2002 SATURN LS Recalls (3)

Campaign:
03V231000 on 06/22/2003
Component:
Electrical system:ignition:module
Manufactured:
07/30/2000 - 06/10/2001
Affected:
239,993
Defect:
On certain passenger vehicles equipped with 2.2l l4 (l61) engines, a failure of the ignition control module may cause deterioration in idle quality, reduction in overall engine power, and the vehicle may be hard to start. continued operation of the vehicle after such an ignition module failure will result in the "service engine soon" light flashing, and may lead to secondary failures of the catalytic converter, oxygen sensor, and exhaust resonator.
Consequence:
Failure of the resonator will cause increased exhaust noise. prolonged operation of the vehicle following a resonator failure may lead to a fire.
Correction:
Dealers will (1) replace the ignition control module, (2) replace the ignition control module and spark plugs, or (3) replace the ignition control module, spark plugs, and update the powertrain control module calibration. owner notification began on august 4, 2003. owners should contact saturn at 1-800-553-6000, prompt 3.
Notes:
Gm recall no. 03033/saturn recall no. 03-c-06.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V158000 on 04/19/2005
Component:
Seat belts
Manufactured:
05/31/2001 - 06/29/2002
Affected:
20,701
Defect:
Certain wagons fail to comply with the requirements of federal motor vehicle safety standard no. 210, "seat belt assembly anchorages." the seat belt anchor may separate from the floor of the vehicle before holding the required test load for the required time.
Consequence:
If a separation occurred in crash, the right and center rear seat occupants may not be properly restrained, increasing the risk of personal injury.
Correction:
Dealers will install a rear seat center belt anchor reinforcement plate to the floor pan of the vehicle free of charge. the recall began on april 25, 2005. owners may contact saturn at 1-800-972-8876.
Notes:
Gm recall no. 05041. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V245000 on 06/01/2005
Component:
Exterior lighting:brake lights
Manufactured:
04/30/2001 - 06/29/2002
Affected:
291,652
Defect:
On certain sedans and wagons, the plastic housing in the rear tail lamp assembly can become distorted if the brake lamps remain on for an extended time.
Consequence:
This can cause (1) an intermittently inoperative brake/tail lamp bulb or (2) a short circuit that opens a fuse causing inoperative brake lamps (including the center high-mounted stop lamp) or tail lamps. a following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning.
Correction:
Dealers will install two new tail lamp reinforcing socket adapters and sockets free of charge. the recall began on october 17, 2005. owners may contact saturn at 1-800-972-8876.
Notes:
Gm recall no. 05052.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2002 SATURN LS TSBs (178)

Bulletin:
01I04
Component:
190000 tires
Summary:
Service information on california vehicle code requirements regarding 2002 modelyear tire chain disclosure for various models including saturn vue. *tt
Bulletin:
01T34
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Information on front brake rotor minimum thickness after refinish and discard thickness specifications. *tt
Bulletin:
00T41A
Component:
162000 structure:body
Summary:
Some customers may comment about water leaking into the passenger compartment and / or rear compartment / rear cargo area. *tt
Bulletin:
01T06A
Component:
162000 structure:body
Summary:
Concerns that the rear fascia to quarter panel is not correctly aligned. *tt
Bulletin:
01T38
Component:
350000 equipment
Summary:
Subject regarding service manual update for certain vehicle's body / electrical volume ii service manuals regarding am / fm stereo with cassette and cd player check charts. *tt
Bulletin:
00T17B
Component:
980000 unknown or other
Summary:
Some customers may comment about the headliner sagging orh anging too low at the rear of the sunroof opening. *tt
Bulletin:
99T36A
Component:
162000 structure:body
Summary:
Customers may comment about a rattle type noise that seems to be coming from rear of vehicle when traveling over rough road surfaces. *tt
Bulletin:
99Y69N
Component:
162000 structure:body
Summary:
Experiencing rattle noises heard in area of dome lamp, sunroof, orheadliner duringnormal operating conditions. *tt
Bulletin:
01T39
