2003 FORD EXPEDITION Recalls (6)

Campaign:
03V094000 on 03/17/2003
Component:
Structure
Manufactured:
07/31/2000 - 03/02/2003
Affected:
3,674
Defect:
Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. these units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Consequence:
This overheating condition can cause the running board to melt or cause a fire.
Correction:
Dealers will replace the wiring harness on these running boards. owner notification began march 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E023000 on 03/13/2006
Component:
Exterior lighting:headlights
Affected:
292,000
Defect:
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Correction:
Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
Notes:
This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E025000 on 03/20/2006
Component:
Exterior lighting:headlights
Affected:
1,450
Defect:
Certain poli-auto combination headlamp assemblies, p/nos. 11-728, 11-728d, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708p, 11-735, 11-725, 11-726, 11-716 (p&c), 11-721-1, 11-733, 11-729, 11-730, and 11-732, sold as replacement lamps for use on certain passenger vehicles. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Poli-auto will notify owners and offer to repurchase the headlamps at its original purchase price. the recall is expected to begin during april 2006. owners may contact poli-auto at 305-477-1356.
Notes:
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E064000 on 07/16/2006
Component:
Exterior lighting
Affected:
4,029
Defect:
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:
This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2003 FORD EXPEDITION TSBs (148)

Bulletin:
16092
Component:
015100 steering:hydraulic power assist:pump
Summary:
Some vehicles may exhibit power steering noise / vibration from the area of the power steering pump accompanied by bluid leakage from the power steering reservoir cap. *tt
Bulletin:
16177
Component:
980000 unknown or other
Summary:
Diagnostics for diagnostic trouble code c1440 omitted from workshop manual. *tt
Bulletin:
16023
Component:
190000 tires
Summary:
Some vehicles may exhibit a feathering of the tread edges on new tires as received from the factory. *tt
Bulletin:
16036
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
Some vehicles built before may 20, 2002 may exhibit a click noise when the brake pedal is depressed or released. *tt
Bulletin:
16047
Component:
110000 electrical system
Summary:
Interactive vehicle dynbamics (ivd) diagnostic trouble code c1998. *tt
Bulletin:
16070
Component:
106000 power train:axle assembly
Summary:
Some 4x4s may exhibit a front axle groan or hum, and / or a slight vibration when operated in 2 high mode. *tt
Bulletin:
16075
Component:
110000 electrical system
Summary:
Diagnostic procedures for diagnostic trouble code c1991 (module calibration failure) omitted from the worshop manual. *tt
Bulletin:
16076
Component:
110000 electrical system
Summary:
Diagnostics provided for diagnostic trouble codes c2777 / c2778 (sensor cluster can bus failure / sensor cluster power supply failure). *tt
Bulletin:
16079
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a no-start condition with no fuel pressure present and / or fuel pump circuit diagnostic trouble codes p0231 or p0232. *tt
Bulletin:
16083
Component:
190000 tires
Summary:
Some vehicles may exhibit a check tire pressure or a tire losing pressure message in the message center. *tt
Bulletin:
16085
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Service tips on on checking fuses 32, 33 and 34. *tt
Bulletin:
16088
Component:
106000 power train:axle assembly
Summary:
Some 4x2 vehicles may exhibit a rear axle whine at 50 and 62 mph in coast or drive. *tt
Bulletin:
15951
Component:
980000 unknown or other
Summary:
This service reminder is in reference to lift (jacking) points. *tt
Bulletin:
15809
Component:
350000 equipment
Summary:
Information on using nsg diagnostic card version 20.1 and service card version 10.2 when servicing. *tt
Bulletin:
15938
Component:
350000 equipment
Summary:
Information used when replacing the drivers seat module. *tt
Bulletin:
15940
Component:
354300 equipment:mechanical:carrier/rack
Summary:
Subject regarding roof rack wind noise. *tt
Bulletin:
0364
Component:
106000 power train:axle assembly
Summary:
Front axle groan or hum, and/or a slight vibration when operated in 2 high mode. *tt *jb
Bulletin:
16675
Component:
135000 visibility:rearview mirrors/devices
Summary:
Reverse tilt-down mirrors not returning to the pre-reverse position after shifting to reverse and then to drive. *tt *jb
Bulletin:
16683
Component:
061000 engine and engine cooling:engine
Summary:
False failure of the vapor management valve (vmv). *tt *jb
Bulletin:
16692
Component:
110000 electrical system
Summary:
Gauges sweeping, power locks cycling, high temp/low oil pressure lights illuminating, alarm system activating, radio/cd/dvd turning on/off and various other functions. *tt *jb
Bulletin:
16705
Component:
021230 suspension:front:springs:air suspension system
Summary:
Air suspension diagnosis. *tt *jb
Bulletin:
16726
Component:
100000 power train
Summary:
Fluid leaks from the rear halfshaft seal. *tt *jb
Bulletin:
16729
Component:
100000 power train
Summary:
Transmission fluid leak between the radiator transmission oil cooler and the transmission oil cooler fitting (not the cooler line into the fitting), which may result in a residue of transmission fluid on the radiator tank around the transmi
Bulletin:
16606
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering return hose leak. *tt
Bulletin:
16642
Component:
030000 service brakes, hydraulic
Summary:
Brake shudder/vibration. *tt
Bulletin:
16885
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Rapid rattle, buzz, flutter, or gurgle noise from the muffler. this condition is intermittent and occurs most predominantly when vehicle is warm, or under a light load, between 1500-2000 rpm. *tt
Bulletin:
16900
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Climate controlled (cc) seat may exhibit premature shutdown of the cc seat when it is in head mode on the second or subsequent heat cycles. *tt
Bulletin:
16923
Component:
106000 power train:axle assembly
Summary:
Chatter, shudder, binding sensation, or vibration during low speed turns. concerns may seem to originate from front axle, or steering gear. *tt
Bulletin:
16926
Component:
030000 service brakes, hydraulic
Summary:
Stability assist (advancetrac/ivd) systems may not be recalibrated properly using wds. *tt
Bulletin:
16762
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Ride height anomalies on vehicles equipped with air suspension, i.e. front suspension lowering while rear rises, due to leaking solenoids.
Bulletin:
16806
Component:
100000 power train
Summary:
Fluid leaks from the rear halfshaft seal. 2002-2003 explorer/mountaineer/aviator added. *tt
Bulletin:
03127
Component:
020000 suspension
Summary:
Steering wheel nibble at highway speeds. vehicles produced before 6/12/2003 only. *tt
Bulletin:
16853
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
Front caliper seepage in extreme temperatures. engineering is investigating via the quicker service fix (qsf). *tt
Bulletin:
16854
Component:
133000 visibility:power window devices and controls
Summary:
Front door glass making a popping noise as it enters the header seal at the top of the door opening at highway speeds. in the case of the navigator driver's door, the glass may bounce off the header and reverse to a mid-position. *tt
Bulletin:
0391
Component:
106200 power train:axle assembly:axle shaft
Summary:
Procedure to separate inboard cv joint halfshafts from differential. *tt
Bulletin:
0397
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Climate controlled seat diagnosis - service tips. *tt *mj
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03164
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles, equipped with the 4.6l 2v engine, with an engine build date prior to 8/29/03 may exhibit an engine tick noise that is present at all temperatures during idle. 2004 models included. *tt
Bulletin:
17084
Component:
162000 structure:body
Summary:
Noise from door cladding at highway speeds. *tt
Bulletin:
03132
Component:
021230 suspension:front:springs:air suspension system
Summary:
This article addresses the proper procedure to clear diagnostic trouble codes c1990 or c1991 from the vehicle dynamics module/4-wheel air suspension module. *tt
Bulletin:
03134
Component:
222000 seats:mid/rear assembly
Summary:
Abnormal surface rust on the metal components of the 20% and/or 40% second-row seats. *tt
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16946
Component:
110000 electrical system
Summary:
Diagnostic trouble code c1790 in air suspension (4was/vdm) module. *tt
Bulletin:
16975
Component:
036000 service brakes, hydraulic:antilock
Summary:
Stability control (advancetrac/ivd) diagnostic trouble code c1998. *tt
Bulletin:
17001
Component:
010000 steering
Summary:
Advancetrac malfunction indicator lamp on with diagnostic trouble code c1277 (steering wheel angle 1 an 2 circuit failure) or c1278 (steering wheel angle 1 and 2 signal faulted) in the ivd module. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03193
Component:
121000 exterior lighting:headlights
Summary:
Excessive moisture in the headlamp assembly. *tt
Bulletin:
03198
Component:
106000 power train:axle assembly
Summary:
Chatter, shudder, a binding sensation, or vibration during low speed turns on vehicles equipped with the 9.75 inch or 8.8 inch limited slip rear axle. *tt
Bulletin:
17133
Component:
110000 electrical system
Summary:
Advancetrac lighting on with diagnostic trouble code c1277 (steering wheel angle 1 and 2 circuit failure) or c1278 (steering wheel angle 1 and 2 signal faulted) in the ivd module. *tt
Bulletin:
17135
Component:
063000 engine and engine cooling:exhaust system
Summary:
Moaning noise from the exhaust system, or vibration in the rear passenger floor pan, when driving 45-55 mph and 1200-1400 rpm all without flex coupling in the exhaust. *tt
Bulletin:
17168
Component:
110000 electrical system
Summary:
Vehicles equipped with advancetrac stability assist/interactive vehicle dynamics - ivd) may exhibit a diagnostic trouble code c1998. *tt
Bulletin:
17247
Component:
030000 service brakes, hydraulic
Summary:
Accumulation of brake dust on the wheels under regulator driving conditions. *tt
Bulletin:
17289
Component:
353000 equipment:electrical
Summary:
Parking aid sensor readings do not display on wds. *tt
Bulletin:
17304
Component:
220000 seats
Summary:
Seat cushion foam damage/shredding. *tt
Bulletin:
17459
Component:
330000 interior lighting
Summary:
Courtesy rail lamps do not operate correctly or cause a battery draw. *tt
Bulletin:
17488
Component:
106000 power train:axle assembly
Summary:
Axle whine between 58-62 mph. *tt
Bulletin:
17521
Component:
106000 power train:axle assembly
Summary:
Click/pop/creak from rear axle. *tt
Bulletin:
0411
Component:
034420 service brakes, hydraulic:foundation components:drum:shoes/linings
Summary:
Brake dust - revised brake linings - vehicles built prior to 12/18/2003. *tt
Bulletin:
17598
Component:
106000 power train:axle assembly
Summary:
Rear axle halfshaft seal leak. *tt
Bulletin:
17621
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitoring system (tpms) low tire or tire very low message and/or the tpms light on. *tt
Bulletin:
17632
Component:
106000 power train:axle assembly
Summary:
Axle whine at highway speeds (40-60 mph). *tt
Bulletin:
17639
Component:
020000 suspension
Summary:
Ride height issues. *tt
Bulletin:
17557
Component:
151200 seat belts:front:webbing
Summary:
Safety belt difficult to pull out due to web stop button used for vehicle assembly. *mj
Bulletin:
17574
Component:
162000 structure:body
Summary:
Interior carpet curling near the emergency brake. *tt
Bulletin:
99263
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Correct lug nut torque specifications - increase wheel nut and stud size - service tip. *tt
Bulletin:
17316
Component:
090000 fuel system, other
Summary:
Fuel signal to instrument cluster service tip. *tt
Bulletin:
17320
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Broken exhaust manifold studs. *tt
Bulletin:
17356
Component:
353600 equipment:air conditioner
Summary:
Loss of climate control cooling during extended driving. *tt
Bulletin:
0471
Component:
110000 electrical system
Summary:
Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
Bulletin:
17693
Component:
110000 electrical system
Summary:
Diagnostic trouble code (dtc) p0320 (ignition engine speed input circuit malfunction). *tt
Bulletin:
17708
Component:
342000 communications:back up alarm
Summary:
Reverse sensing system warning chime volume low. *tt
Bulletin:
17732
Component:
110000 electrical system
Summary:
Check air suspension message with diagnostic trouble code (dtc) c1724, c1873, and/or c1889. *tt
Bulletin:
17738
Component:
110000 electrical system
Summary:
Charging system warning indicator intermittently on with possible diagnostic trouble code (dtc) p0620. *tt
Bulletin:
17755
Component:
106000 power train:axle assembly
Summary:
Axle whine at highway speeds (40-60 mph). *tt
Bulletin:
17881
Component:
020000 suspension
Summary:
Ride height issues on automobiles with air suspension. *tt
Bulletin:
03256
Component:
061000 engine and engine cooling:engine
Summary:
Engine-romeo built 4.6l 2v-tick noise from engine-engines built before 9/17/2003. *mj
Bulletin:
17411
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure monitoring system (tpms) module configuration - service tip. *mj
Bulletin:
17418
Component:
110000 electrical system
Summary:
Diagnostic trouble code (dtc) p0320 with driveability symptoms. *mj
Bulletin:
02227
Component:
061000 engine and engine cooling:engine
Summary:
Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
Bulletin:
16400
Component:
106000 power train:axle assembly
Summary:
Rear axle seal leak - contact request. *mj
Bulletin:
16403
Component:
061000 engine and engine cooling:engine
Summary:
Engine-light tick or rattle type noise from engine after cold start. *mj
Bulletin:
16430
Component:
106000 power train:axle assembly
Summary:
Limited-slip rear axle chatter noise - contact request. *tt
Bulletin:
0454
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Air suspension compressor noise. *tt
Bulletin:
0457
Component:
130000 visibility
Summary:
Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position. *tt
Bulletin:
0459
Component:
353600 equipment:air conditioner
Summary:
Intermittent loss of cooling or airflow from a/c system at highway drives. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02177
Component:
061000 engine and engine cooling:engine
Summary:
Cooling system-motorcraft premium gold engine coolant-serivce tips. *mj
Bulletin:
02179
Component:
162000 structure:body
Summary:
Body-body joint reinforcement material-repair procedure. *mj
Bulletin:
16222
Component:
162300 structure:body:door
Summary:
Door squeak/rattle. *mj
Bulletin:
16236
Component:
011000 steering:wheel and handle bar
Summary:
Steering wheel discoloration under investigation - contact request. *mj
Bulletin:
16242
Component:
353000 equipment:electrical
Summary:
Calibration of navigation radio on pre-delivery vehicles. *mj
Bulletin:
04105
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Axle seal leaks. leaks from rear halfshaft axle seal. service tips. *tt
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
04149
Component:
110000 electrical system
Summary:
Diagnostic trouble code (dtc) p0320 with possible driveability concerns and/or charging system warning indicator on with possible dtc p0620. *tt
Bulletin:
17905
Component:
106000 power train:axle assembly
Summary:
Multiple vehicles using fehp rear axle fluid. fluid usage change. *tt
Bulletin:
18213
Component:
106000 power train:axle assembly
Summary:
Grinding noise from front axle wheel hubs on acceleration in 2wd - service tip. various models including 2005 expedition/navigator. *tt
Bulletin:
18217
Component:
090000 fuel system, other
Summary:
Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
Bulletin:
18228
Component:
190000 tires
Summary:
Tire feathering at low mileage. oasis. various models including 2005 expedition. *tt
Bulletin:
041511
Component:
061000 engine and engine cooling:engine
Summary:
Misfire at idle with diagnostic trouble codes p0300-p0308, p0316. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
18127
Component:
110000 electrical system
Summary:
Various electric concerns. interior illumination, quarter windows, moonroof function, accessory delay, courtesy lamps, electro chromatic mirror, climate controlled seats, electronic park brake release, flasher relay, audio system, electron
Bulletin:
18172
Component:
110000 electrical system
Summary:
Reverse sensing system defaulting off, setting diagnostic trouble codes, or losing communication with diagnostic scan tool. *tt
Bulletin:
0526
Component:
136000 visibility:windshield wiper/washer
Summary:
Wiper blade chatter. *tt
Bulletin:
05310
Component:
150000 seat belts
Summary:
Safety belt web stop button service. *eh
Bulletin:
18423
Component:
106000 power train:axle assembly
Summary:
Axle whine howl service with individual parts instead of an axle assembly. *eh
Bulletin:
18400
Component:
021230 suspension:front:springs:air suspension system
Summary:
Four corner load leveling air suspension may exhibit leveling concerns, such as one front corner dropping. individual air springs available for service. *tt
