2001 FORD EXPLORER SPORT Recalls (7)

Campaign:
00V394000 on 11/28/2000
Component:
Structure:body:hood:hinge and attachments
Manufactured:
09/23/1999 - 10/16/2000
Affected:
137,700
Defect:
Vehicle description: sport utility vehicles with steel hoods and certain pickup trucks equipped with sheet molding compound hoods. a wire formed hood striker could be susceptible to fatigue fractures. if the hood striker fractures, the hood could fly open while the vehicle is being driven.
Consequence:
A hood fly-up while the vehicle is being operated could result in reduced driver visibility.
Correction:
dealers will replace the hood striker.
Notes:
Owner notification began january 23, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01X001000 on 05/21/2001
Component:
Tires:tread/belt
Affected:
13,000,000
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. ford is replacing these tires to prevent possible premature tire failure. vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
Consequence:
Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
Correction:
The replacement/reimbursement program for this campaign expired on march 31, 2002. however, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
Campaign:
03V280000 on 08/06/2003
Component:
Vehicle speed control:cables
Manufactured:
09/23/1999 - 07/30/2000
Affected:
448,005
Defect:
On certain sport utility vehicles equipped with speed control and 4.0l sohc engines, if the strand cover on the speed control cable becomes flared at the end, the speed control cable may bind when the speed control is activated.
Consequence:
The throttle return spring force may not be sufficient to overcome the binding condition when the speed control is disengaged. braking function would be maintained though stopping distances may be increased.
Correction:
Dealers will inspect the speed control cable and, if necessary, replace it. owner notification began august 29, 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s03.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V281000 on 08/06/2003
Component:
Seats:front assembly:recliner
Manufactured:
09/23/1999 - 08/15/2002
Affected:
1,552,880
Defect:
On certain sport utility vehicles equipped with high back seats, the upper bolt on the driver's side high back seat, that attaches the seat recliner mechanism to the seat back frame, could fracture. if the bolt fractures and does not jam in the seat back frame, the seat back may recline until it makes contact with an object behind the seat, such as the second row seat cushion.
Consequence:
The driver could potentially lose contact with the steering wheel or foot pedals during such an event, increasing the risk of a crash.
Correction:
Dealers will replace the driver seat upper bolt with a metal spacer and bolt. in addition, seats with tubular back frames will have the fully threaded lower recliner bolt replaced with a partially threaded bolt. owner notification began on august 29, 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s04.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06V114000 on 04/10/2006
Component:
Seats:front assembly:recliner
Affected:
8,585
Defect:
On certain sport utility vehicles equipped with high back seats, the upper bolt on the driver's side high back seat that attaches the seat recliner mechanism to the seat back frame, could fracture. if the bolt fractures, the seat back may recline until it makes contact with an object behind the seat, such as the second row seat cushion.
Consequence:
The driver could potentially lose contact with the steering wheel or foot pedals during such an event, increasing the risk of a crash.
Correction:
Dealers will replace the driver seat upper bolt with a metal spacer and bolt. in addition, seats with tubular back frames will have the fully threaded lower recliner bolt replaced with a partially threaded bolt. the recall began on april 10, 2006. owners may contact ford at 1-800-392-3673. this is a supplement to a previous recall campaign (03v281).
