2003 CHEVROLET SILVERADO Recalls (13)

Campaign:
03V018000 on 02/04/2003
Component:
Visibility:windshield
Manufactured:
10/26/2002 - 10/27/2003
Affected:
110
Defect:
Certain pickup trucks fail to conform to federal motor vehicle safety standard no. 212, "windshield mounting." some of these vehicles lack a continuous urethane bonding bead between the body surface and the windshield.
Consequence:
in vehicles with this condition, the windshield may not be retained in accordance with the safety standard during a vehicle crash.
Correction:
Dealers will remove, reseal, and reinstall the windshield. owner notification began on january 28, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Notes:
Gm recall no. 03001. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V045000 on 02/05/2004
Component:
Service brakes, hydraulic
Manufactured:
04/30/2003 - 07/30/2003
Affected:
68,875
Defect:
Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Consequence:
Consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
Correction:
Dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
Notes:
Gm recall no. 04004.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V129000 on 03/21/2004
Component:
Structure:body:tailgate:hinge and attachments
Manufactured:
03/31/2002 - 07/30/2003
Affected:
3,662,211
Defect:
On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Consequence:
Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
Correction:
Dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Notes:
Gm recall no. 04007.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04E022000 on 03/29/2004
Component:
Equipment
Affected:
8,000
Defect:
Aftermarket pickup truck over-the-rail bedliners manufactured for installation on 1999-2004 chevrolet silverado and gmc sierra pickup trucks. the toggle wing assembly used to attach the bedliner to the truck bed is not engaging fully in the stake pocket of the pickup truck.
Consequence:
The bedliner can become detached from the pickup while it is motion, possibly endangering following motorists or pedestrians.
Correction:
Durakon will issue a press release in attempt to notify customers that could have purchased the defective bedliner. if you purchased either a durakon allstar of patriot overrail bedliner since august 1, 2003, for 1999 to 2004 chevrolet silverado or gmc sierra trucks, or purchased one of these pickup trucks with either brand bedliner already installed, you should return to an authorized durakon dealer so that the bedliner can be inspected and, if necessary, repaired with a newly designed toggle wing fastening system, or if required, replaced with a new bedliner free of charge. please call the durakon hotline at 1-800-933-4200 to find the nearest authorized durakon dealer.
Notes:
This recall only pertains to aftermarket overrail bedliners and has no relation to any original equipment installed on chevrolet silverado and gmc sierra pickup trucks by general motors.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V225000 on 05/11/2004
Component:
Seat belts:front:anchorage
Manufactured:
05/31/2002 - 06/29/2003
Affected:
736
Defect:
Certain extended and regular cab pickup trucks and cargo vans converted to compressed natural gas (cng) fail to conform to the requirements of federal motor vehicle safety standard no. 225, 'child restraint anchorage systems.' these vehicles have one seating position, the center rear seat, equipped with child restraint lower anchorages.
Consequence:
The standard requires child seat lower anchorages in two seating positions for vehicles with three rear seating positions. the standard cab and cargo van vehicles, which only have front seating positions, have an air bag off switch to disable the front passenger air bag and do not have child restraint lower anchorages in the passenger seat. the standard requires passenger seat child seat lower anchorages in vehicles with an air bag off switch. however, the standard does not require vehicles with only front seating positions to have lower anchorage provisions if the vehicle is not equipped with an air bag off switch.
Correction:
To bring the standard cab and cargo van vehicles into compliance, dealers will inject epoxy into the air bag off switch to prevent air bag activation, relocate the switch behind the instrument panel and then install a cover over the resulting opening. the sun visor label and owner's manual will also be changed. the correction for the extended cab vehicle will consist of changing the front passenger seat to a seat that has child restraint lower anchorages. the recall began on september 9, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 04038.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V161000 on 04/21/2005
Component:
Parking brake
Manufactured:
03/31/2003 - 07/30/2003
Affected:
90,242
Defect:
On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Consequence:
If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
Correction:
Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 05042.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V163000 on 04/21/2005
Component:
Seat belts:rear
Manufactured:
04/02/2002 - 07/30/2003
Affected:
1,359,824
Defect:
On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
Consequence:
A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
Correction:
Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Notes:
Gm recall no. 05037.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E023000 on 03/13/2006
Component:
Exterior lighting:headlights
Affected:
292,000
Defect:
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Correction:
Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
Notes:
This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E060000 on 06/28/2006
Component:
Exterior lighting
Affected:
87,745
Defect:
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Correction:
Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
Notes:
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E064000 on 07/16/2006
Component:
Exterior lighting
Affected:
4,029
Defect:
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:
This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E106000 on 12/18/2007
Component:
Wheels:cap/cover/hub
Affected:
130,000
Defect:
Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. the inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence:
Wheel separation can result in a vehicle crash.
Correction:
Federal-mogul will notify customers and will replace the hub assembly free of charge. the recall began on february 7, 2008. owners can contact federal-mogul toll-free at 877-489-6659.
Notes:
This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

2003 CHEVROLET SILVERADO TSBs (598)

Bulletin:
990308002A
Component:
021000 suspension:front
Summary:
Front suspension coil spring noise. *tt
Bulletin:
010310010C
Component:
020000 suspension
Summary:
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. bulletin 01-03-10-010b not received. *tt
Bulletin:
020730004
Component:
103000 power train:automatic transmission
Summary:
New product information, grade brake feature of allison 1000 series transmission. *slc this bulletin replaces 02-07-30-004. *tt
Bulletin:
02035B
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Customer satisfaction program regarding engine oil contamination for certain models including the 2003 gmc medium duty. *tt
Bulletin:
02035
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Customer satisfaction program regarding engine oil contamination. *tt
Bulletin:
02035A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Customer satisfaction program regarding engine oil contamination. *tt
Bulletin:
020601027
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on higher than expected oil consumption. nlm
Bulletin:
010866005B
Component:
980000 unknown or other
Summary:
Subject regarding availability of pickup box reinforcement kits for toolbox / rear window barrier / ladder rack applications. *tt
Bulletin:
010866014A
Component:
162000 structure:body
Summary:
Pickup box sheet metal fracture / damage with aftermarket accessories installed. *tt
Bulletin:
010864014A
Component:
162300 structure:body:door
Summary:
Some customers may comment that the manual lock lever comes loose from the door trim panel. *tt
Bulletin:
020525005
Component:
980000 unknown or other
Summary:
Subject regarding diagnostic trouble code c0201 set and stored in history. *tt
Bulletin:
020421006
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some customers may comment that the 4wd/awd indicator lights on the selector switch do not work or the 4wd/awd system may be inoperative. *tt
Bulletin:
020417001A
Component:
103000 power train:automatic transmission
Summary:
Concerns with launch shudder / vibration on acceleration. *tt
Bulletin:
020730030
Component:
103000 power train:automatic transmission
Summary:
Some customers may comment that the transmission slips, a shudder, chuggle, or vibration is felt when the transmission shifts from first to second gear. *tt
Bulletin:
020730024A
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
Bulletin:
150702
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Some customes have commented that when the mirror is manually folded inward or outward, the mirror does not return to its original position. *tt
Bulletin:
170702
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Subject regarding power folding outside rearview mirror operation prior to customer delivery and / or test drive. *tt
Bulletin:
220702
Component:
110000 electrical system
Summary:
Subject regarding new enhancement for technical assistance calls related to any electrical issues. *tt
Bulletin:
02066
Component:
111000 electrical system:battery
Summary:
Potential battery drain condition. *tt
Bulletin:
02059
Component:
116000 electrical system:ignition
Summary:
Spark plug replacement. *tt
Bulletin:
020522004A
Component:
030000 service brakes, hydraulic
Summary:
Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
Bulletin:
020601023A
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak at oil cooler to engine block mating surface. *tt
Bulletin:
020522004
Component:
030000 service brakes, hydraulic
Summary:
Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
Bulletin:
020849007
Component:
162000 structure:body
Summary:
Center console lid hard to open or close. *tt
Bulletin:
020941002
Component:
140000 air bags
Summary:
Air bag lamp on, passenger air bag indicator always reads off, diagnostic trouble code (dtc) b0092 set. *tt
Bulletin:
020940005
Component:
152000 seat belts:rear
Summary:
Availability of rear seat shoulder belt comfort guides. *tt
Bulletin:
020842005
Component:
120000 exterior lighting
Summary:
Snowplow roof beacon (lamp) inoperative. *tt
Bulletin:
020522004B
Component:
030000 service brakes, hydraulic
Summary:
Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
Bulletin:
020526002
Component:
050000 parking brake
Summary:
Scraping noise from rear of vehicle. *tt
Bulletin:
020421006A
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Inoperative 4wd/awd lamps, inoperative 4wd/awd system. *tt
Bulletin:
020730032A
Component:
103000 power train:automatic transmission
Summary:
Allison transmission control module fastlearn procedure update required after transmission repairs. *tt
Bulletin:
990089015B
Component:
980000 unknown or other
Summary:
