2004 CHEVROLET AVALANCHE Recalls (6)
- Campaign:
- 04V045000 on 02/05/2004
- Component:
- Service brakes, hydraulic
- Manufactured:
- 04/30/2003 - 06/29/2003
- Affected:
- 68,875
- Defect:
- Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
- Consequence:
- Consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
- Correction:
- Dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
- Notes:
- Gm recall no. 04004.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V129000 on 03/21/2004
- Component:
- Structure:body:tailgate:hinge and attachments
- Manufactured:
- 02/28/2003 - 11/29/2003
- Affected:
- 3,662,211
- Defect:
- On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
- Consequence:
- Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
- Correction:
- Dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
- Notes:
- Gm recall no. 04007.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V043000 on 02/07/2005
- Component:
- Service brakes, hydraulic
- Manufactured:
- 01/31/2004 - 08/30/2004
- Affected:
- 77,411
- Defect:
- Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
- Consequence:
- If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
- Correction:
- Dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493.
- Notes:
- Gm recall no. 05006.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 05V163000 on 04/21/2005
- Component:
- Seat belts:rear
- Manufactured:
- 04/07/2003 - 08/03/2004
- Affected:
- 1,359,824
- Defect:
- On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
- Consequence:
- A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
- Correction:
- Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
- Notes:
- Gm recall no. 05037.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 06E043000 on 05/21/2006
- Component:
- Fuel system, gasoline
- Affected:
- 88,303
- Defect:
- Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.
- Consequence:
- This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.
- Correction:
- Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
- Notes:
- This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06V289000 on 08/02/2006
- Component:
- Engine and engine cooling
- Manufactured:
- 03/31/2003 - 08/30/2004
- Affected:
- 38,439
- Defect:
- On certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper.
- Consequence:
- If the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire.
- Correction:
- Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463.
- Notes:
- Gm recall no. 06080.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2004 CHEVROLET AVALANCHE TSBs (334)
- Bulletin:
- 020730024A
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
- Bulletin:
- 020941002
- Component:
- 140000 air bags
- Summary:
- Air bag lamp on, passenger air bag indicator always reads off, diagnostic trouble code (dtc) b0092 set. *tt
- Bulletin:
- 030417001C
- Component:
- 106000 power train:axle assembly
- Summary:
- Whine noise from rear axle. *tt update. *tt
- Bulletin:
- 030604030
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
- Bulletin:
- 030139008
- Component:
- 353600 equipment:air conditioner
- Summary:
- Changes in air conditioning compessor on/off instrument panel display symbol from 2003 to 2004 model year and synchronizing the driver and passenger set temperatures. *tt
- Bulletin:
- 990730022A
- Component:
- 100000 power train
- Summary:
- Shift stabilization and tow/haul mode feature for hydra-matic 4l60-e/4l65-e and 4l80-e/4l85-e transmissions. *tt
- Bulletin:
- 030864022
- Component:
- 162300 structure:body:door
- Summary:
- Information on removing the front door trim panel during switch removal to avoid breakage. *tt
- Bulletin:
- 020846010E
- Component:
- 980000 unknown or other
- Summary:
- Programming onstar module for canadian french voice recognition. *tt update. *tt updated *eh
- Bulletin:
- 01267A
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Service 4wd light on, the 4wd is inoperative and no codes besides u1000 codes. service vme. *tt
- Bulletin:
- 01332
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Dic message that the fuel cap is not on tight. service vme. *tt
- Bulletin:
- 01339
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Hvac blower motor fan stays on in the high blower position. service vme. *tt
- Bulletin:
- 01345
- Component:
- 190000 tires
- Summary:
- Low tire pressure light on after installing aftermarket wheels/tires. *tt
- Bulletin:
- 01367
- Component:
- 162000 structure:body
- Summary:
- Noise from lower door or running board at road speeds. *tt
- Bulletin:
- 00843C
- Component:
- 350000 equipment
- Summary:
- Replacement (rke) transmitter is inoperative - service vme. *tt
- Bulletin:
- 00634A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Gen iii engine noise after hot soak restart. *tt
- Bulletin:
- 01390
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Xm radio must be tuned to channel 1 through 66 during activation attempt. 2004 chevrolet canyon, gmc denali, gmc colorado also included. *tt
- Bulletin:
- 01267B
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Service 4wd light on no codes besides u1000 codes. service vme. *tt
- Bulletin:
- 01414
- Component:
- 162000 structure:body
- Summary:
- Discoloration of cargo covers. service dme. *tt
- Bulletin:
- 01414B
- Component:
- 350000 equipment
- Summary:
- Parts restriction for cargo covers cancelled. service vme. this bulletin replaces 01414a dated 11/18/03. *tt
- Bulletin:
- 030138015
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Hvac blower motor may run continuously after vehicle is turned off. *tt
- Bulletin:
- 030603001A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Starter cranks after key is released (normal condition). *tt
- Bulletin:
- 030525007
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
- Bulletin:
- 030844018A
- Component:
- 350000 equipment
- Summary:
- Rear seat audio (rsa) and/or rear hvac inoperative. *tt update. *tt
- Bulletin:
- 030852005
- Component:
- 350000 equipment
- Summary:
- Diagnostic information for replacement remote keyless entry (rke) transmitter inoperative - unable to synchronize. *tt
- Bulletin:
- 020421006C
