 engine and engine cooling
Summary:
Engineering is investigating the 04 6.6l lb7 injectors for concerns of dtc p1093 and high return line flow rates. *sc
Bulletin:
3122
Component:
162000 structure:body
Summary:
Dimple in the body side molding. *sc
Bulletin:
3105C
Component:
100000 power train
Summary:
Ping, pop, snap, or click noise from the propeller shaft. *sc
Bulletin:
3155
Component:
180000 vehicle speed control
Summary:
Speedometer inoperative. *tc
Bulletin:
3129A
Component:
070000 fuel system, gasoline
Summary:
Smoke, fuel knock, surging, and high injector balance rates. *tc to include 2005 chevrolet kodiak and gmc topkick. *tt
Bulletin:
3100
Component:
060000 engine and engine cooling
Summary:
Low power service engine soon/malfunction indicator light on diagnostic trouble code p0116 and p0299. *sc
Bulletin:
3157
Component:
190000 tires
Summary:
Excessive tire spin setting diagnostic trouble code c0543. *tc
Bulletin:
3132A
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Nvg149 np3 transfer case may exhibit a bind or shudder on turns. *tc
Bulletin:
3110
Component:
091130 fuel system, other:storage:tank assembly:pressure relief devices
Summary:
Erratic oil pressure with diagnostic trouble code's p0522 and/or p0523. *sc
Bulletin:
3159
Component:
110000 electrical system
Summary:
Instrument panel cluster parts restriction. *tc
Bulletin:
3160
Component:
060000 engine and engine cooling
Summary:
Gas engines exhaust buzz or rattle noise. *tc
Bulletin:
3134B
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd indicator illuminated. *tc with diagnostic trouble code co327. *tt
Bulletin:
3121
Component:
060000 engine and engine cooling
Summary:
Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
Bulletin:
3101
Component:
180000 vehicle speed control
Summary:
Engine low speed engine rpm surge. *sc
Bulletin:
3130
Component:
100000 power train
Summary:
Allison lct 1000 prndl flash and/or will not move. *tc
Bulletin:
3119
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Engineering investigation - catalytic converter replacement. *sc
Bulletin:
3138
Component:
060000 engine and engine cooling
Summary:
Accessory drive belt chirp noise at cold idle. *tc
Bulletin:
3120
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Onstar center unable to perform remote diagnostic. (2004-2005 chevrolet yukon, 2005 chevrolet trailblazer, 2002, 2003, 2005 buick rainier, 2005 chevrolet express van, and 2005 cadillac seville) *sc
Bulletin:
3106
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm radio was working prior to july 26, 2004 and it is inoperative now. *jb
Bulletin:
3121
Component:
060000 engine and engine cooling
Summary:
6.6 lb7 engine with a no charge condition with diagnostic trouble code p0380 p0621. *sc
Bulletin:
3107
Component:
060000 engine and engine cooling
Summary:
P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
Bulletin:
3113
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Gen 6 vehicles in mount airy, nc cannot connect to onstar or emergency services. *sc
Bulletin:
3095
Component:
100000 power train
Summary:
Allison lct 1000 transmission prndl inoperative and no communication with the tech 2 scan tool. *sc updated *eh
Bulletin:
3092
Component:
100000 power train
Summary:
Allison lct 1000 buzz noise feel on tcc apply. *sc
Bulletin:
3090
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Unable to perform set up new onstar on vehicles with gen 6.05 hardware. *sc
Bulletin:
3097
Component:
060000 engine and engine cooling
Summary:
Oil pan or oil cooler line leak. *sc
Bulletin:
3094
Component:
110000 electrical system
Summary:
Allison lct 1000 p1781 or p0802 setting in the electronic control module. (2005 chevrolet kodiak and 2005 gmc top kick) *sc
Bulletin:
3121
Component:
062000 engine and engine cooling:cooling system
Summary:
Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
Bulletin:
00837
Component:
100000 power train
Summary:
Allison lct1000 overdrive disable lamp inoperative after installation of instrument panel (ip). *tt
Bulletin:
3151
Component:
100000 power train
Summary:
Allison lct1000 transmission hard to remove from park. *tt
Bulletin:
3156
Component:
100000 power train
Summary:
261 transfer case drivelines growl 1100-1200 rpm. *tt
Bulletin:
3044
Component:
350000 equipment
Summary:
Generation 5 onstar steering wheel control function. *tt
Bulletin:
3056
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
Bulletin:
3078
Component:
090000 fuel system, other
Summary:
Some 2004 full size trucks and utilities may experience a diagnostic trouble code p0442. *tt
Bulletin:
04007A
Component:
162500 structure:body:tailgate
Summary:
Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
Bulletin:
3161
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 clunk noise on start in park. *eh
Bulletin:
3170
Component:
103000 power train:automatic transmission
Summary:
Harsh 1-2 shift. *eh
Bulletin:
3137
Component:
106000 power train:axle assembly
Summary:
Service 4wd light on and no communication with transfer case control module. *eh
Bulletin:
3061C
Component:
110000 electrical system
Summary:
Diagnostic trouble code c0327 with or without additional diagnostic trouble codes setting. *tt
Bulletin:
3193
Component:
060000 engine and engine cooling
Summary:
Excessive oil consumption. *eh
