2002 COUNTRY COACH INTRIGUE Recalls (5)
- Campaign:
- 01V111002 on 07/02/2001
- Component:
- Service brakes, air:supply:compressor
- Manufactured:
- 09/30/1999 - 03/30/2001
- Affected:
- 667
- Defect:
- Vehicle description: motor homes equipped with cummins isc and isl diesel engines. the internal front bushing can spin, causing damage to the air compressor, and possibly to the spindle drive at the rear face of the air compressor which is used to provide power to the vehicle hydraulic pump. failure of the air compressor's spindle drive could lead to loss of power assist if the hydraulic pump ceases to operate.
- Consequence:
- Without power assist, the vehicle becomes very difficult to turn and could possibly result in a vehicle crash.
- Correction:
- Cummins will notify country coach customers and replace the air compressor free of charge. owner notification began march 30, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins customer assistance center 1-800-343-7357.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V322003 on 12/03/2001
- Component:
- Vehicle speed control:accelerator pedal
- Manufactured:
- 06/24/2001 - 10/23/2001
- Affected:
- 194
- Defect:
- Vehicle description: motor homes equipped with electronic throttle control/accelerator pedals supplied by williams controls industries. the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
- Consequence:
- If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
- Correction:
- Dealers will replace these pedals. owner notification is expected to begin during december 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact country coach at 1-800-452-8015.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V358000 on 12/03/2001
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 03/28/2001 - 04/19/2001
- Affected:
- 21
- Defect:
- Vehicle description: motor homes. the windshield wipers equipped with the smartwheel option were improperly grounded. the improper ground causes the wiper motors and blades to periodically stop when the motor home is in transit at freeway speeds.
- Consequence:
- Failure of the windshield wiper motors to work could lead to loss of visibility during critical periods when wipers are necessary, increasing the risk of a crash.
- Correction:
- Dealers will correctly ground the windshield wiper motor case. owner notification began december 3, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact country coach at 1-800-452-8015.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V109000 on 03/27/2003
- Component:
- Equipment:recreational vehicle
- Manufactured:
- 12/31/2000 - 11/30/2003
- Affected:
- 485
- Defect:
- On certain motorhomes equipped with international thermal research (itr)hurricane hot water heaters, the electronic control board may adversely affect safety features in some of the systems protecting against overheating and potential fire situation.
- Consequence:
- If the safety features do not shut down properly, the heating system can continue heating, possibly resulting in a fire.
- Correction:
- The defective electronic control board will be replaced. in the meantime, customers should turn the system off using the master on/off switch located on the side of the electronic control box which is adjacent to the heater. owners who take their motorhomes to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact itr at 1-800-755-1272 or country coach at 1-800-547-8015.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 07V031000 on 02/05/2007
- Component:
- Equipment:recreational vehicle
- Affected:
- 2,406
- Defect:
- Certain motor homes equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Consequence:
- Release of coolant under certain conditions could ignite and result in a fire.
- Correction:
- Country coach will be working with dometic in order to repair these refrigerators (please see 06e076). a secondary burner housing will be installed free of charge. the recall began on march 28, 2007. owners may contact dometic/stericycle at 1-888-446-5157 or country coach at 1-800-452-8015.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2002 COUNTRY COACH INTRIGUE TSB
- Bulletin:
- 02038
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code b1000. *mr
Home | Privacy