2002 PONTIAC SUNFIRE Recalls (2)

Campaign:
07E021000 on 03/11/2007
Component:
Fuel system, other:storage:tank assembly:pressure relief devices
Affected:
742
Defect:
Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence:
Fuel may leak, possibly resulting in a fire.
Correction:
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Notes:
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E063000 on 10/19/2008
Component:
Steering
Affected:
3,855
Defect:
Dorman products is recalling 3,900 intermediate steering shafts dorman part nos. 425-151, 425-152, and 425-153, (sold under dorman's "oe solutions" brand name), balkamp #'s 7-3057, 7-3058, 7-3059 (sold under the "napa" brand name), and platinum parts #'s 2425151, 2425152, and 2425153 manufactured during the month of september 2007. these replacement steering shafts can be used on the vehicles listed above. the weld connecting the inner tube to the outer tube may be defective.
Consequence:
If the weld fails, loss of steering could result, possibly resulting in a vehicle crash.
Correction:
Dorman will notify owners and replace the steering shafts free of charge. the recall began on october 16, 2008. owners may contact dorman toll free at 1-800-523-2492.
Notes:
This recall only pertains to dorman's oe solutions brand name, balkamp's napa brand, and the platinum brand steering shafts and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

2002 PONTIAC SUNFIRE TSBs (312)

Bulletin:
01-02-32-001
Component:
010000 steering
Summary:
Concerns with clunk noise from front of vehicle turning maneuver / steering wheel rotation.*jb (lubricate or replace intermediate shaft as appropriate). updated 10/05/07. *nj updated 4/1/08. *nj updated 7/1/2008 *pe
Bulletin:
100730024
Component:
103000 power train:automatic transmission
Summary:
Certain vehicles, with either the ln2 or l61 engines, have software that does not allow the tech 2 to display or clear shift adapts. *tt
Bulletin:
310801
Component:
103000 power train:automatic transmission
Summary:
Subject regarding incorrect gear shift knobs installed on certain vehicles with automatic transmissions built between vin 24117800 and 24119810. *tt
Bulletin:
290801
Component:
102000 power train:manual transmission
Summary:
Information on vehicles exhibiting manual transmission gear noise. *tt
Bulletin:
290801
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding pcm connectors may not be fully seated to the pcm. *tt
Bulletin:
000089008A
Component:
980000 unknown or other
Summary:
Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground. this bulletin provides information regarding recreational (dinghy) towing for certain vehicles including the 1996 through 2000 toyota c
Bulletin:
140601
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This message is about a flase diagnostic trouble code, p1683, which is the ignition off timer performance. *tt
Bulletin:
030701
Component:
103000 power train:automatic transmission
Summary:
Subject regarding automatic transmission only, some vehicle were built with incorrect shifter knobs.*jb
Bulletin:
270801
Component:
353000 equipment:electrical
Summary:
Some vehicles new pop out cigarette lighter may cause failure to the 20-amp fuse for the cigarette lighter circuit. *yh
Bulletin:
050901
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding front oxygen sensor connector retention. *slc
Bulletin:
190901
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding power train control module replacement. *slc
Bulletin:
200901
Component:
070000 fuel system, gasoline
Summary:
Subject regarding correct post converter or rear oxygen sensor usage. *slc
Bulletin:
010865001
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Information regarding fuel filler door recessed into quarter panel. *yh
Bulletin:
010232001C
Component:
021000 suspension:front
Summary:
Information regarding clunk noise from front of vehicle during turning. *yh *tt
Bulletin:
221001
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit diagnostic trouble codes such as rough running, miss fires or a no start condition. *tt
Bulletin:
261001
Component:
103000 power train:automatic transmission
Summary:
Subject regarding highline pressure after an overhaul of the transaxle when using overhaul kits. *tt
Bulletin:
291001
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Customer complaint of extended crank time. *tt
Bulletin:
291001
Component:
122000 exterior lighting:fog lights
Summary:
Customer concern of premature fog lamp failure. *tt
Bulletin:
051101
Component:
010000 steering
Summary:
Some vehicles may exhibit a clunk type noise especially felt in the steering wheel while turning. *tt
Bulletin:
010102
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engines exhibiting diagnostic trouble code p0141 with no prior repair attemps. *jg
Bulletin:
000604037A
Component:
980000 unknown or other
Summary:
Some customers may complain that the service engine soon (ses) indicator is illuminated with harsh transmission shifts. *tt
Bulletin:
010858005
Component:
162000 structure:body
Summary:
Some customers may comment that road noise can be heard from the rear of the vehicle primarily on wet road surfaces. *tt
