2001 ISUZU RODEO Recalls (4)

Campaign:
00V298000 on 10/18/2000
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:
07/31/2000 - 08/30/2000
Affected:
3,052
Defect:
Vehicle description: sport utility vehicles. during the manufacture of certain fuel return hoses, incorrect rubber material for the outer layer was used.
Consequence:
The fuel return hose does not meet ozone-resistant specifications, and could ultimately crack, causing fuel leakage. fuel leakage in the presence of an ignition source could result in a fire.
Correction:
Dealers will inspect the vehicle to determine if the vehicle was equipped with an incorrect hose. if it is incorrect, dealers will replace it.
Notes:
Owner notification began october 24, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu 1-800-643-4070, ext. 343.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V055000 on 02/27/2001
Component:
Air bags:frontal
Affected:
3
Defect:
Vehicle description: certain sport utility vehicles were built with the inflators in the passenger side air bag modules having the wrong amount of generant.
Consequence:
In the event of a crash that would trigger a passenger air bag deployment, too much generant can cause the inflator module to explode. if the air bag module explodes, metal and plastic debris could cause severe injury to vehicle occupants.
Correction:
Dealers will replace the passenger side air bag unit.
Notes:
All vehicles involved has been corrected.
Campaign:
02V213000 on 08/08/2002
Component:
Air bags:frontal
Manufactured:
10/31/2000 - 05/30/2001
Affected:
15
Defect:
On certain sport utility vehicles, the passenger-side air bag inflator modules were manufactured and shipped without a necessary component known as a check valve pin.
Consequence:
in the event of a crash, the air bag will not inflate properly or sufficiently resulting in an increased risk of injury to the seat occupant.
Correction:
Dealers will replace the passenger side air bag. owner notification is expected to begin during august or september 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
10V436000 on 09/22/2010
Component:
Suspension:rear
Affected:
149,992
Defect:
Isuzu is recalling certain model year 1998-2002 isuzu rodeo and model year 2002 isuzu axiom vehicles, and honda is recalling certain 1998-2002 honda passport vehicles, that were originally sold, or are currently registered, in the states of maine, new hampshire, vermont, massachusetts, rhode island, connecticut, new york, new jersey, pennsylvania, delaware, maryland, the district of columbia, west virginia, ohio, indiana, michigan, illinois, wisconsin, minnesota, iowa, missouri, and kentucky. vehicles that have experienced sustained exposure to highly corrosive materials used in some jurisdictions for road deicing purposes may experience excessive corrosion in the vicinity of the forward mounting point bracket for the left or right rear suspension lower link prior to the time that such corrosion would normally be expected.
Consequence:
Excessive corrosion may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash.
Correction:
Dealers will inspect the rear suspension lower link bracket area. for vehicles in which little or no corrosion is found, the area will be treated with an anti-corrosive compound. for vehicles in which corrosion has damaged the rear suspension lower link bracket and affected its connection to the vehicle frame, a reinforcement bracket will be installed. in the rare event the corrosion is so severe that the reinforcement bracket remedy would not be appropriate, a repurchase offer will be extended to the vehicle's owner. all inspections and remedies will be provided free of charge for vehicles that are 10 years old or less. for vehicles older than 10 years, isuzu will offer a free remedy, but only if the vehicle is presented to an isuzu service facility, or honda dealer (as applicable), dealer within 12 months of when owner notifications were issued. the safety recall began on december 10, 2010. isuzu owners may contact isuzu at 1-800-255-6727. honda owners may contact honda at 1-800-999-1009.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2001 ISUZU RODEO TSBs (56)

