2002 GMC ENVOY XL Recalls (3)
- Campaign:
- 04V046000 on 02/05/2004
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 09/30/2000 - 06/29/2002
- Affected:
- 581,394
- Defect:
- Certain sport utility vehicles have windshield wiper systems that will not turn on, cease operation while in use, fail to turn off/on by themselves (moisture sensitive wiper system), or have continuous windshield washer pump operation because the presence of water within the wiper modules can either cause a short circuit or can lead to the corrosion of components within the module.
- Consequence:
- Depending on the occurrence and weather situation, driver visibility could be reduced, which could result in a crash.
- Correction:
- Dealers will cover the windshield wiper module vent hole with a patch. also, the wiper motor, circuit board, and electrical connector will be inspected to signs of water intrusion and/or corrosion and be replaced as required. the recall began july 6, 2004. owners should contact chevrolet at 1-800-630-2438; oldsmobile at 1-800-630-6537; or gmc at 1-866-996-9463.
- Notes:
- Gm recall no. 04005.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V527000 on 11/02/2004
- Component:
- Exterior lighting:brake lights
- Manufactured:
- 09/30/2000 - 06/29/2002
- Affected:
- 871,473
- Defect:
- On certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. if this occurs, the bulb may flicker and eventually become inoperative.
- Consequence:
- An inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver's intention to turn to drivers in following vehicles. both of these failures can increase the risk of a crash.
- Correction:
- Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. the recall began on november 22, 2004. owners should contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, buick at 1-866-608-8080, or gmc at 1-866-996-9463.
- Notes:
- Gm recall no. 04087. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V494000 on 10/26/2005
- Component:
- Latches/locks/linkages:doors:latch
- Manufactured:
- 12/31/2001 - 06/29/2002
- Affected:
- 98,007
- Defect:
- Certain sport utility vehicles have a rear side closure latch that may not latch or unlatch due to corrosion caused by road splash, such as water and road salt. these vehicles were originally sold in or currently registered in the following states: connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia.
- Consequence:
- If the door is not latched properly and it goes unnoticed, it may open while the vehicle is in motion. if an unbelted occupant fell out of the vehicle, personal injuries could occur.
- Correction:
- Dealers will install a seal along the lower part of the rocker panel to prevent intrusion of corrosive material, and inspect the rear side closure latches. functional latches will be cleaned and lubricated. non-functioning latches will be replaced. the recall began on february 24, 2006. owners may contact chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or isuzu at 1-800-255-6727.
- Notes:
- Gm recall no. 05077. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2002 GMC ENVOY XL TSBs (40)
- Bulletin:
- 020526001B
- Component:
- 040000 service brakes, air
- Summary:
- Rear parking brake shoe retaining spring clip service kit for drum-in-hat (dih) equipped vehicles. *tt update. *tt
- Bulletin:
- 01764
- Component:
- 070000 fuel system, gasoline
- Summary:
- Vehicle difficult to fill with fuel/ filling station pump shuts off before tank full. also including 2003 buick rainier. *mr
- Bulletin:
- 01900
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Under hood fuse block - 125 amp mega fuse blown. also including buick rainier 2002, 2003. *mr
- Bulletin:
- 01676
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- 4.2 4l60e engine cooling fan contacts shroud after replacing radiator. *mr
- Bulletin:
- 02023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Intermittent no crank no start. security light may be on or off. 4.2 ll8 engine. *nm
- Bulletin:
- 00949C
- Component:
- 162610 structure:body:hatchback/liftgate:hinge and attachments
- Summary:
- The liftgate or liftgate glass binds when opening or does not open completely because the center high mounted stop lamp (chmsl) applique hits the roof of the vehicle. *tt
- Bulletin:
- 040421001
- Component:
- 105000 power train:driveline
- Summary:
- Delayed engagement of front wheels during a slip condition. *mj
- Bulletin:
- 3145
- Component:
- 060000 engine and engine cooling
- Summary:
- When performing campaign 04048, the connector will not fit into the compressor. *tc
- Bulletin:
- 3151
- Component:
- 135100 visibility:rearview mirrors/devices:interior
- Summary:
- Inside rear view mirror does not display ambient temperature with cj2 option. *tc
- Bulletin:
- 3152
- Component:
- 353600 equipment:air conditioner
- Summary:
- Blower speed changes on its own. *tc update. *tt
- Bulletin:
- 04017A
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Tail lamp/stop lamp(s) may become inoperative. gm administrative message. *nm
- Bulletin:
- 3110A
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Washer motor for the front wipers continuously runs while the key on. *sc update. *tt
- Bulletin:
- 040845010
- Component:
- 110000 electrical system
- Summary:
- Various interior electrical concerns, ip gauges/lighting inoperative, hvac controls inoperative, blower motor inoperative, radio inoperative, flasher inoperative. *tt
- Bulletin:
- 030866008
- Component:
- 162000 structure:body
- Summary:
- Perimeter seal/gasket pulls away from license plate housing and/or excessive adhesive around gasket. *tt
- Bulletin:
- 040232001
- Component:
- 010000 steering
- Summary:
- Release of steering gear stub shaft bearing kit for service. *tt updated 08-15-07. *kb updated 10/09/07. *nj
- Bulletin:
- 20050577
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Fuel tank inlet check valve fracture. *eh
- Bulletin:
- 3335
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Supplement to campaign 04087 / screws break in the tail lamp housing. *sc
- Bulletin:
- 060866011
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Rear liftgate binds, improper fit. may be caused by broken welds or cracks formed around the two inner welds. *kb
- Bulletin:
- 040525002
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
- Bulletin:
- 07076
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Buick\chevrolet\gmc\oldsmobile service campaign: see document search button for owner letter. special coverage adjustment - fuel tank modular reservoir assembly corrosion. csc letter was received. updated 11/6/08. *pe updated 5
- Bulletin:
- 08-089
- Component:
- 353000 equipment:electrical
- Summary:
- Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
- Bulletin:
- 08089-B
- Component:
- 110000 electrical system
- Summary:
- General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
- Bulletin:
- SB-070417001D
- Component:
- 022000 suspension:rear
- Summary:
- Gmc/buick/oldsmobile/saab: bump or thump noise is heard coming from the rear suspension or felt in the floor. the information affect vehicles with g67 automatic level control rear suspension. *pe updated 3/30/11. *pe
- Bulletin:
- SB-10-08-50-003B
- Component:
- 221300 seats:front assembly:head restraint
- Summary:
- General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
- Bulletin:
- PIC-5050-A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC-4935-E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- GCUS-9-1493
- Component:
- 090000 fuel system, other
- Summary:
- 14423b - special coverage (revised part information and service procedure). a fuel tank inlet check valve (icv) could fracture. the icv is located above the full fuel level. a fractured icv could allow fuel vapors to pass through and dro
- Bulletin:
- GCUS-9-1522
- Component:
- 090000 fuel system, other
- Summary:
- 14423c - special coverage (revised service procedure). a fuel tank inlet check valve (icv) could fracture. the icv is located above the full fuel level. a fractured icv could allow fuel vapors to pass through and droplets of fuel to accu
- Bulletin:
- 16NA260
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
- Bulletin:
- 000601012F
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
- Bulletin:
- PI1394A
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
- Bulletin:
- PIC4935E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- PIC5050A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC5088F
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
- Bulletin:
- PIT5389A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
- Bulletin:
- PIT5485B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- PIT5485A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- 14423A
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- 14423a - special coverage (revised part information). some 2004 model year buick rainier, 2003-2004 model year chevrolet ssr, 2002-2004 model year chevrolet trailblazer, chevrolet trailblazer ext, gmc envoy, gmc envoy xl, and oldsmobile bra
- Bulletin:
- 14423A
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- 14423a - special coverage (revised part information). some 2004 model year buick rainier, 2003-2004 model year chevrolet ssr, 2002-2004 model year chevrolet trailblazer, chevrolet trailblazer ext, gmc envoy, gmc envoy xl, and oldsmobile bra
- Bulletin:
- 14423
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- 14423 - special coverage. some vehicles contain a fuel tank inlet check valve (icv) that could fracture. the icv is located above the full fuel level. a fractured icv could allow fuel vapors to pass through and droplets of fuel to accumulat
Home | Privacy