Light service support vehicle (lssv). *tt
Bulletin:
010102
Component:
061000 engine and engine cooling:engine
Summary:
Vehicle will not start condition. *tt
Bulletin:
010102
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Front driver and/or passenger door lock bezel is loose and falling out. *tt
Bulletin:
020523004
Component:
030000 service brakes, hydraulic
Summary:
Some vehicles may exhibit a reduced brake power message on the driver's information center (dic). *tt
Bulletin:
020604059
Component:
061000 engine and engine cooling:engine
Summary:
Engine runs rough, service engine soon light on, diagnostic trouble codes p0300 or p0335 set. *tt
Bulletin:
020605005A
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Exhaust / muffler heat shield rattle, popping noise under vehicle. *tt
Bulletin:
02059
Component:
116000 electrical system:ignition
Summary:
Voluntary emission recall involving spark plug replacement. *tt
Bulletin:
02066
Component:
111000 electrical system:battery
Summary:
Customer satisfaction program regarding battery drain condition. *tt
Bulletin:
020138007
Component:
353600 equipment:air conditioner
Summary:
Poor air conditioner performance - air conditioner will not blow cold enough. *tt
Bulletin:
020601038
Component:
060000 engine and engine cooling
Summary:
Engine knock or lifter noise. *tt
Bulletin:
020844020
Component:
353000 equipment:electrical
Summary:
No audio out of speakers at times. *tt
Bulletin:
030805001
Component:
222000 seats:mid/rear assembly
Summary:
Second row seat center armrest panel warping. *tt
Bulletin:
030603001
Component:
061000 engine and engine cooling:engine
Summary:
Engine starter cranks after key is released on cold start. *tt
Bulletin:
030604010
Component:
080000 fuel system, diesel
Summary:
6.6l lb7 duramax diesel fuel pressure regulator replacement. 2500/3500 and c4500/c5500 series models. *tt
Bulletin:
030850003
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Seat heater and/or memory power seat inoperative. *tt
Bulletin:
000235003B
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
030310001
Component:
020000 suspension
Summary:
Tire slowly goes flat and/or excessive wheel vibration caused by bead splits (replace wheels with new heavy duty rim version) *tt *ar updated 4/11/08. *nj
Bulletin:
030852001
Component:
353000 equipment:electrical
Summary:
Remote keyless entry (rke) system inoperative. *tt
Bulletin:
030852001B
Component:
353000 equipment:electrical
Summary:
Remote keyless entry (rke) system inoperative. *tt
Bulletin:
030421001
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4-wheel drive light, 4-wheel drive inoperative, diagnostic trouble codes c0327, p0836, p0500. *tt
Bulletin:
020844020A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
No audio out of speakers at times. *tt
Bulletin:
03011
Component:
110000 electrical system
Summary:
Remote keyless entry system inoperative. *jb
Bulletin:
020844020B
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
No audio out of speakers at times. *tt
Bulletin:
030852001C
Component:
353000 equipment:electrical
Summary:
Remote keyless entry (rke) system inoperative. *tt
Bulletin:
030601011
Component:
060000 engine and engine cooling
Summary:
Accessory drive belt whine. *tt
Bulletin:
032503
Component:
110000 electrical system
Summary:
Anti-lock brake system (abs) telltale light being constantly illuminated with a diagnostic trouble code c0550 being stored. *tt *jb
Bulletin:
032703
Component:
110000 electrical system
Summary:
Passenger door module recall for remote keyless entry, front passenger power window, lock, mirror and heated seat functions. *tt *jb
Bulletin:
030703
Component:
110000 electrical system
Summary:
Multiple diagnostic trouble codes, including any or all of p0708, p0847, p0872, p0875, p1711 or p1713, partial or no prindel display or no movement. *tt *jb
Bulletin:
030139007
Component:
353600 equipment:air conditioner
Summary:
Air conditioning (a/c) inoperative / intermittent, air conditioner blows warm air. *tt
Bulletin:
000523005B
Component:
030000 service brakes, hydraulic
Summary:
Right rear inner brake pad wear. various modles including the 2004 silverado and sierra. *tt
Bulletin:
030604030
Component:
061000 engine and engine cooling:engine
Summary:
Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
030849006
Component:
110000 electrical system
Summary:
Instrument panel cluster high beam indicator too bright. *tt
Bulletin:
030730020
Component:
103000 power train:automatic transmission
Summary:
Transmission has a harsh 1-2 shift, slipping 1-2 shift followed by a harsh engagement. *tt
Bulletin:
120902
Component:
220000 seats
Summary:
Front passenger side manual seat does not fully lock into position. *tt
Bulletin:
02059
Component:
116000 electrical system:ignition
Summary:
Wrong spark plugs. *tt
Bulletin:
000842010A
Component:
120000 exterior lighting
Summary:
Daytime running lamp (drl) bulb replacement. *tt
Bulletin:
020138007A
Component:
353600 equipment:air conditioner
Summary:
Poor air conditioner performance - air conditioner will not blow cold enough. *tt *ar
Bulletin:
010846002C
Component:
350000 equipment
Summary:
Programming of replacement onstar vehicle communication and interface modules (vcim). *tt
Bulletin:
020601010A
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Serpentine belt identification and diagnosis for medium duty trucks. various models including the chevrolet and gmc c5500 md 2003. *tt
Bulletin:
030139008
Component:
353600 equipment:air conditioner
Summary:
Changes in air conditioning compessor on/off instrument panel display symbol from 2003 to 2004 model year and synchronizing the driver and passenger set temperatures. *tt
Bulletin:
030308002
Component:
020000 suspension
Summary:
Rattle/squeak from front of vehicle. *tt *ar
Bulletin:
030418003
Component:
106000 power train:axle assembly
Summary:
Revised wheel drive shaft inner joint and seal replacement. *tt
Bulletin:
030421001C
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4-wheel drive switch indicator lights flashing, 4-wheel drive inoperative, diagnostic trouble codes c0327, p0836, p0500. *tt
Bulletin:
030602005A
Component:
060000 engine and engine cooling
Summary:
Engine coolant loss with no visible leaks. *tt updated *eh
Bulletin:
030604031
Component:
061000 engine and engine cooling:engine
Summary:
Revised diagnostic trouble code p1125. *tt
Bulletin:
030604032
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light on with no drivability concerns, diagnostic trouble code p0120, p0220, p1516, or p1518 set. *tt
Bulletin:
030604033
Component:
061000 engine and engine cooling:engine
Summary:
Revised diagnostic trouble code p0336. *tt update. to include 2004 isuzu nqr commercial models. *tt
Bulletin:
030730020A
Component:
103000 power train:automatic transmission
Summary:
Transmission has a harsh 1-2 shift, slipping 1-2 shift followed by a harsh engagement. *tt
Bulletin:
030849009
Component:
061000 engine and engine cooling:engine
Summary:
Revised engine oil pressure gage inaccurate or inoperative diagnostic information. *tt
Bulletin:
030864018
Component:
120000 exterior lighting
Summary:
Outside rearview mirror courtesy lamp falls out, bulb burns out. *tt
Bulletin:
020605003C
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust moan/vibration. *tt update. *tt
Bulletin:
030844011
Component:
162000 structure:body
Summary:
Tweeter speaker rattle in front side door(s), tweeter speaker falls out of position. *tt
Bulletin:
030864022
Component:
162300 structure:body:door
Summary:
Information on removing the front door trim panel during switch removal to avoid breakage. *tt
Bulletin:
020846010E
Component:
980000 unknown or other
Summary:
Programming onstar module for canadian french voice recognition. *tt update. *tt updated *eh
Bulletin:
052103
Component:
100000 power train
Summary:
Essential tools for servicing the allison transmission. these tools include a four-wheel drive spanner nut wrench, rear bearing puller legs, digital depth micrometer and a rear bearing installer. these tools are required to replace a cr
Bulletin:
071503
Component:
162000 structure:body
Summary:
Revised requirements for installing the running board. *tt
Bulletin:
071703
Component:
330000 interior lighting
Summary:
Service four-wheel drive light and the four-wheel drive is inoperative. *tt
Bulletin:
080403
Component:
100000 power train
Summary:
This vme message applies to the valve body for the allison series 1000 transmission revised for the 2004 model year to add modulated main pressure control. this revision will provide additional transmission oil cooler flow and reduce pump
Bulletin:
01312
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
Fuel leak concern from the fuel rail pressure sensor. *tt
Bulletin:
01267A
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light on, the 4wd is inoperative and no codes besides u1000 codes. service vme. *tt
Bulletin:
01139B
Component:
353600 equipment:air conditioner
Summary:
Air conditioning compressor belt or tensioner jumps or flutters causing a rattle noise. service vme. *tt
Bulletin:
00411B
Component:
061000 engine and engine cooling:engine
Summary:
Lack of power with tac module code of p1518 reduced power mode. *tt *mj
Bulletin:
01342
Component:
061000 engine and engine cooling:engine
Summary:
4.3l lu3 engine hot soak hesitation low power. *tt
Bulletin:
00347A
Component:
022144 suspension:rear:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:
Rear spring slap or clunk noise. *tt
Bulletin:
01322A
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Electronic brake control module part restriction. service vme. *tt *mj
Bulletin:
01348
Component:
353600 equipment:air conditioner
Summary:
Passenger compartment air filter. *tt
Bulletin:
01361
Component:
110000 electrical system
Summary:
6.6l lb7 engine with diagnostic trouble code (dtc) p0201 and p0208. 2500 hd and 3500 models. *tt
Bulletin:
00843C
Component:
350000 equipment
Summary:
Replacement (rke) transmitter is inoperative - service vme. *tt
Bulletin:
00634A
Component:
061000 engine and engine cooling:engine
Summary:
Gen iii engine noise after hot soak restart. *tt
Bulletin:
01368A
Component:
060000 engine and engine cooling
Summary:
Coolant loss (into the crankcase). *tt
Bulletin:
01129A
Component:
100000 power train
Summary:
Allison lct1000 serviceability. *tt
Bulletin:
00938B
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Allison lct1000 repeat transmission control module (tcm) failures with possible multiple diagnostic trouble codes (dtcs). *tt
Bulletin:
00557B
Component:
103000 power train:automatic transmission
Summary:
The allison lct1000 transmissions may experience a leak from oil pump area. *tt
Bulletin:
01390
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm radio must be tuned to channel 1 through 66 during activation attempt. 2004 chevrolet canyon, gmc denali, gmc colorado also included. *tt
Bulletin:
01267B
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light on no codes besides u1000 codes. service vme. *tt
Bulletin:
01410
Component:
100000 power train
Summary:
Poor performance from a stop in 2wd, auto or 4wd hi. 2003, 2003 cadillac ext also included. *tt
Bulletin:
01415
Component:
061000 engine and engine cooling:engine
Summary:
Cam sensor connector does not fit sensor when engine is replaced. *tt
Bulletin:
00690B
Component:
110000 electrical system
Summary:
Diagnostic trouble code c0327 with or without additional diagnostic trouble codes (dtcs) setting. *tt
Bulletin:
00827C
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light on with tac module codes p1516 and possible codes p1514, p1515, p1518. *tt
Bulletin:
01457
Component:
350000 equipment
Summary:
Front license plate bracket. service vme. *tt
Bulletin:
00559B
Component:
103000 power train:automatic transmission
Summary:
4l80e/4l85e may set a diagnostic trouble code (dtc) p0706 (transmission range switch performance) and exhibit a no start condition. *tt
Bulletin:
030601024A
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise in engine. *tt
Bulletin:
030602007
Component:
062000 engine and engine cooling:cooling system
Summary:
Loss of coolant. *tt
Bulletin:
030603001A
Component:
061000 engine and engine cooling:engine
Summary:
Starter cranks after key is released (normal condition). *tt
Bulletin:
030604045
Component:
061000 engine and engine cooling:engine
Summary:
Revised diagnostic trouble code (dtc) p0093 or dtc p1093 diagnostic tables. *tt
Bulletin:
030604046
Component:
061000 engine and engine cooling:engine
Summary:
Revised engine cranks but does not run diagnostic. *tt
Bulletin:
030604047
Component:
090000 fuel system, other
Summary:
Revised fuel system diagnosis-high pressure side. *tt
Bulletin:
030604048
Component:
090000 fuel system, other
Summary:
Revised fuel system diagnosis cab chassis. *tt
Bulletin:
030525007
Component:
036000 service brakes, hydraulic:antilock
Summary:
Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
Bulletin:
030604049
Component:
070000 fuel system, gasoline
Summary:
Revised fuel system diagnosis pickup. *tt
Bulletin:
030604053
Component:
061000 engine and engine cooling:engine
Summary:
Revised fuel injector balance test with tech 2 (manual transmission). *tt
Bulletin:
030604054
Component:
061000 engine and engine cooling:engine
Summary:
Revised fuel injector balance test with tech 2 (automatic transmission). various models including 2003-2004 chevrolet kodiak and gmc topkick. *tt
Bulletin:
030693001A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt
Bulletin:
030730037
Component:
103000 power train:automatic transmission
Summary:
Transmission oil leak, abnormal knocking noise heard at idle. 2500/3500 series pickup models. *tt
Bulletin:
030730038
Component:
103000 power train:automatic transmission
Summary:
Transmission oil leak, abnormal knocking noise heard at idle. 2500/3500 series pickup models. *tt
Bulletin:
030730044
Component:
103000 power train:automatic transmission
Summary:
Information on allison transmission service repairs - full service of internal components. *tt
Bulletin:
030844018A
Component:
350000 equipment
Summary:
Rear seat audio (rsa) and/or rear hvac inoperative. *tt update. *tt
Bulletin:
030852005
Component:
350000 equipment
Summary:
Diagnostic information for replacement remote keyless entry (rke) transmitter inoperative - unable to synchronize. *tt
Bulletin:
990089015C
Component:
980000 unknown or other
Summary:
Light service support vehicle lssv (formerly commercial utility cargo vehicle - cucv ii and iii) service. *tt
Bulletin:
020421006C
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Inoperative 4wd/awd lamps, inoperative 4wd/awd system. *tt
Bulletin:
030419004
Component:
106000 power train:axle assembly
Summary:
Growl or moan noise coming from front axle. *tt
Bulletin:
030601023
Component:
061000 engine and engine cooling:engine
Summary:
Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt
Bulletin:
030601024
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise in engine. *tt
Bulletin:
030603007
Component:
061000 engine and engine cooling:engine
Summary:
Availability of starter motor solenoid if damaged during service. 2004 chevrolet kodiak c4500/5500 and gmc topkick c4500/5500 included. *tt
Bulletin:
030603008
Component:
061000 engine and engine cooling:engine
Summary:
Avoiding oil level sensor harness damage during lower oil pan installation. *tt
Bulletin:
030604041
Component:
061000 engine and engine cooling:engine
Summary:
Poor engine performance - misfire, rough idle, service engine soon/check engine light illuminated, diagnostic trouble code (dtc) p0300 set. *tt
Bulletin:
030730031D
Component:
103000 power train:automatic transmission
Summary:
Transmission leaks, slips, vehicle will not move. *tt
Bulletin:
030850014
Component:
110000 electrical system
Summary:
Intermittent no start, service stability message, anti-lock brake system (abs) light illuminated, multiple diagnostic trouble codes (dtcs), dic shows unknown driver, various electrical related conditions. includes escalade esv and ext mod
Bulletin:
030864028
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Availability of replacement parts for wide load outside rearview mirrors. *tt
Bulletin:
030864029
Component:
162300 structure:body:door
Summary:
Information on removing front door trim panel to avoid breakage. *tt
Bulletin:
00908C
Component:
102000 power train:manual transmission
Summary:
6.6l and manual transmission growl noise while engaging or disengaging clutch. these are c/k models. *tt
Bulletin:
01444
Component:
980000 unknown or other
Summary:
Xm dealer assistance line information. *tt
Bulletin:
01470
Component:
180000 vehicle speed control
Summary:
Erratic idle, idle surge, rough run, or near stall. *tt
Bulletin:
000235003C
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
030419001A
Component:
106000 power train:axle assembly
Summary:
Use of synthetic front axle lubricant for 4wd vehicles sold in cold weather climates. *tt this bulletin replaced previous bulletin dated 10/01/2003. *tt
Bulletin:
030604060
Component:
061000 engine and engine cooling:engine
Summary:
Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt
Bulletin:
020601022C
Component:
061000 engine and engine cooling:engine
Summary:
Information on engine ticking. including 2004 chevrolet kodiak c45/c5500 series and 2004 gmc topkick c4500/c5500 series. *tt update. *tt
Bulletin:
030730054
Component:
100000 power train
Summary:
Transmission fluid leaks out of vent when truck is started after a cold soak. *tt
Bulletin:
030730053
Component:
103000 power train:automatic transmission
Summary:
Allison automatic transmission valve body hardware changes. *tt
Bulletin:
030234001A
Component:
017500 steering:linkages:tie rod assembly
Summary:
Inner tie rod released for service. *tt
Bulletin:
030604059
Component:
061000 engine and engine cooling:engine
Summary:
Revised fuel leaks inside of engine diagnostic. 2004 chevrolet kodiak and gmc topkick also included. *tt
Bulletin:
030862003A
Component:
162000 structure:body
Summary:
Cosmetic rust on front bumper. *tt
Bulletin:
100803
Component:
061000 engine and engine cooling:engine
Summary:
The engine diagnostic fuel leaks inside of the engine. gm voicemail log. this includes 2000 - 2004 chevroand gmc c4500 and 5500 trucks. *tt
Bulletin:
100803
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Excessive duramax turbocharger whine noise or possibly a performance or a fuel economy complaint. gm voicemail log. this includes 2003-2004 4500 and 5500 trucks. *tt
Bulletin:
100903
Component:
061000 engine and engine cooling:engine
Summary:
Duramax diesel fuel in oil diagnostics revisited. gm voicemail log. this includes c4500 and 5500 trucks. *tt
Bulletin:
011603
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Concerns with the service four-wheel drive light or the four-wheel drive is inoperative with a c0327 code stored in the tccm. gm voicemail express. *tt
Bulletin:
010730038B
Component:
103000 power train:automatic transmission
Summary:
The service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt
Bulletin:
030421001D
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4-wheel drive switch indicator lights flashing, 4-wheel drive inoperative, diagnostic trouble codes c0327, p0836, p0500. *tt
Bulletin:
030730037B
Component:
103000 power train:automatic transmission
Summary:
Transmission oil leak, abnormal knocking noise heard at idle. *tt
Bulletin:
030309002
Component:
020000 suspension
Summary:
Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
Bulletin:
030604065
Component:
061000 engine and engine cooling:engine
Summary:
Lack of passenger compartment heat and/or raised/rough idle after start and/or p0128 diagnostic trouble code (dtc) stored with no service engine soon light illuminated. *tt
Bulletin:
03063
Component:
062000 engine and engine cooling:cooling system
Summary:
03063 - obd system software upgrade - on-board diagnostic (obd) system software upgrade - diagnostic trouble code (dtc) p0128 engine coolant temperature below thermostat regulating temperature. *tt
Bulletin:
01555
Component:
020000 suspension
Summary:
D height specification missing from si. sit bulletin 1410632. *tt
Bulletin:
01562
Component:
353000 equipment:electrical
Summary:
Hvac digital display does not illuminate or function. service vme. sit bulletin 1411066. *tt
Bulletin:
01564
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Inside rearview mirror compass inoperative. service vme. sit bulletin 1411219. *tt
Bulletin:
01567
Component:
010000 steering
Summary:
Quadrasteer service update. sit bulletin 1411394. *tt
Bulletin:
01568
Component:
081100 fuel system, diesel:storage:tank assembly
Summary:
Hard to fill fuel tank at high volume diesel pumps. sit bulletin 1411583. *tt
Bulletin:
01592
Component:
110000 electrical system
Summary:
2003-2004 generation 5 onstar steering wheel control function explanation. sit bulletin 1416474. *tt
Bulletin:
00908D
Component:
102000 power train:manual transmission
Summary:
6.6l and manual transmission growl noise while engaging or disengaging clutch. *tt *mj
Bulletin:
01485A
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain tensioner breakpoints for service kit or production fix for vehicle exhibiting rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. sit bulletin 1408407. *tt
Bulletin:
00574A
Component:
110000 electrical system
Summary:
Allison lct1000 no shift, speedometer erratic/inoperative, diagnostic trouble codes (dtcs) p0721, c0237 possible anti-lock brake system (abs) lamp on. si bulletin 1408789. *tt
Bulletin:
01433A
Component:
110000 electrical system
Summary:
6.6l lb7 duramax diesel diagnostic trouble code (dtc)s p0201 - p0208. 2500 hd and 3500 models. sit bulletin 1408805. *tt
Bulletin:
01512
Component:
061200 engine and engine cooling:engine:diesel
Summary:
6.6 liter duramax diesel engine fuel knock noise. various models including the 2004 gmc c4500 and c5500. sit bulletin 1406247. *tt
Bulletin:
00969A
Component:
061000 engine and engine cooling:engine
Summary:
Engine whistle noise. *tt
Bulletin:
01159A
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirrors memory operation. sit bulletin 1404207. *tt
Bulletin:
00822B
Component:
100000 power train
Summary:
No 2nd, no 4th and no reverse. to include 2004 light duty automobiles and trucks equipped with 4l60e or 4l65e automatic transmission. *tt
Bulletin:
00702
Component:
103000 power train:automatic transmission
Summary:
Slip condition in 2nd, 3rd or 4th damaged 2-4 band 3-4 clutch on the 4l60e/4l65e automatic transmission. *tt *mj
Bulletin:
01499
Component:
061000 engine and engine cooling:engine
Summary:
2004 6.6l duramax lb7 engines with extended crank during hot engine restart. diagnostic trouble code (dtc) p0193 may or may not be set. sit bulletin 1402202. *tt
Bulletin:
01501
Component:
033000 service brakes, hydraulic:power assist
Summary:
Supplement brake assist noisy and may run continuously. sit bulletin 1402858. *tt
Bulletin:
00559C
Component:
103000 power train:automatic transmission
Summary:
4l80e, 4l85e automatic transmission diagnostic trouble code (dtc) p0706 and vehicle may not start. *tt
Bulletin:
00537C
Component:
010000 steering
Summary:
Quadrasteer parts restriction. available parts. service vme. sit bulletin 1403216. *tt
Bulletin:
01496
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
6.6l lb7 duramax diesel turbocharger noises or fuel economy complaint. service vme. sit bulletin 1401355. *tt
Bulletin:
01483
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Vehicle has no pcm (power train control module) communication with tech 2. sit bulletin 1400427. *tt
Bulletin:
01484
Component:
061000 engine and engine cooling:engine
Summary:
Gen iii replacement flywheel bolt holes larger than original part. the bolt holes for the crank shaft in the replacement flywheel are larger than the holes in the original part. sit bulletin 1400596. *tt
Bulletin:
01485
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt
Bulletin:
01490
Component:
090000 fuel system, other
Summary:
6.6l lb7 diesel engine recapping tool for fuel system high-pressure side diagnosis. service vme. sit bulletin 1401058. *tt
Bulletin:
00252B
Component:
103700 power train:automatic transmission:torque converter
Summary:
Allison lct1000 knock noise and possible leak from the torque converter area. sit bulletin 1401124. *tt
Bulletin:
01493
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 prndl flash and/or will not move with p0721, p0731, p0732, p0733, p0734, p0743, p0746, p0747, p0776, p0777, p1720, p1721, p1723 and p1724. *tt
Bulletin:
01495
Component:
080000 fuel system, diesel
Summary:
Duramax diesel fuel in oil diagnostics. service vme. lb7 6.6l engine. sit bulletin 1401353. various models including 2003 and 2004 gmc c4500 and 5500 trucks. *tt
Bulletin:
001496A
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary:
This message is in regard to duramax turbocharger noises or possibly a performance or fuel economy complaint. service vme. 6.6 lb7 diesel engine. p0102, p0103, p0236. *tt
Bulletin:
3259C
Component:
103000 power train:automatic transmission
Summary:
4l80e, 4l85e whine noise in first and second gear. *tt
Bulletin:
020730030A
Component:
103000 power train:automatic transmission
Summary:
Some customers may comment that the transmission slips, a shudder, chuggle, or vibration is felt when the transmission shifts from first to second gear. *tt
Bulletin:
030138019
Component:
353600 equipment:air conditioner
Summary:
Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
Bulletin:
030310006
Component:
020000 suspension
Summary:
Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin:
030604062
Component:
061000 engine and engine cooling:engine
Summary:
This bulletin is being issued to revise step 4 of diagnostic trouble code (dtc) p2135. *tt
Bulletin:
030730056
Component:
103000 power train:automatic transmission
Summary:
4l60-e automatic transmission oil pump first and second design identification. *tt
Bulletin:
030605008B
Component:
063000 engine and engine cooling:exhaust system
Summary:
Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt
Bulletin:
030730020C
Component:
103000 power train:automatic transmission
Summary:
Transmission has a harsh 1-2 shift, slipping 1-2 shift followed by a harsh engagement. *tt
Bulletin:
030730307A
Component:
103000 power train:automatic transmission
Summary:
Transmission oil leak, abnormal knocking noise heard at idle. 2500/3500 series pickup models. *tt
Bulletin:
030730057
Component:
103000 power train:automatic transmission
Summary:
Transmission fluid leak from front of transmission - torque converter housing/pump area. 2500/3500 series models. *tt
Bulletin:
030849020
Component:
110000 electrical system
Summary:
Instrument panel cluster (ipc) gauges inoperative. *tt
Bulletin:
030864037
Component:
133000 visibility:power window devices and controls
Summary:
Front power window noisy or inoperative on vehicles located in michigan only. *tt
Bulletin:
030421005
Component:
100000 power train
Summary:
Service 4wd light on, 4wd inoperative, diagnostic trouble codes c0300 and/or c0305 set. *tt
Bulletin:
01766
Component:
138000 visibility:defroster/defogger system
Summary:
Fogging of windows in the defrost mode. also including models: 2003-2004 gmc yukon xl, denali xl, 2003-2004 sierra denali. *mr
Bulletin:
01717
Component:
980000 unknown or other
Summary:
6.6l lb7 engine - fuel rail pressure regulator harness connector servicing. *tt
Bulletin:
01774
Component:
061000 engine and engine cooling:engine
Summary:
6.6l lb7 repeat engine oil leak (left side) #2 main bearing cross bolt. *mr
Bulletin:
01242A
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
6.6l lb7 lly diesel engine drive belt chirping on shut down. sit bulletin 1460352. *tt
Bulletin:
00778A
Component:
160000 structure
Summary:
Business trip and/or personal trip odometer inoperative. sit bulletin 1460572. *tt
Bulletin:
01759
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm rapid activation utilization. *mr
Bulletin:
01747
Component:
070000 fuel system, gasoline
Summary:
Locking gas cap availability. *mr
Bulletin:
01736
Component:
010000 steering
Summary:
Service 4 wheel steer message with diagnostic trouble code (dtc) c0455. sit bulletin 1459978. *tt
Bulletin:
01737
Component:
110000 electrical system
Summary:
Poor ground connection causing diagnostic trouble code (dtc) c0265. sit bulletin 1460187. *tt
Bulletin:
01761
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge diverts to empty after idling on incline. sit bulletin 1459166. *tt
Bulletin:
01698
Component:
131000 visibility:windshield
Summary:
Windshield reveal molding flutering. service vme. sit bulletin 1450940. *tt
Bulletin:
01699
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Anti-lock braking system (abs) light on and the abs pump motor continues to run. sit bulletin 1450952. *tt
Bulletin:
01704
Component:
353600 equipment:air conditioner
Summary:
Programming control heads - hvac ac. *tt
Bulletin:
01712
Component:
021000 suspension:front
Summary:
Left front of vehicle sits low. sit bulletin 1454860. *tt
Bulletin:
01897
Component:
010000 steering
Summary:
Lack of steering assist or shudder during parking lot type maneuvers. *mr
Bulletin:
01935
Component:
353000 equipment:electrical
Summary:
Product information on rear slider. *mr
Bulletin:
01901
Component:
200000 wheels
Summary:
Excessive tire spin setting diagnostic trouble code (dtc) co542. also including 2002, 2003 sierra denali. *mr
Bulletin:
01932
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 dark or discolored transmission fluid with no loss of performance. *mr
Bulletin:
01946
Component:
127000 exterior lighting:hazard flashing warning lights
Summary:
Hazard light flashes when turn signal applied. *mr
Bulletin:
10012003
Component:
062000 engine and engine cooling:cooling system
Summary:
Blueheat coolant heater thermo top c. webasto. *mr
Bulletin:
01850
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Drivers or passengers heated seats turn on by themselves. *mr
Bulletin:
01862
Component:
220000 seats
Summary:
Driver personalization regarding memory seats. *mr
Bulletin:
01864
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Radio cd skips/ejects or clock resets to 12:00. *mr *tt
Bulletin:
01863
Component:
016000 steering:electric power assist system
Summary:
Lack of steering assist when stopped or during parking lot type maneuvers. *mr
Bulletin:
01849
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Vehicles equipped with xm do not have audio, am, fm work correctly. *mr
Bulletin:
01856
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Allison lct1000 will not shift from park due to ice, snow or mud build-up on shift linkage. *mr
Bulletin:
01919
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Replacement radio reads cal error, has no audio or will not program. *tt
Bulletin:
01953
Component:
110000 electrical system
Summary:
Abs and red brake malfunction indicator light on with no diagnostic trouble codes. *mr
Bulletin:
04016
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emission system diagnostic disabled by incorrect fuel level reference. recall bulletin. *tt
Bulletin:
02029
Component:
061000 engine and engine cooling:engine
Summary:
Inaccurate fuel gauge readings and/or engine stall. *mr
Bulletin:
01999
Component:
110000 electrical system
Summary:
Diagnostic trouble code tips- lct1000 transmission. *mr
Bulletin:
02007
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Power folding mirrors will not fold inward.*mr
Bulletin:
01950
Component:
110000 electrical system
Summary:
Abs telltale illuminated, diagnostic trouble code c0550 stored in history.*mr
Bulletin:
02013
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant leak from head cup plugs on gen iii engines. *mr
Bulletin:
01640
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Electronic brake control module part restriction.*mr *mj
Bulletin:
01597
Component:
353600 equipment:air conditioner
Summary:
Blower motor operates on high only.*mr
Bulletin:
01674
Component:
061000 engine and engine cooling:engine
Summary:
Vibration from engine mount bracket. *mr
Bulletin:
01761B
Component:
072000 fuel system, gasoline:delivery
Summary:
Fuel gauge diverts to empty after idling on incline or refueling. *nm
Bulletin:
01634
Component:
010000 steering
Summary:
Intermediate steering shaft service kit. service vme. *tt
Bulletin:
01599
Component:
100000 power train
Summary:
4l60e, 4l65e forward and low reverse waved steel clutch plate appearance change. *tt
Bulletin:
01662
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Xm error on a radio display. *tt
Bulletin:
00764B
Component:
061000 engine and engine cooling:engine
Summary:
6.6l diesel engine rough idle, clatter, stall and/or diagnostic trouble code (dtc) p1223. *tt
Bulletin:
01485B
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt
Bulletin:
01919A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Replacement radio reads cal error, has no audio or will not program. *tt
Bulletin:
00733A
Component:
061000 engine and engine cooling:engine
Summary:
Low oil light on the dic during engine start. *tt
Bulletin:
01634A
Component:
010000 steering
Summary:
Supplement to 00-02-35-003d - clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
01222A
Component:
107000 power train:axle hubs
Summary:
Repeat rear axle hub seal leak. *tt
Bulletin:
00678B
Component:
061000 engine and engine cooling:engine
Summary:
Engine overheats on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin:
00372D
Component:
353000 equipment:electrical
Summary:
Onstar system is attempting and/or completing phone calls which the operator of the vehicle did not initiate. *tt
Bulletin:
00442A
Component:
140000 air bags
Summary:
Dual stage air bag used in single stage application. *tt
Bulletin:
01737A
Component:
110000 electrical system
Summary:
Poor ground connection causing diagnostic trouble code (dtc) c0265. *tt
Bulletin:
02116
Component:
105000 power train:driveline
Summary:
Highway speed vibration on k2500hd 4wd vehicles equipped with a 4l80e automatic transmission. *tt
Bulletin:
02113
Component:
100000 power train
Summary:
Intermittent no forward or reverse with possibly either a flashing prndl display or a range shift inhibited message. *tt
Bulletin:
00844
Component:
136000 visibility:windshield wiper/washer
Summary:
Front windshield wiper arm does not remain upright position as it did on prior models and as a result, customer may inadvertently brake the wiper arm trying to extend the blade. *mj
Bulletin:
00609B
Component:
061000 engine and engine cooling:engine
Summary:
Low power, will not go over 2300 rpms. 6.6l lb7 engine. *tt
Bulletin:
00968A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
6.6l lb7 lly diesel engine with rough, unstable, low idle speed or stall. *tt
Bulletin:
01119A
Component:
061000 engine and engine cooling:engine
Summary:
Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt
Bulletin:
01977
Component:
100000 power train
Summary:
Allison lct1000 prndl flash and/or will not move. *tt
Bulletin:
00700A
Component:
061000 engine and engine cooling:engine
Summary:
4.3l l35 engine wide open throttle diagnostic trouble code (dtc) p0335, p0336, p0339. *tt *mj
Bulletin:
00266
Component:
061000 engine and engine cooling:engine
Summary:
Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt
Bulletin:
01330
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 buzz, moan noise at 1400 rpm with the 8.1 l18 gas engine. *tt
Bulletin:
020601022
Component:
061000 engine and engine cooling:engine
Summary:
Information on engine ticking. *mj
Bulletin:
00573
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Low audio output from speakers. *mj
Bulletin:
00632
Component:
110000 electrical system
Summary:
4.3l l35 engine-diagnostic trouble code p0300 but no misfire can felt. *mj
Bulletin:
01267F
Component:
110000 electrical system
Summary:
Service 4wd light on no codes besides u1000 codes or c0550. *mj
Bulletin:
00895
Component:
110000 electrical system
Summary:
Instrunment panel cluster (ipc) gauges inoperative at times while cranking. *mj
Bulletin:
01637
Component:
110000 electrical system
Summary:
Transfer case inoperative or shifts to 4lo after encoder motor sensor replacement. *mj
Bulletin:
01217B
Component:
110000 electrical system
Summary:
Allison lct1000 diagnostic trouble codes (dtc) p1711, p0872 after completing repairs. *mj
Bulletin:
01060A
Component:
111000 electrical system:battery
Summary:
Roof beacon switch left on causing battery draw. gmc gmt 800. *mj 2005 models added. *tt
Bulletin:
00677
Component:
980000 unknown or other
Summary:
Snow plow prep package information - service vme. *mj
Bulletin:
00786
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Buzz noise and virbation in the accelerator pedal at approx. 10 mph on start up. *mj
Bulletin:
01225
Component:
060000 engine and engine cooling
Summary:
Engine coolant leak at intake gasket. * mj
Bulletin:
02051
Component:
061000 engine and engine cooling:engine
Summary:
Intermittent service engine soon (ses) light comes on and code p0700 along with diagnostic trouble code p0742 stored. *tt
Bulletin:
02052
Component:
160000 structure
Summary:
Noise coming from instrument panel cluster or tachometer. *tt
Bulletin:
02053
Component:
030000 service brakes, hydraulic
Summary:
Information on resurfacing the park brake portion of the rear brake rotor. *tt
Bulletin:
02086
Component:
100000 power train
Summary:
4l60e, 4l65e intermittent neutral from a stop or steady speed. *tt
Bulletin:
02089
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Inaccurate fuel gauge readings and/or engine stall. service vme. *tt
Bulletin:
00856
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 oil pump whine, buzz on cold start. *tt
Bulletin:
00993
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirror glass may crack. *tt
Bulletin:
01936
Component:
162000 structure:body
Summary:
Painted body side moldings dimple (raised surface). service vme. *tt
Bulletin:
01927
Component:
110000 electrical system
Summary:
A no charge condition with diagnostic trouble code (dtc) p0380, p0621. *tt
Bulletin:
990730016A
Component:
100000 power train
Summary:
Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan. *tt
Bulletin:
00428E
Component:
061000 engine and engine cooling:engine
Summary:
Higher than expected oil consumption even after the intake bolts were replaced per 02-06-01-035. *tt
Bulletin:
01188A
Component:
127100 exterior lighting:hazard flashing warning lights:unit
Summary:
Unable to locate emergency light relay and/or blunt cut wires. *tt
Bulletin:
04039
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. special policy adjustment - injectors - replace. *mj updated 2/21/08. *nj csc letter was received. updated 3/5/10. *pe
Bulletin:
01250C
Component:
111000 electrical system:battery
Summary:
Battery or charge indicator light remains on for up to 30 seconds after a cold start and engine running. *tt
Bulletin:
00872A
Component:
061000 engine and engine cooling:engine
Summary:
Oil pan or oil cooler line leak on gen iii v-8 engines equipped with an oil cooler. *tt
Bulletin:
01353
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire due to injector fretting corrosion. *tt
Bulletin:
00823A
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Power steering fluid leaking at hydraulic brake booster. *tt
Bulletin:
040604007
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin:
030864010
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirrors may blow in at highway speeds or power folding feature appears inoperative. also to include 2005 models. *tt
Bulletin:
11252002
Component:
010000 steering
Summary:
Vehicle will not start caused by the steering wheel position sensor. *tt
Bulletin:
09252002
Component:
102000 power train:manual transmission
Summary:
This message is about hydraulic fluid usage for the hydraulic clutch system. *mj
Bulletin:
09262002
Component:
102000 power train:manual transmission
Summary:
This message is about the transmission not shifting into gear with the clutch pedal fully depressed. *mj
Bulletin:
09272002
Component:
980000 unknown or other
Summary:
Contacting tac prior to replacement of an engine control module (ecm). *tt
Bulletin:
030730011B
Component:
100000 power train
Summary:
Transmission slips, delayed engagement, cold hesitation, intermittent, poor performance, power, shift, dtcs p0701, p1709, p1711, p1713, p0841, p0843, p0847, p0870, p0872, or p0875. *tt
Bulletin:
040495001
Component:
105300 power train:driveline:driveshaft
Summary:
Revised wheel drive shaft nut torque specification. *tt
Bulletin:
040525002B
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
Bulletin:
040850007
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Service information for front heated seat inoperative/cold. *mj
Bulletin:
3021
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Clutch pedal assembly squeak noise. the condition typically occurs during hot ambient temperature. *tt
Bulletin:
3011
Component:
061000 engine and engine cooling:engine
Summary:
Repeat engine oil leak at main bearing side bolt. *tt
Bulletin:
3015
Component:
061000 engine and engine cooling:engine
Summary:
6.0l lq4 vin u engine restriction. *tt
Bulletin:
1531156
Component:
080000 fuel system, diesel
Summary:
Parts showing no stock or not available. *mj
Bulletin:
3025
Component:
220000 seats
Summary:
Repairing cloth seats with napped fabric. *mj
Bulletin:
3028
Component:
022000 suspension:rear
Summary:
Replacement tailgate cables bind at shoulder bolt. *mj
Bulletin:
3024
Component:
061000 engine and engine cooling:engine
Summary:
4.8 5.3 6.0 gen 111 engine coated piston information. *mj
Bulletin:
3002
Component:
100000 power train
Summary:
4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
Bulletin:
3018
Component:
061000 engine and engine cooling:engine
Summary:
Engine cylinder head cup plug coolant leak. *mj
Bulletin:
3009A
Component:
020000 suspension
Summary:
Suspension vibration or frame beaming at 40 -60 mph. *mj
Bulletin:
00313
Component:
020000 suspension
Summary:
Squeak or creak noise from underbody over bumps. *mj
Bulletin:
3001
Component:
106000 power train:axle assembly
Summary:
The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
Bulletin:
3004
Component:
061000 engine and engine cooling:engine
Summary:
4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj
Bulletin:
3000
Component:
162300 structure:body:door
Summary:
Service vme - 03 - 04 full size truck, utilities and hummer h2 passenger door module inoperative. *mj
Bulletin:
3002
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Service vme - switching mirrors from power folding to power extending. *mj
Bulletin:
3001
Component:
110000 electrical system
Summary:
No communication with any modules, multipe u-diagnostic trouble codes (dtcs), instrument panel cluster (ipc) warning indicators. 03-04 chevrolet all full size trucks and utilities and 03-04 gmc all full size trucks and utilities and 03-04
Bulletin:
3000A
Component:
022000 suspension:rear
Summary:
Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin:
04152004
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Gm is announcing a product emission recall, number 04016. vehicles could have the .02 engine off natural vacuum, eonv, evaporative emission system leak detection diagnostic disabled by the powertrain control module that incorrectly referen
Bulletin:
3067
Component:
162900 structure:body:roof and pillars
Summary:
Tinny rattle type noise from the roof at highway speeds. *tt
Bulletin:
3045
Component:
200000 wheels
Summary:
Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
Bulletin:
3040
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light and / or reduced engine power mode due to diagnostic trouble codes p0120, p0220, p1516 and/or p1518. this condition is normally very intermittent. *tt
Bulletin:
3042
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light and / or reduced engine power mode due to diagnostic trouble codes p0120, p0220, p1516 and/or p1518. this condition is normally very intermittent. *tt
Bulletin:
3046A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge fluctuation in park or neutral. *tt
Bulletin:
3051
Component:
185000 vehicle speed control:cruise control
Summary:
Cruise control and/or the power take off unit (pto) may be inoperative. *tt
Bulletin:
3048
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Timing chain tensioner breakpoints for service kit or production kit. supplement to 03-06-01-024b. *tt
Bulletin:
09112002
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Power folding mirrors have no detent or they may flop in the wind. *tt
Bulletin:
09162002
Component:
353600 equipment:air conditioner
Summary:
Less than desirable ac performance, especially when the ambient temperature is above 90 degrees on vehicles equipped with the duramax diesel engine. *tt
Bulletin:
10212002
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
Buzz noise felt in the accelerator pedal on the first acceleration after starting the vehicle. *tt
Bulletin:
10212002
Component:
220000 seats
Summary:
Information on diagnostic trouble code 63 for passenger sensing system that is not calibrated. *tt
Bulletin:
10222002
Component:
132000 visibility:glass, side/rear
Summary:
Rear quarter glass service replacement kits may have deformed sealing striped when initially removed from their packaging causing dealers to reorder. *tt
Bulletin:
3083
Component:
100000 power train
Summary:
M74 allison lct1000 pto gear applications. *tt
Bulletin:
3086
Component:
353600 equipment:air conditioner
Summary:
Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
Bulletin:
3086
Component:
061000 engine and engine cooling:engine
Summary:
Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt
Bulletin:
3087
Component:
061000 engine and engine cooling:engine
Summary:
Crank no start with no cranking rpm spark or injector pulse. *tt
Bulletin:
3087
Component:
090000 fuel system, other
Summary:
Updated part number for bulletin 04-08-49-019 stall, inaccurate/incorrect fuel gauge reading. *tt
Bulletin:
3089
Component:
162000 structure:body
Summary:
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. *tt
Bulletin:
3089
Component:
110000 electrical system
Summary:
Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt
Bulletin:
3073
Component:
185000 vehicle speed control:cruise control
Summary:
Downhill cruise control surge. *tt
Bulletin:
3075B
Component:
110000 electrical system
Summary:
Blown mbec 1 or lbec 1 fuse. *tt
Bulletin:
3076
Component:
353600 equipment:air conditioner
Summary:
Repeat hvac blower motor failure. *tt
Bulletin:
3069
Component:
980000 unknown or other
Summary:
Paint for the 2003 gmt800 trucks for canadian dept. of national defense. *tt
Bulletin:
3072
Component:
062000 engine and engine cooling:cooling system
Summary:
The engine coolant temperature or intake air temperature sensor may read -40 degrees when monitored with tech 2. *tt
Bulletin:
3050A
Component:
350000 equipment
Summary:
02-05 onstar equipped vehicles emitting beeping noise before connecting to onstar. *tt
Bulletin:
3073
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
03-06-04-037 supplement - evap canister installation information. *tt
Bulletin:
3038
Component:
061000 engine and engine cooling:engine
Summary:
Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt
Bulletin:
3057
Component:
010000 steering
Summary:
Intermittent concern of the service 4 wheel steer message being displayed on the dic. *tt
Bulletin:
3054
Component:
100000 power train
Summary:
Replacement flexplate may have larger bolt holes than the original flexplate. *tt
Bulletin:
3055
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
Bulletin:
3057
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 pump whine noise. *tt
Bulletin:
3062
Component:
980000 unknown or other
Summary:
Additional part numbers for bulletin 02-01-38-007b. *tt
Bulletin:
30559
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 diagnostic trouble code p1711, p0872 after completing repairs. *tt
Bulletin:
3128
Component:
160000 structure
Summary:
All full size trucks pick up box sheet metal fracture/damage with aftermarket accessories installed. *sc
Bulletin:
3147
Component:
060000 engine and engine cooling
Summary:
Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc
Bulletin:
3125
Component:
080000 fuel system, diesel
Summary:
Duramax diesel low power and fuel economy. *tc
Bulletin:
3105C
Component:
100000 power train
Summary:
Ping, pop, snap, or click noise from the propeller shaft. *sc
Bulletin:
3155
Component:
180000 vehicle speed control
Summary:
Speedometer inoperative. *tc
Bulletin:
3157
Component:
190000 tires
Summary:
Excessive tire spin setting diagnostic trouble code c0543. *tc
Bulletin:
3160
Component:
060000 engine and engine cooling
Summary:
Gas engines exhaust buzz or rattle noise. *tc
Bulletin:
3121
Component:
060000 engine and engine cooling
Summary:
Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
Bulletin:
3024
Component:
060000 engine and engine cooling
Summary:
Gen iii engine coated piston information. *tc
Bulletin:
3130
Component:
100000 power train
Summary:
Allison lct 1000 prndl flash and/or will not move. *tc
Bulletin:
3119
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Engineering investigation - catalytic converter replacement. *sc
Bulletin:
3121
Component:
060000 engine and engine cooling
Summary:
6.6 lb7 engine with a no charge condition with diagnostic trouble code p0380 p0621. *sc
Bulletin:
3107
Component:
060000 engine and engine cooling
Summary:
P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
Bulletin:
3092
Component:
100000 power train
Summary:
Allison lct 1000 buzz noise feel on tcc apply. *sc
Bulletin:
3097
Component:
060000 engine and engine cooling
Summary:
Oil pan or oil cooler line leak. *sc
Bulletin:
3094
Component:
110000 electrical system
Summary:
Allison lct 1000 p1781 or p0802 setting in the electronic control module. (2005 chevrolet kodiak and 2005 gmc top kick) *sc
Bulletin:
3096
Component:
140000 air bags
Summary:
Intermittent air bag telltale sets a false diagnostic trouble code of b0083 and or b0084. *sc
Bulletin:
3143
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Transmission oil cooler line fitting clarification. *tc
Bulletin:
3121
Component:
062000 engine and engine cooling:cooling system
Summary:
Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
Bulletin:
00837
Component:
100000 power train
Summary:
Allison lct1000 overdrive disable lamp inoperative after installation of instrument panel (ip). *tt
Bulletin:
3151
Component:
100000 power train
Summary:
Allison lct1000 transmission hard to remove from park. *tt
Bulletin:
3156
Component:
100000 power train
Summary:
261 transfer case drivelines growl 1100-1200 rpm. *tt
Bulletin:
3044
Component:
350000 equipment
Summary:
Generation 5 onstar steering wheel control function. *tt
Bulletin:
3056
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
Bulletin:
04007A
Component:
162500 structure:body:tailgate
Summary:
Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
Bulletin:
3161
Component:
103000 power train:automatic transmission
Summary:
Allison lct1000 clunk noise on start in park. *eh
Bulletin:
3061C
Component:
110000 electrical system
Summary:
Diagnostic trouble code c0327 with or without additional diagnostic trouble codes setting. *tt
Bulletin:
3193
Component:
060000 engine and engine cooling
Summary:
Excessive oil consumption. *eh
Bulletin:
3205
Component:
100000 power train
Summary:
Allison lct1000 pump separator plate change disregard additional valve. *tt
Bulletin:
3187
Component:
060000 engine and engine cooling
Summary:
Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe
Bulletin:
3011B
Component:
060000 engine and engine cooling
Summary:
Engine oil leak at main bering side bolt. *eh
Bulletin:
3149
Component:
090000 fuel system, other
Summary:
Fuel pressure regulator connector or terminal repairs. *tt
Bulletin:
3087
Component:
060000 engine and engine cooling
Summary:
Crank no start, stall, hard start, and no cranking rpm. *eh
Bulletin:
040731006
Component:
100000 power train
Summary:
Excessive shifter and/or engine vibration, bearing growl and/or rattle type noise while depressing or releasing clutch pedal. *tt
Bulletin:
040523001A
Component:
030000 service brakes, hydraulic
Summary:
Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
Bulletin:
040604001
Component:
061000 engine and engine cooling:engine
Summary:
Various intermittent driveability conditions - hesitation, lack of power, etc. *tt
Bulletin:
040731001
Component:
100000 power train
Summary:
Revised clutch pressure plate adjustment. *tt
Bulletin:
040864003
Component:
133000 visibility:power window devices and controls
Summary:
Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
Bulletin:
040138010
Component:
353600 equipment:air conditioner
Summary:
Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
Bulletin:
040139009
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Hvac blower motor inoperative or stays running. *tt
Bulletin:
040602006
Component:
061000 engine and engine cooling:engine
Summary:
Engine overheating. *tt
Bulletin:
040604057
Component:
061000 engine and engine cooling:engine
Summary:
Start/stall or poor driveability after restart, loss of gasoline or cng hours/miles data with bi-fuel vehicle. *tt
Bulletin:
040849019
Component:
090000 fuel system, other
Summary:
Cranks but no start, stall, inaccurate/incorrect fuel gauge reading, no fuel, vehicle is out of fuel and fuel gauge reads above empty. *tt this bulletin replaces previous bulletin number 04-08-49-019. *tt
Bulletin:
000235003E
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in steering wheel. this bulletin replaces previous bulletin 00-02-35-003e. *tt
Bulletin:
020139007
Component:
980000 unknown or other
Summary:
Automatic dual zone hvac battery draw. *ar
Bulletin:
040850016B
Component:
220000 seats
Summary:
Memory seat may not return to requested position. *eh
Bulletin:
3214
Component:
060000 engine and engine cooling
Summary:
Engine low oil light on the dic. *eh
Bulletin:
3232
Component:
060000 engine and engine cooling
Summary:
Misfire at idle cold and possible p0171 and or p0174. *eh
Bulletin:
3239
Component:
060000 engine and engine cooling
Summary:
Lb7 engine vibration miss or runs rough no diagnostic trouble code. this also includes lb7 c2 c3 c4 c5 d4 d5 e4 e5 k2 k3. *eh
Bulletin:
3243
Component:
103000 power train:automatic transmission
Summary:
Leak from the vent 4l80e/4l85e transmission. *eh
Bulletin:
3227
Component:
162500 structure:body:tailgate
Summary:
Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
Bulletin:
3057
Component:
010000 steering
Summary:
Service 4 wheel steer message with diagnostic trouble code c0455. *eh
Bulletin:
000235003
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
Bulletin:
020138007
Component:
353600 equipment:air conditioner
Summary:
Poor air conditioner performance - air conditioner will not blow cold enough. this service bulletin replaces 020138007a. *eh
Bulletin:
040850011
Component:
150000 seat belts
Summary:
Repairing napped seat fabric. *eh
Bulletin:
040523005
Component:
030000 service brakes, hydraulic
Summary:
Availability of rear wheel mud flaps to reduce debris build-up on rear brake calipers and/or rear wheels. *tt
Bulletin:
040601018
Component:
061000 engine and engine cooling:engine
Summary:
Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt
Bulletin:
040604007E
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin:
020730011
Component:
103000 power train:automatic transmission
Summary:
Slow or no engagement of automatic transmission no start blank prndl display flashing prndl diagnostic trouble code p0708 p0872 p0847 p0875 p1711 p1713 or u1000 set. this service bulletin replaces 020730011. *eh
Bulletin:
040604040
Component:
061000 engine and engine cooling:engine
Summary:
Idle instability, low or rough idle with electronic throttle control. *tt
Bulletin:
030310002
Component:
190000 tires
Summary:
Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
Bulletin:
030310006D
Component:
190000 tires
Summary:
20 inch wheels and tires available through gmspo. *eh *tt
Bulletin:
040138008
Component:
353600 equipment:air conditioner
Summary:
Heat ventilation and air conditioning system cannot be controlled or defaults to defrost mode. *eh
Bulletin:
040848003
Component:
131000 visibility:windshield
Summary:
Windrush around windshield. *tt
Bulletin:
040941003
Component:
140000 air bags
Summary:
Proper use of labor operation code when diagnosis leads to sir passenger presence system replacement. *tt
Bulletin:
030089020