Notes:
Ford recall no. 03s04. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
09/23/1999 - 08/15/2002
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2001 FORD EXPLORER SPORT TSBs (155)

Bulletin:
8047
Component:
980000 unknown or other
Summary:
Brief information stating that certain vehicles do not have neutral tow capability and can only be towed with all 4 wheels off of the ground. *tt
Bulletin:
8161
Component:
200000 wheels
Summary:
Information on new style wheel weight - 16 inch aluminum wheels for 2001 model year vehicles. *tt
Bulletin:
13916
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit a rear power backlite window being inoperative. *tt
Bulletin:
8235
Component:
980000 unknown or other
Summary:
Subject regarding bonus edsr award points. *tt
Bulletin:
8381
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with 4.0l sohc may exhibit a higher than normal base idle speed of 1200-1400 rpm when the vehicle is initially received from the assembly plant. *tt
Bulletin:
13821
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Information regarding vehicles that do not have the neutral tow capability. *mjs
Bulletin:
8161
Component:
200000 wheels
Summary:
Information regarding required wheel balance service. **mr
Bulletin:
8399
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may experience a nibble or vibration felt through the stirring wheel during low speed/ parking lot type maneuvers. **mr
Bulletin:
8561
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a repetitive knock/ thump noise from the left front which is proportional to the wheel speed when braking. **mr
Bulletin:
14073
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may experience left front brake thump noise. **mr
Bulletin:
8579
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some 4x4 vehicles may exhibit a repetitive thump / knock noise from the left front which is proportional to wheel speed when braking. *tt
Bulletin:
14192
Component:
010000 steering
Summary:
Experiencing a nibble or vibration felt through the steering wheel during low speed / parking lot type steering maneuvers. *tt
Bulletin:
14205
Component:
190000 tires
Summary:
Some vehicles equipped with firestone p235 / 75r15 wilderness ht tires may exhibit a vibration at speeds above 45 mph. *tt
Bulletin:
00M12
Component:
061000 engine and engine cooling:engine
Summary:
Ford motor company is providing additional coverage for the 4.0l sohc camshaft chain tensioner and lower intake manifold gasket. *tt
Bulletin:
14467
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some 4x4 vehicles may exhibit a rattling, ringing, rustle or metallic like sound(s) while driving in 4x2 at highway speeds. *tt
Bulletin:
00B58
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding owner notification program recommending that customers return their vehicles to have the powertrain control module (pcm) updated with a revised calibration that will maintain vehicle top speed within the intended design le
Bulletin:
00M12
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding owner notification suppllemental program for vehicles equipped with 4.0l sohc engines - camshaft chain tensioner and lower intake manifold gasket additional coverage. *tt
Bulletin:
14535
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 4.0l sohc engine may exhibit a rolling idle and / or ac cycling at idle and / or ac lack of cooling at idle condition. *tt
Bulletin:
14541
Component:
141100 air bags:frontal:sensor/control module
Summary:
Some vehicles may exhibit the air bag lamp on with diagnostic trouble code b1994 and / or b1998 in self test. *tt
Bulletin:
14562
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information regarding pats change. *rc
Bulletin:
14585
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Some vehicles equipped with automatic transmission do not have neutral tow capability and can only be towed with all 4 wheels off the ground. *tt
Bulletin:
14560
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles may experience start up timing chain noise. *jb
Bulletin:
14597
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit an abs lamp on with diagnostic trouble code b2607 (module configuration mismatch) present. *tt
Bulletin:
010110
Component:
140000 air bags
Summary:
Some vehicles may exhibit the air bag lamp on with diagnostic trouble codes b1994 and / or b1998 stored in memory. *jb
Bulletin:
01110
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Air bag lamp on with diagnostic trouble codes b1994 and / or b1998 stored in memory. *tt
Bulletin:
00L09
Component:
355100 equipment:other:labels
Summary:
Subject pertaining to supplemental tire inflation label. *jb
Bulletin:
14352
Component:
220000 seats
Summary:
Subject pertaining to right front seat movement after rear access. *jb
Bulletin:
14384
Component:
141100 air bags:frontal:sensor/control module
Summary:
Some vehicles may exhibit the air bag lamp on with diagnostic trouble codes b1994 and / or b1998 in self test. *jb
Bulletin:
0161
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
On some sport and sport trac vehicles, the anti-lock brake system (abs) lamp may illuminate and diagnostic trouble code (dtc) b2607 may or may not be set in the abs module. *tt
Bulletin:
0186
Component:
106000 power train:axle assembly
Summary:
On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt
Bulletin:
14832
Component:
341000 communications:horn assembly
Summary:
Some vehicles may exhibit the horn switch sticking after it is depressed. *tt
Bulletin:
14833
Component:
106000 power train:axle assembly
Summary:
Some 4x2 vehicles may exhibit a rear axle whine. *tt
Bulletin:
14847
Component:
106000 power train:axle assembly
Summary:
Concerns with vehicles exhbit fluid leakage from the front axle vent tube. *tt
Bulletin:
14772
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some 4x4 vehicles may exhibit a consistent squealing noise from the front brakes when the brakes are applied. *tt
Bulletin:
14899
Component:
036000 service brakes, hydraulic:antilock
Summary:
Information regarding anti-lock brake system (abs) module configuration. *tt
Bulletin:
14933
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp illuminated and a diagnostic trouble code (dtc) b1342 (anti-lock brake control module failure) in self test. *tt
Bulletin:
13995
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with 4.0l sohc may exhibit a higher than normal base idle speed of 1200-1400 rpm when the vehicle is initially received from the assembly plant. this higher base idle stragety is now used during plant / transportati
Bulletin:
1400
Component:
010000 steering
Summary:
Some vehicles may exhibit a nibble or vibration felt through the steering wheel during low speed / parking lot type steering maneuvers. *tt
Bulletin:
14205
Component:
190000 tires
Summary:
Some vehicles equipped with firestone p235 / 75r15 wilderness ht tires may exhibit a vibration at speeds above 45 mph, due to tires slipping on the wheels and changing index position. *tt
Bulletin:
14206
Component:
103000 power train:automatic transmission
Summary:
Some 4x2 vehicles equipped automatic transmission may exhibit a vibration at high speeds, which may cause the transmission extension housing seals to leak or the transmission extension housing bushing to spin. *tt
Bulletin:
14407
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Some vehicles built on or after 7/24/2000 may exhibit a lack of heat and / or a malfunction indicator lamp (mil) on with d%tc p0125, due to the thermostat sticking open. *tt
Bulletin:
14425
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Subject regarding neutral tow capability. *tt
Bulletin:
14467
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Concerns with transfer case rattling, ringing, rustle or metallic like sound(s) while driving in 4x2 at highway speeds. *tt
Bulletin:
14469
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Certain 4x4s exhibiting a consistent squealing noise from front brakes when brakes are applied. occurs with light brake pedal pressure and goes away with more pressure. *tt
Bulletin:
14430
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit an anti-lock brake system (abs) lamp on with diagnostic trouble code b2607 (module configuration mismatch) present. *tt
Bulletin:
15070
Component:
162300 structure:body:door
Summary:
A condition may exist with flaking or peeling of the interior door pull handle paint on vehicles built before july 24, 2000. *tt
Bulletin:
15080
Component:
105300 power train:driveline:driveshaft
Summary:
Some vehicles with fewer than 10,000 miles may exhibit grease oozing from the front driveshaft cv joint. *tt
Bulletin:
15096
Component:
106000 power train:axle assembly
Summary:
Some 4x2 vehicles may exhibit a rear axle whine. *tt
Bulletin:
15098
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit a hesitation on acceleration or while turning. *tt
Bulletin:
15106
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some 4x4 vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp illuminated and diagnostic trouble code b1342 (anti-lock brake control module failure) in self test. *tt
Bulletin:
01114
Component:
106000 power train:axle assembly
Summary:
Some 4x4 vehicles may exhibit a high-pitched squeal or whistle type noise from the front axle area of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt
Bulletin:
14985
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built after july 24,2000 may exhibit a no crank condition and a communication concern with the powertrain control module. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
15155
Component:
136000 visibility:windshield wiper/washer
Summary:
On some vehicles the rear wiper arm fails to clean back glass. *et
Bulletin:
15217
Component:
980000 unknown or other
