2001 HYUNDAI ELANTRA Recalls (6)

Campaign:
00V332000 on 10/26/2000
Component:
Air bags:side/window
Manufactured:
08/20/2000 - 09/17/2000
Affected:
972
Defect:
Vehicle description: passenger vehicles. the supplemental restraint system side air bag satellite sensors installed were improperly manufactured, causing the air bag warning light to illuminate and the side air bags to not deploy as intended in the event of a crash.
Consequence:
Non-deployment of the side air bags could increase the risk of injury during a crash where side air bag deployment is intended.
Correction:
Dealers will replace the two satellite sensors.
Notes:
Owner notificationbegan october 31, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact hyundai at 1-800-633-5151.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V257000 on 07/28/2003
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Manufactured:
06/29/2000 - 12/14/2002
Affected:
312,292
Defect:
On certain passenger vehicles, the rear brake tubes pass behind the front suspension crossmember. two steering gearbox mounting brackets are welded to the crossmember. on vehicles equipped with an antilock brake system (abs), the rear brake tubes could contact both steering gearbox mounting brackets. on vehicles that are not equipped with abs, the rear brake tubes may contact only the left mounting bracket. contact between the rear brake tubes and the steering brackets could cause wear and corrosion that could result in brake fluid leakage.
Consequence:
Fluid leakage could result in reduced braking capability increasing the risk of a crash.
Correction:
Dealers will reposition the rear brake tubes so they do not contact the mounting brackets, install brake tube clips to control the location of the rear brake tubes, and apply anti-corrosion material to the tubes in the areas where contact with the mounting brackets may have occurred. owner notification began on october 13, 2003. owners should contact hyundai at 1-800-633-5151.
Notes:
Hyundai recall no. 061.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V496000 on 12/02/2003
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Manufactured:
06/29/2000 - 12/14/2002
Affected:
1,993
Defect:
On certain passenger vehicles, the brake tubes for the rear brakes can contact the steering gearbox mounting brackets.
Consequence:
Contact between the rear brake tubes and the steering gearbox mounting brackets may result in rear brake tube wear and corrosion, increasing the risk of brake fluid leakage. brake fluid leakage could result in reduced braking capability, which could result in a crash.
Correction:
Dealers will reposition the rear brake tubes, install brake tube clips, and apply anti-corrosion material to the rear brake tubes. owner notification began january 22, 2004. owners should contact hyundai of puerto rico at 1-800-633-5151.
Notes:
Hyundai recall no. 061.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
08V533000 on 10/13/2008
Component:
Air bags:frontal:sensor/control module
Manufactured:
06/29/2000 - 12/17/2001
Affected:
150,541
Defect:
Hyundai is recalling certain my 2001-2002 elantra vehicles. movement of the side impact air bag wiring harness mounted under each front seat, possibly caused by contact from materials placed under the seat, may result in an electrical resistance that would cause supplemental restraint system (srs) warning light illumination.
Consequence:
This condition only relates to the driver and passenger seat mounted side impact air bags and may prevent seat mounted side impact air bag deployment during a crash where such deployment should occur. non-deployment of the srs air bags may increase the risk of injury to the driver and front passenger under certain crash conditions.
Correction:
Dealers will install new side impact air bag wiring harness connector clips and revised side impact air bag wiring harness attachments under the driver's and front passenger's seats. the recall is expected to begin during the fourth quarter of 2008, and will be sent out in six mailings. owners may contact hyundai at 1-800-633-5151.
Notes:
Hyundai recall no. 088.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V532000 on 10/13/2008
Component:
Air bags:frontal:sensor/control module
Manufactured:
06/29/2000 - 04/25/2001
Affected:
78,369
Defect:
Hyundai is recalling certain my 2001 elantra vehicles. if a liquid is spilled in the area of the cupholder on the center console, it may seep through the console opening for the parking brake lever and then drip onto the air bag control module electrical connector. the spilled liquid may contaminate the air bag control module and its electrical connector to the air bag wiring harness and cause the supplemental restraint system (srs) warning light to illuminate.
Consequence:
This condition may affect the driver and passenger frontal air bags and may prevent air bag deployment during a crash where such deployment should occur. non-deployment of the srs air bags may increase the risk of injury to the driver and front passenger under certain crash conditions.
Correction:
Dealers will install a protective cover over the vehicle's air bag control module connector. the recall owner notification began on november 30, 2008, and letters will be sent out in six mailings. owners may contact hyundai at 1-800-633-5151.