Bulletin:
010602012
Component:
062000 engine and engine cooling:cooling system
Summary:
Some owners may comment on leakage of a few drops of coolant after parking their vehicle. *tt
Bulletin:
010102
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding product feedback request with 2.2l ln2 engines exhibiting an oil filter leak. *jg
Bulletin:
111201
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding vehicles with automatic transmissions setting diagnostic trouble code p0716, 717, input speed sensor codes. *tt
Bulletin:
141201
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding false diagnostic trouble code p0116. *tt
Bulletin:
160102
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Customers may comment that the engine lags power, stalls, won't start or is hard to start. *tt
Bulletin:
280102
Component:
116200 electrical system:ignition:module
Summary:
Information on diagnostic trouble codes p0753, p0758 and p1860. *tt
Bulletin:
070202
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Some customers may have a comment of the vehicle being difficult to fuel or that the fuel gauge reads low yet they cannot put fuel in the vehicle. *tt
Bulletin:
180202
Component:
090000 fuel system, other
Summary:
Subject regarding proper repair for fuel gauge inaccuracy complaints. *tt
Bulletin:
280202
Component:
980000 unknown or other
Summary:
Some customers may comment that they would like the radio key fob personalization turned on or off. *tt
Bulletin:
280202
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding oil filter leaks. *tt
Bulletin:
020729001
Component:
102000 power train:manual transmission
Summary:
Some customers may complain on a grinding or rattle type noise coming from the transmission. *slc
Bulletin:
020601001A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Customers may complain on a drone noise coming from the engine area. *slc
Bulletin:
010604008C
Component:
090000 fuel system, other
Summary:
Some customers may comment about inaccurate or erratic fuel gauge readings. *slc
Bulletin:
010849016
Component:
353000 equipment:electrical
Summary:
Vehicles may experience an inoperative cigarette lighter. *slc
Bulletin:
010845006A
Component:
110000 electrical system
Summary:
Subject regarding availability of new micro 64 electrical terminals for wiring repairs. *tt
Bulletin:
02020
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Customer satisfaction program - engine cylinder bore liner. *tt
Bulletin:
020604045
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding revised dtc p0327 - this bulletin is being issued to revise step 3 of dtc p0327 in the engine controls. nlm
Bulletin:
020604044
Component:
980000 unknown or other
Summary:
Subject regarding service engine soon (ses) light illuminated, dtc p0440 set 9replace fuel tank evaporative emission control system (evap vent solenoid harness). nlm
Bulletin:
020844012
Component:
980000 unknown or other
Summary:
Remote keyless entry key fob radio personalization feature enabled (turned on) or disabled (turned off). *tt
Bulletin:
020604011
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding revised diagnostic trouble code p0140. *tt
Bulletin:
010232001B
Component:
010000 steering
Summary:
Some customers may comment on a clunk type noise coming from the front of the vehicle during a turning maneuver. *tt
Bulletin:
020308006
Component:
021000 suspension:front
Summary:
This bulletin is being issued to revise the front suspension fastner tightening specifications.*tt
Bulletin:
020139004
Component:
138000 visibility:defroster/defogger system
Summary:
Information regarding new pag oil released for certain vehicles including all 2003 passenger cars and trucks. *tt
Bulletin:
020730022A
Component:
980000 unknown or other
Summary:
Service engine soon light on with diagnostic trouble codes p0716 and / or p0717, p0730, p0753, p0758, p1860, p1887 or other miscellaneous transmission trouble codes set. *tt
Bulletin:
020731003
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Clutch pedal buzz or vibration. *tt
Bulletin:
020730002
Component:
980000 unknown or other
Summary:
Some customers may comment that the service engine soon (ses) indicator is illuminated and that while the light is illuminated, transmission shifts are extremely harsh. *tt
Bulletin:
041802
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Customer complaints of low clutch pedal reserve or clutch pedal sticks to the floor. *tt
Bulletin:
210602
Component:
114000 electrical system:wiring
Summary:
This service is regarding a wire routing issue that can lead to service engine soon lamp activation and various drivability concerns. *tt
Bulletin:
170702
Component:
980000 unknown or other
Summary:
Concerns with service engine soon light on with diagnostic trouble code p0440 code set. *tt
Bulletin:
180702
Component:
101000 power train:clutch assembly
Summary:
This message covers vehicles with the manual transmission and a complaint of clutch will not release completely after installation of the new spo clutch parts. *tt
Bulletin:
290702
Component:
353600 equipment:air conditioner
Summary:
A customer may complain about an inoperative air conditioning system or a hesitation misfire under acceleration while the air conditioning is on. *tt
Bulletin:
020604046
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light on intermittently and diagnostic trouble code p1441 stored. *tt
Bulletin:
020232012
Component:
010000 steering
Summary:
Rattle / knock noise when turning while driving over rough roads. *tt
Bulletin:
010310005A
Component:
020000 suspension
Summary:
Squeak type noise coming from front or rear wheels. various models including the 2001 toyota cavalier. *tt
Bulletin:
020308008
Component:
020000 suspension
Summary:
Rattle, creak, popping type noise from front of vehicle when turning. *tt
Bulletin:
020730050
Component:
100000 power train
Summary:
Engineering changes to the valve body, pressure regulator valve, 2-3 accumulator valve and bore for 2002-2003 model year 4t45e transaxles and subsequent overhaul procedures which affect 1995-2001 model year transaxles. *tt
Bulletin:
030859001
Component:
162000 structure:body
Summary:
Rattle noise from front center of dash area. *tt
Bulletin:
010310005B
Component:
020000 suspension
Summary:
Wheel squeak on vehicles with 14 and 15 inch wheel covers. *tt
Bulletin:
022403
Component:
015000 steering:hydraulic power assist system
Summary:
Intermittent condition of a momentary reduction in power steering assist at startup. *tt *jb
Bulletin:
022703
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Inoperative manual outside rearview mirror(s). *tt *jb
Bulletin:
030603
Component:
103000 power train:automatic transmission
Summary:
Service engine soon (ses) light on and/or traction light illuminated, and the automatic transmission slipping or stuck in gear. *tt *jb
Bulletin:
031103
Component:
070000 fuel system, gasoline
Summary:
Complaints that are root caused to the fuel module and complaints of gauge accuracy that are root caused to the fuel level sensor. *tt *jb
Bulletin:
030601018
Component:
061000 engine and engine cooling:engine
Summary:
New cylinder bore liner replacement procedure. *tt
Bulletin:
030604030
Component:
061000 engine and engine cooling:engine
Summary:
Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
030730021
Component:
100000 power train
Summary:
Neutral flare and/or rpm flare while in drive, no 1-2 upshift, service engine soon (ses) light illuminated, diagnostic trouble codes (dtcs) p1810, diagnostic trouble code p1815 set. *tt
Bulletin:
020232012A
Component:
010000 steering
Summary:
Rattle/knock noise when turning while driving over rough roads. *tt
Bulletin:
020844012A
Component:
980000 unknown or other
Summary:
Enable or disable remote keyless entry (rke) radio personalization feature. *tt
Bulletin:
030729005
Component:
100000 power train
Summary:
Clunk noise from front end during low speed turns or maneuvers. *tt
Bulletin:
030867004
Component:
134000 visibility:sun roof assembly
Summary:
Parts availability for sunroof repairs. *tt
Bulletin:
052903
Component:
350000 equipment
Summary:
Clarification of service bulletin 02-08-44-012. certain steps in the service bulletin to disable or enable the remote keyless entry radio personalization feature has been deleted in the tech 2 software. concern will be updated in july rel
Bulletin:
071503
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant lose, evidence fluid on the garage floor, etc., or coolant warning light coming on. *tt
Bulletin:
071603
Component:
162000 structure:body
Summary:
Rattle or buzz from the right front speaker. *tt
Bulletin:
071003
Component:
062000 engine and engine cooling:cooling system
Summary:
This vme message is a water pump replacement due to a known cam driveline. some customers may question about whine noise coming from the front engine area. *tt
Bulletin:
071103
Component:
061000 engine and engine cooling:engine
Summary:
This vme message concerns a cylinder boreliner tool now available for the l61 2.2 liter engine. the tool is referenced in service bulletin 030601018. the purpose of the tool is to extend the total service life of the block. *tt
Bulletin:
01411
Component:
110000 electrical system
Summary:
False code b3785. service vme. *tt
Bulletin:
000089008B
Component:
980000 unknown or other
Summary:
Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground. this bulletin provides information regarding recreational (dinghy) towing for certain vehicles including 1988-2004 chevrolet and gmc li
Bulletin:
010232001C
Component:
010000 steering
Summary:
Some customers may comment on a clunk type noise coming from the front of the vehicle during a turning maneuver. *tt
Bulletin:
020731003A
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Clutch pedal buzz or vibration. *tt
Bulletin:
030864009A
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Left outside breakaway mirror inoperative. *tt update. *tt
Bulletin:
030864011A
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Mirror vibrates at highway speeds. *tt
Bulletin:
030730036
Component:
100000 power train
Summary:
Transmission slips in 4th gear, stuck in 2nd gear or ses/tcs light illuminated, diagnostic trouble codes (dtcs) p0753, p0758, p1860, c1223, c1224 or c1275 may be set. *tt
Bulletin:
01432
Component:
103000 power train:automatic transmission
Summary:
Automatic transmission poor acceleration, performance. *tt
Bulletin:
030730012A
Component:
103000 power train:automatic transmission
Summary:
Transaxle or transmission slips, won't shift, no reverse, 2nd, 3rd or overdrive, erratic shifts. *tt
Bulletin:
030729005A
Component:
100000 power train
Summary:
Clunk noise from front end during low speed turns or maneuvers. *tt
Bulletin:
010310005C
Component:
020000 suspension
Summary:
Wheel squeak on vehicles with 14 and 15 inch wheel covers. *tt
Bulletin:
020730022B
Component:
980000 unknown or other
Summary:
Service engine soon light on with diagnostic trouble codes p0716 and / or p0717, p0730, p0753, p0758, p1860, p1887 or other miscellaneous transmission trouble codes set. *tt
Bulletin:
030232001A
Component:
015000 steering:hydraulic power assist system
Summary:
Momentary reduction on power steering (p/s) assist on initial start up with low ambient temperatures. *tt
Bulletin:
030859003
Component:
162000 structure:body
Summary:
Right front speaker rattle. *tt
Bulletin:
100703
Component:
134000 visibility:sun roof assembly
Summary:
Jammed sunroof that will not open or a close completely. gm voicemail log. *tt
Bulletin:
090903
Component:
110000 electrical system
Summary:
The body control module (bcm) may set a false code of b3785. gm voicemail log. *tt
Bulletin:
012803
Component:
183000 vehicle speed control:cables
Summary:
Throttle cable rattle noise heard in the front of dash area, most noticeable at the center defroster duct. gm voicemail express. *tt
Bulletin:
01522
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Clutch pedal stays to floor repeat slave cylinder fail. sit bulletin 1405756. *tt
Bulletin:
000089008E
Component:
980000 unknown or other
Summary:
Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground. this bulletin provides information regarding recreational (dinghy) towing for certain vehicles including 1988-2004 chevrolet and gmc li
Bulletin:
030730021A
Component:
103000 power train:automatic transmission
Summary:
Neutral flare and/or rpm flare while in drive, no 1-2 upshift, service engine soon (ses) light illuminated, diagnostic trouble codes (dtcs) p1810, diagnostic trouble code p1815 set. *tt
Bulletin:
030867009
Component:
134000 visibility:sun roof assembly
Summary:
Sunroof will not open or close completely due to the sunroof motor. *tt
Bulletin:
03064
Component:
061000 engine and engine cooling:engine
Summary:
On-board diagnostic system software upgrade - obd system improvements. *tt
Bulletin:
020138003
Component:
353600 equipment:air conditioner
Summary:
Air conditioning may be inoperative or may operate intermittently, engine hesitation/surge. *tt
Bulletin:
020730048
Component:
106000 power train:axle assembly
Summary:
Pressure control solenoid replacement for 4t65-e, 4t40-e, and 4t45-e transaxle/transmission.*mr
Bulletin:
01967
Component:
021000 suspension:front
Summary:
Front suspension steer noise smooth road turns. *mr
Bulletin:
01995
Component:
061000 engine and engine cooling:engine
Summary:
Replacing a 02 or 03 2.2l l61 with a 04 2.2l l61 engine replacement.*mr
Bulletin:
01604
Component:
100000 power train
Summary:
4t40e, 4t45e change in appearance of forward, second and reverse clutch wave plate. *tt
Bulletin:
01598
Component:
134000 visibility:sun roof assembly
Summary:
Sunroof supplemental information to 03-08-67-009.*mr
Bulletin:
00966B
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Abs front wheel speed codes - jumper harness. *tt
Bulletin:
00434
Component:
061000 engine and engine cooling:engine
Summary:
Engine will crank but not start, also makes noise while cranking. 2.2 l61 engine. *tt
Bulletin:
00966
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Anti-lock braking system (abs) front wheel speed codes - jumper harness. *tt
Bulletin:
01353
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire due to injector fretting corrosion. *tt
Bulletin:
040235004D
Component:
010000 steering
Summary:
Clunk noise from front of vehicle during turning maneuver/steering wheel rotation. *tt *nm
Bulletin:
02139
Component:
021000 suspension:front
Summary:
Squeak or rub type noise on turns coming from the front suspension as if it is coming from the shock absorber or the top mount. *tt
Bulletin:
04152004
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Vehicles may set anyone or a combination of front-wheel speed sensor anti-lock brake system codes as intermittent or hard failures. gm voicemail express. *tt
Bulletin:
3070
Component:
110000 electrical system
Summary:
Service engine soon light with diagnostic trouble code p0130, p0134 and/or p0135. *tt
Bulletin:
04059
Component:
980000 unknown or other
Summary:
Emission label - replace - vehicle emission control labels that are wrinkled, damaged, or completely missing. *nm
Bulletin:
3115
Component:
180000 vehicle speed control
Summary:
High idle when clutch is depressed. *sc
Bulletin:
3189
Component:
090000 fuel system, other
Summary:
Crank no start, low or no fuel pressure. *tt
Bulletin:
040308015A
Component:
020000 suspension
Summary:
Squeaking noise in front end on turns. *tt
Bulletin:
030601022
Component:
061000 engine and engine cooling:engine
Summary:
Guidelines for cylinder bore liner/piston sleeve replacement on the l4 ecotec engine. *tt
Bulletin:
3263
Component:
020000 suspension
Summary:
Front suspension noise on turns. *eh
Bulletin:
030232001B
Component:
010000 steering
Summary:
Momentary reduction of power steering ps assist on initial start up with low ambient temperatures. this service bulletin replaces 030232001a. *eh
Bulletin:
030729005
Component:
103000 power train:automatic transmission
Summary:
Clunk noise from front end during low speed turns or maneuvers. this service bulletin replaces 030729005a. *eh
Bulletin:
030601018
Component:
060000 engine and engine cooling
Summary:
New cylinder bore liner replacement procedure. this service bulletin replaces 030601018a. *eh
Bulletin:
040308010
Component:
020000 suspension
Summary:
Changes to labor time guide relating to front suspension labor operations components. *eh
Bulletin:
030863002
Component:
162000 structure:body
Summary:
Carpet wet on driver's side. *tt
Bulletin:
040232001
Component:
010000 steering
Summary:
Release of steering gear stub shaft bearing kit for service. *tt updated 08-15-07. *kb updated 10/09/07. *nj
Bulletin:
10072002
Component:
010000 steering
Summary:
Knocking rattle noise when turning and driving over bumps. engineering is currently evaluating a new high-pressure hose assembly to correct this condition. *tt
Bulletin:
3477
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Tech 2 displays asterisk for the left front wheel speed sensor. *tt
Bulletin:
610
Component:
060000 engine and engine cooling
Summary:
Engine idle flare when the clutch is depressed. also low speed engine decel stall when coming to a stop. gm tech link. *tt
Bulletin:
510
Component:
160000 structure
Summary:
Right front speaker rattle. *sc
Bulletin:
3481
Component:
185000 vehicle speed control:cruise control
Summary:
Cruise control shuts off when the hazards are switched on. *tt
Bulletin:
3433
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3. *tt updated 08-15-07. *kb
Bulletin:
3447
Component:
100000 power train
Summary:
4t40e or 4t45e will not shift no diagnostic trouble codes. *tt
Bulletin:
3253
Component:
103000 power train:automatic transmission
Summary:
Vehicle will not move in either direction. transmission may show over full. p90 4t40e 4t45e no movement drive or reverse. converter may be empty of fluid. *tt
Bulletin:
3321A
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Fuel tank is hard to fill. *tt
Bulletin:
050604026
Component:
061000 engine and engine cooling:engine
Summary:
Vehicle hesitates, no start, lack of power, low fuel pressure. *tt
Bulletin:
709
Component:
030000 service brakes, hydraulic
Summary:
Car issues - fix it right the first time (new issues in bold). to include 2006 and 2007 models. gm. tech link. *tt
Bulletin:
3648
Component:
114100 electrical system:wiring:front underhood
Summary:
Hesitation on acceleration after internal engine repairs - check injector harness orientation. *tt
Bulletin:
1749019
Component:
061000 engine and engine cooling:engine
Summary:
Information on transferring original fuel rail to goodwrench engine. *ak
Bulletin:
3669
Component:
103000 power train:automatic transmission
Summary:
M86/m94 transmission information to disassemble third fourth and fifth gear. *ak
Bulletin:
3670
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
Information on transferring original fuel rail to goodwrench engine. *ak
Bulletin:
3915
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Clutch pedal stays to floor. *tt
Bulletin:
010232001F
Component:
010000 steering
Summary:
Clunk felt/noise heard from steering column, steering gear and/or front of vehicle during turning maneuver and/or steering wheel rotation. *tt
Bulletin:
3859
Component:
061000 engine and engine cooling:engine
Summary:
Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj
Bulletin:
4014
Component:
980000 unknown or other
Summary:
Parts update - timing chain tensioner design change. *kb
Bulletin:
070232006
Component:
012000 steering:column
Summary:
Clunk felt/noise heard from steering column, steering gear and/or front of vehicle during turning maneuver and/or steering wheel rotation (lubricate intermediate shaft [i-shaft]). *nj
Bulletin:
4615
Component:
040000 service brakes, air
Summary:
Abs pump running when not needed. *nj
Bulletin:
070730025
Component:
103000 power train:automatic transmission
Summary:
Information on 4t40-e (mn4) and 4t45-e (mn5) front wheel drive automatic transmission valve body reconditioning, dtc p0741, p0742, p0751, p0752, p0756, p0757, p1811, harsh shifts, slips, no drive, no reverse. *nj
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
PIP-4495C
Component:
061000 engine and engine cooling:engine
Summary:
Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm
Bulletin:
SB-10-08-50-003B
Component:
221300 seats:front assembly:head restraint
Summary:
General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
15-08-44-001H
Component:
118000 electrical system: software
Summary:
This informational bulletin provodes information on the gm of canada onstar cellular communication upgrade.
