2001 FORD EXPLORER Recalls (12)

Campaign:
00V313000 on 10/23/2000
Component:
Equipment:other:labels
Manufactured:
09/24/2000 - 09/24/2000
Affected:
5
Defect:
Vehicle description: certain sport utility vehicles fail to comply with the requirements of part 567.4, "certification." these vehicles were shipped from the assembly plant without safety certification labels.
Consequence:
Incorrect tire inflation pressure could result in tire tread separation, increasing the risk of a crash.
Correction:
Dealers will replace the certification labels.
Notes:
All vehicles were at dealerships and certification labels were affixed to these units on october 9, 2000.this recall is 100% complete.
Campaign:
01X001000 on 05/21/2001
Component:
Tires:tread/belt
Affected:
13,000,000
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. ford is replacing these tires to prevent possible premature tire failure. vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
Consequence:
Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
Correction:
The replacement/reimbursement program for this campaign expired on march 31, 2002. however, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
Campaign:
03V094000 on 03/17/2003
Component:
Structure
Manufactured:
07/31/2000 - 03/02/2003
Affected:
3,674
Defect:
Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. these units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Consequence:
This overheating condition can cause the running board to melt or cause a fire.
Correction:
Dealers will replace the wiring harness on these running boards. owner notification began march 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V280000 on 08/06/2003
Component:
Vehicle speed control:cables
Manufactured:
03/04/1999 - 12/23/2000
Affected:
448,005
Defect:
On certain sport utility vehicles equipped with speed control and 4.0l sohc engines, if the strand cover on the speed control cable becomes flared at the end, the speed control cable may bind when the speed control is activated.
Consequence:
The throttle return spring force may not be sufficient to overcome the binding condition when the speed control is disengaged. braking function would be maintained though stopping distances may be increased.
Correction:
Dealers will inspect the speed control cable and, if necessary, replace it. owner notification began august 29, 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s03.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V281000 on 08/06/2003
Component:
Seats:front assembly:recliner
Manufactured:
05/12/1997 - 12/23/2000
Affected:
1,552,880
Defect:
On certain sport utility vehicles equipped with high back seats, the upper bolt on the driver's side high back seat, that attaches the seat recliner mechanism to the seat back frame, could fracture. if the bolt fractures and does not jam in the seat back frame, the seat back may recline until it makes contact with an object behind the seat, such as the second row seat cushion.
Consequence:
The driver could potentially lose contact with the steering wheel or foot pedals during such an event, increasing the risk of a crash.
Correction:
Dealers will replace the driver seat upper bolt with a metal spacer and bolt. in addition, seats with tubular back frames will have the fully threaded lower recliner bolt replaced with a partially threaded bolt. owner notification began on august 29, 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s04.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E056000 on 06/22/2006
Component:
Fuel system, gasoline
Affected:
58,640
Defect:
Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence:
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Correction:
Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
Notes:
This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
06/15/1998 - 09/26/2000
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09V399000 on 10/12/2009
Component:
Vehicle speed control
Manufactured:
08/10/1994 - 08/29/2002
Affected:
4,500,000
Defect:
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
Consequence:
A vehicle fire could occur with or without the engine running.