Bulletin:
IB0008S005
Component:
190000 tires
Summary:
This information bulletin is to inform you the vehicle tire pressure is increased for vehicle shipping. *tt
Bulletin:
IB0012S003
Component:
353600 equipment:air conditioner
Summary:
Information bulletin regarding rodeo and amigo / rodeo sport hvac operation update for vehicles with factory installed air conditioning only. *tt
Bulletin:
SB0004S004
Component:
110000 electrical system
Summary:
On some s models with manually operated windows, the interior mirror / map lights may stay on continually even with the dome light in the off position. over a prolonged period of time, this can cause the battery to lose power.
Bulletin:
IB0108S001
Component:
980000 unknown or other
Summary:
Information bulletin containing quick reference guide corrections for various 2001 model year vehicles including the 2002 model year axiom. *tt
Bulletin:
IB0104S001
Component:
110000 electrical system
Summary:
Service information regarding diagnostic trouble code p1340 ion sensing module cylinder id fault.
Bulletin:
SB0111S003
Component:
162300 structure:body:door
Summary:
Some owners may comment on loud door check arm popping sound when opening and closing the door. *tt
Bulletin:
SB0004S004A
Component:
110000 electrical system
Summary:
Campaign service bulletin to properly install map light resistor kit. *tt
Bulletin:
IB0104S002
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding p0337 crankshaft position sensor circuit low input correction. *tt
Bulletin:
IB0110S001
Component:
010000 steering
Summary:
Information regarding sector shaft alignment on the steering rack assembly. *tt
Bulletin:
SB0108S001
Component:
020000 suspension
Summary:
Some vehicles built prior to vin breakpoint 14330722 equipped with oem p215 / 235 15 inch and p225 / 245 16 inch tires may exhibit a steering wheel vibration / shimmy (nibble) or body vibration through the steering wheel or floorboard respe
Bulletin:
SB0111S006
Component:
200000 wheels
Summary:
Some vehicles built prior to vin breakpoint 14327313 may experience mud flap interference causing a rubbing sound when making a turn. *tt
Bulletin:
IB0101S001
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service information regarding diagnostic trouble code p1340 ion sensing module cylinder id fault. *tt
Bulletin:
IB0109S001
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Subject regarding drum brake adjustment procedure. *tt
Bulletin:
IB0113S002
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information concerning the nakamichi audio wiring harness adapter for certain anniversary edition models. *tt
Bulletin:
SB0104S001
Component:
180000 vehicle speed control
Summary:
Some engines may ocassionally experience idle fluctuation and / or the malfunction indicator lamp will illuminate because an accelerator position sensor (aps) diagnostic trouble code p1271, p1273, p1275, p1280, or p1285 is set.
Bulletin:
SB0103S001
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding carb obd ii evaporative leak diagnosis regulation emissions campaign o1e-001. *tt
Bulletin:
0211S001
Component:
162300 structure:body:door
Summary:
Door check arm popping sound. *jg
Bulletin:
0211S002
Component:
162000 structure:body
Summary:
Rear storage compartment lid lock knob broken. *jg
Bulletin:
0204S003
Component:
100000 power train
Summary:
Replacement odometer programing. *jg
Bulletin:
0202S001
Component:
070000 fuel system, gasoline
Summary:
Diagnostic trouble code p0440 evap system leak detection or p0442 evap system small leak detected is set. *jg
Bulletin:
0301S002
Component:
061000 engine and engine cooling:engine
Summary:
Throttle body mounting bolt torque specifications. *tt
Bulletin:
0211S004
Component:
350000 equipment
Summary:
Rear beverage holder swing arm loose. *tt
Bulletin:
0208S001
Component:
190000 tires
Summary:
Termination of tire replacement program. *tt
Bulletin:
0303S001
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Evaporative emission control system. *eh
Bulletin:
0505004
Component:
100000 power train
Summary:
Shift lock solenoid removal and replacement procedures. *tt 2002-2004 isuzu axiom (up), 198-2004 rodeo (ue) and 1998-2004 rodeo sport. update *sc
Bulletin:
0709002
Component:
045300 service brakes, air:disc:rotor
Summary:
Rear brake rotors. *kb
Bulletin:
PIC3278F
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIP5226A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIC5491J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. technician should turn off the ignition and cancel retained accessory power. after the vehic
Bulletin:
PIP5029G
Component:
060000 engine (pws)
Summary:
This preliminary information communication provides information to the technician about vehicles that have a malfunction indicator lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. technician will need
Bulletin:
PIC5953
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIP5163A
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIC4310J
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC5959B
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicle that has no xm audio on certain channels but xm channel info is displayed. technician will need to contact xm and deactivate and activate the mo
Bulletin:
PIT3099M
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIP5226
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIP5163
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIC4935D
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar
Bulletin:
PIP3720D
Component:
106000 power train:axle assembly
Summary:
This preliminary information communication provides information to the technician with the axel setup information from american axle manufacturing. technician should be advised that the maximum pinion shim to be used or stacked behind the p
Bulletin:
PIC4310H
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT3173C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. dealer should send the correc
Bulletin:
PIC3718E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles may have a no power or no connect concern. technician will find that the onstar led is red and diagnostic trouble code u1500 is set. technician
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC5953A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIT5399
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
Bulletin:
PIP5338
Component:
020000 suspension
Summary:
This preliminary information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. technician will need to use pico oscilloscope di
Bulletin:
PIP5232B
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIT3099P
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIC3100F
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicle&#39;s odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odomete
Bulletin:
PIC5588B
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
PIP5232
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
PIT5264A
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
PIT5399A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap

Home | Privacy