2002 INTERNATIONAL RE BUS Recall
- Campaign:
- 02V004010 on 09/24/2002
- Component:
- Vehicle speed control
- Manufactured:
- 02/06/1994 - 08/20/2002
- Affected:
- 31,145
- Defect:
- On certain school and transit buses equipped with electronic throttle control/accelerator pedals supplied by williams controls industries, the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
- Consequence:
- If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
- Correction:
- International will retrofit vehicles with a new pedal rod and bracket. owner notification began december 16, 2002. owners who do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
2002 INTERNATIONAL RE BUS TSBs (38)
- Bulletin:
- IK-2200060
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- International bus: bus, passenger window plastic guide. passenger split sash windows that are hard to slide and exhibit latching issues may have the plastic slide broken loose and out of position causing the window to bind. windows are h
- Bulletin:
- SB-IK-2200069-5
- Component:
- 162300 structure:body:door
- Summary:
- Navistar: forward door bracket pulled loose from the door. improper adjustment, loose attachment bolts, or an obstruction limiting door travel are the most common cause. *rm
- Bulletin:
- IK-0800219
- Component:
- 060000 engine (pws)
- Summary:
- International/navistar: a new design aps sensors (accelerator position sensor) has been developed to replaced open/closed ivs switches in old sensors. *pe updated 11/6/2013 *js updated 1/27/15. *pe
- Bulletin:
- IK-2200116
- Component:
- 162300 structure:body:door
- Summary:
- International: air door has bent adjustment rods, poor link arm clearance, opens due to highway speeds or cross winds, water leaks, fails to close. while electric door has similar issues, motor failure, water leaks, header box fit, poor li
- Bulletin:
- IK-2200117
- Component:
- 110000 electrical system
- Summary:
- International: information provided regarding procedure to replacing and adjusting electric door drive motor on buses. *pe
- Bulletin:
- IK-2200069
- Component:
- 162300 structure:body:door
- Summary:
- Iknow: use the reinforcement kit to repair bus door entrance failures. applies to vehicle models cs, ic, be ce, fe, re buses built before 9/15/2011. *js updated 12/18/13. *pe
- Bulletin:
- IK-2200085
- Component:
- 114000 electrical system:wiring
- Summary:
- Iknow: some vehicles are experiencing reversed polarity of the power and ground circuits to the pump. this causes the pump to operate backwards. models include all ce, re, and fe buses. no specific model years were provided.*js
- Bulletin:
- IK-1500051
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
- Bulletin:
- IK1200029
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Radiator internal restriction and flush procedure
- Bulletin:
- IK1201360
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1201363
- Component:
- 070000 fuel system, gasoline
- Summary:
- Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1900022
- Component:
- 353600 equipment:air conditioner
- Summary:
- A/c refrigerant and oil capacities
- Bulletin:
- IK2700090
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand ez-tech download center
- Bulletin:
- IK2700100
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand eztech
- Bulletin:
- IK2900030
- Component:
- 118000 electrical system: software
- Summary:
- Dealer ez-tech and diagnostic software support resource center
- Bulletin:
- IK0800341
- Component:
- 110000 electrical system
- Summary:
- Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK1200921
- Component:
- 118000 electrical system: software
- Summary:
- Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
- Bulletin:
- IK1201009
- Component:
- 060000 engine (pws)
- Summary:
- Winter front usage
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities
- Bulletin:
- IK2700100
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand ez-tech
- Bulletin:
- IK4300001
- Component:
- 118000 electrical system: software
- Summary:
- Updating oncommand link with accelerator
- Bulletin:
- IK0500038
- Component:
- 010000 steering
- Summary:
- Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
- Bulletin:
- IK0500058
- Component:
- 010000 steering
- Summary:
- Steering fluids
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800351
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link source address information
- Bulletin:
- IK1201248
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Cooling system flush procedure
- Bulletin:
- IK2500511
- Component:
- 118000 electrical system: software
- Summary:
- Using supplier software to check dtcs
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0700096
- Component:
- 110000 electrical system
- Summary:
- Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
- Bulletin:
- IK0700097
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- New ultrasonic def tank sending unit; only models with scr aftertreatment system.
- Bulletin:
- IK0800546
- Component:
- 060000 engine and engine cooling
- Summary:
- Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
- Bulletin:
- IK0800080
- Component:
- 353000 equipment:electrical
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800059
- Component:
- 110000 electrical system
- Summary:
- Brake lights staying on
- Bulletin:
- IK0800092
- Component:
- 111000 electrical system:battery
- Summary:
- First check to make when troubleshooting any body controller or esc issue
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
- Bulletin:
- IK1900022
- Component:
- 060000 engine (pws)
- Summary:
- A/c refrigerant and oil capacities
Home | Privacy