Bulletin:
PIC3278F
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIP5226A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIC5491J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. technician should turn off the ignition and cancel retained accessory power. after the vehic
Bulletin:
PIC5492E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have a diagnostic trouble code b101d-37 history in the vehicle communication interface module or telematics communication interface contro
Bulletin:
PIT3099L
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIT4864F
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about a customer?s request to install onstar bluetooth. dealer should be advised at this time, there are no provisions to add this option to vehicles that wer
Bulletin:
PIT5264
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicles that when a canadian customer may comment that when they travel to the united states, they are unable to connect to onstar or use hands free ca
Bulletin:
PIC5453A
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician that general motors and general motors of canada company do not support cross border sales. the general motors of canada customer care centre is the sole auth
Bulletin:
PIT4943C
Component:
030000 service brakes, hydraulic
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0442. technician will need to review t
Bulletin:
PIC3011H
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicles that have the onstar system does not respond properly to some numbers and/or voice commands. dealer should direct the customer to review the op
Bulletin:
PIP3140F
Component:
350000 equipment
Summary:
This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. technician should look for non - general motors a
Bulletin:
PIC5953
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIP5163A
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIC4310J
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT3099M
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIP5226
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIP5163
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIT3099J
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory parts. technician can check service information for some accessories. technician can also contact partech for assist
Bulletin:
PIC4935D
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar
Bulletin:
PIT4907A
Component:
030000 brakes (pws)
Summary:
This preliminary information communication provides information to the technician about brake rotors on new vehicles and replacement parts from general motors service parts operations. technician should be advised the costing should not be
Bulletin:
PIC4310H
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT3173C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. dealer should send the correc
Bulletin:
PIC3718E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles may have a no power or no connect concern. technician will find that the onstar led is red and diagnostic trouble code u1500 is set. technician
Bulletin:
PIP4495D
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Bulletin:
08-07-30-026C
Component:
113000 electrical system:starter assembly
Summary:
This informational bulletin provides information on vehicles may rock or move slightly forward or rearward while in park at start up after cold soak and that this is considered a normal conditon and no repairs are necessary
Bulletin:
PIP5094
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician that, when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of
Bulletin:
PIP3140E
Component:
350000 equipment
Summary:
This preliminary information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. technician should look for non - general motors a
Bulletin:
PIT4720C
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician that after replacing the instrument panel cluster the exchange center is unable to program the actual mileage on the odometer or the actual mileage is unknown
Bulletin:
PIC5904
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that the onstar system will not connect. technician should record module info per the latest version of pic4310 and contact general motors tech
Bulletin:
PIT3099K
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partech for assista
Bulletin:
PIC5913
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have a supplemental inflatable restraint lamp, service vehicle soon lamp on and/or radio locked, possibly after module replacement. techni
Bulletin:
PIP5338A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
Bulletin:
PIP5029H
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
Bulletin:
PIC5588C
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
PIC3278G
Component:
010000 steering
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIC4801H
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on how to diagnose and repair vehicles that may have an onstar turn-by-turn navigation the system that is inoperative. technician verifies there are no diagno
Bulletin:
PIP4723B
Component:
118000 electrical system: software
Summary:
This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
Bulletin:
PIC4935F
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIT5389C
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
02-08-42-001H
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
Bulletin:
15-08-44-001B
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
05-06-04-035E
Component:
090000 fuel system, other
Summary:
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:
15-08-44-001C
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-73-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
09-09-40-001C
Component:
150000 seat belts
Summary:
This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
Bulletin:
11-00-89-005C
Component:
356000 equipment adaptive
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
PIP5232C
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIC6181
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician after the onstar canada upgrade the onstar vehicle diagnostic email report is inoperative. please communicate to the customer that we apologize for this inconvenience and tha
Bulletin:
11-00-89-005H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty bulletin clarifies the use of dealer empowerment to satisfy the customer.
