2003 SATURN ION Recalls (8)
- Campaign:
- 04V003000 on 01/13/2004
- Component:
- Fuel system, gasoline
- Manufactured:
- 05/31/2002 - 09/29/2003
- Affected:
- 127,285
- Defect:
- Certain passenger vehicles equipped with 2.2l 4-cylinder (l61) engines were built with a fuel filter that could corrode prematurely on the exterior surface.
- Consequence:
- If corrosion on the exterior surface of the fuel filter progresses to the point of creating a hole in the shell, fuel droplets could form and drop to the ground. if an ignition source is present, a fire could result.
- Correction:
- Dealers will replace the fuel filter assembly. owner notification began on december 30, 2003. owners should contact saturn at 1-800-972-8876.
- Notes:
- Gm recall no. 03068.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V004000 on 01/13/2004
- Component:
- Visibility:power window devices and controls
- Manufactured:
- 05/31/2002 - 09/29/2003
- Affected:
- 79,204
- Defect:
- Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 118, "power-operated window, partition, and roof panel systems." the power windows and/or sunroof may be operable after the ignition has been turned to the "off" position and the front passenger door is opened.
- Consequence:
- If unsupervised children are left unattended in the vehicle and operate the power windows or sunroof, there is an increased risk of injury to the child.
- Correction:
- Dealers will upgrade the body control module (bcm) calibration. owner notification began on december 30, 2003. owners should contact saturn at 1-800-972-8876.
- Notes:
- Gm recall no. 03069.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V547000 on 11/17/2004
- Component:
- Exterior lighting:turn signal
- Manufactured:
- 05/31/2002 - 07/30/2003
- Affected:
- 178,798
- Defect:
- Certain passenger vehicles have a condition in which the turn signal lamp and daytime running lamp (drl) on either front side can stop working because of loss of contact between the bulb and socket.
- Consequence:
- If a front turn signal lamp is inoperative, others may react more slowly to a turning vehicle and a crash could occur.
- Correction:
- Dealers will replace the drl/turn signal bulb on both the left and right front side and inspect for and add a drl jumper kit if not present. the recall began november 17, 2004. owners should contact saturn at 1-800-972-8876.
- Notes:
- Gm recall no. 04095.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 14V047000 on 02/10/2014
- Component:
- Electrical system:ignition:switch
- Manufactured:
- 05/31/2002 - 07/23/2003
- Affected:
- 2,190,934
- Defect:
- This defect can affect the safe operation of the airbag system. until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. the key fob (if applicable), should also be removed from the key ring. general motors llc (gm) notified the agency on february 10, 2014 that they are recalling 619,122 model year 2005-2007 chevrolet cobalt, and 2007 pontiac g5 vehicles. on february 25, 2014, gm increased the recall to include an additional 748,024 model year 2006-2007 chevrolet hhr and pontiac solstice vehicles and 2003-2007 saturn ion vehicles and 2007 saturn sky vehicles. in these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. on march 27, 2014, gm notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result gm will be recalling certain model year 2008-2010 chevrolet cobalt, saturn sky, and pontiac g5 and solstice, and 2008-2011 chevrolet hhr vehicles. the part numbers for the service parts are 10392423 (a/k/a acdelco d1461f), 10392737, 15857948, 15854953, 15896640, and 25846762. this expansion represents an additional 823,788 vehicles.
- Consequence:
- If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
- Correction:
- Gm will notify owners, and dealers will replace the ignition switch, free of charge. an interim notification was issued to owners of 2007 and earlier models on march 10, 2014, informing them of the safety defect. owners of 2008 and later vehicles will be mailed an interim letter on april 21, 2014. all affected owners will receive another letter once parts are available. the recall began on april 18, 2014. owners may contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737 or saturn at 1-800-553-6000. gm's number for the initial recall is 13454 and 14063 for the expansion. gm's recall number for the vehicles that may have received the replacement parts is 14092. note: until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. the key fob (if applicable), should also be removed from the key ring. always wear your seatbelt.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14V047000 on 02/10/2014
- Component:
- Air bags
- Manufactured:
- 05/31/2002 - 07/23/2003
- Affected:
- 2,190,934
- Defect:
- This defect can affect the safe operation of the airbag system. until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. the key fob (if applicable), should also be removed from the key ring. general motors llc (gm) notified the agency on february 10, 2014 that they are recalling 619,122 model year 2005-2007 chevrolet cobalt, and 2007 pontiac g5 vehicles. on february 25, 2014, gm increased the recall to include an additional 748,024 model year 2006-2007 chevrolet hhr and pontiac solstice vehicles and 2003-2007 saturn ion vehicles and 2007 saturn sky vehicles. in these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. on march 27, 2014, gm notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result gm will be recalling certain model year 2008-2010 chevrolet cobalt, saturn sky, and pontiac g5 and solstice, and 2008-2011 chevrolet hhr vehicles. the part numbers for the service parts are 10392423 (a/k/a acdelco d1461f), 10392737, 15857948, 15854953, 15896640, and 25846762. this expansion represents an additional 823,788 vehicles.
- Consequence:
- If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
- Correction:
- Gm will notify owners, and dealers will replace the ignition switch, free of charge. an interim notification was issued to owners of 2007 and earlier models on march 10, 2014, informing them of the safety defect. owners of 2008 and later vehicles will be mailed an interim letter on april 21, 2014. all affected owners will receive another letter once parts are available. the recall began on april 18, 2014. owners may contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737 or saturn at 1-800-553-6000. gm's number for the initial recall is 13454 and 14063 for the expansion. gm's recall number for the vehicles that may have received the replacement parts is 14092. note: until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. the key fob (if applicable), should also be removed from the key ring. always wear your seatbelt.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14V171000 on 04/09/2014
- Component:
- Electrical system:ignition
- Manufactured:
- 05/31/2002 - 07/23/2003
- Affected:
- 2,191,014
- Defect:
- General motors llc (gm) is recalling certain model year 2005-2010 chevrolet cobalt, 2006-2011 chevrolet hhr, 2007-2010 pontiac g5, 2006-2010 pontiac solstice, 2003-2007 saturn ion, and 2007-2010 saturn sky vehicles. in the affected vehicles, the key can be removed from the ignition when the ignition is not in the "off" position.
