2003 FORD F-150 Recalls (11)

Campaign:
03V349000 on 09/29/2003
Component:
Steering:gear box:shaft pitman
Manufactured:
04/23/2003 - 04/24/2003
Affected:
300
Defect:
On certain pickup trucks, the pitman arm to steering gear retaining nut was not fully tightened to the required specification.
Consequence:
If the pitman arm to gearbox attachment nut loosens, a noise and a loose feel in the steering could occur. if the condition progressed and service was not sought, the nut could back off completely and the pitman arm could separate from the gear causing a loss of steering. if the warning is not heeded and steering is lost, a crash may result.
Correction:
Dealers will tighten the pitman arm retaining nut to specifications. owner notification began on october 1, 2003. owners should contact ford at 1-866-436-7332.
Notes:
Ford recall no. 03s07.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E052000 on 06/11/2006
Component:
Exterior lighting:headlights
Affected:
14,616
Defect:
Certain eagle eyes headlamps, p/nos. fr208-b101r, fr208-b101l, fr208-b001r, and fr208-b001l, sold for use as replacement equipment for the passenger vehicles listed above. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabry lee will notify owners and offer full credit for any noncompliant headlamp. the recall is expected to begin on june 14, 2006. owners may contact sabry lee account executive at 1-866-467-2279.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E056000 on 06/22/2006
Component:
Fuel system, gasoline
Affected:
58,640
Defect:
Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence:
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Correction:
Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
Notes:
This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E067000 on 07/31/2006
Component:
Exterior lighting:headlights
Affected:
19,413
Defect:
Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Maxzone will notify owners and offer reimbursement for any noncompliant headlights. the recall began on july 28, 2006. owners may contact maxzone at 909-822-3288.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V078000 on 03/05/2007
Component:
Vehicle speed control
Manufactured:
07/28/2002 - 10/29/2003
Affected:
155,584
Defect:
On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
Consequence:
Overheating could result in smoke, burn, or an underhood fire.
Correction:
Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on march 12, 2007. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017, 05v388, and 06v286)
Notes:
Ford recall no. 05s28. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
11/04/2002 - 05/17/2004
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V385000 on 07/31/2011
Component:
Fuel system, gasoline:storage:tank assembly:mounting
Manufactured:
06/19/1995 - 08/03/2004
Affected:
1,100,000
Defect:
Ford is recalling certain 1997 through 2003 model year ford f-150, 2004 model year ford f-150 heritage, 1997 through 1999 model year f-250 less than 8,500 lbs. gross vehicle weight rating (gvwr), and 2002 and 2003 lincoln blackwood vehicles manufactured from june 20, 1995, through august 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.
Consequence:
As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. either scenario may result in a fuel leak presenting a fire hazard.
Correction:
Ford will notify owners and instruct them to take their vehicles to a ford or lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. early in this campaign, if replacement straps are not available, dealers may install a cable support under the strap as an interim repair or a steel reinforcement over the existing strap as a permanent repair. any repairs will be performed free of charge. the safety recall began on september 16, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. ford's recall campaign number is 11s21
Notes:
Ford's recall campaign number is 11s21.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2003 FORD F-150 TSBs (90)

Bulletin:
15271
Component:
091110 fuel system, other:storage:tank assembly:filling/charging
Summary:
Dedicated cng regulator bowl kit available. *jg
Bulletin:
16172
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Some vehicles with 4-wheel disc brakes may exhibit a moan from the rear brakes on light brake applications. *tt
Bulletin:
020503
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Guidance for cng tank inspection for vehicles produced after december 2, 1996. *tt update. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
03B04
Component:
061000 engine and engine cooling:engine
Summary:
Customer satisfaction program - cold start calibration product enhancement. *tt
Bulletin:
03610
Component:
017500 steering:linkages:tie rod assembly
Summary:
Tie rod end inspection procedure. canada vehicles only. *tt *jb
Bulletin:
0342
Component:
090000 fuel system, other
Summary:
Possible fuel leak may occur at the fuel fill valve, on some dedicated cng vehicles. *tt *jb
Bulletin:
0343
Component:
060000 engine and engine cooling
Summary:
Crank no start when the cht (cylinder head temperature) at ambient temperature. *tt *jb
Bulletin:
031703
Component:
015100 steering:hydraulic power assist:pump
Summary:
Whine noise from the power steering pump most noticeable while turning at slow speeds. *tt *jb
Bulletin:
16669
Component:
116000 electrical system:ignition
Summary:
Revised spark plug for service. *tt *jb