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding redesigned oil filter element and oil filter cap. *tt
Bulletin:
01T36
Component:
355100 equipment:other:labels
Summary:
Information regarding installation procedures for correct placement of model badges on rear decklid liftgates. *slc
Bulletin:
00T17B
Component:
162000 structure:body
Summary:
Customers may complain of headliner sagging or hanging too low at the rear of the sunroof opening. *slc
Bulletin:
00T41A
Component:
162000 structure:body
Summary:
Customers may complain of water leaking into the passenger compartment and/or rear compartment cargo area. *slc
Bulletin:
01T06A
Component:
162200 structure:body:bumpers
Summary:
Customers may complain that the rear fascia to quarter panel is not correctly aligned. *slc
Bulletin:
01T38
Component:
980000 unknown or other
Summary:
Service manual revision regarding body/electrical volume ii. *slc
Bulletin:
99T36A
Component:
022000 suspension:rear
Summary:
Customers may complain of a rattle type noise that seems to be coming from rear of vehicle when traveling over rough road surfaces. *slc
Bulletin:
99T69B
Component:
980000 unknown or other
Summary:
Some customers may complain of rattle noises heard in area of dome lamp, sunroof, or headliner during normal operating conditions. *slc
Bulletin:
01T40
Component:
980000 unknown or other
Summary:
Information regarding 1st and 2nd design oil filter elements and oil filter caps available for the 4 cylinder engine and how to determine which oil filter and cap combination should be used. *slc
Bulletin:
01T37
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Some customers may complain of the service engine soon lamp illuminating with p0116 or p1683 set in pcm history. *slc
Bulletin:
01T34
Component:
980000 unknown or other
Summary:
Information regarding front brake rotor minimum thickness after refinish and discard thickness specificatons. *slc
Bulletin:
01T49
Component:
980000 unknown or other
Summary:
Subject regarding outside air temperature sensor service procedure. *jg
Bulletin:
01T50
Component:
980000 unknown or other
Summary:
Information regarding service manual updates, engine service manuals, and body/electrical volume ii service manuals. *jg
Bulletin:
01T52
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Subject regarding rattle noise from rear of vehicle while driving. *jg
Bulletin:
01T51
Component:
116000 electrical system:ignition
Summary:
Subject regarding new ignition lock cylinder design and new key codes for ignition lock cylinder and key cuts. *jg
Bulletin:
01I10
Component:
136000 visibility:windshield wiper/washer
Summary:
Subject regarding change in production window washer solvent. *jg
Bulletin:
01T36
Component:
355100 equipment:other:labels
Summary:
Subject regarding placement of vehicle model badges on decklid applique or liftgate. *jg
Bulletin:
01T57
Component:
151100 seat belts:front:anchorage
Summary:
Subject regarding incorrect part number and repositioning instruction stamped on sir roll coil connector. *jg
Bulletin:
01T58
Component:
103000 power train:automatic transmission
Summary:
Service manual regarding solenoid circuit schematic, input speed sensor performance, and input speed sensor circuit low voltage schematics. *jg
Bulletin:
01T56
Component:
980000 unknown or other
Summary:
Subject regarding service manual update for engine service manuals regarding diagnostic troble codes and flowcharts. *jg
Bulletin:
01T55
Component:
980000 unknown or other
Summary:
Service manual update for engine service manuals regarding cruise control diagnostics. *jg
Bulletin:
01T52
Component:
036000 service brakes, hydraulic:antilock
Summary:
Subject pertaining to a rattle noise from rear of vehicle while driving, vehicles equipped with rear antilock disc brakes.*jb
Bulletin:
00T66A
Component:
060000 engine and engine cooling
Summary:
Information regarding engine oil leaks and/or engine coolant leaks, on v-6 engines.*jb
Bulletin:
01T57
Component:
116000 electrical system:ignition
Summary:
Subject pertaining to incorrect part number and repositioning instruction stamped on sir roll coil connector.*jb
Bulletin:
00T66A
Component:
060000 engine and engine cooling
Summary:
Information regarding engine oil leaks and or engine coolant leaks. *yh
Bulletin:
02T03
Component:
353600 equipment:air conditioner
Summary:
Subject regarding automatic climate control system overcompensation and excessive electric parasitic draw (install updated automatic climate control module calibration) *jg