Notes:
Hyundai recall no. 088.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09V125000 on 04/15/2009
Component:
Suspension:front:control arm
Manufactured:
06/29/2000 - 01/12/2003
Affected:
160,904
Defect:
Hyundai is recalling 160,904 my 2001-2003 elantra and my 2003 tiburon vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. road salt used during the winter months in these jurisdictions may result in internal corrosion and thinning of the steel in the front lower control arms. the corrosion may progress to the point where the lower control arm's upper and lower panels become perforated. a perforated front lower control arm may fracture between its ball joint attachment and the forward and rearward pivot attachments to the chassis.
Consequence:
The fracturing of the control arm could an owner's control over their vehicle that may increase the risk of a crash.
Correction:
Dealers will inspect the front lower control arms for corrosion damage. if specified levels of internal corrosion damage are found, the front lower control arms will be replaced with new front lower control arms incorporating additional holes in the upper and lower panels. if the front lower control arms do not require replacement, the dealer will add drainage holes to the front lower control arms and will treat the front lower control arms with rust-proofing materials to arrest the internal corrosion process. these procedures will be performed free of charge. the recall began on august 17, 2009. owners may contact the hyundai customer assistance center at 1-800-633-5151.
Notes:
Hyundai recall no. 091.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2001 HYUNDAI ELANTRA TSBs (79)

Bulletin:
0040008
Component:
106000 power train:axle assembly
Summary:
Subject regarding the automatic transaxle tester i designed to troubleshoot the new generation transaxle for all 2000 models. *tt
Bulletin:
0036014
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding rear (downstream) oxygen sensor -- electrical troubleshooting manual schematic error. *tt
Bulletin:
0090006
Component:
110000 electrical system
Summary:
Subject regarding trunk room lamp connection (electrical troubleshooting manual correction). *tt
Bulletin:
151100
Component:
980000 unknown or other
Summary:
Subject regarding reprogramming keyless entry transmitters for the elantra security / keyless remote system. *tt
Bulletin:
1010
Component:
162000 structure:body
Summary:
Information on the redesigned all-new 2001 elantra. *tt
Bulletin:
0101002
Component:
980000 unknown or other
Summary:
Keyless entry programming service campaign 912. *sb
Bulletin:
260101
Component:
980000 unknown or other
Summary:
Subject regarding keyless remote transmitter. *tt
Bulletin:
190101
Component:
350000 equipment
Summary:
Information on the code saving tool kit used for programming new remotes for the security system. *tt
Bulletin:
250101
Component:
980000 unknown or other
Summary:
Hyundai motor america is conducting a customer notification campaign on specified model year vehicles originally sold with only one transmitter. *tt
Bulletin:
0040014
Component:
106000 power train:axle assembly
Summary:
Information on diagnosing transaxle diagnostic trouble codes. *tt
Bulletin:
041000
Component:
142000 air bags:side/window
Summary:
Hyundai has determined that it is necessary to replace the satelitte sensors that control the side airbags on certain models that were manufactured beginning august 21, 2000 through september 18, 2000. *tt
Bulletin:
111000
Component:
142000 air bags:side/window
Summary:
Hyundai motor america is conducting a voluntary dealership stock / customer notification safety recall on specified vehicles to replace the srs side airbag satellite sensors. *tt
Bulletin:
181000
Component:
222000 seats:mid/rear assembly
Summary:
Subject regarding orange buttons on rear seat back. these are indicators for the location of child seat anchors mounted behind the seat between the back and cushion. *tt
Bulletin:
0136018
Component:
110000 electrical system
Summary:
Subject regarding electrical troubleshooting manual (etm) corrections. *tt
Bulletin:
01600011
Component:
162000 structure:body
Summary:
This bulletin provides body dimensions to include the luggage compartment dimensions for the gt 5 door model. *tt
Bulletin:
0140014
Component:
103000 power train:automatic transmission
Summary:
Subject regarding automatic transaxle final drive gear whine noise. *et
Bulletin:
0190004
Component:
110000 electrical system
Summary:
Corrosion in the front door wiring connector. *yh
Bulletin:
0136012
Component:
185000 vehicle speed control:cruise control
Summary:
Information regarding shop manual correction for idle speed actuator resistance check. *yh
Bulletin:
061101
Component:
103000 power train:automatic transmission
Summary:
Subject regarding final drive gear whine noise. *yh
Bulletin:
14092001
Component:
980000 unknown or other
Summary:
Information regarding the shop manual correction for idle speed actuator resistance check.