Summary:
Information on service parts for hard start condition. *tt
Bulletin:
15230
Component:
221200 seats:front assembly:recliner
Summary:
Some vehicles may exhibit an passenger seat that does not latch securely after rleasing, sliding forward, and returning the seat to its normal position. *tt
Bulletin:
15251
Component:
105300 power train:driveline:driveshaft
Summary:
Some 4x4 vehicles with fewer than 10,000 miles may exhibit grease oozing from the front driveshaft cv joint. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
01B77
Component:
190000 tires
Summary:
Owner notification program supplement 7 revised information - regarding replacement of wilderness at tires. *tt
Bulletin:
15532
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Information on vehicles exhibitng fuel line damage due to pinching/squeezing of the fuel return line. *tt
Bulletin:
15531
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine quitting on deceleration/stopping.*yd
Bulletin:
15551
Component:
120000 exterior lighting
Summary:
Customers may complain of moisture in headlamp. *yh
Bulletin:
15567
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built before april 23, 2001 may exhibit a hard start/long crank after sitting for an hour or more. *tt
Bulletin:
15572
Component:
151600 seat belts:front:warning light/devices
Summary:
Some vehicles equipped with belt minder may exhibit the belt minder warning chime staying on after the driver seat belt buckle has been buckled. *tt
Bulletin:
15358
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with engine quitting during deceleration. *tt
Bulletin:
15378
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with the 4.0l engine may exhibit an engine flutter noise. *tt
Bulletin:
15381
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with a manual transmission may exhibit an engine loss or reduction in power condition on deceleration, but will immediately restart. *tt
Bulletin:
15382
Component:
102000 power train:manual transmission
Summary:
Some vehicles may exhibit either a very hard or very soft clutch pedal feel, and/or a difficulty in shifting gears. *tt
Bulletin:
15406
Component:
137000 visibility:rear window wiper/washer
Summary:
Concerns with rear wipers that do not sufficiently clean the back glass. *tt
Bulletin:
15422
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank condition after sitting for an hour or more. *tt
Bulletin:
15428
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a no crank condition and a problem communicating with the powertrain control module (pcm). *tt
Bulletin:
01241
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some vehicles may exhibit a condition of not being able to disengage clutch as the clutch pedal is stroked or the clutch pedal remains on floor. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15471
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some 4.0l sohc engines may exhibit excessive sulphur smell from the exhaust system while operating under certain drive modes. *tt
Bulletin:
0232
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 4.0l sohc engine may exhibit a check engine light on with diagnostic trouble codes p0300 (random misfire) or p0301. *tt
Bulletin:
15644
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhbit a hard start/no start condition when trying to start the vehicle. *tt
Bulletin:
15655
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles equipped with a 4.0l sohc engine may exhibit excessive sulphur smeel from the exhaust when operating under certain drive modes. *tt
Bulletin:
15655
Component:
063000 engine and engine cooling:exhaust system
Summary:
Concerns with excessive sulphur smell from the exhaust when operating under certain drive modes. *tt
Bulletin:
02138
Component:
102000 power train:manual transmission
Summary:
Low line pressure reading at wide open throttle (wot), slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set on vehicles built before 12/1/2001. *tt
Bulletin:
0276
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on diagnosing engine rattle noise from primary chain drive area between 2000-3000 rpm on cold engine operation only. *tt
Bulletin:
0258
Component:
100000 power train
Summary:
Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
Bulletin:
0242
Component:
106000 power train:axle assembly
Summary:
Certain vehicles with 4x4 or all-wheel drive may have a fluid leak from the front axle vent tube. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
16114
Component:
140000 air bags
Summary:
Some vehicles may exhibit repeat service for air bag lamp on with diagnostic trouble code b1994 (driver side air bag circuit resistance high) and / or b1998 (passenger side air bag circuit resistance high). *tt
Bulletin:
16121
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Some vehicles may exhibit uneven and / or premature front brake pad wear, particularly the front inside pad. *tt