Correction:
Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
Notes:
Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2001 FORD EXPLORER TSBs (116)

Bulletin:
8423
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some vehicles may exhibit an oil leak from the inside diameter of the rear axle pinion oil seal. *tt
Bulletin:
14011
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some 2000 and 2001 model year vehicles may exhibit an oil leak from the inside diameter of the rear axle pinion oil seal. *tt
Bulletin:
8512
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr
Bulletin:
8534
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit a cooling system leak due to a broken constant tension clamp. **mr
Bulletin:
14056
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr
Bulletin:
14062
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit a cooling system leak due to a broken constant tension clamp. **mr
Bulletin:
14061
Component:
980000 unknown or other
Summary:
Some vehicles may come in for a malfunction indicator lamp (mil) on with diagnostic trouble code p0171 and/or p0174 in self test. **mr
Bulletin:
14090
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start / no start condition when attempting to start the vehicle. *tt
Bulletin:
14198
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a squeak noise from the front lower door hinge(s) when opening or closing the doors. *tt
Bulletin:
00M12
Component:
061000 engine and engine cooling:engine
Summary:
Ford motor company is providing additional coverage for the 4.0l sohc camshaft chain tensioner and lower intake manifold gasket. *tt
Bulletin:
00245
Component:
980000 unknown or other
Summary:
Some vehicles equipped with a 5.0l engine may exhibit a malfunction indicator lamp (mil) on with diagnostic trouble codes (dtcs) p0351 through p0354 possible with no driveability concerns present. *tt
Bulletin:
14451
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 5.0l engine may exhibit a malfunction indicator light (mil) on with possible diagnostic trouble codes p0351, p0352, p0353 and / or p0354 in self test with no driveability concerns present. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
002405
Component:
980000 unknown or other
Summary:
Some vehicles equipped with a 5.0l engine may exhibit a malfunction indicator lamp (mil) on with diagnostic trouble code (dtc) p0351 through p0354 possible with no driveability concerns present. *tt
Bulletin:
14584
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding flex fuel vechicle oil and fuel recommendations. *jb
Bulletin:
14554
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 4r70w transmission may exhibit the tcil on with diagnostic trouble code p0741 (torque converter clutch system performance or stuck off) in continuous memory. *jb
Bulletin:
14555
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with engine ticking sound/noise. *jb
Bulletin:
14583
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Concerns with broken thermostats on engines. *jb
Bulletin:
14586
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some 4.0l vehicles with a4wd built prior to 9/13/99 may exhibit a vibration / pulsation at 0-45 mph on dry pavement under light to moderate acceleration in 4 auto mode which may characteristic with the control trac 4x4 system. *jb
Bulletin:
14617
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Subject pertaining to broken thermostat. *jb
Bulletin:
01110
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Air bag lamp on with diagnostic trouble codes b1994 and / or b1998 stored in memory. *tt
Bulletin:
00143
Component:
162000 structure:body
Summary:
Subject regarding vibration, shake, resonance noise at speeds above 72 km/h (45mph). *jb
Bulletin:
00L09
Component:
355100 equipment:other:labels
Summary:
Subject pertaining to supplemental tire inflation label. *jb
Bulletin:
00201
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Some vehicles may exhibit hesitation on acceleration or while turning. *jb
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
14345
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit the oil pressure gauge registering low or no oil pressure usually on initial strt-up after several hours of cold soak. *jb
Bulletin:
14371
Component:
020000 suspension
Summary:
Subject regarding pop / creak noise from the rear underbody while driving. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
0186
Component:
106000 power train:axle assembly
Summary:
On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt
Bulletin:
14819
Component:
106000 power train:axle assembly
Summary:
Some 4x4 vehicles may exhibit a fluid leak from the front axle vent tube. *tt
Bulletin:
14823
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc engine may exhibit a primary chain rattle noise between 2000 - 3000 rpm (sometimes described as a spark knock-type noise). *tt
Bulletin:
14847
Component:
106000 power train:axle assembly
Summary:
Concerns with vehicles exhbit fluid leakage from the front axle vent tube. *tt
Bulletin:
14868
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc engine may exhibit a primary chain rattle noise (sometimes described as a spark knock-type noise). *tt
Bulletin:
01411
Component:
106000 power train:axle assembly
Summary:
High-pitched front axle squeal or whistle type noise from the front of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt
Bulletin:
0154
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) accompanied by a diagnostic trouble code (dtc) p0741 and in some cases p1728. *tt
Bulletin:
01B75
Component:
106000 power train:axle assembly
Summary:
Field action for certain usps vehicles built with incorrect front axle to frame horizontal bolts. *tt
Bulletin:
01B75
Component:
106000 power train:axle assembly
Summary:
On some u.s. postal service 4x4 vehicles, an incorrect bolt and washer may have been inadvertently installed in the front axle. if the correct bolt and washer were installed, it may be possible for it to become loose and fall out, causing
Bulletin:
14871
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit driveability conditions or check engine lamp (mil) illuminated with a diagnostic trouble code p0455 (gross leak detected). *tt
Bulletin:
14907
Component:
980000 unknown or other
Summary:
Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
Bulletin:
14306
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit one or all power windows inoperative, all or one of the power door locks inoperative or allthe power door locks cycling un-commanded. *tt
Bulletin:
14451
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 5.0l engine may exhibit a malfunction indicator light (mil) on with possible diagnostic trouble codes (dtc) p0351, p0352, p0353 and / or p0354 in self test with no driveability concerns present.
