2002 AUDI TT Recalls (2)

Campaign:: 07E023000 on 03/28/2007
Component:: Service brakes, hydraulic:foundation components:master cylinder
Affected:: 13,128
Defect:: Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
Consequence:: Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Correction:: Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
Notes:: This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 14E007000 on 03/11/2014
Component:: Engine and engine cooling:engine
Affected:: 50
Defect:: The gates corporation (gates) is recalling certain aftermarket tru-flow water pumps, part number tfw 41127, sold at certain napa auto parts and/or installed by automotive service technicians after november 1, 2013 (and manufactured august 2013 through october 2013) that have a black-colored pulley/sprocket or do not have 'us9377' stamped on the water pump housing. these service replacement parts were sold for use in model year 1999-2005 audi a4, 2000-2006 audi tt, 1998-2005 volkswagen beetle, 1999-2006 golf, 1999-2008 and 2011-2013 volkswagen jetta, and 2000-2005 volkswagen passat. in the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Consequence:: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Correction:: Gates will notify owners, and dealers will replace the water pump, free of charge. the recall began during may 2014. owners may contact the gates corporation at 1-303-744-1911.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2002 AUDI TT TSBs (65)

Bulletin:: 910202
Component:: 110000 electrical system
Summary:: Subject regarding noise interference in the am radio for certain models with all wheel drive. *tt
Bulletin:: 0207
Component:: 061000 engine and engine cooling:engine
Summary:: Diagnosis of driveability complaints such as rough idling, hesitation, lack of power and multiple misfires or diagnostic trouble codes p0103, p1111, p1112, p1128, p1130, p1144, p1145, p1146, p1147, p1148 or p1557 on turbo charged engines.
Bulletin:: 0401
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: Oil leak in area of turbocharger. *mj
Bulletin:: 240501
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: Fuel injectors, unnecessary replacement. *tt
Bulletin:: 0501
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: Fuel injectors, unnecessary replacement. update. *tt
Bulletin:: 0402
Component:: 060000 engine and engine cooling
Summary:: Oil leaks from upper engine areas, diagnostic guidelines. *tt
Bulletin:: 09012006
Component:: 116000 electrical system:ignition
Summary:: Ignition coils may fail causing a rough idle or reduced driving power could occur. *kb
Bulletin:: 20056243
Component:: 121000 exterior lighting:headlights
Summary:: Headlight aiming, using hella universal beamsetter. *kb
Bulletin:: 20036582
Component:: 061000 engine and engine cooling:engine
Summary:: Loses power or will not move after stop. *kb
Bulletin:: AWA-08-05
Component:: 117000 digital instrument panel
Summary:: Limited warranty extension on original instrument clusters for 2000-2005 audi tt vehicles. *pe
Bulletin:: 2012749-2
Component:: 121000 exterior lighting:headlights
Summary:: Exterior lights, mositure accumulation. *pe
Bulletin:: AWA-08-05
Component:: 117000 digital instrument panel
Summary:: Audi: limited new vehicle warranty for original equipment manufacturer instrument clusters for 2000-2005 model year tt vehicles up to and including vin tru_8n_51017389 is extended to six (6) years from the vehicle's original in service da
Bulletin:: 101508
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: Audi service campaign: see document search button for owner letter. csc letter was received for audi model years 2000-2003 a4 and tt. revised maintenance instructions and a warranty extension covering certain timing belt tensioner system re
Bulletin:: 15-D-4-JZ
Component:: 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:: Audi: the internal engine damage resulting from a broken timing belt. if the timing belt of vehicle were to break, the engine will not run and may sustain serious internal damage. *pe
Bulletin:: 15D4/JZ
Component:: 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:: Audi service campaign: see document search button for owner letter. internal engine damage resulting from a broken timing belt. if timing belt of vehicle were to break, the engine will not run and may sustain serious internal damage.
Bulletin:: TSB-44-08-14
Component:: 203000 wheels:lugs/nuts/bolts
Summary:: Audi: wheel bolts require torque adjustment. torque sticks and torque extension bars are not approved by audi of america, inc. and should not be used to apply torque to wheel bolts. all audi models included. *pe
Bulletin:: TSB-01-08-33
Component:: 118000 electrical system: software
Summary:: Audi: software version management(svm) operating instructions. its a process to update the programming in flashable (reprogrammable) control modules and/or to document changes in software levels in all audi vehicles. *pe
Bulletin:: TSB-01-09-06
Component:: 118000 electrical system: software
Summary:: Audi: software version management (svm), operating instructions. svm is a process to update the programming in flashable (re-programmable) control modules and/or to document changes in software levels in audi vehicles. this system uses t
Bulletin:: SA-28F2 J1
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Audi: (revised) vehicles affected by this action may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminate to let you know that the vehicle may experience
Bulletin:: TSB-28-10-04
Component:: 116000 electrical system:ignition
Summary:: Audi: for interim claims for 28f2/j1 vehicles campaign only. applicable vehicles must fall within vin ranges noted. engines 2.8l are not affected in this scope. coils of screw down design (non pencil type) are also not affected. the mi
Bulletin:: TSB-28F2
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Audi: emissions service action circular. gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. the malfuncti
Bulletin:: TSB-28F2-REV 7
Component:: 116000 electrical system:ignition
Summary:: Audi: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. (added phase 7-april 10 vin information).malfuncti
Bulletin:: TSB-00-10-02
Component:: 118000 electrical system: software
Summary:: Audi: software version management (svm) operating instructions. detailing the general process for carrying out a software version management (svm) software update for any tsb or required vehicle update (rvu). troubleshooting information
Bulletin:: SAC-28F2-REV
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Audi: gasoline engine vehicles; inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. added final mailing phase-8/10 vin information.
