2001 SATURN LS Recalls (7)
- Campaign:
- 00V235000 on 08/24/2000
- Component:
- Air bags:side/window
- Manufactured:
- 06/30/2000 - 08/30/2000
- Affected:
- 168
- Defect:
- Vehicle description: passenger vehicles equipped with a side impact air bag system. the air bag system has a lower side impact safing sensor threshold than specified. because of this reduced threshold, there could be an inadvertent deployment of the side head curtain air bag with severe slamming of the door.
- Consequence:
- This could cause injury to an occupant.
- Correction:
- Dealers will replace the inflatable restraint sensing and diagnostic module assembly.
- Notes:
- No vehicles have been sold to customers.
- Campaign:
- 00V344000 on 10/29/2000
- Component:
- Power train:automatic transmission:gear position indication (prndl)
- Manufactured:
- 10/01/2000 - 10/08/2000
- Affected:
- 1,637
- Defect:
- Vehicle description: passenger vehicles equipped with automatic transaxles. some of these vehicles were assembled with the transaxle shift cable clip missing or improperly seated. without the clip, the cable can slip out of its bracket and the transaxle lever would not move along with the shift lever. the driver may put the shift lever in park, but the transaxle may be in reverse or neutral.
- Consequence:
- Unexpected movement of the vehicle could cause a crash without prior warning.
- Correction:
- Dealers will inspect the transaxle shift cable retainer clip to verify proper installation and, if necessary, replace the clip and adjust the cable to specifications.
- Notes:
- Owner notification began october 27, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saturn at 1-800-553-6000, prompt #5. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V026000 on 02/06/2001
- Component:
- Air bags:frontal
- Manufactured:
- 12/31/1999 - 02/27/2000
- Affected:
- 38
- Defect:
- Vehicle description: passenger, sport utility vehicles and minivans. the passenger air bag inflator modules were built without the correct amount of generant, which produces the gas that fills the air bag. some were built with a double load of generant and some were built without generant.
- Consequence:
- In the event of a crash that would trigger a passenger air bag deployment, a double load of generant can cause the inflator module to explode. if the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupant. a module with no generant would not inflate the air bag, and the occupants could receive more severe injuries.
- Correction:
- Dealers will replace the passenger air bag module. telephone calls were made to owners on january 29, 2001. follow up owner mailing began on april 17, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or saturn at 1-800-553-6000.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V329000 on 12/18/2002
- Component:
- Air bags:frontal
- Manufactured:
- 09/02/2001 - 09/27/2001
- Affected:
- 272
- Defect:
- On certain passenger, sport utility vehicles and mini vans, some of these vehicles have a passenger air bag that was manufactured without a check valve pin. an air bag without the check valve pin could produce increased pressure at the onset of the air bag deployment and reduced pressure afterward.
- Consequence:
- This could increase the severity of injury to a person who was not properly restrained and who was close to the passenger air bag at the time of deployment. it could also reduce the ab8ility of the air bag to protect a restrained front seat passenger.
- Correction:
- Dealers will inspect and, if necessary, replace the passenger air bag. owner notification began december 16, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, oldsmobile at 1-800-442-6537, or saturn at 1-800-553-6000, prompt #3.
- Notes:
- Gm recall no. 02061. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V231000 on 06/22/2003
- Component:
- Electrical system:ignition:module
- Manufactured:
- 06/17/2001 - 07/16/2002
- Affected:
- 239,993
- Defect:
- On certain passenger vehicles equipped with 2.2l l4 (l61) engines, a failure of the ignition control module may cause deterioration in idle quality, reduction in overall engine power, and the vehicle may be hard to start. continued operation of the vehicle after such an ignition module failure will result in the "service engine soon" light flashing, and may lead to secondary failures of the catalytic converter, oxygen sensor, and exhaust resonator.
- Consequence:
- Failure of the resonator will cause increased exhaust noise. prolonged operation of the vehicle following a resonator failure may lead to a fire.
- Correction:
- Dealers will (1) replace the ignition control module, (2) replace the ignition control module and spark plugs, or (3) replace the ignition control module, spark plugs, and update the powertrain control module calibration. owner notification began on august 4, 2003. owners should contact saturn at 1-800-553-6000, prompt 3.
