2002 CHEVROLET AVALANCHE Recalls (4)
- Campaign:
- 04V129000 on 03/21/2004
- Component:
- Structure:body:tailgate:hinge and attachments
- Manufactured:
- 09/30/2000 - 07/30/2002
- Affected:
- 3,662,211
- Defect:
- On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
- Consequence:
- Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
- Correction:
- Dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
- Notes:
- Gm recall no. 04007.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V379000 on 08/28/2005
- Component:
- Service brakes, hydraulic:antilock
- Manufactured:
- 12/31/2000 - 08/30/2002
- Affected:
- 1,353,718
- Defect:
- Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. this condition is more likely to occur in environmentally corrosive areas. this recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
- Consequence:
- This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
- Correction:
- Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. the recall began september 22, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
- Notes:
- Gm recall no. 05068. gm revised the involved vehicles by amending the original 573 report on october 4, 2005. gm revised the original 573 report on december 16, 2005, to include additional states and vehicle population.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 06E043000 on 05/21/2006
- Component:
- Fuel system, gasoline
- Affected:
- 88,303
- Defect:
- Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.
- Consequence:
- This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.
- Correction:
- Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
- Notes:
- This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2002 CHEVROLET AVALANCHE TSBs (277)
- Bulletin:
- 010601
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding rebroadcast dates for 2002 chevrolet avalanche know how seminar. *tt
- Bulletin:
- 010844008
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This bulletin is being issued to inform dealers that effective with vehicle production in may 1, 2001, certain vehicles are being shipped with a new fluorescent orange plastic antenna wrench as part of the antenna. *tt
- Bulletin:
- 010857001
- Component:
- 162000 structure:body
- Summary:
- Some vehicles may exhibit a wet carpet in the front or rear footwell. *tt
- Bulletin:
- 290801
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Subject regarding reports received indicating that the onstar antenna was not in the loose parts package of certain vehicles. *tt
- Bulletin:
- 290801
- Component:
- 350000 equipment
- Summary:
- This message pertains to optional roof rack or assist steps (running boards). *tt
- Bulletin:
- 270601
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Information pertaining to the optional roof rack installation procedures. *tt
- Bulletin:
- 010866006
- Component:
- 162000 structure:body
- Summary:
- Information regarding avalanche cargo area. nlm
- Bulletin:
- 010940001
- Component:
- 151300 seat belts:front:retractor
- Summary:
- Information regarding replacement of the front seat belt retractor and buckle usage. *tt
- Bulletin:
- 010101
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding dealer installed options. *slc
- Bulletin:
- 010101
- Component:
- 980000 unknown or other
- Summary:
- Information regarding soft tonneau cover spo part numbers. *slc
- Bulletin:
- 010101
- Component:
- 162000 structure:body
- Summary:
- Some vehicles may have been shipped from the assembly plant with a seam that is not completely sealed in the rear wheelhouse area, vehicles built prior to 13-jun-2001 could be affected. *slc
- Bulletin:
- 260601
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Vehicles equipped with sunroof and the optional or accessory roof rack package can generate wind noise when the sunroof is open. *jb
- Bulletin:
- 010101
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Some vehicles equipped with a sunroof and the option accessory roof rack can generate windnoise when the sunroof is open depending on the positioning of the front roof rack cross bow. *slc
- Bulletin:
- 120601
- Component:
- 350000 equipment
- Summary:
- This message pertains to dealer-installed roof rack or assist step equipment. *tt
- Bulletin:
- 020701
- Component:
- 980000 unknown or other
- Summary:
- Information on instrument panel cover soft touched paint peel, blister, or cracking conditions, on some gmc, chvrolet, and cadilliac full size pickups and sport utility trucks. *jb
- Bulletin:
- 071101
- Component:
- 980000 unknown or other
- Summary:
- Information regarding onstar antenna missing on the 2002 chevrolet avalanche, a double inspection procedure has been implemented within process to assure the the part is in fact present in the loose patrs bag. nlm
- Bulletin:
- 060601
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Information regarding roof rack installation instructions. *slc
- Bulletin:
- 010101
- Component:
- 022000 suspension:rear
- Summary:
- Some vehicles may experience a fluid leak at the rear axle differential cover. *yd
- Bulletin:
- 300701
- Component:
- 162000 structure:body
- Summary:
- Information regarding to installation of the dealer installed roof rack. *yh
- Bulletin:
- 210801
- Component:
- 162500 structure:body:tailgate
- Summary:
- Subject regarding tailgate closing effort. *jg
- Bulletin:
- 050901
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Subject regarding optional roof rack installation. *slc
- Bulletin:
- 050901
- Component:
- 022000 suspension:rear
- Summary:
- Some vehicles may experience rear axle oil leaks. *slc
- Bulletin:
- 180901
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Subject regarding optional roof rack installaition procedures. *slc
- Bulletin:
- 021001
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding time variations on auto-pdi. *jg
- Bulletin:
- 010102
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Information regarding removable backglass encapsulation cracking. *yh
- Bulletin:
- 010102
- Component:
- 162000 structure:body
- Summary:
- Subject on staining of the roof panel. *yh
- Bulletin:
- 010864014
- Component:
- 162300 structure:body:door
- Summary:
- Subject on door manual lock lever disengages from door trim panel. *yh
- Bulletin:
- 010864015
- Component:
- 162300 structure:body:door
- Summary:
- Information regarding front and rear side access door noise. *yh
- Bulletin:
- 010102
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Information regarding fuel nozzle shuts off prematurely. *yh
- Bulletin:
- 010866013
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Information regarding end gate lock cylinder being loose. *yh
- Bulletin:
- 021001
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Information regarding the black polypropylene material that surrounds the removable back glass may be cracked. *yh
- Bulletin:
- 261001
- Component:
- 162000 structure:body
- Summary:
- Some vehicles with roof racks may exhibit staining and the appearance of corrosion in the areas of the rubber seals that run along the sides of the roof panel above both doors. *tt
- Bulletin:
- 261001
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Some vehicles may have a crack that surrounds the moveable back glass. *tt
- Bulletin:
- 021101
- Component:
- 162500 structure:body:tailgate
- Summary:
- Information on tailgate closing efforts. *tt
- Bulletin:
- 061101
- Component:
- 980000 unknown or other
- Summary:
- Concerns with flapping noise emanating from the dash area, usually when the engine is running and the radio is off. *tt
- Bulletin:
- 201101
- Component:
- 120000 exterior lighting
- Summary:
- Information addressing headlamp, fog lamp and daytime running lamp condensation. *tt
- Bulletin:
- 201101
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Information on full size 3/4 ton uitility trucks equipped with dual fuel tanks. *tt
- Bulletin:
- 010102
- Component:
- 120000 exterior lighting
- Summary:
- Subject regarding head lamp fog lamp and daytime running lamp condensation. *jg
- Bulletin:
- 010864015
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Subject regarding front and rear side door access door noise (replace door check link). *jg
- Bulletin:
- 010864014
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Subject regarding door manual lock lever disengages from door trim panel (repair lock lever) *jg
- Bulletin:
- 020857001
- Component:
- 162000 structure:body
- Summary:
- Experiencing water on mat in rear corners of cargo box. *tt
- Bulletin:
- 010139007
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- A condition may exist where the customer cannot control the hvac system modes and / or the temperature. *tt
- Bulletin:
- 010139007
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding loss of hvac system mode and/or temperature control. *tt
- Bulletin:
- 010866015
- Component:
- 162500 structure:body:tailgate
- Summary:
- Some customers may comment that the end gate handle binds when opening. *tt
- Bulletin:
- 010102
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Subject regarding revised removable back glass to address cracked encapsulation. *tt
- Bulletin:
- 010102
- Component:
- 162000 structure:body
- Summary:
- Subject regarding front facia fit to fender. *tt
- Bulletin:
- 020310001
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- Information concerning the spare tire having a different size than other tires. *tt
- Bulletin:
- 020857002
- Component:
- 980000 unknown or other
- Summary:
- Some customers may comment that the rear floor carpet is wet. *tt
- Bulletin:
- 020866001
- Component:
- 162000 structure:body
- Summary:
- Cargo cover seal pulls off. *yd
- Bulletin:
- 041201
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on customers reporting intermittent stall or no start condition. *tt
- Bulletin:
- 111201
- Component:
- 162000 structure:body
- Summary:
- Exhibiting a condition where the upper rear corners of the front fascia are deflected outboard of the front fender at the wheelhouse opening. *tt