Bulletin:
18439
Component:
100000 power train
Summary:
Tiny crack or cracks around the transfer case drain plug. *eh
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
16297
Component:
134000 visibility:sun roof assembly
Summary:
Moonroof water leak, inoperative - contact request in metro detroit area. *tt
Bulletin:
16308
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Various 2003 vehicles equipped with premium cd-6 radios - cd-6 shuffle feature between discs not available. *tt
Bulletin:
16309
Component:
353600 equipment:air conditioner
Summary:
High side pressure fluctuations on vehicles equipped with a fixed scroll a/c compressor. *tt
Bulletin:
16336
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Diagnostics for diagnostic trouble code c1991 in the abs (antilock brake system) module - omitted from workshop manual - procedure provided. *tt
Bulletin:
16366
Component:
353600 equipment:air conditioner
Summary:
A/c evaporator core icing. *tt
Bulletin:
04174
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
Bulletin:
0514
Component:
030000 service brakes, hydraulic
Summary:
Brake shudder (rotor thickness variation) due to the new low dust front brake lining used in production, or new linings that were installed per tsb 04-05-02. *tt
Bulletin:
042116
Component:
135000 visibility:rearview mirrors/devices
Summary:
Reverse tilt mirror system diagnostics and repair. *eh
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
06216
Component:
106000 power train:axle assembly
Summary:
Limited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
04251
Component:
162000 structure:body
Summary:
Aluminum corrosion - service tip. *tt
Bulletin:
040704
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Climate controlled seat diagnosis - service tips. *tt
Bulletin:
18466
Component:
106000 power train:axle assembly
Summary:
Axle whine howl. this includes 1997-05 ford vehicles. *eh
Bulletin:
05417
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
Bulletin:
18478
Component:
106000 power train:axle assembly
Summary:
Axle seal leaks. *eh
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
18506
Component:
200000 wheels
Summary:
Aluminum alloy wheels pitting and or peeling cleaning procedures. *eh
Bulletin:
0554
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Use of stainless steel exhaust studs in service for 5.4l 2v engine. *tt
Bulletin:
050618
Component:
022000 suspension:rear
Summary:
Rear axle noise repair. *sc
Bulletin:
05198
Component:
137000 visibility:rear window wiper/washer
Summary:
Rear window wiper inoperative. *tt
Bulletin:
031207
Component:
010000 steering
Summary:
Steering wheel at 65 mph (105 km/h) or higher. *tt
Bulletin:
05618
Component:
106000 power train:axle assembly
Summary:
Rear axle noise repair. *tt
Bulletin:
05419
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt
Bulletin:
051610
Component:
161000 structure:frame and members
Summary:
Clunk/grind/thump noise - frame repair procedure. *tt
Bulletin:
0594
Component:
221600 seats:front assembly:power adjust
Summary:
Drivers front power seat will not move forward or rearward. *tt
Bulletin:
18815
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
A tiny crack, or cracks, around the transfer case drain plug hole. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
052624
Component:
190000 tires
Summary:
Vibration diagnosis - tire/wheel runout. *tt
Bulletin:
052308
Component:
050000 parking brake
Summary:
Parking aid system inoperative. *ak
Bulletin:
0637
Component:
190000 tires
Summary:
Low tire indicator on - tpms system sensor wake up. *tt
Bulletin:
052621
Component:
033000 service brakes, hydraulic:power assist
Summary:
Unintended brake assist. *tt
Bulletin:
062013
Component:
050000 parking brake
Summary:
Parking aid system inoperative - dtc c1983. *kb
Bulletin:
061510
Component:
021230 suspension:front:springs:air suspension system
Summary:
Air suspension performance - height sensor linkage arm disengaging. *kb
Bulletin:
062513
Component:
980000 unknown or other
Summary:
Parking aid system is inoperative - dtc c1983. *kb
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
TSB-08-19-3
Component:
106200 power train:axle assembly:axle shaft
Summary:
Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal. oil separation appears to be and is often misdiagnosed, as an axle lube leak. *pe

Home | Privacy