2002 AMTRAN CE Recalls (6)
- Campaign:
- 03V118000 on 03/31/2003
- Component:
- Seats
- Manufactured:
- 05/31/2002 - 07/30/2002
- Affected:
- 159
- Defect:
- Certain school buses equipped with flip seats fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." seats with seat belts were bolted to the floor without the use of required reinforcements under the floor.
- Consequence:
- during a crash, this condition may allow the seat to become loose which could cause personal injury or death to the seat occupant.
- Correction:
- Dealers will add reinforcements to the seat mounting at the floor. owner notification began on april 23, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic corporation at 1-800-843-5615.
- Notes:
- Ic corporation recall no. 03301.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V326000 on 09/03/2003
- Component:
- Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
- Manufactured:
- 06/03/2001 - 05/30/2002
- Affected:
- 75
- Defect:
- Certain flat floor school buses were built with the incorrect hydraulic brake drop hoses from frame to axle. the hoses installed were 3 inches shorter than specified and may fail from tension caused by axle articulation.
- Consequence:
- This hose failure will result in the loss of rear brakes, increasing the risk of a crash.
- Correction:
- Dealers will replace the hoses and bleed the brake system. owner notification began on october 9, 2003. owners should contact ic at 1-800-843-5615.
- Notes:
- Ic recall no. 03304.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V354000 on 01/14/2004
- Component:
- Structure:body
- Manufactured:
- 05/24/2001 - 05/30/2002
- Affected:
- 66,749
- Defect:
- Ce model school buses which fail to comply to federal motor vehicle safety standard no. 221, school bus body joint strength. the roof top sheet may be improperly located, reducing the material edge distance at the rivet line.
- Consequence:
- In the event of a vehicle crash, the joint strenght could fail possibily resulting in injuries to the vehicle occupants.
- Correction:
- Ic will notify its customers and will provide inspection and repair instruction. the recall began on january 25, 2005. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic customer service at (we do not yet have a telephone number for this campaign.)
- Notes:
- Ic recall no. 03305.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04E058000 on 08/12/2004
- Component:
- Equipment adaptive
- Manufactured:
- 06/03/2001 - 05/23/2002
- Affected:
- 300,000
- Defect:
- Certain sure-lok wheelchair tie-down securement assemblies p/n 8625-13 for use on certain school and transit buses. the sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
- Consequence:
- In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries to the seat occupant and/or other passengers.
- Correction:
- Sure-lok will notify its customers and replace the defective part free of charge. the recall began august 16, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact sure-lok customer service at 866-787-3565.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V469000 on 09/23/2004
- Component:
- Equipment adaptive
- Affected:
- 1,220
- Defect:
- Certain my 2001-2005 amtran/ic corporation ce, fe, and re school buses equipped with sure-lok wheelchair tie-down securement assemblies p/n 8625-13. the sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
- Consequence:
- In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
- Correction:
- Sure-lok will notify ic's customers and repair the buses on ic's behalf at no cost to the customer. the recall began august 16, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact sure-lok at 1-908-231-1804.
- Campaign:
- 04V498000 on 10/14/2004
- Component:
- Seats
- Manufactured:
- 06/28/2001 - 05/24/2002
- Affected:
- 154
- Defect:
- Certain 1998, 2000-2005 my ce, fe, and re school buses built with one or more ce white 30-inch child restraint seats and manufactured between march 25, 1998 and august 24, 2004. the seat cushion retention may not retain the seat in all circumstances.
- Consequence:
- In the event of a sudden stop, the seat cushion may tip forward and may become unattached causing the passenger to slide off the seat and/or be trapped by the seat cushion. this action could possibly result in personal injury or death.
- Correction:
- Ic corp will notify its customers and will repair the cushion by adding a clip to the cushion tying it to the seat frame. the recall began on october 5, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic compliance department at 1-800-843-5615.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Home | Privacy