2001 CHRYSLER PT CRUISER Recalls (7)
- Campaign:
- 00V366000 on 11/14/2000
- Component:
- Child seat
- Manufactured:
- 06/14/1999 - 10/30/2000
- Affected:
- 1,211,756
- Defect:
- Vehicle description: certain passenger vehicles, pickup trucks and sport utility vehicles fail to comply with the requirements of fmvss no. 225, "child restraint anchorage systems." some of the owner's manuals for these vehicles are missing instructions that provide a step-by-step procedure, including diagrams, for properly attaching a child restraint system's tether strap to the tether anchorage.
- Consequence:
- In the event of a crash, the child seat may not be properly attached increasing the risk of injury to the child.
- Correction:
- Owners will be provided with an addendum to the owner's manuals.
- Notes:
- Owner notification began november 12, 2000.owners who do not receive the free owner's manual addendum within a reasonable time should contact daimlerchrysler at 1-800-853-1403.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V162000 on 06/25/2002
- Component:
- Seats:front assembly:recliner
- Manufactured:
- 07/31/1999 - 10/23/2000
- Affected:
- 77,000
- Defect:
- Certain passenger vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." the right rear "65%" seat center lower anchor was manufactured with a wire diameter that is greater than the maximum allowable dimension as specified in the standard.
- Consequence:
- if the connector for a latch-type child restraint is not attached correctly to the anchorage points, the restraint will not properly protect a child in the event of a crash.
- Correction:
- Dealers will inspect the right rear seat center anchor and, if necessary, resize the anchor to meet the diameter specified within the standard. owner notification began november 4, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. b21.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V214000 on 08/11/2002
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 05/14/2000 - 01/22/2001
- Affected:
- 97,779
- Defect:
- On certain passenger vehicles, the fuel supply line could contact the air-conditioning tube service port. this can cause chafing of the line resulting in a fuel leakage.
- Consequence:
- Fuel leakage in the presence of an ignition source could result in a fire.
- Correction:
- Dealers will inspect the fuel line for abrasion and install a clip to ensure isolation. in cases with evidence of fuel line abrasion, the fuel line will be replaced. owner notification began august 12, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no.b16. also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V215000 on 08/11/2002
- Component:
- Fuel system, gasoline:delivery
- Manufactured:
- 10/03/1999 - 06/29/2002
- Affected:
- 345,436
- Defect:
- On certain passenger vehicles, the fuel pump module mounting flange could leak fuel if the vehicle is involved in a rollover crash.
- Consequence:
- Fuel leakage in the presence of an ignition source could result in a fire.
- Correction:
- dealers will install a secondary seal over the fuel pump module. owner notification began august 12, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no.b23.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V268000 on 06/02/2004
- Component:
- Steering:hydraulic power assist:hose, piping, and connections
- Manufactured:
- 01/16/2000 - 04/25/2004
- Affected:
- 438,391
- Defect:
- On certain passenger vehicles equipped with 2.4l non-turbocharged engines and automatic transaxles, the power steering pressure hose may contact the automatic transaxle differential cover, potentially damaging the hose.
- Consequence:
- Power steering fluid leakage in the presence of an ignition source can result in an underhood fire.
- Correction:
- Dealers will inspect and relocate, or replace as necessary, the power steering hose and confirm torque of the hose fastener at the steering gear end. the recall began on september 20, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. d18.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 08E033000 on 04/16/2008
- Component:
- Suspension
- Affected:
- 6,903
- Defect:
- Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between november 9, 2007 and march 26, 2008, which may have been packaged with incorrect nuts. the part numbers packaged with incorrect nuts are: k7147, k7329, k8683, and 104353. these parts were made for use on the various vehicles listed above.
- Consequence:
- The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. if the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. this may result in loss of vehicle control, possibly resulting in a vehicle crash.
- Correction:
- Federal mogul will notify owners and replace the parts free of charge. the recall began on may 22, 2008. owners can contact federal mogul at 877-489-6659.