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary of published bulletins. *eh
Bulletin:
030605007
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust rattle noise or vibration. *tt
Bulletin:
030419003
Component:
105000 power train:driveline
Summary:
Fluid leak from front of vehicle add teflon tape to front axle vent plug threads. *eh
Bulletin:
030604036
Component:
060000 engine and engine cooling
Summary:
Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb
Bulletin:
030604037
Component:
060000 engine and engine cooling
Summary:
Service engine soon light on with diagnostic trouble code p0446 set replace canister. *eh
Bulletin:
030730031
Component:
100000 power train
Summary:
Transmission leaks, slips, vehicle will not move. *tt
Bulletin:
030864025
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Left camper mirror will not lock into detent when mirror is folded inward. *tt
Bulletin:
030236002
Component:
010000 steering
Summary:
Revised steering wheel position sensor or steering shaft lower bearing replacement procedure and steering wheel position sensor centering procedure. *eh
Bulletin:
040525005A
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Antilock brake system light on service brake system message on driver information center. *eh updated *eh
Bulletin:
040604007A
Component:
060000 engine and engine cooling
Summary:
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. this service bulletin replaces 040604007. *eh
Bulletin:
040137004
Component:
353600 equipment:air conditioner
Summary:
Revised air conditioning (a/c) system performance test. *tt
Bulletin:
040849007
Component:
110000 electrical system
Summary:
Personal trip business trip feature must be on for trip odometer to accumulate. *eh
Bulletin:
040850003
Component:
150000 seat belts
Summary:
Enabling memory seat feature via dic if feature appears inoperative. *eh
Bulletin:
040603002
Component:
060000 engine and engine cooling
Summary:
Diagnostic information for intermittent vehicle no crank dead battery. *eh
Bulletin:
040604070
Component:
061000 engine and engine cooling:engine
Summary:
Information on the revised fuel filter for the 6.6l duramax diesel. *tt
Bulletin:
040138013
Component:
353600 equipment:air conditioner
Summary:
Hvac not cold enough a/c compressor does not engage . *eh
Bulletin:
040138014
Component:
353600 equipment:air conditioner
Summary:
High pitched tone heard inside vehicle when ac compressor is engaged. *eh
Bulletin:
020601023C
Component:
060000 engine and engine cooling
Summary:
Oil leak at cooler to engine block mating surface. *eh
Bulletin:
01292004
Component:
133000 visibility:power window devices and controls
Summary:
Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
Bulletin:
08242004
Component:
100000 power train
Summary:
Bearing growl or rattle type noise while depressing or releasing the clutch pedal. *tt
Bulletin:
10082002
Component:
103000 power train:automatic transmission
Summary:
Service engine soon light is illuminated and the vehicle may not start. diagnostic trouble code p0706, which relates to transmission range switch performance may be stored. *tt
Bulletin:
11062003
Component:
060000 engine and engine cooling
Summary:
Airflow sensor problem. *eh
Bulletin:
09302002
Component:
161100 structure: frame and members:underbody shields
Summary:
Frame beaming or vehicle shaking and or vibration. *eh
Bulletin:
10042002
Component:
110000 electrical system
Summary:
Rpo c82 no longer include the instrument panel jumper wiring harness. *eh
Bulletin:
3300C
Component:
341000 communications:horn assembly
Summary:
Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
Bulletin:
040846004
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Onstar system inoperative onstar system status light is red radio locked in phone mode or dtc b1000. *eh
Bulletin:
050090001
Component:
060000 engine and engine cooling
Summary:
Information on the proper air filter for the duramax diesel. *eh
Bulletin:
0502118001
Component:
010000 steering
Summary:
Quadrasteer intermittent service 4-wheel steer message. *tt
Bulletin:
050730002
Component:
103000 power train:automatic transmission
Summary:
New essential tool j 45096 23 automatic transmission oil cooler line adapter for allison transmission. *eh
Bulletin:
3282
Component:
061000 engine and engine cooling:engine
Summary:
Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin:
3292
Component:
060000 engine and engine cooling
Summary:
Diesel engine balance rates all showing zero. *eh
Bulletin:
3373
Component:
140000 air bags
Summary:
Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
Bulletin:
3386
Component:
015000 steering:hydraulic power assist system
Summary:
Lack of steering assist or shudder during parking lot type maneuvers. *tt
Bulletin:
3294
Component:
106000 power train:axle assembly
Summary:
Highway speed vibration on smooth surface. *eh
Bulletin:
3299
Component:
060000 engine and engine cooling
Summary:
Diesel oil leak from pcv vent tube. *eh
Bulletin:
3300
Component:
105000 power train:driveline
Summary:
4wd models with noise, vibration on dry pavement. *eh
Bulletin:
07012004
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
Bulletin:
3464
Component:
162310 structure:body:door:hinge and attachments
Summary:
Door hinge replacement kit. *tt
Bulletin:
03102005
Component:
010000 steering
Summary:
Steering gear whistle noise on turns. *eh
Bulletin:
3351
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
Bulletin:
3155
Component:
110000 electrical system
Summary:
No shift, speedometer erratic/inoperative, p0721 c0237 p0500 c0055. *tt
Bulletin:
3357
Component:
110000 electrical system
Summary:
Malfunction indicator light is on and the vehicle has a code p0706. *tt
Bulletin:
3232
Component:
061000 engine and engine cooling:engine
Summary:
1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
Bulletin:
3491
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Anti-lock braking system (abs) telltale illuminated with diagnostic trouble code c0550. *tt
Bulletin:
3499
Component:
017300 steering:linkages:arm:idler and attachment
Summary:
Steering idler arm inspection procedure. *tt
Bulletin:
3375
Component:
060000 engine and engine cooling
Summary:
Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt
Bulletin:
3380
Component:
060000 engine and engine cooling
Summary:
Oil leak from the pcv vent tube. *tt
Bulletin:
020307002
Component:
020000 suspension
Summary:
Revised front caster and camber adjustment procedure. original not yet received. *tt
Bulletin:
3364
Component:
106000 power train:axle assembly
Summary:
Rear axle retainer button breakage. *eh
Bulletin:
040604088
Component:
060000 engine and engine cooling
Summary:
Replacement of connector when replacing fuel tank module/fuel pump module. *tt
Bulletin:
050604021
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt
Bulletin:
050604024
Component:
060000 engine and engine cooling
Summary:
Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
Bulletin:
050604025
Component:
060000 engine and engine cooling
Summary:
Revised diagnostic trouble code (dtc) u2104. *tt
Bulletin:
050846006A
Component:
350000 equipment
Summary:
Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital). *tt
Bulletin:
610
Component:
162000 structure:body
Summary:
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. gm tech link. *tt
Bulletin:
609
Component:
102000 power train:manual transmission
Summary:
Clutch pedal squeak. *sc
Bulletin:
510
Component:
220000 seats
Summary:
Repairing napped fabric-seats may have been upholstered in napped fabrics with dorchester on the bolster and honeycomb on the insert. *sc
Bulletin:
702
Component:
061000 engine and engine cooling:engine
Summary:
Duramax air filter. gm tech links. *tt
Bulletin:
708
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Heated seats turn off. *sc
Bulletin:
05546
Component:
355200 equipment:other:owners/service/other manual
Summary:
Program bulletin (customer satisfaction program)-15,000 mile (24,000 km) fuel filter change. 2002 chevrolet kodiak and 2001-2002 gmc topkick. *sc
Bulletin:
3671
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Service vme - outside rearview mirror vibration. *tt
Bulletin:
3526
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
Bulletin:
3556
Component:
061000 engine and engine cooling:engine
Summary:
Hard start or extended crank time on initial cold start when using alcohol blended fuels. *sc
Bulletin:
3427
Component:
110000 electrical system
Summary:
Additional diagnostic information dtc p0757. *tt
Bulletin:
3639
Component:
135000 visibility:rearview mirrors/devices
Summary:
Service vme-outside rear view mirror inoperative. *sc
Bulletin:
3225A
Component:
061200 engine and engine cooling:engine:diesel
Summary:
01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc
Bulletin:
3048A
Component:
061000 engine and engine cooling:engine
Summary:
Supplement to 03-06-01-024b 4.3l lu3 l35 timing chain tensioner. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. *tt
Bulletin:
3267
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc
Bulletin:
3422
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Inaccurate outside temperature reading on inside rearview mirror. *tt
Bulletin:
3312
Component:
060000 engine and engine cooling
Summary:
No start, hard start, loss of power, or white smoke. *tt
Bulletin:
3314
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Duramax diesel engine hard start, no start, stall of diagnostic trouble code p0093, p1093. *tt
Bulletin:
3317
Component:
060000 engine and engine cooling
Summary:
Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe
Bulletin:
3105
Component:
100000 power train
Summary:
Ping, pop, snap or click noise from the propeller shaft. *tt
Bulletin:
3343
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil dipstick unseated or oil leak. *tt
Bulletin:
3630A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge is inaccurate or reads empty on diesel equipped chassis cab with dual tanks. *tt
Bulletin:
3573
Component:
133000 visibility:power window devices and controls
Summary:
Unwanted operation of rear windows. *tt
Bulletin:
3424
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Electronic transfer case unable to complete shift. *tt
Bulletin:
3422
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Duramax diesel pilot to main injection fuel knock noise. *tt
Bulletin:
050604029
Component:
061000 engine and engine cooling:engine
Summary:
Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300. *tt
Bulletin:
050604008
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt
Bulletin:
050310005
Component:
200000 wheels
Summary:
Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
Bulletin:
050850008
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Intermittent heated seats inoperative, diagnostic trouble code b3941 set. *tt
Bulletin:
050601014
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt
Bulletin:
0502118002
Component:
010000 steering
Summary:
Diagnostic trouble code c0455, service rear wheel steering, system jumps from 4-wheel steer to 2-wheel steer. *tt
Bulletin:
050604007
Component:
061000 engine and engine cooling:engine
Summary:
Poor engine performance - misfire, rough idle, stalls, engine cranks but does not run, service engine soon/check engine light illuminated, diagnostic trouble code (dtc) p0300 set. *tt
Bulletin:
05-04-21-003
