2003 DODGE DAKOTA Recalls (11)

Campaign:
02V322000 on 12/09/2002
Component:
Exterior lighting:headlights:switch
Manufactured:
10/30/2002 - 11/07/2002
Affected:
3,640
Defect:
On certain pickup trucks, the central timer module (ctm) has an improperly sized circuit board trace that could potentially cause the right headlamp low beam to become inoperative.
Consequence:
If the lights fail, a visibility problem could occur, increasing the risk of a vehicle crash.
Correction:
dealers will replace the ctm. owner notification began december 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
Notes:
Daimlerchrysler recall no. b32.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V389000 on 10/14/2003
Component:
Electrical system:wiring
Manufactured:
06/30/2000 - 07/30/2003
Affected:
50,082
Defect:
On certain pickup trucks equipped with manual transmissions, the headlamp and dash wiring harness may be chafed by the actuation of the clutch pedal. this could result in abnormal operation of the wipers, turn signals, horn or lighting systems.
Consequence:
This could affect driver visibility, could prevent a driver from sounding a warning by using the horn, and, when the turn signals are inoperative, the driver cannot use them to signal intent to turn, increasing the risk of a crash.
Correction:
Dealers will reroute the wire harness and repair the harness if necessary. owner notification began november 3, 2003. owners should contact daimlerchrysler at 1-800-992-1997.
Notes:
Daimlerchrysler recall no. c35.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V216000 on 05/09/2004
Component:
Visibility:windshield wiper/washer
Manufactured:
04/23/2002 - 09/14/2003
Affected:
320,188
Defect:
On certain pickup trucks and sport utility vehicles, the windshield wiper module motor may be susceptible to water intrusion that could cause internal corrosion and result in partial or complete loss of front windshield wiping capability.
Consequence:
Driver visibility could be reduced, which could result in a crash.
Correction:
Dealers will replace the front windshield wiper module. owner notification began on july 12, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
Notes:
Daimlerchrysler recall no. d22.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V596000 on 12/20/2004
Component:
Suspension:front:control arm:upper ball joint
Manufactured:
01/06/1999 - 12/30/2002
Affected:
592,707
Defect:
On certain sport utility vehicles and pickup trucks equipped with four-wheel drive (4x4), if moisture leaks into the front suspension upper ball joint, evacuation of the lubricant and corrosion of the joint may cause the joint to wear over an extended period of time. this could cause a clunking noise in the front suspension, which may not always be heard by the vehicle occupants.
Consequence:
Excessive wear in the upper ball joint may allow it to separate, which could result in loss of control of the vehicle.
Correction:
Dealers will replace the front suspension upper ball joints. this safety improvement campaign began on december 21, 2004. owners can contact daimlerchrysler at 1-800-853-1403.
Notes:
This action is deemed a safety improvement campaign and is not being conducted under the safety act.
Campaign:
06E011000 on 01/31/2006
Component:
Fuel system, gasoline:delivery:fuel pump
Affected:
7,291
Defect:
Certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.
Consequence:
In the presence of an ignition source, a fuel leak could result in a fire.
Correction:
Airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.
Notes:
This recall only pertains to aftermarket airtex electric fuel pumps and has no relation to any original equipment installed on jeep grand cherokee, cherokee, wrangler, or dodge dakota vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E024000 on 03/16/2006
Component:
Engine and engine cooling
Affected:
44,386
Defect:
Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. p5007069 and p5007070). all kits were manufactured from april 20, 1999, through september 23, 2004. these assemblies were manufactured as replacement equipment for certain dodge pickup trucks and suvs. a small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position.
Consequence:
A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.
Correction:
K&n will provide owners with a free repair kit along with repair instructions. the recall began on april 20, 2006.
Notes:
This recall only pertains to replacement k&n fuel performance kits and has no relation to any original equipment installed on dodge vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E065000 on 07/16/2006
Component:
Exterior lighting
Affected:
3,593
Defect:
Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
Notes:
This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E064000 on 10/19/2008
Component:
Suspension:front:hub
Affected:
2,805
Defect:
Skf is recalling 2,805 hub units, part no. br930361, sold as a service part for 1997-2004 dodge dakota vehicles and 1999-2003 dodge durango vehicles equipped with 2-wheel drive & rear axle abs. due to a specification error, the rotor pilot for the hub unit may be too long. this results in the wheel to not be seated fully against the hub flange face during mounting.
Consequence:
Improper seating of the wheel can result in excessive vibration, brake rotor noise, difficulty removing the wheel after installation and operation of the vehicle, and possibly wheel-end separation during vehicle operation. should wheel-end separation occur, the driver could loose control of the vehicle, possibly resulting in a crash.
Correction:
Skf will notify owners and replace the defective hub units free of charge. the recall began on november 5, 2008. owners may contact skf vsm north america customer service at 1-800-644-8999.
Notes:
Skf's recall no. skf pro 08-029us/ca.this recall only pertains to aftermarket skf hub units and has no relation to any original equipment installed on dodge dakota or durango vehicles manufactured by chrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2003 DODGE DAKOTA TSBs (30)

