2002 FORD EXPLORER Recalls (10)

Campaign:
01V171000 on 05/31/2001
Component:
Tires:sidewall
Manufactured:
08/13/2000 - 04/26/2001
Affected:
52,000
Defect:
Vehicle description: sport utility vehicles. the right side tires may have horizontal cuts on the edge of the tread that could have occurred during vehicle assembly.
Consequence:
Over time, the tire could fail, increasing the risk of a crash.
Correction:
Dealers will inspect the tires and, if any slices are found, the cut tires will be replaced. owner notification began june 7, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01I010000 on 07/22/2001
Component:
Visibility:glass, side/rear
Manufactured:
02/04/2001 - 03/29/2001
Affected:
50,224
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 2002 ford explorer and mercury montaineer sport utility vehicles. the brackets connecting the left cylinders to each side of the liftgate glass could rotate out of position if either the urethane bond or torque are not sufficient.
Consequence:
Rotation of the brackets could potentially cause the lift cylinders to detach from the glass or, in some cases, could potentially cause the liftgate glass to break. either condition is most likely to occur when the glass is being closed.
Correction:
Ford dealers will inspect the vehicles for the position of both the left and right liftgatge glass lift cylinder brackets. if the brackets are in the proper position, the bracket retainers will be tightened to a higher torque. in cases where the bracket is not properly position, the bracket must be re-aligned.
Notes:
Ford has decided to conduct a special service campaign to inspect and torque the liftgate glass bracket on affected vehicles. owners can contact ford at1-800-392-3673, concerning this program.
Campaign:
03V094000 on 03/17/2003
Component:
Structure
Manufactured:
07/31/2000 - 03/02/2003
Affected:
3,674
Defect:
Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. these units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Consequence:
This overheating condition can cause the running board to melt or cause a fire.
Correction:
Dealers will replace the wiring harness on these running boards. owner notification began march 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V442000 on 09/14/2004
Component:
Structure:body:hatchback/liftgate:hinge and attachments
Manufactured:
07/31/2000 - 06/22/2003
Affected:
955,732
Defect:
On certain sport utility vehicles, the liftgate glass strut may become disengaged or the hinge may fracture allowing the glass to fall and possibly break.
Consequence:
If the hinge should fracture, there is a potential for the glass to fall and ultimately break and personal injuries could occur.
Correction:
Dealers will have the liftgate glass strut brackets and glass hinges replaced. for the vehicles built from august 1, 2000 through march 3, 2002, the dealers will replace the hinges and liftgate strut bracket. on vehicles built from march 3, 2002 through june 23, 2003, the dealers will only replace the hinges. the recall began on september 30, 2004. a postcard was sent to owners on december 27, 2004, advising them that parts are now available. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 04s20.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E104000 on 12/10/2007
Component:
Visibility:glass, side/rear
Affected:
1,657
Defect:
Certain curved tempered replacement glass manufactured by hangzhou safety glass ltd and supplied to safelite by auto temp inc., identified as dot-430, and sold for use on certain domestic and foreign vehicles may not break into small pieces as expected of tempered glass and fails to conform to federal motor vehicle safety standard no. 205, "glazing materials."
Consequence:
In the event of a vehicle crash, the occupant(s) may be seriously injured by shattered glass.
Correction:
Safelite will notify its retail customers and replace the glass free of charge. retail customers can contact safelite toll free at 1-888-843-2906. safelite will notify its wholesale customers and reimburse wholesale customers for current inventory and at a specified rate for replacing their customer's glass. wholesale customers can contact safelite's wholesale division, service autoglass toll free at 1-888-246-6298. the recall began on january 15, 2008.
Notes:
This recall only pertains to certain curved tempered replacement glass manufactured by hangzhou safety glass, ltd. (dot-430) and supplied to safelite by auto temp inc., and has no relation to any original equipment installed on the vehicles listed above. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V399000 on 10/12/2009
Component:
Vehicle speed control
Manufactured:
08/10/1994 - 08/29/2002
Affected:
4,500,000
Defect:
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
Consequence:
A vehicle fire could occur with or without the engine running.