- Bulletin:
- 080102
- Component:
- 131000 visibility:windshield
- Summary:
- Subject regarding flutter noise in the area of the lower windshield pillars. *tt
- Bulletin:
- 220102
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Customers may comment that it may be difficult to completely fill the fuel tank. *tt
- Bulletin:
- 020866002
- Component:
- 162000 structure:body
- Summary:
- Some customers may comment on water leaking down the inside of the endgate. *slc
- Bulletin:
- 020604112
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Some customers may comment that the fuel tank on 2002 chevrolet and gmc c/k series is difficult to fill from approximately 3/4 to full . *slc
- Bulletin:
- 010102
- Component:
- 106000 power train:axle assembly
- Summary:
- Product feedback request for vehicle exhibiting rear axle whine condition until may 24, 2002. *tt
- Bulletin:
- 010102
- Component:
- 162000 structure:body
- Summary:
- Subject regarding water leak repairs for wet carpeting in the passenger compartment in certain models including the ext model. *tt
- Bulletin:
- 020866008
- Component:
- 162500 structure:body:tailgate
- Summary:
- Some customers may comment that the endgate appears to be closed but opens periodically while driving. *tt
- Bulletin:
- 020842002
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Subject regarding headlamp condensation. *tt
- Bulletin:
- 020604023
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment on a mild to severe engine ping (spark knock) during acceleration and / or illuminated malfunction indicator lamp with diagnostic trouble code p0332 set. *tt
- Bulletin:
- 020604023A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment on a mild to severe engine ping (commonly referred to as spark knock) usually worse during acceleration and / or an illuminated malfunction indicator lamp. *tt
- Bulletin:
- 010601029B
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment on higher than expected engine oil consumption. *tt
- Bulletin:
- 010864014A
- Component:
- 162300 structure:body:door
- Summary:
- Some customers may comment that the manual lock lever comes loose from the door trim panel. *tt
- Bulletin:
- 020421004
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Some customers may comment on the service 4wd indicator illuminating with diagnostic trouble code b2725 set. *tt
- Bulletin:
- 020421005
- Component:
- 100000 power train
- Summary:
- Some vehicles will not move when 4-wheel drive is requested, noise, shudder, poor performance, transmission / transfer case slips, transmission will not upshift, slips in 4-wheel drive. *tt
- Bulletin:
- 020730024A
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
- Bulletin:
- 040902
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Certain vehicles may be suspect of a mid gate glass encapsulation cracking condition. *tt
- Bulletin:
- 041802
- Component:
- 160000 structure
- Summary:
- Information on diagnosing water leaks in the rear passenger and the front seating areas. *tt
- Bulletin:
- 051402
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Customers may comment that the end gate does not latch properly from side to side. *tt
- Bulletin:
- 040602
- Component:
- 162000 structure:body
- Summary:
- Subject regarding wet carpet at passenger foot well condition. *tt
- Bulletin:
- 100602
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the june edition of emerging issues for various models. *tt
- Bulletin:
- 110602
- Component:
- 162000 structure:body
- Summary:
- This message involves the three-piece hard surface cargo cover. *tt
- Bulletin:
- 190602
- Component:
- 160000 structure
- Summary:
- Subject regarding the optional chrome tubular assist steps. *tt
- Bulletin:
- 020522004A
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
- Bulletin:
- 020601029
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Needle bearings found in oil pan. *tt
- Bulletin:
- 020522004
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
- Bulletin:
- 020863003
- Component:
- 162200 structure:body:bumpers
- Summary:
- Bumper fascia cover retainers pulling out of fascia. *tt
- Bulletin:
- 020601035
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- High oil consumption. *tt
- Bulletin:
- 020522004B
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
- Bulletin:
- 020526002
- Component:
- 050000 parking brake
- Summary:
- Scraping noise from rear of vehicle. *tt
- Bulletin:
- 020523004
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Some vehicles may exhibit a reduced brake power message on the driver's information center (dic). *tt
- Bulletin:
- 020605005A
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Exhaust / muffler heat shield rattle, popping noise under vehicle. *tt
- Bulletin:
- 020601038
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine knock or lifter noise. *tt
- Bulletin:
- 000235003B
- Component:
- 010000 steering
- Summary:
- Clunking noise under hood and can be felt in the steering wheel. *tt
