2000 THOMAS MVP ER Recalls (12)
- Campaign:
- 00V232002 on 08/08/2000
- Component:
- Service brakes, air:antilock
- Manufactured:
- 02/12/1998 - 08/02/2000
- Affected:
- 35,405
- Defect:
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence:
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
- Correction:
- Dealers will replace the abs ecu.
- Notes:
- Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V362000 on 11/05/2000
- Component:
- Seats
- Manufactured:
- 03/31/1996 - 09/29/2000
- Affected:
- 6,500
- Defect:
- Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. a bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. this bracket is located at the top of the height adjuster.
- Consequence:
- If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- Correction:
- Dealers will replace the seat base and add reinforcement to the seat assembly
- Notes:
- Owner notification began february 9, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built atalso contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V232011 on 11/28/2000
- Component:
- Service brakes, air:antilock
- Manufactured:
- 02/12/1998 - 08/02/2000
- Affected:
- 4,780
- Defect:
- Vehicle description: school bus chassis and emergency vehicles built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence:
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
- Correction:
- Dealers will replace the abs ecu.
- Notes:
- Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V105000 on 03/28/2001
- Component:
- Service brakes, air:supply:low pressure warning
- Manufactured:
- 09/30/2000 - 02/27/2001
- Affected:
- 153
- Defect:
- Vehicle description: certain school buses fail to comply with requirements of fmvss no. 121, "air brake systems." these vehicles do not comply due to the low air warning system detecting pressure in only one reservoir system and not both as required.
- Consequence:
- This does not meet the standard.
- Correction:
- Dealers will correct the low air pressure switch wiring. owner notification began july 27, 2001. owner notification is expected to begin owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-881-7219.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V097009 on 07/02/2001
- Component:
- Seat belts:front:buckle assembly
- Manufactured:
- 08/06/2000 - 08/17/2000
- Affected:
- 129
- Defect:
- Vehicle description: school and transit buses equipped with safety belt assemblies produced by am-safe. on some seat belts, the buckle and connector may unlatch during a collision.
- Consequence:
- Serious injury or death could occur if the vehicle occupant is not properly restrained.
- Correction:
- Am-safe notified thomas built's customers to return their vehicle to an authorized dealer to have the seat belts repaired free of charge. owner notification began september 21, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-889-4871.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V085000 on 03/25/2002
- Component:
- Engine and engine cooling:cooling system:fan
- Manufactured:
- 05/12/1995 - 03/19/2001
- Affected:
- 4,800
- Defect:
- On certain school buses, misalignment of the fan drive system components can cause premature belt and pulley bearing wear.
- Consequence:
- If the school bus is disabled by a cooling system failure and is stalled on the side of the road, an increased risk of a crash resulting in injury to a school bus occupant could occur.
- Correction:
- Dealers will replace the fan belt, idler pulley, and belt tensioner and the pulley's laser will be aligned. owner notification began june 10, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V221000 on 08/13/2002
- Component:
- Wheels:lugs/nuts/bolts
- Manufactured:
- 05/31/1999 - 03/06/2002
- Affected:
- 15
- Defect:
- On certain school and transit buses, the wheel lug nut may not tighten completely.
- Consequence:
- The wheel could loosen increasing the risk of loss of control of the vehicle.
- Correction:
- Dealers will install new wheel studs. owner notification began february 28, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V160009 on 01/16/2003
- Component:
- Seat belts
- Manufactured:
- 08/16/2000 - 03/13/2001
- Affected:
- 2,371
- Defect:
- On certain school or transit buses with passenger seat belts with retractors, the cover halves for the retractable portion of the belt can separate completely and release the seat belt connector. if this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. in the event of a crash, the seat occupant would not be properly restrained resulting in an injury. the seat belt supplier, amsafe, will provide a snap on "over-cover" to owners to prevent the seat belt cover from separating.
- Consequence:
- If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. in the event of a crash, the seat occupant would not be properly restrained resulting in an injury.
- Correction:
- Dealers will provide a plastic outer cover that snaps over the existing cover on units in the field and will replace broken seat belts free of charge. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-841-5924 or amsafe at 574-266-8330.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V205000 on 05/05/2005
- Component:
- Fuel system, diesel
- Manufactured:
- 11/30/1997 - 01/30/2003
- Affected:
- 16,000
- Defect:
- Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. the fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
- Consequence:
- Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
- Correction:
- Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. owners may contact cummins at 1-800-diesels.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07V137000 on 03/22/2007
- Component:
- Service brakes, air
- Manufactured:
- 04/22/2000 - 11/13/2003
- Affected:
- 3,000
- Defect:
- Certain my 2000 through 2003 thomas built hdx and mvp-er school buses manufactured between april 23, 2000, and november 14, 2003. the service air brake pedal, for both non-adjustable and adjustable brake pedals, may contact the front structure on the bus, limiting the maximum brake force available.
- Consequence:
- Insufficient air brake pressure may cause extended stopping distances without prior warning, possibly resulting in a vehicle crash.
- Correction:
- Thomas built will notify owners and repair the affected buses free of charge. the recall began on september 14, 2007. owners can contact thomas built at 336-889-4871 or contact freightliner at 800-547-0712.
- Notes:
- Freightliner recall no. fl-493.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08V087000 on 02/26/2008
- Component:
- Structure:body:door:hinge and attachments
- Manufactured:
- 12/31/1993 - 03/09/2008
- Affected:
- 243,435
- Defect:
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. continued corrosion and pitting weakens the handle. handles weakened by corrosion may break while trying to open the door from the exterior.
- Consequence:
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- Correction:
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. repairs will be performed by thomas built buses dealerships. the recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. owners may contact thomas built at 336-889-4871.
- Notes:
- Daimler trucks recall no. fl-525.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08V356000 on 07/29/2008
- Component:
- Engine and engine cooling
- Manufactured:
- 06/07/1995 - 02/15/2001
- Affected:
- 3,773
- Defect:
- Daimler trucks is recalling 3,773 my 1996 through 2002 thomas built mvp er school buses manufactured from june 8, 1995 through february 16, 2001, equipped with caterpillar 3116 and 3126 engines. un-fused power cables were tie-wrapped to a wire braid engine fuel return hose. over time these cables may chafe, wearing through the wire loom and eventually through the cable insulation and fuel line covering in an area not easily detectable during normal maintenance without removing the tie wraps and opening the wire loom. un-fused and un-switched power cables which wear through and contact the fuel line wire braid may short circuit.
- Consequence:
- In the event of a short circuit, a vehicle fire can occur.
- Correction:
- Thomas built will notify owners and inspect and replace the cables as necessary free of charge. the recall is expected to begin on or about november 28, 2008. owners may contact thomas built at 1-336-889-4871.
- Notes:
- Daimler trucks' recall no. fl-534.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Home | Privacy