2000 FORD FOCUS Recalls (18)

Campaign:
99V346000 on 12/21/1999
Component:
Vehicle speed control
Manufactured:
07/18/1999 - 10/31/1999
Affected:
28,958
Defect:
Vehicle description: passenger vehicles equipped with speed control. the speed control cable end fitting can allow water to enter the speed control servo assembly. if this occurs, corrosion in the servo assembly could develop and cause intermittent speed control operation or prevent the throttle from returning to idle.
Consequence:
A throttle that does not return to idle could result in unexpected acceleration, increasing the risk of a crash.
Correction:
Dealers will replace the speed control cable (with a new cable that incorporates a glass-filled end cap) and inspect the assembly for internal corrosion. servos with evidence of corrosion will also be replaced. owners are advised not to use the speed control until the vehicles are repaired.
Notes:
Owner notification began december 13, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V218000 on 08/10/2000
Component:
Structure:frame and members
Manufactured:
07/18/1999 - 07/30/2000
Affected:
276,500
Defect:
Vehicle description: passenger vehicles. certain vehicles fail to comply with requirements of fmvss no. 201, "occupant protection in interior impact." the resultant hic(d) value at one target location ap1, located on the trim panel at the juncture of the a-pillar and roof side rail, may be greater than design intent.
Consequence:
In the event of a crash, an occupant contacting that location may not be provided the interior impact protection intended.
Correction:
Dealers will remove the left and right side b-pillar and a-pillar trim panels, revise the headliner edge near the tops of the a-pillars to accept the new a-pillar trim panels with their energy absorbing tubes, and install the new a-pillar and the old b-pillar trim panels.
Notes:
Owner notification will be phased.the first mailing will be for the 3-door sedan vehicles and began on november 30, 2000.the second phase is for 4-door sedan and wagon vehicles and will begin on december 29, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V302000 on 10/23/2000
Component:
Vehicle speed control:cables
Manufactured:
03/07/1999 - 02/24/2000
Affected:
28,800
Defect:
Vehicle description: passenger vehicles equipped with speed control and automatic transmission. a speed control cable could have a core wire that is long enough to catch on the sleeve at the throttle body end of the cable during wide-open throttle acceleration.
Consequence:
A throttle that does not return to idle could result in reduced vehicle control and, potentially, a vehicle crash.
Correction:
Dealers will inspect these vehicles and, if necessary, replace the speed control cable. owner notification began october 12, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V303000 on 10/23/2000
Component:
Wheels:lugs/nuts/bolts
Manufactured:
03/04/1999 - 05/04/2000
Affected:
203,700
Defect:
Vehicle description: passenger vehicles. the rear wheel hub retaining nuts can loosen and allow the left rear wheel and brake drum assembly to separate from the vehicle.
Consequence:
This condition could result in a vehicle crash.
Correction:
Dealers will inspect the rear wheel bearings and install a rear wheel retention cap to prevent left rear wheel separation. owner notification began october 12, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V411000 on 12/11/2000
Component:
Electrical system:wiring
Manufactured:
03/07/1999 - 12/14/1999
Affected:
74,500
Defect:
Vehicle description: passenger vehicles. a decklid wire harness can fatigue and develop broken wires in the bend area of the wire harness.
Consequence:
This could result in either a loss of individual lamp functions, or in the case of a short of the broken wires that causes a fuse to open, in the loss of stop lamp or tail lamp function. loss of stop lamp or tail lamp function could increase the risk of a crash.
Correction:
Dealers will replace the decklid wire harness.
Notes:
Owner notification began december 19, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V418000 on 12/17/2000
Component:
Seats:front assembly:recliner
Manufactured:
03/03/1999 - 10/11/2000
Affected:
95,000
Defect:
Vehicle description: station wagons and 3-door vehicles. the subject vehicles have a folding 60/40 second seat that becomes a load floor in the folded position. when the 60% portion of the seat is folded down and a load is applied to the front edge of the load floor, the outboard hinge pivot could disengage from the hinge.
Consequence:
If the seat is then returned to the upright position without re-engaging the hinge pivot, the seat and seat belts may not provide the intended level of performance in the event of a crash.
Correction:
Dealers will install a revised seat back hinge pivot.
Notes:
Owner notification ibegan january 24, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V258000 on 08/22/2001
Component:
Visibility:windshield wiper/washer:motor
Affected:
1,083,000
Defect:
Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. a switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. these vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.
Consequence:
Loss of visibility while driving increases the risk of a crash.
