2002 MAZDA B-SERIES TRUCK Recalls (2)

Campaign:
07V347000 on 08/07/2007
Component:
Vehicle speed control
Manufactured:
04/03/1997 - 12/09/2002
Affected:
76,000
Defect:
On certain trucks equipped with a speed control system, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. an interim notice was sent to owners on september 7, 2007, directing them to have the speed deactivation control switch disconnected temporarily. a second notification letter to owners was in february 2008 advising them to return to dealers for installation of the repair part. owners of affected vehicles who did not receive a phase 2 notice and have not had the recall completed will be notified beginning august 6, 2008. owners may contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 4707h.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09V414000 on 10/26/2009
Component:
Vehicle speed control:cruise control
Manufactured:
08/05/2001 - 07/30/2002
Affected:
39,600
Defect:
Mazda is recalling model year 1995 through 1997 and model year 2001 through 2003 trucks equipped with texas instruments speed control deactivation switch (scds) and/or anti-lock brake system (abs) and manufactured on or before december 5, 2002. a component of the cruise control deactivation switch may deteriorate over time and develop a leak. this occurrence could cause the switch to overheat, smoke or burn which could result in an under hood fire.
Consequence:
A vehicle fire could occur with or without the engine running.
Correction:
Mazda will notify owners that dealers will install a universal fused jumper harness on the cruise control deactivation switch free of charge. the safety recall began on december 11, 2009. owners may contact mazda at 1-800-222-5500 option #6.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2002 MAZDA B-SERIES TRUCK TSBs (75)

Bulletin:
0100302
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding recommended engine oil. *slc
Bulletin:
0100402
Component:
070000 fuel system, gasoline
Summary:
Subject regarding diagnostic information of oxygen sensor, catalyst efficiency and fuel system monitors. *slc
Bulletin:
0101202
Component:
980000 unknown or other
Summary:
Subject regarding 4.0l sohc engine - malfunction indicator lamp illuminated with diagnostic trouble code p0300. *slc
Bulletin:
0501002
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with automatic transmission and built between 01-jun-2001 and 31-mar-2002 may exhibit a fluid leak at a transmission servo cover (intermediate and/or overdrive). *slc
Bulletin:
0600102
Component:
011000 steering:wheel and handle bar
Summary:
Clicking noise while turning the steering wheel. *tt this bulletin replaces previous bulletin 06-001-02 dated 6/18/2002. *tt
Bulletin:
0500402
Component:
101000 power train:clutch assembly
Summary:
Service bulletin regarding a hooting, eeking, or moaning noise coming from the clutch when shifting into gears, while the engine is running. *tt
Bulletin:
0101502
Component:
100000 power train
Summary:
Some vehicles may exhibit inoperative or inaccurate speedometer, 4x4 lamp illumination, and / or diagnostic trouble codes p1635 and / or p1639, p0602 present after power train control module (pcm) or instrument cluster replacement. *tt
Bulletin:
0102402
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may exhibit a primary timing chain rattle noise between 2000-3000 rpm. *tt
Bulletin:
0500902
Component:
103000 power train:automatic transmission
Summary:
Automatic tranmission slipping, delayed engagement and diagnostic trouble codes p0732, p0733 or p1762. *tt
Bulletin:
0901202
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding passive anti-theft (pats) diagnostic service tips. *tt
Bulletin:
0901202
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Passive anti-theft (pats) diagnostic service tips. *tt
Bulletin:
0100303
Component:
061000 engine and engine cooling:engine
Summary:
Front crankshaft bolt service warning. *tt
Bulletin:
0100203
Component:
090000 fuel system, other
Summary:
Reduced capacity obd evaporative emission monitor calibration update. *tt
Bulletin:
0100503
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) on and/or diagnostic trouble codes p0401, p0402, p1400 or p1401 and runs rough, lacks power, surge, poor fuel economy. *tt
Bulletin:
0100703
Component:
061000 engine and engine cooling:engine
Summary:
Rough idle / engine vibration. *tt
Bulletin:
0800203
Component:
140000 air bags
Summary:
Safety belt pretensioner diagnostic trouble code b1877 / lfc 46 and / or diagnostic trouble code b1881 / lfc 47. *tt
Bulletin:
0500503
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Transmission fluid in-line filter kit - repeat repairs of transmission - service tips. *tt
Bulletin:
0300303
Component:
100000 power train
Summary:
Thumping noise / bumping sensation accelerating from a stop. this bulletin also supersedes 03-002/01r. *tt
Bulletin:
0902203
Component:
116100 electrical system:ignition:switch
Summary:
Sticking or binding ignition lock cylinder or high effort when turning ignition switch. *tt
Bulletin:
0300303
Component:
105300 power train:driveline:driveshaft
Summary:
4wd-b-series-thumping noise/bumping sensation accerlerating from a stop. *mn *tt
Bulletin:
0902503
Component:
110000 electrical system
Summary:
Service wiring harness replacement guidelines - service tips - electrical. *tt this bulletin replaces previous bulletin 09-025-03 dated 12/1/2003. *tt
Bulletin:
0103003
Component:
110000 electrical system
Summary:
A malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap light illuminated with dtc p0457. various models including the 2005 tribue and 2004 b-series. *tt
Bulletin:
0102903
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) on with or without rough running, lack of power, surge or poor fuel economy, along with diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. *tt
Bulletin:
0004123
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
B28 and later pcm calibration update information. repair information review1. *tt
Bulletin:
0004110
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
A loud accessory drive belt squeal and/or chirp under all driving conditions on certain vehicles built prior to 09/18/03. repair information review1. 2004 models also included. *tt
Bulletin:
0004164
Component:
061000 engine and engine cooling:engine
Summary:
Spark knock, detonation or ping condition throttle tip-in or during steady state operation at or near wide open throttle on certain vehicles equipped with 3.0l ffv/efi engines. repair information review1. *tt
Bulletin:
0100304
Component:
061000 engine and engine cooling:engine
Summary:
3.0l lower engine oil leaks- diagnostic-service tip. *jb tt
Bulletin:
0900504
Component:
162000 structure:body
Summary:
Bed extender component replacement and removal/ installation instructions. also including the 2004 mazda b-series.*mr
Bulletin:
0101504
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) on and/or diagnostic trouble codes p0401, p0402, p1400 or p1401 and runs rough, lacks power, surge, poor fuel economy. *tt this bulletin replaces previous bulletin dated 4/26/04. *tt
Bulletin:
0902004
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Exterior mirror glass and motor replacement guidelines. *mj
Bulletin:
0101505
Component:
061000 engine and engine cooling:engine
Summary:
Front crankshaft bolt service warning. *mj including 2005 mazda b2300 and 2005 mazda6. (update) *sc
Bulletin:
0407
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Dpfe sensor application revision. parts flash. *tt dpfe sensor warranty extension program - special service program (ssp) 59. *tt
Bulletin:
53
Component:
190000 tires
Summary:
Firestone wilderness at tire replacement spp 53 program end. mazda has revised the expiration date for special service program (ssp) 53 to september 15, 2004. this change is to ensure that all customers have affected tires replaced. *t
Bulletin:
53
Component:
190000 tires
Summary:
Firestone wilderness at tire replacement ssp 53 program end. ssp 53 ends september 13, 2004. this communication and the attachments provide updated program end information. *tt
Bulletin:
53
Component:
190000 tires
Summary:
Wilderness at tire replacement program end with attached updates and program changes. *tt
Bulletin:
0902604
Component:
353000 equipment:electrical
Summary:
Speedometer replacement procedure. *tt
Bulletin:
0102504
Component:
111000 electrical system:battery
Summary:
Battery test procedure requirements. *tt
Bulletin:
08022004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release. *tt
Bulletin:
0102604
Component:
061000 engine and engine cooling:engine
Summary:
Rough idle and/or 1800-2200 rpm boom/vibration. *tt
Bulletin:
08042004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release - 08/04/2004. *tt
Bulletin:
0400504
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Grabbing condition from rear drum brakes. *tt updated 4/25/08. *nj
Bulletin:
59
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Delta pressure feedback egr (dpfe) sensor warranty extension program. special service program (ssp) 59. *tt
Bulletin:
06012004
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Programmable module installation. ( 2004 mazda b series) *jb
Bulletin:
0800405
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retracts too slowly. mazda including 2006 b-series trucks. *sc
Bulletin:
0101505
Component:
060000 engine and engine cooling
Summary:
Front crankshaft bolt service warning. *sc
Bulletin:
0300104
Component:
100000 power train
Summary:
Thump / clunk from driveline on light acceleration or when stopping. *tt
Bulletin:
0901703
Component:
114000 electrical system:wiring
Summary:
Electrical - wiring - soldering and crimping repairs - service tip. *tt
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
0102206
Component:
021000 suspension:front
Summary:
Front crankshaft bolt service warning. *nj
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
00-004/12
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
05-002-13-2777
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
05-001-16-3128
Component:
355200 equipment:other:owners/service/other manual
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:' atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy