2000 SATURN LS Recalls (6)

Campaign:
99V197000 on 07/28/1999
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
04/30/1999 - 07/19/1999
Affected:
1,300
Defect:
Vehicle description: passenger vehicles. these vehicles do not comply with requirements of fmvss no. 301, "fuel system integrity." these vehicles may have been produced with an inoperative valve within the fuel tank assembly.
Consequence:
If a vehicle with an inoperative valve were involved in a rollover, fuel spillage could occur.
Correction:
Dealers will inspect the vehicles to ensure that the fuel tank assembly valve is operating as intended. they will replace the fuel tank assembly if necessary.
Notes:
Owner notification began july 23, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saturn at 1-800-553-6000, prompt 3. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V199000 on 07/28/1999
Component:
Exterior lighting:turn signal:switch
Manufactured:
04/30/1999 - 07/19/1999
Affected:
1,395
Defect:
Vehicle description: passenger vehicles. these vehicles do not comply with requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment." because of a problem in the hazard warning switch assembly, the turn signal lamps may not work or may work intermittently when the driver uses the turn signal lever or hazard warning switch. if the vehicle turn signal indicators are not flashing, then the turn signal lamps may not be flashing.
Consequence:
Other drivers may not be alerted that the vehicle is turning and a crash could occur.
Correction:
Dealers will replace the hazard warning switch assembly.
Notes:
Owner notification began july 23, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saturn at 1-800-553-6000, prompt 3. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V345000 on 12/06/1999
Component:
Fuel system, gasoline:storage
Manufactured:
04/30/1998 - 10/30/1999
Affected:
36,848
Defect:
Vehicle description: passenger vehicles. fuel tank assemblies in these vehicles have an over pressure relief (opr) valve that can become stuck open in a frontal collision. if the vehicle rolls over, fuel spillage could occur.
Consequence:
If an ignition source is present, a fire could result.
Correction:
Dealers will permanently seal the outlet port of the opr valve.
Notes:
Owner notification is expected to begin during december 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saturn at 1-800-553-6000, prompt #3.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V228003 on 08/21/2000
Component:
Seat belts
Manufactured:
03/31/2000 - 05/30/2000
Affected:
156,305
Defect:
Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. the buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Consequence:
In the event of a vehicle crash, the occupant may not be properly restrained.
Correction:
Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
Notes:
Owner notification began august 24, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1-800-521-7300; chevrolet at 1-800-222-1020; gmc at 1-800-462-8782; oldsmobile at 1-800-442-6537; pontiac at 1-800-762-2737; or saturn at 1-800-553-6000. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V231000 on 06/22/2003
Component:
Electrical system:ignition:module
Manufactured:
06/10/2002 - 06/11/2003
Affected:
239,993
Defect:
On certain passenger vehicles equipped with 2.2l l4 (l61) engines, a failure of the ignition control module may cause deterioration in idle quality, reduction in overall engine power, and the vehicle may be hard to start. continued operation of the vehicle after such an ignition module failure will result in the "service engine soon" light flashing, and may lead to secondary failures of the catalytic converter, oxygen sensor, and exhaust resonator.
Consequence:
Failure of the resonator will cause increased exhaust noise. prolonged operation of the vehicle following a resonator failure may lead to a fire.
Correction:
Dealers will (1) replace the ignition control module, (2) replace the ignition control module and spark plugs, or (3) replace the ignition control module, spark plugs, and update the powertrain control module calibration. owner notification began on august 4, 2003. owners should contact saturn at 1-800-553-6000, prompt 3.
Notes:
Gm recall no. 03033/saturn recall no. 03-c-06.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V245000 on 06/01/2005
Component:
Exterior lighting:brake lights
Manufactured:
04/30/1999 - 07/30/2000
Affected:
291,652
Defect:
On certain sedans and wagons, the plastic housing in the rear tail lamp assembly can become distorted if the brake lamps remain on for an extended time.
Consequence:
This can cause (1) an intermittently inoperative brake/tail lamp bulb or (2) a short circuit that opens a fuse causing inoperative brake lamps (including the center high-mounted stop lamp) or tail lamps. a following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning.
Correction:
Dealers will install two new tail lamp reinforcing socket adapters and sockets free of charge. the recall began on october 17, 2005. owners may contact saturn at 1-800-972-8876.
Notes:
Gm recall no. 05052.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2000 SATURN LS TSBs (166)

Bulletin:
99T32
Component:
353600 equipment:air conditioner
Summary:
Conditions with a/c system pag oil accumulation at set screw on rear head of a/c compressor. *tt
Bulletin:
95T52B
Component:
162000 structure:body
Summary:
Subject pertaining to bumps or iron dust on paint surface. *tt
Bulletin:
99T59
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Some sedans and wagons may exhibit a wind whistle noise at driver and / or passenger front door glass area(s) from outside rear view mirror(s). *tt
Bulletin:
99T52
Component:
162700 structure:body:trunk lid
Summary:
Service information and installation procedures for trap-resistant trunk kit. *tt
Bulletin:
99T55
Component:
020000 suspension
Summary:
Owners of sedans and wagons may comment regarding a steering wheel shake or vibration at highway speeds. *tt
Bulletin:
92T55D
Component:
162000 structure:body
Summary:
Information regarding cleaning procedures for removal of rubbing compound. *tt
Bulletin:
99T60
Component:
980000 unknown or other
Summary:
Some sedans and wagons built before vin yy618329 may experience a rattle coming from behind the right hand side of the instrument panel. *tt
Bulletin:
99T49
Component:
162300 structure:body:door
Summary:
Some sedans and wagons built before and including vin yy601594 may have a condition with front doors re-locking after being unlocked with the key. *tt
Bulletin:
99T69
Component:
162000 structure:body
Summary:
Customers may comment of rattle noised heard from area of dome lamp, sunroof, or headliner during normal operating conditions. *tt
Bulletin:
00T01
Component:
131000 visibility:windshield
Summary:
A condition may exist where the driver and passenger front door glass binds on and distorts outer window run channel weatherstrips. *tt
Bulletin:
00T04
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Some customers may comment of service wrench telltale on; engine coolant temperature telltale is on; coolant temperature gauge needle is in the red zone; 30a cool fan #1 fuse located in under hood fuse block (uhfb) is open. *tt
Bulletin:
00T07
Component:
136000 visibility:windshield wiper/washer
Summary:
Vehicles may experience windshield wiper chatter or hop across windshield during wiper operation. *mjs
Bulletin:
00T08
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject on (mil) service engine soon telltale on with dtc po333-knock sensor 2 high frequency, engine hesitation, and/or vehicle lacks power. *mjs
Bulletin:
00C09
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject on the inspection and replacement of 4 cylinder engines, if necessary. *mjs
Bulletin:
00T18
Component:
060000 engine and engine cooling
Summary:
Subject on incorrect engine cooling fan operation on low speed and/or increased under hood noise at idle. *mjs
Bulletin:
00T16
Component:
103000 power train:automatic transmission
Summary:
Subject on no. 3rd and 4th gear (replace direct clutch piston assembly). *mjs
Bulletin:
00T17
Component:
980000 unknown or other
Summary:
Vehicle may experience headliner sagging or hanging too low at rear of sunroof opening. *mjs
Bulletin:
00T22
Component:
133000 visibility:power window devices and controls
Summary:
Some customers may comment on inoperative power windows and/or sunroof. *mjs
Bulletin:
OOT21
Component:
162300 structure:body:door
Summary:
Subject on the remote keyless entry (rke) transmitter is inoperative or intermittently inoperative. *mjs
Bulletin:
00T19
Component:
100000 power train
Summary:
Subject on vehicles that have a dead battery after being towed behind a recreational vehicle with all four wheels on the ground. *mjs
Bulletin:
00T36
Component:
133000 visibility:power window devices and controls
Summary:
Some customers may comment that the power lock, power window, speaker, or courtesy lamp is inoperative on the left and / or right rear door. *tt
Bulletin:
00T37
Component:
221600 seats:front assembly:power adjust
Summary:
Vehicles equipped with power driver seats and built before vin yy678353 may exhibit a power seat switch that inadvertently acuates the recliner motor when the driver enters or exits the vehicle. *tt
Bulletin:
00T07A
Component:
136000 visibility:windshield wiper/washer
Summary:
Some customers may comment about the windshield wipers chattering or hopping across the windshield during wiper operation. *tt
Bulletin:
00T50
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit engine hesitation under heavy acceleration or after turning a corner. *tt
