2002 SATURN VUE Recalls (2)

Campaign:
01V386000 on 01/01/2002
Component:
Seat belts:front:anchorage
Manufactured:
09/30/2001 - 12/30/2001
Affected:
327
Defect:
Vehicle description: certain sport utility vehicles fail to comply with the requirements of fmvss no. 210, "seat belt assembly anchorages." some vehicles were produced with rear outer seat belt shoulder guide anchor bolts that were incorrectly installed.
Consequence:
If these bolts were incorrectly installed, they would not withstand the load requirements of the standard. if an anchorage failed in a crash, the occupant would not be properly restrained and could have an increased risk of injury.
Correction:
Dealers will replace the rear shoulder guide anchor bolts. owner notification began december 19, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saturn at 1-800-553-6000.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
14V490000 on 08/07/2014
Component:
Electrical system:ignition
Manufactured:
09/10/2001 - 06/11/2002
Affected:
202,155
Defect:
General motors llc (gm) is recalling certain model year 2002-2004 saturn vue vehicles manufactured september 11, 2001, to april 6, 2004. in the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "off" position.
Consequence:
If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "reverse" position. this potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Correction:
Gm will notify owners, and dealers will inspect the vehicle to see if the key can be pulled out when the ignition is off. if it can, dealers will replace the ignition cylinder and keys, free of charge. the recall began in october 2014. owners may contact saturn customer service at 1-800-553-6000. gm's number for this recall is 14506. note: until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "park," or in the case of a manual transmission, that the vehicle is in the "reverse" position and the parking brake is engaged.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2002 SATURN VUE TSBs (376)

Bulletin:
01I04
Component:
190000 tires
Summary:
Service information on california vehicle code requirements regarding 2002 modelyear tire chain disclosure for various models including saturn vue. *tt
Bulletin:
01I06
Component:
980000 unknown or other
Summary:
2002 model year essential service tool update #1 and storage rack system information for vue essential tools. *tt
Bulletin:
01I07
Component:
980000 unknown or other
Summary:
Information regarding essential tool package. *slc
Bulletin:
01T54
Component:
980000 unknown or other
Summary:
Service information regarding engine exchange program (us only). *jg
Bulletin:
02C04
Component:
220000 seats
Summary:
Subject regarding verification of proper installation and torque of rear seat belt shoulder guide anchor bolts. *jg
Bulletin:
02T08
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may comment about a rattle or tapping noise coming from the steering column shroud area. *jg
Bulletin:
02T14
Component:
022000 suspension:rear
Summary:
Some customers may complain about a creaking noise coming from the right or left rear of the vehicle while driving. *jg
Bulletin:
02T08
Component:
011000 steering:wheel and handle bar
Summary:
Some customers may comment about a ratle or tapping noise coming from the steering column shroud area. *jg
Bulletin:
02T14
Component:
022000 suspension:rear
Summary:
Some customers may comment about a creaking noise coming from the right or left rear of the vehicle while driving. *jg
Bulletin:
02T18
Component:
110000 electrical system
Summary:
Subject regarding onstar system unable to send or receive cellular phone calls.*jb
Bulletin:
02T21
Component:
220000 seats
Summary:
Subject regarding squeak/itch noise from front seats. *jb
Bulletin:
02T28
Component:
980000 unknown or other
Summary:
Malfunction indicator service engine soon telltale is illuminated.*jb
Bulletin:
02T30
Component:
103000 power train:automatic transmission
Summary:
Information pertaining to on-board diagnostic software upgrade.*jb
Bulletin:
02T31
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on engine flare during 2-3 upshift.*jb
Bulletin:
02T33
Component:
162000 structure:body
Summary:
Subject pertaining to sunshade not lowering or rotating to foward most position.*jb
Bulletin:
01T64
Component:
980000 unknown or other
Summary:
Information regarding service manual update for restraints and chassis service manuals regarding electronic power steering. *slc
Bulletin:
02T09
Component:
100000 power train
Summary:
Subject regarding service manual update for transaxel service manuals. *slc
Bulletin:
02T13
Component:
980000 unknown or other
Summary:
Subject regarding service manual update for chassis service manuals regarding differential housing support bushing removal and installation. *slc
Bulletin:
02T01
Component:
980000 unknown or other
Summary:
Subject regarding service manual update for chassis service manuals. *slc
Bulletin:
02T02
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on service manual update for powertrain and engine service manuals regarding evaporative emission flowcharts and evap pressure/purge diagnostic chart test procdure, also includes 2000-2002 l series. *slc
Bulletin:
02T19
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Service information regarding onstar communication and interface module (cim) programming. *tt
Bulletin:
02T15
Component:
070000 fuel system, gasoline
Summary:
Service manual update for 2002 engine service manuals regarding fuel level sender and float. *tt
Bulletin:
02T20
Component:
110000 electrical system
Summary:
Service manual update for 2002 body electrical diagnostic service manuals regarding am/fm stereo with cassette and 6-disc cd player check charts. *tt
Bulletin:
02T29
Component:
980000 unknown or other
Summary:
Some customers may comment the rear seat cushion cover is baggy or loose along the bottom edge. *tt
Bulletin:
02T25
Component:
162000 structure:body
Summary:
Service manual update for 2002 body removal and installation service manuals regarding revised headlamp removal and installation procedure. *tt
Bulletin:
02T34
Component:
162000 structure:body
Summary:
Service manual update for 2002 body removal and installation service manuals regarding removal and installation procedure for liftgate emblems. *tt
Bulletin:
02T32
Component:
106000 power train:axle assembly
Summary:
Service information on vt25-e transaxle assembly replacement program. *tt
Bulletin:
02T30A
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding on-board diagnostic (obd) software upgrade - unable to communicate with ecm using generic (non-tech 2) scan tool. *tt
Bulletin:
02SE02
Component:
151200 seat belts:front:webbing
Summary:
Subject regarding rear seat shoulder belt comfort guide kit. *jg
Bulletin:
02T14A
Component:
022000 suspension:rear
Summary:
Subject regarding creaking noise from rear of vehicle while driving (replace and secure all four insulators to rear coil springs). *jg
Bulletin:
02T20