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC3278F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC5953A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT5399
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
Bulletin:
PIT5264B
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIP5029F
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
Bulletin:
PIT5353
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIT5389B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to contact general motors t
Bulletin:
PIP5163B
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leaka
Bulletin:
PIT3099N
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIP5338
Component:
020000 suspension
Summary:
This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
Bulletin:
PIC5953B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4696A
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PIC4696B
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PIT4943D
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp. technician may find diagnostic trouble code p0442. technician will need to review t
Bulletin:
PIT5353A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIT5486
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicles that when dialing certain numbers using onstar hands-free calling, the audio is distorted or has poor quality after performing the onstar canad
Bulletin:
PIC6101
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that are unable to receive onstar hands free calling calls and or the onstar center is unable to perform remote services. technician will need
Bulletin:
PIT5384A
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that may have the onstar wireless fidelity inoperative. technician will need to contact general motors technical assistance center with a scan
Bulletin:
PIC6107
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about being unable to receive onstar ?over the air? updates. technician will need to press the onstar button and verify they have an active account and that t
Bulletin:
PIC3100E
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odometer. i
Bulletin:
PIP5232B
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
03-08-46-004S
Component:
118000 electrical system: software
Summary:
This informational bulletin provides information on onstar® vcim is currently restricted parts. by working closely with our dealers and technicians, through the part restriction process, the general motors team will gain a better understand
Bulletin:
10-00-89-006F
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information for dealers how to submit a product information report.
Bulletin:
16-NA-025
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information on behavior of non-upgraded onstar equipped vehicles operating in canada after decommissioning of 2g cdma cellular networks
Bulletin:
01-08-42-001K
Component:
121000 exterior lighting:headlights
Summary:
This informational bulletin provides information on exterior lamp condinsation and replacement guidelines
Bulletin:
02-08-42-001I
Component:
121000 exterior lighting:headlights
Summary:
This informational bulletin provides an out line on headlamp, tail lamp, license lamp or fog/driving lamp damage and what should be considered warranty replacement and not
Bulletin:
11-00-89-005I
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm (u.s. only)
Bulletin:
PIT3099P
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIC5588D
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
11-00-89-005B
Component:
356000 equipment adaptive
Summary:
This warranty administrational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm
Bulletin:
PIP4495E
Component:
162800 structure:body:hood
Summary:
This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Bulletin:
PIT5353B
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about what xm offerings are available for vehicles. a dealer or customer can access the website listed below for vehicle specific xm offerings and availabilit
Bulletin:
PIC3100F
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odomete
Bulletin:
PIC5588B
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
PIC5088E
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about vehicles that may not receiving all channels on the xm band. technician will need to use a scan tool and verify current digital radio receiver status un
Bulletin:
080846004A
Component:
118000 electrical system: software
Summary:
This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.
Bulletin:
000089027G
Component:
350000 equipment
Summary:
This informational bulletin provides a step by step procedure on how to properly use the gm chemicals to eliminate unwanted odors in vehicles and which products to use for each application.
Bulletin:
100089010B
Component:
350000 equipment
Summary:
This informational bulletin provides information and rules for gm keycode look up applicationa dn the key code security rules and regulations for canada only.
Bulletin:
010089010J
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides a single point reference and strategy document to aid in reducing customer comebacks, and the possibility of buyback situations by outlining specific guidelines, strategy and forms that will assist with
Bulletin:
030848006J
Component:
138000 visibility:defroster/defogger system
Summary:
This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.
Bulletin:
PIC5088E
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary bulletin provides procedures on how to reset or refresh the xm radio receiver is the customers states that they only get a few channels.
Bulletin:
PIP3535C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. dealers
Bulletin:
PIP5325
Component:
070000 fuel system, gasoline
Summary:
This preliminary information communication provides information to the technician to help determine if the vehicle is equipped with factory or aftermarket compressed natural gas, liquefied petroleum gas, or bi-fuel systems. technician will
Bulletin:
PIT5464
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that the incoming caller id may no longer be available or displayed after the canada onstar upgrade. dealer should communicate to the customer
Bulletin:
PIP5540
Component:
350000 equipment
Summary:
This preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. to allow the ice to melt so that it can be drained from the related component
Bulletin:
PIP5540A
Component:
060000 engine (pws)
Summary:
This preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. to allow the ice to melt so that it can be drained from the related component
Bulletin:
PIP5226B
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
10-00-89-009B
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on key code security and information on gm key code look up applications.