Bulletin:
00T40A
Component:
220000 seats
Summary:
Some customers may comment that the driver's seat makes a popping sound when braking, accelerating, or moving in the seat. *tt
Bulletin:
00T37A
Component:
221600 seats:front assembly:power adjust
Summary:
Some customers may comment that the power driver seat recliner is inadvertently actuated when the driver enters or exits the vehicle. *tt
Bulletin:
00T17A
Component:
162000 structure:body
Summary:
Some customers may comment about the headliner sagging or hanging too low at the rear of the sunroof opening. *tt
Bulletin:
00T70
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Customers may comment the service engine soon lamp is illuminated and / or the transaxle shifts are harsh or erratic. *tt
Bulletin:
01T02
Component:
980000 unknown or other
Summary:
Some customers may comment that the malfunction indicator lamp (mil) service engine soon is illuminated and diagnostic trouble code (dtc) p0440 or dtc p0455 has been stored. *tt
Bulletin:
00T32A
Component:
106000 power train:axle assembly
Summary:
Some customers may comment the service wrench lamp illuminated and no driveabilty symptoms were present. *tt
Bulletin:
99T69A
Component:
162000 structure:body
Summary:
Experiencing rattle noises heard from the area of dome lamp, sunroof, or headliner during normal operating conditions. *tt
Bulletin:
99T52A
Component:
350000 equipment
Summary:
The purpose of this bulletin is to inform saturn retailer personnel of the system function and procedure used to install the trap-resistant trunk kit. *tt
Bulletin:
00T47
Component:
138000 visibility:defroster/defogger system
Summary:
Some vehicles built before and including vin yy649000 may exhibit a hvac blower motor that operates on high fan speed only. *tt
Bulletin:
99T55A
Component:
020000 suspension
Summary:
Some customers may comment regarding a steering wheel shake or vibration felt when driving vehicle at highway speeds. *tt
Bulletin:
01T13
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment about the engine cranks but will not start and / or the engine starts and then stalls. *tt
Bulletin:
01T14
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment about the engine running rough at idle after a cold engine start in ambient temperatures between 10 degrees - 30 degrees celsius (50 degrees - 85 degrees fahrenheit. *tt
Bulletin:
01T23
Component:
116000 electrical system:ignition
Summary:
Some customers may comment tht the ignition key will not turn out of the lock position. *tt
Bulletin:
01T32
Component:
980000 unknown or other
Summary:
Some customers may comment of poor remote keyless entry (rke) range while trying to lock or unlock vehicle(s) up to and including vin 1y570729. *tt
Bulletin:
01T34
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Information on front brake rotor minimum thickness after refinish and discard thickness specifications. *tt
Bulletin:
01T32
Component:
980000 unknown or other
Summary:
Vehicles equipped with remote keyless entry up to and including vin 1y570729 may experience poor remote keyless entry (rke) transmitter range. *tt
Bulletin:
00T41A
Component:
162000 structure:body
Summary:
Some customers may comment about water leaking into the passenger compartment and / or rear compartment / rear cargo area. *tt
Bulletin:
01T06A
Component:
162000 structure:body
Summary:
Concerns that the rear fascia to quarter panel is not correctly aligned. *tt
Bulletin:
00T17B
Component:
980000 unknown or other
Summary:
Some customers may comment about the headliner sagging orh anging too low at the rear of the sunroof opening. *tt
Bulletin:
99T36A
Component:
162000 structure:body
Summary:
Customers may comment about a rattle type noise that seems to be coming from rear of vehicle when traveling over rough road surfaces. *tt
Bulletin:
99Y69N
Component:
162000 structure:body
Summary:
Experiencing rattle noises heard in area of dome lamp, sunroof, orheadliner duringnormal operating conditions. *tt
Bulletin:
01T16
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment about intermittent click / tick noise coming from engine compartment. *tt
Bulletin:
01T39
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding redesigned oil filter element and oil filter cap. *tt
Bulletin:
01T39
Component:
162000 structure:body
Summary:
Service manual update for 2000 and 2001 l-series body electrical volume i and volume ii service manuals regarding inner door pullhandle removal. *tt
Bulletin:
00T17B
Component:
162000 structure:body
Summary:
Customers may complain of headliner sagging or hanging too low at the rear of the sunroof opening. *slc
Bulletin:
00T41A
Component:
162000 structure:body
Summary:
Customers may complain of water leaking into the passenger compartment and/or rear compartment cargo area. *slc
Bulletin:
01T06A
Component:
162200 structure:body:bumpers
Summary:
Customers may complain that the rear fascia to quarter panel is not correctly aligned. *slc
Bulletin:
99T36A
Component:
022000 suspension:rear
Summary:
Customers may complain of a rattle type noise that seems to be coming from rear of vehicle when traveling over rough road surfaces. *slc
Bulletin:
99T69B
Component:
980000 unknown or other
Summary:
Some customers may complain of rattle noises heard in area of dome lamp, sunroof, or headliner during normal operating conditions. *slc
Bulletin:
01T39
Component:
980000 unknown or other
Summary:
Service manual revision on body electrical volume i and volume ii. *slc
Bulletin:
01T40
Component:
980000 unknown or other
Summary:
Information regarding 1st and 2nd design oil filter elements and oil filter caps available for the 4 cylinder engine and how to determine which oil filter and cap combination should be used. *slc
Bulletin:
01T34
Component:
980000 unknown or other
Summary:
Information regarding front brake rotor minimum thickness after refinish and discard thickness specificatons. *slc
Bulletin:
01T45
Component:
980000 unknown or other
Summary:
Subject regarding front and rear suspension torque specifications. *jg
Bulletin:
00T30A
Component:
221600 seats:front assembly:power adjust
Summary:
The driver's side 6-way power seat functions are inoperative. *jg
Bulletin:
01T48
Component:
174200 latches/locks/linkages:hatchback/liftgate:lock
Summary:
Subject regarding liftgate wiring harness connector. *jg
Bulletin:
01T53
Component:
353600 equipment:air conditioner
Summary:
Subject regarding odor from the air conditioner outlets at vehicle start up. *jg
Bulletin:
01T58
Component:
103000 power train:automatic transmission
Summary:
Service manual regarding solenoid circuit schematic, input speed sensor performance, and input speed sensor circuit low voltage schematics. *jg
Bulletin:
00T44A
Component:
980000 unknown or other
Summary:
Information on malfunction indicator lamp service engine soon telltale coming on.*jb
Bulletin:
01T53
Component:
353600 equipment:air conditioner
Summary:
Information regarding an odor from air conditioner outlets at vehicle start up. *jb
Bulletin:
00T66A
Component:
060000 engine and engine cooling
Summary:
Information regarding engine oil leaks and/or engine coolant leaks, on v-6 engines.*jb
Bulletin:
01T48
Component:
174200 latches/locks/linkages:hatchback/liftgate:lock
Summary:
Information on a new design liftgate lock cylinder case connector that does not mate with existing liftgate wiring harness connector.*jb
Bulletin:
00T66A
Component:
060000 engine and engine cooling
Summary:
Information regarding engine oil leaks and or engine coolant leaks. *yh
Bulletin:
00T17C
Component:
134000 visibility:sun roof assembly
Summary:
Some customers may comment about the headliner sagging or hanging too low at the rear of the sunroof opening. *jg
Bulletin:
00T44A
Component:
980000 unknown or other
Summary:
Some customers may complain about the service engine soon telltale and/or the reduced power telltale coming on. *jg
Bulletin:
00T17C
Component:
980000 unknown or other
Summary:
Subject regarding headliner sags or hangs too low at rear of sunroof opening. *yd
Bulletin:
02T17
Component:
980000 unknown or other
Summary:
Information on service engine soon lamp illuminated.*jb
Bulletin:
99T55B
Component:
010000 steering
Summary:
Some vehicles may experience steering wheel shake or vibration at highway speeds.*jb
Bulletin:
02C07
Component:
100000 power train
Summary:
Subject regarding inaccurate odometer reading after loss of battery power.*jb
Bulletin:
02T22
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding whistle noise under certain engine operating conditions.*jb
Bulletin:
02T27
Component:
131000 visibility:windshield
Summary:
Customers may complain of rear door glass being inoperative or operates erractically.*jb
Bulletin:
02T05
Component:
220000 seats
Summary:
Service manual update regarding front seat cushion cover/pad removal and installation. *slc
Bulletin:
02T06
Component:
021000 suspension:front
Summary:
Service manual update for chassis service manuals regarding front strut assembly procedure. *slc
Bulletin:
02T06
Component:
021000 suspension:front
Summary:
Subject regarding service manual update for chassis service manuals regarding front strut assembly procedure. *slc