- Notes:
- Gm recall no. 03033/saturn recall no. 03-c-06.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V245000 on 06/01/2005
- Component:
- Exterior lighting:brake lights
- Manufactured:
- 05/31/2000 - 06/29/2001
- Affected:
- 291,652
- Defect:
- On certain sedans and wagons, the plastic housing in the rear tail lamp assembly can become distorted if the brake lamps remain on for an extended time.
- Consequence:
- This can cause (1) an intermittently inoperative brake/tail lamp bulb or (2) a short circuit that opens a fuse causing inoperative brake lamps (including the center high-mounted stop lamp) or tail lamps. a following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning.
- Correction:
- Dealers will install two new tail lamp reinforcing socket adapters and sockets free of charge. the recall began on october 17, 2005. owners may contact saturn at 1-800-972-8876.
- Notes:
- Gm recall no. 05052.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07V519000 on 11/06/2007
- Component:
- Engine and engine cooling
- Manufactured:
- 10/31/2000 - 02/27/2001
- Affected:
- 20,514
- Defect:
- On certain passenger vehicles equipped with a 2.2l 4-cylinder engine, links in the engine's timing chain can separate.
- Consequence:
- If a timing chain link separates while the engine is running, the engine will stall and will not restart increasing the risk of a crash.
- Correction:
- Dealers will replace the timing chain free of charge. the recall began on january 15, 2008. owners may contact saturn at 1-800-972-8876.
- Notes:
- Gm recall no. 06074.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2001 SATURN LS TSBs (155)
- Bulletin:
- 00T17A
- Component:
- 162000 structure:body
- Summary:
- Some customers may comment about the headliner sagging or hanging too low at the rear of the sunroof opening. *tt
- Bulletin:
- 00T63
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- On some vehicles, the engine will start and then stalls, engine cranks but will not start, or engine hesitates under heavy acceleration. *tt
- Bulletin:
- 00T70
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Customers may comment the service engine soon lamp is illuminated and / or the transaxle shifts are harsh or erratic. *tt
- Bulletin:
- 01T01
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Some ls 300 and lw 300 model vehibles may exhibit a vibration or boom noise inside the vehicle while at idle and the a/c is on. the vibration or boom may also be more noticeable while vehicle is in gear. *tt
- Bulletin:
- 01T02
- Component:
- 980000 unknown or other
- Summary:
- Some customers may comment that the malfunction indicator lamp (mil) service engine soon is illuminated and diagnostic trouble code (dtc) p0440 or dtc p0455 has been stored. *tt
- Bulletin:
- 99T69A
- Component:
- 162000 structure:body
- Summary:
- Experiencing rattle noises heard from the area of dome lamp, sunroof, or headliner during normal operating conditions. *tt
- Bulletin:
- 01T05
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Some vehicles built before and including vin 1y530200 may exhibit windshield wipers that chatter or hop across the windshield during wiper operation. *tt
- Bulletin:
- 99T52A
- Component:
- 350000 equipment
- Summary:
- The purpose of this bulletin is to inform saturn retailer personnel of the system function and procedure used to install the trap-resistant trunk kit. *tt
- Bulletin:
- 99T55A
- Component:
- 020000 suspension
- Summary:
- Some customers may comment regarding a steering wheel shake or vibration felt when driving vehicle at highway speeds. *tt
- Bulletin:
- 01T13
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment about the engine cranks but will not start and / or the engine starts and then stalls. *tt
- Bulletin:
- 01T14
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment about the engine running rough at idle after a cold engine start in ambient temperatures between 10 degrees - 30 degrees celsius (50 degrees - 85 degrees fahrenheit. *tt
- Bulletin:
- 01T23
- Component:
- 116000 electrical system:ignition
- Summary:
- Some customers may comment tht the ignition key will not turn out of the lock position. *tt
- Bulletin:
- 01T25
- Component:
- 110000 electrical system
- Summary:
- This purpose of this bulletin is to update engine cooling fan schematics. *tt
- Bulletin:
- 01T32
- Component:
- 980000 unknown or other
- Summary:
- Some customers may comment of poor remote keyless entry (rke) range while trying to lock or unlock vehicle(s) up to and including vin 1y570729. *tt
- Bulletin:
- 01T34
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Information on front brake rotor minimum thickness after refinish and discard thickness specifications. *tt
- Bulletin:
- 01T32
- Component:
- 980000 unknown or other
- Summary:
- Vehicles equipped with remote keyless entry up to and including vin 1y570729 may experience poor remote keyless entry (rke) transmitter range. *tt
- Bulletin:
- 01T33
- Component:
- 162300 structure:body:door
- Summary:
- The purpose of this bulletin is to provide an updated programming procedure for the customer programmable automatic door lock and unlock feature for vehicles built after and including vin 1y585334. *tt
- Bulletin:
- 00T41A
- Component:
- 162000 structure:body
- Summary:
- Some customers may comment about water leaking into the passenger compartment and / or rear compartment / rear cargo area. *tt
- Bulletin:
- 01T06A
- Component:
- 162000 structure:body
- Summary:
- Concerns that the rear fascia to quarter panel is not correctly aligned. *tt
- Bulletin:
- 00T17B
- Component:
- 980000 unknown or other
- Summary:
- Some customers may comment about the headliner sagging orh anging too low at the rear of the sunroof opening. *tt
- Bulletin:
- 99T36A
- Component:
- 162000 structure:body
- Summary:
- Customers may comment about a rattle type noise that seems to be coming from rear of vehicle when traveling over rough road surfaces. *tt
- Bulletin:
- 99Y69N
- Component:
- 162000 structure:body
- Summary:
- Experiencing rattle noises heard in area of dome lamp, sunroof, orheadliner duringnormal operating conditions. *tt
- Bulletin:
- 01T16
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment about intermittent click / tick noise coming from engine compartment. *tt
- Bulletin:
- 01T39
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service information regarding redesigned oil filter element and oil filter cap. *tt
- Bulletin:
- 01T39
- Component:
- 162000 structure:body
- Summary:
- Service manual update for 2000 and 2001 l-series body electrical volume i and volume ii service manuals regarding inner door pullhandle removal. *tt
- Bulletin:
- 01T33
- Component:
- 980000 unknown or other
- Summary:
- Information regarding an updated programming procedure for the customer programmable automatic door lock and unlock feature. *slc
- Bulletin:
- 00T17B
- Component:
- 162000 structure:body
- Summary:
- Customers may complain of headliner sagging or hanging too low at the rear of the sunroof opening. *slc
- Bulletin:
- 00T41A
- Component:
- 162000 structure:body
- Summary:
- Customers may complain of water leaking into the passenger compartment and/or rear compartment cargo area. *slc
- Bulletin:
- 01T06A
- Component:
- 162200 structure:body:bumpers
- Summary:
- Customers may complain that the rear fascia to quarter panel is not correctly aligned. *slc
- Bulletin:
- 99T36A
- Component:
- 022000 suspension:rear
- Summary:
- Customers may complain of a rattle type noise that seems to be coming from rear of vehicle when traveling over rough road surfaces. *slc
- Bulletin:
- 99T69B
- Component:
- 980000 unknown or other
- Summary:
- Some customers may complain of rattle noises heard in area of dome lamp, sunroof, or headliner during normal operating conditions. *slc
- Bulletin:
- 01T39
- Component:
- 980000 unknown or other
- Summary:
- Service manual revision on body electrical volume i and volume ii. *slc
- Bulletin:
- 01T40
- Component:
- 980000 unknown or other
- Summary:
- Information regarding 1st and 2nd design oil filter elements and oil filter caps available for the 4 cylinder engine and how to determine which oil filter and cap combination should be used. *slc
- Bulletin:
- 01T34
- Component:
- 980000 unknown or other
- Summary:
- Information regarding front brake rotor minimum thickness after refinish and discard thickness specificatons. *slc
- Bulletin:
- 01T45
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding front and rear suspension torque specifications. *jg
- Bulletin:
- 00T30A
- Component:
- 221600 seats:front assembly:power adjust
- Summary:
- The driver's side 6-way power seat functions are inoperative. *jg
- Bulletin:
- 01T46
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- The engine cranks but will not start and/or decklid release is inoperative. *jg
- Bulletin:
- 01T58
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service manual regarding solenoid circuit schematic, input speed sensor performance, and input speed sensor circuit low voltage schematics. *jg
- Bulletin:
- 01T55
- Component:
- 980000 unknown or other
- Summary:
- Service manual update for engine service manuals regarding cruise control diagnostics. *jg
- Bulletin:
- 00T44A
- Component:
- 980000 unknown or other
- Summary:
- Information on malfunction indicator lamp service engine soon telltale coming on.*jb
- Bulletin:
- 00T66A
- Component:
- 060000 engine and engine cooling
- Summary:
- Information regarding engine oil leaks and/or engine coolant leaks, on v-6 engines.*jb
- Bulletin:
- 00T66A
- Component:
- 060000 engine and engine cooling
- Summary:
- Information regarding engine oil leaks and or engine coolant leaks. *yh
- Bulletin:
- 00T17C
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Some customers may comment about the headliner sagging or hanging too low at the rear of the sunroof opening. *jg
- Bulletin:
- 01T01A
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Some customers may complain about a vibration or boom noise inside the vehicle while at idle and the air conditioner is on. (also vehicle ls300 2002 and lw300 2002) *jg
- Bulletin:
- 00T44A
- Component:
- 980000 unknown or other
- Summary:
- Some customers may complain about the service engine soon telltale and/or the reduced power telltale coming on. *jg
- Bulletin:
- 01T01A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some customers may comment about a vibration or boom noise inside the vehicle while at idle and the air conditioner is on. *jg
- Bulletin:
- 00T17C
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding headliner sags or hangs too low at rear of sunroof opening. *yd
- Bulletin:
- 02T17
- Component:
- 980000 unknown or other
- Summary:
- Information on service engine soon lamp illuminated.*jb
- Bulletin:
- 99T55B
- Component:
- 010000 steering
- Summary:
- Some vehicles may experience steering wheel shake or vibration at highway speeds.*jb
- Bulletin:
- 02C07
- Component:
- 100000 power train
- Summary:
- Subject regarding inaccurate odometer reading after loss of battery power.*jb
- Bulletin:
- 02T22
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information regarding whistle noise under certain engine operating conditions.*jb
- Bulletin:
- 02T27
- Component:
- 131000 visibility:windshield
- Summary:
- Customers may complain of rear door glass being inoperative or operates erractically.*jb
- Bulletin:
- 02T05
- Component:
- 220000 seats
- Summary:
- Service manual update regarding front seat cushion cover/pad removal and installation. *slc
- Bulletin:
- 02T06
- Component:
- 021000 suspension:front
- Summary:
- Service manual update for chassis service manuals regarding front strut assembly procedure. *slc
- Bulletin:
- 02T04
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding service manual and quick reference specifications guide update regarding incorrect cylinder head bolt torque specifications. *slc
- Bulletin:
- 02T06
- Component:
- 021000 suspension:front
- Summary:
- Subject regarding service manual update for chassis service manuals regarding front strut assembly procedure. *slc
- Bulletin:
- 02T16
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Service information regarding design change to thermostat housing, thermostat housing bolts, and thermostat housing o-ring seal. *tt
- Bulletin:
- 02T26
- Component:
- 111100 electrical system:battery:cables
- Summary:
- The purpose of this bulletin is to provide new positive and negative battery cable replacement procedures. *tt
- Bulletin:
- 02C07
- Component:
- 110000 electrical system
- Summary:
- Subject regarding inaccurate odometer reading after loss of battery power. *jg
- Bulletin:
- 02T22
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding whistle noise under certain engine operating consitions. *jg
- Bulletin:
- 02T43
- Component:
- 106000 power train:axle assembly
- Summary:
- Subject regarding service manual update for transaxle service manuals regarding new differential ring gear replacement procedure. *jg
- Bulletin:
- 02T26
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding service manual update for engine service manuals regarding new positive and negative battery cable replacement procedures. *jg
- Bulletin:
- 02T27
- Component:
- 162300 structure:body:door
- Summary:
- Some consumers may complain that the rear door glass is inoperative or displays erratic operation. *jg
- Bulletin:
- 02T35
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding service manual update for engine service manuals regarding balance shaft timing procedure. *jg
- Bulletin:
- 02T37
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Subject regarding service information on new oil cooler cover sealant. *jg
- Bulletin:
- 02T39
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding installation procedures for standard hvac controller with 3rd mounting boss. *jg
- Bulletin:
- 02T40
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding service manual update for engine service manuals regarding evaporative emission (evap) system flowchart. *jg
- Bulletin:
- 02T44
- Component:
- 106000 power train:axle assembly
- Summary:
- Subject regarding service information regarding new design line pressure control solenoids. *jg
- Bulletin:
- 02T48
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Subject regarding mass air flow sensor failure due to oil contamination of sensor membrane (install new mass air flow (maf) sensor and update electronic control module calibration) *jg
- Bulletin:
- 02T46
