2002 INTERNATIONAL 7300 Recalls (4)
- Campaign:
- 02V205000 on 07/31/2002
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 07/18/2001 - 07/15/2002
- Affected:
- 1,066
- Defect:
- On certain heavy duty trucks, the fuel line is routed too close to a turbo charger outlet/exhaust pipe. if an interference condition occurs between the fuel harness and the exhaust pipe, the fuel line inside the reflective heat wrap could melt due to excessive heat.
- Consequence:
- The melting of the line could result in immediate engine shut down, increasing the risk of a crash.
- Correction:
- Dealers will inspect the vehicles for proper routing of the fuel harness. if the harness is routed near the exhaust system, a new fuel harness will be installed. owner notification began december 27, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V161000 on 04/29/2003
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 10/23/2000 - 10/14/2001
- Affected:
- 15,354
- Defect:
- Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 104, "windshield wiping and washing systems." due to the design of the windshield washer pump motor circuit, the system's ability to function is impaired when it is full of frozen water and the pump motor shaft is locked or frozen (cannot rotate).
- Consequence:
- Any resultant reduced visibility could cause a crash.
- Correction:
- Dealers will install a new 10 amp fuse in place of the 5 amp fuse and a new 10 amp label will be placed over the original 5 amp designation on the fuse panel label. owner notification began on june 27, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- Notes:
- International recall no. 01516.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V144000 on 03/25/2004
- Component:
- Power train:driveline:universal joint
- Manufactured:
- 09/26/2001 - 03/07/2004
- Affected:
- 2,021
- Defect:
- On certain trucks equipped with dt466 or dt530 1308 style engines and 4x4 or 6x6 capability, the universal joint between the front drive shaft and drive axle could come in contact with the engine oil filter under certain braking conditions.
- Consequence:
- This could cause a loss of complete engine oil which could result in the engine shutting down and increase the risk of property damage, personal injury, or a crash.
- Correction:
- Dealers will install a shorter oil filter and adapter. owner notification is expected to begin april 29, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- Notes:
- International recall no. 04504.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V306000 on 06/29/2004
- Component:
- Electrical system:battery:cables
- Manufactured:
- 10/01/2001 - 05/18/2004
- Affected:
- 18,545
- Defect:
- On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar i-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
- Consequence:
- This could cause an electrical short and/or fire.
- Correction:
- Dealers will inspect for any chafing. if there is no evidence of chafing, a saddle clamp will be installed. if there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. the recall began on august 16, 2004. owners should contact international at 1-800-448-7825.
- Notes:
- International recall no. 04510. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
2002 INTERNATIONAL 7300 TSBs (36)
- Bulletin:
- 0308
- Component:
- 110000 electrical system
- Summary:
- Instrument cluster pto indicator light activation while using in-cab or remote engine speed control. various models including the 7600 and 8600. *tt
- Bulletin:
- 04901
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- High pressure oil pump fitting and plug leakage in international truck and bus models built between march 1, 2002 and october 15, 2002 with international dt 466e and 530e engines. models ic bus, 3000fe, 3000re, 3200, 3800, 4300, 4400, 7300
- Bulletin:
- 0438
- Component:
- 110000 electrical system
- Summary:
- Hvac setting fault code 613-14-1-6 prematurely. *mj
- Bulletin:
- 04903
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Replace meritor transfer case il pump with new design oil pump in 7300, 7400, 7500 4x4 and 6x6 models built between september 27, 2001 and september 15, 2003. international models 7300, 7400, 7500 start date 09/01 end date 09/03. *
- Bulletin:
- 051501
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Dual fuel tank transfer pump system with two wire fuel transfer pump troubleshooting. international. *tt
- Bulletin:
- 061208
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- The engine turbocharger clean air intake hose nipple that provides air to the air compressor may disconnect from the intake hose in a limited number of international 7300 models built between december 01, 2004 with international i-6 engines
- Bulletin:
- 061302
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Guidelines to ensure satisfactory performance of meritor transfer case models mtc-4208, mtc-4210, mtc-4213 in certain international 7000 hpv models. *tt
- Bulletin:
- IK-1500051
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Ik1500051 - davco fuel pro 382 technical manual, installation, diagnostics, and service
- Bulletin:
- IK1200029
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Radiator internal restriction and flush procedure
- Bulletin:
- IK1201360
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1201363
- Component:
- 070000 fuel system, gasoline
- Summary:
- Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1900022
- Component:
- 353600 equipment:air conditioner
- Summary:
- A/c refrigerant and oil capacities
- Bulletin:
- IK2700090
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand ez-tech download center
- Bulletin:
- IK2700100
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand eztech
- Bulletin:
- IK2900030
- Component:
- 118000 electrical system: software
- Summary:
- Dealer ez-tech and diagnostic software support resource center
- Bulletin:
- IK0800341
- Component:
- 110000 electrical system
- Summary:
- Trailer auxiliary switch lamp burning out; only vehicles equipped with feature code 0008tth or 0008thg
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK1200921
- Component:
- 118000 electrical system: software
- Summary:
- Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
- Bulletin:
- IK1201009
- Component:
- 060000 engine (pws)
- Summary:
- Winter front usage
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities
- Bulletin:
- IK2700100
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand ez-tech
- Bulletin:
- IK4300001
- Component:
- 118000 electrical system: software
- Summary:
- Updating oncommand link with accelerator
- Bulletin:
- IK0500038
- Component:
- 010000 steering
- Summary:
- Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
- Bulletin:
- IK0500058
- Component:
- 010000 steering
- Summary:
- Steering fluids
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800351
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link source address information
- Bulletin:
- IK1201248
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Cooling system flush procedure
- Bulletin:
- IK2500511
- Component:
- 118000 electrical system: software
- Summary:
- Using supplier software to check dtcs
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0700096
- Component:
- 110000 electrical system
- Summary:
- Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
- Bulletin:
- IK0700097
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- New ultrasonic def tank sending unit; only models with scr aftertreatment system.
- Bulletin:
- IK0800546
- Component:
- 060000 engine and engine cooling
- Summary:
- Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
- Bulletin:
- IK0800080
- Component:
- 353000 equipment:electrical
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities all electronic international engines 1994 - present. cummins isb, ism & isx
- Bulletin:
- IK1900022
- Component:
- 060000 engine (pws)
- Summary:
- A/c refrigerant and oil capacities
Home | Privacy