Bulletin:: TSB-01-12-39
Component:: 061000 engine and engine cooling:engine
Summary:: Audi: engine has reduced engine performance without loss of power or stalling; circuit grounds; fuel quality poor; mil is constantly illuminated or flashing; rough idle; ignition coils incorrectly installed; electrical connections loose or
Bulletin:: 37-13-07
Component:: 180000 vehicle speed control
Summary:: Audi: some vehicles may lack power or will not move after stop due to simultaneously depressing the brake and accelerator pedals. *js
Bulletin:: TSB-44-13-46
Component:: 356000 equipment adaptive
Summary:: Audi: on certain vehicles, use calibrated torque wrench and not torque sticks, torque extension bars and impact guns/wrenches not approved for usage on wheel bolts by manufacturer, that can cause damage to brake, steering wheel, hub. mode
Bulletin:: SB-01-15-29
Component:: 060000 engine (pws)
Summary:: Audi: engine, on some vehicles, would run irregularly or have malfunction indicator lamp (mil) on or possible filter element for camshaft adjustment valve can loosen and in oil circuit, there is no damage from loosened particles. model al
Bulletin:: A011514 2014753-
Component:: 070000 fuel system, gasoline
Summary:: Supersedes technical service bulletin group 01 number 13-09 dated june 21, 2013. the use of contaminated gasoline or gasoline with a low content of deposit control additives may result in excessive accumulation of deposits on intake valves,
Bulletin:: A101511 2018288-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 10 number 13-10 dated september 5, 2013. prior to engine replacement, any debris lodged in transferred assemblies must be removed. if the engine experienced a serious mechanical problem, it is pos
Bulletin:: A171557 2010043-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 17 number 13-35 dated january 9, 2013. this bulletin lists engine oils that meet audi oil quality standards (vw 501 01, 502 00, 505 00, 505 01, and 504 00/507 00).
Bulletin:: A911579 2038824-
Component:: 110000 electrical system
Summary:: Supersedes technical service bulletin group 91 number 14-69 dated november 4, 2014. the following message appears on the mmi display: "device or cable type not supported". the ami cable being used is a genuine audi-branded cable with an aud
Bulletin:: A941565 2012749-
Component:: 121000 exterior lighting:headlights
Summary:: Supersedes technical service bulletin group 94 number 12-92 dated october 24, 2012. condensation is visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, or third brake l
Bulletin:: A971548 2013504-
Component:: 110000 electrical system
Summary:: Supersedes technical service bulletin group 97 number 10-15 dated october 20, 2010. sporadic fault memory entries are stored in various control modules. contacts may be widened (over 0.63 mm) if incorrect pins or incorrect methods for curre
Bulletin:: A011507 2028344-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 01 number 13-69 dated february 14, 2013. noises and inconsistent engine operation after cold start during the catalyst heating phase. the customer may misinterpret these symptoms as engine misfiri
Bulletin:: A101310 2018288-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 10 number 10-02 dated september 14, 2010. prior to engine replacement, any debris lodged in transferred assemblies must be removed. if the vehicle's engine experienced a serious mechanical problem
Bulletin:: A901341 2010353-
Component:: 356000 equipment adaptive
Summary:: Supersedes technical service bulletin group 90 number 10-14 dated august 10, 2010. cigarette lighter element will not lock into the lighter socket -u1- to begin the heating process, or the lighter element will not automatically release once
Bulletin:: A441346 2010334-
Component:: 200000 wheels
Summary:: Supersedes technical service bulletin group 44 number 12-32 dated august 2, 2012. wheel bolt requires torque adjustment. torque sticks, torque extension bars, and impact guns/wrenches are not approved by audi of america, inc., and should no
Bulletin:: 741312 2004327-4
Component:: 160000 structure
Summary:: Supersedes technical service bulletin group 70 number 08-39 dated december 4, 2008. leather upholstery is dirty or stained.
Bulletin:: A191450 2025303-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 19 number 13-41 dated june 20, 2013. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service
Bulletin:: A371430 2003658-
Component:: 101100 power train:clutch assembly:pedal/linkage
Summary:: Supersedes technical service bulletin group 37 number 13-07 dated may 29, 2013. customer states that the engine returns to idle speed of approximately 1,400 rpm although the accelerator is depressed, and/or the vehicle hesitates (lacks powe
Bulletin:: A001465 2011732-
Component:: 118000 electrical system: software
Summary:: Supersedes technical service bulletin group 00 number 12-32 dated february 7, 2012. this technical service bulletin (tsb) details the general process for carrying out a software version management (svm) software update for any tsb or update
Bulletin:: A001467 2002047-
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Supersedes technical service bulletin group 00 number 14-61 dated may 1, 2014. technician preparation when calling the audi technical assistance center (tac).