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Service information regarding power steering system noise and/or leak diagnosis. *jg
- Bulletin:
- 02T62
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Service information regarding redesigned wiper linkage and new service procedures. *jg
- Bulletin:
- 02T42
- Component:
- 162000 structure:body
- Summary:
- Subject regarding squeak, rattle and poor fit from defroster grille (install redesigned defroster grille) *jg
- Bulletin:
- 02T49
- Component:
- 355100 equipment:other:labels
- Summary:
- Subject regarding service engine soon (ses) lamp illuminated with diagnostic trouble code (dtc) p1441 set in pcm history (install new pcm calibration) *jg
- Bulletin:
- 02T50
- Component:
- 110000 electrical system
- Summary:
- Subject regarding service manual update for body /electrical volume ii service manuals regarding liftgate release-wagon circuit description and operation. *jg
- Bulletin:
- 99T55C
- Component:
- 020000 suspension
- Summary:
- Some consumers may complain about a steering wheel shake or vibration felt when driving vehicle at highway speeds. this condition is most noticeable on smooth road surfaces at vehicle speeds above 65mph (105 km/h) *jg
- Bulletin:
- 00T72A
- Component:
- 022000 suspension:rear
- Summary:
- Subject regarding service manual update for chassis service manualss regarding alignment specifications and service procedure for installation of spacers between rear suspension support and vehicle body when performing wheel alignment. *jg
- Bulletin:
- 02T86
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Service information regarding elimination of auxiliary water pump and instructions to install 2nd design heater inlet hose and heater inlet elbow in place of the 1st design water pump and heat inlet hose. *tt
- Bulletin:
- 02T77
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Whistle noise from power steering while turning left. *tt
- Bulletin:
- 02T86
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service information regarding elimination of auxiliary water pump and instruments to install 2nd design heater inlet hose and heater inlet elbow in place of the 1st design water pump and heater inlet hose. *tt
- Bulletin:
- 03T03
- Component:
- 220000 seats
- Summary:
- Loose or torn seat covers. *tt
- Bulletin:
- 030853001
- Component:
- 162000 structure:body
- Summary:
- Defroster grille popping noise encountered during cold temperatures. *tt
- Bulletin:
- 030844007
- Component:
- 353000 equipment:electrical
- Summary:
- Information for concerns on noise heard through the audio system when another electrical component is activated or used. *tt
- Bulletin:
- 030604016
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service information regarding the engine control module (ecm) connector and terminal locations on saturn v6 engines. *tt
- Bulletin:
- 030601014
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service manual update regarding the use of saturn special tool j-42065 crank hub holding tool. *tt
- Bulletin:
- 030601015
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service manual update for removal of the sealer used on oil pump gasket during oil pump installation. *tt
- Bulletin:
- 030731004
- Component:
- 100000 power train
- Summary:
- Bleeding procedure for hydraulic clutch release system including clutch actuator cylinder. *tt
- Bulletin:
- 030601017
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Timing chain design change and revised service procedures. *tt
- Bulletin:
- 030601019
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service manual update - revised engine torque specification table. *tt
- Bulletin:
- 990091002D
- Component:
- 020000 suspension
- Summary:
- Steering wheel shake or vibration at highway speeds. *tt update. *tt
- Bulletin:
- 030139012
- Component:
- 353600 equipment:air conditioner
- Summary:
- Odor from air conditioning at vehicle start-up. *tt
- Bulletin:
- 030844017
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Changes to the am/fm stereo and audio disc player radio on-board diagnostic modes and cd load operation. *tt
- Bulletin:
- 030604043
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Malfunction indicator lamp (mil) service engine soon telltale lamp on, reduced power lamp may illuminate with diagnostic trouble codes p0121, p0221, and/or p2135. *tt
- Bulletin:
- 030856002
- Component:
- 110000 electrical system
- Summary:
- Intermittent security telltale illumination and/or diagnostic trouble code b2960. *tt
- Bulletin:
- 030843005
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Little or no windshield solvent coming from washer nozzles. *tt
- Bulletin:
- 030089033A
- Component:
- 980000 unknown or other
- Summary:
- Trailer, recreational and disabled vehicle towing information. *tt *sc
- Bulletin:
- 030089032
- Component:
- 980000 unknown or other
- Summary:
- Recreational and disabled vehicle towing information. *tt
- Bulletin:
- 030232045
- Component:
- 010000 steering
- Summary:
- Moan or groan noise when turning steering wheel at low speeds. *tt
- Bulletin:
- 030090003
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil filter cap assembly and oil filter element design change. *tt
- Bulletin:
- 030089025
- Component:
- 980000 unknown or other
- Summary:
- Clarification of labor codes used for reprogramming vehicle controllers. various models including the 2004 l-series. *tt
- Bulletin:
- 030524001
- Component:
- 034410 service brakes, hydraulic:foundation components:drum:wheel cylinders
- Summary:
- Service information regarding saturn rear drum wheel cylinder inspections. *tt update. *tt
- Bulletin:
- 030849022A
- Component:
- 090000 fuel system, other
- Summary:
- Fuel gauge displays an erratic or false reading or no start condition after vehicle is shut off with low fuel level. *tt this bulletin replaces previous dated 12/01/03. *tt this bulletin replaces previous dated 08/01/04. *tt
- Bulletin:
- 030844016A
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Compact discs (cds) skip in single cd player. *tt
- Bulletin:
- 040842001
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Information on intermittent dimming (flickering) of headlamps and/or instrument panel lighting-normal characteristic. this may occur because of transient current loads on the electrical system during normal vehicle operation. *mn
- Bulletin:
- 040601004
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service information regarding engine support during removal of right front engine mount assembly. *tt
- Bulletin:
- 040604008
- Component:
- 060000 engine and engine cooling
- Summary:
- Service engine soon (ses) lamp illuminated with dtc p0135 ho2s heater circuit performance bank 1 sensor 1 and/or dtc p0155 ho2s heater performance bank 2 sensor 1. *mr this bulletin replaces previous 04-06-04-008. *eh
- Bulletin:
- 040089012
- Component:
- 980000 unknown or other
- Summary:
- Saturn field product reminder- vehicle fix it right the first time issues, parts restriction information and technical bulletins released in january, february, and march 2004. *mr
- Bulletin:
- 040730020
- Component:
- 100000 power train
- Summary:
- Service vehicle soon lamp illuminated with diagnostic trouble code (dtc) p1811 maximum adapt and long shifts. *tt
- Bulletin:
- 040601009
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil leak from front cover seal during extremely cold weather. *tt
- Bulletin:
- 040601010
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Blue smoke at engine start-up. *tt
- Bulletin:
- 040601011
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service manual update for engine block clearance, cylinder head clearance and fastener torque specifications. *tt
- Bulletin:
- 040235008
- Component:
- 010000 steering
- Summary:
- Clunk noise from front of vehicle during turning maneuver/steering wheel rotation. *tt
- Bulletin:
- 040137005
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information regarding air conditioning (a/c) compressor noise at engine start (a/c or defrost mode selected) or at a/c or defrost activation (after engine start). *tt
- Bulletin:
- 040844015
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Return form for compact discs (cds) or digital versatile discs (dvds) that are stuck in cd player when returned as a core return. *tt
- Bulletin:
- 3036
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Dark rectangles or circles in the center of the roof. *tt
- Bulletin:
- 3037
- Component:
- 190000 tires
- Summary:
- Thump noise/vibration/flat spotted tires on vehicle. *tt
- Bulletin:
- 3120
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Aux coolant pump will not connect to replacement radiator. *sc
- Bulletin:
- 3116
- Component:
- 060000 engine and engine cooling
- Summary:
- Ses illuminated engine miss/misfire feel or rough idle. *sc
- Bulletin:
- 3119
- Component:
- 980000 unknown or other
- Summary:
- No selection fir saturn when programming a saturn vehilcle. *sc
- Bulletin:
- 3135
- Component:
- 060000 engine and engine cooling
- Summary:
- Pop noise from engine area during heavy throttle input. *tc
- Bulletin:
- 3099
- Component:
- 015200 steering:hydraulic power assist:hose, piping, and connections
- Summary:
- Routing the longer tuned power steering hose per tsb 03-02-32-045. *sc
- Bulletin:
- 010604016
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon (ses) telltale illuminated with diagnostic trouble codes (dtcs) p0171, p0172, p0174 and/or p0175. *tt
- Bulletin:
- 040604085
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service engine soon (ses) and/or reduced power lamp illuminating following cold engine start up in subfreezing temperatures, diagnostic trouble codes (dtc) p0638, p1510 and/or p1516 stored in engine control module (ecm). *tt