Bulletin:
3235
Component:
190000 tires
Summary:
20 inch wheels stop sell on 1500 crew cab with 5'8' bed. *eh
Bulletin:
3204
Component:
060000 engine and engine cooling
Summary:
Coolant leak at engine mount bolt. *eh
Bulletin:
3113
Component:
980000 unknown or other
Summary:
No connect. gen 6 vehicles in ashe, alleghany, surry and wilkes county, nc cannot connect o onstar or emergency services. *tt
Bulletin:
3205
Component:
100000 power train
Summary:
Allison lct1000 pump separator plate change disregard additional valve. *tt
Bulletin:
3187
Component:
060000 engine and engine cooling
Summary:
Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe
Bulletin:
3208
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Certain 2004 6.6l lly duramax diesel engines may have an issue with the high pressure fuel lines that prevent them from achieving the proper torque upon reinstallation after a repair. *tt
Bulletin:
3011B
Component:
060000 engine and engine cooling
Summary:
Engine oil leak at main bering side bolt. *eh
Bulletin:
3149
Component:
090000 fuel system, other
Summary:
Fuel pressure regulator connector or terminal repairs. *tt
Bulletin:
3087
Component:
060000 engine and engine cooling
Summary:
Crank no start, stall, hard start, and no cranking rpm. *eh
Bulletin:
040604065
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Engineering investigation (ei #04073) high, low or erratic oil pressure gauge reading setting diagnostic trouble codes p0522 and/or p0523. 2004 isuzu w4 also included. *tt update. *tt
Bulletin:
040731006
Component:
100000 power train
Summary:
Excessive shifter and/or engine vibration, bearing growl and/or rattle type noise while depressing or releasing clutch pedal. *tt
Bulletin:
040523001A
Component:
030000 service brakes, hydraulic
Summary:
Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
Bulletin:
040604001
Component:
061000 engine and engine cooling:engine
Summary:
Various intermittent driveability conditions - hesitation, lack of power, etc. *tt
Bulletin:
040731001
Component:
100000 power train
Summary:
Revised clutch pressure plate adjustment. *tt
Bulletin:
040864003
Component:
133000 visibility:power window devices and controls
Summary:
Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
Bulletin:
040138010
Component:
353600 equipment:air conditioner
Summary:
Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
Bulletin:
040139009
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Hvac blower motor inoperative or stays running. *tt
Bulletin:
040602006
Component:
061000 engine and engine cooling:engine
Summary:
Engine overheating. *tt
Bulletin:
040849019
Component:
090000 fuel system, other
Summary:
Cranks but no start, stall, inaccurate/incorrect fuel gauge reading, no fuel, vehicle is out of fuel and fuel gauge reads above empty. *tt this bulletin replaces previous bulletin number 04-08-49-019. *tt
Bulletin:
020139007
Component:
980000 unknown or other
Summary:
Automatic dual zone hvac battery draw. *ar
Bulletin:
040850016B
Component:
220000 seats
Summary:
Memory seat may not return to requested position. *eh
Bulletin:
09132004
Component:
060000 engine and engine cooling
Summary:
Rough idle with white smoke and high balance rates. a 1700 1800 light throttle combustion noise. parking lot surge under ten miles per hour with engine rpm around 800 to 1000 rpm. this also includes 2004 3500 trucks with 6.6 liter diesel en
Bulletin:
3068B
Component:
060000 engine and engine cooling
Summary:
Turbo air charge cooler hoses oil seepage or blows off on acceleration. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin:
3212A
Component:
060000 engine and engine cooling
Summary:
Fuel leaking from body of injector. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin:
3227
Component:
060000 engine and engine cooling
Summary:
Broken #2 and #7 injector connector terminals. this also includes lly 6.6 c2 c3 c4 c5 k2 k3 d4 d5 e4 e5. *eh
Bulletin:
3230
Component:
060000 engine and engine cooling
Summary:
Diesel oil leak at right rear of engine. this includes lly c2 c3 c4 c5 d4 d5 e4 e5 k2 k3 models. *eh
Bulletin:
3238C
Component:
060000 engine and engine cooling
Summary:
Fuel injector driver circuit codes p0201 through p0208. this also includes 2004 2005 lly c2 c3 c4 c5 e4 e5 d4 d5 k2 k3 models. *eh updated *eh
Bulletin:
3239
Component:
060000 engine and engine cooling
Summary:
Lb7 engine vibration miss or runs rough no diagnostic trouble code. this also includes lb7 c2 c3 c4 c5 d4 d5 e4 e5 k2 k3. *eh
Bulletin:
3243
Component:
103000 power train:automatic transmission
Summary:
Leak from the vent 4l80e/4l85e transmission. *eh
Bulletin:
3227
Component:
162500 structure:body:tailgate
Summary:
Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
Bulletin:
3057
Component:
010000 steering
Summary:
Service 4 wheel steer message with diagnostic trouble code c0455. *eh
Bulletin:
000235003
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
Bulletin:
020138007
Component:
353600 equipment:air conditioner
Summary:
Poor air conditioner performance - air conditioner will not blow cold enough. this service bulletin replaces 020138007a. *eh
Bulletin:
040850011
Component:
150000 seat belts
Summary:
Repairing napped seat fabric. *eh
Bulletin:
040523005
Component:
030000 service brakes, hydraulic
