2000 MAZDA B-SERIES TRUCK Recalls (3)

Campaign:
00T005000 on 08/09/2000
Component:
Tires:tread/belt
Affected:
14,400,000
Defect:
Tire description: firestone wilderness at, size p235/75r15, produced at the decatur, illinois tire plant and all firestone radial atx and radial atx ii tires, size p235/75r15. operation of these tires at low inflation pressures, high speed, and in hot weather, can contribute to separation of the tire tread.
Consequence:
If the tread separates from the tire, the driver can lose control of the vehicle, possibly resulting in a crash causing injury or death.
Correction:
The replacement/reimbursement program for this campaign expired on august 29, 2001. however, customers should contact firestone customer service at 1-800-465-1904 for possible assistance.
Campaign:
00V228002 on 08/21/2000
Component:
Seat belts
Manufactured:
05/02/2000 - 05/15/2000
Affected:
460
Defect:
Vehicle description: light duty trucks equipped with trw seat belt buckle assemblies. the buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Consequence:
In the event of a vehicle crash, the occupant may not be properly restrained.
Correction:
Dealers will inspect the buckle assemblies to determine whether the buckle assembly build date codes are within the suspect range. those within the suspect date code range will be replaced.
Notes:
Owner notification began december 27, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mazda at 1-800-222-5500. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07V347000 on 08/07/2007
Component:
Vehicle speed control
Manufactured:
04/03/1997 - 12/09/2002
Affected:
76,000
Defect:
On certain trucks equipped with a speed control system, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. an interim notice was sent to owners on september 7, 2007, directing them to have the speed deactivation control switch disconnected temporarily. a second notification letter to owners was in february 2008 advising them to return to dealers for installation of the repair part. owners of affected vehicles who did not receive a phase 2 notice and have not had the recall completed will be notified beginning august 6, 2008. owners may contact mazda at 1-800-222-5500.
Notes:
Mazda recall no. 4707h.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2000 MAZDA B-SERIES TRUCK TSBs (75)

Bulletin:
01799
Component:
136000 visibility:windshield wiper/washer
Summary:
On vehicles with manufacture dates before 9/16/99 may have windshield wipers that operative while switch is in off position. *tt
Bulletin:
00299
Component:
020000 suspension
Summary:
Some vehicles with rear gawr of 2600 or 2750 may have a low sitting appearance in the rear. *tt
Bulletin:
00300
Component:
353600 equipment:air conditioner
Summary:
Subject regarding air conditioner accumulator replacement criteria when repairing the air conditioner system. *tt
Bulletin:
00500
Component:
060000 engine and engine cooling
Summary:
Exhibiting a temperature gauge fluctuation and / or a knocking / thumping noise in the passenger compartment on some vehicles. *tt
Bulletin:
000401
Component:
138000 visibility:defroster/defogger system
Summary:
Customer may complain that the heater and / or air conditioner switch from panel vent mode to defrost mode at wide oen throttle on vehicles built before nov. 15, 1999. *tt
Bulletin:
000401
Component:
015100 steering:hydraulic power assist:pump
Summary:
Information on replacing and removing the power steering pump. *tt
Bulletin:
00300
Component:
102000 power train:manual transmission
Summary:
Some vehicles with manual transmission built before 11/1/99, may exhibit a grinding and / or buzzing noise or a notchy feeling during the 2-3 upshift. *tt
Bulletin:
01100R
Component:
180000 vehicle speed control
Summary:
Some vehicles with manual transmissions may exhibit a high idle. this may be caused by a poor electrical connection at the wire harness to the throttle position sensor (tps). a service kit is available to resolve this concern. *tt
Bulletin:
181000
Component:
980000 unknown or other
Summary:
2000 service bulletin index. *tt
Bulletin:
00500R
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles may exhibit a transmission fluid leak between the radiator transmission oil cooler and the radiator transmission oil cooler fitting. *tt
Bulletin:
00600
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some 4x4 models may have a vibration at high speeds which may cause the transmission extension housing to leak or the transmission extension housing bushing to move out of position or become damaged. *tt
Bulletin:
01700
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a spark knock sound or ping type noise during acceleration. *tt
