2001 AMTRAN FE Recalls (12)
- Campaign:
- 00V208000 on 08/08/2000
- Component:
- Equipment:other:labels
- Manufactured:
- 06/02/2000 - 08/09/2000
- Affected:
- 327
- Defect:
- Vehicle description: school buses. these vehicles fail to comply with the requirements of fmvss 565, "vehicle identification number requirements." the vehicles have the wrong model year code in the vehicle identification number (vin).
- Consequence:
- These errors will affect the registration of the vehicle.
- Correction:
- Owners will be provided with corrected certification labels.
- Notes:
- Owner notification began september 15, 2000. owners who do not receive the free label within a reasonable time should contact amtran at 1-800-993-7686. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V145001 on 04/26/2001
- Component:
- Visibility:rearview mirrors/devices:exterior
- Manufactured:
- 08/27/2000 - 03/22/2001
- Affected:
- 603
- Defect:
- Vehicle description: school buses equipped with rosco cross over mirrors. the position of the driver's rear view mirror does not allow complete visibility of pedestrians as required under federal motor vehicle safety standard no. 111, "rearview mirrors."
- Consequence:
- A pedestrian could be injured or killed if the driver of the school bus cannot see them.
- Correction:
- Amtran will notify owners with instructions to reposition the driver's rear view mirror up 3 1/8 inches. owner notification began june 4, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact amtran at 501-505-2190.
- Notes:
- Also contact the national highway traffic safety administration=s auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V241000 on 07/30/2001
- Component:
- Visibility:defroster/defogger system:windshield:blower
- Manufactured:
- 05/31/2000 - 05/30/2001
- Affected:
- 11,944
- Defect:
- Vehicle description: certain school and transit buses were built with a poor quality heater/defroster blower switch. in some cases this has caused the melting of the heater harness connector at the switch terminals or the high-speed wire insulation at the connector. also, some of the units had improper circuit protection size installed in the heater defroster circuit.
- Consequence:
- If an operator detects smoke or the smell of melting wire insulation from the blower control panel, the operation of the heater/defroster at high speed should be discontinued until the repair is made.
- Correction:
- Owners will be provided with instructions and parts to replace the switch and switch harness with a new switch, switch harness, relay and relay harness. for the re units built prior to january 1, 1999, the kit will also include a 20-ampere manual circuit breaker. owner notification began december 15, 2001. owners who do not receive the free remedy within a reasonable time should contact amtran at 800-843-5615.
- Notes:
- Also contact the national highway traffic safety administration=s auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V269000 on 09/03/2001
- Component:
- Seats
- Manufactured:
- 05/31/2000 - 05/30/2001
- Affected:
- 3,694
- Defect:
- Vehicle description: school and transit buses equipped with 39-inch flip seats. the flip seats could bind in the occupied position and not return to the stored position when not occupied. the cushion frame support bar slides off the seat support pad, which could retain the seat in the occupied position.
- Consequence:
- The seat could block the aisle to the emergency exit during an emergency, which may result in injury or death.
- Correction:
- Owners will be provided with instructions and parts to repair the seats free of charge. owner notification began october 23, 2001. owners who do not receive the free remedy within a reasonable time should contact amtran at 800-843-5615.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V350000 on 11/14/2001
- Component:
- Electrical system:wiring
- Manufactured:
- 04/28/2001 - 05/30/2001
- Affected:
- 307
- Defect:
- Vehicle description: certain buses were built with an improper connection of the heater harness from the heater switch to the connector just outside the heater unit. the assembly left a loose hot wire in the heater harness with an unprotected terminal that could cause a direct short. this wire is protected with a 20-ampere circuit protection, but in a rare case could cause a fire.
- Consequence:
- Electrical component failure without the correct protection in some cases can cause overheating of the component.
- Correction:
- Owners will be provided with instructions on how to repair the defect. the repair procedure for this defect will require placing the connectors correctly in the terminals to the high-speed blower relay and harness connection at the heater. owner notification began december 18, 2001. owners who do not receive the free instructions within a reasonable time should contact amtran at 1-800-843-5615.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V369000 on 12/18/2001
- Component:
- Electrical system:wiring
- Manufactured:
- 05/31/2000 - 05/30/2001
- Affected:
- 3,190
- Defect:
- Vehicle description: certain buses were built with a wiring diagram decal that shows the circuit protection size of 30 amperes instead of 20 amperes for the heater supply circuits.