Summary:
Availability of rear wheel mud flaps to reduce debris build-up on rear brake calipers and/or rear wheels. *tt
Bulletin:
040601018
Component:
061000 engine and engine cooling:engine
Summary:
Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt
Bulletin:
040601020
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil leak near oil filter. *tt
Bulletin:
040604007E
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin:
020730011
Component:
103000 power train:automatic transmission
Summary:
Slow or no engagement of automatic transmission no start blank prndl display flashing prndl diagnostic trouble code p0708 p0872 p0847 p0875 p1711 p1713 or u1000 set. this service bulletin replaces 020730011. *eh
Bulletin:
030310002
Component:
190000 tires
Summary:
Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
Bulletin:
030310006D
Component:
190000 tires
Summary:
20 inch wheels and tires available through gmspo. *eh *tt
Bulletin:
040604043
Component:
061000 engine and engine cooling:engine
Summary:
Unable to reset engine oil life monitor. *tt
Bulletin:
040138008
Component:
353600 equipment:air conditioner
Summary:
Heat ventilation and air conditioning system cannot be controlled or defaults to defrost mode. *eh
Bulletin:
040848003
Component:
131000 visibility:windshield
Summary:
Windrush around windshield. *tt
Bulletin:
040852005
Component:
350000 equipment
Summary:
Remote keyless entry (rke) system inoperative. *tt
Bulletin:
040941003
Component:
140000 air bags
Summary:
Proper use of labor operation code when diagnosis leads to sir passenger presence system replacement. *tt
Bulletin:
030604036
Component:
060000 engine and engine cooling
Summary:
Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb
Bulletin:
040525005A
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Antilock brake system light on service brake system message on driver information center. *eh updated *eh
Bulletin:
040601012
Component:
060000 engine and engine cooling
Summary:
Rattle or crackling noise from engine compartment. *eh updated 03-07-06. *kb
Bulletin:
040604007A
Component:
060000 engine and engine cooling
Summary:
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. this service bulletin replaces 040604007. *eh
Bulletin:
040604032
Component:
060000 engine and engine cooling
Summary:
Proper method to secure fuel cap during refueling. *eh
Bulletin:
040849007
Component:
110000 electrical system
Summary:
Personal trip business trip feature must be on for trip odometer to accumulate. *eh
Bulletin:
040850003
Component:
150000 seat belts
Summary:
Enabling memory seat feature via dic if feature appears inoperative. *eh
Bulletin:
040603002
Component:
060000 engine and engine cooling
Summary:
Diagnostic information for intermittent vehicle no crank dead battery. *eh
Bulletin:
040604070
Component:
061000 engine and engine cooling:engine
Summary:
Information on the revised fuel filter for the 6.6l duramax diesel. *tt
Bulletin:
040138013
Component:
353600 equipment:air conditioner
Summary:
Hvac not cold enough a/c compressor does not engage . *eh
Bulletin:
040138014
Component:
353600 equipment:air conditioner
Summary:
High pitched tone heard inside vehicle when ac compressor is engaged. *eh
Bulletin:
020601023C
Component:
060000 engine and engine cooling
Summary:
Oil leak at cooler to engine block mating surface. *eh
Bulletin:
03122004
Component:
980000 unknown or other
Summary:
Please stop the delivery due to the limitations of the gm administrative message system. *tt
Bulletin:
01292004
Component:
133000 visibility:power window devices and controls
Summary:
Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
Bulletin:
10192004
Component:
200000 wheels
Summary:
20 inch plus wheels are no longer to be installed on this body style. *eh
Bulletin:
10292004
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
This is in regards to the unnecessary changing of turbochargers due to oil seepage. *tt
Bulletin:
08242004
Component:
100000 power train
Summary:
Bearing growl or rattle type noise while depressing or releasing the clutch pedal. *tt
Bulletin:
11062003
Component:
060000 engine and engine cooling
Summary:
Airflow sensor problem. *eh
Bulletin:
3300C
Component:
341000 communications:horn assembly
Summary:
Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
Bulletin:
050090001
Component:
060000 engine and engine cooling
Summary:
Information on the proper air filter for the duramax diesel. *eh
Bulletin:
0502118001
Component:
010000 steering
Summary:
Quadrasteer intermittent service 4-wheel steer message. *tt
Bulletin:
0508132001
Component:
350000 equipment
Summary:
Accessory power outlet (apo) turns off automatically - parallel hybrid truck (rpo hp2). *tt
Bulletin:
050730002
Component:
103000 power train:automatic transmission
Summary:
New essential tool j 45096 23 automatic transmission oil cooler line adapter for allison transmission. *eh
Bulletin:
3343
Component:
211000 trailer hitches:fifth wheel assembly
Summary:
Why the crew cab short bed (5 foot 8 inch) is not recommended for fifth wheel trailering. *tt
Bulletin:
3280
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Rust found in the injector inlet filter during injector repairs. *tt
Bulletin:
3282
Component:
061000 engine and engine cooling:engine
Summary:
Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin:
3292
Component:
060000 engine and engine cooling
Summary:
Diesel engine balance rates all showing zero. *eh
Bulletin:
3373
Component:
140000 air bags
Summary:
Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
Bulletin:
3386
Component:
015000 steering:hydraulic power assist system
Summary:
Lack of steering assist or shudder during parking lot type maneuvers. *tt
Bulletin:
3294
Component:
106000 power train:axle assembly
Summary:
Highway speed vibration on smooth surface. *eh
Bulletin:
3299
Component:
060000 engine and engine cooling
Summary:
Diesel oil leak from pcv vent tube. *eh
Bulletin:
3300
Component:
105000 power train:driveline
Summary:
4wd models with noise, vibration on dry pavement. *eh
Bulletin:
04056
Component:
200000 wheels
Summary:
20 inch plus size wheel restriction - supplement to accessories bulletin acc04-056. gm voicemail express. *tt
Bulletin:
07012004
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
Bulletin:
3346
Component:
061000 engine and engine cooling:engine
Summary:
There has been a high percentage of no trouble found (ntf) 6.6 lly engine control modules (ecms) being returned to the warranty parts center. the no trouble found (ntf) ecms are being replaced for a specific list of diagnostic trouble code
Bulletin:
3464
Component:
162310 structure:body:door:hinge and attachments
Summary:
Door hinge replacement kit. *tt
Bulletin:
3348
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Noise, service engine soon (ses) light, or low power. dealer may find turbine (exhaust side) wheel rub damage, a broken turbine shaft, or turbo bearing concern. *tt
Bulletin:
03102005
Component:
010000 steering
Summary:
Steering gear whistle noise on turns. *eh
Bulletin:
3351
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
Bulletin:
3352
Component:
100000 power train
Summary:
Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module. *tt
Bulletin:
3155
Component:
110000 electrical system
Summary:
No shift, speedometer erratic/inoperative, p0721 c0237 p0500 c0055. *tt
Bulletin:
3357
Component:
110000 electrical system
Summary:
Malfunction indicator light is on and the vehicle has a code p0706. *tt
Bulletin:
3232
Component:
061000 engine and engine cooling:engine
Summary:
1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
Bulletin:
3499
Component:
017300 steering:linkages:arm:idler and attachment
Summary:
Steering idler arm inspection procedure. *tt
Bulletin:
3375
Component:
060000 engine and engine cooling
Summary:
Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt
Bulletin:
3380
Component:
060000 engine and engine cooling
Summary:
Oil leak from the pcv vent tube. *tt
Bulletin:
020307002
Component:
020000 suspension
Summary:
Revised front caster and camber adjustment procedure. original not yet received. *tt
Bulletin:
3328A
Component:
060000 engine and engine cooling
Summary:
Surge at idle or 1100 to 1400 rpm. *eh
Bulletin:
3364
Component:
106000 power train:axle assembly
Summary:
Rear axle retainer button breakage. *eh
Bulletin:
050603001
Component:
060000 engine and engine cooling
Summary:
Revised engine electrical and automatic transmission - 4l60e/4l65e subsections - new caution statements added. *tt
Bulletin:
050604021
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt
Bulletin:
050604023
Component:
060000 engine and engine cooling
Summary:
Revised diagnostic trouble code (dtc) p2563. *tt
Bulletin:
050604024
Component:
060000 engine and engine cooling
Summary:
Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
Bulletin:
050604025
Component:
060000 engine and engine cooling
Summary:
Revised diagnostic trouble code (dtc) u2104. *tt
Bulletin:
050846006A
Component:
350000 equipment
Summary:
Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital). *tt
Bulletin:
701
Component:
090000 fuel system, other
Summary:
Fuel filter replacement. gm tech link. *tt
Bulletin:
610
Component:
162000 structure:body
Summary:
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. gm tech link. *tt
Bulletin:
609
Component:
021700 suspension:front:hub
Summary:
Front hub bearing grease leak. *sc
Bulletin:
510
Component:
220000 seats
Summary:
Repairing napped fabric-seats may have been upholstered in napped fabrics with dorchester on the bolster and honeycomb on the insert. *sc
Bulletin:
702
Component:
061000 engine and engine cooling:engine
Summary:
Duramax air filter. gm tech links. *tt
Bulletin:
708
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Heated seats turn off. *sc
Bulletin:
3504
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Hard start hot only after the engine has reached operating temperature and then shut off. *tt
Bulletin:
05546
Component:
355200 equipment:other:owners/service/other manual
Summary:
Program bulletin (customer satisfaction program)-15,000 mile (24,000 km) fuel filter change. 2002 chevrolet kodiak and 2001-2002 gmc topkick. *sc
Bulletin:
3497
Component:
103000 power train:automatic transmission
Summary:
Range inhibit and/or will not move. *tt
Bulletin:
3671
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Service vme - outside rearview mirror vibration. *tt
Bulletin:
3526
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
Bulletin:
3525