- Bulletin:
- 020421005A
- Component:
- 100000 power train
- Summary:
- Slips in 4-wheel drive, noise, vibration, leaks, hot odor. *tt
- Bulletin:
- 030730005
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service engine soon indicator illuminated, transmission slips, engine flare, delayed 2-3 shift, shifts missing, no shift, diagnostic trouble codes p0730, p0756, p0757. *tt
- Bulletin:
- 030417001C
- Component:
- 106000 power train:axle assembly
- Summary:
- Whine noise from rear axle. *tt update. *tt
- Bulletin:
- 020604054B
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Increased accelerator pedal effort, idle instability. *tt
- Bulletin:
- 030601011
- Component:
- 060000 engine and engine cooling
- Summary:
- Accessory drive belt whine. *tt
- Bulletin:
- 030604030
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
- Bulletin:
- 000842010A
- Component:
- 120000 exterior lighting
- Summary:
- Daytime running lamp (drl) bulb replacement. *tt
- Bulletin:
- 020604012A
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Slow, difficult fuel fill, short fill, fuel gauge inaccurate. *tt
- Bulletin:
- 030308002
- Component:
- 020000 suspension
- Summary:
- Rattle/squeak from front of vehicle. *tt *ar
- Bulletin:
- 030417001
- Component:
- 106000 power train:axle assembly
- Summary:
- Whine noise from rear axle. *tt
- Bulletin:
- 030418003
- Component:
- 106000 power train:axle assembly
- Summary:
- Revised wheel drive shaft inner joint and seal replacement. *tt
- Bulletin:
- 030864018
- Component:
- 120000 exterior lighting
- Summary:
- Outside rearview mirror courtesy lamp falls out, bulb burns out. *tt
- Bulletin:
- 030844011
- Component:
- 162000 structure:body
- Summary:
- Tweeter speaker rattle in front side door(s), tweeter speaker falls out of position. *tt
- Bulletin:
- 060303
- Component:
- 980000 unknown or other
- Summary:
- Water management system. function, maintenance and preventative measures mentioned in the may emerging issues idl broadcast. *tt
- Bulletin:
- 01139B
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning compressor belt or tensioner jumps or flutters causing a rattle noise. service vme. *tt
- Bulletin:
- 01335
- Component:
- 980000 unknown or other
- Summary:
- Real time dampening module identification. *tt
- Bulletin:
- 01367
- Component:
- 162000 structure:body
- Summary:
- Noise from lower door or running board at road speeds. *tt
- Bulletin:
- 00634A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Gen iii engine noise after hot soak restart. *tt
- Bulletin:
- 01414
- Component:
- 162000 structure:body
- Summary:
- Discoloration of cargo covers. service dme. *tt
- Bulletin:
- 01415
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cam sensor connector does not fit sensor when engine is replaced. *tt
- Bulletin:
- 01414B
- Component:
- 350000 equipment
- Summary:
- Parts restriction for cargo covers cancelled. service vme. this bulletin replaces 01414a dated 11/18/03. *tt
- Bulletin:
- 030525007
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
- Bulletin:
- 030601023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt
- Bulletin:
- 01470
- Component:
- 180000 vehicle speed control
- Summary:
- Erratic idle, idle surge, rough run, or near stall. *tt
- Bulletin:
- 000235003C
- Component:
- 010000 steering
- Summary:
- Clunking noise under hood and can be felt in the steering wheel. *tt
- Bulletin:
- 030419001A
- Component:
- 106000 power train:axle assembly
- Summary:
- Use of synthetic front axle lubricant for 4wd vehicles sold in cold weather climates. *tt this bulletin replaced previous bulletin dated 10/01/2003. *tt
- Bulletin:
- 030866012
- Component:
- 162000 structure:body
- Summary:
- Midgate rear glass storage retainers now available for service. *tt
- Bulletin:
- 030604060
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt
- Bulletin:
- 030234001A
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Inner tie rod released for service. *tt
- Bulletin:
- 091503
- Component:
- 162000 structure:body
- Summary:
- Discoloration of the cargo covers. gm voicemail log. *tt
- Bulletin:
- 030235006
- Component:
- 010000 steering
- Summary:
- Revised steering wheel replacement procedure. *tt
- Bulletin:
- 030309002
- Component:
- 020000 suspension
- Summary:
- Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
- Bulletin:
- 030857001A
- Component:
- 162000 structure:body
- Summary:
- Rear floor carpet wet with dirty water. *tt
- Bulletin:
- 01555
- Component:
- 020000 suspension
- Summary:
- D height specification missing from si. sit bulletin 1410632. *tt
- Bulletin:
- 00969A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine whistle noise. *tt
- Bulletin:
- 00702
- Component:
- 103000 power train:automatic transmission
- Summary:
- Slip condition in 2nd, 3rd or 4th damaged 2-4 band 3-4 clutch on the 4l60e/4l65e automatic transmission. *tt *mj
- Bulletin:
- 01483
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Vehicle has no pcm (power train control module) communication with tech 2. sit bulletin 1400427. *tt