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject reagarding service manual update for body electrical diagnostics service manuals regarding am/fm stereo with cassette and 6-disc cd player check charts. *jg
Bulletin:
02T21
Component:
220000 seats
Summary:
Some consumers may complain of a squeak/itch noise coming from the front seat(s) when moving right or left in the seat or when moving laterally or exiting the vehicle. *jg
Bulletin:
02T24
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding on board diagnostic (obd) system improvements-scan tool inspection/maintenance (i/m) readiness status for heated oxygen sensor (ho2s/o2s) will not indicate ready. *jg
Bulletin:
02T25
Component:
121000 exterior lighting:headlights
Summary:
Subject regarding service manual update for body removal and installation service manuals regarding revised headlamp removal and installation procedure. *jg
Bulletin:
02T28
Component:
980000 unknown or other
Summary:
Malfunction indicator lamp service engine soon tell tale is illuminated with diagnostic trouble codes p0171 and/or p0174. *jg
Bulletin:
02T29
Component:
220000 seats
Summary:
Subject regarding rear seat cushion cover loose with drawstring cut. *jg
Bulletin:
02T30A
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding on board diagnostic (obd) software upgrade - unable to communicate with electronic control module using generic (non tech 2) scan tool (install new tcm calibration). *jg
Bulletin:
02T31A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine flare during 2-3 upshift during pre- delivery inspection (pdi) road test (install new transmission control module calibration). *jg
Bulletin:
02T32A
Component:
106000 power train:axle assembly
Summary:
Subject regarding service information on transaxle assembly replacement program. *jg
Bulletin:
02T32
Component:
106000 power train:axle assembly
Summary:
Subject regarding service information on transaxle assembly replacement program. *jg
Bulletin:
02T33
Component:
162000 structure:body
Summary:
Subject regarding sunshade not lowering or rotating to forward most position. *jg
Bulletin:
02T34
Component:
355100 equipment:other:labels
Summary:
Subject regarding service manual update for body removal and installation service manuals regarding removal and installation procedure for liftgate emblems. *jg
Bulletin:
02T36
Component:
021000 suspension:front
Summary:
Subject regarding front suspension struts and front stabilizer bar links service parts update. *jg
Bulletin:
02T37
Component:
062000 engine and engine cooling:cooling system
Summary:
Subject regarding service information on new oil cooler cover sealant. *jg
Bulletin:
02T38
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge is displaying a false low reading or stuck on empty. this may be intermittent. a diagnostic trouble code p0461 - fuel level sensor performance- may also be set in electronic control module memory. *jg
Bulletin:
02T41
Component:
138000 visibility:defroster/defogger system
Summary:
Subject regarding hvac module condensation leak into driver and passenger side footwell area- seal heater core cover and evaporator core cover. *jg
Bulletin:
02T45
Component:
106000 power train:axle assembly
Summary:
Subject regarding idle vibration at idle and/or clunk at start up. *jg
Bulletin:
02T47
Component:
020000 suspension
Summary:
Subject regarding service manual update for chassis service manuals regarding front and rear alignment specifications. *jg
Bulletin:
02T53
Component:
106000 power train:axle assembly
Summary:
Subject regarding clunk noise while driving vehicle in reverse. *jg
Bulletin:
02T60
Component:
110000 electrical system
Summary:
Subject regarding starter remaining engaged after engine start up and/or electrical accessories being inoperative intermittently. *jg
Bulletin:
020864019
Component:
162300 structure:body:door
Summary:
Squeak noise from front inner door armrest/pull handle. *jg
Bulletin:
02SE03
Component:
980000 unknown or other
Summary:
Subject regarding recreational and disabled vehicle towing information. *jg
Bulletin:
02T51
Component:
021000 suspension:front
Summary:
Subject regarding noise from front of vehicle while turning (modify the rosebud fastener and install second design pilot rings). *jg
Bulletin:
02T52
Component:
106000 power train:axle assembly
Summary:
Subject regarding clunk pop or click noise when transitioning between acceleration and decelration (torque both front axle nuts) *jg
Bulletin:
02T54
Component:
980000 unknown or other
Summary:
Subject regarding clutch master cylinder assembly part number change. *jg
Bulletin:
02T56
Component:
162000 structure:body
Summary:
Subject regarding service information regarding installation of 12v accesory outlet to left rear interior wheel opening service replacement panel assembly. *jg
Bulletin:
02T57
Component:
220000 seats
Summary:
Some consumers may complain of a squeak noise coming from the driver or passenger seat back when pressure is applied. *jg
Bulletin:
02T63
Component:
100000 power train
Summary:
Subject regarding powertrain vibration at idle with the air conditioner on and transmission in reverse or drive. *tt
Bulletin:
02T64
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service information regarding elimination of auxiliary water pump and instructions to install 2nd design heater outlet hoses in place of the 1st design water pump and heater outlet hoses. *tt
Bulletin:
02T89
Component:
103000 power train:automatic transmission
Summary:
2002 model year vt25e transaxle replacement with 2003 model year vt25e transaxle. *tt
Bulletin:
02T88
Component:
162000 structure:body
Summary:
Information on removal of luggage carrier rail assembly bolts strip out and / or heads break off when removing while installing ria luggage carriers. *tt
Bulletin:
02T85
Component:
162300 structure:body:door
Summary:
Foam gasket material protruding out and around outside door handle base. *tt
Bulletin:
02T63
Component:
100000 power train
Summary:
Powertrain vibration at idle with the air conditioner on and transmission in reverse or drive. *tt
Bulletin:
02T64
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Service information regarding elimination of auxiliary water pump and instructions to install 2nd design heater outlet hoses in place of the 1st design water pump and heater outlet hoses. *tt
Bulletin:
02T73
Component:
162000 structure:body
Summary:
Front carpet edge exposed near front door hinge pillar garnish molding. *tt
Bulletin:
02T72
Component:
030000 service brakes, hydraulic
Summary:
Service information about first and second design brake pipe flares, updated service procedures and new tool for brake pipe repair. *tt
Bulletin:
02T69
Component:
102000 power train:manual transmission
Summary:
Grinding / rattle type noise coming from transaxle. *tt
Bulletin:
02T66
Component:
100000 power train
Summary:
Hiss / chirp noise in park or neutral. *tt
Bulletin:
02T65
Component:
162000 structure:body
Summary:
Liftgate outside handle gasket is protruding out between the handle and base. *tt
Bulletin:
02T52A
Component:
162000 structure:body
Summary:
Clunk pop or click noise when transitioning between acceleration and deceleration. *tt
Bulletin:
02T66A
Component:
103000 power train:automatic transmission
Summary:
Hiss / chirp noise in park or neutral. *tt
Bulletin:
02T78
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Excessive noise from (one speed) engine cooling fan at idle. *tt
Bulletin:
02T80
Component:
012000 steering:column
Summary:
Fluid dripping on driver's floormat. *tt
Bulletin:
02T81
Component:
103000 power train:automatic transmission
Summary:
Harsh garage shift, shift delay and / or double bump. *tt
Bulletin:
02T85
Component:
162300 structure:body:door
Summary:
Foam gasket material protruding out and around outside door handle base. *tt
Bulletin:
02T88
Component:
162000 structure:body
Summary:
Information on removal of luggage carrier rail assembly bolts strip out and / or heads break off when removing while installing ria luggage carriers. *tt
Bulletin:
02T89
Component:
103000 power train:automatic transmission
Summary:
2002 model year vt25e transaxle replacement with 2003 model year vt25e transaxle. *tt
Bulletin:
02T47A
Component:
020000 suspension
Summary:
Service manual update for 2002/2003 vue chassis service manuals regarding front and rear alignment specifications. *tt
Bulletin:
03T06
Component:
100000 power train
Summary:
Transaxle shifter cable whine noise. *tt
Bulletin:
03T08
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Inside rear view mirror compass will not display all 8 compass directions. *tt
Bulletin:
030850007
Component:
220000 seats
Summary:
Armrest angled down on front driver or passenger seat when seat is in upright position. *tt
Bulletin:
030601007
Component:
061000 engine and engine cooling:engine
Summary:
Buzzing, grinding, or growling noise or vibration from rear of vehicle when fuel pump is running. *tt
Bulletin:
030850009
Component:
220000 seats
Summary:
Front seat cushion cover lower edge loose due to broken cushion drawstring. *tt
Bulletin:
030139003
Component:
353600 equipment:air conditioner
Summary:
Insufficient air conditioner cooling during periods of high humidity. *tt
Bulletin:
030602002
Component:
060000 engine and engine cooling
Summary:
Insufficient heat, service engine soon (malfunction indicator lamp) telltale on, diagnostic trouble code p0128 set. *tt
Bulletin:
03T09
Component:
170000 latches/locks/linkages
Summary:
Due to a design change in the door and liftgate latching system, a second design latch kit is used to service first design 2002 and 2003 interim door and liftgate latching systems. *tt
Bulletin:
030604016
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding the engine control module (ecm) connector and terminal locations on saturn v6 engines. *tt
Bulletin:
030729001
Component:
102000 power train:manual transmission
Summary:
Shudder/vibration in reverse. *tt
Bulletin:
030604023
Component:
061000 engine and engine cooling:engine
Summary:
Intermittent whistle/chirp noise from engine compartment. *tt
Bulletin:
020601016A
Component:
061000 engine and engine cooling:engine
Summary:
(mil) service engine soon telltale illuminated with diagnostic trouble codes (dtc) p0171 and/or p0174. *tt
Bulletin:
030138002
Component:
160000 structure
Summary:
Condensation forming on the instrument panel (i/p) top cover and i/p accessory bezel. *tt
Bulletin:
020604021A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
The fuel gauge is displaying a false low reading or stuck on empty. this condition may be intermittent. a diagnostic trouble code p0461 - fuel level sensor performance may also be set in ecm memory. *tt
Bulletin:
030730013
Component:
103000 power train:automatic transmission
Summary:
Service manual update for vt25e (vti) transmission fluid pump pressure relief valve. *tt
Bulletin:
030941002
Component:
010000 steering
Summary:
Noise from upper steering column behind steering wheel. *tt
Bulletin:
030601014
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update regarding the use of saturn special tool j-42065 crank hub holding tool. *tt
Bulletin:
030601015
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update for removal of the sealer used on oil pump gasket during oil pump installation. *tt
Bulletin:
030730018
Component:
103000 power train:automatic transmission
Summary:
Enhanced automatic transaxle fluid fill procedure and plug location/ identification. *tt
Bulletin:
030848003
Component:
135100 visibility:rearview mirrors/devices:interior
Summary:
Inside rear view mirror compass will not display all 8 compass directions. *tt
Bulletin:
030730010
Component:
100000 power train
Summary:
Vt25e (vti) transaxle off-vehicle repair authorization. *tt
Bulletin:
030601017
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain design change and revised service procedures. *tt
Bulletin:
030730022
Component:
100000 power train
Summary:
Service manual update on transaxle oil cooler flushing procedure for vti transaxles. *tt
Bulletin:
030139003A
Component:
353600 equipment:air conditioner
Summary:
Insufficient air conditioner cooling during periods of high humidity. *tt
Bulletin:
030843003
Component:
136000 visibility:windshield wiper/washer
Summary:
Windshield washer nozzles do not spray washer fluid. *tt
Bulletin:
030308001
Component:
021000 suspension:front
Summary:
Squeak noise from front of vehicle. *tt *mj
Bulletin:
030729003
Component:
100000 power train
Summary:
Vibration with the transmission in park when parked on an incline. *tt
Bulletin:
030138010
Component:
138000 visibility:defroster/defogger system
Summary:
Defrost mode not clearing condensation in lower right and left corners of windshield. *tt
Bulletin:
030730026
Component:
100000 power train
Summary:
Service manual update - revised torque specification for vt23e (vti) transaxle variable driven pulley bearing retainer bolts. *tt
Bulletin:
030864020
Component:
133000 visibility:power window devices and controls
Summary:
Left front door power window will not go up or works intermittently. *tt
Bulletin:
030844010
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Six-disc radio will not load, eject and/or play compact discs (cds). *tt
Bulletin:
020729004A
Component:
100000 power train
Summary:
Idle vibration at idle and/or clunk at start-up. *tt
Bulletin:
020308005A
Component:
021000 suspension:front
Summary:
Service information regarding front suspension struts and front stabilizer bar links service parts update. *tt
Bulletin:
030845003C
Component:
110000 electrical system
Summary:
Reduced vehicle power, no transaxle down shift, ses light on, buzz noise from door speakers/speakers inoperative, heater blower motor inoperative, various diagnostic trouble codes (dtc) set. *tt
Bulletin:
030601021
Component:
061000 engine and engine cooling:engine
Summary:
Crank no start after backfire or rough run/high idle after engine start. *tt
Bulletin:
030845002
Component:
110000 electrical system
Summary:
Revised 2.2l engine control module j1 & j2 connector face diagram. *tt
Bulletin:
030844017
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Changes to the am/fm stereo and audio disc player radio on-board diagnostic modes and cd load operation. *tt
Bulletin:
030604043
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) service engine soon telltale lamp on, reduced power lamp may illuminate with diagnostic trouble codes p0121, p0221, and/or p2135. *tt
Bulletin:
030852007
Component:
350000 equipment
Summary:
Remote keyless entry (rke) transmitter range poor. *tt
Bulletin:
030089033A
Component:
980000 unknown or other
Summary:
Trailer, recreational and disabled vehicle towing information. *tt *sc
Bulletin:
030844019
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Low volume ticking noise, radio volume resolution or cd will not load/eject. *tt
Bulletin:
030089032
Component:
980000 unknown or other
Summary:
Recreational and disabled vehicle towing information. *tt
Bulletin:
030730048
Component:
106000 power train:axle assembly
Summary:
Service information regarding transaxle poor performance after case cover replacement, diagnostic trouble code p1882 set. *tt
Bulletin:
030090003
Component:
061000 engine and engine cooling:engine
Summary:
Oil filter cap assembly and oil filter element design change. *tt
Bulletin:
030138017
Component:
353600 equipment:air conditioner
Summary:
Service manual update - revised air conditioning compressor does not operate (chart 6 ) diagnostic flow chart. *tt
Bulletin:
030729007
Component:
102000 power train:manual transmission
Summary:
Service information regarding design change to the manual transmission shift control housing and the manual transmission select and shift lever cables. *tt
Bulletin:
010418001C
Component:
100000 power train
Summary:
Driveline characteristics for all-wheel drive (awd) and four-wheel drive (4wd) systems. *tt updated *eh
Bulletin:
030138014
Component:
353600 equipment:air conditioner
Summary:
Service manual update for air conditioning evaporator temperature sensor performance - chart 11. *tt
Bulletin:
030730041
Component:
103000 power train:automatic transmission
Summary:
Service manual update for vt25e (vti) transmission front differential carrier thrust washer. *tt
Bulletin:
030089025
Component:
980000 unknown or other
Summary:
Clarification of labor codes used for reprogramming vehicle controllers. various models including the 2004 l-series. *tt
Bulletin:
030730034
Component:
100000 power train
Summary:
Revision to second coast clutch disassemble/assemble procedure. *tt
Bulletin:
030234002
Component:
010000 steering
Summary:
Squeak or squeal noise while turning vehicle. *tt
Bulletin:
030730055
Component:
100000 power train
Summary:
Service information regarding 2002 and 2003 model year vt25e transaxle replacement with 2004 model year vt25e transaxle. *tt
Bulletin:
030730049
Component:
160000 structure
Summary:
Speedometer fluctuation. *tt
Bulletin:
03065
Component:
061000 engine and engine cooling:engine
Summary:
On-board diagnostic (obd) system software upgrade. *tt
Bulletin:
030524001
Component:
034410 service brakes, hydraulic:foundation components:drum:wheel cylinders
Summary:
Service information regarding saturn rear drum wheel cylinder inspections. *tt update. *tt
Bulletin:
030137003
Component:
353600 equipment:air conditioner
Summary:
Inoperative hvac rear defrost, recirc, or air condition (ac) mode switches and/or reduced or no airflow from vents. *tt
Bulletin:
030844016A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Compact discs (cds) skip in single cd player. *tt
Bulletin:
010104
Component:
110000 electrical system
Summary:
Speedometer fluctuation. *tt
Bulletin:
040601001
Component:
061000 engine and engine cooling:engine
Summary:
Oil leaks from engine after sub-freezing temperatures. *tt
Bulletin:
030730023A
Component:
103000 power train:automatic transmission
Summary:
Vehicle does not shift or move after running for a period of time and/or check engine light is on and dtc p0741 is set. *ph *sc
Bulletin:
030842013
Component:
121000 exterior lighting:headlights
Summary:
Headlamp assembly lens with hazy or cloudy cosmetic appearance. *ph
Bulletin:
020235008A
Component:
012000 steering:column
Summary:
Fluid dripping on driver's floormat. *ph
Bulletin:
030730052A
Component:
103000 power train:automatic transmission
Summary:
Engine flare during 2-3 shift, most noticeable during light to moderate acceleration. the condition may be caused by aeration of transaxle fluid, resulting in a delayed apply of 3rd clutch. corporate bulletin number 03-07-30-052 *m
Bulletin:
040730011
Component:
100000 power train
Summary:
Anaerobic sealant application requirements for vt25e transaxle. service manual update. *tt *mj
Bulletin:
040864006
Component:
162000 structure:body
Summary:
Wind and/or whistle noise coming from the outside rearview mirror. *tt
Bulletin:
040601004
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding engine support during removal of right front engine mount assembly. *tt
Bulletin:
040863003
Component:
176100 latches/locks/linkages:hood:latch
Summary:
Service manual update - hood opening procedure for inoperative hood latch. *tt
Bulletin:
040604008
Component:
060000 engine and engine cooling
Summary:
Service engine soon (ses) lamp illuminated with dtc p0135 ho2s heater circuit performance bank 1 sensor 1 and/or dtc p0155 ho2s heater performance bank 2 sensor 1. *mr this bulletin replaces previous 04-06-04-008. *eh
Bulletin:
040420001
Component:
106000 power train:axle assembly
Summary:
Drone noise between 50-75 mph (80-120 km/h). *mr
Bulletin:
040235006
Component:
012000 steering:column
Summary:
Rattle noise from steering column. *mr
Bulletin:
04020
Component:
106000 power train:axle assembly
Summary:
Special policy adjustment - extended transmission warranty coverage for the variable transmission with intelligence (vti) transmission. *mr
Bulletin:
040089012
Component:
980000 unknown or other
Summary:
Saturn field product reminder- vehicle fix it right the first time issues, parts restriction information and technical bulletins released in january, february, and march 2004. *mr
Bulletin:
040420002
Component:
105500 power train:driveline:differential unit
Summary:
Service manual update for rtv sealant usage on the rear drive module. *tt
Bulletin:
040601009
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak from front cover seal during extremely cold weather. *tt
Bulletin:
040601010
Component:
061000 engine and engine cooling:engine
Summary:
Blue smoke at engine start-up. *tt
Bulletin:
040601011
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update for engine block clearance, cylinder head clearance and fastener torque specifications. *tt
Bulletin:
040604033
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light on with p0440 or p0442 stored. *tt this bulletin replaces previous bulletin dated 05/01/2004. *tt