Correction:
Dealers will inspect the date code on the wiper motor. motors built with the suspect time frame will have the wiper motor gear case cover replaced. owner notification began august 20, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01I017000 on 01/06/2002
Component:
Wheels:lugs/nuts/bolts
Manufactured:
07/18/1999 - 06/17/2001
Affected:
238,653
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 2000-2001 ford focus passenger vehicles, originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohiom, pennsylvania, rhode island, vermont, west virginia, and wisconsin. in high corrosion areas, where salt is used on roadways in the winter, the rear wheel bearing seal race can experience surface corrosion. if this condition occurs, the wheel bearing seals could become damaged and allow contamination to enter the wheel bearings.
Consequence:
The wheel bearings could prematurely wear and cause a noticeable noise. if not repaired, this condition could progress to the point where the wheel begins to wobble.
Correction:
Dealers will replace the rear wheel bearings at no cost to the consumer. additional bearing seals will also be installed to ensure a smooth ride. this program will be in effect until december 31, 2002, regardless of mileage. even if the vehicle has already been serviced under recall campaign 00s31, ford has taken additional steps to keep the wheel bearings in top shape. owners can contact ford at 1-866-436-7332, concerning this program.
Notes:
Ford has decided to conduct a service campaign to replace the rear wheel bearings. owners can contact ford at1-866-436-7332, concerning this program.
Campaign:
02V288000 on 11/05/2002
Component:
Electrical system:battery:cables
Manufactured:
07/18/1999 - 05/30/2001
Affected:
291,854
Defect:
Certain passenger vehicles equipped with zetec engines, loose or broken attachments and misrouted battery cables could lead to cable insulation damage.
Consequence:
This, in turn, could cause the battery cables to short resulting in heat damage to the cables. besides heat damage, the "check engine" light may illuminate, the vehicle may fail to start, or smoke, melting, or fire could also occur.
Correction:
Dealers will inspect the battery cables for the condition of the cable insulation and proper tightening of the terminal ends. as necessary, cables will be rerouted, retaining clips installed, and damaged battery cables replaced. owner notification began february 10, 2003. owners who do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02V289000 on 11/05/2002
Component:
Steering:linkages
Manufactured:
03/04/1999 - 05/30/2001
Affected:
446,569
Defect:
Certain passenger vehicles have loose pinch bolts that secure the lower control arm to the steering knuckle have been reported.
Consequence:
Loose pinch bolts could exhibit noise, vibration and, in extreme cases if left uncorrected, separation of the joint or fracture of the ball joint stud, increasing the risk of a crash.
Correction:
Dealers will inspect the steering knuckle pinch bolt for tightness and correct as necessary. owner notification began february 10, 2003. owners who do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V482000 on 11/19/2003
Component:
Fuel system, gasoline
Manufactured:
05/04/1999 - 06/12/2001
Affected:
671,000
Defect:
On certain passenger vehicles, contamination of the filter in the fuel delivery module (fdm) can reduce, and eventually block, the flow of fuel to the engine.
Consequence:
This may cause engine hesitation, loss of power, surging, and other similar symptoms. over time, the filter may become sufficiently blocked to cause the engine to stall, which could result in a crash.
Correction:
This action is deemed a safety improvement campaign and is not being conducted under the safety act. all owners will be notified of the problem, and dealers will replace the fdm with a new design at no charge if the owner reports that the vehicle exhibits any of the identified symptoms. the free replacement will be available for a period of 10 years following the original purchase of the vehicle, with no mileage limit. owner notification is expected to begin during november 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford campaign no. 03n01.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V030000 on 02/01/2005
Component:
Latches/locks/linkages:doors:latch
Manufactured:
04/06/1999 - 09/01/2002
Affected:
589,932
Defect:
Certain passenger vehicles with four or five doors and originally sold in or currently registered in connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia, a build-up of corrosion at the pawl pivot area of the rear door latch can cause a binding condition of the pawl that may affect proper engagement of the pawl into the catch. the occupant may experience difficulty opening or closing a rear door, and eventually the rear door may not latch properly.
Consequence:
If not latched properly, the door may open while the vehicle is in motion. if an occupant fell out of the vehicle, personal injuries could occur.