Bulletin:
10-00-89-010C
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on key codes security rules and information on gm key code look up application.
Bulletin:
99-04-20-002H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides a revision of 99-04-20-002g to add 2013-2014 model years.
Bulletin:
13-00-89-005
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides warranty administration - new labor codes information.
Bulletin:
05-00-89-072C
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.
Bulletin:
10-00-89-006C
Component:
284300 back over prevention: sensing system: radar
Summary:
This informational bulletin provides directions on submitting different pirs
Bulletin:
08-08-51-002A
Component:
162000 structure:body
Summary:
This informational bulletin provides information pre-painting/cleaning process for tpo plastic fascias.
Bulletin:
00-03-10-002G
Component:
200000 wheels
Summary:
This informational bulletin provides information on the appearance of chromed aluminum wheels due to chemical staining, pitting corrosion and/or spotted.
Bulletin:
11-00-89-005D
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provide policy information on clarification of use-dealer empowerment labor operations and customer enthusiasm.
Bulletin:
02-08-42-001G
Component:
350000 equipment
Summary:
This informational bulletin is to assist with the identification of issues that are not considered warrantable.
Bulletin:
01-08-42-001J
Component:
120000 exterior lighting
Summary:
This informational bulletin explains condensation in exterior lights and replacment guidelines for warranty replacement.
Bulletin:
PIC6036
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicles that show an error message when a media disc is installed. technician will need to check the regular production option code list to verify if t
Bulletin:
PIP5232
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIT5264A
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIP5232A
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIT5099A
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
Bulletin:
15-08-73-001
Component:
110000 electrical system
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
15-08-44-001G
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar cellular communication upgrade.
Bulletin:
15-08-44-001F
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar cellular communication upgrade.
Bulletin:
00-06-01-012G
Component:
060000 engine (pws)
Summary:
This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on engine surfaces.
Bulletin:
16-NA-383
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
Bulletin:
PIP5163C
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
10-00-89-006E
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
10-00-89-006D
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
00-00-89-027H
Component:
353600 equipment:air conditioner
Summary:
This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
Bulletin:
00-06-01-012E
Component:
350000 equipment
Summary:
This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
15-08-44-001I
Component:
118000 electrical system: software
Summary:
This informational bulletin provides information for the gm of canada onstar cellular communication upgrade to 3g/4g lte for vehicles that may need an upgrade.
Bulletin:
15-08-73-001A
Component:
118000 electrical system: software
Summary:
This informational bulletin explains how to update the older onstar module software to new software over gsa.
Bulletin:
17-NA-073
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Bulletin:
11-00-89-005C
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
10-00-89-006D
Component:
355200 equipment:other:owners/service/other manual
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
00-00-89-027H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
Bulletin:
00-06-01-012E
Component:
355200 equipment:other:owners/service/other manual
Summary:
This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
Bulletin:
05-08-48-001C
Component:
350000 equipment
Summary:
This informational bulletin provides a revision for 05-08-48-001b to add 2010-2014 model years and update labor operation.
Bulletin:
08-06-01-006D
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information for engine squealing type noise on start-up or vibration condition.
Bulletin:
11-00-89-005E
Component:
350000 equipment
Summary:
This informational bulletin provides a revision for 11-00-89-005d to add additional mandatory minimum tables and additional information concerning policy decision making.
Bulletin:
PI1394
Component:
060000 engine and engine cooling
Summary:
This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
Bulletin:
10-08-45-001E
Component:
110000 electrical system
Summary:
This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
Bulletin:
10-00-89-006D
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
00-00-89-027H
Component:
350000 equipment
Summary:
This informational bulletin provides information on what products gm has to aid in the eliminating unwanted odors in a vehicle.
Bulletin:
00-06-01-012E
Component:
060000 engine (pws)
Summary:
This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.
Bulletin:
PIT5399A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
Bulletin:
PIC4696C
Component:
150000 seat belts
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
10-00-89-006E
Component:
350000 equipment
Summary:
This information bulletin provides the dealers on how to submit a product information report.
Bulletin:
PIP4495F
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Bulletin:
PIT5099C
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
Bulletin:
PIP5163D
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIT5099D
Component:
353600 equipment:air conditioner
Summary:
This preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have hi
Bulletin:
PIP5601
Component:
350000 equipment
Summary:
This preliminary information communicates

Home | Privacy