Bulletin:
040137006
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Heater-ventilation-air conditioning (hvac) hiss-type noise. *mr
Bulletin:
01802A
Component:
110000 electrical system
Summary:
App sensor 2 and/or tp sensor 2 signal circuit voltages drop. *tt
Bulletin:
040730024A
Component:
100000 power train
Summary:
No movement in drive or reverse with or without diagnostic trouble codes (dtcs) p1758, p1758, p1882, p0841, p0741, p0742. *mj this bulletin replaced previous 04-07-30-024. *tt
Bulletin:
040846001
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Service support and technical assistance for onstar and/or xm radio. *mj
Bulletin:
040605009
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding a pop/clunk noise from the rear of the vehicle on initial cold start and/or during the warm-up drive cycle. *tt
Bulletin:
040844015
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Return form for compact discs (cds) or digital versatile discs (dvds) that are stuck in cd player when returned as a core return. *tt
Bulletin:
040417002
Component:
100000 power train
Summary:
Vibration felt in seatback or armrest at vehicle speeds between 48 to 89 km/h (30 to 55 mph). *tt
Bulletin:
040730036
Component:
100000 power train
Summary:
Revised vt25e (vti) spacer plate available. *tt
Bulletin:
3034
Component:
100000 power train
Summary:
No reverse after case cover assembly replaced. *tt
Bulletin:
3035
Component:
100000 power train
Summary:
No forward or reverse gears or line pressure after a valve body replacement on a vt25e transaxle. *tt
Bulletin:
3122
Component:
034300 service brakes, hydraulic:foundation components:differential proportional valve
Summary:
Delay into reverse or no reverse after valvebody replacement. *sc
Bulletin:
3116
Component:
060000 engine and engine cooling
Summary:
Ses illuminated engine miss/misfire feel or rough idle. *sc
Bulletin:
3119
Component:
980000 unknown or other
Summary:
No selection fir saturn when programming a saturn vehilcle. *sc
Bulletin:
3135
Component:
060000 engine and engine cooling
Summary:
Pop noise from engine area during heavy throttle input. *tc
Bulletin:
3117
Component:
060000 engine and engine cooling
Summary:
Rear toe cam adjustment nut for service applications. *sc
Bulletin:
040138007
Component:
138000 visibility:defroster/defogger system
Summary:
Information on proper mode switch setting (between defrost and heater/defrost) to prevent window moisture and hvac controller assembly logic revision. *tt
Bulletin:
040603007
Component:
061000 engine and engine cooling:engine
Summary:
Crank no start, hard start, stalling, or front lamps intermittently inoperative setting any of the following diagnostic trouble codes (dtcs) - p0629, b2752, b3722, n3717, b2717, b2600, b2722. *tt
Bulletin:
040604074
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) and/or reduced power lamp illuminated, limited throttle response following cold engine start up, diagnostic trouble code (dtc) p0638. *tt
Bulletin:
04067
Component:
022000 suspension:rear
Summary:
Replacement of rear lateral link assemblies. *tt parts update. *tt message update. *tt
Bulletin:
3400
Component:
100000 power train
Summary:
Vibration from 30 mph or faster felt in the drivers seat or floorboard area. *tt
Bulletin:
07012004
Component:
355200 equipment:other:owners/service/other manual
Summary:
Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
Bulletin:
050730004
Component:
103000 power train:automatic transmission
Summary:
Intermittent no movement in drive or reverse with or without diagnostic trouble codes. *eh
Bulletin:
050730006
Component:
110000 electrical system
Summary:
Service engine soon telltale illuminated with diagnostic trouble code p0742. *eh
Bulletin:
701
Component:
090000 fuel system, other
Summary:
Fuel filter replacement. gm tech link. *tt
Bulletin:
3690
Component:
036000 service brakes, hydraulic:antilock
Summary:
Anti-lock braking system (abs) light on diagnostic trouble code (dtc) c0551 after replacing the ebcm. *tt
Bulletin:
040843008
Component:
355200 equipment:other:owners/service/other manual
Summary:
Service manual update-wiper/washer systems schematics. *sc
Bulletin:
3433
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3. *tt updated 08-15-07. *kb
Bulletin:
3251
Component:
100000 power train
Summary:
Transaxle slips, no third gear, engine flare during shift after transaxle service. *sc
Bulletin:
050309004
Component:
022000 suspension:rear
Summary:
Rear suspension torque specifications. *tt
Bulletin:
050523005
Component:
030000 service brakes, hydraulic
Summary:
Rattle noise from front of vehicle at slow speeds on rough surfaces when brake pedal is not applied. *tt
Bulletin:
050730003
Component:
100000 power train
Summary:
Intermittent hesitation during vehicle launch. *tt
Bulletin:
050308003
Component:
020000 suspension
Summary:
Service manual update - lower control arm ball stud nut torque specification changes. *tt
Bulletin:
050308011
Component:
020000 suspension
Summary:
Information on identifying proper design level and torque spec change for front lower control arm. *tt
Bulletin:
050604059
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Fuel nozzle shuts off intermittently or prematurely during fuel fill and/or ses lamp on with dtc p0446 evap vent system performance set. *tt
Bulletin:
3633
Component:
103000 power train:automatic transmission
Summary:
Remanufactured vt25e transmission quality issues. inoperative, noise, slip, low pressure or leak related concern. *tt
Bulletin:
3648
Component:
114100 electrical system:wiring:front underhood
Summary:
Hesitation on acceleration after internal engine repairs - check injector harness orientation. *tt
Bulletin:
060232002
Component:
010000 steering
Summary:
Normal operating characteristics of electric power steering (eps) system during extended lock-to-lock (maximum steering wheel rotation) usage. *tt updated 3/30/11. *pe
Bulletin:
060730001
Component:
103000 power train:automatic transmission
Summary:
Transmission fluid leak from right hand axle seal area. *tt
Bulletin:
3859
Component:
061000 engine and engine cooling:engine
Summary:
Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj
Bulletin:
4014
Component:
980000 unknown or other
Summary:
Parts update - timing chain tensioner design change. *kb
Bulletin:
03-00-89-033
Component:
980000 unknown or other
Summary:
Trailer, recreational and disabled vehicle towing information. *kb updated 08-15-07. *kb updated 10/09/07. *nj updated 4/3/08. *nj
Bulletin:
07-08-42-002
Component:
120000 exterior lighting
Summary:
Daytime running lamps (drl) inoperative (inspect/replace drl resistor). *kb updated 7/11/08. *nj
Bulletin:
070235001
Component:
010000 steering
Summary:
Information on servicing vehicles using new ignition start switch housing (ignition lock module) without steering column lock. *kb
Bulletin:
07251
Component:
116200 electrical system:ignition:module
Summary:
Saturn service campaign: see document search button for owner letter. ignition control module - replace on vehicles equipped with 2.2l 4 cylinder (rpo l61 - vin d) engine. csc was received. *nj
Bulletin:
08-089
Component:
353000 equipment:electrical
Summary:
Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin:
08089-B
Component:
110000 electrical system
Summary:
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin:
SB-09280A
Component:
103000 power train:automatic transmission
Summary:
Saturn service campaign: see document search button for owner letter. new special reimbursement policy for vehicles equipped with variable transmission with intelligence (vti) transmission-50 percent of transmission repair cost will be pai
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
PIP-4495C
Component:
061000 engine and engine cooling:engine
Summary:
Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm
Bulletin:
SB-10-08-50-003B
Component:
221300 seats:front assembly:head restraint
Summary:
General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
Bulletin:
14506
Component:
116000 electrical system:ignition
Summary:
Summary to be provided on a future date.
Bulletin:
14506A
Component:
116000 electrical system:ignition
Summary:
Summary to be provided on a future date.
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
14319A
Component:
103000 power train:automatic transmission
Summary:
14319a - special coverage (revised model year vehicles). some 2005-2006 model year (my) chevrolet equinox, 2006 my pontiac torrent and 2002-2007 my saturn vue vehicles may have a condition in which the ignition key may be removed when the
Bulletin:
PIC3278F
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIP5226A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIP5029G
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
Bulletin:
PIC5492E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have a diagnostic trouble code b101d-37 history in the vehicle communication interface module or telematics communication interface contro
Bulletin:
PIT3099L
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIT4864F
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about a customer?s request to install onstar bluetooth. dealer should be advised at this time, there are no provisions to add this option to vehicles that wer
Bulletin:
PIT5264
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicles that when a canadian customer may comment that when they travel to the united states, they are unable to connect to onstar or use hands free ca
Bulletin:
PIC5453A
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician that general motors and general motors of canada company do not support cross border sales. the general motors of canada customer care centre is the sole auth
Bulletin:
PIT4943C
Component:
030000 service brakes, hydraulic
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0442. technician will need to review t
Bulletin:
PIC3011H
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicles that have the onstar system does not respond properly to some numbers and/or voice commands. dealer should direct the customer to review the op
Bulletin:
PIP3140F
Component:
350000 equipment
Summary:
This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. technician should look for non - general motors a
Bulletin:
PIC5953
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIP5163A
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIC4310J
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC5959B
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicle that has no xm audio on certain channels but xm channel info is displayed. technician will need to contact xm and deactivate and activate the mo
Bulletin:
PIT3099M
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIP5226
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIP5163
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIT3099J
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory parts. technician can check service information for some accessories. technician can also contact partech for assist
Bulletin:
PIC4935D
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar
Bulletin:
PIT4907A
Component:
030000 brakes (pws)
Summary:
This preliminary information communication provides information to the technician about brake rotors on new vehicles and replacement parts from general motors service parts operations. technician should be advised the costing should not be
Bulletin:
PIP3720D
Component:
106000 power train:axle assembly
Summary:
This preliminary information communication provides information to the technician with the axel setup information from american axle manufacturing. technician should be advised that the maximum pinion shim to be used or stacked behind the p
Bulletin:
PIC4310H
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT3173C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. dealer should send the correc
Bulletin:
PIC3718E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles may have a no power or no connect concern. technician will find that the onstar led is red and diagnostic trouble code u1500 is set. technician
Bulletin:
08-07-30-026C
Component:
113000 electrical system:starter assembly
Summary:
This informational bulletin provides information on vehicles may rock or move slightly forward or rearward while in park at start up after cold soak and that this is considered a normal conditon and no repairs are necessary
Bulletin:
PIP5094
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician that, when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of
Bulletin:
PIP3140E
Component:
350000 equipment
Summary:
This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. technician should look for non - general motors a
Bulletin:
PIT3117H
Component:
354000 equipment:mechanical
Summary:
This preliminary information communication provides information to the technician of part numbers that are missing from the service information documents. the following part numbers are for a cam nut that is available to adjust the rear to
Bulletin:
PIT4720C
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician that after replacing the instrument panel cluster the exchange center is unable to program the actual mileage on the odometer or the actual mileage is unknown
Bulletin:
PIC5904
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that the onstar system will not connect. technician should record module info per the latest version of pic4310 and contact general motors tech
Bulletin:
PIT3099K
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partech for assista
Bulletin:
PIP5338A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
Bulletin:
PIP5029H
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
Bulletin:
PIC5588C
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
PIC3278G
Component:
010000 steering
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIC4801H