Bulletin:
01137
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
Bulletin:
15080
Component:
105300 power train:driveline:driveshaft
Summary:
Some vehicles with fewer than 10,000 miles may exhibit grease oozing from the front driveshaft cv joint. *tt
Bulletin:
15093
Component:
980000 unknown or other
Summary:
Exhibiting drivability conditions or check engine lamp illuminated with diagnostic trouble code p0455 (gross leak detected). *tt
Bulletin:
01114
Component:
106000 power train:axle assembly
Summary:
Some 4x4 vehicles may exhibit a high-pitched squeal or whistle type noise from the front axle area of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt
Bulletin:
15022
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Concerns that the anti-lock brake system (abs) lamp is on with diagnostic trouble codes c1230, c1229, or c1237. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15119
Component:
126200 exterior lighting:turn signal:switch
Summary:
Information regarding multifunction switch part number clarification. *slc
Bulletin:
15155
Component:
136000 visibility:windshield wiper/washer
Summary:
On some vehicles the rear wiper arm fails to clean back glass. *et
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15215
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit drivability conditions or check engine lamp illuminated with diagnostic trouble code p0455 or p0457 stored. *tt
Bulletin:
15215
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit drivability conditions or check engine lamp illuminated with diagnostic trouble code p0455 or p0457. *tt
Bulletin:
15217
Component:
980000 unknown or other
Summary:
Information on service parts for hard start condition. *tt
Bulletin:
15223
Component:
980000 unknown or other
Summary:
Some postal vehicles may exhibit a malfunction indicator lamp with a diagnostic trouble code p0442. *tt
Bulletin:
15249
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with high brake pedal force to stop after rotor machining. *tt
Bulletin:
15251
Component:
105300 power train:driveline:driveshaft
Summary:
Some 4x4 vehicles with fewer than 10,000 miles may exhibit grease oozing from the front driveshaft cv joint. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
01B77
Component:
190000 tires
Summary:
Owner notification program supplement 7 revised information - regarding replacement of wilderness at tires. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15532
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Information on vehicles exhibitng fuel line damage due to pinching/squeezing of the fuel return line. *tt
Bulletin:
15563
Component:
980000 unknown or other
Summary:
Information regarding malfunction indicator light illuminating with diagnostic trouble code p0300/p0301.*yh
Bulletin:
15564
Component:
121000 exterior lighting:headlights
Summary:
Some 4 door vehicles with the autolamp feature may exhibit a condition of the headlamps staying on all the time. *tt
Bulletin:
15567
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built before april 23, 2001 may exhibit a hard start/long crank after sitting for an hour or more. *tt
Bulletin:
15290
Component:
061000 engine and engine cooling:engine
Summary:
Some 4.0l sohc may exhibit an engine oil leak condition, coming from the oil pan or ladder frame area. *tt
Bulletin:
15406
Component:
137000 visibility:rear window wiper/washer
Summary:
Concerns with rear wipers that do not sufficiently clean the back glass. *tt
Bulletin:
15422
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank condition after sitting for an hour or more. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15470
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with spark knock noise or chain rattle noise between 2000-3000 rpm, during cold engine operation only. *tt
Bulletin:
15486
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a check engine lamp illuminated with diagnostic trouble code p0457 (gross leak after fuel fill). *tt
Bulletin:
15496
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built before april 23, 2001 may exhibit a hard start/long crank after sitting for an hour or more due to fuel system contamination. *tt
Bulletin:
0232
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 4.0l sohc engine may exhibit a check engine light on with diagnostic trouble codes p0300 (random misfire) or p0301. *tt
Bulletin:
02138
Component:
102000 power train:manual transmission
Summary:
Low line pressure reading at wide open throttle (wot), slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set on vehicles built before 12/1/2001. *tt
Bulletin:
0276