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Inoperative 4wd/awd lamps, inoperative 4wd/awd system. *tt
- Bulletin:
- 030601023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt
- Bulletin:
- 030850014
- Component:
- 110000 electrical system
- Summary:
- Intermittent no start, service stability message, anti-lock brake system (abs) light illuminated, multiple diagnostic trouble codes (dtcs), dic shows unknown driver, various electrical related conditions. includes escalade esv and ext mod
- Bulletin:
- 030864029
- Component:
- 162300 structure:body:door
- Summary:
- Information on removing front door trim panel to avoid breakage. *tt
- Bulletin:
- 01444
- Component:
- 980000 unknown or other
- Summary:
- Xm dealer assistance line information. *tt
- Bulletin:
- 01470
- Component:
- 180000 vehicle speed control
- Summary:
- Erratic idle, idle surge, rough run, or near stall. *tt
- Bulletin:
- 000235003C
- Component:
- 010000 steering
- Summary:
- Clunking noise under hood and can be felt in the steering wheel. *tt
- Bulletin:
- 030419001A
- Component:
- 106000 power train:axle assembly
- Summary:
- Use of synthetic front axle lubricant for 4wd vehicles sold in cold weather climates. *tt this bulletin replaced previous bulletin dated 10/01/2003. *tt
- Bulletin:
- 030861002D
- Component:
- 162000 structure:body
- Summary:
- Snap/popping type noise coming from front of vehicle. *tt *eh
- Bulletin:
- 030866012
- Component:
- 162000 structure:body
- Summary:
- Midgate rear glass storage retainers now available for service. *tt
- Bulletin:
- 030604060
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt
- Bulletin:
- 030234001A
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Inner tie rod released for service. *tt
- Bulletin:
- 091503
- Component:
- 162000 structure:body
- Summary:
- Discoloration of the cargo covers. gm voicemail log. *tt
- Bulletin:
- 010730038B
- Component:
- 103000 power train:automatic transmission
- Summary:
- The service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt
- Bulletin:
- 030861002B
- Component:
- 162000 structure:body
- Summary:
- Snap/popping type noise coming from front of vehicle. *tt 03-08-61-002b, dated 05/01/2004 replaced. *tt
- Bulletin:
- 030309002
- Component:
- 020000 suspension
- Summary:
- Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
- Bulletin:
- 030857001A
- Component:
- 162000 structure:body
- Summary:
- Rear floor carpet wet with dirty water. *tt
- Bulletin:
- 01555
- Component:
- 020000 suspension
- Summary:
- D height specification missing from si. sit bulletin 1410632. *tt
- Bulletin:
- 01561
- Component:
- 353600 equipment:air conditioner
- Summary:
- Sizzle noise after vehicle shut off. service vme. sit bulletin 1410828. *tt
- Bulletin:
- 01564
- Component:
- 135100 visibility:rearview mirrors/devices:interior
- Summary:
- Inside rearview mirror compass inoperative. service vme. sit bulletin 1411219. *tt
- Bulletin:
- 01345A
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Low tire pressure light illuminated on instrument cluster. service vme. sit bulletin 1411230. *tt
- Bulletin:
- 01332A
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Tighten fuel cap message on the dic. sit bulletin 1411567. *tt
- Bulletin:
- 01425A
- Component:
- 021000 suspension:front
- Summary:
- Snap and popping noise in the front suspension area. *tt
- Bulletin:
- 01588
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Change in gas cap tether attachment point. service vme. sit bulletin 1414321. *tt
- Bulletin:
- 01159A
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Outside rearview mirrors memory operation. sit bulletin 1404207. *tt
- Bulletin:
- 00702
- Component:
- 103000 power train:automatic transmission
- Summary:
- Slip condition in 2nd, 3rd or 4th damaged 2-4 band 3-4 clutch on the 4l60e/4l65e automatic transmission. *tt *mj
- Bulletin:
- 01483
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Vehicle has no pcm (power train control module) communication with tech 2. sit bulletin 1400427. *tt
- Bulletin:
- 3259C
- Component:
- 103000 power train:automatic transmission
- Summary:
- 4l80e, 4l85e whine noise in first and second gear. *tt
- Bulletin:
- 010866006A
- Component:
- 162000 structure:body
- Summary:
- Information regarding cadillac escalade ext and chevrolet avalanche cargo area. *tt
- Bulletin:
- 030138019
- Component:
- 353600 equipment:air conditioner
- Summary:
- Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
- Bulletin:
- 030730056
- Component:
- 103000 power train:automatic transmission
- Summary:
- 4l60-e automatic transmission oil pump first and second design identification. *tt
- Bulletin:
- 030605008B
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt
- Bulletin:
- 030864037
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Front power window noisy or inoperative on vehicles located in michigan only. *tt
- Bulletin:
- 020526001B
- Component:
- 040000 service brakes, air
- Summary:
- Rear parking brake shoe retaining spring clip service kit for drum-in-hat (dih) equipped vehicles. *tt update. *tt
- Bulletin:
- 01766
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Fogging of windows in the defrost mode. also including models: 2003-2004 gmc yukon xl, denali xl, 2003-2004 sierra denali. *mr
- Bulletin:
- 00778A
- Component:
- 160000 structure
- Summary:
- Business trip and/or personal trip odometer inoperative. sit bulletin 1460572. *tt
- Bulletin:
- 01759
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Xm rapid activation utilization. *mr
- Bulletin:
- 01747
- Component:
- 070000 fuel system, gasoline
- Summary:
- Locking gas cap availability. *mr
- Bulletin:
- 01760
- Component:
- 162000 structure:body
- Summary:
- Buzz noise from headliner above driver. *mr
- Bulletin:
- 01698
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield reveal molding flutering. service vme. sit bulletin 1450940. *tt
- Bulletin:
- 01704
- Component:
- 353600 equipment:air conditioner
- Summary:
- Programming control heads - hvac ac. *tt
- Bulletin:
- 1146
- Component:
- 980000 unknown or other
- Summary:
- Stop delivery order on certain vehicles with 4l80e or 4l8e automatic transmission. this also includes 2004 gmc, chevrolet w-medium duty and isuzu w series. *tt