Correction:
Dealers will have a lower rocker seal added to the door and have the rear door latches evaluated free of charge. a latch that passes the evaluation will be lubricated to prevent future corrosion. a latch that does not pass the evaluation will be replaced. in addition, a sticker will be affixed to the rear doors advising the owners to use the recommended lubricant. the recall began on march 9, 2005. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 05s27.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12E007000 on 02/23/2012
Component:
Equipment
Affected:
10,006
Defect:
Ride control, llc (ride control) is recalling certain readymount assemblies, p/n 746641mt and 746646mt, with corresponding aftermarket customer part numbers: gabriel g56944 and gabriel g56945, and privately branded partsmaster with part numbers g68944 and g68945. the readymount assemblies were sold as aftermarket service equipment for use on certain 2000 through 2005 ford focus vehicles. these assemblies were assembled with a nut without the necessary washer. the absence of the washer can allow the readymount assembly to pull apart the top mount.
Consequence:
If the assembly separates during installation, it could result in injury to the installer. if the assembly separates while the vehicle is in motion, it could result in secondary damage to the vehicle and possibly result in a vehicle crash.
Correction:
Ride control will notify owners and will set up procedures to inspect, repair, and/or replace the affected parts without charge to the owner. the safety recall began on march 30, 2012. owners may contact ride control at 1-800-999-3903.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2000 FORD FOCUS TSBs (296)

Bulletin:
996840
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject pertaining to vehicles equipped with the 4500n (cassette) or 4600n (cd) radios exhibiting intermittent and / or inoperative speakers. *tt
Bulletin:
99B21
Component:
061000 engine and engine cooling:engine
Summary:
Owner notification program to replace the engine fuel pulse damper. *tt
Bulletin:
99B22
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding passenger side engine mount assembly manufactured with incorrect hardware prior to assembly replacement. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
6712
Component:
980000 unknown or other
Summary:
Subject regarding bonus edsr award points for ford focus reports. *tt
Bulletin:
6928
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Exhibiting a squeaking / rattle in the instrument panel, ppor radio fit in instrument panel or excessive compact disc (cd) skipping. *tt
Bulletin:
7000
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information regarding the new passive anti-theft system named encrypted passive anti theft (epats). *tt
Bulletin:
7105
Component:
160000 structure
Summary:
Information regarding the 2000 focus edsr request. *mjs
Bulletin:
13188
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information regarding focus key programming, anti theft system. *mjs
Bulletin:
7205
Component:
330000 interior lighting
Summary:
Some models may exhibit instrument cluster warning lamps that are inoperative. *tt
Bulletin:
7212
Component:
980000 unknown or other
Summary:
Information on programming the remote keyless entry (rke) transmitters on certain vehicles. *tt
Bulletin:
7242
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some customer may report a concern with the radio volume going up and down on its own while driving or fluctuating by itself. *tt
Bulletin:
7243
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Vehicles may exhibit a radio that is intermittently inoperative. *tt
Bulletin:
7249
Component:
353600 equipment:air conditioner
Summary:
Information on using peanut style a/c fittings. *tt
Bulletin:
7257
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with automatic transmission, the ignition key may be difficult to remove in the park position. *tt
Bulletin:
7258
Component:
106000 power train:axle assembly
Summary:
Vehicles equipped with automatic transaxle may exhibit a harsh transmission engagement with possible malfunction indicator lamp (mil) on and diagnostic trouble code (dtc) po705. *tt
Bulletin:
7308
Component:
015100 steering:hydraulic power assist:pump
Summary:
Experiencing excessive power steering noise and fluid foaming in the reservoir on initial engine start up. *tt
Bulletin:
13288
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit instrument cluster warning lamps that are inoperative. *tt
Bulletin:
13419
Component:
015100 steering:hydraulic power assist:pump
Summary:
Vehicles built prior to 10/06/99 equipped with 2.0l spi engine will have a 7 rib power steering pump pulley driven by a 6 rib belt. *tt
Bulletin:
7362
Component:
015100 steering:hydraulic power assist:pump
Summary:
Brief information stating that the orange o-ring on the power steering pulley is for assembly purposes only and is not used for service. *tt
Bulletin:
7422
Component:
180000 vehicle speed control
Summary:
Subject regarding the speed control servo / cable install service tip. *tt
Bulletin:
7427
Component:
100000 power train
Summary:
Some vehicles may exhibit a speedometer indicator needle that sticks on 140 mph (220 kph). *tt
Bulletin:
7429
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit gauges that sweep especially after starting the engine. *tt
Bulletin:
7430
Component:
180000 vehicle speed control
Summary:
Information regarding speed control switch voltage readings - service tip. *tt
Bulletin:
7433
Component:
021000 suspension:front
Summary:
Some vehicles built before 10/28/99 may exhibit a noise condition described as flutter, tapping, flapping or ticking coming from the outboard edges of i/p, inner dash panel, insulator front wheeliner or exterior front suspension noise.