- Bulletin:
- 3259C
- Component:
- 103000 power train:automatic transmission
- Summary:
- 4l80e, 4l85e whine noise in first and second gear. *tt
- Bulletin:
- 010866006A
- Component:
- 162000 structure:body
- Summary:
- Information regarding cadillac escalade ext and chevrolet avalanche cargo area. *tt
- Bulletin:
- 030138019
- Component:
- 353600 equipment:air conditioner
- Summary:
- Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
- Bulletin:
- 030730056
- Component:
- 103000 power train:automatic transmission
- Summary:
- 4l60-e automatic transmission oil pump first and second design identification. *tt
- Bulletin:
- 030605008B
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt
- Bulletin:
- 020526001B
- Component:
- 040000 service brakes, air
- Summary:
- Rear parking brake shoe retaining spring clip service kit for drum-in-hat (dih) equipped vehicles. *tt update. *tt
- Bulletin:
- 01760
- Component:
- 162000 structure:body
- Summary:
- Buzz noise from headliner above driver. *mr
- Bulletin:
- 01698
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield reveal molding flutering. service vme. sit bulletin 1450940. *tt
- Bulletin:
- 01913
- Component:
- 350000 equipment
- Summary:
- Cargo covers- cladding stained or discolored. *mr
- Bulletin:
- 01610
- Component:
- 162000 structure:body
- Summary:
- Stained or faded cargo covers. *tt
- Bulletin:
- 01634
- Component:
- 010000 steering
- Summary:
- Intermediate steering shaft service kit. service vme. *tt
- Bulletin:
- 01599
- Component:
- 100000 power train
- Summary:
- 4l60e, 4l65e forward and low reverse waved steel clutch plate appearance change. *tt
- Bulletin:
- 01624
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Gen iii engines with maf (mass airflow) sensor code p0101. *tt
- Bulletin:
- 01634A
- Component:
- 010000 steering
- Summary:
- Supplement to 00-02-35-003d - clunking noise under hood and can be felt in the steering wheel. *tt
- Bulletin:
- 01913A
- Component:
- 350000 equipment
- Summary:
- Cargo covers- cladding stained or discolored. *tt
- Bulletin:
- 00372D
- Component:
- 353000 equipment:electrical
- Summary:
- Onstar system is attempting and/or completing phone calls which the operator of the vehicle did not initiate. *tt
- Bulletin:
- 00266
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt
- Bulletin:
- 01586
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 8.1l changes in heads, bolts and gasket for for 2004 1/2 engines. various models including the chevrolet and gmc 2500hd/3500 my2001-2004 and 2001, 2002, and 2003 gmt 560. *mj
- Bulletin:
- 02052
- Component:
- 160000 structure
- Summary:
- Noise coming from instrument panel cluster or tachometer. *tt
- Bulletin:
- 00711A
- Component:
- 353600 equipment:air conditioner
- Summary:
- The fan blower motor continues to run after the key has been turned off or the a/c control head locking up. *tt
- Bulletin:
- 01353
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire due to injector fretting corrosion. *tt
- Bulletin:
- 010860001
- Component:
- 160000 structure
- Summary:
- Revised recommendations regarding paint for structural reaction injection molding (srim) composite box. *tt
- Bulletin:
- 11062002
- Component:
- 190000 tires
- Summary:
- Information when performing a four-wheel balance using labor code e0203 and/or tire replacing using labor code e0431 or e0437. *tt
- Bulletin:
- 040495001
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Revised wheel drive shaft nut torque specification. *tt
- Bulletin:
- 040525002B
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
- Bulletin:
- 3032
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon (ses) light on with p0446 due to dust in the evap vent valve on vehicles that are operated in dusty environments, such as farming or off-road applications. *tt
- Bulletin:
- 3025
- Component:
- 220000 seats
- Summary:
- Repairing cloth seats with napped fabric. *mj
- Bulletin:
- 3028
- Component:
- 022000 suspension:rear
- Summary:
- Replacement tailgate cables bind at shoulder bolt. *mj
- Bulletin:
- 3002
- Component:
- 100000 power train
- Summary:
- 4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
- Bulletin:
- 3001
- Component:
- 106000 power train:axle assembly
- Summary:
- The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
- Bulletin:
- 3004
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj
- Bulletin:
- 3000A
- Component:
- 022000 suspension:rear
- Summary:
- Rear axle locking differential chatter shudder noise on turns. *mj
- Bulletin:
- 04222004
- Component:
- 162000 structure:body
- Summary:
- This message relates to the purchase of armor-dillo to treat faded or stained cargo covers and cladding. gm voicemail express. *tt
- Bulletin:
- 3045
- Component:
- 200000 wheels
- Summary:
- Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
- Bulletin:
- 09172002
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Mid gate glass encapsulation cracking condition. *tt