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Service vmx - duramax injector wiring harness support bracket kit. *tt
Bulletin:
3562A
Component:
190000 tires
Summary:
Bridgestone dueler product information update. *tt *sc
Bulletin:
3556
Component:
061000 engine and engine cooling:engine
Summary:
Hard start or extended crank time on initial cold start when using alcohol blended fuels. *sc
Bulletin:
3491
Component:
090000 fuel system, other
Summary:
Highway speed excessive smoke and fuel knock. *tt
Bulletin:
3427
Component:
110000 electrical system
Summary:
Additional diagnostic information dtc p0757. *tt
Bulletin:
3394C
Component:
080000 fuel system, diesel
Summary:
Duramax diesel injector driver codes. misfire, rough running, and the malfunction indicator lamp (mil) / service engine soon (ses) light on. *tt
Bulletin:
3568A
Component:
030000 service brakes, hydraulic
Summary:
Service brake booster message. *tt
Bulletin:
3438A
Component:
103000 power train:automatic transmission
Summary:
Tcc surge and/or fluid contamination. *tt
Bulletin:
3394
Component:
061000 engine and engine cooling:engine
Summary:
6.6 lly injector driver codes. misfire, rough running, and the mil/ses light on. *sc
Bulletin:
3639
Component:
135000 visibility:rearview mirrors/devices
Summary:
Service vme-outside rear view mirror inoperative. *sc
Bulletin:
3400
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Rough idle, fuel knock or smoke while driving, combustion leak type noise, or a misfire. 6.6 lly injector knock, heavy smoke during warm up cycle. *tt
Bulletin:
3545
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Blower motor inoperative at low ambient temperatures. *tt
Bulletin:
3225A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc
Bulletin:
3260
Component:
100000 power train
Summary:
4l80e/4l85e harsh shift or slip no tcc apply. *tt
Bulletin:
3048A
Component:
061000 engine and engine cooling:engine
Summary:
Supplement to 03-06-01-024b 4.3l lu3 l35 timing chain tensioner. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. *tt
Bulletin:
3267
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc
Bulletin:
3258
Component:
061000 engine and engine cooling:engine
Summary:
6.6l lly engine oil leak at rear housing cover bolt. *tt
Bulletin:
3272
Component:
180000 vehicle speed control
Summary:
Diesel hesitation or throttle delay. *sc
Bulletin:
3256A
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Vehicle may be brought in for service engine soon (ses) or malfunction indicator lamp (mil) light on. *tt
Bulletin:
3422
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Inaccurate outside temperature reading on inside rearview mirror. *tt
Bulletin:
3322
Component:
061000 engine and engine cooling:engine
Summary:
Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161. *tt
Bulletin:
3328B
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Engine rpm surge at 1100 to 1400 rpm. this condition may be noticed more when towing. *tt
Bulletin:
3312
Component:
060000 engine and engine cooling
Summary:
No start, hard start, loss of power, or white smoke. *tt
Bulletin:
3314
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Duramax diesel engine hard start, no start, stall of diagnostic trouble code p0093, p1093. *tt
Bulletin:
3317
Component:
060000 engine and engine cooling
Summary:
Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe
Bulletin:
3105
Component:
100000 power train
Summary:
Ping, pop, snap or click noise from the propeller shaft. *tt
Bulletin:
3343
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil dipstick unseated or oil leak. *tt
Bulletin:
3616A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge inoperative or inaccurate, the service engine soon malfunction indicator lamp on, or front fuel tank is over filled with fuel, to the top of the filler cap. *tt
Bulletin:
3630A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge is inaccurate or reads empty on diesel equipped chassis cab with dual tanks. *tt
Bulletin:
3616
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge inaccurate/ diagnostic trouble code p0461 and or p2636/ transfer pump will not shut off. *tt
Bulletin:
3573
Component:
133000 visibility:power window devices and controls
Summary:
Unwanted operation of rear windows. *tt
Bulletin:
3424
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Electronic transfer case unable to complete shift. *tt
Bulletin:
3422
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Duramax diesel pilot to main injection fuel knock noise. *tt
Bulletin:
3569
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005). *tt
Bulletin:
050604029
Component:
061000 engine and engine cooling:engine
Summary:
Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300. *tt
Bulletin:
050604008
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt
Bulletin:
050310005
Component:
200000 wheels
Summary:
Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
Bulletin:
050730013
Component:
103000 power train:automatic transmission
Summary:
4l60-e/4l65-e automatic transmission second gear start, lack/loss of power when accelerating from a stop. *tt
Bulletin:
050138012
Component:
353600 equipment:air conditioner
Summary:
Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated *kb
Bulletin:
050850008
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Intermittent heated seats inoperative, diagnostic trouble code b3941 set. *tt