Bulletin:
16602
Component:
173100 latches/locks/linkages:tailgate:latch
Summary:
Locking tailgate locks itself. *tt
Bulletin:
16605
Component:
010000 steering
Summary:
Reduced power steering assist and/or power steering leaks when driven in temperatures equal to or less than -25 degrees celcius. *tt
Bulletin:
030402
Component:
090000 fuel system, other
Summary:
On some dedicated cng vehicles, a possible fuel leak may occur at the fuel fill valve. revised service parts. *tt
Bulletin:
16899
Component:
061000 engine and engine cooling:engine
Summary:
Rolling idle after shifting to park or neutral, from drive or reverse, when the engine temperature is 100 - 140 degrees f. *tt
Bulletin:
16914
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
5.4l b-fuel engine may exhibit a no start condition when programming passive anti-theft system (pats) keys. *tt this oasis updates oasis 16914 dated 06/01/2003. *tt
Bulletin:
16928
Component:
110000 electrical system
Summary:
Various intermittent electrical concerns including but not limited to some accessories remaining powered up with the key out of the ignition, multiple system warning lights with short to power or low battery voltage diagnostic trouble codes
Bulletin:
16776
Component:
126200 exterior lighting:turn signal:switch
Summary:
Servicing multifunction switch wiring interference. *tt
Bulletin:
16818
Component:
180000 vehicle speed control
Summary:
Throttle control splash shield installation requirements. *tt
Bulletin:
16835
Component:
173100 latches/locks/linkages:tailgate:latch
Summary:
Tailgate locking by itself when slammed shut or when the vehicle is being driven over rough roads. *tt
Bulletin:
03103
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles without the coolant lock-off may exhibit a no start condition. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
0399
Component:
010000 steering
Summary:
Tie rod end inspection procedure. *tt
Bulletin:
03164
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles, equipped with the 4.6l 2v engine, with an engine build date prior to 8/29/03 may exhibit an engine tick noise that is present at all temperatures during idle. 2004 models included. *tt
Bulletin:
17009
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illumination with no hard fault. *tt
Bulletin:
17063
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) on with diagnostic trouble codes (dtc) p0171, or p0174. f150 lighting and f150 harley davidson supercrew. *tt
Bulletin:
17064
Component:
106000 power train:axle assembly
Summary:
Whine / howl from rear axle. *tt
Bulletin:
17086
Component:
010000 steering
Summary:
Noise from the front end of the vehicle which appears to be coming from the steering idler arm. *tt
Bulletin:
17087
Component:
106000 power train:axle assembly
Summary:
Whine/howl from rear axle 40 to 60 mph. *tt
Bulletin:
031513
Component:
017500 steering:linkages:tie rod assembly
Summary:
Tie rod end inspection procedure. *tt
Bulletin:
03B08
Component:
013200 steering:gear box:shaft pitman
Summary:
The pitman arm retaining nub may not be tightened to specifications. this could result in customer complaints of a noise or vibration. ford is providing a no-charge customer satisfaction program , #03b08, to tighten the pitman arm nut to
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16969
Component:
120000 exterior lighting
Summary:
Damaged rear license plate lamps due to rocks and/or gravel hitting the lamp assemblies. *tt
Bulletin:
03183
Component:
180000 vehicle speed control
Summary:
Dedicated compressed natural gas (cng) rough idle or no start when cold vehicles equipped with dedicated 4.6l or 5.4l cng engine only. *tt
Bulletin:
17104
Component:
061000 engine and engine cooling:engine
Summary:
Ticking/tapping noise with the engine warmed up and the transmission in gear at idle. 2003 e150 included. *tt
Bulletin:
03206
Component:
061000 engine and engine cooling:engine
Summary:
Some dedicated cng vehicles may exhibit various driveability conditions due to a loss of injector performance, resulting from fuel quality. loss of power at heavy load, diagnostic trouble codes (dtcs) for lean fuel, rough idle, hard start,
Bulletin:
17257
Component:
353000 equipment:electrical
Summary:
Unsatisfactory remote keyless entry range performance. *tt
Bulletin:
17259
Component:
061000 engine and engine cooling:engine
Summary:
Rough idle and/or misfire with diagnostic trouble code p0316 after an overnight soak in extreme cold and high humidity conditions. *tt
Bulletin:
17306
Component:
353600 equipment:air conditioner
Summary:
Air conditioner condensate leak on passenger floor. *tt
Bulletin:
17486
Component:
106000 power train:axle assembly
Summary:
Rear axle pinion seal leak. *tt
Bulletin:
0416
Component:
105000 power train:driveline
Summary:
Driveline clunking/grunting noise or shudder sensation during light to moderate accelreation and/or braking. *tt
Bulletin:
0422
Component:
162000 structure:body
Summary:
Windnoise and/or a water leak from the sliding back glass area. *tt
Bulletin:
17655
Component:
063000 engine and engine cooling:exhaust system
Summary:
Evidence of oil in the air intake system. *tt
Bulletin:
17656
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Cd or cd6 radio overheating. *tt
Bulletin:
16462
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with kenwood radio, will not have the radio faceplate when delivered from the plant. *tt
