2002 INTERNATIONAL 7400 Recalls (5)

Campaign:: 02V205000 on 07/31/2002
Component:: Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:: 07/18/2001 - 07/15/2002
Affected:: 1,066
Defect:: On certain heavy duty trucks, the fuel line is routed too close to a turbo charger outlet/exhaust pipe. if an interference condition occurs between the fuel harness and the exhaust pipe, the fuel line inside the reflective heat wrap could melt due to excessive heat.
Consequence:: The melting of the line could result in immediate engine shut down, increasing the risk of a crash.
Correction:: Dealers will inspect the vehicles for proper routing of the fuel harness. if the harness is routed near the exhaust system, a new fuel harness will be installed. owner notification began december 27, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Notes:: Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:: 03V161000 on 04/29/2003
Component:: Visibility:windshield wiper/washer
Manufactured:: 10/23/2000 - 10/14/2001
Affected:: 15,354
Defect:: Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 104, "windshield wiping and washing systems." due to the design of the windshield washer pump motor circuit, the system's ability to function is impaired when it is full of frozen water and the pump motor shaft is locked or frozen (cannot rotate).
Consequence:: Any resultant reduced visibility could cause a crash.
Correction:: Dealers will install a new 10 amp fuse in place of the 5 amp fuse and a new 10 amp label will be placed over the original 5 amp designation on the fuse panel label. owner notification began on june 27, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Notes:: International recall no. 01516.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:: 04V144000 on 03/25/2004
Component:: Power train:driveline:universal joint
Manufactured:: 09/26/2001 - 03/07/2004
Affected:: 2,021
Defect:: On certain trucks equipped with dt466 or dt530 1308 style engines and 4x4 or 6x6 capability, the universal joint between the front drive shaft and drive axle could come in contact with the engine oil filter under certain braking conditions.
Consequence:: This could cause a loss of complete engine oil which could result in the engine shutting down and increase the risk of property damage, personal injury, or a crash.
Correction:: Dealers will install a shorter oil filter and adapter. owner notification is expected to begin april 29, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Notes:: International recall no. 04504.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:: 04V306000 on 06/29/2004
Component:: Electrical system:battery:cables
Manufactured:: 08/14/2001 - 05/19/2004
Affected:: 18,545
Defect:: On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar i-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
Consequence:: This could cause an electrical short and/or fire.
Correction:: Dealers will inspect for any chafing. if there is no evidence of chafing, a saddle clamp will be installed. if there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. the recall began on august 16, 2004. owners should contact international at 1-800-448-7825.
Notes:: International recall no. 04510. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:: 05V188000 on 04/28/2005
Component:: Trailer hitches:fifth wheel assembly
Manufactured:: 10/09/2001 - 03/20/2005
Affected:: 4,616
Defect:: On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. this could result in inadvertent operation of the fifth wheel slide control.
Consequence:: If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning.
Correction:: Dealers will relocate the msva 7-pack to a less water intensive environment. a new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. the recall began on august 5, 2005. owners may contact international at 1-800-448-7825.
Notes:: International recall no.05511. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2002 INTERNATIONAL 7400 TSBs (38)

