2004 AUDI ALLROAD Recalls (3)
- Campaign:
- 04V133000 on 03/21/2004
- Component:
- Electrical system
- Manufactured:
- 08/13/1997 - 02/11/2004
- Affected:
- 172,866
- Defect:
- On certain passenger vehicles, if a driver's knees push against the knee bolster (crash element) located under the dashboard, it can contact the headlight switch wiring harness, and an electrical short could occur.
- Consequence:
- A fire could originate in the left dashboard area.
- Correction:
- Dealers will install a protective covering on the knee bolster (crash element). in addition, the wiring harness as well as the felt protector on the left side of the dashboard carrier will be checked, and replaced if necessary. the recall began on july 26, 2004. owners should contact audi at 1-800-822-2834.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06V198000 on 06/06/2006
- Component:
- Electrical system
- Manufactured:
- 07/31/1997 - 06/29/2005
- Affected:
- 70,512
- Defect:
- On certain passenger vehicles equipped with halogen low beam headlights, certain connector pins in the headlight switch connector come into contact with each other causing a short circuit. note: vehicles with xenon low beam headlights are not affected because the circuit in these vehicles contains a fuse, which precludes excessive current flow in the case of a short circuit. audi s6 and s6 avant vehicles are all equipped with xenon low beam headlights and, therefore, are not longer affected by this recall.
- Consequence:
- This condition could lead to overheating or fire.
- Correction:
- Dealers will reroute the wiring harness by installing a jumper wiring harness. the recall began on december 16, 2006. owners may contact audi at 1-800-822-2834.
- Notes:
- Volkswagen (audi) recall no. jn.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V157000 on 04/07/2008
- Component:
- Fuel system, gasoline:storage:tank assembly
- Manufactured:
- 06/01/2001 - 05/31/2005
- Affected:
- 68,240
- Defect:
- Volkswagen is recalling 68,240 my 2001-2004 audi a6 quattro vehicles equipped with 2.7l, 2.8l, or 3.0l engines and my 2001-2005 allroad quattro vehicles equipped with 2.7l or 4.2l engines. the aging of the plastic material in the fuel tank rollover valve combined with bending stress from the aluminum ventilation line to the rollover valve nipple may lead to cracking of the nipple. if this happens, a fuel leak may result.
- Consequence:
- A fuel leak in the presence of an ignition source could lead to a vehicle fire.
- Correction:
- Dealers will reinforce the nipple on the rollover valve to prevent leakage or repair the cracking at the nipple. the recall began on june 27, 2008. owners may contact audi at 1-800-822-2834.
- Notes:
- Vw recall no. 20l8/jy.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
2004 AUDI ALLROAD TSBs (33)
- Bulletin:
- 0402
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine, intake manifold mounting bolt torque. audi s4,s4 cabriolet, allroad, a6, a8l model year 2004. *mj update. *tt
- Bulletin:
- 480501
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Power steering, noisy. to include 2006 models. *tt
- Bulletin:
- 0501
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Fuel injectors, unnecessary replacement. update. *tt
- Bulletin:
- 0501
- Component:
- 060000 engine and engine cooling
- Summary:
- Secondary air injection (air) pump motor -v101- is noisy. *tt
- Bulletin:
- 0526
- Component:
- 103000 power train:automatic transmission
- Summary:
- Authorization requirements for automatic transmissions. *tt
- Bulletin:
- 0601
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Control housing for camshaft adjuster, ensuring shim washer installation when repairing. *tt
- Bulletin:
- 20056243
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Headlight aiming, using hella universal beamsetter. *kb
- Bulletin:
- 20036582
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Loses power or will not move after stop. *kb
- Bulletin:
- AWA-08-04
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine coolant temperature sensor warranty extension for certain 2001-2004 model year audi vehicles. *pe
- Bulletin:
- AWA-08-03
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Audi service campaign: see document search button for owner letter. engine coolant temperature sensor warranty extension for certain 2001-2004 audi model year vehicles. csc was received *pe
- Bulletin:
- TSB-44-08-14
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Audi: wheel bolts require torque adjustment. torque sticks and torque extension bars are not approved by audi of america, inc. and should not be used to apply torque to wheel bolts. all audi models included. *pe
- Bulletin:
- TSB-45-08-04
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Audi: abs activates during light brake application . control noises are heard from the abs unit at low speed without brake application. *pe
- Bulletin:
- TSB-01-08-33
- Component:
- 118000 electrical system: software
- Summary:
- Audi: software version management(svm) operating instructions. its a process to update the programming in flashable (reprogrammable) control modules and/or to document changes in software levels in all audi vehicles. *pe