Correction:
Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
Notes:
Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2002 FORD EXPLORER TSBs (258)

Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
0186
Component:
106000 power train:axle assembly
Summary:
On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt
Bulletin:
01T02
Component:
132000 visibility:glass, side/rear
Summary:
Special service instructions for the liftgate glass bracket inspection and torque procedure. *tt
Bulletin:
14804
Component:
202000 wheels:center section
Summary:
Information on front wheel hub assemblies. *tt
Bulletin:
14827
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on vehicles equipped with with 5r55w transmission having a (powertrain control module) pcm adaptive learning strategy feature that controls shift feel and timing. *tt
Bulletin:
14866
Component:
100000 power train
Summary:
Some vehicles equipped with 5r55w transmission may exhibit various firm and / or soft shifts. *tt
Bulletin:
14868
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc engine may exhibit a primary chain rattle noise (sometimes described as a spark knock-type noise). *tt
Bulletin:
14710
Component:
980000 unknown or other
Summary:
Subject regarding edsr bonus points. *tt
Bulletin:
14714
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Information on availability of neutral tow kit. *tt
Bulletin:
14726
Component:
061000 engine and engine cooling:engine
Summary:
Information on the intake manifold valley stuffer bag. *tt
Bulletin:
14745
Component:
980000 unknown or other
Summary:
Information on obtaining engineering assistance for anti-lock brake system. *tt
Bulletin:
14759
Component:
103000 power train:automatic transmission
Summary:
Information regarding transmission oil level checking guidelines. *tt
Bulletin:
14723
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may exhibit a tinny rattle noise coming from the center steering column area while driving over bumpy roads. this may be due to a frequency being induced into the brake shift interlock (bsi) switch pintle, creating an audibl
Bulletin:
14741
Component:
980000 unknown or other
Summary:
Malfunction indicator lamp on with diagnostic trouble code p1633 and / or p1639 with no driveability concern present. *tt
Bulletin:
14742
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a malfunction indicator lamp (mil) on with egr system related diagnostic trouble codes p0400, p0401, p0402, p1400, p1401, p1405, p1406, p1408, p1409. *tt
Bulletin:
01102
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
A fluid leak at the transmission cooler line-to-transmission case connection. this may be caused by contamination on the cooler tube between the tube nut and flare, contamination on the tube nut threads or improper installation torque. v
Bulletin:
01107
Component:
330000 interior lighting
Summary:
Some vehicles built 11/13/2000 through 3/8/2001 equipped with a 5r55w transmission may exhibit a transmission control indicator lamp (tcil) flashing with various diagnostic trouble codes (dtcs) in self test. dtc p0713 is the code that is
Bulletin:
14903
Component:
046200 service brakes, air:antilock:interconnecting assembly(wiring)
Summary:
Information regarding trailer wiring - brake controller connector location. *tt
Bulletin:
14871
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit driveability conditions or check engine lamp (mil) illuminated with a diagnostic trouble code p0455 (gross leak detected). *tt
Bulletin:
14872
Component:
100000 power train
Summary:
Some vehicles may exhibit an intermittent no crank condition and no communication from the powertrain electronic controller (ptec) with the wds / ngs diagnostic equipment. *tt
Bulletin:
14874
Component:
103300 power train:automatic transmission:gear position indication (prndl)
Summary:
Some vehicles may exhibit a transmission shifter stuck in the park gear position. this may be due to the brake shift interlock switch. *tt
Bulletin:
14881
Component:
220000 seats
Summary:
Some vehicles equipped with 7 passenger seating may exhibit the 2nd row 40 percent seat back staying in the down position. this may be due to a rivet interference at the floorpan latches. *tt
Bulletin:
14890
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit excessive efforts when trying to insert or remove the key from the ignition lock. *tt
Bulletin:
14894
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a repetitive thump / knock noise from the rear which is proportional to wheel speed when brake. this may be caused by the initial finish / spiral cut of the rear break rotor(s). *tt
Bulletin:
14896
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may exhibit an error indicating that there is no communication or return diagnostic trouble codes (dtc) that are not related to the anti-lock brake (abs) system when retrieving dtcs from or attempting to view pids in the abs m
Bulletin:
14900
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit an anti-lock brake system light on with diagnostic trouble code c1230 and / or c1237 from the anti-lock brake system. *tt
Bulletin:
14901
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit a condition in which the rear door(s) will not unlock via manual or power operation. *tt
Bulletin:
14906
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on performing any passtive anti-theft (pats) system functions including key replacements with wds or ngs. *tt
Bulletin:
14923
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles equipped with 5r55w transmission may exhibit various firm and / or soft shifts. *tt
Bulletin:
14933
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp illuminated and a diagnostic trouble code (dtc) b1342 (anti-lock brake control module failure) in self test. *tt
Bulletin:
14934
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles equipped with 5r55w transmission may exhibit various firm and / or soft shifts. *tt
Bulletin:
14947
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may exhibit a steering wheel shudder during low speed turning maneuvers. *tt
Bulletin:
011002
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some 4-door vehicles built 11/13/2000 through 4/2/2001 equipped with the 5r55w transmission may exhibit a fluid leak at the transmission cooler line-to-transmission case connection. this may be caused by comtamination on the cooler tube b
Bulletin:
011007
Component:
980000 unknown or other
Summary:
Some vehicles built 11/13/2000 thorugh 3/8/2001 equipped with a 5r55w transmission may exhibit a transmission control indicator lamp (tcil) flashing with various diagnostic trouble codes (dtcs) in self test. dtc po713 is the code that is
Bulletin:
14741
Component:
980000 unknown or other
Summary:
Malfunction indicator lamp on with diagnostic trouble code p1633 and / or p1639 with no driveability concern present. *tt
Bulletin:
01132
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles produced before 6/3/2001 may exhibit the moonroof opening interior molding coming loose or the sunshade tearing during use. *tt
Bulletin:
01134
Component:
070000 fuel system, gasoline
Summary:
Fuel hesitation while making hard sweeping right hand turns (such as a highway on-ramp)
Bulletin:
01142
Component:
103000 power train:automatic transmission
Summary:
Some vehicles, built prior to 8/01/2001, may exhibit a whine or howl noise during cold starts at temperatures below 4 degrees c (40 degrees f). *tt
Bulletin:
15030
Component:
103500 power train:automatic transmission:lever and linkage:floor shift
Summary:
Some vehicles may exhibit a transmission shifter stuck in the park gear position. *tt
Bulletin:
15054
Component:
180000 vehicle speed control
Summary:
Vehicles with 4.0l engine may exhibit an intermittent hesitation on acceleration. *tt
Bulletin:
15055
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Information on the location of the heated seat switch. *tt
Bulletin:
15058
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 5r55w automatic transmission may exhibit a tick noise while at idle in park and neutral. *tt
Bulletin:
15069
Component:
103000 power train:automatic transmission
Summary:
Vehicles equipped with the 5r55w automatic transmission built prior to 08/01/2001 may exhibit a neutral out condition when coming to a stop. *tt
Bulletin:
15080
Component:
105300 power train:driveline:driveshaft
Summary:
Some vehicles with fewer than 10,000 miles may exhibit grease oozing from the front driveshaft cv joint. *tt
Bulletin:
15084
Component:
020000 suspension
Summary:
Steering wheel shudder during low-speed turning maneuvers. *tt
Bulletin:
15088
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 5r55w transmission may exhibit no transmission engagement into forward and / or reverse gear. *tt
Bulletin:
15090
Component:
162000 structure:body
Summary:
Some vehicles may develop yellow stains on the rear liftgate paint, usually noticed on white colored vehicles. *tt
Bulletin:
15091
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may exhibit a scrunch noise from the upper steering column when making near full lock turns. *tt
Bulletin:
15093
Component:
980000 unknown or other
Summary:
Exhibiting drivability conditions or check engine lamp illuminated with diagnostic trouble code p0455 (gross leak detected). *tt
Bulletin:
15103
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a rough idle or rought idle after initial start-up that clears up after a few minutes. *tt
Bulletin:
15104
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a rough idle or rough idle after initial start-up that clears up after a few minutes. *tt
Bulletin:
15105
Component:
180000 vehicle speed control
Summary:
Some vehicles equipped with a 4.0l engine may exhibit an intermittent hesitation on acceleration. *tt
Bulletin:
15107
Component:
116000 electrical system:ignition
Summary:
Some vehicles may require excessive effort when trying to insert the key into the ignition lock cylinder. *tt
Bulletin:
01111
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4.0l engine and 5r55w automatic transmission built 11/13/2000 through 5/21/2001 may exhibit light throttle soft or long 2-3 upshifts between 16-40 km/h (10-25 mph) or harsh 3-4 upshifts between 32-56 km/h (20-3
Bulletin:
01115
Component:
103700 power train:automatic transmission:torque converter
Summary:
Fluid leak in the converter housing area on vehicles built 11/13/2000 through 4/27/2001. *tt
Bulletin:
011110
Component:
161000 structure:frame and members
Summary:
Some vehicles equipped with a class ii hitch may exhibit insufficient clearance int he receiver to attach tubular hitch acessories to the vehicle. *tt
Bulletin:
01126
Component:
353600 equipment:air conditioner
Summary:
Some vehicles equipped with the manual a/c system may exhibit a continuous clicking noise from the blend door actuator whenthe blower speed is set at the #2 position and the temperature control knob is set between the 12:00 and 2:00 positio
Bulletin:
14795
Component:
023000 suspension:multiple axle
Summary:
Some vehicles may exhibit a noisy and / or loose front wheel bearing. *tt
Bulletin:
14983
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles equipped with 4.0l engine may exhibit excessive sulphur smell from the exhaust system while oeprating under drive modes. *tt
Bulletin:
15041
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with 4.0l engine may exhibit a rough idle condition. *tt
Bulletin:
15017
Component:
010000 steering
Summary:
Stiff steering or poor steering wheel returnability. *tt
Bulletin:
15019
Component:
102000 power train:manual transmission
Summary:
Some vehicles equipped with 5r55w transmission may exhibit a whine noise that occurs in 3rd gear only. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15156
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit damage to the radio antenna after running through certain car washes. *yh
Bulletin:
15182
Component:
162300 structure:body:door
Summary:
Information regarding autolock enabled/disable procedure correction. *yd
Bulletin:
15191
Component:
350000 equipment
Summary:
Information regarding new compass setting procedure, pdi must set all. *yd
Bulletin:
15193
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit intermittent difficulty turning the ignition key upon starting. *jg
Bulletin:
15181
Component:
102000 power train:manual transmission
Summary:
Some vehicles equipped with 4.6l engine and 5r55w transmission may exhibit various firm and/or soft shifts. *et
Bulletin:
15250
Component:
100000 power train
Summary:
Information regarding misdiagnosis of main controls - incorrect pressures. *tt
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15261
Component:
980000 unknown or other
Summary:
Information regarding the smokers package. *tt
Bulletin:
15210
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles equpped with 4.0l engine may exhibit excessive sulphur smell fromthe exhaust system while operating under certain drive modes related to calibration. *tt
Bulletin:
15215
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit drivability conditions or check engine lamp illuminated with diagnostic trouble code p0455 or p0457 stored. *tt
Bulletin:
15215
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit drivability conditions or check engine lamp illuminated with diagnostic trouble code p0455 or p0457. *tt
Bulletin:
15242
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit uneven air discharge temperatures in a/c cooling modes. *tt
Bulletin:
15248
Component:
045300 service brakes, air:disc:rotor
Summary:
Some owners may notice a knocking noise from the rear of the vehicle when the brakes are applied. *tt
Bulletin:
15251
Component:
105300 power train:driveline:driveshaft
Summary:
Some 4x4 vehicles with fewer than 10,000 miles may exhibit grease oozing from the front driveshaft cv joint. *tt
Bulletin:
15263
Component:
353600 equipment:air conditioner
Summary:
Concerns with a/c performance temp. difference side-side at registers. *tt
Bulletin:
15267
Component:
100000 power train
Summary:
Some vehicles with 5r5w may exhibit a no engagement condition. engineering is investigating. *tt
Bulletin:
01203
Component:
103000 power train:automatic transmission
Summary:
Exhibit harsh 1-2, 3-4 upshifts at light to medium throttle on some vehicles equipped with a 4.6l engine and 5r55w automatic transmission built through 9/21/2001. *tt
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
01207
Component:
103000 power train:automatic transmission
Summary:
Some vehicles produced before 9/6/2001 equipped with the 5r55w transmission may exhibit a tick noise emanating from the front or intermediate servo cover. *tt
Bulletin:
01B77
Component:
190000 tires
Summary:
Owner notification program supplement 7 revised information - regarding replacement of wilderness at tires. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15532
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Information on vehicles exhibitng fuel line damage due to pinching/squeezing of the fuel return line. *tt
Bulletin:
15504
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit driveabilty conditions and/or check engine lamp illuminated with a diagnostic trouble code p0455 (gross leak detected). *tt
Bulletin:
15519
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Some vehicles may experienced a strong sulphur odor during certain drive modes.*yd
Bulletin:
15540
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding engine wind noise.*yh
Bulletin:
15563
Component:
980000 unknown or other
Summary:
Information regarding malfunction indicator light illuminating with diagnostic trouble code p0300/p0301.*yh
Bulletin:
15575
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit the drivers door unlocking after it has been locked. *tt
Bulletin:
15580
Component:
010000 steering
Summary:
Some 4 door vehicles may exhibit a steering column rattle at speeds of 10-20 mph on uneven surfaces. *tt
Bulletin:
15590
Component:
111000 electrical system:battery
Summary:
Some vehicles may exhibit a battery draw and/or a dead battery condition. *tt
Bulletin:
15287
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a flutter/turbulence noise condition (i.e., helicopter noise) at highway speeds when the rear door windows are in the down position. *tt
Bulletin:
15286