- Bulletin:
- 3295
- Component:
- 106000 power train:axle assembly
- Summary:
- Service wrench and ses telltale may be illuminated and transaxle may shift harshly. *eh
- Bulletin:
- 3419
- Component:
- 116000 electrical system:ignition
- Summary:
- Ignition key will not rotate back to off position or shift lever will not move out of park. *tt
- Bulletin:
- 3668
- Component:
- 060000 engine and engine cooling
- Summary:
- Tick noise from engine. *tt
- Bulletin:
- 020232009
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Power steering system noise and/or leak diagnosis. *tt
- Bulletin:
- 3648
- Component:
- 114100 electrical system:wiring:front underhood
- Summary:
- Hesitation on acceleration after internal engine repairs - check injector harness orientation. *tt
- Bulletin:
- 3933
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Timing belt replacement. *kb
- Bulletin:
- 3859
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07. *nj
- Bulletin:
- 4014
- Component:
- 980000 unknown or other
- Summary:
- Parts update - timing chain tensioner design change. *kb
- Bulletin:
- 03-00-89-033
- Component:
- 980000 unknown or other
- Summary:
- Trailer, recreational and disabled vehicle towing information. *kb updated 08-15-07. *kb updated 10/09/07. *nj updated 4/3/08. *nj
- Bulletin:
- 000310006
- Component:
- 020000 suspension
- Summary:
- Information on tire radial force variation (rfv). 2008 and prior gm passenger cars and light duty trucks including 2008 and prior hummer h2, h3 and 2005-08 saab 9-7x and 2000-05 saturn l series and 2003-07 saturn ion. *kb updated 4/1
- Bulletin:
- 070730025
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on 4t40-e (mn4) and 4t45-e (mn5) front wheel drive automatic transmission valve body reconditioning, dtc p0741, p0742, p0751, p0752, p0756, p0757, p1811, harsh shifts, slips, no drive, no reverse. *nj
- Bulletin:
- PIE-0012
- Component:
- 070000 fuel system, gasoline
- Summary:
- Saturn: e109213-fuel smell/odor or leak near fuel tank area *engineering information). customers complain about a fuel smell/odor while driving or after the vehicle is parked. some dampness may also be noticed on the ground near the fuel
- Bulletin:
- SB-00-03-10-006C
- Component:
- 190000 tires
- Summary:
- General motors: information on tire radial force variation. vehicle must be driven before measuring tires on equipment hunter gsp9700 toensure removal of any flatspotting. models include all gm passenger cars and light trucks, as well as
- Bulletin:
- 09-09-40-001A
- Component:
- 150000 seat belts
- Summary:
- Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
- Bulletin:
- PIP-4495C
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Gm: there may be noise coming from the cylinder head, because of low oil pressure which is caused by debris. *rm
- Bulletin:
- SB-10-08-50-003B
- Component:
- 221300 seats:front assembly:head restraint
- Summary:
- General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
- Bulletin:
- PIC-5050-A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIC-4935-E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- 16NA260
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
- Bulletin:
- 000601012F
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
- Bulletin:
- PI1394A
- Component:
- 060000 engine (pws)
- Summary:
- This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
- Bulletin:
- PIC4935E
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
- Bulletin:
- PIC5050A
- Component:
- 353000 equipment:electrical
- Summary:
- This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
- Bulletin:
- PIT5389A
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
- Bulletin:
- PIT5485B
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- PIT5485A
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
- Bulletin:
- PIP5226A
- Component:
- 350000 equipment
- Summary:
- This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
- Bulletin:
- PIC5491J
- Component:
- 110000 electrical system
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. technician should turn off the ignition and cancel retained accessory power. after the vehic
- Bulletin:
- 03-08-46-004R
- Component:
- 353000 equipment:electrical
- Summary:
- This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
- Bulletin:
- 02-08-42-001H
- Component:
- 356000 equipment adaptive
- Summary:
- This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
- Bulletin:
- PIT3099P
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
- Bulletin:
- PIC5588D
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
- Bulletin:
- PIP4495E
- Component:
- 162800 structure:body:hood
- Summary:
- This preliminary information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. technician will need to check the lower and oil pressure to t
Home | Privacy