- Consequence:
- Electrical component failure without the correct protection in some cases can cause overheating of the component and/or fire.
- Correction:
- Owners will be provided with a strip and installation instructions that should be placed over the incorrect information on the current decal. owner notification began december 21, 2001. owners who do not receive the free strip and installation instructions within a reasonable time should contact amtran at 1-800-993-7686.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V195000 on 05/27/2003
- Component:
- Structure:body:roof and pillars
- Manufactured:
- 12/13/2000 - 05/20/2001
- Affected:
- 13
- Defect:
- Certain school buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." these buses do not comply with the emergency exit requirements.
- Consequence:
- During an emergency situation, this condition could prevent passengers from exiting the bus, which could cause personal injury or death.
- Correction:
- Dealers will add one roof exit in the center of the passenger compartment. all owners have been notified and arrangements made to remedy their buses.
- Notes:
- Ic recall no. 03302.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V354000 on 01/14/2004
- Component:
- Structure:body
- Manufactured:
- 05/31/2000 - 05/24/2001
- Affected:
- 66,749
- Defect:
- Ce model school buses which fail to comply to federal motor vehicle safety standard no. 221, school bus body joint strength. the roof top sheet may be improperly located, reducing the material edge distance at the rivet line.
- Consequence:
- In the event of a vehicle crash, the joint strenght could fail possibily resulting in injuries to the vehicle occupants.
- Correction:
- Ic will notify its customers and will provide inspection and repair instruction. the recall began on january 25, 2005. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic customer service at (we do not yet have a telephone number for this campaign.)
- Notes:
- Ic recall no. 03305.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V010000 on 01/14/2004
- Component:
- Structure:body
- Manufactured:
- 05/31/2000 - 05/23/2001
- Affected:
- 7,321
- Defect:
- Certain fe model school buses manufactured from october 14, 1991, and march 4, 2003. a gap between the modesty panel and the wheel well located behind the driver's seat can be created if the panel is bent out of position. under the panel, the edges are sharp and jagged.
- Consequence:
- Should someone reach under the panel, they could cut thier hands, fingers, or toes on the jagged edges.
- Correction:
- Ic will notify its customers and repair the panel free of charge. owner notification is expected to begin january 20, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic corporation compliance department toll-free at 1-800-843-5615. customers can locate the nearest dealer by calling 1-800-993-7686.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V469000 on 09/23/2004
- Component:
- Equipment adaptive
- Affected:
- 1,220
- Defect:
- Certain my 2001-2005 amtran/ic corporation ce, fe, and re school buses equipped with sure-lok wheelchair tie-down securement assemblies p/n 8625-13. the sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
- Consequence:
- In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
- Correction:
- Sure-lok will notify ic's customers and repair the buses on ic's behalf at no cost to the customer. the recall began august 16, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact sure-lok at 1-908-231-1804.
- Campaign:
- 04V498000 on 10/14/2004
- Component:
- Seats
- Manufactured:
- 07/19/2000 - 07/20/2000
- Affected:
- 154
- Defect:
- Certain 1998, 2000-2005 my ce, fe, and re school buses built with one or more ce white 30-inch child restraint seats and manufactured between march 25, 1998 and august 24, 2004. the seat cushion retention may not retain the seat in all circumstances.
- Consequence:
- In the event of a sudden stop, the seat cushion may tip forward and may become unattached causing the passenger to slide off the seat and/or be trapped by the seat cushion. this action could possibly result in personal injury or death.
- Correction:
- Ic corp will notify its customers and will repair the cushion by adding a clip to the cushion tying it to the seat frame. the recall began on october 5, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic compliance department at 1-800-843-5615.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V492000 on 10/14/2004
- Component:
- Seats
- Manufactured:
- 06/02/2000 - 05/25/2001
- Affected:
- 8,165
- Defect:
- Certain fe school and commercial buses built with ce white driver seats with a pedestal style mount and manufactured between january 10, 1992 through february 24, 2004. these pedestals can develop cracks rendering the seat unstable.
- Consequence:
- In the event of a vehicle crash, the seat could separate from the base, possibly resulting in personal injury or death.
- Correction:
- Ic will notify its customers and repair the seat by replacing the upper portion of the assembly with a more robust design. the recall began june 3, 2005. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic compliance department at 1-800-843-5615.
- Notes:
- Ic predicts parts will be available in the second week of may 2005.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Home | Privacy