2002 COACHMEN AURORA Recalls (4)
- Campaign:
- 03V040000 on 02/11/2003
- Component:
- Service brakes, hydraulic:switches:brake warning
- Manufactured:
- 05/12/1999 - 10/21/2002
- Affected:
- 3,539
- Defect:
- Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by standard.
- Consequence:
- In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.
- Correction:
- Dealers will repair the brake warning lamp circuit. owner notification began march 24, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact coachmen at 1-219-825-5821.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V373000 on 10/19/2003
- Component:
- Equipment:recreational vehicle
- Manufactured:
- 04/30/2000 - 12/10/2002
- Affected:
- 19,110
- Defect:
- On certain motor homes, travel trailers, and fifth wheel trailers equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. this may cause the oven to activate without pressing any key pads.
- Consequence:
- An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
- Correction:
- Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or coachmen at 1-219-825-5821.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V518000 on 10/27/2004
- Component:
- Service brakes, hydraulic:foundation components:disc:caliper
- Manufactured:
- 09/30/2001 - 10/30/2002
- Affected:
- 238
- Defect:
- On motor home chassis built by workhorse and equipped with bosch brakes, the pads can drag on the rotor surface due to the pin slide.
- Consequence:
- A hang up or lock up may cause the calipers to over heat and not allow the driver to stop safely. this could cause overheating of the brake calipers which could result in a vehicle fire.
- Correction:
- Workhorse is conducting the owner notification and remedy for this campaign. dealers will repair the brake caliper. owners should contact workhorse at 1-877-294-6773 or coachmen at 219-825-5821.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 09V193000 on 05/31/2009
- Component:
- Service brakes, hydraulic:fluid
- Manufactured:
- 07/31/2000 - 05/30/2008
- Affected:
- 2,555
- Defect:
- Coachmen is recalling 2,555 my 2000-2009 georgie boy and coachmen recreational trailers equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. when combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. this can result in abnormal heat generation at the wheel end causing brake drag. the driver would normally have warning of the brake drag if undetected by the driver.
- Consequence:
- The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
- Correction:
- Dealers will inspect and replace the necessary components free of charge. workhorse is handling the remedy for this campaign please see 09v-110. the manufacturer has not yet provided an owner notification schedule. owners may contact workhorse at 1-877-246-7731 or coachmen at 1-574-266-4030, option 5.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2002 COACHMEN AURORA TSB
- Bulletin:
- 02038
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code b1000. *mr
Home | Privacy