Bulletin:
00T17C
Component:
134000 visibility:sun roof assembly
Summary:
Some customers may comment about the headliner sagging or hanging too low at the rear of the sunroof opening. *jg
Bulletin:
02T03
Component:
353600 equipment:air conditioner
Summary:
Subject regarding automatic climate control system overcompensation and excessive electric parasitic draw (install updated automatic climate control module calibration). *jg
Bulletin:
01T01A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment about a vibration or boom noise inside the vehicle while at idle and the air conditioner is on. *jg
Bulletin:
00T17C
Component:
980000 unknown or other
Summary:
Subject regarding headliner sags or hangs too low at rear of sunroof opening. *yd
Bulletin:
SB-020842001B
Component:
121000 exterior lighting:headlights
Summary:
General motors vehicles and trucks: subject regarding, 2002 and prior passenger cars and trucks, chemical damage to exterior polycarbonate headlamp lenses. *slc updated *eh updated 3/30/11. headlamp lens overheating when cov
Bulletin:
02T18
Component:
110000 electrical system
Summary:
Subject regarding onstar system unable to send or receive cellular phone calls.*jb
Bulletin:
02T17
Component:
980000 unknown or other
Summary:
Information on service engine soon lamp illuminated.*jb
Bulletin:
99T55B
Component:
010000 steering
Summary:
Some vehicles may experience steering wheel shake or vibration at highway speeds.*jb
Bulletin:
02C07
Component:
100000 power train
Summary:
Subject regarding inaccurate odometer reading after loss of battery power.*jb
Bulletin:
02T23
Component:
341000 communications:horn assembly
Summary:
Concerns with muffled tone or intermittent low or no tone horn.*jb
Bulletin:
02T22
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding whistle noise under certain engine operating conditions.*jb
Bulletin:
02T27
Component:
131000 visibility:windshield
Summary:
Customers may complain of rear door glass being inoperative or operates erractically.*jb
Bulletin:
02T05
Component:
220000 seats
Summary:
Service manual update regarding front seat cushion cover/pad removal and installation. *slc
Bulletin:
02T06
Component:
021000 suspension:front
Summary:
Service manual update for chassis service manuals regarding front strut assembly procedure. *slc
Bulletin:
01T61
Component:
103000 power train:automatic transmission
Summary:
Subject regarding service information regarding transaxle shift adaptives reset procedure. *slc
Bulletin:
02T04
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding service manual and quick reference specifications guide update regarding incorrect cylinder head bolt torque specifications. *slc
Bulletin:
02T06
Component:
021000 suspension:front
Summary:
Subject regarding service manual update for chassis service manuals regarding front strut assembly procedure. *slc
Bulletin:
02T19
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
Service information regarding onstar communication and interface module (cim) programming. *tt
Bulletin:
02T16
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Service information regarding design change to thermostat housing, thermostat housing bolts, and thermostat housing o-ring seal. *tt
Bulletin:
02T26
Component:
111100 electrical system:battery:cables
Summary:
The purpose of this bulletin is to provide new positive and negative battery cable replacement procedures. *tt
Bulletin:
02C07
Component:
110000 electrical system
Summary:
Subject regarding inaccurate odometer reading after loss of battery power. *jg
Bulletin:
01T36A
Component:
162000 structure:body
Summary:
Subject regarding the placement of vehicle badges on decklid applique or liftgate. *jg
Bulletin:
02I01A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject regarding service information regarding rear seat entertainment system diagnostics and service procedures. *jg
Bulletin:
02T22
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding whistle noise under certain engine operating consitions. *jg
Bulletin:
02T23
Component:
341000 communications:horn assembly
Summary:
Subject regarding muffled tone or intermittent low or no tone from horn. *jg
Bulletin:
02T43
Component:
106000 power train:axle assembly
Summary:
Subject regarding service manual update for transaxle service manuals regarding new differential ring gear replacement procedure. *jg