- Consequence:
- If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "reverse" position. this potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
- Correction:
- General motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. for vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. the recall began on april 18, 2014. chevrolet owners may contact general motors at 1-800-222-1020, pontiac owners at 1-800-762-2737, and saturn owners at 1-800-553-6000. general motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. note: until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "park," or in the case of a manual transmission, that the vehicle is in the "reverse" position and the parking brake is engaged.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14E021000 on 05/08/2014
- Component:
- Electrical system:ignition:switch
- Affected:
- 14,529
- Defect:
- Uci-fram group is recalling certain ls1328 ignition switches sold as wells ls1328, duralast ls1328, airtex 1s6097, and carquest 53-27479, and ls1497 ignition switches sold as wells ls1497, duralast ls1497, airtex 1s10961, and carquest 53-27967, for use on various general motors model and model year vehicles during repair and replacement of the original ignition switch. the weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
- Consequence:
- If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
- Correction:
- Uci-fram group has notified its purchasers to quarantine and return all inventory. any switches already installed in vehicles will be replaced by gm dealers as part of nhtsa recall 14v-047, free of charge. uci-fram's purchasers should contact uci-fram group at 1-800-890-2075. gm vehicle owners requiring additional information on that recall campaign should contact gm at 1-800-222-1020 (chevrolet), 1-800-762-2737 (pontiac) or 1-800-553-6000 (saturn).
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2003 SATURN ION TSBs (364)
- Bulletin:
- 02I09
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding california vehicle code requirements regarding tire chain disclosure. vehicles that should not be operated with chains. *jg
- Bulletin:
- 02T74
- Component:
- 116000 electrical system:ignition
- Summary:
- Service manual update for certain 2003 models volume i preliminary service manual regarding ignition lock cylinder replacement / removal procedure and ignition cylinder and key code information in the 2003 key code manual. *tt
- Bulletin:
- 02T83
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Engine coolant leak from coolant pump drain plug. *tt
- Bulletin:
- 03T08
- Component:
- 135100 visibility:rearview mirrors/devices:interior
- Summary:
- Inside rear view mirror compass will not display all 8 compass directions. *tt
- Bulletin:
- 030602001
- Component:
- 060000 engine and engine cooling
- Summary:
- Design change to water pump used on l61 engine. *tt
- Bulletin:
- 030603005
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- (engine control module / transmission control module) ecm/tcm ignition module ground location change. *tt *mj
- Bulletin:
- 030604022
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Revised fuel inlet pipe to rail connection procedure and torque specification. *tt
- Bulletin:
- 030730013
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service manual update for vt25e (vti) transmission fluid pump pressure relief valve. *tt
- Bulletin:
- 030138004
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Hvac blower motor inoperative and/or blower speed is higher/lower than requested speed. *tt
- Bulletin:
- 030848003
- Component:
- 135100 visibility:rearview mirrors/devices:interior
- Summary:
- Inside rear view mirror compass will not display all 8 compass directions. *tt
- Bulletin:
- 030730010
- Component:
- 100000 power train
- Summary:
- Vt25e (vti) transaxle off-vehicle repair authorization. *tt
- Bulletin:
- 030604024
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Excessive fuel pump buzzing, growling noise, vibration from rear of vehicle. *tt
- Bulletin:
- 030138006
- Component:
- 353600 equipment:air conditioner
- Summary:
- Revised hvac compressor clutch does not engage diagnostic table. *tt
- Bulletin:
- 030601017
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Timing chain design change and revised service procedures. *tt
- Bulletin:
- 030842005
- Component:
- 120000 exterior lighting
- Summary:
- Service manual update for 2003 saturn ion body and accessories service manual regarding stop lamp switch replacement procedure. *tt
- Bulletin:
- 030864016
- Component:
- 162300 structure:body:door
- Summary:
- Rear outer door panel cracking at front upper mounting bolt/bumper location. *tt
- Bulletin:
- 030731003
- Component:
- 100000 power train
- Summary:
- Clutch makes chatter/rattling noise and/or will not release when clutch pedal is fully depressed. *tt
- Bulletin:
- 030604029
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine light (service engine soon) illuminated, diagnostic trouble code p1683 and/or p0116 set. *tt
- Bulletin:
- 030730026
- Component:
- 100000 power train
- Summary:
- Service manual update - revised torque specification for vt23e (vti) transaxle variable driven pulley bearing retainer bolts. *tt
- Bulletin:
- 030867006
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Roof panel flexing during sunroof operation or sunroof rattling on rough road surfaces. *tt
- Bulletin:
- 030522001
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Service manual update regarding updated mini schematic, diagnostic trouble code (dtc) c0267, in the hydraulic brakes section of the 2003 saturn ion brakes service manual. *tt
- Bulletin:
- 030844010
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Six-disc radio will not load, eject and/or play compact discs (cds). *tt
- Bulletin:
- 030730030
- Component:
- 100000 power train
- Summary:
- 1st design af23-5 transaxle replacements with 2nd design transaxles. *tt
- Bulletin:
- 030842009
- Component:
- 120000 exterior lighting
- Summary:
- One or both daytime running lamps (drl) are inoperative, diagnostic trouble code (dtc) b3948 and/or b3949 may be set. *tt erratic front turn signal operation when using a cell phone charger in either accessory power outlet. *tt
- Bulletin:
- 030844012
- Component:
- 162000 structure:body
- Summary:
- Water leaks into the front driver and/or passenger foot wells near the front speaker grill area after sustained heavy rain. *tt
- Bulletin:
- 030139011A
- Component:
- 353600 equipment:air conditioner
- Summary:
- Water leaks into passenger compartment with vehicle in incline/uphill position. *tt this bulletin replaced previous version dated 08-01-03. *tt
- Bulletin:
- 030843004
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Windshield wipers chatter or hop across windshield during wiper operation. *tt
- Bulletin:
- 030862002
- Component:
- 162000 structure:body
- Summary:
- Rear fascia paint is scuffed below rear compartment lid applique. *tt
- Bulletin:
- 030844017
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Changes to the am/fm stereo and audio disc player radio on-board diagnostic modes and cd load operation. *tt
- Bulletin:
- 030730030A
- Component:
- 100000 power train
- Summary:
- Af23-5 transaxle replacement and transmission control module (tcm) reprogramming. *tt
- Bulletin:
- 030866010
- Component:
- 162000 structure:body
- Summary:
- Wet and/or stained trim carpeting in right rear area of trunk. *tt
- Bulletin:
- 030844016
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Compact discs (cds) skip in single cd player. *tt
- Bulletin:
- 030852006
- Component:
- 350000 equipment
- Summary:
- Installation of remote keyless entry (rke) to ion2 vehicles. *tt
- Bulletin:
- 030864035
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Front side door lock cylinder is missing or does not sit flush to the outer door panel. *tt
- Bulletin:
- 030089033A
- Component:
- 980000 unknown or other
- Summary:
- Trailer, recreational and disabled vehicle towing information. *tt *sc