- Bulletin:
- 09172002
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Roof racks exhibiting staining and the presence of corrosion in areas of the rubber seals that run along the sides of the roof panel above both doors. *tt
- Bulletin:
- 09182002
- Component:
- 162000 structure:body
- Summary:
- Field reports that exterior non-painted cladding and bed covers appear to lighten in color or fade. *tt
- Bulletin:
- 09182002
- Component:
- 162000 structure:body
- Summary:
- Light colored grease like substance coming from the three-panel bed hardcover area. *tt
- Bulletin:
- 3086
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
- Bulletin:
- 3086
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt
- Bulletin:
- 3073
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Downhill cruise control surge. *tt
- Bulletin:
- 3047
- Component:
- 350000 equipment
- Summary:
- 99 through 05 year vehicles, equipped with three-button onstar systems. *tt
- Bulletin:
- 3054
- Component:
- 100000 power train
- Summary:
- Replacement flexplate may have larger bolt holes than the original flexplate. *tt
- Bulletin:
- 3055
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
- Bulletin:
- 3147
- Component:
- 060000 engine and engine cooling
- Summary:
- Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc
- Bulletin:
- 3118A
- Component:
- 160000 structure
- Summary:
- Pop/clunk noise on right or left turns. *tc *sc
- Bulletin:
- 3121
- Component:
- 060000 engine and engine cooling
- Summary:
- Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
- Bulletin:
- 3139
- Component:
- 160000 structure
- Summary:
- Water intrusion into cab at midgate. *sc
- Bulletin:
- 3024
- Component:
- 060000 engine and engine cooling
- Summary:
- Gen iii engine coated piston information. *tc
- Bulletin:
- 3119
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- Engineering investigation - catalytic converter replacement. *sc
- Bulletin:
- 3168
- Component:
- 110000 electrical system
- Summary:
- Traction off lamp being illuminated. supplement to tsb: 03-05-25-002. *tc
- Bulletin:
- 3107
- Component:
- 060000 engine and engine cooling
- Summary:
- P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
- Bulletin:
- 3144
- Component:
- 162800 structure:body:hood
- Summary:
- Supplement to 00-02-35-003f clunking noise under hood and can be felt in steering wheel. *sc
- Bulletin:
- 3121
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
- Bulletin:
- 3056
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
- Bulletin:
- 04007A
- Component:
- 162500 structure:body:tailgate
- Summary:
- Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
- Bulletin:
- 3193
- Component:
- 060000 engine and engine cooling
- Summary:
- Excessive oil consumption. *eh
- Bulletin:
- 3243
- Component:
- 010000 steering
- Summary:
- Pop/clunk/click noise on right or left turns. *eh
- Bulletin:
- 040857005
- Component:
- 162000 structure:body
- Summary:
- Water intrusion into cab at midgate. *tt
- Bulletin:
- 040523001A
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
- Bulletin:
- 040864003
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
- Bulletin:
- 0408111001
- Component:
- 162000 structure:body
- Summary:
- Cargo covers and/or body cladding discolored (chalky). *tt this bulletin replaced previous bulletin 04-08-111-001, dated 01/01/2004. *tt
- Bulletin:
- 040138010
- Component:
- 353600 equipment:air conditioner
- Summary:
- Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
- Bulletin:
- 040310007D
- Component:
- 020000 suspension
- Summary:
- 20 inch wheels and tires available through gmspo. *tt updated. *nm
- Bulletin:
- 040523006
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Revised brake pads replacement-rear. *tt
- Bulletin:
- 000235003E
- Component:
- 010000 steering
- Summary:
- Clunking noise under hood and can be felt in steering wheel. this bulletin replaces previous bulletin 00-02-35-003e. *tt
- Bulletin:
- 040861003
- Component:
- 162000 structure:body
- Summary:
- Running board cover is loose. *eh
- Bulletin:
- 3232
- Component:
- 060000 engine and engine cooling
- Summary:
- Misfire at idle cold and possible p0171 and or p0174. *eh
- Bulletin:
- 3203
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Resonance noise at idle. *eh
- Bulletin:
- 3227
- Component:
- 162500 structure:body:tailgate
- Summary:
- Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
- Bulletin:
- 3118B
- Component:
- 162000 structure:body
- Summary:
- Pop cluck click noise on right or left turns. *eh
- Bulletin:
- 000235003
- Component:
- 010000 steering
- Summary:
- Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
- Bulletin:
- 040866009
- Component:
- 162000 structure:body
- Summary:
- Stowage box lid strap breaking. *tt
- Bulletin:
- 040850011
- Component:
- 150000 seat belts
- Summary:
- Repairing napped seat fabric. *eh
- Bulletin:
- 040601018
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt
- Bulletin:
- 020310001A
- Component:
- 190000 tires