Bulletin:
02T26
Component:
980000 unknown or other
Summary:
Subject regarding service manual update for engine service manuals regarding new positive and negative battery cable replacement procedures. *jg
Bulletin:
02T27
Component:
162300 structure:body:door
Summary:
Some consumers may complain that the rear door glass is inoperative or displays erratic operation. *jg
Bulletin:
02T37
Component:
062000 engine and engine cooling:cooling system
Summary:
Subject regarding service information on new oil cooler cover sealant. *jg
Bulletin:
02T44
Component:
106000 power train:axle assembly
Summary:
Subject regarding service information regarding new design line pressure control solenoids. *jg
Bulletin:
02T48
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding mass air flow sensor failure due to oil contamination of sensor membrane (install new mass air flow (maf) sensor and update electronic control module calibration) *jg
Bulletin:
02T46
Component:
015000 steering:hydraulic power assist system
Summary:
Service information regarding power steering system noise and/or leak diagnosis. *jg
Bulletin:
02T62
Component:
136000 visibility:windshield wiper/washer
Summary:
Service information regarding redesigned wiper linkage and new service procedures. *jg
Bulletin:
02T42
Component:
162000 structure:body
Summary:
Subject regarding squeak, rattle and poor fit from defroster grille (install redesigned defroster grille) *jg
Bulletin:
02T49
Component:
355100 equipment:other:labels
Summary:
Subject regarding service engine soon (ses) lamp illuminated with diagnostic trouble code (dtc) p1441 set in pcm history (install new pcm calibration) *jg
Bulletin:
99T55C
Component:
020000 suspension
Summary:
Some consumers may complain about a steering wheel shake or vibration felt when driving vehicle at highway speeds. this condition is most noticeable on smooth road surfaces at vehicle speeds above 65mph (105 km/h) *jg
Bulletin:
02T58
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject regarding rear seat entertainment dvd screen will not latch in stowed position. (replace mountig spring button) *jg
Bulletin:
00T72A
Component:
022000 suspension:rear
Summary:
Subject regarding service manual update for chassis service manualss regarding alignment specifications and service procedure for installation of spacers between rear suspension support and vehicle body when performing wheel alignment. *jg
Bulletin:
02I01A
Component:
350000 equipment
Summary:
Service information regarding rear seat entertainment system diagnostic and service procedures. *tt
Bulletin:
02T86
Component:
062000 engine and engine cooling:cooling system
Summary:
Service information regarding elimination of auxiliary water pump and instructions to install 2nd design heater inlet hose and heater inlet elbow in place of the 1st design water pump and heat inlet hose. *tt
Bulletin:
02T70
Component:
100000 power train
Summary:
Service manual update for certain 2002-2003 model powertrain electrical diagnostics service manuals regarding diagnostic trouble codes (dtc) p0218, p0711, p0712, p0713, p1810, p1815, p1816, p1817, p1818, p1860 and p1887. *tt
Bulletin:
02T77
Component:
015000 steering:hydraulic power assist system
Summary:
Whistle noise from power steering while turning left. *tt
Bulletin:
02T86
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding elimination of auxiliary water pump and instruments to install 2nd design heater inlet hose and heater inlet elbow in place of the 1st design water pump and heater inlet hose. *tt
Bulletin:
03T01
Component:
061000 engine and engine cooling:engine
Summary:
Service engine misfire on paired cylinders (1 and 4 or 2 and 3), diagnostic trouble codes p0300 - p0304 2.2l 4 cyl revised repair procedure. *tt
Bulletin:
03T03
Component:
220000 seats
Summary:
Loose or torn seat covers. *tt
Bulletin:
03T04
Component:
061000 engine and engine cooling:engine
Summary:
Spark plug usage change, and if necessary, update pcm (power train control module) calibration. *tt
Bulletin:
03T10
Component:
353600 equipment:air conditioner
Summary:
Automatic climate control performance. *tt
Bulletin:
030853001
Component:
162000 structure:body
Summary:
Defroster grille popping noise encountered during cold temperatures. *tt
Bulletin:
030602002
Component:
060000 engine and engine cooling
Summary:
Insufficient heat, service engine soon (malfunction indicator lamp) telltale on, diagnostic trouble code p0128 set. *tt