- Bulletin:
- 030844019
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Low volume ticking noise, radio volume resolution or cd will not load/eject. *tt
- Bulletin:
- 030089032
- Component:
- 980000 unknown or other
- Summary:
- Recreational and disabled vehicle towing information. *tt
- Bulletin:
- 030730048
- Component:
- 106000 power train:axle assembly
- Summary:
- Service information regarding transaxle poor performance after case cover replacement, diagnostic trouble code p1882 set. *tt
- Bulletin:
- 030090003
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil filter cap assembly and oil filter element design change. *tt
- Bulletin:
- 030729007
- Component:
- 102000 power train:manual transmission
- Summary:
- Service information regarding design change to the manual transmission shift control housing and the manual transmission select and shift lever cables. *tt
- Bulletin:
- 030730041
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service manual update for vt25e (vti) transmission front differential carrier thrust washer. *tt
- Bulletin:
- 030089025
- Component:
- 980000 unknown or other
- Summary:
- Clarification of labor codes used for reprogramming vehicle controllers. various models including the 2004 l-series. *tt
- Bulletin:
- 030844013
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Revised saturn radio lockout code phone number. 2003 saturn ion and 2004 saturn l-series. *tt
- Bulletin:
- 030730051
- Component:
- 103000 power train:automatic transmission
- Summary:
- Low speed coast grinding noise and/or hesitation at vehicle launch - technical service bulletin. *tt to include 2005 saturn vue. *eh
- Bulletin:
- 030730052
- Component:
- 100000 power train
- Summary:
- Engine flare during 2-3 shift, most noticeable during light to moderate acceleration. *tt updated *eh
- Bulletin:
- 030234002
- Component:
- 010000 steering
- Summary:
- Squeak or squeal noise while turning vehicle. *tt
- Bulletin:
- 030730055
- Component:
- 100000 power train
- Summary:
- Service information regarding 2002 and 2003 model year vt25e transaxle replacement with 2004 model year vt25e transaxle. *tt
- Bulletin:
- 030138020
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning (a/c) condensation leaking onto the vehicle floor during times of a/c usage. *tt this bulletin replaces 03-01-38-020 dated 11/01/2003. *tt
- Bulletin:
- 030730049
- Component:
- 160000 structure
- Summary:
- Speedometer fluctuation. *tt
- Bulletin:
- 030524001
- Component:
- 034410 service brakes, hydraulic:foundation components:drum:wheel cylinders
- Summary:
- Service information regarding saturn rear drum wheel cylinder inspections. *tt update. *tt
- Bulletin:
- 030844016A
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Compact discs (cds) skip in single cd player. *tt
- Bulletin:
- 010104
- Component:
- 110000 electrical system
- Summary:
- Speedometer fluctuation. *tt
- Bulletin:
- 030730023A
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicle does not shift or move after running for a period of time and/or check engine light is on and dtc p0741 is set. *ph *sc
- Bulletin:
- 060303010
- Component:
- 060000 engine and engine cooling
- Summary:
- Service manual update regarding troubleshooting table for diagnostic trouble code (dtc) p0621. *ph
- Bulletin:
- 030864039
- Component:
- 162300 structure:body:door
- Summary:
- Water enters passenger compartment, creaking noise from door while driving and/or rear door header seal pulls away from door. *ph
- Bulletin:
- 020235008A
- Component:
- 012000 steering:column
- Summary:
- Fluid dripping on driver's floormat. *ph
- Bulletin:
- 030604024A
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Excessive fuel pump buzzing, growling noise, vibration from rear of vehicle. *tt
- Bulletin:
- 01592
- Component:
- 110000 electrical system
- Summary:
- 2003-2004 generation 5 onstar steering wheel control function explanation. sit bulletin 1416474. *tt
- Bulletin:
- 030730052A
- Component:
- 103000 power train:automatic transmission
- Summary:
- Engine flare during 2-3 shift, most noticeable during light to moderate acceleration. the condition may be caused by aeration of transaxle fluid, resulting in a delayed apply of 3rd clutch. corporate bulletin number 03-07-30-052 *m
- Bulletin:
- 040730005
- Component:
- 103000 power train:automatic transmission
- Summary:
- Hiss/chirp noise in park or neutral. *mn
- Bulletin:
- 030235005
- Component:
- 010000 steering
- Summary:
- Service procedure to verify proper valet key functions prior to customer delivery. *tt
- Bulletin:
- 030603010
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service manual update regarding troubleshooting table for diagnostic trouble code (dtc) p0621. *tt
- Bulletin:
- 030842011
- Component:
- 114000 electrical system:wiring
- Summary:
- Service manual update for headlamp wiring harness replacement. *tt
- Bulletin:
- 030864038
- Component:
- 130000 visibility
- Summary:
- Aftermarket window tinting scratched or torn. *tt
- Bulletin:
- 0306123001
- Component:
- 060000 engine and engine cooling
- Summary:
- Slight loss of coolant or low coolant light coming on with no signs of external leaks. also the engine may be difficult to start; engine misfire for several seconds; and/or white smoke or coolant odor from the tailpipe. *tt
- Bulletin:
- 040730011
- Component:
- 100000 power train
- Summary:
- Anaerobic sealant application requirements for vt25e transaxle. service manual update. *tt *mj
- Bulletin:
- 040604010
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Malfunction indicator lamp (mil) service engine soon telltale illuminated, diagnostic trouble code (dtc) p0606 may be stored. *tt
- Bulletin:
- 040863003
- Component:
- 176100 latches/locks/linkages:hood:latch
- Summary:
- Service manual update - hood opening procedure for inoperative hood latch. *tt
- Bulletin:
- 040868001
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Service manual update regarding the cruise control inoperative/malfunctioning diagnostic table. *tt
- Bulletin:
- 040863002
- Component:
- 176100 latches/locks/linkages:hood:latch
- Summary:
- Hood latch release cable frozen/seized. *tt
- Bulletin:
- 040235006
- Component:
- 012000 steering:column
- Summary:
- Rattle noise from steering column. *mr
- Bulletin:
- 040730016
- Component:
- 100000 power train
- Summary:
- 1-2 and/or 2-3 upshift delay, harsh tip-in downshift, erratic engagement of down slope mode. *tt
- Bulletin:
- 040308003
- Component:
- 021100 suspension:front:stabilizer bar
- Summary:
- Squeak, rattle, pop or clunk noise from front of vehicle during suspension movement. *mr *tt
- Bulletin:
- 04020
- Component:
- 106000 power train:axle assembly
- Summary:
- Special policy adjustment - extended transmission warranty coverage for the variable transmission with intelligence (vti) transmission. *mr
- Bulletin:
- 040089012
- Component:
- 980000 unknown or other
- Summary:
- Saturn field product reminder- vehicle fix it right the first time issues, parts restriction information and technical bulletins released in january, february, and march 2004. *mr
- Bulletin:
- 040849010
- Component:
- 162000 structure:body
- Summary:
- Instrument cluster needle pointers do not light up when key is in the run position and the headlamps are off - normal operating condition. *tt
- Bulletin:
- 040604029
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Erratic engine speed control at closed throttle. elevated engine rpm and/or stall. *tt this bulletin replaces previous version dated april 2004. *tt
- Bulletin:
- 040601009
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil leak from front cover seal during extremely cold weather. *tt
- Bulletin:
- 040845005
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- No crank, no start when ambient temperatures is cold - diagnostic trouble codes (dtcs) b2960 and or b3033 are set. *tt
- Bulletin:
- 040308005
- Component:
- 020000 suspension
- Summary:
- Service manual update regarding tightening procedure and specification for the ball joint-to-steering knuckle nut.*mr
- Bulletin:
- 040308006
- Component:
- 020000 suspension
- Summary:
- Cluck, thump or rattle noise from front suspension while driving over rough road conditions or when braking (replace front lower control arm rear bushing). *mj updated 10/5/07. *nj updated 5/20/11. *pe
- Bulletin:
- 040845006
- Component:
- 110000 electrical system
- Summary:
- Sunroof inoperative and/or inside rearview mirror electrical functions inoperative. *tt
- Bulletin:
- 040604035
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code (dtc) po132, p0138, or p0172 diagnostic enhancements. *mj
- Bulletin:
- 040730024A
- Component:
- 100000 power train
- Summary:
- No movement in drive or reverse with or without diagnostic trouble codes (dtcs) p1758, p1758, p1882, p0841, p0741, p0742. *mj this bulletin replaced previous 04-07-30-024. *tt
- Bulletin:
- 040846001
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Service support and technical assistance for onstar and/or xm radio. *mj
- Bulletin:
- 040845002
- Component:
- 110000 electrical system
- Summary:
- Service manual updated - body control module (bcm) connector c3 and c4 illustrations. *mj
- Bulletin:
- 040138011
- Component:
- 353600 equipment:air conditioner
- Summary:
- Temperature/mode control knobs may not rotate, air flow restricted, or hvac mode door gasket or temperature door gasket foam comes off. *tt
- Bulletin:
- 040844015
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Return form for compact discs (cds) or digital versatile discs (dvds) that are stuck in cd player when returned as a core return. *tt
- Bulletin:
- 040850013
- Component:
- 162000 structure:body
- Summary:
- Squeak/itch noise from rear seat when driving on rough surfaces. *tt
- Bulletin:
- 040730032
- Component:
- 103000 power train:automatic transmission
- Summary:
- Grind/rattle noise from transaxle in park and neutral after an extended cold soak following case cover replacement or other internal transaxle overhaul. *tt
- Bulletin:
- 040845007
- Component:
- 110000 electrical system
- Summary:
- Additional power distribution information for body control module electrical (bcm elect) fuse in the instrument panel fuse block (ipfb). *tt
- Bulletin:
- 040730036
- Component:
- 100000 power train
- Summary:
- Revised vt25e (vti) spacer plate available. *tt
- Bulletin:
- 3034
- Component:
- 100000 power train
- Summary:
- No reverse after case cover assembly replaced. *tt
- Bulletin:
- 3050A
- Component:
- 350000 equipment
- Summary:
- 02-05 onstar equipped vehicles emitting beeping noise before connecting to onstar. *tt
- Bulletin:
- 3035
- Component:
- 100000 power train
- Summary:
- No forward or reverse gears or line pressure after a valve body replacement on a vt25e transaxle. *tt
- Bulletin:
- 040308013
- Component:
- 020000 suspension
- Summary:
- Creaking/squeaking noise from the front suspension when turning the steering wheel. *tt
- Bulletin:
- 3122
- Component:
- 034300 service brakes, hydraulic:foundation components:differential proportional valve
- Summary:
- Delay into reverse or no reverse after valvebody replacement. *sc
- Bulletin:
- 3119
- Component:
- 980000 unknown or other
- Summary:
- No selection fir saturn when programming a saturn vehilcle. *sc
- Bulletin:
- 3105
- Component:
- 160000 structure
- Summary:
- Gap is present between the front fascia and headlamp assembly. *jb
- Bulletin:
- 3044
- Component:
- 350000 equipment
- Summary:
- Generation 5 onstar steering wheel control function. *tt
- Bulletin:
- 040137008
- Component:
- 353600 equipment:air conditioner
- Summary:
- Heater-ventilation-air conditioning (hvac) blower motor click/tick or chirping noise. *tt
- Bulletin:
- 04095
- Component:
- 120000 exterior lighting
- Summary:
- Daytime running lights (drl) / turn signal bulb. replacement and drl jumper kit installation. latest part availability and shortage information. stocking policy message. *tt
- Bulletin:
- 040730007
- Component:
- 103000 power train:automatic transmission
- Summary:
- On wheel movement in snow or slippery surfaces. *eh
- Bulletin:
- 040842002
- Component:
- 126100 exterior lighting:turn signal:flasher unit
- Summary:
- Turn signal indicator flashing faster than normal and corresponding front turn signal bulb inoperative. *eh updated *eh
- Bulletin:
- 040867007
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Sunroof drain hose rattle. *tt
- Bulletin:
- 050307001A
- Component:
- 020000 suspension
- Summary:
- Premature and/or irregular tire wear. *tt
- Bulletin:
- 2377
- Component:
- 126000 exterior lighting:turn signal
- Summary:
- Update-2003-2004 ion sedan turn signal lamp/drl saturn letter to owners. *sc
- Bulletin:
- 0804
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil life system reset procedures - cars. *nm
- Bulletin:
- 3421B
- Component:
- 110000 electrical system
- Summary:
- Engine stalls, loss of electrical systems, and no diagnostic trouble code (dtc). including 2005-06 pontiac pursuit. *tt *sc
- Bulletin:
- 050730004
- Component:
- 103000 power train:automatic transmission
- Summary:
- Intermittent no movement in drive or reverse with or without diagnostic trouble codes. *eh
- Bulletin:
- 050730005
- Component:
- 103000 power train:automatic transmission
- Summary:
- Low speed grind noise and or hesitation while driving. *eh
- Bulletin:
- 050730008
- Component:
- 103000 power train:automatic transmission
- Summary:
- Engine flare during 2-3 shift most noticeable during light to moderate acceleration. *eh
- Bulletin:
- 050730006
- Component:
- 110000 electrical system
- Summary:
- Service engine soon telltale illuminated with diagnostic trouble code p0742. *eh
- Bulletin:
- 3433
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon (ses) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3. *tt updated 08-15-07. *kb
- Bulletin:
- 3396
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Sulfur odor from exhaust. *sc
- Bulletin:
- 3251
- Component:
- 100000 power train
- Summary:
- Transaxle slips, no third gear, engine flare during shift after transaxle service. *sc
- Bulletin:
- 050232002A
- Component:
- 010000 steering
- Summary:
- Power steering inoperative/steering wheel hard to turn, pwr str message displayed on driver information center (dic) after jump starting vehicle. *tt
- Bulletin:
- 050730003
- Component:
- 100000 power train
- Summary:
- Intermittent hesitation during vehicle launch. *tt
- Bulletin:
- 050232005
- Component:
- 010000 steering
- Summary:
- Ei05093 - clunk noise in steering system at slow speeds while turning and/or driving over bumps. *tt (replace intermediate shaft). updated 10/05/07. *nj updated 11/02/07 *nj
- Bulletin:
- 050848003
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Rear defogger grid inoperative or incomplete defogging of rear glass. *tt
- Bulletin:
- 709
- Component:
- 060000 engine and engine cooling
- Summary:
- Oil life system reset procedures - cars. gm tech link. *tt
- Bulletin:
- 3506A
- Component:
- 110000 electrical system
- Summary:
- Incorrect mileage displayed after programming a new bcm. various models including 2005 - 2006 pontiac pursuit (canada only). *tt
- Bulletin:
- 3633
- Component:
- 103000 power train:automatic transmission
- Summary:
- Remanufactured vt25e transmission quality issues. inoperative, noise, slip, low pressure or leak related concern. *tt
- Bulletin:
- 3627
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Fuel tank is slow to fill and/or dtc p0446 - inspect evap vent pipe. the ses lamp may be illuminated due to a p0466 dtc. *tt updated 08-15-07. *kb
- Bulletin:
- 050309010
- Component:
- 020000 suspension
- Summary:
- Identifying correct design level of rear axle assembly. *jb
- Bulletin:
- 3648
- Component:
- 114100 electrical system:wiring:front underhood
- Summary:
- Hesitation on acceleration after internal engine repairs - check injector harness orientation. *tt
- Bulletin:
- 3674
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon light due to p0300 - inspect fuel system for rust contamination. *tt