Bulletin:
16131
Component:
140000 air bags
Summary:
Some vehicles may exhibit repeat service for an air bag lamp on with diagnostic trouble codes b1994 and b1998 set. *tt
Bulletin:
16134
Component:
126200 exterior lighting:turn signal:switch
Summary:
Information on servicing multifunction switch wiring on vehicles equipped with tilt steering column. *tt
Bulletin:
16134
Component:
126200 exterior lighting:turn signal:switch
Summary:
Information on servicing the multifunction switch on vehicles equipped with tilt steering column. *tt
Bulletin:
16021
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles with 4wabs may exhibit diagnostic trouble codes c1233 and c1234 (anti-lock brake sensor output failures) in slippery conditions. *tt
Bulletin:
16038
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 5r55e automatic transmission may exhibit a gear whine type noise in 1st and / or 2nd gears only. *tt
Bulletin:
16040
Component:
010000 steering
Summary:
Experiencing a clicking / popping noise from the upper steering column area when turning the steering wheel. *tt
Bulletin:
15689
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some vehicles may exhibit either a very hard or very soft clutch pedal feel. *tt
Bulletin:
15696
Component:
980000 unknown or other
Summary:
Some engines may exhibit a hesitation in various drive modes and / or a malfunction indicator lamp illumination with codes set in memory p0171/p0174 and / or p0172/p0175. *tt
Bulletin:
15723
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles may exhibit adhesive extruding from the headliner material around the moonroof. *tt
Bulletin:
15751
Component:
140000 air bags
Summary:
Some vehicles may exhibit an air bag light on with diagnostic trouble code b1993. *tt
Bulletin:
15754
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.0l engine and manual transmission may exhibit an intermittent stumble during deceleration and / or at stops when the clutch pedal is depressed. *tt
Bulletin:
15765
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit wind noise around the front doors, near the top rear-ward portion of the door / glass at highway speeds, or in a cross wind. *tt
Bulletin:
15769
Component:
010000 steering
Summary:
Some vehicles may exhibit a condition of steering wheel leather peeling. *tt
Bulletin:
15785
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 5r55e/5r44e transmission may exhibit a whine noise in 1st gear that goes away after the 1-2 or 1-3 shift is completed. *tt
Bulletin:
15813
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles equipped with 4wabs may exhibit diagnostic trouble codes c1233 and c1234 (anti-lock brake sensor output failure). *tt
Bulletin:
15859
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles with 4wabs may exhibit diagnostic trouble codes c1233 and c1234 (anti-lock brake sensor output failure). *tt
Bulletin:
15869
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some vehicles may exhibit an intermittent soft clutch pedal which may cause difficulty in shifting gears (a notchy feel). *tt
Bulletin:
15887
Component:
100000 power train
Summary:
Some vehicles may exhibit a no 1-2 upshift, no 2-3 upshift, a no engine braking condition in manual 1 or diagnostic trouble code p0732 (gear 2 incorrect ratio) or p0733 (gear 3 incorrect ratio). *tt
Bulletin:
15898
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start / no start condition due to fuel pressure bleed down. *tt
Bulletin:
15910
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with brake vibration, roughness and / or grinding noise, and excessive brake rotor corrosion. *tt
Bulletin:
15936
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equpped with 4.0l engine and automatic transmission may exhibit a rough idle, low speed engine quit, hesitation on cold engine tip-in and / or hesitation during a 5-3 donwshift. *tt
Bulletin:
0281
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc (single over-head cam) engine may exhibit a primary timing chain rattle noise. *tt
Bulletin:
0282
Component:
100000 power train
Summary:
Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings while in drive, no 2nd gear, no 3rd gear, no engine braking in manual 1st and slipping shifts and / or delayed engagements. *tt
Bulletin:
0283
Component:
100000 power train
Summary:
Some vehicles equipped with a 2.3l, 3.0l or 4.0l engine and 5r44e or 5r55e automatic transmission may exhibit a fluid leak at the transmission servo covers in cold climates. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
0361
Component:
060000 engine and engine cooling
Summary:
Malfunction indicator lamp on with or without rough running, lack of power, surge or poor fuel economy with diagnostic trouble codes p0401, p0402, p1400, p1401. *tt *jb
Bulletin:
0358
Component:
106000 power train:axle assembly
Summary:
Fluid may leak out of the front axle vent tube. *tt *jb