Bulletin:
030844007
Component:
353000 equipment:electrical
Summary:
Information for concerns on noise heard through the audio system when another electrical component is activated or used. *tt
Bulletin:
030310003
Component:
162000 structure:body
Summary:
When making a full left turn on vehicles equipped with p215/55r16 tires, a rubbing noise may be encountered coming from the right front inner fender area. *tt
Bulletin:
030604016
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding the engine control module (ecm) connector and terminal locations on saturn v6 engines. *tt
Bulletin:
030850010
Component:
221600 seats:front assembly:power adjust
Summary:
Power driver seat inoperable. *tt
Bulletin:
030139002A
Component:
353600 equipment:air conditioner
Summary:
Automatic climate control performance. *tt
Bulletin:
030601014
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update regarding the use of saturn special tool j-42065 crank hub holding tool. *tt
Bulletin:
030601015
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update for removal of the sealer used on oil pump gasket during oil pump installation. *tt
Bulletin:
030731004
Component:
100000 power train
Summary:
Bleeding procedure for hydraulic clutch release system including clutch actuator cylinder. *tt
Bulletin:
030601017
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain design change and revised service procedures. *tt
Bulletin:
990091002D
Component:
020000 suspension
Summary:
Steering wheel shake or vibration at highway speeds. *tt update. *tt
Bulletin:
030844010
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Six-disc radio will not load, eject and/or play compact discs (cds). *tt
Bulletin:
030849011
Component:
162000 structure:body
Summary:
Center console arm rest lid contacts lumbar adjuster knob. *tt
Bulletin:
030139012
Component:
353600 equipment:air conditioner
Summary:
Odor from air conditioning at vehicle start-up. *tt
Bulletin:
030941004
Component:
140000 air bags
Summary:
Rattle or buzz noise from rear of passenger compartment. curtain inflator (side airbag) module contacting the vehicle frame. *tt
Bulletin:
030844017
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Changes to the am/fm stereo and audio disc player radio on-board diagnostic modes and cd load operation. *tt
Bulletin:
030604043
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) service engine soon telltale lamp on, reduced power lamp may illuminate with diagnostic trouble codes p0121, p0221, and/or p2135. *tt
Bulletin:
030856002
Component:
110000 electrical system
Summary:
Intermittent security telltale illumination and/or diagnostic trouble code b2960. *tt
Bulletin:
030843005
Component:
136000 visibility:windshield wiper/washer
Summary:
Little or no windshield solvent coming from washer nozzles. *tt
Bulletin:
030089033A
Component:
980000 unknown or other
Summary:
Trailer, recreational and disabled vehicle towing information. *tt *sc
Bulletin:
030844019
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Low volume ticking noise, radio volume resolution or cd will not load/eject. *tt
Bulletin:
030089032
Component:
980000 unknown or other
Summary:
Recreational and disabled vehicle towing information. *tt
Bulletin:
030232045
Component:
010000 steering
Summary:
Moan or groan noise when turning steering wheel at low speeds. *tt
Bulletin:
030090003
Component:
061000 engine and engine cooling:engine
Summary:
Oil filter cap assembly and oil filter element design change. *tt
Bulletin:
030089025
Component:
980000 unknown or other
Summary:
Clarification of labor codes used for reprogramming vehicle controllers. various models including the 2004 l-series. *tt
Bulletin:
030139015
Component:
138000 visibility:defroster/defogger system
Summary:
Service manual update regarding a change in the defrost operation for the automatic climate control. *tt
Bulletin:
030524001
Component:
034410 service brakes, hydraulic:foundation components:drum:wheel cylinders
Summary:
Service information regarding saturn rear drum wheel cylinder inspections. *tt update. *tt
Bulletin:
030849022A
Component:
090000 fuel system, other
Summary:
Fuel gauge displays an erratic or false reading or no start condition after vehicle is shut off with low fuel level. *tt this bulletin replaces previous dated 12/01/03. *tt this bulletin replaces previous dated 08/01/04. *tt