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
Bulletin:
05500
Component:
116000 electrical system:ignition
Summary:
The ignition distributor cap and rotor may corrode and cause ignition system failure. a product emission recall to inspect / replace the distributor ignition system. *tt gm parts bulletins & information. *tt
Bulletin:
050850012
Component:
220000 seats
Summary:
Unwanted/loose seat movement. *tt
Bulletin:
3287B
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Heated seat inoperative or shut off in 30 seconds. diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module. *tt
Bulletin:
3616
Component:
090000 fuel system, other
Summary:
Service vme - 2006 duramax diesel engine fuel system components are not interchangeable with earlier year model vehicles. *tt
Bulletin:
3691A
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Front hvac blower inoperative. *tt
Bulletin:
3665
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4wd inoperative and possible dtc c0327 stored in the transfer case control module. *tt
Bulletin:
3170E
Component:
121000 exterior lighting:headlights
Summary:
Ipc, interior lights and/or headlamps flicker. *ak fb2
Bulletin:
3691B
Component:
061000 engine and engine cooling:engine
Summary:
Generation iii v8 engine piston repairs. *tt
Bulletin:
060601003
Component:
061000 engine and engine cooling:engine
Summary:
Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt
Bulletin:
050604077
Component:
061000 engine and engine cooling:engine
Summary:
Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak
Bulletin:
060308002
Component:
021510 suspension:front:control arm:upper arm
Summary:
Revised upper control arm replacement. *tt
Bulletin:
3630
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Inaccurate fuel gauge readings/rear float arm stuck. *tt updated 03-01-07. *kb updated 3/15/10. *pe
Bulletin:
3401
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Turbocharger oil feed line kinked or restricted. *tt
Bulletin:
3870
Component:
101000 power train:clutch assembly
Summary:
Clutch pedal fade or clutch will not disengage typically when towing. *tt
Bulletin:
4150
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Dual tanks fuel gauge defaults to empty - new calibrations. stall start tank transfer. vehicles with 6.6l rpo lb7 or lly engines. *kb
Bulletin:
030693001
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb
Bulletin:
3340
Component:
021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:
Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
Bulletin:
3009
Component:
020000 suspension
Summary:
Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe
Bulletin:
3190
Component:
110000 electrical system
Summary:
Unable to locate emergency light relay and/or blunt cut wires. *kb
Bulletin:
4179
Component:
140000 air bags
Summary:
Dual stage passenger air bag used in single stage application. *kb
Bulletin:
3136
Component:
102000 power train:manual transmission
Summary:
Slip condition in 2nd, 3rd, or 4th. damaged 2-4 or 3-4 clutch. *kb updated 10/31/07. *nj
Bulletin:
4231
Component:
061000 engine and engine cooling:engine
Summary:
Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
Bulletin:
3425
Component:
190000 tires
Summary:
Unable to program tire size in ebcm/vses. *kb
Bulletin:
010310010
Component:
020000 suspension
Summary:
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. *kb
Bulletin:
3568
Component:
040000 service brakes, air
Summary:
Service brake booster message. *kb
Bulletin:
4365
Component:
330000 interior lighting
Summary:
Ipc backlighting inoperative tbc 2a fuse open. *kb
Bulletin:
4030
Component:
106000 power train:axle assembly
Summary:
New design front axle side bearing adjusters. *kb
Bulletin:
070601009
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Diesel engine cylinder head gasket missing thickness grade markings. *kb
Bulletin:
4144
Component:
102000 power train:manual transmission
Summary:
Allison lct1000 harsh 3-2, 2-1 downshift, and abs may activate. *kb
Bulletin:
040525002
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
Bulletin:
050232008
Component:
015100 steering:hydraulic power assist:pump
Summary:
Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
Bulletin:
3075
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Blown mbec 1 or lbec 1 fuse. *kb
Bulletin:
4486
Component:
117000 digital instrument panel
Summary:
One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
Bulletin:
070842013
Component:
126100 exterior lighting:turn signal:flasher unit
Summary:
Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
Bulletin:
07187
Component:
117000 digital instrument panel
Summary:
Cadillac\chevrolet\gmc service campaign: see document search button for owner letter. instrument panel cluster gauge needle function may cause inaccurate readings on some 2003-2004 cadillac, chevrolet, and gmc vehicles. *nj updated 2/5
Bulletin:
PIP-4290
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Engine surge or stall at stop and/or dtc p0742 possible tcc applied. equipped with allison lct1000 transmission rpo m74 or mw7. *nj updated 4/22/13. *pe
Bulletin:
07057
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment - engine glow plug on certain vehicles with 6.6l diesel v8 (rpo lb7 - vin 1) engine & california emissions (yf5/ne1) or clean fuel emis
Bulletin:
PIP3343
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary:
Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
Bulletin:
PIP4054A
Component:
022000 suspension:rear
Summary:
Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin:
000235003N
Component:
012000 steering:column
Summary:
Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin:
PIT3504D
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
Bulletin:
07187A
Component:
117000 digital instrument panel
Summary:
Cadillac\chevrolet\gmc service campaign: see document search button for owner letter. some vehicles could develop a condition where one or more of the instrument panel gauge needles may stick, flutter, or become inoperative. csc letter
Bulletin:
08-089
Component:
353000 equipment:electrical
Summary:
Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin:
PIT-3046E
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin:
PIT-4722
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
Bulletin:
08-089B
Component:
355200 equipment:other:owners/service/other manual
Summary:
Buick\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. csc letter was received. *pe
Bulletin:
08089-B
Component:
110000 electrical system
Summary:
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin:
PIP-4492P
Component:
061000 engine and engine cooling:engine
Summary:
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin:
SB-10-02-33-001
Component:
010000 steering
Summary:
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin:
PIT-3749D
Component:
161000 structure:frame and members
Summary:
Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
Bulletin:
PIP-4138K
Component:
060000 engine and engine cooling
Summary:
Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
10-00-89-017C
Component:
980000 unknown or other
Summary:
Gm: information on fixing multiple situations right the first time. *rm
Bulletin:
PI-0011A
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
Bulletin:
PB-10037A
Component:
110000 electrical system
Summary:
Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm
Bulletin:
SB-10240
Component:
353600 equipment:air conditioner
Summary:
General motors service campaign: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm updated 4/6/12. *pe
Bulletin:
SB-10-08-50-003B
Component:
221300 seats:front assembly:head restraint
Summary:
General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
Bulletin:
SB-13-05-22-001
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
Bulletin:
SB-080604003-C
Component:
060000 engine (pws)
Summary:
Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500, topkick c4500-c5500, 2006-15 express, savana. *pe
Bulletin:
UIB-117
Component:
061000 engine and engine cooling:engine
Summary:
General motors: an optional engine block heater plug in for onboard ac power and with continuous usage will result in shorting of wires, over heating system, electrical failure and compartment engine fires. model 2003-15 express cut away
Bulletin:
06-03-09-004H
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
Bulletin:
PIT5195A
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIT3227J
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIT3237G
Component:
131000 visibility:windshield
Summary:
This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
Bulletin:
PIP4379K
Component:
103000 power train:automatic transmission
Summary:
This preliminary information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. technician may find diagnostic trouble codes
Bulletin:
PIP5072
Component:
101000 power train:clutch assembly
Summary:
This preliminary information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. technician will inspect the 3-4 clutches and the forward clutch
Bulletin:
PIT3665C
Component:
030000 brakes (pws)
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT3330F
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about customers may inquire about the availability of the passenger compartment air filter. dealer should advise the customer starting in 2003 the passenger c
Bulletin:
PIT3271F
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIP3259J
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. technician should compare the noise to a like vehicle. technician will nee
Bulletin:
PIP4138L
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
Bulletin:
PIT5195
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIP4972C
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that will not move in forward or reverse. technician may find diagnostic trouble code p0877 or p2723 set. technician will need to inspect the v
Bulletin:
PIT3665E
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT3227M
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
00-03-10-003R
Component:
190000 tires
Summary:
This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.
Bulletin:
15-08-44-001B
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
05-06-04-035E
Component:
090000 fuel system, other
Summary:
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:
02-07-30-052J
Component:
103000 power train:automatic transmission
Summary:
This informational bulletin provides technicians with information regarding automatic transmission oil cooler flow test essential tool j-45096 transflow®.
Bulletin:
15-08-44-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-73-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
09-09-40-001C
Component:
150000 seat belts
Summary:
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
Bulletin:
10-00-89-017X
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
Bulletin:
11-00-89-005C
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
07-08-49-020I
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides a quick guide to updating which model vehicle after replacing the ipc.
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC3278F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIT3271G
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC5953A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech

Home | Privacy