- Bulletin:
- 3669
- Component:
- 103000 power train:automatic transmission
- Summary:
- M86/m94 transmission information to disassemble third fourth and fifth gear. *ak
- Bulletin:
- 060232002
- Component:
- 010000 steering
- Summary:
- Normal operating characteristics of electric power steering (eps) system during extended lock-to-lock (maximum steering wheel rotation) usage. *tt updated 3/30/11. *pe
- Bulletin:
- 3958
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Bcm service part not available for tsb 04-08-45-005c. *ak
- Bulletin:
- 050232002
- Component:
- 010000 steering
- Summary:
- Power steering inoperative/steering wheel hard to turn, pwr str displayed on driver information center (dic). after jump starting the vehicle. *kb (replace fuse and instruct owner how to jump start vehicle). updated 2/17/10. *p
- Bulletin:
- 3859
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj
- Bulletin:
- 050235007
- Component:
- 010000 steering
- Summary:
- Information on inadvertent turning of key cylinder, loss of electrical system and no dtc's. *kb
- Bulletin:
- 4014
- Component:
- 980000 unknown or other
- Summary:
- Parts update - timing chain tensioner design change. *kb
- Bulletin:
- 03-00-89-033
- Component:
- 980000 unknown or other
- Summary:
- Trailer, recreational and disabled vehicle towing information. *kb updated 08-15-07. *kb updated 10/09/07. *nj updated 4/3/08. *nj
- Bulletin:
- 000310006
- Component:
- 020000 suspension
- Summary:
- Information on tire radial force variation (rfv). 2008 and prior gm passenger cars and light duty trucks including 2008 and prior hummer h2, h3 and 2005-08 saab 9-7x and 2000-05 saturn l series and 2003-07 saturn ion. *kb updated 4/1
- Bulletin:
- 070729001
- Component:
- 102000 power train:manual transmission
- Summary:
- Mg3, m86 transaxle grinding/whining noise in 3rd or 4th gear, excessive engagement or disengagement effort while shifting into 3rd or 4th gear, will not shift into either 3rd or 4th gear. (replace complete output shaft assembly). *kb
- Bulletin:
- 070861005
- Component:
- 111000 electrical system:battery
- Summary:
- Floor plan corrosion (rust) perforation in battery compartment. *kb
- Bulletin:
- 070232007
- Component:
- 010000 steering
- Summary:
- Diagnostic tips for power steering inoperative/steering wheel hard to turn, power steering message displayed on dic, dtc's c0176, c0176, c0475, c0476, c0550, u2105, u2107 set. *nj updated 2/17/10. *pe updated 3
- Bulletin:
- 08-089
- Component:
- 353000 equipment:electrical
- Summary:
- Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
- Bulletin:
- 08089-B
- Component:
- 110000 electrical system
- Summary:
- General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
- Bulletin:
- SB-09280A
- Component:
- 103000 power train:automatic transmission
- Summary:
- Saturn service campaign: see document search button for owner letter. new special reimbursement policy for vehicles equipped with variable transmission with intelligence (vti) transmission-50 percent of transmission repair cost will be pai
- Bulletin:
- SB-00-03-10-006C
- Component:
- 190000 tires
- Summary:
- General motors: information on tire radial force variation. vehicle must be driven before measuring tires on equipment hunter gsp9700 toensure removal of any flatspotting. models include all gm passenger cars and light trucks, as well as
- Bulletin:
- PIP-4674
- Component:
- 102000 power train:manual transmission
- Summary:
- Chevrolet/pontiac/saturn: blocked shift, gear hop out 1st, 3rd, 5th gear or difficulty shifting. the shift lever on the manual transmissions roll pin can back out and contact the shift cover during a shift event. this can cause an incompl
- Bulletin:
- 09-09-40-001A
- Component:
- 150000 seat belts
- Summary:
- Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
- Bulletin:
- PIP-4495C
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm
- Bulletin:
- SB-10-08-50-003B
- Component:
- 221300 seats:front assembly:head restraint
- Summary:
- General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
- Bulletin:
- PIC-5580
- Component:
- 035000 service brakes, hydraulic:fluid
- Summary:
- Saturn: low brake fluid warning and/or red brake light on due to possible brake fluid reservoir or fluid switch being replaced. brake and brake pedal operation not affected. *pe updated 2/8/12. *pe
- Bulletin:
- 14632
- Component:
- 116000 electrical system:ignition
- Summary:
- General motors 2005-2011 chevrolet cobalt, hhr 2006-2010 pontiac solstice, g5,g4,2007-2010 saturn sky , 2003-2007 saturn ion: see document search button for owners letter. certain vehicles are unable to remove ignition key due transmissio
- Bulletin:
- 14632B
- Component:
- 116000 electrical system:ignition
- Summary:
- This tsb contains owner notification letter. select document search button below. general motors 2003-2011 vehicles equipped with an automatic transmission, unable to remove ignition key. *lj
- Bulletin:
- SB-0000186359-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000190527-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000186726-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000187754-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000187705-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000188486-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000189716-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-02000189717-A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000189719-A
- Component:
- 116000 electrical system:ignition
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000190649-A
- Component:
- 116000 electrical system:ignition
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000191604-A
- Component:
- 116000 electrical system:ignition
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-0000191608-A
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 14063
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 14063A
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 14063B
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 14063C
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- PIC-5050-A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC-4935-E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- G-208939
- Component:
- 016000 steering:electric power assist system
- Summary:
- 14119 - special coverage (message only - customer letter mailing notification). some 2006-2009 model year chevrolet hhr (non-turbo) and 2003 model year saturn ion vehicles equipped with electric power steering may experience a sudden loss o
- Bulletin:
- G-206561
- Component:
- 116000 electrical system:ignition
- Summary:
- 14632 - special coverage. on some vehicles equipped with an automatic transmission, the vehicle's transmission shifter may not properly transmit an electrical signal that allows the ignition key to be turned counter clockwise past the acce
- Bulletin:
- G-206857
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 14632 - special coverage (q&a). on december 11, 2014, general motors released special coverage adjustment 14632. the total number of u.s. vehicles involved is approximately 1.9 million. in order to assist dealers with responding to custome
- Bulletin:
- 16NA260
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
- Bulletin:
- 000601012F
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
- Bulletin:
- PI1394A
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
- Bulletin:
- PIC4935E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- PIC5050A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC5088F
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
- Bulletin:
- PIT5389A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
- Bulletin:
- PIT5485B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- PIT5485A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- 14119
- Component:
- 010000 steering
- Summary:
- 14119 - special coverage. some vehicles equipped with electric power steering may experience a sudden loss of power steering assist that could occur at any time while driving. if the power steering assist is lost, a message is displayed on
- Bulletin:
- PIC3278F
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
- Bulletin:
- PIP5226A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
- Bulletin:
- PIC5491J
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. technician should turn off the ignition and cancel retained accessory power. after the vehic
- Bulletin:
- PIP5029G
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
- Bulletin:
- PIC5492E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a diagnostic trouble code b101d-37 history in the vehicle communication interface module or telematics communication interface contro
- Bulletin:
- PIT3099L
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
- Bulletin:
- PIT4864F
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician about a customer?s request to install onstar bluetooth. dealer should be advised at this time, there are no provisions to add this option to vehicles that wer
- Bulletin:
- PIT5264
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication provides information to the technician about vehicles that when a canadian customer may comment that when they travel to the united states, they are unable to connect to onstar or use hands free ca
- Bulletin:
- PIC5453A
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This preliminary information communication provides information to the technician that general motors and general motors of canada company do not support cross border sales. the general motors of canada customer care centre is the sole auth
- Bulletin:
- PIT4943C
- Component:
- 030000 service brakes, hydraulic
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0442. technician will need to review t
- Bulletin:
- PIC3011H
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have the onstar system does not respond properly to some numbers and/or voice commands. dealer should direct the customer to review the op
- Bulletin:
- PIP3140F
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. technician should look for non - general motors a
- Bulletin:
- PIC5953
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIP5163A
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
- Bulletin:
- PIC4310J
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIT3099M
- Component:
- 356000 equipment adaptive
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
- Bulletin:
- PIP5226
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
- Bulletin:
- 03-08-46-004R
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
- Bulletin:
- PIP5163
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
- Bulletin:
- PIT3099J
- Component:
- 356000 equipment adaptive
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory parts. technician can check service information for some accessories. technician can also contact partech for assist
- Bulletin:
- PIC4935D
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar
- Bulletin:
- PIT4907A
- Component:
- 030000 brakes (pws)
- Summary:
- This preliminary information communication provides information to the technician about brake rotors on new vehicles and replacement parts from general motors service parts operations. technician should be advised the costing should not be
- Bulletin:
- PIC4310H
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIT3173C
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. dealer should send the correc
- Bulletin:
- PIC3718E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles may have a no power or no connect concern. technician will find that the onstar led is red and diagnostic trouble code u1500 is set. technician
- Bulletin:
- PIP4495D
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
- Bulletin:
- 08-07-30-026C
- Component:
- 113000 electrical system:starter assembly
- Summary:
- This informational bulletin provides information on vehicles may rock or move slightly forward or rearward while in park at start up after cold soak and that this is considered a normal conditon and no repairs are necessary
- Bulletin:
- PIP5094
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician that, when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of
- Bulletin:
- PIP3140E
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. technician should look for non - general motors a
- Bulletin:
- PIT4720C
- Component:
- 117000 digital instrument panel
- Summary:
- This preliminary information communication provides information to the technician that after replacing the instrument panel cluster the exchange center is unable to program the actual mileage on the odometer or the actual mileage is unknown
- Bulletin:
- PIC5904
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the onstar system will not connect. technician should record module info per the latest version of pic4310 and contact general motors tech
- Bulletin:
- PIT3099K
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partech for assista
- Bulletin:
- PIP5338A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
- Bulletin:
- PIP5029H
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
- Bulletin:
- PIC5588C
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
- Bulletin:
- PIC3278G
- Component:
- 010000 steering
- Summary:
- This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
- Bulletin:
- PIC4801H
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have an onstar turn-by-turn navigation the system that is inoperative. technician verifies there are no diagno
- Bulletin:
- PIP4723B
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
- Bulletin:
- PIC4935F
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- PIT5389C
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- 00-03-10-003R
- Component:
- 190000 tires
- Summary:
- This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
- Bulletin:
- 02-08-42-001H
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
- Bulletin:
- 15-08-44-001B
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-44-001A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 05-06-04-035E
- Component:
- 090000 fuel system, other
- Summary:
- This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
- Bulletin:
- 02-07-30-052J
- Component:
- 103000 power train:automatic transmission
- Summary:
- This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool j-45096 transflow®.
- Bulletin:
- 15-08-44-001C
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-44-001
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-73-001
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
- Bulletin:
- 05-08-46-006T
- Component:
- 110000 electrical system
- Summary:
- This informational bulletin provides information to dealership personnel on upgrading certain onstar analog/digital-ready systems to onstar generation 6 digital-capable system.
- Bulletin:
- 09-09-40-001C
- Component:
- 150000 seat belts
- Summary:
- This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
- Bulletin:
- 10-00-89-017X
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
- Bulletin:
- 11-00-89-005C
- Component:
- 356000 equipment adaptive
- Summary:
- This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
- Bulletin:
- PIP5232C
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
- Bulletin:
- PIC6181
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication advises the technician after the onstar canada upgrade the onstar vehicle diagnostic email report is inoperative. please communicate to the customer that we apologize for this inconvenience and tha
- Bulletin:
- 11-00-89-005H
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This warranty bulletin clarifies the use of dealer empowerment to satisfy the customer.
- Bulletin:
- 13-00-89-004J
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
- Bulletin:
- 07-08-49-020I
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides a quick guide to updating which model vehicle after replacing the ipc.
