2003 JAYCO LEGACY Recalls (5)

Campaign:
03V383000 on 10/21/2003
Component:
Equipment:recreational vehicle
Manufactured:
07/05/2001 - 10/14/2003
Affected:
6,442
Defect:
On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. this may cause the oven to activate without pressing any key pads.
Consequence:
An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
Correction:
Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or jayco at 1-574-825-0608.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V364000 on 07/22/2004
Component:
Wheels
Manufactured:
05/29/2001 - 12/06/2002
Affected:
742
Defect:
On certain travel trailers, due to various factors, including excessive paint coating on the brake hub, the aluminum wheels could exhibit lessened clamping pressure between the aluminum wheel and the axle hub assembly.
Consequence:
This could lead to wheel separation, which could result in a crash.
Correction:
Dealers will inspect all wheels, lugs, studs and mating surfaces, and remove paint from the mating surfaces of the wheel and hub. the recall began on october 18, 2004. owners should contact jayco at 1-219-825-5861.
Notes:
Jayco recall no. 9901054.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
09V288000 on 07/22/2009
Component:
Equipment
Manufactured:
08/14/2001 - 04/27/2004
Affected:
273
Defect:
Jayco is recalling 273 model year 2002-2004 legacy fifth wheel motorhomes equipped with norcold model 1200lrim refrigerators, manufactured from march 1, 2001 to december 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. if a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. at such high temperatures, the cooling unit could rupture.
Consequence:
If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.
Correction:
Jayco will notify owners and the vehicle's refrigerator will be repaired free of charge. the safety recall is expected to begin during august 2009. owners may contact jayco at 1-800-283-8267 or norcold's recall center at 1-800-767-9101.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V649000 on 12/26/2010
Component:
Equipment:recreational vehicle
Manufactured:
05/30/2002 - 12/07/2010
Affected:
387
Defect:
Jayco is recalling certain fifth wheel trailers equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Consequence:
The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Correction:
Jayco is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the recall began on january 31, 2011. owners may contact norcold at 1-800-767-9101.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
17V746000 on 11/27/2017
Component:
Equipment
Affected:
49,563
Defect:
Jayco, inc. (jayco) is recalling various 2002-2016 recreational vehicles equipped with kidde plastic-handle or push button 'pindicator' fire extinguishers. a list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/rmisc-17v746-9524.pdf. these extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. for a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/rmisc-17e062-5427.pdf
Consequence:
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Correction:
Jayco will notify owners, instructing them to contact kidde for a replacement fire extinguisher, free of charge. the recall began on january 15, 2018. owners may contact jayco customer service at 1-800-283-8267, or kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "product safety recall" for more information.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

Home | Privacy