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an intermittent no crank condition and no communication from the powertrain electronic controller (ptec) with the wds / ngs diagnostic equipment. *tt
Bulletin:
15290
Component:
061000 engine and engine cooling:engine
Summary:
Some 4.0l sohc may exhibit an engine oil leak condition, coming from the oil pan or ladder frame area. *tt
Bulletin:
15329
Component:
221200 seats:front assembly:recliner
Summary:
Some vehicles equipped with 3rd row seating may exhibit a condition with the seat release latch sticking/binding. *tt
Bulletin:
15335
Component:
162000 structure:body
Summary:
Concerns with squeak and rattle noiss coming from the instrument panel and from the side door windows. *tt
Bulletin:
01223
Component:
103700 power train:automatic transmission:torque converter
Summary:
Some vehicles built prior to 11/11/2001 equipped with 5r55w transmission and 4.6l engine, may exhibit a buzzing noise when the torque converter is engaged. *tt
Bulletin:
15378
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with the 4.0l engine may exhibit an engine flutter noise. *tt
Bulletin:
15383
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an intermittent no crank condition and no communication from the powertrain electronic controller with the wds/ngs diagnostic equipment. *tt
Bulletin:
15408
Component:
010000 steering
Summary:
Some vehicles equipped with dual automatic temperature control (datc) may exhibit inoperative redundant steering wheel controls (rswc). *tt
Bulletin:
15423
Component:
185000 vehicle speed control:cruise control
Summary:
Exhibiting rough idle, or rough idle upon initial start-up that clears up after a few minutes. *tt
Bulletin:
15445
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a rattle noise when closing either the midgate or the rear liftgate. *tt
Bulletin:
01245
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with the 4.0l engine may exhibit a condition of unable to access with the securilock passive anti-theft system (pats). *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15470
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with spark knock noise or chain rattle noise between 2000-3000 rpm, during cold engine operation only. *tt
Bulletin:
15486
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a check engine lamp illuminated with diagnostic trouble code p0457 (gross leak after fuel fill). *tt
Bulletin:
15489
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.6l engines may exhibit a high frequency whine noise (hair dryer type noise), that lasts for 30-60 seconds after cold start. *tt
Bulletin:
0222
Component:
060000 engine and engine cooling
Summary:
Some vehicles may exhibit an intake manifold crossover (first runner) coolant seepage condition. *tt
Bulletin:
0232
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 4.0l sohc engine may exhibit a check engine light on with diagnostic trouble codes p0300 (random misfire) or p0301. *tt
Bulletin:
15605
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit driveability conditions and / or check engine lamp illuminated with a diagnostic trouble p0455 (gross leak detected). *tt
Bulletin:
15646
Component:
106000 power train:axle assembly
Summary:
Concerns with clunk noise from front axle area. *tt
Bulletin:
15647
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles equipped with a v6 engine may exhibit a steering rattle noise which may be heard and felt in the steering wheel and column. *tt
Bulletin:
0276
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on diagnosing engine rattle noise from primary chain drive area between 2000-3000 rpm on cold engine operation only. *tt
Bulletin:
0262
Component:
103000 power train:automatic transmission
Summary:
Subject regarding 5r55w automatic transmission harsh upshifts during light to medium throttle concerns. *tt
Bulletin:
0256
Component:
980000 unknown or other
Summary:
This bulletin involves proper procedures for preparation of service sheet metal parts coated with electro deposition primer (e-coat). *tt
Bulletin:
0258
Component:
100000 power train
Summary:
Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
16090
Component:
220000 seats
Summary:
Some 4dr vehicles may exhibit seating appearance or related issues. *tt
Bulletin:
16094
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Some vehicles may exhibit fuel diagnostic trouble codes p0171, p0172, p0174, p0175 or mass air flow diagnostic trouble codes p0102, p0103, p0112, p0113. *tt
Bulletin:
16029
Component:
110000 electrical system
Summary:
Some vehicles may exhibit unintended smart unlock activation without key in ignition. *tt
Bulletin:
15683
Component:
121000 exterior lighting:headlights
Summary:
Some vehicles may exhibit a need for headlamp aim adjust after driving on rough roads. *tt
Bulletin:
15984
Component:
020000 suspension
Summary:
Exhibiting squeak / creak noises during front suspension movement. *tt
Bulletin:
15783
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit excessive sulphur smeel from the exhaust under certain drive modes. *tt
Bulletin:
15804
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built since october 1, 2001 may exhibit a no start condition or an intermittent no start condition, and / or possibly no communication from the powertrain electronic controller with the wds / ngs diagnostic equipment. *tt
Bulletin:
15829
Component:
353000 equipment:electrical
Summary:
Subject regarding cigar lighter revised installation procedures. *tt