- Bulletin:
- PIC4310K
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIC3278F
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
- Bulletin:
- PIT3271G
- Component:
- 190000 tires
- Summary:
- This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
- Bulletin:
- PIT5264C
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
- Bulletin:
- PIC5953A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIC4310L
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIT5399
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
- Bulletin:
- PIP5029F
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
- Bulletin:
- PIT5353
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
- Bulletin:
- PIT5389B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to contact general motors t
- Bulletin:
- PIP5163B
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leaka
- Bulletin:
- PIT3099N
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
- Bulletin:
- PIP5338
- Component:
- 020000 suspension
- Summary:
- This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
- Bulletin:
- PIC5953B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIT4943D
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0442. technician will need to review t
- Bulletin:
- PIT5353A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
- Bulletin:
- PIT5486
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication provides information to the technician about vehicles that when dialing certain numbers using onstar hands-free calling, the audio is distorted or has poor quality after performing the onstar canad
- Bulletin:
- PIC6101
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that are unable to receive onstar hands free calling calls and or the onstar center is unable to perform remote services. technician will need
- Bulletin:
- PIT5384A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have the onstar wireless fidelity inoperative. technician will need to contact general motors technical assistance center with a scan
- Bulletin:
- PIC6107
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about being unable to receive onstar ?over the air? updates. technician will need to press the onstar button and verify they have an active account and that t
- Bulletin:
- PIC3100E
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odometer. i
- Bulletin:
- PIP5232B
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
- Bulletin:
- 03-08-46-004S
- Component:
- 118000 electrical system: software
- Summary:
- This informational bulletin provides information on onstar® vcim is currently restricted parts. by working closely with our dealers and technicians, through the part restriction process, the general motors team will gain a better understand
- Bulletin:
- 07-08-49-020L
- Component:
- 110000 electrical system
- Summary:
- This informational bulletin provides information for the ipc odometer programming method quick reference guide.
- Bulletin:
- 10-00-89-006F
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides information for dealers how to submit a product information report.
- Bulletin:
- 01-08-42-001K
- Component:
- 121000 exterior lighting:headlights
- Summary:
- This informational bulletin provides information on exterior lamp condinsation and replacement guidelines
- Bulletin:
- 02-08-42-001I
- Component:
- 121000 exterior lighting:headlights
- Summary:
- This informational bulletin provides an out line on headlamp, tail lamp, license lamp or fog/driving lamp damage and what should be considered warranty replacement and not
- Bulletin:
- 11-00-89-005I
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm (u.s. only)
- Bulletin:
- PIT3099P
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
- Bulletin:
- PIC5588D
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
- Bulletin:
- 10-00-89-017V
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
- Bulletin:
- 11-00-89-005B
- Component:
- 356000 equipment adaptive
- Summary:
- This warranty administrational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm
- Bulletin:
- 10-08-110-001A
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides a revision for 10-08-110-001 to add the 2012-2014 model years.
- Bulletin:
- 05-06-04-022J
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides a revision for 04-06-04-047 to add the 2014 model year.
- Bulletin:
- 04-06-04-047L
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides a revision for 04-06-04-047k to add the 2014 model year.
- Bulletin:
- 13-00-89-004D
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides an update for 13-00-89-004c to include updated information.
- Bulletin:
- 07-08-49-020K
- Component:
- 118000 electrical system: software
- Summary:
- This informational bulletin explains the programming method quick reference guide for the ipc odometer.
- Bulletin:
- 09-00-89-008C
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This warranty admin bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the personal property damage process.
- Bulletin:
- PIP4495E
- Component:
- 162800 structure:body:hood
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
- Bulletin:
- PIT5353B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
- Bulletin:
- PIC3100F
- Component:
- 117000 digital instrument panel
- Summary:
- This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odomete
- Bulletin:
- PIC5588B
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
- Bulletin:
- PIC5088E
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may not receiving all channels on the xm band. technician will need to use a scan tool and verify current digital radio receiver status un
- Bulletin:
- 080846004A
- Component:
- 118000 electrical system: software
- Summary:
- This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.
- Bulletin:
- 000089027G
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a step by step procedure on how to properly use the gm chemicals to eliminate unwanted odors in vehicles and which products to use for each application.
- Bulletin:
- 100089010B
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides information and rules for gm keycode look up applicationa dn the key code security rules and regulations for canada only.
- Bulletin:
- 100089017W
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a list of newly released pi and bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.
- Bulletin:
- 010089010J
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides a single point reference and strategy document to aid in reducing customer comebacks, and the possibility of buyback situations by outlining specific guidelines, strategy and forms that will assist with
- Bulletin:
- 1008110001C
- Component:
- 350000 equipment
- Summary:
- This information provides the proper way to install the floor mats .
- Bulletin:
- 030848006J
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.
- Bulletin:
- PIC5088E
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary bulletin provides procedures on how to reset or refresh the xm radio receiver is the customers states that they only get a few channels.
- Bulletin:
- GCUS-9-3091
- Component:
- 100000 power train
- Summary:
- 14632c special coverage. on some vehicles equipped with an automatic transmission, the vehicle's transmission shifter may not properly transmit an electrical signal that allows the ignition key to be turned counter clockwise past the access
- Bulletin:
- PIP3535C
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. dealers
- Bulletin:
- PIP5325
- Component:
- 070000 fuel system, gasoline
- Summary:
- This preliminary information communication provides information to the technician to help determine if the vehicle is equipped with factory or aftermarket compressed natural gas, liquefied petroleum gas, or bi-fuel systems. technician will
- Bulletin:
- PIT5464
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the incoming caller id may no longer be available or displayed after the canada onstar upgrade. dealer should communicate to the customer
- Bulletin:
- PIP5540
- Component:
- 350000 equipment
- Summary:
- This preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. to allow the ice to melt so that it can be drained from the related component
- Bulletin:
- PIP5540A
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. to allow the ice to melt so that it can be drained from the related component
- Bulletin:
- PIT3271H
- Component:
- 200000 wheels
- Summary:
- This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
- Bulletin:
- PIP5226B
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
- Bulletin:
- 10-00-89-009B
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides information on key code security and information on gm key code look up applications.
- Bulletin:
- 10-00-89-010C
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides information on key codes security rules and information on gm key code look up application.
- Bulletin:
- 13-00-89-004
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This technical bulletin provides a revision of 10-00-89-017z to include updated information.
- Bulletin:
- 99-04-20-002H
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This technical bulletin provides a revision of 99-04-20-002g to add 2013-2014 model years.
- Bulletin:
- 13-00-89-004A
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This technical bulletin provides a revision of 13-00-89-004 to update car issues information for reference information/bulletin pi0746c.
- Bulletin:
- 13-00-89-005
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This technical bulletin provides warranty administration - new labor codes information.
- Bulletin:
- 05-00-89-072C
- Component:
- 070000 fuel system, gasoline
- Summary:
- This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.
- Bulletin:
- 13-00-89-004E
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This preliminary information bulletin provides a revision of 13-00-89-004d to include updated information.