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have an onstar turn-by-turn navigation the system that is inoperative. technician verifies there are no diagno
Bulletin:
PIP4723B
Component:
118000 electrical system: software
Summary:
This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
Bulletin:
PIC4935F
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIT5389C
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
02-08-42-001H
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
Bulletin:
15-08-44-001B
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
05-06-04-035E
Component:
090000 fuel system, other
Summary:
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:
15-08-44-001C
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-73-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
05-08-46-006T
Component:
110000 electrical system
Summary:
This informational bulletin provides information to dealership personnel on upgrading certain onstar analog/digital-ready systems to onstar generation 6 digital-capable system.
Bulletin:
09-09-40-001C
Component:
150000 seat belts
Summary:
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
Bulletin:
11-00-89-005C
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
PIP5232C
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIC6181
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician after the onstar canada upgrade the onstar vehicle diagnostic email report is inoperative. please communicate to the customer that we apologize for this inconvenience and tha
Bulletin:
11-00-89-005H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty bulletin clarifies the use of dealer empowerment to satisfy the customer.
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC3278F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC5953A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT5399
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
Bulletin:
PIT3117J
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician of part numbers that are missing from the service information documents. the following part numbers are for a cam nut that is available to adjust the rear to
Bulletin:
PIT5264B
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIP5029F
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
Bulletin:
PIT5353
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIT5389B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to contact general motors t
Bulletin:
PIP5163B
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leaka
Bulletin:
PIT3099N
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIP5338
Component:
020000 suspension
Summary:
This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
Bulletin:
PIC5953B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIT4943D
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0442. technician will need to review t
Bulletin:
PIT5353A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIT5486
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicles that when dialing certain numbers using onstar hands-free calling, the audio is distorted or has poor quality after performing the onstar canad
Bulletin:
PIC6101
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that are unable to receive onstar hands free calling calls and or the onstar center is unable to perform remote services. technician will need
Bulletin:
PIT5384A
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that may have the onstar wireless fidelity inoperative. technician will need to contact general motors technical assistance center with a scan
Bulletin:
PIC6107
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about being unable to receive onstar ?over the air? updates. technician will need to press the onstar button and verify they have an active account and that t
Bulletin:
PIC3100E
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odometer. i
Bulletin:
PIP5232B
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
03-08-46-004S
Component:
118000 electrical system: software
Summary:
This informational bulletin provides information on onstar® vcim is currently restricted parts. by working closely with our dealers and technicians, through the part restriction process, the general motors team will gain a better understand
Bulletin:
10-00-89-006F
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information for dealers how to submit a product information report.
Bulletin:
01-08-42-001K
Component:
121000 exterior lighting:headlights
Summary:
This informational bulletin provides information on exterior lamp condinsation and replacement guidelines
Bulletin:
02-08-42-001I
Component:
121000 exterior lighting:headlights
Summary:
This informational bulletin provides an out line on headlamp, tail lamp, license lamp or fog/driving lamp damage and what should be considered warranty replacement and not
Bulletin:
11-00-89-005I
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm (u.s. only)
Bulletin:
PIT3099P
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIC5588D
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
11-00-89-005B
Component:
356000 equipment adaptive
Summary:
This warranty administrational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm
Bulletin:
PIP4495E
Component:
162800 structure:body:hood
Summary:
This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Bulletin:
PIT5353B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIC3100F
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odomete
Bulletin:
PIC5588B
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
PIC5088E
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about vehicles that may not receiving all channels on the xm band. technician will need to use a scan tool and verify current digital radio receiver status un
Bulletin:
080846004A
Component:
118000 electrical system: software
Summary:
This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.
Bulletin:
000089027G
Component:
350000 equipment
Summary:
This informational bulletin provides a step by step procedure on how to properly use the gm chemicals to eliminate unwanted odors in vehicles and which products to use for each application.
Bulletin:
100089010B
Component:
350000 equipment
Summary:
This informational bulletin provides information and rules for gm keycode look up applicationa dn the key code security rules and regulations for canada only.
Bulletin:
010089010J
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides a single point reference and strategy document to aid in reducing customer comebacks, and the possibility of buyback situations by outlining specific guidelines, strategy and forms that will assist with
Bulletin:
030848006J
Component:
138000 visibility:defroster/defogger system
Summary:
This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.
Bulletin:
PIC5088E
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary bulletin provides procedures on how to reset or refresh the xm radio receiver is the customers states that they only get a few channels.