Bulletin:: 0308
Component:: 110000 electrical system
Summary:: Instrument cluster pto indicator light activation while using in-cab or remote engine speed control. various models including the 7600 and 8600. *tt
Bulletin:: 04901
Component:: 061000 engine and engine cooling:engine
Summary:: High pressure oil pump fitting and plug leakage in international truck and bus models built between march 1, 2002 and october 15, 2002 with international dt 466e and 530e engines. models ic bus, 3000fe, 3000re, 3200, 3800, 4300, 4400, 7300
Bulletin:: 0438
Component:: 110000 electrical system
Summary:: Hvac setting fault code 613-14-1-6 prematurely. *mj
Bulletin:: 04903
Component:: 061000 engine and engine cooling:engine
Summary:: Replace meritor transfer case il pump with new design oil pump in 7300, 7400, 7500 4x4 and 6x6 models built between september 27, 2001 and september 15, 2003. international models 7300, 7400, 7500 start date 09/01 end date 09/03. *
Bulletin:: 051501
Component:: 091100 fuel system, other:storage:tank assembly
Summary:: Dual fuel tank transfer pump system with two wire fuel transfer pump troubleshooting. international. *tt
Bulletin:: 061208
Component:: 061000 engine and engine cooling:engine
Summary:: The engine turbocharger clean air intake hose nipple that provides air to the air compressor may disconnect from the intake hose in a limited number of international 7300 models built between december 01, 2004 with international i-6 engines
Bulletin:: 061302
Component:: 104000 power train:transfer case (4-wheel drive)
Summary:: Guidelines to ensure satisfactory performance of meritor transfer case models mtc-4208, mtc-4210, mtc-4213 in certain international 7000 hpv models. *tt
Bulletin:: IK-0800219
Component:: 060000 engine (pws)
Summary:: International/navistar: a new design aps sensors (accelerator position sensor) has been developed to replaced open/closed ivs switches in old sensors. *pe updated 11/6/2013 *js updated 1/27/15. *pe
Bulletin:: IK-1500051
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
Bulletin:: 2016-0893
Component:: 350000 equipment
Summary:: E-one vehicles are designed with electrical circuit protection (e.g. fuses), to provide overcurrent protection during short-circuit conditions or malfunction of components. fuses are sometimes shared amongst different circuits. for example,
Bulletin:: IK1200029
Component:: 062100 engine and engine cooling:cooling system:radiator assembly
Summary:: Radiator internal restriction and flush procedure
Bulletin:: IK1201360
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
Bulletin:: IK1201363
Component:: 070000 fuel system, gasoline
Summary:: Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
Bulletin:: IK1900022
Component:: 353600 equipment:air conditioner
Summary:: A/c refrigerant and oil capacities
Bulletin:: IK2700090
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Oncommand ez-tech download center
Bulletin:: IK2700100
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Oncommand eztech
Bulletin:: IK2900030
Component:: 118000 electrical system: software
Summary:: Dealer ez-tech and diagnostic software support resource center
Bulletin:: IK0800341
Component:: 110000 electrical system
Summary:: Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
Bulletin:: IK0800080
Component:: 118000 electrical system: software
Summary:: J1939 data link troubleshooting
Bulletin:: IK1200921
Component:: 118000 electrical system: software
Summary:: Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
Bulletin:: IK1201009
Component:: 060000 engine (pws)
Summary:: Winter front usage
Bulletin:: IK1201299
Component:: 060000 engine (pws)
Summary:: Engine oil capacities
Bulletin:: IK2700100
Component:: 118000 electrical system: software
Summary:: Oncommand ez-tech
Bulletin:: IK4300001
Component:: 118000 electrical system: software
Summary:: Updating oncommand link with accelerator
Bulletin:: IK0500038
Component:: 010000 steering
Summary:: Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
Bulletin:: IK0500058
Component:: 010000 steering
Summary:: Steering fluids
Bulletin:: IK0800080
Component:: 118000 electrical system: software
Summary:: J1939 data link troubleshooting
Bulletin:: IK0800351
Component:: 118000 electrical system: software
Summary:: J1939 data link source address information
Bulletin:: IK1201248
Component:: 062000 engine and engine cooling:cooling system
Summary:: Cooling system flush procedure
Bulletin:: IK2500511
Component:: 118000 electrical system: software
Summary:: Using supplier software to check dtcs
Bulletin:: IK0800080
Component:: 118000 electrical system: software
Summary:: J1939 data link troubleshooting
Bulletin:: IK0700096
Component:: 110000 electrical system
Summary:: Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
Bulletin:: IK0700097
Component:: 061200 engine and engine cooling:engine:diesel
Summary:: New ultrasonic def tank sending unit; only models with scr aftertreatment system.
Bulletin:: IK0800546
Component:: 060000 engine and engine cooling
Summary:: Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
Bulletin:: IK0800080
Component:: 353000 equipment:electrical
Summary:: J1939 data link troubleshooting
Bulletin:: IK0800475
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Radio diagnostics and information
Bulletin:: IK1201299
Component:: 060000 engine (pws)
Summary:: Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
Bulletin:: IK1900022
Component:: 060000 engine (pws)
Summary:: A/c refrigerant and oil capacities

Home | Privacy