2002 CHRYSLER SEBRING CONVERTIBLE Recalls (3)
- Campaign:
- 07E023000 on 03/28/2007
- Component:
- Service brakes, hydraulic:foundation components:master cylinder
- Affected:
- 13,128
- Defect:
- Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
- Consequence:
- Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
- Correction:
- Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
- Notes:
- This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E056000 on 10/12/2009
- Component:
- Suspension:front:control arm:lower ball joint
- Affected:
- 5,787
- Defect:
- Qualis automotive is recalling certain aftermarket ball joints sold for use on certain passenger vehicles. the socket may have been excessively hardened which could cause it to crack near the retaining ring groove allowing the ball stud to separate under impact load. the subject ball joints were sold as four part numbers, d10945, d10946, g10945, and g10946. the affected control arms, d10945 and d10946, are stamped with the following dates on the ball joints: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, and 116609. the g10945 and g10946 are the same part as the d10945 and d10946 respectively. they are labeled differently depending on the aftermarket customer.
- Consequence:
- Separation of the ball stud from the socket of the ball joint housing would allow the control arm to collapse and the wheel to fold in causing loss of steering control, possibly resulting in a crash.
- Correction:
- Qualis automotive will replace the ball joints free of charge. the safety recall began on november 9, 2009. owners may contact qualis automotive at 1-800-493-4128.
- Notes:
- This recall only pertains to aftermarket ball joints and has no relation to any original equipment installed on vehicles produced by chrysler.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 10E059000 on 12/26/2010
- Component:
- Suspension:front:control arm:lower arm
- Affected:
- 22,689
- Defect:
- Federal-mogul is recalling certain replacement control arm assemblies, part numbers k7425, 10945, fa4510x, k7427, 10946, and fa4611x, sold for use on various passenger vehicles listed above. the ball joint on the control arm assembly can fail causing the ball stud to wear through the control arm housing resulting in noise and/or separation of the ball stud from the housing.
- Consequence:
- If there is a separation of the ball stud from the housing, the driver can loose steering control, possibly resulting in a vehicle crash.
- Correction:
- Federal-mogul will notify owners of record and replace the affected control arms free of charge. the safety recall began on january 28, 2011. owners may contact federal-mogul at 1-877-489-6659.
- Notes:
- This recall only pertains to replacement control arm assemblies and has no relation to any original equipment installed on vehicles manufactured by chrysler llc.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2002 CHRYSLER SEBRING CONVERTIBLE TSBs (47)
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2301701
- Component:
- 162000 structure:body
- Summary:
- Subject regarding water leak information. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 1900701
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Information on new power steering fluid.*slc
- Bulletin:
- 2401001
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Experiencing a/c honk or fog horn sound coming from the a/c expansion valve. *tt
- Bulletin:
- 2401001
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Experiencing honk or fog horn sound coming from the a/c expansion valve. *tt
- Bulletin:
- 2302301
- Component:
- 162000 structure:body
- Summary:
- Some subject vehicles may develop fascia to headlamp gap in high sun load conditions. *tt
- Bulletin:
- 0801701
- Component:
- 110000 electrical system
- Summary:
- Subject regarding safety systems - vehicle modifications / repair. *tt
- Bulletin:
- 1802701
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit moderate to severe high way speed 45-60 mph vehicle surge. *tt
- Bulletin:
- 0802601
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may exhibit a flickering trip computer and/or radio display, instrument panel illumination, and/or overhead/dome lights. *tt
- Bulletin:
- 0800102
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- On some vehicles the rear window defogger is inoperative and defogger grid terminal(s) is separated from the rear window heating grid and/or may be broken. *tt
- Bulletin:
- 0700202
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- A vehicle may exhibit low or no cabin heat, engine overheating and / or coolant bottle damage after service has been performed on the engine cooling system. *tt
- Bulletin:
- 0700202
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Subject regarding low or no cabin head, engine cooling system system fill procedure. *tt
- Bulletin:
- 15
- Component:
- 131000 visibility:windshield
- Summary:
- Subject regarding rear window breakage. *tt
- Bulletin:
- 2301602
- Component:
- 162000 structure:body
- Summary:
- Subject regarding delamination of the door trim belt line molding. *slc
- Bulletin:
- 2302302
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may experience the vinyl surface of the instrument panel being damaged or blemished. *slc
- Bulletin:
- 2302402
- Component:
- 162000 structure:body
- Summary:
- Subject regarding distorted audio system bass sound and/or door trim panel buzz/rattle. *slc
- Bulletin:
- 2302702
- Component:
- 162000 structure:body
- Summary:
- Subject regarding a rattle/squeak/tick sound from base of a-pillar. *slc
- Bulletin:
- 1900402
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Subject regarding steering column click sound. *slc
- Bulletin:
- 2200102
- Component:
- 980000 unknown or other
- Summary:
- Chrome wheel care. *slc
- Bulletin:
- 0800702
- Component:
- 110000 electrical system
- Summary:
- Subject regarding remote keyless entry programming procedures. *slc
- Bulletin:
- 1400102
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Subject regarding fuel cap difficult to remove. *slc
- Bulletin:
- B01
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Some vehicles may experience a broken convertible top rear window glass for jr27 models. *slc
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 02012
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may experience a slipping or no drive condition in reverse or first gear. *tt
- Bulletin:
- 02012
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may experience a slipping or no drive condition in reverse or first gear. *tt
- Bulletin:
- 2100102
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may have a transaxle that will not move or slips in reverse or first gear. *tt
- Bulletin:
- 1400102A
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Fuel cap difficult to remove. *tt
- Bulletin:
- 02020
- Component:
- 106000 power train:axle assembly
- Summary:
- Delayed transaxle engagement after initial start up. *tt
- Bulletin:
- 27
- Component:
- 106000 power train:axle assembly
- Summary:
- The transaxle low/reverse accumulator cover o-ring on certain vehicles may become dislodged. *tt
- Bulletin:
- 1900702
- Component:
- 012000 steering:column
- Summary:
- Lower steering column click sound. *tt
- Bulletin:
- 0801003
- Component:
- 150000 seat belts
- Summary:
- Seat belt cinch bar service for various models including 2004 models. *tt
- Bulletin:
- 2301403
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- When cycling door glass up and down, a clicking noise can be heard when the window travel changes direction on various models including the 2004 sebring sedan and sebring convertible. *tt
- Bulletin:
- 0801505
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Powertrain control module initialization. *sc
- Bulletin:
- 9003623
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Wiper if mopar oe wipers are unavailable, the below alternatives can be offered instead. 05066964a$ = wbrw0011a$ 05066973a$ = wb000019a$ or wbf00019a$ 05096134a$ = wb000027a$ or wbf00028a$ 55154762a$ = wb000013a$ 68001330a$ = wb000019
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 20616
- Component:
- 110000 electrical system
- Summary:
- P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
- Bulletin:
- 22892
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
- Bulletin:
- 22867
- Component:
- 110000 electrical system
- Summary:
- Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
- Bulletin:
- 22958
- Component:
- 117000 digital instrument panel
- Summary:
- 1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
- Bulletin:
- 20244
- Component:
- 350000 equipment
- Summary:
- Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- 23137
- Component:
- 350000 equipment
- Summary:
- Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
- Bulletin:
- 23104
- Component:
- 120000 lighting (pws)
- Summary:
- 05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
- Bulletin:
- 23027
- Component:
- 114000 electrical system:wiring
- Summary:
- Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p
Home | Privacy