Bulletin:
2200102
Component:
980000 unknown or other
Summary:
Chrome wheel care. *slc
Bulletin:
2100202
Component:
103000 power train:automatic transmission
Summary:
Subject regarding revision in diagnostic procedures and labor operation times for re transmissions. *tt
Bulletin:
02024
Component:
103000 power train:automatic transmission
Summary:
Harsh shifts due to a sticking pressure sensor transducer. *tt
Bulletin:
02026
Component:
103000 power train:automatic transmission
Summary:
The transmission may overheat due to a restriction in the torque converter drain back valve. *tt
Bulletin:
1800103
Component:
100000 power train
Summary:
Customers may complain the vehicle will not shift out of 2nd gear while climbing a grade. update to transmission calibrations. *tt
Bulletin:
01
Component:
103700 power train:automatic transmission:torque converter
Summary:
Customer satisfaction notification - 3/8" torque converter drain back valve. *tt
Bulletin:
02026A
Component:
103000 power train:automatic transmission
Summary:
The transmission may overheat due to a restriction in the torque converter drain back valve and may cause damage to the transmission. *tt
Bulletin:
1800503
Component:
180000 vehicle speed control
Summary:
Transmission shift/speed control improvements. *jb
Bulletin:
1800503A
Component:
180000 vehicle speed control
Summary:
Transmission shift/speed control improvements/possible malfunction indicator lamp illumination. *tt
Bulletin:
1800103A
Component:
100000 power train
Summary:
Customers may complain the vehicle will not shift out of 2nd gear while climbing a grade. update to transmission calibrations.
Bulletin:
0802303
Component:
110000 electrical system
Summary:
Intermittent locking/unlocking of doors without activating the power door lock switch. *tt
Bulletin:
1800503B
Component:
180000 vehicle speed control
Summary:
Transmission shift/speed control improvements/possible malfunction indicator lamp illumination. *tt
Bulletin:
1800503C
Component:
100000 power train
Summary:
Transmission shift / speed control improvements / possible malfunction indicator lamp illumination. *tt
Bulletin:
0703
Component:
162000 structure:body
Summary:
Disconnecting the park brake release handle when servicing the steering column opening cover. *tt
Bulletin:
0500603
Component:
030000 service brakes, hydraulic
Summary:
Rear brake moan. *tt
Bulletin:
1803703
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp illumination, erroneous diagnostic trouble code (dtc) p0116, p2172, p2173. *tt
Bulletin:
1801504
Component:
180000 vehicle speed control
Summary:
Idle fluctuation while turning. *tt
Bulletin:
2301004
Component:
162000 structure:body
Summary:
Passenger compartment floor water leak. *tt this bulletin supersedes bulletin 23-010-04 dated 04-29-04. *tt
Bulletin:
10023
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Powertrain diagnostic information. service information tuneups. *tt
Bulletin:
10023
Component:
012000 steering:column
Summary:
Steering column service. information. service information tuneups. *tt
Bulletin:
0201004
Component:
020000 suspension
Summary:
Upper ball joint extended warranty. *tt
Bulletin:
0801505
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Powertrain control module initialization. *sc
Bulletin:
2401305
Component:
353600 equipment:air conditioner
Summary:
Air conditioning (a/c) cooling coil odor. *tt
Bulletin:
2101505
Component:
100000 power train
Summary:
45rfe/545rfe trans - delayed engagement due to cooler return filter replacement. *sc
Bulletin:
0803006
Component:
103000 power train:automatic transmission
Summary:
Powertrain control module initialization. *kb
Bulletin:
9002519
Component:
355200 equipment:other:owners/service/other manual
Summary:
82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
Bulletin:
9002872
Component:
116100 electrical system:ignition:switch
Summary:
56045489a$ - neutral safety switch - trans assy 06036369aa screw and washer is now available as a service part , 2 required to attach neutral start switch
Bulletin:
9002872
Component:
100000 power train
Summary:
56045489a$ - neutral safety switch - trans assy 06036369aa screw and washer is now available as a service part , 2 required to attach neutral start switch
Bulletin:
9002828
Component:
160000 structure
Summary:
Part description: insulator in lever assembly - valve body - trans issue description: the manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. if the insulator requires replacement lease order 68253
Bulletin:
9002849
Component:
160000 structure
Summary:
Part description: insulator on lever assy manual valve - valve body - rwd transmission issue description: the manual valve insulator, attaching rivet and instruction sheet are now available as a kit. if the insulator requires replacement

Home | Privacy