Bulletin:
02T16
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Service information regarding design change to thermostat housing, thermostat housing bolts, and thermostat housing o-ring seal. *tt
Bulletin:
02T26
Component:
111100 electrical system:battery:cables
Summary:
The purpose of this bulletin is to provide new positive and negative battery cable replacement procedures. *tt
Bulletin:
02C07
Component:
110000 electrical system
Summary:
Subject regarding inaccurate odometer reading after loss of battery power. *jg
Bulletin:
02T22
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding whistle noise under certain engine operating consitions. *jg
Bulletin:
02T43
Component:
106000 power train:axle assembly
Summary:
Subject regarding service manual update for transaxle service manuals regarding new differential ring gear replacement procedure. *jg
Bulletin:
02T26
Component:
980000 unknown or other
Summary:
Subject regarding service manual update for engine service manuals regarding new positive and negative battery cable replacement procedures. *jg
Bulletin:
02T27
Component:
162300 structure:body:door
Summary:
Some consumers may complain that the rear door glass is inoperative or displays erratic operation. *jg
Bulletin:
02T35
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding service manual update for engine service manuals regarding balance shaft timing procedure. *jg
Bulletin:
02T37
Component:
062000 engine and engine cooling:cooling system
Summary:
Subject regarding service information on new oil cooler cover sealant. *jg
Bulletin:
02T39
Component:
138000 visibility:defroster/defogger system
Summary:
Subject regarding installation procedures for standard hvac controller with 3rd mounting boss. *jg
Bulletin:
02T40
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding service manual update for engine service manuals regarding evaporative emission (evap) system flowchart. *jg
Bulletin:
02T44
Component:
106000 power train:axle assembly
Summary:
Subject regarding service information regarding new design line pressure control solenoids. *jg
Bulletin:
02T48
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding mass air flow sensor failure due to oil contamination of sensor membrane (install new mass air flow (maf) sensor and update electronic control module calibration) *jg
Bulletin:
02T46
Component:
015000 steering:hydraulic power assist system
Summary:
Service information regarding power steering system noise and/or leak diagnosis. *jg
Bulletin:
02T62
Component:
136000 visibility:windshield wiper/washer
Summary:
Service information regarding redesigned wiper linkage and new service procedures. *jg
Bulletin:
02T42
Component:
162000 structure:body
Summary:
Subject regarding squeak, rattle and poor fit from defroster grille (install redesigned defroster grille) *jg
Bulletin:
99T55C
Component:
020000 suspension
Summary:
Some consumers may complain about a steering wheel shake or vibration felt when driving vehicle at highway speeds. this condition is most noticeable on smooth road surfaces at vehicle speeds above 65mph (105 km/h) *jg
Bulletin:
00T72A
Component:
022000 suspension:rear
Summary:
Subject regarding service manual update for chassis service manualss regarding alignment specifications and service procedure for installation of spacers between rear suspension support and vehicle body when performing wheel alignment. *jg
Bulletin:
02T86
Component:
062000 engine and engine cooling:cooling system
Summary:
Service information regarding elimination of auxiliary water pump and instructions to install 2nd design heater inlet hose and heater inlet elbow in place of the 1st design water pump and heat inlet hose. *tt
Bulletin:
02T77
Component:
015000 steering:hydraulic power assist system
Summary:
Whistle noise from power steering while turning left. *tt
Bulletin:
02T84
Component:
330000 interior lighting
Summary:
Service wrench lamp illuminated with diagnostic trouble code p1811 maximum adapt and long shifts. *tt
Bulletin:
02T86
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding elimination of auxiliary water pump and instruments to install 2nd design heater inlet hose and heater inlet elbow in place of the 1st design water pump and heater inlet hose. *tt
Bulletin:
03T03
Component:
220000 seats
Summary:
Loose or torn seat covers. *tt
Bulletin:
030853001
Component:
162000 structure:body
Summary:
Defroster grille popping noise encountered during cold temperatures. *tt
Bulletin:
030844007
Component:
353000 equipment:electrical
Summary:
Information for concerns on noise heard through the audio system when another electrical component is activated or used. *tt
Bulletin:
030604016
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding the engine control module (ecm) connector and terminal locations on saturn v6 engines. *tt
Bulletin:
030601014
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update regarding the use of saturn special tool j-42065 crank hub holding tool. *tt
Bulletin:
030601015
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update for removal of the sealer used on oil pump gasket during oil pump installation. *tt
Bulletin:
030138007
Component:
060000 engine and engine cooling
Summary:
Service information regarding elimination of front auxiliary water pump and instructions to install elbow in place of pump. *tt
Bulletin:
030731004
Component:
100000 power train
Summary:
Bleeding procedure for hydraulic clutch release system including clutch actuator cylinder. *tt
Bulletin:
030601017
Component:
061000 engine and engine cooling:engine
Summary:
Timing chain design change and revised service procedures. *tt
Bulletin:
030601019
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update - revised engine torque specification table. *tt
Bulletin:
990091002D
Component:
020000 suspension
Summary:
Steering wheel shake or vibration at highway speeds. *tt update. *tt
Bulletin:
030844017
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Changes to the am/fm stereo and audio disc player radio on-board diagnostic modes and cd load operation. *tt
Bulletin:
030604043
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) service engine soon telltale lamp on, reduced power lamp may illuminate with diagnostic trouble codes p0121, p0221, and/or p2135. *tt
Bulletin:
030856002
Component:
110000 electrical system
Summary:
Intermittent security telltale illumination and/or diagnostic trouble code b2960. *tt
Bulletin:
030843005
Component:
136000 visibility:windshield wiper/washer
Summary:
Little or no windshield solvent coming from washer nozzles. *tt
Bulletin:
030089033A
Component:
980000 unknown or other
Summary:
Trailer, recreational and disabled vehicle towing information. *tt *sc
Bulletin:
030089032
Component:
980000 unknown or other
Summary:
Recreational and disabled vehicle towing information. *tt
Bulletin:
030232045
Component:
010000 steering
Summary:
Moan or groan noise when turning steering wheel at low speeds. *tt
Bulletin:
030090003
Component:
061000 engine and engine cooling:engine
Summary:
Oil filter cap assembly and oil filter element design change. *tt
Bulletin:
030089025
Component:
980000 unknown or other
Summary:
Clarification of labor codes used for reprogramming vehicle controllers. various models including the 2004 l-series. *tt
Bulletin:
030524001
Component:
034410 service brakes, hydraulic:foundation components:drum:wheel cylinders
Summary:
Service information regarding saturn rear drum wheel cylinder inspections. *tt update. *tt
Bulletin:
030849022A
Component:
090000 fuel system, other
Summary:
Fuel gauge displays an erratic or false reading or no start condition after vehicle is shut off with low fuel level. *tt this bulletin replaces previous dated 12/01/03. *tt this bulletin replaces previous dated 08/01/04. *tt
Bulletin:
030844016A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Compact discs (cds) skip in single cd player. *tt
Bulletin:
040842001
Component:
121000 exterior lighting:headlights
Summary:
Information on intermittent dimming (flickering) of headlamps and/or instrument panel lighting-normal characteristic. this may occur because of transient current loads on the electrical system during normal vehicle operation. *mn
Bulletin:
040601004
Component:
061000 engine and engine cooling:engine
Summary:
Service information regarding engine support during removal of right front engine mount assembly. *tt
Bulletin:
040604008
Component:
060000 engine and engine cooling
Summary:
Service engine soon (ses) lamp illuminated with dtc p0135 ho2s heater circuit performance bank 1 sensor 1 and/or dtc p0155 ho2s heater performance bank 2 sensor 1. *mr this bulletin replaces previous 04-06-04-008. *eh
Bulletin:
040089012
Component:
980000 unknown or other
Summary:
Saturn field product reminder- vehicle fix it right the first time issues, parts restriction information and technical bulletins released in january, february, and march 2004. *mr
Bulletin:
040601009
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak from front cover seal during extremely cold weather. *tt
Bulletin:
040601010
Component:
061000 engine and engine cooling:engine
