2002 FORD ESCAPE Recalls (12)

Campaign:
04V165000 on 04/13/2004
Component:
Power train:automatic transmission:control module (tcm, pcm)
Manufactured:
01/30/2000 - 09/10/2002
Affected:
321,903
Defect:
On certain sport utility vehicles equipped with 3.0l v6 engines, during deceleration, the engine can stall.
Consequence:
Should the engine stall, a vehicle crash could occur.
Correction:
Dealers will reprogram the power control module (pcm) with the appropriate calibration. owner notification began on april 21, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 04s13.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V574000 on 12/08/2004
Component:
Vehicle speed control:cables
Manufactured:
05/29/2001 - 01/22/2004
Affected:
470,245
Defect:
On certain sport utility vehicles built with 3.0l v6 engines, the accelerator cable may prevent the throttle from returning to the idle position.
Consequence:
An unexpected increase in engine idle speed may increase stopping distance and may result in a vehicle crash.
Correction:
Dealers will replace the accelerator cable. the recall began on january 10, 2005. owners should contact ford at 1-866-436-7332.
Notes:
Ford recall no. 04s25.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V602000 on 12/22/2004
Component:
Latches/locks/linkages:doors:latch
Affected:
262,113
Defect:
Certain 2004-2005 sport utility vehicles and certain 2001-2003 sport utiity vehicle having rear liftgate components serviced with 2004 equivalent components fail to comply with the requirements of federal motor vehicle safety standard no. 206, 'door locks and door retention components.' the rear liftgate latching system does not meet the inertia load requirement in one direction.
Consequence:
If the liftgate is left unlocked, there is the potential that it may open during a crash.
Correction:
Dealers will replace the rear liftgate latch release rod, the release rod attachment clip and the door handle return spring. the recall began on march 31, 2005. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 04c09.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236.
Campaign:
07E023000 on 03/28/2007
Component:
Service brakes, hydraulic:foundation components:master cylinder
Affected:
13,128
Defect:
Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
Consequence:
Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Correction:
Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
Notes:
This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V156000 on 04/10/2007
Component:
Service brakes, hydraulic:antilock:control unit/module
Manufactured:
10/21/1999 - 01/22/2004
Affected:
446,460
Defect:
On certain sport utility vehicles equipped with antilock brakes (abs), the abs module connector may have missing or dislodged wire seals. this condition could allow contamination to enter the module connector, creating a potential for an electrical short.
Consequence:
An electrical short might cause an abs malfunction that would illuminate the abs warning light, and in some cases, the module may overheat resulting in burning odor, smoke, and/or fire. this condition could occur either when the vehicle ignition switch is in the off position or while the vehicle is being operated.
Correction:
Dealers will inspect the wire harness connector to the abs module for missing or dislodged wire seals, and repair or replace the harness connector as appropriate. the dealer will also inspect the connector on the abs module and replace it if it is found to be corroded or damaged. the recall began on april 23, 2007. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 07s51.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
12V005000 on 01/08/2012
Component:
Service brakes, hydraulic:antilock:control unit/module
Manufactured:
10/21/1999 - 07/18/2002
Affected:
244,530
Defect:
Ford is recalling certain model year 2001-2002 escape vehicles manufactured from october 22, 1999, through july 19, 2002, equipped with a brake master cylinder reservoir cap that could leak brake fluid. if brake fluid leaks from the cap, it could come in contact with the antilock brake system (abs) module wiring harness connector.
Consequence:
Corrosion can develop in the electrical connector leading to melting, smoke or a fire.
Correction:
Dealers will replace the brake master cylinder reservoir cap and the abs electrical system will be modified. an interim letter was mailed on january 20, 2012. due to a parts delay, however, the remedy may not be available currently. if parts are not available, ford will instruct owners to park their vehicles outside until such time as parts become available. owners may contact the ford motor company customer relationship center at 1-866-436-7332. this recall campaign is related to 07v-156.
Notes:
Ford's safety recall number is 11s24.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V353000 on 07/25/2012
Component:
Engine and engine cooling
Affected:
529,719
Defect:
Ford motor company is recalling certain model year 2001 through 2004 escape vehicles equipped with 3.0l v6 engines and speed control manufactured from october 22, 1999, through january 23, 2004. inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. this risk exists regardless of whether or not speed control (cruise control) is used.
Consequence:
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Correction:
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. the safety recall began august 3, 2012. remedy parts are expected to be available in mid-august 2012. until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall campaign number is 12s37.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
12V353000 on 07/25/2012
Component:
Vehicle speed control:cables
Affected:
529,719
Defect:
Ford motor company is recalling certain model year 2001 through 2004 escape vehicles equipped with 3.0l v6 engines and speed control manufactured from october 22, 1999, through january 23, 2004. inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. this risk exists regardless of whether or not speed control (cruise control) is used.
Consequence:
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Correction:
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. the safety recall began august 3, 2012. remedy parts are expected to be available in mid-august 2012. until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall campaign number is 12s37.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V165000 on 04/07/2014
Component:
Structure:frame and members
Manufactured:
10/21/1999 - 12/18/2003
Affected:
348,950
Defect:
Ford motor company (ford) is recalling certain model year 2001-2004 escape vehicles manufactured october 22, 1999, through january 23, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia. these vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
Consequence:
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Correction:
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. the recall began on may 30, 2014. owners may contact ford at 1-800-392-3673. ford's number for this recall is 14s02.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15E045000 on 06/02/2015
Component:
Suspension:front:wheel bearing
Affected:
576
Defect:
The timken company (timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from january 22, 2015, to may 21, 2015, to be used as service parts on 2001-2012 ford escape, 2001-2011 mazda tribute, and 2005-2011 mercury mariner vehicles. the affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Consequence:
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Correction:
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. the recall began on may 21, 2015. owners may contact timken customer service at 1-866-984-6536.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V606000 on 09/28/2015
Component:
Power train:automatic transmission:gear position indication (prndl)
Manufactured:
03/30/2001 - 08/31/2009
Affected:
57
Defect:
Ford motor company (ford) is recalling certain model year 2001-2008 ford escape and mercury mariner vehicles manufactured march 31, 2001, to september 1, 2009. the affected vehicles are equipped with either a 2.3l or 3.0l engine and have had their cd4e transmission replaced with remanufactured one that was rebuilt between june 11, 2015 through july 15, 2015. these service repair part transmissions have a shift lever bolt that may not be properly tightened. as a result, the shift control lever could disengage from the transmission without warning.
Consequence:
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "park" position, but the vehicle transmission may not actually be in the "park" gear position. if the vehicle is not in the "park" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. a vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Correction:
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. these repairs will be performed free of charge. the recall began on october 23, 2015. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 15s28.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V606000 on 09/28/2015
Component:
Power train:automatic transmission:lever and linkage:floor shift
Manufactured:
03/30/2001 - 08/31/2009
Affected:
57
Defect:
Ford motor company (ford) is recalling certain model year 2001-2008 ford escape and mercury mariner vehicles manufactured march 31, 2001, to september 1, 2009. the affected vehicles are equipped with either a 2.3l or 3.0l engine and have had their cd4e transmission replaced with remanufactured one that was rebuilt between june 11, 2015 through july 15, 2015. these service repair part transmissions have a shift lever bolt that may not be properly tightened. as a result, the shift control lever could disengage from the transmission without warning.
Consequence:
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "park" position, but the vehicle transmission may not actually be in the "park" gear position. if the vehicle is not in the "park" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. a vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Correction:
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. these repairs will be performed free of charge. the recall began on october 23, 2015. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 15s28.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2002 FORD ESCAPE TSBs (107)

Bulletin:
14982
Component:
020000 suspension
Summary:
Information regarding alignment specifications. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15112
Component:
980000 unknown or other
Summary:
Customers may complain of difficulty programming a key by using the customer spare key programming method. *yd
Bulletin:
15159
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some vehicles may exhibit a pcv disengaged at the upper intake manifold in the event of an engine backfire. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15224
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit an intermittent high frequency brake squeal noise. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15524
Component:
102000 power train:manual transmission
Summary:
Some vehicles may experience gear shifter buzz or rattle when in 3rd or 4th gear.*yd
Bulletin:
15566
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a tacky surface on the instrument panel (ip). *tt
Bulletin:
15576
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles built before 12/11/2001 may exhibit a slight looseness of the steering wheel in a fore-aft direction. *tt
Bulletin:
15589
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an intermittent engine quit condition, usually 1 time during closed throttle decel with no diagnostic trouble codes or malfunction indicator lamps. *tt
Bulletin:
15430
Component:
105500 power train:driveline:differential unit
Summary:
Some 4x4 vehicles may exhibit driveline binding, wheel hop on tight turns, or a clunk type noise from the driveline during torque reversal. *tt
Bulletin:
15427
Component:
200000 wheels
Summary:
Exhibiting a clicking type noise from either or both of the front wheels when turning at slow speeds after driving for approximatel 20-30 minutes. *tt
Bulletin:
15434
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an intermittent engine quit condition. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15476
Component:
350000 equipment
Summary:
On some vehicles, the aftermarket/non-factory installed trailer tow wiring may become inoperative. *tt
Bulletin:
15456
Component:
353600 equipment:air conditioner
Summary:
Exhibiting a condition of the climate control system defaulting to defrost/windshield on acceleration. *tt
Bulletin:
15482
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a duratec engine may experience engine damage as a result of microscopic internal cracks in a batch of intake valves. *tt
Bulletin:
0224
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with the cd4e transaxle may exhibit harsh and delayed 1-2/2-3 upshifts after transaxle or turbine shaft speed sensor replacement, possible diagnostic trouble codes 628, 642, 645, 646, 647, 648, p0731, p0732, p0734, p0
Bulletin:
15604
Component:
980000 unknown or other
Summary:
Some vehicles with 3.0l duratec engine built between june 12, 2000 and december 15, 2000 may exhibit an intemittent malfunction indicator lamp illumination and / or diagnostic trouble codes p0301 or p0351. *tt
Bulletin:
0252
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Some vehicles built before 2/12/2002 may exhibit a power steering fluid leak at the return hose and / or cooler hose at the intermiediate tube assembly during extreme cold ambient temperatures -20 to -28c (-5 to -20 f), *tt
Bulletin:
0256
Component:
980000 unknown or other
Summary:
This bulletin involves proper procedures for preparation of service sheet metal parts coated with electro deposition primer (e-coat). *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
0293
Component:
162300 structure:body:door
Summary:
Some vehicles built before 12/15/01 may exhibit door latches that will not open. *tt
Bulletin:
16103
Component:
161100 structure: frame and members:underbody shields
Summary:
This bulletin states that the rear underbody heat shield is discontinued. *tt
Bulletin:
16116
Component:
100000 power train
Summary:
Subject regarding throttle body service replacement / transmission vent hose bracket instructions. *tt
Bulletin:
16154
Component:
020000 suspension
Summary:
Some vehicles with aluminum wheels may exhibit a clicking noise heard coming from the front of the vehicle during left or right hand turns. *tt
Bulletin:
16016
Component:
020000 suspension
Summary:
Some vehicles may exhibit a clicking noise heard on left or right hand turns coming from the front suspension. *tt
Bulletin:
16046
Component:
020000 suspension
Summary:
Some vehicles may exhibit a rear shock leak and / or noise condition. *tt
Bulletin:
16056
Component:
100000 power train
Summary:
Cd4e transaxle may exhibit a final drive whine / warble type noise mostly in the 25-45 mph speed range on light throttle acceleration or deceleration. *tt
Bulletin:
15685
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 2.0l engine and a manual transmission, may exhibit a rolling idle condition in high ambient temperatures. *tt
Bulletin:
15756
Component:
162300 structure:body:door
Summary:
Subject regarding hanging door weatherstrip. *tt
Bulletin:
15999
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit cd ejecting or loading issues with the cdx-6 radio. *tt
Bulletin:
15766
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a crank / no start, poor idle, and / or lack of power, with camshafts out of time. *tt
Bulletin:
15800
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Some vehicles may exhibit a high accelerator pedal effort just off idle or tip in. *tt
Bulletin:
15818
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Some vehicles built 09/2001 through 11/2001 and equipped with a 2.0l zetec engine may exhibit a fead belt noise. *tt
Bulletin:
15828
Component:
116200 electrical system:ignition:module
Summary:
Some vehicles may exhibit diagnostic trouble code b1213, b1342, b1601, b2431. *tt
Bulletin:
15860
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Some vehicles may exhibit a brake fluid leak from the master cylinder reservoir cap. *tt
Bulletin:
0286
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 3.0l duratec engine may exhibit an intermittent engine quit condition. *tt
Bulletin:
0361
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on with or without rough running, lack of power, surge or poor fuel economy with diagnostic trouble codes p0401, p0402, p1400, p1401. *tt *jb
Bulletin:
16696
Component:
021000 suspension:front
Summary:
Whining / propeller / helicopter type noise from front wheel / knuckle bearing area. *tt *jb
Bulletin:
16717
Component:
106000 power train:axle assembly
Summary:
Automatic transaxle shudder. *tt *jb
Bulletin:
0322
Component:
061000 engine and engine cooling:engine
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401, or runs rough, lacks power, surge, poor fuel economy, and the above listed dtcs without
Bulletin:
16645
Component:
030000 service brakes, hydraulic
Summary:
Instrument panel brake lamp illumination and/or brake fluid leaking condition. *tt
Bulletin:
16908
Component:
015000 steering:hydraulic power assist system
Summary:
Squeaking noise from the power steering rack when turning. *tt
Bulletin:
16779
Component:
110000 electrical system
Summary:
Perceived condition of no entry or unable to manually unlock the door. this may occur when the battery is allowed to become discharged or completely dead and the remote keyless entry (keyfob) is used while the battery is in this state.
Bulletin:
16811
Component:
110000 electrical system
Summary:
Intermittent electrical conditions with power windows, locks, fobs, radio, lighting, cruise control or other electrical accessories. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
17067
Component:
151000 seat belts:front
Summary:
Front seatbelt slow to retract. *tt
Bulletin:
031513
Component:
017500 steering:linkages:tie rod assembly
Summary:
Tie rod end inspection procedure. *tt
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16964
Component:
030000 service brakes, hydraulic
Summary:
Excessive brake pad/lining dust and wear. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
032011
Component:
110000 electrical system
Summary:
Airbag lamp illuminated and diagnostic trouble codes (dtcs) b1877 (driver pretensioner circuit open) or b1881 (passenger pretensioner circuit open). *tt this bulletin supersedes tsb 03-20-11 dated 2003. *tt
Bulletin:
02M01
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Customer satisfaction program 02m01 supplement #4. certain ford 2000 through 2003 vehicles equipped with a tube-mounted egr pressure sensor - additional egr pressure sensor warranty coverage. *tt supplement #3. *mj supplement #6
Bulletin:
17457
Component:
030000 service brakes, hydraulic
Summary:
Excessive front rotor wear and/or brake dust. *tt
Bulletin:
03223
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy. *tt
Bulletin:
17657
Component:
102000 power train:manual transmission
Summary:
Clutch chatter when cold. *tt
Bulletin:
17532
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Low pressure power steering line leak after cold soak in temperatures of -23c (-10) or lower. *mj
Bulletin:
16447
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Musty odor from climate control system. *tt
Bulletin:
17316
Component:
090000 fuel system, other
Summary:
Fuel signal to instrument cluster service tip. *tt
Bulletin:
17343
Component:
151000 seat belts:front
Summary:
Front safety belt slow to retract and/or missing web stop button. *tt
Bulletin:
17366
Component:
100000 power train
Summary:
Final drive whine most noticeable at 25-45 mph during light acceleration or deceleration. *tt
Bulletin:
17380
Component:
090000 fuel system, other
Summary:
A check fuel cap indicator illuminated with diagnostic trouble code (dtc) p0457 or a malfunction indicator lamp illuminated with dtc p0455 or p0457. *tt
Bulletin:
02231
Component:
061000 engine and engine cooling:engine
Summary:
Driveability-intermittent engine quit or idle dip-no diagnostic trouble codes (dtcs) present-vehicles equipped with 3.0l duratec engine only. *mj
Bulletin:
17703
Component:
061000 engine and engine cooling:engine
Summary:
Ticking noise from left cylinder head with warm engine. *tt
Bulletin:
04111
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy.
Bulletin:
03252
Component:
060000 engine and engine cooling
Summary:
Engine-cooling system-low coolant warning indicator lamp illuminaion-coolant degas bottle inspection-serice tip. *mj
Bulletin:
16405
Component:
030000 service brakes, hydraulic
Summary:
Brake squeal / engineering contract request. *mj
Bulletin:
16409
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Click on turns. *mj
Bulletin:
16410
Component:
114000 electrical system:wiring
Summary:
Trailer tow harness installation / service tip. *mj
Bulletin:
16413
Component:
050000 parking brake
Summary:
Park brake adjustment / contact request. *mj
Bulletin:
16420
Component:
162600 structure:body:hatchback/liftgate
Summary:
Squeak, creak or rattle type noise from rear liftgate area. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
16209
Component:
353600 equipment:air conditioner
Summary:
Cimate control system odor. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
04141
Component:
103000 power train:automatic transmission
Summary:
Transmission control indicator lamp (tcil) on with diagnostic trouble code p1783 and/or p0733 cold climate shift/engagement concerns with a cd4e transaxle. *tt
Bulletin:
18217
Component:
090000 fuel system, other
Summary:
Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
18173
Component:
100000 power train
Summary:
A final drive whine at 25-45 mph (40-72 km/h). *tt
Bulletin:
05310
Component:
150000 seat belts
Summary:
Safety belt web stop button service. *eh
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
16266
Component:
353100 equipment:electrical:anti-theft devices
Summary:
False alarm activation. *tt
Bulletin:
04174
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
Bulletin:
04214
Component:
010000 steering
Summary:
Steering drift/pull - improved diagnostic and repair procedure - service tip. *tt
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
042210
Component:
010000 steering
Summary:
Steering gear squeak - when turning the steering wheel during low speed parking maneuvers. *tt
Bulletin:
04232
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Wheel speed sensor removal tip. *eh
Bulletin:
18280
Component:
140000 air bags
Summary:
Air bag warning lamp on . *eh
Bulletin:
18281
Component:
124000 exterior lighting:back up lights
Summary:
Condensation inside the foglamps. *eh
Bulletin:
18284
Component:
140000 air bags
Summary:
High airflow from defroster vents when in floor or floor defrost modes. *eh
Bulletin:
04191
Component:
150000 seat belts
Summary:
Safety belt buckle and pretensioner diagnostic trouble code (dtc) b1877, b1881, b1885 or b1886. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
042513
Component:
160000 structure
Summary:
Serviceability of instrument panel register vents. *tt
Bulletin:
042612
Component:
140000 air bags
Summary:
Side air bag diagnostic trouble code (dtc) b1994 or b1998. *tt
Bulletin:
04244
Component:
110000 electrical system
Summary:
Restraint system - safety belt buckle and pretensioner diagnostic trouble code (dtc) b1877 and/or b1881. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
19016
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Replace timing belt idler pulley during 2.0l zetec engine cylinder head replacement - service tip. *tt
Bulletin:
04208
Component:
061000 engine and engine cooling:engine
Summary:
Camshaft tick noise - 3.0l 4v engine only. *tt
Bulletin:
0693
Component:
110000 electrical system
Summary:
Pcm failure - electrical accessories intermittent - inoperative. *tt
Bulletin:
TSB-14-0143
Component:
021530 suspension:front:control arm:lower arm
Summary:
Ford: the lower control arm (lca) forward attachment will separate from subframe, causing diminishing directional control, due to operating in high corrosion areas for extended period of time. model 2001-2004 escape. *pe

Home | Privacy