Bulletin:
0140023
Component:
103000 power train:automatic transmission
Summary:
Subject regarding automatic transaxle oil drain plug. *yd
Bulletin:
0240001
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may experience a 2-3 shift flare condition (engine speed increases during shift). *tt
Bulletin:
0250002
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
Subject regarding front brake caliper rattle noise repair kit. *tt
Bulletin:
0150010
Component:
021000 suspension:front
Summary:
Experiencing a metallic grinding or groaning noise from the front suspension when driving over bumpy roads or while turning the vehicle. *tt
Bulletin:
0240008
Component:
103000 power train:automatic transmission
Summary:
Vehicles may experience a harsh or delayed park-reverse or park-drive engagement in vehicles equipped with automatic transmissions. *slc
Bulletin:
0240011
Component:
103000 power train:automatic transmission
Summary:
Information regarding automatic transaxle diagnostic trouble codes list. *yh
Bulletin:
0240012
Component:
103000 power train:automatic transmission
Summary:
Subject regarding automatic transaxle diagnostic trouble codes list. *yh
Bulletin:
122
Component:
103000 power train:automatic transmission
Summary:
Subject regarding automatic transaxle harsh or delayed park-reverse or park-drive engagement. *slc
Bulletin:
0220001
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding 2.0 l mechanical lash adjuster maintenance schedule and shop manual corrections. *slc
Bulletin:
0236022
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine rpm fluctuation - cruise control cable adjustment procedure. *jg
Bulletin:
0240019
Component:
106000 power train:axle assembly
Summary:
Subject regarding automatic transaxle harsh and/or delayed shifts. *jg
Bulletin:
0100004
Component:
354300 equipment:mechanical:carrier/rack
Summary:
Subject regarding sports rack lock key part number. *jg
Bulletin:
0150009
Component:
021000 suspension:front
Summary:
Subject regarding front suspension crossmember attaching bolt torque specification. *jg
Bulletin:
0180004
Component:
221200 seats:front assembly:recliner
Summary:
Subject regarding rear seat back latch release button replacement procedure. *jg
Bulletin:
0220006
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
This tsb provides shop manual corrections for camshaft timing chain timing procedures. *tt
Bulletin:
126
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on adjusting mechanical valves on vehicles equipped with the 2.0l 4-cylinder beta engine. *tt
Bulletin:
0240024
Component:
101000 power train:clutch assembly
Summary:
Improved clutch release shaft upper and lower bushing. *tt
Bulletin:
0220008
Component:
060000 engine and engine cooling
Summary:
Oil pan, suction tube, capacity and drain plug changes. *tt
Bulletin:
0220008
Component:
061000 engine and engine cooling:engine
Summary:
Oil pan, suction tube, capacity and drain plug changes. *tt
Bulletin:
02360221
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles may experience engine rpm fluctuation - cruise control cable adjustment procedure. *tt
Bulletin:
0240026
Component:
106000 power train:axle assembly
Summary:
Ata solenoid diagnostic trouble codes p0740, p0743, p0750, p0755, p0760, p0765, p0770. *tt
Bulletin:
0360002
Component:
162000 structure:body
Summary:
High pitched wind noise related to front door weatherstrip. *tt
Bulletin:
0390009
Component:
110000 electrical system
Summary:
Corrosion in the front door wiring connector. this bulletin supersedes 01-90-004. *tt
Bulletin:
0301005
Component:
355100 equipment:other:labels
Summary:
Emission control information label replacement - campaign 060. *tt
Bulletin:
060
Component:
355100 equipment:other:labels
Summary:
Campaign 060 - customer notification recall campaign - underhood emission label replacement. *tt
Bulletin:
060
Component:
355100 equipment:other:labels
Summary:
Detailed information to all hyundai service and parts managers regarding campaign 060 - incorrect emission labels. *tt
Bulletin:
0336002
Component:
112000 electrical system:alternator/generator/regulator
Summary:
Generator change for the 2.0l engine. *tt
Bulletin:
0360001
Component:
221200 seats:front assembly:recliner
Summary:
Procedure for replacement of the front seat track recliner cable. *tt
Bulletin:
0340006
Component:
100000 power train
Summary:
Ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0750, p0755, p0760, p0765, p0770. *tt
Bulletin:
0340014
Component:
103000 power train:automatic transmission
Summary:
Automatic transaxle diagnostic trouble code (dtc) p1723 accompanied with malfunction indicator lamp (mil) illuminated; transaxle held in 2rd gear fail-safe; harsh shifts into reverse or drive. *tt
Bulletin:
133
Component:
103000 power train:automatic transmission
Summary:
Third gear fail-safe information. *tt
Bulletin:
0380001
Component:
162300 structure:body:door
Summary:
Door frame black tape replacement procedure. *tt
Bulletin:
0380003
Component:
162300 structure:body:door
Summary:
Interior door trim panel fabric repair. *tt
Bulletin:
061
Component:
030000 service brakes, hydraulic
Summary:
Campaign 061 provides the procedures for repositioning the rear brake tubes to prevent contact with the front suspension crossmember's steering gear box mounting brackets. *tt
Bulletin:
033600201
Component:
112000 electrical system:alternator/generator/regulator
Summary:
Generator change for the 2.0l engine. *tt
Bulletin:
0336024
Component:
180000 vehicle speed control
Summary:
Resistance values for idle speed control actuator (isca). various models including the 2004 sonata. *tt
Bulletin:
0436004
Component:
061000 engine and engine cooling:engine
Summary:
Ecm (engine control module) reprogramming for warm ambient cold start stumble (wacss) and engine hesitation at approximately 3800 rpm. *tt
Bulletin:
0490010
Component:
133000 visibility:power window devices and controls
Summary:
Power window regulator motor.*mr
Bulletin:
0136025
Component:
061000 engine and engine cooling:engine
Summary:
Engine control module (ecm) reprogramming to reduce the delay in rpm drop between shifts with the air conditioner on. *tt
Bulletin:
0440009
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Automatic transaxle differential oil seal. *tt
Bulletin:
0340014
Component:
100000 power train
Summary:
Automatic transaxle diagnostic trouble code p0885 & p1723. *tt
Bulletin:
0497002
Component:
353600 equipment:air conditioner
Summary:
Fd46xg pag oil specifications for air conditioning component replacement. *tt
Bulletin:
0140010
Component:
103000 power train:automatic transmission
Summary:
Automatic transaxle diagnostic trouble code p0711, p0712 and p0713. *tt
Bulletin:
0501001
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust manifold assembly inspection and replacement campaign. *eh
Bulletin:
V04
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Exhaust noise coming from the engine compartment. voluntary service campaign v04 involves inspecting and, if necessary, replacing the exhaust manifold. *tt
Bulletin:
0804
Component:
353600 equipment:air conditioner
Summary:
Fd46xg poly alkylen glycol (pag) oil specifications for air conditioning component replacement. *nm
Bulletin:
0501001
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Exhaust manifold assembly inspection and replacement campaign - v04. *tt
Bulletin:
0540008
Component:
103000 power train:automatic transmission
Summary:
Automatic transaxle diagnostic trouble codes list. *sc
Bulletin:
05400061
Component:
061000 engine and engine cooling:engine
Summary:
Ata solenoid diagnostic codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. supersedes tsb# 0540006 to include dtc descriptions in september 10. *sc updated 3/5/10. *pe
Bulletin:
0140005
Component:
061000 engine and engine cooling:engine
Summary:
Automatic transaxle diagnostic trouble codes p0715, p0717, p0720, p0721, p0722. *sc
Bulletin:
034006
Component:
103000 power train:automatic transmission
Summary:
Ata solenoid diagnostic codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0756, p0770. *tt
Bulletin:
01011901
Component:
110000 electrical system
Summary:
Automatic transaxle diagnostic trouble codes list. *nm
Bulletin:
0640018
Component:
106000 power train:axle assembly
Summary:
Automatic transaxle diagnostic trouble codes (dtc) list. *kb
Bulletin:
0740009
Component:
103000 power train:automatic transmission
Summary:
Automatic transaxle harsh and/or delayed engagement into drive or reverse. *kb
Bulletin:
0740016
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Automatic transaxle diagnostic trouble codes p0715, p0716, p0717, p07120, p0721 and p0722. *nj
Bulletin:
TSB0740010
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Automatic transaxle harsh and/or delayed upshift or downshift - gds analysis. *pe
Bulletin:
TSB-09-AT-013
Component:
061000 engine and engine cooling:engine
Summary:
Hyundai: automatic transaxle range switch diagnostic trouble codes p0705 (range switch signal problems), p0707 (range switch open circuit), and p0708 (range switch short circuit or multiple inputs). an improperly adjusted or improperly op
Bulletin:
TSB-09-AT-018
Component:
061000 engine and engine cooling:engine
Summary:
Hyundai: ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. incorrect operation of the transaxle solenoids may result in the following symptoms-check engine light illuminated
Bulletin:
5NP-S9D9P-10
Component:
103000 power train:automatic transmission
Summary:
This bulletin provides information on components, attributes, and precautions of the 7-speed dry-type dual clutch transmission (dct).

Home | Privacy