- Bulletin:
- 01913
- Component:
- 350000 equipment
- Summary:
- Cargo covers- cladding stained or discolored. *mr
- Bulletin:
- 01850
- Component:
- 221700 seats:front assembly:seat heater/cooler
- Summary:
- Drivers or passengers heated seats turn on by themselves. *mr
- Bulletin:
- 1158
- Component:
- 980000 unknown or other
- Summary:
- Stop delivery order inspection claim submission. also including 2004 isuzu w-series. *mr
- Bulletin:
- 1148
- Component:
- 980000 unknown or other
- Summary:
- Stop delivery order (chevrolet bac 113611-114593). *mr
- Bulletin:
- 01862
- Component:
- 220000 seats
- Summary:
- Driver personalization regarding memory seats. *mr
- Bulletin:
- 01864
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio cd skips/ejects or clock resets to 12:00. *mr *tt
- Bulletin:
- 01863
- Component:
- 016000 steering:electric power assist system
- Summary:
- Lack of steering assist when stopped or during parking lot type maneuvers. *mr
- Bulletin:
- 01826A
- Component:
- 110000 electrical system
- Summary:
- Cargo lamp indicator turns on briefly when dome- glove box lamp is activated. *mr also includes 2003 and 2004 gmc full size pickup. *tt
- Bulletin:
- 01807
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Service tire pressure monitoring system diagnostic codes. *mr
- Bulletin:
- 01849
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Vehicles equipped with xm do not have audio, am, fm work correctly. *mr
- Bulletin:
- 01822
- Component:
- 160000 structure
- Summary:
- Front door frame contacts the windshield reveal molding. *mr
- Bulletin:
- 01919
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Replacement radio reads cal error, has no audio or will not program. *tt
- Bulletin:
- 04019
- Component:
- 100000 power train
- Summary:
- 4l80e / 4l85e transmission may have a condition in which the transmission overdrive gear set may fail due to inadequate lubrication as a result of a transmission casting change. customer satisfaction program bulletin. also to include 2004
- Bulletin:
- 02038
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code b1000. *mr
- Bulletin:
- 02007
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Power folding mirrors will not fold inward.*mr
- Bulletin:
- 01955
- Component:
- 170000 latches/locks/linkages
- Summary:
- Passenger door module lock up.*mr
- Bulletin:
- 02013
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant leak from head cup plugs on gen iii engines. *mr
- Bulletin:
- 01610
- Component:
- 162000 structure:body
- Summary:
- Stained or faded cargo covers. *tt
- Bulletin:
- 01622
- Component:
- 350000 equipment
- Summary:
- Secondary sunshade visor elimination.*mr
- Bulletin:
- 01634
- Component:
- 010000 steering
- Summary:
- Intermediate steering shaft service kit. service vme. *tt
- Bulletin:
- 01599
- Component:
- 100000 power train
- Summary:
- 4l60e, 4l65e forward and low reverse waved steel clutch plate appearance change. *tt
- Bulletin:
- 01624
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Gen iii engines with maf (mass airflow) sensor code p0101. *tt
- Bulletin:
- 01662
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Xm error on a radio display. *tt
- Bulletin:
- 01919A
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Replacement radio reads cal error, has no audio or will not program. *tt
- Bulletin:
- 01634A
- Component:
- 010000 steering
- Summary:
- Supplement to 00-02-35-003d - clunking noise under hood and can be felt in the steering wheel. *tt
- Bulletin:
- 01588A
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Fuel cap tether strap too short. *tt
- Bulletin:
- 01913A
- Component:
- 350000 equipment
- Summary:
- Cargo covers- cladding stained or discolored. *tt
- Bulletin:
- 00372D
- Component:
- 353000 equipment:electrical
- Summary:
- Onstar system is attempting and/or completing phone calls which the operator of the vehicle did not initiate. *tt
- Bulletin:
- 01448A
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Water leaking from center roof console. *tt
- Bulletin:
- 00844
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Front windshield wiper arm does not remain upright position as it did on prior models and as a result, customer may inadvertently brake the wiper arm trying to extend the blade. *mj
- Bulletin:
- 01972
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Erratic oil pressure gmt 610 or gmt800 with codes p0522 or p0523. *tt 01972a replaced and updated 01/01/04. *sc
- Bulletin:
- 00266
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt
- Bulletin:
- 01954
- Component:
- 980000 unknown or other
- Summary:
- Unwanted stabilitrak activation during sweeping turns. *tt
- Bulletin:
- 00573
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Low audio output from speakers. *mj
- Bulletin:
- 01267F
- Component:
- 110000 electrical system
- Summary:
- Service 4wd light on no codes besides u1000 codes or c0550. *mj
- Bulletin:
- 01586
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 8.1l changes in heads, bolts and gasket for for 2004 1/2 engines. various models including the chevrolet and gmc 2500hd/3500 my2001-2004 and 2001, 2002, and 2003 gmt 560. *mj
- Bulletin:
- 00786
- Component:
- 181000 vehicle speed control:accelerator pedal
- Summary:
- Buzz noise and virbation in the accelerator pedal at approx. 10 mph on start up. *mj
- Bulletin:
- 02052
- Component:
- 160000 structure
- Summary:
- Noise coming from instrument panel cluster or tachometer. *tt
- Bulletin:
- 02054
- Component:
- 060000 engine and engine cooling
- Summary:
- Elimination of low coolant message from dic. service vme. *tt
- Bulletin:
- 00993
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Outside rearview mirror glass may crack. *tt
- Bulletin:
- 01936
- Component:
- 162000 structure:body
- Summary:
- Painted body side moldings dimple (raised surface). service vme. *tt
- Bulletin:
- 01353
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire due to injector fretting corrosion. *tt
- Bulletin:
- 00823A
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Power steering fluid leaking at hydraulic brake booster. *tt
- Bulletin:
- 0408111002
- Component:
- 162000 structure:body
- Summary:
- Raised surface, dimple in body side molding. *mj this bulletin replaced previous bulletin 04-08-111-002, dated 05/01/2004. *tt
- Bulletin:
- 030864010
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Outside rearview mirrors may blow in at highway speeds or power folding feature appears inoperative. also to include 2005 models. *tt
- Bulletin:
- 040495001
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Revised wheel drive shaft nut torque specification. *tt
- Bulletin:
- 040525002B
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
- Bulletin:
- 040850007
- Component:
- 221700 seats:front assembly:seat heater/cooler
- Summary:
- Service information for front heated seat inoperative/cold. *mj
- Bulletin:
- 1530076
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles and hummer h2 with a high altitude stall. *mj
- Bulletin:
- 3013
- Component:
- 251000 electronic stability control:automatic (asc)
- Summary:
- Unwanted stabilitrak activation or stabilitrak disable message appears on the dic. *tt
- Bulletin:
- 3025
- Component:
- 220000 seats
- Summary:
- Repairing cloth seats with napped fabric. *mj
- Bulletin:
- 3028
- Component:
- 022000 suspension:rear
- Summary:
- Replacement tailgate cables bind at shoulder bolt. *mj
- Bulletin:
- 3002
- Component:
- 100000 power train
- Summary:
- 4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
- Bulletin:
- 3018
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine cylinder head cup plug coolant leak. *mj
- Bulletin:
- 3025
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 04 model year 4.8.5.3.7.6.0 gen iii engine piston pin information. *mj
- Bulletin:
- 3001
- Component:
- 106000 power train:axle assembly
- Summary:
- The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
- Bulletin:
- 3000
- Component:
- 162300 structure:body:door
- Summary:
- Service vme - 03 - 04 full size truck, utilities and hummer h2 passenger door module inoperative. *mj
- Bulletin:
- 3002
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Service vme - switching mirrors from power folding to power extending. *mj
- Bulletin:
- 3001
- Component:
- 110000 electrical system
- Summary:
- No communication with any modules, multipe u-diagnostic trouble codes (dtcs), instrument panel cluster (ipc) warning indicators. 03-04 chevrolet all full size trucks and utilities and 03-04 gmc all full size trucks and utilities and 03-04
- Bulletin:
- 3000A
- Component:
- 022000 suspension:rear
- Summary:
- Rear axle locking differential chatter shudder noise on turns. *mj
- Bulletin:
- 3045
- Component:
- 200000 wheels
- Summary:
- Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
- Bulletin:
- 3086
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
- Bulletin:
- 3086
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt
- Bulletin:
- 3087
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Crank no start with no cranking rpm spark or injector pulse. *tt
- Bulletin:
- 3089
- Component:
- 110000 electrical system
- Summary:
- Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt
- Bulletin:
- 3073
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Downhill cruise control surge. *tt
- Bulletin:
- 3075B
- Component:
- 110000 electrical system
- Summary:
- Blown mbec 1 or lbec 1 fuse. *tt
- Bulletin:
- 3076
- Component:
- 353600 equipment:air conditioner
- Summary:
- Repeat hvac blower motor failure. *tt
- Bulletin:
- 3047
- Component:
- 350000 equipment
- Summary:
- 99 through 05 year vehicles, equipped with three-button onstar systems. *tt
- Bulletin:
- 3022A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 04 full size trucks and utilities with vin g, n, t, v and u engines may have a high altitude, high ambient temperature stall. *tt
- Bulletin:
- 3054
- Component:
- 100000 power train
- Summary:
- Replacement flexplate may have larger bolt holes than the original flexplate. *tt
- Bulletin:
- 3055
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
- Bulletin:
- 3118A
- Component:
- 160000 structure
- Summary:
- Pop/clunk noise on right or left turns. *tc *sc
- Bulletin:
- 3111
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Navigation system coverage of canada. (2004-2005 chevrolet trailblazer, 2004-2005 gmc envoy, 2004-2005 buick rainier/rendezvous, 2004-2005 cadillac escalade, 2005 chevrolet avalanche/suburban/tahoe, 2004-2005 gmc denali, 2005 gmc yukon, a
- Bulletin:
- 3110
- Component:
- 091130 fuel system, other:storage:tank assembly:pressure relief devices
- Summary:
- Erratic oil pressure with diagnostic trouble code's p0522 and/or p0523. *sc
- Bulletin:
- 3159
- Component:
- 110000 electrical system
- Summary:
- Instrument panel cluster parts restriction. *tc
- Bulletin:
- 3121
- Component:
- 060000 engine and engine cooling
- Summary:
- Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
- Bulletin:
- 3139
- Component:
- 160000 structure
- Summary:
- Water intrusion into cab at midgate. *sc
- Bulletin:
- 3119
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- Engineering investigation - catalytic converter replacement. *sc
- Bulletin:
- 3106
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Xm radio was working prior to july 26, 2004 and it is inoperative now. *jb
- Bulletin:
- 3107
- Component:
- 060000 engine and engine cooling
- Summary:
- P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
- Bulletin:
- 3113
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Gen 6 vehicles in mount airy, nc cannot connect to onstar or emergency services. *sc
- Bulletin:
- 3101
- Component:
- 353600 equipment:air conditioner
- Summary:
- Insufficient cooling of the a/c system. *sc
- Bulletin:
- 3143
- Component:
- 190000 tires
- Summary:
- Check tire pressure message. (to include 2004-05 gmc denali) *sc
- Bulletin:
- 3090
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Unable to perform set up new onstar on vehicles with gen 6.05 hardware. *sc
- Bulletin:
- 3121
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
- Bulletin:
- 3179
- Component:
- 353600 equipment:air conditioner
- Summary:
- Automatic dual zone hvac battery draw supplement to 02-01-39-007a. *tt