Summary:
Blue smoke at engine start-up. *tt
Bulletin:
040601011
Component:
061000 engine and engine cooling:engine
Summary:
Service manual update for engine block clearance, cylinder head clearance and fastener torque specifications. *tt
Bulletin:
040235008
Component:
010000 steering
Summary:
Clunk noise from front of vehicle during turning maneuver/steering wheel rotation. *tt
Bulletin:
040137005
Component:
353600 equipment:air conditioner
Summary:
Information regarding air conditioning (a/c) compressor noise at engine start (a/c or defrost mode selected) or at a/c or defrost activation (after engine start). *tt
Bulletin:
040844015
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Return form for compact discs (cds) or digital versatile discs (dvds) that are stuck in cd player when returned as a core return. *tt
Bulletin:
3036
Component:
162900 structure:body:roof and pillars
Summary:
Dark rectangles or circles in the center of the roof. *tt
Bulletin:
3037
Component:
190000 tires
Summary:
Thump noise/vibration/flat spotted tires on vehicle. *tt
Bulletin:
3120
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Aux coolant pump will not connect to replacement radiator. *sc
Bulletin:
3119
Component:
980000 unknown or other
Summary:
No selection fir saturn when programming a saturn vehilcle. *sc
Bulletin:
3135
Component:
060000 engine and engine cooling
Summary:
Pop noise from engine area during heavy throttle input. *tc
Bulletin:
3099
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Routing the longer tuned power steering hose per tsb 03-02-32-045. *sc
Bulletin:
010604016
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) telltale illuminated with diagnostic trouble codes (dtcs) p0171, p0172, p0174 and/or p0175. *tt
Bulletin:
040604085
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon (ses) and/or reduced power lamp illuminating following cold engine start up in subfreezing temperatures, diagnostic trouble codes (dtc) p0638, p1510 and/or p1516 stored in engine control module (ecm). *tt
Bulletin:
3295
Component:
106000 power train:axle assembly
Summary:
Service wrench and ses telltale may be illuminated and transaxle may shift harshly. *eh
Bulletin:
3419
Component:
116000 electrical system:ignition
Summary:
Ignition key will not rotate back to off position or shift lever will not move out of park. *tt
Bulletin:
020232009
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering system noise and/or leak diagnosis. *tt
Bulletin:
03-00-89-033
Component:
980000 unknown or other
Summary:
Trailer, recreational and disabled vehicle towing information. *kb updated 08-15-07. *kb updated 10/09/07. *nj updated 4/3/08. *nj
Bulletin:
000310006
Component:
020000 suspension
Summary:
Information on tire radial force variation (rfv). 2008 and prior gm passenger cars and light duty trucks including 2008 and prior hummer h2, h3 and 2005-08 saab 9-7x and 2000-05 saturn l series and 2003-07 saturn ion. *kb updated 4/1
Bulletin:
070730025
Component:
103000 power train:automatic transmission
Summary:
Information on 4t40-e (mn4) and 4t45-e (mn5) front wheel drive automatic transmission valve body reconditioning, dtc p0741, p0742, p0751, p0752, p0756, p0757, p1811, harsh shifts, slips, no drive, no reverse. *nj
Bulletin:
SB-00-03-10-006C
Component:
190000 tires
Summary:
General motors: information on tire radial force variation. vehicle must be driven before measuring tires on equipment hunter gsp9700 toensure removal of any flatspotting. models include all gm passenger cars and light trucks, as well as
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
SB-10-08-50-003B
Component:
221300 seats:front assembly:head restraint
Summary:
General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIP5226A
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIC5491J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have an onstar system that will not power up. technician should turn off the ignition and cancel retained accessory power. after the vehic
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIT3099P
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIC5588D
Component:
118000 electrical system: software
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
99-04-20-002H
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides a revision of 99-04-20-002g to add 2013-2014 model years.
Bulletin:
13-00-89-005
Component:
355200 equipment:other:owners/service/other manual
Summary:
This technical bulletin provides warranty administration - new labor codes information.

Home | Privacy