- Bulletin:
- TSB-01-09-06
- Component:
- 118000 electrical system: software
- Summary:
- Audi: software version management (svm), operating instructions. svm is a process to update the programming in flashable (re-programmable) control modules and/or to document changes in software levels in audi vehicles. this system uses t
- Bulletin:
- TSB-24-09-16
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Audi: mil on (mass airflow sensor dtcs p0101, p0102, p0103, p0112, p0113 in ecm). engine has low performance without significant loss of power or stalling. dtcs related to the mass air flow sensor and fuel trim faults can be related to (
- Bulletin:
- TSB-24-08-04
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Audi: mil on (mass airflow sensor dtcs p0101, p0102, p0103, p0112, p0113 in ecm). engine has low performance without significant loss of power or stalling. models s4, s4 cabriolet, allroad, rs6, & r8. *pe
- Bulletin:
- SA-28F2 J1
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Audi: (revised) vehicles affected by this action may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminate to let you know that the vehicle may experience
- Bulletin:
- TSB-28F2-REV 7
- Component:
- 116000 electrical system:ignition
- Summary:
- Audi: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. (added phase 7-april 10 vin information).malfuncti
- Bulletin:
- TSB-00-10-02
- Component:
- 118000 electrical system: software
- Summary:
- Audi: software version management (svm) operating instructions. detailing the general process for carrying out a software version management (svm) software update for any tsb or required vehicle update (rvu). troubleshooting information
- Bulletin:
- SAC-28F2-REV
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Audi: gasoline engine vehicles; inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. added final mailing phase-8/10 vin information.
- Bulletin:
- TSB-01-12-39
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Audi: engine has reduced engine performance without loss of power or stalling; circuit grounds; fuel quality poor; mil is constantly illuminated or flashing; rough idle; ignition coils incorrectly installed; electrical connections loose or
- Bulletin:
- 37-13-07
- Component:
- 180000 vehicle speed control
- Summary:
- Audi: some vehicles may lack power or will not move after stop due to simultaneously depressing the brake and accelerator pedals. *js
- Bulletin:
- TSB-44-13-46
- Component:
- 356000 equipment adaptive
- Summary:
- Audi: on certain vehicles, use calibrated torque wrench and not torque sticks, torque extension bars and impact guns/wrenches not approved for usage on wheel bolts by manufacturer, that can cause damage to brake, steering wheel, hub. mode
- Bulletin:
- SB-01-15-29
- Component:
- 060000 engine (pws)
- Summary:
- Audi: engine, on some vehicles, would run irregularly or have malfunction indicator lamp (mil) on or possible filter element for camshaft adjustment valve can loosen and in oil circuit, there is no damage from loosened particles. model al
- Bulletin:
- A571385 2017082-
- Component:
- 110000 electrical system
- Summary:
- Supersedes technical service bulletin group 57 number 13-82 dated february 5, 2013. central locking via remote control does not work either sporadically or permanently. the locks can still be operated manually. missing synchronization betwe
- Bulletin:
- A571382 2017082-
- Component:
- 170000 latches/locks/linkages
- Summary:
- Supersedes technical service bulletin group 57 number 11-55 dated august 22, 2011. central locking via remote control does not work either sporadically or permanently. the locks can still be operated manually. missing synchronization betwee
- Bulletin:
- 2013_06_ATU Audi
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains information on the audi side assist update.
- Bulletin:
- A941791 2012749-
- Component:
- 120000 exterior lighting
- Summary:
- This informational bulletin contains technical information for when there is condensation visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, and/or third brake light l
- Bulletin:
- A911743 2042097-
- Component:
- 110000 electrical system
- Summary:
- This informational bulletin contains resource information for when the traffic feature is inoperative in the mmi navigation.
- Bulletin:
- A441662 2010334-
- Component:
- 200000 wheels
- Summary:
- This information tsb provides information regarding the correct way to torque adjust a wheel bolt.
- Bulletin:
- A571738 2017082-
- Component:
- 111000 electrical system:battery
- Summary:
- This informational bulletin contains instructions for sychronizing the remote key after the battery has been disconnected or replaced.
- Bulletin:
- ATE-17-05
- Component:
- 350000 equipment
- Summary:
- Due to increasing requests for high voltage personal protective equipment (hve ppe) for dealer technicians working with high voltage vehicles (hybrid, plugin hybrid, electric vehicle), the volkswagen tools and equipment team has identified
- Bulletin:
- A171782 2010043-
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin contains all the the audi oil quality standards that should be used when doing an oil change.
Home | Privacy