- Bulletin:
- 3056
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
- Bulletin:
- 3078
- Component:
- 090000 fuel system, other
- Summary:
- Some 2004 full size trucks and utilities may experience a diagnostic trouble code p0442. *tt
- Bulletin:
- 04007A
- Component:
- 162500 structure:body:tailgate
- Summary:
- Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
- Bulletin:
- 3170
- Component:
- 103000 power train:automatic transmission
- Summary:
- Harsh 1-2 shift. *eh
- Bulletin:
- 3061C
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code c0327 with or without additional diagnostic trouble codes setting. *tt
- Bulletin:
- 3193
- Component:
- 060000 engine and engine cooling
- Summary:
- Excessive oil consumption. *eh
- Bulletin:
- 3236
- Component:
- 190000 tires
- Summary:
- Slow tire leak or low tire pressure warning message. *eh
- Bulletin:
- 3187
- Component:
- 110000 electrical system
- Summary:
- Intermittent service stability message displayed, history diagnostic trouble code c0550. *tt
- Bulletin:
- 3113
- Component:
- 980000 unknown or other
- Summary:
- No connect. gen 6 vehicles in ashe, alleghany, surry and wilkes county, nc cannot connect o onstar or emergency services. *tt
- Bulletin:
- 3243
- Component:
- 010000 steering
- Summary:
- Pop/clunk/click noise on right or left turns. *eh
- Bulletin:
- 3087
- Component:
- 060000 engine and engine cooling
- Summary:
- Crank no start, stall, hard start, and no cranking rpm. *eh
- Bulletin:
- 040604065
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Engineering investigation (ei #04073) high, low or erratic oil pressure gauge reading setting diagnostic trouble codes p0522 and/or p0523. 2004 isuzu w4 also included. *tt update. *tt
- Bulletin:
- 040857005
- Component:
- 162000 structure:body
- Summary:
- Water intrusion into cab at midgate. *tt
- Bulletin:
- 040523001A
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
- Bulletin:
- 040864003
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
- Bulletin:
- 0408111001
- Component:
- 162000 structure:body
- Summary:
- Cargo covers and/or body cladding discolored (chalky). *tt this bulletin replaced previous bulletin 04-08-111-001, dated 01/01/2004. *tt
- Bulletin:
- 040138010
- Component:
- 353600 equipment:air conditioner
- Summary:
- Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
- Bulletin:
- 040139009
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Hvac blower motor inoperative or stays running. *tt
- Bulletin:
- 040310007D
- Component:
- 020000 suspension
- Summary:
- 20 inch wheels and tires available through gmspo. *tt updated. *nm
- Bulletin:
- 040523006
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Revised brake pads replacement-rear. *tt
- Bulletin:
- 020139007
- Component:
- 980000 unknown or other
- Summary:
- Automatic dual zone hvac battery draw. *ar
- Bulletin:
- 040850016B
- Component:
- 220000 seats
- Summary:
- Memory seat may not return to requested position. *eh
- Bulletin:
- 040861003
- Component:
- 162000 structure:body
- Summary:
- Running board cover is loose. *eh
- Bulletin:
- 040864016
- Component:
- 162300 structure:body:door
- Summary:
- Rear door puddle lamp reflector replacement. *eh
- Bulletin:
- 3249
- Component:
- 110000 electrical system
- Summary:
- Intermittent sir lamp with diagnostic trouble code b0044 or b0026. *eh
- Bulletin:
- 3203
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Resonance noise at idle. *eh
- Bulletin:
- 3227
- Component:
- 162500 structure:body:tailgate
- Summary:
- Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
- Bulletin:
- 3118B
- Component:
- 162000 structure:body
- Summary:
- Pop cluck click noise on right or left turns. *eh
- Bulletin:
- 000235003
- Component:
- 010000 steering
- Summary:
- Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
- Bulletin:
- 040866009
- Component:
- 162000 structure:body
- Summary:
- Stowage box lid strap breaking. *tt
- Bulletin:
- 040601023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine vibration/noise at idle, rough idle, steering wheel shake. *tt
- Bulletin:
- 040601018
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt
- Bulletin:
- 020310001A
- Component:
- 190000 tires
- Summary:
- Spare tire is different size than other tires. this service bulletin replaces 020310001. *eh update. *tt
- Bulletin:
- 030310002
- Component:
- 190000 tires
- Summary:
- Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
- Bulletin:
- 040604043
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Unable to reset engine oil life monitor. *tt
- Bulletin:
- 040138008
- Component:
- 353600 equipment:air conditioner
- Summary:
- Heat ventilation and air conditioning system cannot be controlled or defaults to defrost mode. *eh
- Bulletin:
- 040848003
- Component:
- 131000 visibility:windshield
- Summary:
- Windrush around windshield. *tt
- Bulletin:
- 040852005
- Component:
- 350000 equipment
- Summary:
- Remote keyless entry (rke) system inoperative. *tt
- Bulletin:
- 040941003
- Component:
- 140000 air bags
- Summary:
- Proper use of labor operation code when diagnosis leads to sir passenger presence system replacement. *tt
- Bulletin:
- 040604032
- Component:
- 060000 engine and engine cooling
- Summary:
- Proper method to secure fuel cap during refueling. *eh
- Bulletin:
- 040137004
- Component:
- 353600 equipment:air conditioner
- Summary:
- Revised air conditioning (a/c) system performance test. *tt
- Bulletin:
- 040849007
- Component:
- 110000 electrical system
- Summary:
- Personal trip business trip feature must be on for trip odometer to accumulate. *eh
- Bulletin:
- 040850003
- Component:
- 150000 seat belts
- Summary:
- Enabling memory seat feature via dic if feature appears inoperative. *eh
- Bulletin:
- 040603002
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnostic information for intermittent vehicle no crank dead battery. *eh
- Bulletin:
- 040138013
- Component:
- 353600 equipment:air conditioner
- Summary:
- Hvac not cold enough a/c compressor does not engage . *eh
- Bulletin:
- 040138014
- Component:
- 353600 equipment:air conditioner
- Summary:
- High pitched tone heard inside vehicle when ac compressor is engaged. *eh