- Summary:
- Spare tire is different size than other tires. this service bulletin replaces 020310001. *eh update. *tt
- Bulletin:
- 040604040
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Idle instability, low or rough idle with electronic throttle control. *tt
- Bulletin:
- 030310002
- Component:
- 190000 tires
- Summary:
- Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
- Bulletin:
- 040139007
- Component:
- 353600 equipment:air conditioner
- Summary:
- Loss of heating ventilation air conditioning. system mode and or temperature control. *eh
- Bulletin:
- 040848003
- Component:
- 131000 visibility:windshield
- Summary:
- Windrush around windshield. *tt
- Bulletin:
- 030419003
- Component:
- 105000 power train:driveline
- Summary:
- Fluid leak from front of vehicle add teflon tape to front axle vent plug threads. *eh
- Bulletin:
- 030236002
- Component:
- 010000 steering
- Summary:
- Revised steering wheel position sensor or steering shaft lower bearing replacement procedure and steering wheel position sensor centering procedure. *eh
- Bulletin:
- 040603002
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnostic information for intermittent vehicle no crank dead battery. *eh
- Bulletin:
- 01292004
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
- Bulletin:
- 3300C
- Component:
- 341000 communications:horn assembly
- Summary:
- Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
- Bulletin:
- 3276
- Component:
- 100000 power train
- Summary:
- 4l80e output carrier thrust washer changes. *tt
- Bulletin:
- 3373
- Component:
- 140000 air bags
- Summary:
- Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
- Bulletin:
- 3386
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Lack of steering assist or shudder during parking lot type maneuvers. *tt
- Bulletin:
- 3300
- Component:
- 105000 power train:driveline
- Summary:
- 4wd models with noise, vibration on dry pavement. *eh
- Bulletin:
- 07012004
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
- Bulletin:
- 3351
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
- Bulletin:
- 3232
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
- Bulletin:
- 3499
- Component:
- 017300 steering:linkages:arm:idler and attachment
- Summary:
- Steering idler arm inspection procedure. *tt
- Bulletin:
- 020307002
- Component:
- 020000 suspension
- Summary:
- Revised front caster and camber adjustment procedure. original not yet received. *tt
- Bulletin:
- 020846009
- Component:
- 350000 equipment
- Summary:
- Proper onstar cellular antenna mast usage. *tt
- Bulletin:
- 3364
- Component:
- 106000 power train:axle assembly
- Summary:
- Rear axle retainer button breakage. *eh
- Bulletin:
- 050604024
- Component:
- 060000 engine and engine cooling
- Summary:
- Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
- Bulletin:
- 050864007
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Outside rearview mirror housings come loose from base. *tt
- Bulletin:
- 510
- Component:
- 220000 seats
- Summary:
- Repairing napped fabric-seats may have been upholstered in napped fabrics with dorchester on the bolster and honeycomb on the insert. *sc
- Bulletin:
- 3526
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
- Bulletin:
- 3525
- Component:
- 022000 suspension:rear
- Summary:
- Automatic level control inoperative due to water ingestion. *tt
- Bulletin:
- 05068
- Component:
- 046300 service brakes, air:antilock:wheel speed sensor
- Summary:
- Product safety recall regarding front wheel speed sensor corrosion. *tt
- Bulletin:
- 3427
- Component:
- 110000 electrical system
- Summary:
- Additional diagnostic information dtc p0757. *tt
- Bulletin:
- 00773
- Component:
- 100000 power train
- Summary:
- 4l60e, 4l65e replacement valve body gaskets does not seem to fit. *tt
- Bulletin:
- 3455
- Component:
- 046300 service brakes, air:antilock:wheel speed sensor
- Summary:
- Supplement to 04094 front wheel speed sensor corrosion. *tt
- Bulletin:
- 3424
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Electronic transfer case unable to complete shift. *tt
- Bulletin:
- 050310005
- Component:
- 200000 wheels
- Summary:
- Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
- Bulletin:
- 020867009
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Sunroof jams when closing. *tt
- Bulletin:
- 050850012
- Component:
- 220000 seats
- Summary:
- Unwanted/loose seat movement. *tt
- Bulletin:
- 3782
- Component:
- 122000 exterior lighting:fog lights
- Summary:
- Fog lamps inoperative. *tt
- Bulletin:
- 3340
- Component:
- 021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
- Summary:
- Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
- Bulletin:
- 4231
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
- Bulletin:
- 3300
- Component:
- 341000 communications:horn assembly
- Summary:
- Horn inoperative at times. *kb
- Bulletin:
- 4030
- Component:
- 106000 power train:axle assembly
- Summary:
- New design front axle side bearing adjusters. *kb
- Bulletin:
- 040525002
