2001 NEW FLYER D35LF Recalls (4)
- Campaign:
- 01V265000 on 09/03/2001
- Component:
- Steering:linkages:tie rod assembly
- Manufactured:
- 06/30/1998 - 07/30/2001
- Affected:
- 1,552
- Defect:
- Vehicle description: transit buses. the clamp nuts for the center link tie rods may have been inadequately tightened.
- Consequence:
- Inadequately tightened clamp nuts could lead to the tie rods separating from the center link possibly resulting in a vehicle crash.
- Correction:
- New flyer will will inspect the tie rod end clamp lock nuts to ensure that the nuts are properly tightened. any damaged tie rods will be replaced. owner notification began september 17, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-982-8181.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V004008 on 05/20/2002
- Component:
- Vehicle speed control
- Manufactured:
- 04/30/2001 - 10/30/2001
- Affected:
- 1,107
- Defect:
- On certain buses equipped with electronic throttle control/accelerator pedals supplied by williams controls industries, the weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate.
- Consequence:
- If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash.
- Correction:
- Williams controls is handling the replacement of this pedal. owners who do not receive the free remedy within a reasonable time should contact williams control at 1-503-684-8600 or new flyer at 204-982-8181.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V112000 on 05/21/2002
- Component:
- Steering:hydraulic power assist:hose, piping, and connections
- Affected:
- 480
- Defect:
- On certain low floor buses, the power steering hose was incorrectly installed.
- Consequence:
- The hose can leak, creating the risk of an engine fire.
- Correction:
- Dealers will replace the hose. owner notification began july 1, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-228-8984.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 07V068000 on 02/26/2007
- Component:
- Exterior lighting
- Manufactured:
- 12/31/1994 - 12/30/2002
- Affected:
- 1,707
- Defect:
- Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." the flashing deceleration lamps were an optional item for some of these buses.
- Consequence:
- The standard requires that the deceleration lamp is a solid light rather than a flashing light.
- Correction:
- Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. the recall began on march 5, 2007. owners may contact new flyer at 204-934-4874.
- Notes:
- Customers may contact the national highway traffic safety administration1s vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
2001 NEW FLYER D35LF TSBs (4)
- Bulletin:
- PMB049
- Component:
- 350000 equipment
- Summary:
- This parts manual bulletin provides new part number information for the moveable arm kit for the kongsberg brake and accelerator assembly on specifically equipped vehicles.
- Bulletin:
- SMB178
- Component:
- 350000 equipment
- Summary:
- This service manual bulletin provides new oem (kongsberg) pm inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- SMB180
- Component:
- 100000 power train
- Summary:
- This service manual bulletin provides updated preventive maintenace interval for the crankcase breather tube element on buses equipped with a cummins diesel isl 07 or isl 09 engine.
Home | Privacy