Bulletin:
0322
Component:
061000 engine and engine cooling:engine
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401, or runs rough, lacks power, surge, poor fuel economy, and the above listed dtcs without
Bulletin:
0335
Component:
061000 engine and engine cooling:engine
Summary:
Idle air control (iac) valve diagnostic service tips. *tt
Bulletin:
16604
Component:
062000 engine and engine cooling:cooling system
Summary:
Engine overheating due to thermostat failure. *tt
Bulletin:
16610
Component:
061000 engine and engine cooling:engine
Summary:
No start, no communication with power train control module (pcm) using wds/ngs or a miss/buck/jerk while driving. *tt
Bulletin:
16623
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Excessive fuel gauge fluctuation while driving (qsf). *tt
Bulletin:
16735
Component:
022000 suspension:rear
Summary:
Various noise issues from the rear leaf springs while driving. *tt
Bulletin:
16776
Component:
126200 exterior lighting:turn signal:switch
Summary:
Servicing multifunction switch wiring interference. *tt
Bulletin:
16810
Component:
061000 engine and engine cooling:engine
Summary:
Rough idle and/or check engine lamp due to closure hose which becomes loose or disconnected at the right hand cam cover. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
031912
Component:
010000 steering
Summary:
Steering wheel shudder during low speed turning maneuvers. 2004 explorer sport trac included. *tt
Bulletin:
17198
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Wear-through condition on the abrasion sleeve of the upper radiator hose near the air conditioning accumulator or transmission fluid dipstick. *tt
Bulletin:
17231
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Anti-lock brake system (abs) light flashing with diagnostic trouble code (dtc) b2477 after replacement of the abs module. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
17253
Component:
162900 structure:body:roof and pillars
Summary:
Water leak near the roof opening panel. 2004 explorer sport trac included. *tt
Bulletin:
17254
Component:
010000 steering
Summary:
Clicking/popping noise from upper steering column area when turning. 2004 e series and explorer sport trac also included. *tt
Bulletin:
17280
Component:
112000 electrical system:alternator/generator/regulator
Summary:
Generator whistle/hoot noise in cold ambient temperatures. *tt
Bulletin:
02M01
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Customer satisfaction program 02m01 supplement #4. certain ford 2000 through 2003 vehicles equipped with a tube-mounted egr pressure sensor - additional egr pressure sensor warranty coverage. *tt supplement #3. *mj supplement #6
Bulletin:
03223
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy. *tt
Bulletin:
031912
Component:
010000 steering
Summary:
Steering shudder felt when turning, driving at slow speeds or at stop. *tt
Bulletin:
17647
Component:
160000 structure
Summary:
Paint peeling and/or bubbling on the center finish panel of the instrument panel. *tt
Bulletin:
17544
Component:
061000 engine and engine cooling:engine
Summary:
Generator noise in cold ambient temperatures. *mj
Bulletin:
04111
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy.
Bulletin:
02222
Component:
103000 power train:automatic transmission
Summary:
Noise-gear whine noise in 1st and 2nd gear only-vehicles equipped with 5r55e transmission and 4.0l engine only. *mj
Bulletin:
16402
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Front brake wear - under investigation. *mj
Bulletin:
16437
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Diagnostic trouble code (dtc) c1233 & c1234 - replace anti-lock brake system euc. *mj
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
04133
Component:
121000 exterior lighting:headlights
Summary:
Moisture in headlamp. *tt
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
020801
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise from primary chain drive area 2000-3000 rpm - 4.0l sohc engine. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
05310
Component:
150000 seat belts
Summary:
Safety belt web stop button service. *eh
Bulletin:
02216
Component:
063000 engine and engine cooling:exhaust system
Summary:
Excessive sulfur smell from exhaust. *eh
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
042419
Component:
021000 suspension:front
Summary:
Revised procedure for adjusting alignment on all suspensions - new right hand upper control arm design for torsion bar front suspensions. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
030508
Component:
106000 power train:axle assembly
Summary:
Front axle leaks fluid from vent tube - vehicles equipped with 4x4 or awd. *tt
Bulletin:
0427
Component:
010000 steering
Summary:
Steering shudder during low speed maneuvers - 4.0l engine. *tt
Bulletin:
CSP-08B01
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe

Home | Privacy