- Bulletin:
- 10-00-89-006C
- Component:
- 284300 back over prevention: sensing system: radar
- Summary:
- This informational bulletin provides directions on submitting different pirs
- Bulletin:
- 070849020M
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides information for the ipc odometer programming method quick reference guide.
- Bulletin:
- 07-08-49-020H
- Component:
- 117000 digital instrument panel
- Summary:
- This technical service bulletin provides a revision for 07-08-49-020g to add the 2014 model year and update model list.
- Bulletin:
- 00-03-10-002G
- Component:
- 200000 wheels
- Summary:
- This informational bulletin provides information on the appearance of chromed aluminum wheels due to chemical staining, pitting corrosion and/or spotted.
- Bulletin:
- 10-00-89-017Z
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides information on fix it right for first time issues.
- Bulletin:
- 11-00-89-005D
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This warranty administration bulletin provide policy information on clarification of use-dealer empowerment labor operations and customer enthusiasm.
- Bulletin:
- 14632A
- Component:
- 110000 electrical system
- Summary:
- 14632a - special coverage (part name revised). on some vehicles equipped with an automatic transmission, the vehicle?s transmission shifter may not properly transmit an electrical signal that allows the ignition key to be turned counter clo
- Bulletin:
- 13-00-89-004H
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This information bulletin provides the technician with additional information on fixing the vehicle right the first time by listing possible concerns to specific vehicles.
- Bulletin:
- 02-08-42-001G
- Component:
- 350000 equipment
- Summary:
- This informational bulletin is to assist with the identification of issues that are not considered warrantable.
- Bulletin:
- 01-08-42-001J
- Component:
- 120000 exterior lighting
- Summary:
- This informational bulletin explains condensation in exterior lights and replacment guidelines for warranty replacement.
- Bulletin:
- PIP3333C
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have an intermittent engine misfire and a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p030
- Bulletin:
- PIC6036
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication provides information to the technician about vehicles that show an error message when a media disc is installed. technician will need to check the regular production option code list to verify if t
- Bulletin:
- PIP5232
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
- Bulletin:
- PIT5264A
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
- Bulletin:
- PIP5232A
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
- Bulletin:
- PIT5099A
- Component:
- 353600 equipment:air conditioner
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
- Bulletin:
- 15-08-73-001
- Component:
- 110000 electrical system
- Summary:
- This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
- Bulletin:
- 05-08-46-006T
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This informational bulletin provides information to dealership personnel on upgrading certain onstar analog/digital-ready systems to onstar generation 6 digital-capable system.
- Bulletin:
- PIC3843E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communicates to the dealer to disconnectthe ipc from bcm before programming will force the bcm to prompt the technician to enter the mileage during programming.
- Bulletin:
- 16-NA-383
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
- Bulletin:
- PIP5163C
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
- Bulletin:
- 10-00-89-006E
- Component:
- 350000 equipment
- Summary:
- This information bulletin provides the dealers on how to submit a product information report.
- Bulletin:
- 10-08-110-001B
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides information on how to use floor mats.
- Bulletin:
- 10-00-89-006D
- Component:
- 350000 equipment
- Summary:
- This information bulletin provides the dealers on how to submit a product information report.
- Bulletin:
- 00-00-89-027H
- Component:
- 353600 equipment:air conditioner
- Summary:
- This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
- Bulletin:
- 00-06-01-012E
- Component:
- 350000 equipment
- Summary:
- This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
- Bulletin:
- 13-00-89-004G
- Component:
- 350000 equipment
- Summary:
- This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
- Bulletin:
- 05-06-04-035D
- Component:
- 070000 fuel system, gasoline
- Summary:
- This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
- Bulletin:
- 13-00-89-004I
- Component:
- 350000 equipment
- Summary:
- This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
- Bulletin:
- 05-08-46-006S
- Component:
- 118000 electrical system: software
- Summary:
- This informational bulletin advises the technician to update the onstar from an analog system to a digital system if the customer wishes.
- Bulletin:
- 15-08-73-001A
- Component:
- 118000 electrical system: software
- Summary:
- This informational bulletin explains how to update the older onstar module software to new software over gsa.
- Bulletin:
- 17-NA-073
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
- Bulletin:
- 11-00-89-005C
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
- Bulletin:
- 10-00-89-017X
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
- Bulletin:
- 10-00-89-006D
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This information bulletin provides the dealers on how to submit a product information report.
- Bulletin:
- 00-00-89-027H
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
- Bulletin:
- 00-06-01-012E
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
- Bulletin:
- 13-00-89-004F
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
- Bulletin:
- 13-00-89-004B
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a revision for 13-00-89-004a to include updated information.
- Bulletin:
- 05-08-48-001C
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a revision for 05-08-48-001b to add 2010-2014 model years and update labor operation.
- Bulletin:
- 09-00-89-008A
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a revision for 09-00-89-008 to add model years, update the labor operation information and transaction submissions procedure and general content updates.
- Bulletin:
- 02-08-98-002D
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a revision for 02-08-98-002c to add the 2010-2013 model years and revise the approved refinish materials booklet information.
- Bulletin:
- 08-06-01-006D
- Component:
- 060000 engine and engine cooling
- Summary:
- This informational bulletin provides information for engine squealing type noise on start-up or vibration condition.
- Bulletin:
- 11-00-89-005E
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides a revision for 11-00-89-005d to add additional mandatory minimum tables and additional information concerning policy decision making.
- Bulletin:
- 02-07-30-052I
- Component:
- 100000 power train
- Summary:
- This informational bulletin provides information for automatic transmission oil cooler flow test essential tool j-45096 transflow.
- Bulletin:
- PI1394
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
- Bulletin:
- 10-08-45-001E
- Component:
- 110000 electrical system
- Summary:
- This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
- Bulletin:
- 10-00-89-006D
- Component:
- 350000 equipment
- Summary:
- This information bulletin provides the dealers on how to submit a product information report.
- Bulletin:
- 00-00-89-027H
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
- Bulletin:
- 00-06-01-012E
- Component:
- 060000 engine (pws)
- Summary:
- This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
- Bulletin:
- PIT5399A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
- Bulletin:
- 10-00-89-006E
- Component:
- 350000 equipment
- Summary:
- This information bulletin provides the dealers on how to submit a product information report.
- Bulletin:
- 10-08-110-001B
- Component:
- 350000 equipment
- Summary:
- This informational bulletin provides information on how to use floor mats.
- Bulletin:
- PIP4495F
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
- Bulletin:
- PIT5099C
- Component:
- 353600 equipment:air conditioner
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
- Bulletin:
- PIP5163D
- Component:
- 060000 engine (pws)
- Summary:
- This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
- Bulletin:
- PIT5099D
- Component:
- 353600 equipment:air conditioner
- Summary:
- This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
- Bulletin:
- PIP5601
- Component:
- 350000 equipment
- Summary:
- This preliminary information communicates
Home | Privacy