Bulletin:: A941292 2012749-
Component:: 120000 exterior lighting
Summary:: Supersedes technical service bulletin group 94 number 11-52 dated october 11, 2011. condensation is visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, or third brake
Bulletin:: A171232 2018550-
Component:: 060000 engine (pws)
Summary:: Supersedes technical service bulletin group 17 number 12 - 31 dated august 30, 2012. oil consumption measurement - repair authorization (ca). in order to provide effective lubrication and cooling of internal engine components, all internal
Bulletin:: A191341 2025303-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 19 number 13-35 dated march 25, 2013. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service
Bulletin:: A011309 2014753-
Component:: 070000 fuel system, gasoline
Summary:: Supersedes technical service bulletin group 00 number 10-01 dated february 5, 2010. excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. engine runs rough after cold start. excessive
Bulletin:: A001578 2021205-
Component:: 355100 equipment:other:labels
Summary:: Supersedes technical service bulletin group 00 number 10-05 dated june 14, 2010. vin plate and/or b-pillar safety certification label requires replacement.
Bulletin:: A201559 2011703-
Component:: 070000 fuel system, gasoline
Summary:: Supersedes technical service bulletin group 20 number 13-29 dated november 15, 2013. the fuel tank has been removed from the vehicle and must be neutralized before shipment or disposal. when the fuel tank in a vehicle is replaced, the origi
Bulletin:: A191562 2025303-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 19 number 15-61 dated july 7, 2015. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service a
Bulletin:: A961501 2019260-
Component:: 118000 electrical system: software
Summary:: Supersedes technical service bulletin group 96 number 13-67 dated july 10, 2013. the customer may report that the handheld transmitter cannot be programmed to the garage door opener control module, j530. the customer?s door opener system ma
Bulletin:: A571385 2017082-
Component:: 110000 electrical system
Summary:: Supersedes technical service bulletin group 57 number 13-82 dated february 5, 2013. central locking via remote control does not work either sporadically or permanently. the locks can still be operated manually. missing synchronization betwe
Bulletin:: A191335 2025303-
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 19 number 11-19 dated february 10, 2011. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for serv
Bulletin:: A001348 2002047-
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Supersedes technical service bulletin group 00 number 11-19 dated april 8, 2011. this tsb contains information on technician preparation when calling the audi technical assistance center
Bulletin:: A571382 2017082-
Component:: 170000 latches/locks/linkages
Summary:: Supersedes technical service bulletin group 57 number 11-55 dated august 22, 2011. central locking via remote control does not work either sporadically or permanently. the locks can still be operated manually. missing synchronization betwee
Bulletin:: A961367 2019260-
Component:: 353000 equipment:electrical
Summary:: Supersedes technical service bulletin group 96 number 12-37 dated june 11, 2012. the customer may report that the handheld transmitter cannot be programmed to the garage door opener control module, j530. the customer's door opener system ma
Bulletin:: A441455 2010334-
Component:: 200000 wheels
Summary:: Supersedes technical service bulletin group 44 number 13-46 dated december 9, 2013. wheel bolt requires torque adjustment.
Bulletin:: A001470 2039206-
Component:: 110000 electrical system
Summary:: High quality media files (video and sound) are now integrated into technical service bulletins on a case-by-case basis. media files can now be viewed on any smartphone or tablet. audi of america has started to host its tsb videos outside of
Bulletin:: Accessories Oper
Component:: 350000 equipment
Summary:: This is an advance notice for audi of america employees. this notice contains information for the accessories operations technical bulletin.
Bulletin:: A941791 2012749-
Component:: 120000 exterior lighting
Summary:: This informational bulletin contains technical information for when there is condensation visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, and/or third brake light l
Bulletin:: A441662 2010334-
Component:: 200000 wheels
Summary:: This information tsb provides information regarding the correct way to torque adjust a wheel bolt.
Bulletin:: A571738 2017082-
Component:: 111000 electrical system:battery
Summary:: This informational bulletin contains instructions for sychronizing the remote key after the battery has been disconnected or replaced.
Bulletin:: ATE-17-05
Component:: 350000 equipment
Summary:: Due to increasing requests for high voltage personal protective equipment (hve ppe) for dealer technicians working with high voltage vehicles (hybrid, plugin hybrid, electric vehicle), the volkswagen tools and equipment team has identified
Bulletin:: A171782 2010043-
Component:: 060000 engine (pws)
Summary:: This informational bulletin contains all the the audi oil quality standards that should be used when doing an oil change.
Bulletin:: A1915612025303-5
Component:: 060000 engine and engine cooling
Summary:: Supersedes technical service bulletin group 19 number 14-50 dated june 20, 2014. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service

Home | Privacy