- Bulletin:
- 040138015
- Component:
- 353600 equipment:air conditioner
- Summary:
- Diagnostic information for moan groan or boom noise at idle vibration in steering wheel or felt through floor when ac compressor engages do not replace ac compressor. *eh
- Bulletin:
- 03122004
- Component:
- 980000 unknown or other
- Summary:
- Please stop the delivery due to the limitations of the gm administrative message system. *tt
- Bulletin:
- 01292004
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
- Bulletin:
- 08022004
- Component:
- 353600 equipment:air conditioner
- Summary:
- Overcharge of refrigerant in the air condition system. *eh
- Bulletin:
- 3300C
- Component:
- 341000 communications:horn assembly
- Summary:
- Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
- Bulletin:
- 040849006B
- Component:
- 110000 electrical system
- Summary:
- Service stability message displayed. *eh
- Bulletin:
- 050941001
- Component:
- 140000 air bags
- Summary:
- Supplemental inflatable restraint (sir) light on, diagnostic trouble codes (dtc) b0026 and/or b004. to include 2003-2006 chevrolet/gmc full size pickup and utility models. *tt
- Bulletin:
- 3276
- Component:
- 100000 power train
- Summary:
- 4l80e output carrier thrust washer changes. *tt
- Bulletin:
- 3373
- Component:
- 140000 air bags
- Summary:
- Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
- Bulletin:
- 3386
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Lack of steering assist or shudder during parking lot type maneuvers. *tt
- Bulletin:
- 3396
- Component:
- 251000 electronic stability control:automatic (asc)
- Summary:
- Service stability message displayed in the dic. diagnostic trouble codes c0290, c0292, c0131, or c0196 set in the ebcm. *tt
- Bulletin:
- 3300
- Component:
- 105000 power train:driveline
- Summary:
- 4wd models with noise, vibration on dry pavement. *eh
- Bulletin:
- 07012004
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
- Bulletin:
- 3351
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
- Bulletin:
- 3352
- Component:
- 100000 power train
- Summary:
- Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module. *tt
- Bulletin:
- 3232
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
- Bulletin:
- 3499
- Component:
- 017300 steering:linkages:arm:idler and attachment
- Summary:
- Steering idler arm inspection procedure. *tt
- Bulletin:
- 020307002
- Component:
- 020000 suspension
- Summary:
- Revised front caster and camber adjustment procedure. original not yet received. *tt
- Bulletin:
- 3364
- Component:
- 106000 power train:axle assembly
- Summary:
- Rear axle retainer button breakage. *eh
- Bulletin:
- 050525003A
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Service stability message on, diagnostic trouble code (dtc) c0131, c0196, c0290 and/or c0292 set. *tt
- Bulletin:
- 050604021
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt
- Bulletin:
- 050604024
- Component:
- 060000 engine and engine cooling
- Summary:
- Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
- Bulletin:
- 050846006A
- Component:
- 350000 equipment
- Summary:
- Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital). *tt
- Bulletin:
- 701
- Component:
- 090000 fuel system, other
- Summary:
- Fuel filter replacement. gm tech link. *tt
- Bulletin:
- 510
- Component:
- 220000 seats
- Summary:
- Repairing napped fabric-seats may have been upholstered in napped fabrics with dorchester on the bolster and honeycomb on the insert. *sc
- Bulletin:
- 3671
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Service vme - outside rearview mirror vibration. *tt
- Bulletin:
- 3687A
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Hoot or squeak type noise on rapid brake apply. *tt
- Bulletin:
- 3526
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
- Bulletin:
- 3571
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Check tire pressure message. *tt
- Bulletin:
- 3525
- Component:
- 022000 suspension:rear
- Summary:
- Automatic level control inoperative due to water ingestion. *tt
- Bulletin:
- 1656326
- Component:
- 110000 electrical system
- Summary:
- Bulletin-sit-bulletin-1656326: pit3569. low tire light on and or dic check tire pressure message when cold. *sc
- Bulletin:
- 3427
- Component:
- 110000 electrical system
- Summary:
- Additional diagnostic information dtc p0757. *tt
- Bulletin:
- 3568A
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Service brake booster message. *tt
- Bulletin:
- 3438A
- Component:
- 103000 power train:automatic transmission
- Summary:
- Tcc surge and/or fluid contamination. *tt
- Bulletin:
- 3639
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Service vme-outside rear view mirror inoperative. *sc
- Bulletin:
- 3545
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Blower motor inoperative at low ambient temperatures. *tt
- Bulletin:
- 3260
- Component:
- 100000 power train
- Summary:
- 4l80e/4l85e harsh shift or slip no tcc apply. *tt
- Bulletin:
- 3573
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Unwanted operation of rear windows. *tt
- Bulletin:
- 3424
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Electronic transfer case unable to complete shift. *tt
- Bulletin:
- 3569
- Component:
- 022520 suspension:rear:axle:non-powered axle assembly
- Summary:
- Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005). *tt
- Bulletin:
- 050310005
- Component:
- 200000 wheels
- Summary:
- Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
- Bulletin:
- 050730013
- Component:
- 103000 power train:automatic transmission
- Summary:
- 4l60-e/4l65-e automatic transmission second gear start, lack/loss of power when accelerating from a stop. *tt
- Bulletin:
- 020867009
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Sunroof jams when closing. *tt
- Bulletin:
- 050138012
- Component:
- 353600 equipment:air conditioner
- Summary:
- Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated *kb
- Bulletin:
- 050850008
- Component:
- 221700 seats:front assembly:seat heater/cooler
- Summary:
- Intermittent heated seats inoperative, diagnostic trouble code b3941 set. *tt
- Bulletin:
- 050601014
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt
- Bulletin:
- 050730017
- Component:
- 103000 power train:automatic transmission
- Summary:
- 4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission. *tt
- Bulletin:
- 05-04-21-003
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
- Bulletin:
- 050850012
- Component:
- 220000 seats
- Summary:
- Unwanted/loose seat movement. *tt
- Bulletin:
- 3287B
- Component:
- 221700 seats:front assembly:seat heater/cooler
- Summary:
- Heated seat inoperative or shut off in 30 seconds. diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module. *tt
- Bulletin:
- 3766
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Front blower inoperative stay running during low ambient temperature. *tt
- Bulletin:
- 3637A
- Component:
- 031000 service brakes, hydraulic:pedals and linkages
- Summary:
- Brake pedal assembly replacement bracket service kit. *tt updated 3/26/10. *pe
- Bulletin:
- 3691A
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Front hvac blower inoperative. *tt
- Bulletin:
- 3665
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- 4wd inoperative and possible dtc c0327 stored in the transfer case control module. *tt
- Bulletin:
- 060308002
- Component:
- 021510 suspension:front:control arm:upper arm
- Summary:
- Revised upper control arm replacement. *tt
- Bulletin:
- 3340
- Component:
- 021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
- Summary:
- Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
- Bulletin:
- 3562
- Component:
- 190000 tires
- Summary:
- Bridgestone dueler product information update. *kb
- Bulletin:
- 3190
- Component:
- 110000 electrical system
- Summary:
- Unable to locate emergency light relay and/or blunt cut wires. *kb
- Bulletin:
- 3713
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Door glass pops out of run channel. *kb
- Bulletin:
- 3136
- Component:
- 102000 power train:manual transmission
- Summary:
- Slip condition in 2nd, 3rd, or 4th. damaged 2-4 or 3-4 clutch. *kb updated 10/31/07. *nj
- Bulletin:
- 4231
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
- Bulletin:
- 3425
- Component:
- 190000 tires
- Summary:
- Unable to program tire size in ebcm/vses. *kb
- Bulletin:
- 3568
- Component:
- 040000 service brakes, air
- Summary:
- Service brake booster message. *kb
- Bulletin:
- 4030
- Component:
- 106000 power train:axle assembly
- Summary:
- New design front axle side bearing adjusters. *kb
- Bulletin:
- 040525002
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
- Bulletin:
- 3750
- Component:
- 110000 electrical system
- Summary:
- Additional diagnostic for yaw/lat sensor dtc's. *kb
- Bulletin:
- 050232008
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
- Bulletin:
- 3075
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Blown mbec 1 or lbec 1 fuse. *kb
- Bulletin:
- 4486
- Component:
- 117000 digital instrument panel
- Summary:
- One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
- Bulletin:
- 070842013
- Component:
- 126100 exterior lighting:turn signal:flasher unit
- Summary:
- Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
- Bulletin:
- 07187
- Component:
- 117000 digital instrument panel
- Summary:
- Cadillac\chevrolet\gmc service campaign: see document search button for owner letter. instrument panel cluster gauge needle function may cause inaccurate readings on some 2003-2004 cadillac, chevrolet, and gmc vehicles. *nj updated 2/5
- Bulletin:
- PIT3569
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Low tire light on and/or dic check tire pressure message when cold, with rpo uj6. *nj
- Bulletin:
- PIP3343
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
- Bulletin:
- PIP4054A
- Component:
- 022000 suspension:rear
- Summary:
- Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
- Bulletin:
- PIT3504D
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
- Bulletin:
- 08-089
- Component:
- 353000 equipment:electrical
- Summary:
- Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
- Bulletin:
- PIT-3046E
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
- Bulletin:
- PIT-4662
- Component:
- 110000 electrical system
- Summary:
- Gmc: sir mil dtc b0084 and/or b0085. this concern could be caused by broken seat position sensor circuits under the driver or passenger front seats. over time, from repeated seat movement, the wiring could break. *pe
- Bulletin:
- PIT-4722
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
- Bulletin:
- 08-089B
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Buick\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. csc letter was received. *pe
- Bulletin:
- 08089-B
- Component:
- 110000 electrical system
- Summary:
- General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
- Bulletin:
- PIP-4492P
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
- Bulletin:
- SB-10-02-33-001
- Component:
- 010000 steering
- Summary:
- Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
- Bulletin:
- PIT-3749D
- Component:
- 161000 structure:frame and members
- Summary:
- Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
- Bulletin:
- PIP-4138K
- Component:
- 060000 engine and engine cooling
- Summary:
- Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
- Bulletin:
- 09-09-40-001A
- Component:
- 150000 seat belts
- Summary:
- Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
- Bulletin:
- 10-00-89-017C
- Component:
- 980000 unknown or other
- Summary:
- Gm: information on fixing multiple situations right the first time. *rm
- Bulletin:
- PI-0011A
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
- Bulletin:
- SB-10240
- Component:
- 353600 equipment:air conditioner
- Summary:
- General motors service campaign: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm updated 4/6/12. *pe
- Bulletin:
- PIP-3366-B
- Component:
- 103000 power train:automatic transmission
- Summary:
- Cadillac/chevrolet/gmc/hummer: some suvs and trucks are exhibiting a condition where by grinding/ratcheting type noise coming from automatic transmission when shifting into park while in 4wd low (4lo) range. *pe
- Bulletin:
- PIT-5141
- Component:
- 353600 equipment:air conditioner
- Summary:
- Buick/cadillac/chevrolet/gmc/oldsmobile: if blower motor is set to any speed position and when key is off, it becomes inoperative and may still be inoperative after key is turned on. *pe updated on 5/1/12. *js
- Bulletin:
- 05-02-32-008D
- Component:
- 010000 steering
- Summary:
- General motors: diagnosing power steering concerns. in rare cases, customers may comment on a lack of steering assist when stopped or during parking lot type of maneuvers. *js updated 09/02/14*lj
- Bulletin:
- PIT-4954-C
- Component:
- 020000 suspension
- Summary:
- Gm: if the service suspension system is displayed on the dic, the trim height may be incorrect, loose compressor inlet hose, or the compressor self test may be inoperative. also included suburban ld my 2001-2013, yukon denali xl my 2013, y
- Bulletin:
- SB-13-05-22-001
- Component:
- 034100 service brakes, hydraulic:foundation components:master cylinder
- Summary:
- Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
- Bulletin:
- PIP5226A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
- Bulletin:
- PIT5195A
- Component:
- 117000 digital instrument panel
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
- Bulletin:
- PIC5953
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIT3227J
- Component:
- 162500 structure:body:tailgate
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
- Bulletin:
- PIP3119M
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
- Bulletin:
- PIP5163A
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
- Bulletin:
- 06-06-01-010C
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period.
- Bulletin:
- 03-08-46-004R
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
- Bulletin:
- PIT3237G
- Component:
- 131000 visibility:windshield
- Summary:
- This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
- Bulletin:
- PIT3078F
- Component:
- 021700 suspension:front:hub
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have grease leaking from front hub bearings. technician should not replace the bearing for grease purge. technician should be advised to n
- Bulletin:
- PIP5072
- Component:
- 101000 power train:clutch assembly
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. technician will inspect the 3-4 clutches and the forward clutch
- Bulletin:
- PIT3665C
- Component:
- 030000 brakes (pws)
- Summary:
- This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
- Bulletin:
- PIP3720D
- Component:
- 106000 power train:axle assembly
- Summary:
- This preliminary information communication provides information to the technician with the axel setup information from american axle manufacturing. technician should be advised that the maximum pinion shim to be used or stacked behind the p
- Bulletin:
- PIT3330F
- Component:
- 353600 equipment:air conditioner
- Summary:
- This preliminary information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. dealer should advise the customer starting in 2003 the passenger c
- Bulletin:
- PIT3271F
- Component:
- 190000 tires
- Summary:
- This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
- Bulletin:
- PIP3259J
- Component:
- 100000 power train
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. technician should compare the noise to a like vehicle. technician will nee
- Bulletin:
- PIP4138L
- Component:
- 100000 power train
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
- Bulletin:
- PIT5195
- Component:
- 117000 digital instrument panel
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
- Bulletin:
- PIP3119L
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician on the steps to diagnose and repair vehicles that may have a service engine soon malfunction indicator lamp on at low mileage. technician may find diagnostic
- Bulletin:
- 00-03-10-003R
- Component:
- 190000 tires
- Summary:
- This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
- Bulletin:
- 06-06-01-010B
- Component:
- 060000 engine and engine cooling
- Summary:
- This informational bulletin provides information on close-coupled converter and engine replacement.
- Bulletin:
- 05-00-89-055E
- Component:
- 356000 equipment adaptive
- Summary:
- This warranty administration bulletin provides information to clarify proper transaction administration of gm dealer empowerment program and goodwill cases.
- Bulletin:
- 15-08-44-001B
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-44-001A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 05-06-04-035E
- Component:
- 090000 fuel system, other
- Summary:
- This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
- Bulletin:
- 02-07-30-052J
- Component:
- 103000 power train:automatic transmission
- Summary:
- This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool j-45096 transflow®.
- Bulletin:
- 15-08-44-001
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-73-001
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
- Bulletin:
- 09-09-40-001C
- Component:
- 150000 seat belts
- Summary:
- This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
- Bulletin:
- 10-00-89-017X
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
- Bulletin:
- 11-00-89-005C
- Component:
- 356000 equipment adaptive
- Summary:
- This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
- Bulletin:
- PIT5484A
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication advises the technician that if onstar is unable to configure the vehicle after the onstar 15-08-44-001 upgrade and onstar receives a 118 error code when attempting to configure the vehicle. dealers
- Bulletin:
- 07-08-49-020I
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides a quick guide to updating which model vehicle after replacing the ipc.
- Bulletin:
- PIC4310K
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIC3278F
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
- Bulletin:
- PIT3271G
- Component:
- 190000 tires
- Summary:
- This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
- Bulletin:
- PIT5264C
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
- Bulletin:
- PIC5953A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIC4310L
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIT5399
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
- Bulletin:
- PIP5232B
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Home | Privacy