Bulletin:
16477
Component:
330000 interior lighting
Summary:
Glove box or ash-cup lamps no longer included. *tt
Bulletin:
03235
Component:
162000 structure:body
Summary:
Bed extender component replacement service tip. *tt
Bulletin:
99263
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Correct lug nut torque specifications - increase wheel nut and stud size - service tip. *tt
Bulletin:
17316
Component:
090000 fuel system, other
Summary:
Fuel signal to instrument cluster service tip. *tt
Bulletin:
17320
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Broken exhaust manifold studs. *tt
Bulletin:
17346
Component:
017300 steering:linkages:arm:idler and attachment
Summary:
Steering idler arm noise. *tt
Bulletin:
17702
Component:
106000 power train:axle assembly
Summary:
Axle whine 40-60 mph. *tt
Bulletin:
17731
Component:
015000 steering:hydraulic power assist system
Summary:
Whine from power steering. *tt
Bulletin:
03256
Component:
061000 engine and engine cooling:engine
Summary:
Engine-romeo built 4.6l 2v-tick noise from engine-engines built before 9/17/2003. *mj
Bulletin:
17372
Component:
106000 power train:axle assembly
Summary:
Heritage f-150 4x2 with 8.8 inch rear axle - whine/howl noise from rear axle. *mj
Bulletin:
02221
Component:
061000 engine and engine cooling:engine
Summary:
Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
Bulletin:
02227
Component:
061000 engine and engine cooling:engine
Summary:
Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
Bulletin:
16400
Component:
106000 power train:axle assembly
Summary:
Rear axle seal leak - contact request. *mj
Bulletin:
16416
Component:
061000 engine and engine cooling:engine
Summary:
No/hard start in cold ambients / new two-piece block heater cord released. *mj
Bulletin:
0457
Component:
130000 visibility
Summary:
Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position. *tt
Bulletin:
0483
Component:
110000 electrical system
Summary:
Splicing new wire(s) into existing electrical harness. service procedure. *tt
Bulletin:
17777
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Rear leaf spring noise. *tt
Bulletin:
17823
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Power steering leak - service tip. *tt
Bulletin:
02177
Component:
061000 engine and engine cooling:engine
Summary:
Cooling system-motorcraft premium gold engine coolant-serivce tips. *mj
Bulletin:
16185
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Equipped with 100i dual media radio - speed adjust volume function not supported. *mj owner guide update. *tt
Bulletin:
17905
Component:
106000 power train:axle assembly
Summary:
Multiple vehicles using fehp rear axle fluid. fluid usage change. *tt
Bulletin:
18217
Component:
090000 fuel system, other
Summary:
Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
Bulletin:
18250
Component:
100000 power train
Summary:
Intermittent clunk on 3-2 downshift during coastdown/tip-in. oasis. to include 2005 f-150, e-series and expedition. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
16299
Component:
980000 unknown or other
Summary:
The interior lock rod cap color changed to ebony regardless of interior trim panel color. *tt
Bulletin:
16308
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Various 2003 vehicles equipped with premium cd-6 radios - cd-6 shuffle feature between discs not available. *tt
Bulletin:
16318
Component:
162300 structure:body:door
Summary:
Running change - door trim panel white puddle lamp discontinued. *tt
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
04251
Component:
162000 structure:body
Summary:
Aluminum corrosion - service tip. *tt
Bulletin:
04266
Component:
105000 power train:driveline
Summary:
A driveline clunk or bump when starting from a stop. *tt
Bulletin:
18466
Component:
106000 power train:axle assembly
Summary:
Axle whine howl. this includes 1997-05 ford vehicles. *eh
Bulletin:
05417
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
Bulletin:
0554
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Use of stainless steel exhaust studs in service for 5.4l 2v engine. *tt
Bulletin:
050618
Component:
022000 suspension:rear
Summary:
Rear axle noise repair. *sc
Bulletin:
05618
Component:
106000 power train:axle assembly
Summary:
Rear axle noise repair. *tt
Bulletin:
051713
Component:
060000 engine and engine cooling
Summary:
Coolant degas bottle overflow. *tt
Bulletin:
05173
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on with diagnostic trouble code p1131 and/or p1151 - 4.2l engine. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
06310
Component:
117000 digital instrument panel
Summary:
Water-in-fuel (wif) lamp on. *tt
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
20228
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj
Bulletin:
TSB-14-0147
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln: safety recall issued due to one or both fuel tank straps fracturing due to being in high corrosion areas for an extended period and dislodging fuel tank. model 1997-99 f250, 1997-03 f150, 2004 f150 heritage, 2002-2003 blackw
Bulletin:
TSB-14-0164
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln: safety recall regarding high corrosion areas for operating, for an extended time, vehicles where both or one strap of fuel tank can fracture, after contacting ground. model 1997-99 f250 ld, 1997-03 f150, 2004 f150 heritage,

Home | Privacy