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on diagnosing engine rattle noise from primary chain drive area between 2000-3000 rpm on cold engine operation only. *tt
Bulletin:
0242
Component:
106000 power train:axle assembly
Summary:
Certain vehicles with 4x4 or all-wheel drive may have a fluid leak from the front axle vent tube. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
16114
Component:
140000 air bags
Summary:
Some vehicles may exhibit repeat service for air bag lamp on with diagnostic trouble code b1994 (driver side air bag circuit resistance high) and / or b1998 (passenger side air bag circuit resistance high). *tt
Bulletin:
16131
Component:
140000 air bags
Summary:
Some vehicles may exhibit repeat service for an air bag lamp on with diagnostic trouble codes b1994 and b1998 set. *tt
Bulletin:
16040
Component:
010000 steering
Summary:
Experiencing a clicking / popping noise from the upper steering column area when turning the steering wheel. *tt
Bulletin:
15692
Component:
020000 suspension
Summary:
Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps. *tt
Bulletin:
15887
Component:
100000 power train
Summary:
Some vehicles may exhibit a no 1-2 upshift, no 2-3 upshift, a no engine braking condition in manual 1 or diagnostic trouble code p0732 (gear 2 incorrect ratio) or p0733 (gear 3 incorrect ratio). *tt
Bulletin:
15910
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with brake vibration, roughness and / or grinding noise, and excessive brake rotor corrosion. *tt
Bulletin:
0281
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc (single over-head cam) engine may exhibit a primary timing chain rattle noise. *tt
Bulletin:
0282
Component:
100000 power train
Summary:
Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings while in drive, no 2nd gear, no 3rd gear, no engine braking in manual 1st and slipping shifts and / or delayed engagements. *tt
Bulletin:
0285
Component:
353600 equipment:air conditioner
Summary:
On some vehicles, the electronic automatic temperature control (eatc) blows cold air from the floor ducts on vehicles produced before 9/30/2000 only. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
0358
Component:
106000 power train:axle assembly
Summary:
Fluid may leak out of the front axle vent tube. *tt *jb
Bulletin:
0335
Component:
061000 engine and engine cooling:engine
Summary:
Idle air control (iac) valve diagnostic service tips. *tt
Bulletin:
16735
Component:
022000 suspension:rear
Summary:
Various noise issues from the rear leaf springs while driving. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16935
Component:
100000 power train
Summary:
An uncommanded shift to 4x4 low. *tt
Bulletin:
16952
Component:
061000 engine and engine cooling:engine
Summary:
Postal fleet vehicles equipped with 4.0l fe engine may exhibit a low oil pressure gauge reading, check engine light on and sometimes upper or lower engine noise. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03199
Component:
061000 engine and engine cooling:engine
Summary:
Rattle/buzz sound from under the vehicle on 4.0l single overhead cam (sohc) engines. *tt
Bulletin:
03223
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy. *tt
Bulletin:
17316
Component:
090000 fuel system, other
Summary:
Fuel signal to instrument cluster service tip. *tt
Bulletin:
0471
Component:
110000 electrical system
Summary:
Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
Bulletin:
04111
Component:
110000 electrical system
Summary:
Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy.
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
02171
Component:
162000 structure:body
Summary:
Paint-premature clearcoat cracking-service tips. *mj
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
020801
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise from primary chain drive area 2000-3000 rpm - 4.0l sohc engine. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
02216
Component:
063000 engine and engine cooling:exhaust system
Summary:
Excessive sulfur smell from exhaust. *eh
Bulletin:
04174
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
042419
Component:
021000 suspension:front
Summary:
Revised procedure for adjusting alignment on all suspensions - new right hand upper control arm design for torsion bar front suspensions. *tt
Bulletin:
042421
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retraction speed. *tt
Bulletin:
04251
Component:
162000 structure:body
Summary:
Aluminum corrosion - service tip. *tt
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
030508
Component:
106000 power train:axle assembly
Summary:
Front axle leaks fluid from vent tube - vehicles equipped with 4x4 or awd. *tt
Bulletin:
CSP-08B01
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe

Home | Privacy