Bulletin:
15853
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding intermittent engine quit during transmission engagements or parking maneuvers. *tt
Bulletin:
15892
Component:
162000 structure:body
Summary:
Subject regarding rear liftgate applique (trim panel) cracks. *tt
Bulletin:
15899
Component:
012200 steering:column locking:anti-theft device
Summary:
Subject regarding theft light relocation. *tt
Bulletin:
15906
Component:
015000 steering:hydraulic power assist system
Summary:
Information on power steering leak condition. *tt
Bulletin:
15910
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with brake vibration, roughness and / or grinding noise, and excessive brake rotor corrosion. *tt
Bulletin:
15938
Component:
350000 equipment
Summary:
Information used when replacing the drivers seat module. *tt
Bulletin:
0281
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc (single over-head cam) engine may exhibit a primary timing chain rattle noise. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
0361
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on with or without rough running, lack of power, surge or poor fuel economy with diagnostic trouble codes p0401, p0402, p1400, p1401. *tt *jb
Bulletin:
0365
Component:
110000 electrical system
Summary:
Intermittent fuel gauge level dropping to empty when fuel level is not actually empty. diagnostic trouble codes b1201, b1202, b1204 may or may not be present. *tt *jb
Bulletin:
0357
Component:
103000 power train:automatic transmission
Summary:
Fluid leak from the converter housing area. *tt *jb
Bulletin:
16688
Component:
132000 visibility:glass, side/rear
Summary:
Back glass hinge rattling/looseness, glass misalignment and/or glass hard-to-close. *tt *jb
Bulletin:
16702
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
4x4 control module not interchangeable issues. *tt *jb
Bulletin:
16703
Component:
110000 electrical system
Summary:
Battery light on or an alternator that is not charging. *tt *jb
Bulletin:
16706
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Squeaking accelerator pedal while driving during cold, hot, dusty, and dry conditions. *tt *jb
Bulletin:
16708
Component:
100000 power train
Summary:
An audible creak / click / pop (not a clunk) from the rear driveline. *tt *jb
Bulletin:
0322
Component:
061000 engine and engine cooling:engine
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401, or runs rough, lacks power, surge, poor fuel economy, and the above listed dtcs without
Bulletin:
0335
Component:
061000 engine and engine cooling:engine
Summary:
Idle air control (iac) valve diagnostic service tips. *tt
Bulletin:
16608
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Unintended door unlocks without key in ignition (qsf). *tt
Bulletin:
16617
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Open f2.20 5 amp fuse which may result in loss of function of several systems including power seats, adjustable pedals and power door locks. *tt
Bulletin:
16618
Component:
140000 air bags
Summary:
Illuminated air bag warning lamp with diagnostic trouble code (dtc) b2292. *tt
Bulletin:
16640
Component:
105000 power train:driveline
Summary:
Rear driveline ping/creak/pop noise. *tt
Bulletin:
16665
Component:
110000 electrical system
Summary:
Blinking/half illuminated supplemental restraint system (srs) and/or anti-lock brake (abs) warning indicators after cold soak during ambient temperatures colder than 30 degrees fahrenheit. *tt
Bulletin:
16898
Component:
100000 power train
Summary:
A whine noise on tip-in at speeds of 45 to 65 mph. this may be due to driveline stack-up tolerance with the driveshaft and rear axle. *tt
Bulletin:
16918
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Anti-lock brake system (abs) indicator lamp on with codes c1235 and c1236 or c1237. *tt
Bulletin:
16926
Component:
030000 service brakes, hydraulic
Summary:
Stability assist (advancetrac/ivd) systems may not be recalibrated properly using wds. *tt
Bulletin:
16754
Component:
106000 power train:axle assembly
Summary:
Excessive whine noise from the rear axle at cruise, or on acceleration and/or deceleration. *tt
Bulletin:
16771
Component:
061000 engine and engine cooling:engine
Summary:
Rough / rolling idle and hesitation on acceleration after a first cold startup. *tt
Bulletin:
16806
Component:
100000 power train
Summary:
Fluid leaks from the rear halfshaft seal. 2002-2003 explorer/mountaineer/aviator added. *tt
Bulletin:
03126
Component:
162600 structure:body:hatchback/liftgate
Summary:
Liftgate glass applique damaged/cracked - service procedure. *tt
Bulletin:
03106
Component:
061000 engine and engine cooling:engine
Summary:
Throttle cable routing and splash shield modification when replacing throttle cable during normal service. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03164
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles, equipped with the 4.6l 2v engine, with an engine build date prior to 8/29/03 may exhibit an engine tick noise that is present at all temperatures during idle. 2004 models included. *tt
Bulletin:
17011
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated and diagnostic trouble codes (dtc's) p0171, p0172, p0174, or p0175. *tt
Bulletin:
17049
Component:
061000 engine and engine cooling:engine
Summary:
Rough idle / engine shake. *tt
Bulletin:
17054
Component:
106000 power train:axle assembly
Summary:
Axle whine at cruise or during acceleration/ deceleration. *tt