Bulletin:
030844016A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Compact discs (cds) skip in single cd player. *tt
Bulletin:
040842001
Component:
121000 exterior lighting:headlights
Summary:
Information on intermittent dimming (flickering) of headlamps and/or instrument panel lighting-normal characteristic. this may occur because of transient current loads on the electrical system during normal vehicle operation. *mn
Bulletin:
030139014
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Service information on replacing auto climate control (acc) control head. *tt
Bulletin:
040601004
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding engine support during removal of right front engine mount assembly. *tt
Bulletin:
040604008
Component:
060000 engine and engine cooling
Summary:
Service engine soon (ses) lamp illuminated with dtc p0135 ho2s heater circuit performance bank 1 sensor 1 and/or dtc p0155 ho2s heater performance bank 2 sensor 1. *mr this bulletin replaces previous 04-06-04-008. *eh
Bulletin:
040139001
Component:
353600 equipment:air conditioner
Summary:
Automatic climate control overcompensation. *mr
Bulletin:
040310003
Component:
200000 wheels
Summary:
Information on clicking noise from chrome clad wheels at low speeds- normal characteristic/ no service required. also including 2004-2005 saturn l-series. *mr
Bulletin:
040089012
Component:
980000 unknown or other
Summary:
Saturn field product reminder- vehicle fix it right the first time issues, parts restriction information and technical bulletins released in january, february, and march 2004. *mr
Bulletin:
040730020
Component:
100000 power train
Summary:
Service vehicle soon lamp illuminated with diagnostic trouble code (dtc) p1811 maximum adapt and long shifts. *tt
Bulletin:
040601009
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak from front cover seal during extremely cold weather. *tt
Bulletin:
040601010
Component:
061000 engine and engine cooling:engine
Summary:
Blue smoke at engine start-up. *tt
Bulletin:
040601011
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update for engine block clearance, cylinder head clearance and fastener torque specifications. *tt
Bulletin:
040235008
Component:
010000 steering
Summary:
Clunk noise from front of vehicle during turning maneuver/steering wheel rotation. *tt
Bulletin:
040137005
Component:
353600 equipment:air conditioner
Summary:
Information regarding air conditioning (a/c) compressor noise at engine start (a/c or defrost mode selected) or at a/c or defrost activation (after engine start). *tt
Bulletin:
040846001
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Service support and technical assistance for onstar and/or xm radio. *mj
Bulletin:
040844015
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Return form for compact discs (cds) or digital versatile discs (dvds) that are stuck in cd player when returned as a core return. *tt
Bulletin:
3036
Component:
162900 structure:body:roof and pillars
Summary:
Dark rectangles or circles in the center of the roof. *tt
Bulletin:
3037
Component:
190000 tires
Summary:
Thump noise/vibration/flat spotted tires on vehicle. *tt
Bulletin:
3116
Component:
060000 engine and engine cooling
Summary:
Ses illuminated engine miss/misfire feel or rough idle. *sc
Bulletin:
3119
Component:
980000 unknown or other
Summary:
No selection fir saturn when programming a saturn vehilcle. *sc
Bulletin:
3135
Component:
060000 engine and engine cooling
Summary:
Pop noise from engine area during heavy throttle input. *tc
Bulletin:
3099
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Routing the longer tuned power steering hose per tsb 03-02-32-045. *sc
Bulletin:
010604016
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) telltale illuminated with diagnostic trouble codes (dtcs) p0171, p0172, p0174 and/or p0175. *tt
Bulletin:
040604085
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) and/or reduced power lamp illuminating following cold engine start up in subfreezing temperatures, diagnostic trouble codes (dtc) p0638, p1510 and/or p1516 stored in engine control module (ecm). *tt
Bulletin:
3295
Component:
106000 power train:axle assembly
Summary:
Service wrench and ses telltale may be illuminated and transaxle may shift harshly. *eh
Bulletin:
0804
Component:
061000 engine and engine cooling:engine
Summary:
Oil life system reset procedures - cars. *nm
Bulletin:
3419
Component:
116000 electrical system:ignition
Summary:
Ignition key will not rotate back to off position or shift lever will not move out of park. *tt
Bulletin:
3668
Component:
060000 engine and engine cooling
Summary:
Tick noise from engine. *tt
Bulletin:
020232009
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering system noise and/or leak diagnosis. *tt
Bulletin:
709
Component:
060000 engine and engine cooling
Summary:
Oil life system reset procedures - cars. gm tech link. *tt
Bulletin:
3648
Component:
114100 electrical system:wiring:front underhood
Summary:
Hesitation on acceleration after internal engine repairs - check injector harness orientation. *tt
Bulletin:
3933
Component:
061000 engine and engine cooling:engine
Summary:
Timing belt replacement. *kb
Bulletin:
3859
Component:
061000 engine and engine cooling:engine
Summary:
Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj
Bulletin:
4014
Component:
980000 unknown or other
Summary:
Parts update - timing chain tensioner design change. *kb
Bulletin:
03-00-89-033
Component:
980000 unknown or other
Summary:
Trailer, recreational and disabled vehicle towing information. *kb updated 08-15-07. *kb updated 10/09/07. *nj updated 4/3/08. *nj
Bulletin:
000310006
Component:
020000 suspension
Summary:
Information on tire radial force variation (rfv). 2008 and prior gm passenger cars and light duty trucks including 2008 and prior hummer h2, h3 and 2005-08 saab 9-7x and 2000-05 saturn l series and 2003-07 saturn ion. *kb updated 4/1
Bulletin:
070730025
Component:
103000 power train:automatic transmission
Summary:
Information on 4t40-e (mn4) and 4t45-e (mn5) front wheel drive automatic transmission valve body reconditioning, dtc p0741, p0742, p0751, p0752, p0756, p0757, p1811, harsh shifts, slips, no drive, no reverse. *nj
Bulletin:
08-089
Component:
353000 equipment:electrical
Summary:
Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin:
08089-B
Component:
110000 electrical system
Summary:
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin:
PIE-0012
Component:
070000 fuel system, gasoline
Summary:
Saturn: e109213-fuel smell/odor or leak near fuel tank area *engineering information). customers complain about a fuel smell/odor while driving or after the vehicle is parked. some dampness may also be noticed on the ground near the fuel
Bulletin:
SB-00-03-10-006C
Component:
190000 tires
Summary:
General motors: information on tire radial force variation. vehicle must be driven before measuring tires on equipment hunter gsp9700 toensure removal of any flatspotting. models include all gm passenger cars and light trucks, as well as
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
PIP-4495C
Component:
061000 engine and engine cooling:engine
Summary:
Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm
Bulletin:
SB-10-08-50-003B
Component:
221300 seats:front assembly:head restraint
Summary:
General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIP5226A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIC5491J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. technician should turn off the ignition and cancel retained accessory power. after the vehic
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
02-08-42-001H
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
Bulletin:
PIT3099P
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIC5588D
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
11-00-89-005B
Component:
356000 equipment adaptive
Summary:
This warranty administrational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm
Bulletin:
PIP4495E
Component:
162800 structure:body:hood
Summary:
This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Bulletin:
PIT5353B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIC5088E
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about vehicles that may not receiving all channels on the xm band. technician will need to use a scan tool and verify current digital radio receiver status un
Bulletin:
10-00-89-009B
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on key code security and information on gm key code look up applications.
Bulletin:
99-04-20-002H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides a revision of 99-04-20-002g to add 2013-2014 model years.
Bulletin:
13-00-89-005
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides warranty administration - new labor codes information.

Home | Privacy