Bulletin:
00500
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a transmission leak between the radiator transmission oil cooler and the radiator transmission oil cooler fitting. *jb
Bulletin:
00300R
Component:
102000 power train:manual transmission
Summary:
Some vehicles may exhibit manual transmission grinding and / or buzzing noise or a notchy feeling during the 2-3 upshift. *jb
Bulletin:
0100801
Component:
110000 electrical system
Summary:
Some vehicles built prior to january 2, 2001 may exhibit rough idle, anti-lock brake system (abs) warning lamp illumination, inoperative or erratic speedometer, diagnostic trouble code (dtc) p0500, p0501, p0503, p1721, p0176, p1000, abs dtc
Bulletin:
0900301
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles built between january 1998 and february 1, 2001 may exhibit a chatter or binding condition when operating the power side window(s) in the down or up mode. *tt
Bulletin:
0300401R
Component:
105000 power train:driveline
Summary:
Subject regarding troy lee - driveline thump/bump noise. *jg
Bulletin:
0300301
Component:
106000 power train:axle assembly
Summary:
Subject regarding squealing/whistle noise from front axle area. *jg
Bulletin:
0302201R
Component:
020000 suspension
Summary:
Subject regarding thumping noise/ bumping sensation. *jg
Bulletin:
0101701
Component:
116000 electrical system:ignition
Summary:
Subject regarding spark knock/ping noise during acceleration. *jg
Bulletin:
0800201
Component:
151600 seat belts:front:warning light/devices
Summary:
Subject regarding belt minder disabling / enabling procedures. *tt
Bulletin:
0100302
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding recommended engine oil. *slc
Bulletin:
0100402
Component:
070000 fuel system, gasoline
Summary:
Subject regarding diagnostic information of oxygen sensor, catalyst efficiency and fuel system monitors. *slc
Bulletin:
0500401
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a delay or slipping 1-2 upshift during light throttle, vehicles built from 01-aug-1999 to 31-jul-2000 with automatic transmissions. *slc
Bulletin:
0901501
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject regarding a whining/buzzing noise from radio speakers. *slc
Bulletin:
0600102
Component:
011000 steering:wheel and handle bar
Summary:
Clicking noise while turning the steering wheel. *tt this bulletin replaces previous bulletin 06-001-02 dated 6/18/2002. *tt
Bulletin:
0101802
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil leak at pan after gasket replacement. *tt
Bulletin:
0300102
Component:
105500 power train:driveline:differential unit
Summary:
Clunking or grunting noise heard from the driveline during acceleration and / or braking on 1999 - 2002 troy lee and truck dual sport cab-plus models. *tt
Bulletin:
0500402
Component:
101000 power train:clutch assembly
Summary:
Service bulletin regarding a hooting, eeking, or moaning noise coming from the clutch when shifting into gears, while the engine is running. *tt
Bulletin:
010102
Component:
105500 power train:driveline:differential unit
Summary:
Information on driveline thump and bump noise, also mazda truck 2001-2002 dual sprt cab plus.*tt
Bulletin:
0500902
Component:
103000 power train:automatic transmission
Summary:
Automatic tranmission slipping, delayed engagement and diagnostic trouble codes p0732, p0733 or p1762. *tt
Bulletin:
0901202
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding passive anti-theft (pats) diagnostic service tips. *tt
Bulletin:
0901202
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Passive anti-theft (pats) diagnostic service tips. *tt
Bulletin:
0101503
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil leak a pan after gasket replacement. *tt
Bulletin:
0500503
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Transmission fluid in-line filter kit - repeat repairs of transmission - service tips. *tt
Bulletin:
0102603
Component:
061000 engine and engine cooling:engine
Summary:
Spark knock / ping / detonation noise during acceleration. this bulletin also replaces 01-017/00. *tt
Bulletin:
0300303
Component:
100000 power train
Summary:
Thumping noise / bumping sensation accelerating from a stop. this bulletin also supersedes 03-002/01r. *tt
Bulletin:
0902203
Component:
116100 electrical system:ignition:switch
Summary:
Sticking or binding ignition lock cylinder or high effort when turning ignition switch. *tt
Bulletin:
0300303
Component:
105300 power train:driveline:driveshaft
Summary:
4wd-b-series-thumping noise/bumping sensation accerlerating from a stop. *mn *tt
Bulletin:
0103003
Component:
110000 electrical system
Summary:
A malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap light illuminated with dtc p0457. various models including the 2005 tribue and 2004 b-series. *tt
Bulletin:
0100304
Component:
061000 engine and engine cooling:engine
Summary:
3.0l lower engine oil leaks- diagnostic-service tip. *jb tt
Bulletin:
0400170
Component:
190000 tires
Summary:
Wilderness at tire replacement ssp 53. two tire sizes for ssp 53 must now be ordered through the mazda tire program. *tt
Bulletin:
0902604
Component:
353000 equipment:electrical
Summary:
Speedometer replacement procedure. *tt
Bulletin:
0102504
Component:
111000 electrical system:battery
Summary:
Battery test procedure requirements. *tt
Bulletin:
08042004
Component:
980000 unknown or other
Summary:
Dealer notice - service bulletin release - 08/04/2004. *tt
Bulletin:
06012004
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Programmable module installation. ( 2004 mazda b series) *jb
Bulletin:
0800405
Component:
151300 seat belts:front:retractor
Summary:
Safety belt retracts too slowly. mazda including 2006 b-series trucks. *sc
Bulletin:
0300104
Component:
100000 power train
Summary:
Thump / clunk from driveline on light acceleration or when stopping. *tt
Bulletin:
0901703
Component:
114000 electrical system:wiring
Summary:
Electrical - wiring - soldering and crimping repairs - service tip. *tt
Bulletin:
0800306
Component:
140000 air bags
Summary:
Non genuine accessories affect air bag operation. *kb
Bulletin:
00307
Component:
980000 unknown or other
Summary:
Availability of non-required tools. *kb
Bulletin:
SB-09-005-13
Component:
350000 equipment
Summary:
Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
Bulletin:
00-004/12
Component:
060000 engine (pws)
Summary:
Summary to be provided on a future date.
Bulletin:
00-001-13-2748
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
02-001-13-2752
Component:
350000 equipment
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
09-005-13-2781
Component:
350000 equipment
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
Bulletin:
05-002-13-2777A
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
05-002-13-2777
Component:
102400 power train:manual transmission:lubricant
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission.note:'atf m-v (type m5) is not the same fluid as mercon®v or merco
Bulletin:
00-001-13-2748A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
00-004-12-2741
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
00-002-14-2936
Component:
350000 equipment
Summary:
Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
Bulletin:
09-027-14-2935
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
09-034-14-2956
Component:
356000 equipment adaptive
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
Bulletin:
SA-061-17
Component:
117000 digital instrument panel
Summary:
In an effort to achieve a higher level of customer experience and retain the value of mazda's vehicles, mnao warranty operations is© 2017 mazda north american operations, u.s.a. allowing all mazda dealers to utilize a third party, specmo en
Bulletin:
09-035-17-3080
Component:
117000 digital instrument panel
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
Bulletin:
00-001-18-3446
Component:
350000 equipment
Summary:
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
Bulletin:
09-014-18-3443
Component:
160000 structure
Summary:
When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
Bulletin:
09-019-18-3450
Component:
356000 equipment adaptive
Summary:
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
Bulletin:
01-008-18-3451
Component:
111000 electrical system:battery
Summary:
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
Bulletin:
01-009-18-3452
Component:
111000 electrical system:battery
Summary:
The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
Bulletin:
02-006-18-3449
Component:
021300 suspension:front:shock absorber
Summary:
Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
Bulletin:
05-001-18-3453
Component:
100000 power train
Summary:
Always be sure to use the correct automatic transmission fluid when replacing atf. using the wrong atf may cause shift quality complaints or may even damage the transmission. note: atf m-v (type m5) is not the same fluid as mercon®v or merc
Bulletin:
00-003-18-3480
Component:
030000 brakes (pws)
Summary:
Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
Bulletin:
09-034-18-3430
Component:
180000 vehicle speed control
Summary:
In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
Bulletin:
01-016-18-3522
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a

Home | Privacy