Bulletin:
17069
Component:
061000 engine and engine cooling:engine
Summary:
Rough/rolling idle or hesitation after first startup or a rough/rolling engine speed when returning to idle after a short trip. *tt
Bulletin:
03136
Component:
110000 electrical system
Summary:
No crank condition. service tips. *tt
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
03147
Component:
103000 power train:automatic transmission
Summary:
Shudder during 4/5 upshift and/or 5/4 downshift on vehicles equipped with a 4.6l engine and 5r55w automatic transmission. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16949
Component:
106000 power train:axle assembly
Summary:
Rear axle vibration/drone above 60 mph. *tt
Bulletin:
16967
Component:
110000 electrical system
Summary:
Cluster locking up & various accessories such as the radio, power windows, power locks and moonroof being inoperative. *tt
Bulletin:
16968
Component:
061000 engine and engine cooling:engine
Summary:
Driveability conditions due to calibration vehicles equipped with the 4.0l sohc engine. idle air control (iac) valve replacement for these symptoms is typically not effective. *tt
Bulletin:
17002
Component:
110000 electrical system
Summary:
An intermittent or continuous open of fuse 1.15. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03198
Component:
106000 power train:axle assembly
Summary:
Chatter, shudder, a binding sensation, or vibration during low speed turns on vehicles equipped with the 9.75 inch or 8.8 inch limited slip rear axle. *tt
Bulletin:
17107
Component:
105000 power train:driveline
Summary:
Driveline vibration on drone/boom at highway speeds. *tt
Bulletin:
17163
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Excessive engine cooling fan noise. *tt
Bulletin:
17167
Component:
061000 engine and engine cooling:engine
Summary:
Multiple vehicles with 3.0l or 4.0l engines lacks power/runs rough/black smoke. 2004 sport trac included. *tt
Bulletin:
17215
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
The amber anti-lock brake system (abs) warning light on with diagnostic trouble codes c1235, c1236/c1237 stored in memory. *tt
Bulletin:
17216
Component:
162610 structure:body:hatchback/liftgate:hinge and attachments
Summary:
Breakage of a liftgate window hinge. *tt
Bulletin:
17217
Component:
353600 equipment:air conditioner
Summary:
Air conditioner hooting noise during light load acceleration at low speeds, from 1000-1300 rpm. *tt
Bulletin:
17246
Component:
110000 electrical system
Summary:
Instrument cluster locking up and accessories such as the radio, power windows, power locks and moonroof inoperative. *tt
Bulletin:
17280
Component:
112000 electrical system:alternator/generator/regulator
Summary:
Generator whistle/hoot noise in cold ambient temperatures. *tt
Bulletin:
16508
Component:
061000 engine and engine cooling:engine
Summary:
Vibration condition. contact request st. louis region. oasis. *tt
Bulletin:
01T02
Component:
162610 structure:body:hatchback/liftgate:hinge and attachments
Summary:
Liftgate glass bracket inspection and torque procedure. *mr
Bulletin:
04B15
Component:
106000 power train:axle assembly
Summary:
Rear axle date code inspection and service. vehicles may have been built with an improper mix of rear axle lubricant and friction modifier additive. if so, the customer may experience noise and vibration while driving. *tt *mj
Bulletin:
02M01
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Customer satisfaction program 02m01 supplement #4. certain ford 2000 through 2003 vehicles equipped with a tube-mounted egr pressure sensor - additional egr pressure sensor warranty coverage. *tt supplement #3. *mj supplement #6
Bulletin:
17494
Component:
090000 fuel system, other
Summary:
Distance to empty not displayed. *tt
Bulletin:
03223
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy. *tt
Bulletin:
17640
Component:
141000 air bags:frontal
Summary:
Poor fit between driver air bag and steering wheel. *tt
Bulletin:
17641
Component:
106000 power train:axle assembly
Summary:
Rear 3.55 axle noise. certified rear axle or improved gear set available. *tt
Bulletin:
17544
Component:
061000 engine and engine cooling:engine
Summary:
Generator noise in cold ambient temperatures. *mj
Bulletin:
17555
Component:
100000 power train
Summary:
Certified rear axle available. *mj
Bulletin:
17558
Component:
110000 electrical system
Summary:
Intermittent air bag warning lamp on, memory seat, and/or adjustable pedal concerns. *mj
Bulletin:
17560
Component:
100000 power train
Summary:
Rear axle noise. also includes lincoln aviator 2002. *mj
Bulletin:
17316
Component:
090000 fuel system, other
Summary:
Fuel signal to instrument cluster service tip. *tt
Bulletin:
17375
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) on and hard start/long crank. *tt
Bulletin:
0471
Component:
110000 electrical system
Summary:
Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
Bulletin:
17717
Component:
106000 power train:axle assembly
Summary:
Rear axle chatter, shudder, binding sensation, or vibration during low speed turns. *tt
Bulletin:
17729
Component:
353000 equipment:electrical
Summary:
Message center displays computing fuel instead of distance to empty. *tt
Bulletin:
17735
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Belt slippage. *tt
Bulletin:
17736
Component:
106000 power train:axle assembly
Summary:
Rear axle noise. *tt
Bulletin:
04111
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy.