- Notes:
- This recall only pertains to aftermarket ball joint assemblies and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2001 CHRYSLER PT CRUISER TSBs (77)
- Bulletin:
- 080400
- Component:
- 120000 exterior lighting
- Summary:
- Subject regarding light bulb applications and replacement information. *tt
- Bulletin:
- 030100
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Subject pertaining to driveshaft removal information. *tt
- Bulletin:
- 190200
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Brief information regarding ignition lock cylinder service. *tt
- Bulletin:
- 050200
- Component:
- 050000 parking brake
- Summary:
- Subject regarding revised parking brake equalizer assembly removal procedures. *tt
- Bulletin:
- 081400
- Component:
- 090000 fuel system, other
- Summary:
- Customer may report that the fuel gauge needle does not reach the full mark with the fuel tank full, even after topping the tank off. *tt
- Bulletin:
- 231400
- Component:
- 162000 structure:body
- Summary:
- Information concerning cargo net installation instructions. *tt
- Bulletin:
- 231600
- Component:
- 162300 structure:body:door
- Summary:
- The front door water dam may contact the speaker and create a buzz / hum type sound. *tt
- Bulletin:
- 0017
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Subject regarding owners manual addendum items. *tt
- Bulletin:
- 0018
- Component:
- 160000 structure
- Summary:
- Some vehicles may exhibit wind buffeting with the windows and / or sunroof in certain open or partially open positions. *tt
- Bulletin:
- 140400
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- A condition may exist where the vehicle is hard or slow to start. *tt
- Bulletin:
- 180400
- Component:
- 980000 unknown or other
- Summary:
- The customer will notice an erroneous malfunction indicator lamp (mil) illuminated with p0441 - evap purge flow monitor failure. *tt
- Bulletin:
- 181800
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding driveability improvements / system enhancements. *tt
- Bulletin:
- 0043
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Due to a delamination problem, the accessory drive belt for the power steering pump and a/c compressor may require replacement. *tt
- Bulletin:
- 0048
- Component:
- 162000 structure:body
- Summary:
- Customers may complain of loose or missing stanchion covers on the roof rack of certain vehicles. *tt
- Bulletin:
- 082700
- Component:
- 140000 air bags
- Summary:
- Subject regarding non-deployed airbag handling procedures. *tt
- Bulletin:
- 0803300
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may exhibit a fault code in the radio when performing diagnostic using the drb iii. the code reads cold cd. the fault code is not displayed to the customer and is only displayed when performing diagnostics.
- Bulletin:
- 0803400
- Component:
- 110000 electrical system
- Summary:
- Subject regarding pdc relay remover / installation tool. *tt
- Bulletin:
- 0803600
- Component:
- 110000 electrical system
- Summary:
- Subject regarding circuits effected by ignition off draw (iod) fuse. *tt
- Bulletin:
- 2303600
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Customers may complain of loose or missing stanchion covers on roof rack. *tt
- Bulletin:
- 0803700
- Component:
- 140000 air bags
- Summary:
- This bulletin involves the service of the foam rubber pads under the drivers airbag retention clips. *tt
- Bulletin:
- 0803800
- Component:
- 110000 electrical system
- Summary:
- Subject regarding safety systems - vehicle modifications / repair. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0700400
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Information regarding transaxle cooler line splice kit. *jb
- Bulletin:
- 1400101
- Component:
- 090000 fuel system, other
- Summary:
- Customers may complain that fuel guage will not indicate full. *jb
- Bulletin:
- 01001
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles may experience a no start condition in cold temperatures due to 5 volt regulator failure in the sbec pcm module. *jb
- Bulletin:
- 00055
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Advance service information regarding steering wheel foam pad installation. *tt
- Bulletin:
- 00057
- Component:
- 090000 fuel system, other
- Summary:
- Some vehicles may exhibit a condition described by customers as fuel tank cannot be filled to full, gas pump shuts off before tank is full, or gauge does not indicate full. *tt
- Bulletin:
- 00062
- Component:
- 350000 equipment
- Summary:
- Advance service information regarding under-seat storage bin retrofit. *tt
- Bulletin:
- 2300301
- Component:
- 162000 structure:body
- Summary:
- This bulletin states that all factory installed equipment, such as a sunroof, meet the upper interior head protection requirements of fmvss 201. *tt
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 0900301
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- This bulletin reinforces a requirement to cease the current practice of using supplemental oil additive treatments in all diamler chrysler engines. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2300801
- Component:
- 162000 structure:body
- Summary:
- A condition may exist when the hvac unit blower is turned on high, a ticking sound can be heard from the rear seating position. the cause of the ticking sound is the body exhauster flaps hitting the body exhauster housing retainer. this
- Bulletin:
- 2600401