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
- Bulletin:
- PIP3343
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
- Bulletin:
- PIP4054A
- Component:
- 022000 suspension:rear
- Summary:
- Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
- Bulletin:
- 08-089
- Component:
- 353000 equipment:electrical
- Summary:
- Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
- Bulletin:
- PIT-3046E
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
- Bulletin:
- PIT-4722
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
- Bulletin:
- 08-089B
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Buick\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. csc letter was received. *pe
- Bulletin:
- 08089-B
- Component:
- 110000 electrical system
- Summary:
- General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
- Bulletin:
- SB-10-02-33-001
- Component:
- 010000 steering
- Summary:
- Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
- Bulletin:
- PIP-4138K
- Component:
- 060000 engine and engine cooling
- Summary:
- Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
- Bulletin:
- 09-09-40-001A
- Component:
- 150000 seat belts
- Summary:
- Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
- Bulletin:
- 10-00-89-017C
- Component:
- 980000 unknown or other
- Summary:
- Gm: information on fixing multiple situations right the first time. *rm
- Bulletin:
- PI-0011A
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
- Bulletin:
- SB-10-08-50-003B
- Component:
- 221300 seats:front assembly:head restraint
- Summary:
- General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
- Bulletin:
- PIT-4954-C
- Component:
- 020000 suspension
- Summary:
- Gm: if the service suspension system is displayed on the dic, the trim height may be incorrect, loose compressor inlet hose, or the compressor self test may be inoperative. also included suburban ld my 2001-2013, yukon denali xl my 2013, y
- Bulletin:
- SB-13-05-22-001
- Component:
- 034100 service brakes, hydraulic:foundation components:master cylinder
- Summary:
- Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
- Bulletin:
- PIP5226A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
- Bulletin:
- PIC5953
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIT3227J
- Component:
- 162500 structure:body:tailgate
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
- Bulletin:
- PIP5163A
- Component:
- 060000 engine and engine cooling
- Summary:
- This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
- Bulletin:
- 03-08-46-004R
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
- Bulletin:
- PIT3237G
- Component:
- 131000 visibility:windshield
- Summary:
- This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
- Bulletin:
- PIP5072
- Component:
- 101000 power train:clutch assembly
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. technician will inspect the 3-4 clutches and the forward clutch
- Bulletin:
- PIT3665C
- Component:
- 030000 brakes (pws)
- Summary:
- This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
- Bulletin:
- PIP3720D
- Component:
- 106000 power train:axle assembly
- Summary:
- This preliminary information communication provides information to the technician with the axel setup information from american axle manufacturing. technician should be advised that the maximum pinion shim to be used or stacked behind the p
- Bulletin:
- PIT3271F
- Component:
- 190000 tires
- Summary:
- This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
- Bulletin:
- PIP3259J
- Component:
- 100000 power train
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. technician should compare the noise to a like vehicle. technician will nee
- Bulletin:
- PIP4138L
- Component:
- 100000 power train
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
- Bulletin:
- 15-08-44-001B
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-44-001A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 05-06-04-035E
- Component:
- 090000 fuel system, other
- Summary:
- This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
- Bulletin:
- 15-08-44-001
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
- Bulletin:
- 15-08-73-001
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
- Bulletin:
- 09-09-40-001C
- Component:
- 150000 seat belts
- Summary:
- This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic
- Bulletin:
- 11-00-89-005C
- Component:
- 356000 equipment adaptive
- Summary:
- This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
- Bulletin:
- PIC4310K
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIC3278F
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
- Bulletin:
- PIT5264C
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
- Bulletin:
- PIC5953A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
- Bulletin:
- PIC4310L
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
- Bulletin:
- PIT5399
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
- Bulletin:
- PIP5232B
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Home | Privacy