Bulletin:
03256
Component:
061000 engine and engine cooling:engine
Summary:
Engine-romeo built 4.6l 2v-tick noise from engine-engines built before 9/17/2003. *mj
Bulletin:
03263
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Anti-lock brake system (abs) lamp illuminated and diagnostic trouble code (dtc) c1235, c1236, c1237 on vehicles with differential-mounted rar wheel speed sensor. *tt
Bulletin:
16427
Component:
010000 steering
Summary:
Low speed or stationary noise/vibration at lower steering shaft area when turning. *mj
Bulletin:
0485
Component:
162000 structure:body
Summary:
Liftgate glass applique damaged/cracked. service procedure. *tt
Bulletin:
02171
Component:
162000 structure:body
Summary:
Paint-premature clearcoat cracking-service tips. *mj
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
021710
Component:
110000 electrical system
Summary:
Electrical-central security module (csm) service tips. *mj
Bulletin:
16195
Component:
162300 structure:body:door
Summary:
Contact st louis assembly plant/st louis vicinity only. *mj
Bulletin:
04105
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Axle seal leaks. leaks from rear halfshaft axle seal. service tips. *tt
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
17905
Component:
106000 power train:axle assembly
Summary:
Multiple vehicles using fehp rear axle fluid. fluid usage change. *tt
Bulletin:
18215
Component:
162300 structure:body:door
Summary:
Broken rear cargo storage door lift handle. various models including 2005 explorer/mountaineer. *tt
Bulletin:
18217
Component:
090000 fuel system, other
Summary:
Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
Bulletin:
18221
Component:
106000 power train:axle assembly
Summary:
Rear axle noise. oasis. various models including 2005 explorer, mountaineer and aviator. *tt
Bulletin:
18224
Component:
090000 fuel system, other
Summary:
Runs rough or misfire - diagnostic trouble codes p0300-p0308 or p0316. *tt
Bulletin:
020801
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise from primary chain drive area 2000-3000 rpm - 4.0l sohc engine. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
18121
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge slow to update. *tt
Bulletin:
18123
Component:
100000 power train
Summary:
Updated rear halfshaft removal procedure. *tt
Bulletin:
18171
Component:
113000 electrical system:starter assembly
Summary:
No crank/no start condition when vehicle temperature is below freezing (32f/0c). *tt
Bulletin:
0537
Component:
105000 power train:driveline
Summary:
Driveline 1st order vibration/boom/drone. *tt
Bulletin:
18423
Component:
106000 power train:axle assembly
Summary:
Axle whine howl service with individual parts instead of an axle assembly. *eh
Bulletin:
02216
Component:
063000 engine and engine cooling:exhaust system
Summary:
Excessive sulfur smell from exhaust. *eh
Bulletin:
16304
Component:
160000 structure
Summary:
Sun visor rattle / detroit area dealers contact request. *tt
Bulletin:
16309
Component:
353600 equipment:air conditioner
Summary:
High side pressure fluctuations on vehicles equipped with a fixed scroll a/c compressor. *tt
Bulletin:
04174
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
Bulletin:
04259
Component:
133000 visibility:power window devices and controls
Summary:
Rear power window(s) inoperative. *tt
Bulletin:
18381
Component:
110000 electrical system
Summary:
Open fuse f2.20 (5 amp) and/or f2.1 (30 amp) which may result in loss of function of several systems including power seats, adjustable pedals and power door locks. *tt
Bulletin:
042115
Component:
081100 fuel system, diesel:storage:tank assembly
Summary:
Fuel gauge slow to update after refueling. *eh
Bulletin:
042212
Component:
103300 power train:automatic transmission:gear position indication (prndl)
Summary:
Gear selector lever - increased effort to shift from drive to park. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
03254
Component:
103000 power train:automatic transmission
Summary:
5r55w transmission - no 3rd gear or slipping 2-3 shift - diagnostic trouble code p0733 and p0745 - vehicles built prior to 3/4/2002. *tt
Bulletin:
06216
Component:
106000 power train:axle assembly
Summary:
Limited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
04251
Component:
162000 structure:body
Summary:
Aluminum corrosion - service tip. *tt
Bulletin:
18466
Component:
106000 power train:axle assembly
Summary:
Axle whine howl. this includes 1997-05 ford vehicles. *eh
Bulletin:
05416
Component:
220000 seats
Summary:
Front seat(s) slight movement when accelerating and/or decelerating. *tt
Bulletin:
18478
Component:
106000 power train:axle assembly
Summary:
Axle seal leaks. *eh
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
050618
Component:
022000 suspension:rear
Summary:
Rear axle noise repair. *sc
Bulletin:
051313
Component:
061000 engine and engine cooling:engine
Summary:
Hard start/no start condition during cold ambeint temperatures after short hot soak period-4.0l engine. *sc
Bulletin:
05136
Component:
132000 visibility:glass, side/rear
Summary:
Backglass difficult to close and an intermittent door ajar lamp. *tt
Bulletin:
18719
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp coming on with diagnostic trouble codes (dtcs) p0171, p0172, p0174 and/or p0175 (fuel system too rich or lean). *tt
Bulletin:
18572
Component:
060000 engine and engine cooling
Summary:
No start/hard start n hot soak restart. *tt
Bulletin:
05618
Component:
106000 power train:axle assembly
Summary:
Rear axle noise repair. *tt
Bulletin:
05419
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt
Bulletin:
051710
Component:
021600 suspension:front:wheel bearing
Summary:
Noise from rear wheel hub bearings. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
05N04
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Extended coverage program 05n04 - extended coverage for composite intake manifold. this program is being provided as a settlement to a class action lawsuit. the terms of the settlement extend the coverage of the all-composite intake manif
Bulletin:
05213
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Malfunction indicator lamp on with pcm diagnostic trouble code p0463 and/or ic diagnostic trouble code b1201 - fuel gauge drops to empty or slow to update after refueling. *tt
Bulletin:
19091
Component:
110000 electrical system
Summary:
Low oil pressure indication/warning, a/c compressor inoperative and/or no crank condition on 4.6l equipped vehicles. *tt
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
TSB-08-19-3
Component:
106200 power train:axle assembly:axle shaft
Summary:
Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal. oil separation appears to be and is often misdiagnosed, as an axle lube leak. *pe

Home | Privacy