Bulletin:
PIP3535C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. dealers
Bulletin:
PIP5325
Component:
070000 fuel system, gasoline
Summary:
This preliminary information communication provides information to the technician to help determine if the vehicle is equipped with factory or aftermarket compressed natural gas, liquefied petroleum gas, or bi-fuel systems. technician will
Bulletin:
PIT5464
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that the incoming caller id may no longer be available or displayed after the canada onstar upgrade. dealer should communicate to the customer
Bulletin:
PIP5540
Component:
350000 equipment
Summary:
This preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. to allow the ice to melt so that it can be drained from the related component
Bulletin:
PIP5540A
Component:
060000 engine (pws)
Summary:
This preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. to allow the ice to melt so that it can be drained from the related component
Bulletin:
PIP5226B
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
10-00-89-009B
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on key code security and information on gm key code look up applications.
Bulletin:
10-00-89-010C
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on key codes security rules and information on gm key code look up application.
Bulletin:
99-04-20-002H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides a revision of 99-04-20-002g to add 2013-2014 model years.
Bulletin:
13-00-89-005
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides warranty administration - new labor codes information.
Bulletin:
05-00-89-072C
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.
Bulletin:
10-00-89-006C
Component:
284300 back over prevention: sensing system: radar
Summary:
This informational bulletin provides directions on submitting different pirs
Bulletin:
00-03-10-002G
Component:
200000 wheels
Summary:
This informational bulletin provides information on the appearance of chromed aluminum wheels due to chemical staining, pitting corrosion and/or spotted.
Bulletin:
11-00-89-005D
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provide policy information on clarification of use-dealer empowerment labor operations and customer enthusiasm.
Bulletin:
02-08-42-001G
Component:
350000 equipment
Summary:
This informational bulletin is to assist with the identification of issues that are not considered warrantable.
Bulletin:
01-08-42-001J
Component:
120000 exterior lighting
Summary:
This informational bulletin explains condensation in exterior lights and replacment guidelines for warranty replacement.
Bulletin:
PIC6036
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicles that show an error message when a media disc is installed. technician will need to check the regular production option code list to verify if t
Bulletin:
PIP5232
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIT5264A
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIP5232A
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIT5099A
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
Bulletin:
15-08-73-001
Component:
110000 electrical system
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
05-08-46-006T
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This informational bulletin provides information to dealership personnel on upgrading certain onstar analog/digital-ready systems to onstar generation 6 digital-capable system.
Bulletin:
10-08-64-002B
Component:
350000 equipment
Summary:
This warranty administration bulletin provides information on what should be considerd warranty damage or damage that was at fault of the cutomer and how to properly claim them on the warranty paperwork
Bulletin:
10-00-89-010B
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This informational bulletin provides information and rules for gm keycode look up applicationa dn the key code security rules and regulations for canada only.
Bulletin:
06-00-89-026J
Component:
350000 equipment
Summary:
This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. also provides information on how to submit claims within the gl
Bulletin:
12-03-10-002
Component:
200000 wheels
Summary:
This informational bulletin provides a description of the proper wheel installation and proper wheel torque techniques used to install wheels onto vehicles
Bulletin:
16-NA-383
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
Bulletin:
PIP5163C
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
10-00-89-006E
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
10-00-89-006D
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
00-00-89-027H
Component:
353600 equipment:air conditioner
Summary:
This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
Bulletin:
00-06-01-012E
Component:
350000 equipment
Summary:
This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
05-08-46-006S
Component:
118000 electrical system: software
Summary:
This informational bulletin advises the technician to update the onstar from an analog system to a digital system if the customer wishes.
Bulletin:
15-08-73-001A
Component:
118000 electrical system: software
Summary:
This informational bulletin explains how to update the older onstar module software to new software over gsa.
Bulletin:
10-08-64-002B
Component:
350000 equipment
Summary:
This warranty administration bulletin provides information on what should be considerd warranty damage or damage that was at fault of the cutomer and how to properly claim them on the warranty paperwork
Bulletin:
10-00-89-010B
Component:
350000 equipment
Summary:
This informational bulletin provides information and rules for gm keycode look up applicationa dn the key code security rules and regulations for canada only.
Bulletin:
06-00-89-026J
Component:
350000 equipment
Summary:
This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. also provides information on how to submit claims within the gl
Bulletin:
12-03-10-002
Component:
200000 wheels
Summary:
This informational bulletin provides a description of the proper wheel installation and proper wheel torque techniques used to install wheels onto vehicles
Bulletin:
11-00-89-005C
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
10-00-89-006D
Component:
355200 equipment:other:owners/service/other manual
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
00-00-89-027H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
Bulletin:
00-06-01-012E
Component:
355200 equipment:other:owners/service/other manual
Summary:
This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
Bulletin:
05-08-48-001C
Component:
350000 equipment
Summary:
This informational bulletin provides a revision for 05-08-48-001b to add 2010-2014 model years and update labor operation.
Bulletin:
08-06-01-006D
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information for engine squealing type noise on start-up or vibration condition.
Bulletin:
11-00-89-005E
Component:
350000 equipment
Summary:
This informational bulletin provides a revision for 11-00-89-005d to add additional mandatory minimum tables and additional information concerning policy decision making.
Bulletin:
PI1394
Component:
060000 engine and engine cooling
Summary:
This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
Bulletin:
10-08-45-001E
Component:
110000 electrical system
Summary:
This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
Bulletin:
10-00-89-006D
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
00-00-89-027H
Component:
350000 equipment
Summary:
This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
Bulletin:
00-06-01-012E
Component:
060000 engine (pws)
Summary:
This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
Bulletin:
PIT5399A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
Bulletin:
PIC4696C
Component:
150000 seat belts
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
10-00-89-006E
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
PIP4495F
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Bulletin:
PIT5099C
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
Bulletin:
PIP5163D
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIT5099D
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
Bulletin:
PIP5601
Component:
350000 equipment
Summary:
This preliminary information communicates

Home | Privacy