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding service / diagnostic manual revisions. *tt
- Bulletin:
- 1900601
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Subject regarding steering column click sound. *tt
- Bulletin:
- 0801301
- Component:
- 110000 electrical system
- Summary:
- Subject regarding radio connector repair kit. *tt
- Bulletin:
- 1400101A
- Component:
- 090000 fuel system, other
- Summary:
- A condition may exist in which the fuel gauge doe snot register full even though the fuel tank is full. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 2301001
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Subject regarding sunroof wind deflector vibration. *tt
- Bulletin:
- 2600501
- Component:
- 980000 unknown or other
- Summary:
- This technical service bulletin contains both updated self-adhesive service and / or diagnostic manual pages and update pages. *tt
- Bulletin:
- 2600601
- Component:
- 980000 unknown or other
- Summary:
- This technical service bulletin contains both updated self-adhesive service and / or diagnostic manual pages and update pages requiring hand written changes to existing pages. *tt
- Bulletin:
- 0900301
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- This bulletin reinforces a requirement to cease the current practice of using supplemental oil additive treatments in all daimlerchrysler engines. *tt
- Bulletin:
- 2302701
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *tt
- Bulletin:
- 1802701
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit moderate to severe high way speed 45-60 mph vehicle surge. *tt
- Bulletin:
- 1900601A
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Experiencing steering column click sound when the steering wheel is turned. *tt
- Bulletin:
- 0802801
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Moisture accumulation inside a vented headlamp assembly condition. *tt
- Bulletin:
- 2300402
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Subject regarding front window regulator squeak. *tt
- Bulletin:
- 0800802
- Component:
- 110000 electrical system
- Summary:
- Subject regarding excessive ignition off draw voltage. *slc
- Bulletin:
- 1900402
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Subject regarding steering column click sound. *slc
- Bulletin:
- 2301502
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *slc
- Bulletin:
- 2200102
- Component:
- 980000 unknown or other
- Summary:
- Chrome wheel care. *slc
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 2304602
- Component:
- 152000 seat belts:rear
- Summary:
- Rear child seat lower anchor too large. *tt
- Bulletin:
- 0801003
- Component:
- 150000 seat belts
- Summary:
- Seat belt cinch bar service for various models including 2004 models. *tt
- Bulletin:
- 2100903
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission diagnostic teardown procedure. various models including the 2004 ram truck, durango, sebring convertible, cherokee, vision, neon, and voyager. *tt *sc
- Bulletin:
- 0900704
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Irregular engine snapping sound. *tt
- Bulletin:
- 1900402
- Component:
- 012000 steering:column
- Summary:
- Steering column click sound. *mj
- Bulletin:
- 1802004
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Flash: engine sag or rough idle or veichle surge at engine speeds around 3000 rpm. *mj
- Bulletin:
- 1900304
- Component:
- 010000 steering
- Summary:
- Steering column click sound. *tt
- Bulletin:
- 0300604
- Component:
- 106200 power train:axle assembly:axle shaft
- Summary:
- Front hub/half shaft click/pop sound. *tt
- Bulletin:
- 0600105
- Component:
- 102000 power train:manual transmission
- Summary:
- Transmission gear rattle sound at idle. *tt
- Bulletin:
- 0801505
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Powertrain control module initialization. *sc
- Bulletin:
- 1900805
- Component:
- 010000 steering
- Summary:
- Revised power steering system bleeding procedures. *sc
- Bulletin:
- 0803006
- Component:
- 103000 power train:automatic transmission
- Summary:
- Powertrain control module initialization. *kb
- Bulletin:
- 0800107
- Component:
- 140000 air bags
- Summary:
- Passenger air bag deactivation. *kb
- Bulletin:
- 9003623
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Wiper if mopar oe wipers are unavailable, the below alternatives can be offered instead. 05066964a$ = wbrw0011a$ 05066973a$ = wb000019a$ or wbf00019a$ 05096134a$ = wb000027a$ or wbf00028a$ 55154762a$ = wb000013a$ 68001330a$ = wb000019
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 20616
- Component:
- 110000 electrical system
- Summary:
- P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
- Bulletin:
- 22892
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
- Bulletin:
- 22867
- Component:
- 110000 electrical system
- Summary:
- Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
- Bulletin:
- 22958
- Component:
- 117000 digital instrument panel
- Summary:
- 1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
- Bulletin:
- 20244
- Component:
- 350000 equipment
- Summary:
- Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- 23137
- Component:
- 350000 equipment
- Summary:
- Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
- Bulletin:
- 23104
- Component:
- 120000 lighting (pws)
- Summary:
- 05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
- Bulletin:
- 23027
- Component:
- 114000 electrical system:wiring
- Summary:
- Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p
Home | Privacy