Bulletin:
05-06-04-047
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light on with reduction in engine power, diagnostic trouble codes p0202 and p2146 or p0207 and p2149 set. *tt add dtc p1294. install revised 90 degree injector connector with harness support bracket servi
Bulletin:
050601014
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt
Bulletin:
0502118002
Component:
010000 steering
Summary:
Diagnostic trouble code c0455, service rear wheel steering, system jumps from 4-wheel steer to 2-wheel steer. *tt
Bulletin:
050730017
Component:
103000 power train:automatic transmission
Summary:
4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission. *tt
Bulletin:
05-04-21-003
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
Bulletin:
0509610018
Component:
060000 engine and engine cooling
Summary:
Accessory drive belt chirp, squeal, or squeak type noise at cold idle. *tt
Bulletin:
050604063
Component:
061000 engine and engine cooling:engine
Summary:
Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement. *tt
Bulletin:
050850012
Component:
220000 seats
Summary:
Unwanted/loose seat movement. *tt
Bulletin:
3639
Component:
060000 engine and engine cooling
Summary:
Oil pressure gauge reading low or near red zone. *tt
Bulletin:
3287B
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Heated seat inoperative or shut off in 30 seconds. diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module. *tt
Bulletin:
3616
Component:
090000 fuel system, other
Summary:
Service vme - 2006 duramax diesel engine fuel system components are not interchangeable with earlier year model vehicles. *tt
Bulletin:
3766
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Front blower inoperative stay running during low ambient temperature. *tt
Bulletin:
3100C
Component:
060000 engine and engine cooling
Summary:
Ses light due to dtc p0116. *tt
Bulletin:
3691A
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Front hvac blower inoperative. *tt
Bulletin:
050849026
Component:
060000 engine and engine cooling
Summary:
Low oil pressure message display and chimes activated while driving following hybrid (hp2) lm7 engine auto-start (reprogram the pcm). *ts
Bulletin:
3665
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4wd inoperative and possible dtc c0327 stored in the transfer case control module. *tt
Bulletin:
3170E
Component:
121000 exterior lighting:headlights
Summary:
Ipc, interior lights and/or headlamps flicker. *ak fb2
Bulletin:
3673
Component:
185000 vehicle speed control:cruise control
Summary:
Cruise control inoperative and/or malfunction indicator lamp on with diagnostic trouble code p0833 stored. the condition may not be able to be duplicated by the dealer yet the consumer may have a repeat concern. *ak
Bulletin:
3691B
Component:
061000 engine and engine cooling:engine
Summary:
Generation iii v8 engine piston repairs. *tt
Bulletin:
060601003
Component:
061000 engine and engine cooling:engine
Summary:
Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt
Bulletin:
060232001
Component:
010000 steering
Summary:
Increased steering and brake effort. *tt
Bulletin:
050604077
Component:
061000 engine and engine cooling:engine
Summary:
Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak
Bulletin:
060308002
Component:
021510 suspension:front:control arm:upper arm
Summary:
Revised upper control arm replacement. *tt
Bulletin:
3630
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Inaccurate fuel gauge readings/rear float arm stuck. *tt updated 03-01-07. *kb updated 3/15/10. *pe
Bulletin:
3401
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Turbocharger oil feed line kinked or restricted. *tt
Bulletin:
3870
Component:
101000 power train:clutch assembly
Summary:
Clutch pedal fade or clutch will not disengage typically when towing. *tt
Bulletin:
3927
Component:
103000 power train:automatic transmission
Summary:
Engine with a repeat cracked flywheel. *kb
Bulletin:
4150
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Dual tanks fuel gauge defaults to empty - new calibrations. stall start tank transfer. vehicles with 6.6l rpo lb7 or lly engines. *kb
Bulletin:
060604026
Component:
061000 engine and engine cooling:engine
Summary:
Intermittent ses/mil lamp illuminated, reduced engine power, fuel injector driver circuit. dtc's p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208. cylinder bank shut down dtc's p2146, or p2149. *kb
Bulletin:
030693001
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb
Bulletin:
3340
Component:
021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:
Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
Bulletin:
3562
Component:
190000 tires
Summary:
Bridgestone dueler product information update. *kb
Bulletin:
3009
Component:
020000 suspension
Summary:
Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe
Bulletin:
3190
Component:
110000 electrical system
Summary:
Unable to locate emergency light relay and/or blunt cut wires. *kb
Bulletin:
4179
Component:
140000 air bags
Summary:
Dual stage passenger air bag used in single stage application. *kb
Bulletin:
3713
Component:
133000 visibility:power window devices and controls
Summary:
Door glass pops out of run channel. *kb
Bulletin:
3136
Component:
102000 power train:manual transmission
Summary:
Slip condition in 2nd, 3rd, or 4th. damaged 2-4 or 3-4 clutch. *kb updated 10/31/07. *nj
Bulletin:
4231
Component:
061000 engine and engine cooling:engine
Summary:
Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
Bulletin:
3425
Component:
190000 tires
Summary:
Unable to program tire size in ebcm/vses. *kb
Bulletin:
060417002
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Rear drive axle whine noise (replace slip yoke assembly). *kb
Bulletin:
010310010
Component:
020000 suspension
Summary:
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. *kb
Bulletin:
3568
Component:
040000 service brakes, air
Summary:
Service brake booster message. *kb
Bulletin:
4365
Component:
330000 interior lighting
Summary:
Ipc backlighting inoperative tbc 2a fuse open. *kb
Bulletin:
4030
Component:
106000 power train:axle assembly
Summary:
New design front axle side bearing adjusters. *kb
Bulletin:
070601009
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Diesel engine cylinder head gasket missing thickness grade markings. *kb
Bulletin:
060139002
Component:
061000 engine and engine cooling:engine
Summary:
Front blower motor inoperative or may not shut off in extremely low ambient temperature conditions. *kb
Bulletin:
4144
Component:
102000 power train:manual transmission
Summary:
Allison lct1000 harsh 3-2, 2-1 downshift, and abs may activate. *kb
Bulletin:
040525002
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
Bulletin:
050232008
Component:
015100 steering:hydraulic power assist:pump
Summary:
Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
Bulletin:
3075
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Blown mbec 1 or lbec 1 fuse. *kb
Bulletin:
4486
Component:
117000 digital instrument panel
Summary:
One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
Bulletin:
070842013
Component:
126100 exterior lighting:turn signal:flasher unit
Summary:
Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
Bulletin:
07187
Component:
117000 digital instrument panel
Summary:
Cadillac\chevrolet\gmc service campaign: see document search button for owner letter. instrument panel cluster gauge needle function may cause inaccurate readings on some 2003-2004 cadillac, chevrolet, and gmc vehicles. *nj updated 2/5
Bulletin:
PIP-4290
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Engine surge or stall at stop and/or dtc p0742 possible tcc applied. equipped with allison lct1000 transmission rpo m74 or mw7. *nj updated 4/22/13. *pe
Bulletin:
07057
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment - engine glow plug on certain vehicles with 6.6l diesel v8 (rpo lb7 - vin 1) engine & california emissions (yf5/ne1) or clean fuel emis
Bulletin:
PIP3394
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Duramax diesel injector driver codes with 6.6 engine (vin 2 - rpo lly). *nj
Bulletin:
PIP3343
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
Bulletin:
PIP4054A
Component:
022000 suspension:rear
Summary:
Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin:
000235003N
Component:
012000 steering:column
Summary:
Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin:
08136
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. on-board diagnostics (obd)-fuel level sender-reprogram engine control module (ecm). csc was received. *pe
Bulletin:
PIT3504D
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
Bulletin:
07187A
Component:
117000 digital instrument panel
Summary:
Cadillac\chevrolet\gmc service campaign: see document search button for owner letter. some vehicles could develop a condition where one or more of the instrument panel gauge needles may stick, flutter, or become inoperative. csc letter
Bulletin:
08-089
Component:
353000 equipment:electrical
Summary:
Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin:
PIT-3046E
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin:
PIT-4722
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
Bulletin:
08-089B
Component:
355200 equipment:other:owners/service/other manual
Summary:
Buick\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. csc letter was received. *pe
Bulletin:
08089-B
Component:
110000 electrical system
Summary:
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin:
PIP-4629
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin:
PIP-4492P
Component:
061000 engine and engine cooling:engine
Summary:
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin:
SB-10-02-33-001
Component:
010000 steering
Summary:
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin:
PIP-3504C
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm
Bulletin:
PIT-3749D
Component:
161000 structure:frame and members
Summary:
Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
Bulletin:
PIP-4138K
Component:
060000 engine and engine cooling
Summary:
Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
10-00-89-017C
Component:
980000 unknown or other
Summary:
Gm: information on fixing multiple situations right the first time. *rm
Bulletin:
PI-0011A
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
Bulletin:
PB-10037A
Component:
110000 electrical system
Summary:
Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm
Bulletin:
SB-10240
Component:
353600 equipment:air conditioner
Summary:
General motors service campaign: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm updated 4/6/12. *pe
Bulletin:
PIP-3366-B
Component:
103000 power train:automatic transmission
Summary:
Cadillac/chevrolet/gmc/hummer: some suvs and trucks are exhibiting a condition where by grinding/ratcheting type noise coming from automatic transmission when shifting into park while in 4wd low (4lo) range. *pe
Bulletin:
SB-13-05-22-001
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
Bulletin:
SB-080604003-C
Component:
060000 engine (pws)
Summary:
Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500, topkick c4500-c5500, 2006-15 express, savana. *pe
Bulletin:
UIB-117
Component:
061000 engine and engine cooling:engine
Summary:
General motors: an optional engine block heater plug in for onboard ac power and with continuous usage will result in shorting of wires, over heating system, electrical failure and compartment engine fires. model 2003-15 express cut away
Bulletin:
06-03-09-004H
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
Bulletin:
PIT5195A
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIT3227J
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
PIP3119M
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
Bulletin:
PIT4780Q
Component:
100000 hybrid powertrain
Summary:
This preliminary information communication advises the technician that parallel hybrid truck parts are on parts restriction. dealer will need to call general motors technical assistance center for further assistance.
Bulletin:
06-06-01-010C
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period.
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIT3237G
Component:
131000 visibility:windshield
Summary:
This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
Bulletin:
PIP4379K
Component:
103000 power train:automatic transmission
Summary:
This preliminary information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. technician may find diagnostic trouble codes
Bulletin:
PIT3078F
Component:
021700 suspension:front:hub
Summary:
This preliminary information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. technician should not replace the bearing for grease purge. technician should be advised to n
Bulletin:
PIP5072
Component:
101000 power train:clutch assembly
Summary:
This preliminary information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. technician will inspect the 3-4 clutches and the forward clutch
Bulletin:
PIT3665C
Component:
030000 brakes (pws)
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT3330F
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. dealer should advise the customer starting in 2003 the passenger c
Bulletin:
PIT3271F
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIP3259J
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. technician should compare the noise to a like vehicle. technician will nee
Bulletin:
PIP4138L
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
Bulletin:
PIT5195
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIP4972C
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that will not move in forward or reverse. technician may find diagnostic trouble code p0877 or p2723 set. technician will need to inspect the v
Bulletin:
PIT4780M
Component:
100000 hybrid powertrain
Summary:
This preliminary information communication advises the technician that the 2004-2007 parallel hybrid truck parts will be placed on restriction through the general motors technical assistance center. dealer will need to contact general motor
Bulletin:
PIP3119L
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
Bulletin:
PIT3665E
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT3227M
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
00-03-10-003R
Component:
190000 tires
Summary:
This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
Bulletin:
06-06-01-010B
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information on close-coupled converter and engine replacement.
Bulletin:
05-00-89-055E
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information to clarify proper transaction administration of gm dealer empowerment program and goodwill cases.
Bulletin:
15-08-44-001B
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
05-06-04-035E
Component:
090000 fuel system, other
Summary:
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:
02-07-30-052J
Component:
103000 power train:automatic transmission
Summary:
This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool j-45096 transflow®.
Bulletin:
15-08-44-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-73-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
09-09-40-001C
Component:
150000 seat belts
Summary:
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
Bulletin:
10-00-89-017X
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
Bulletin:
11-00-89-005C
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
07-08-49-020I
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides a quick guide to updating which model vehicle after replacing the ipc.
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC3278F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIT3271G
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC5953A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech

Home | Privacy