Bulletin:
7435
Component:
020000 suspension
Summary:
Concerns with noise from the front struts due to normal suspension travel at full rebound while driving over speed bumps. *tt
Bulletin:
7436
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some brief information for vehicles exhibiting a front brake groan / grunt noise. *tt
Bulletin:
7437
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a squeal noise from the rear brakes. *tt
Bulletin:
7438
Component:
204000 wheels:cap/cover/hub
Summary:
Information on installing and removing steel wheel covers. *tt
Bulletin:
7439
Component:
204000 wheels:cap/cover/hub
Summary:
Service information on installing the 5-spoke trend wheel center cap properly. *tt
Bulletin:
7451
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 2.0l engine may exhibit a timing belt shredding or timing belt striking the front cover. *tt
Bulletin:
7476
Component:
330000 interior lighting
Summary:
Sbuect regarding dome lamp issues. *tt
Bulletin:
7477
Component:
133000 visibility:power window devices and controls
Summary:
Concerns with inoperative power windows. *tt
Bulletin:
7478
Component:
162700 structure:body:trunk lid
Summary:
Some vehicles may exhibit a trunk lid that is difficult to close. *tt
Bulletin:
7480
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with the automatic transaxle may exhibit a stall condition or a vibration / shudder during decel when coming to a stop. *tt
Bulletin:
7483
Component:
015100 steering:hydraulic power assist:pump
Summary:
Updated information regarding the power steering pump pulley on vehicles built prior to 10/06/1999 and equipped with 2.0 spi engines. *tt
Bulletin:
7491
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a fuel gauge that always indicates empty even after filling the fuel tank.
Bulletin:
7518
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles may require ignition keys to be reprogrammed after the key codes have been erased. *tt
Bulletin:
7535
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a check engine lamp on with diagnostic trouble codes p1516, p1518, p1519 or p1520 for the integrated manifold runner control (imrc) assembly. *tt
Bulletin:
7540
Component:
162700 structure:body:trunk lid
Summary:
Concerns woth vehicles exhibiting a deck lid that is difficult to close. *tt
Bulletin:
13434
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with automatic transmission may exhibit a malfunction indicator lamp (mil) on and a diagnostic trouble code (dtc) p0705 stored in memory. *tt
Bulletin:
13444
Component:
180000 vehicle speed control
Summary:
Service tip information on installing speed control servo / cable. *tt
Bulletin:
13489
Component:
330000 interior lighting
Summary:
Concerns about the dome lamp not operating or on all the time. *tt
Bulletin:
13490
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit power windows that are inoperative. *tt
Bulletin:
13491
Component:
162700 structure:body:trunk lid
Summary:
Concerns with vehicles exhibiting a trunk lide that is difficult to close. *tt
Bulletin:
13523
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may require separating or replacing the engine or transmission assemblies in service. *tt
Bulletin:
13552
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some customers may report a concern of radio operating with ignition switch off, with or without a key in ignition. *tt
Bulletin:
13572
Component:
162300 structure:body:door
Summary:
Information on inoperative exterior door handles. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
8034
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 2.0l spi 2v engine only, may exhibit a hot soak restart stall or hesitation upon restart after short hot soak (15-30 minutes). *tt
Bulletin:
8088
Component:
131000 visibility:windshield
Summary:
Information on replacing a broken / cracked windsdhield. *tt
Bulletin:
8089
Component:
021000 suspension:front
Summary:
Information on vehicles exhibiting a steering pull / drift left or right condition. *tt
Bulletin:
0021
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Vehicle may experience a fluttering noise from the pcv valve after engine shutdown on some vehicles. *mjs
Bulletin:
8137
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp on with one or more of the followig diagnostic trouble codes c1145, c1234, c1233, c1265, c1235, c1175, c1236, or a flase activation of the 4wabs. *tt
Bulletin:
8152
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Some vehicles may exhibit a freeze of the pid data during four wheel anti-lock brake (4wabs) activation. *tt
Bulletin:
8171
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a slight engine vibration. *tt
Bulletin:
7919
Component:
036000 service brakes, hydraulic:antilock
Summary:
Diagnostic assistance for anti-lock brake system.
Bulletin:
7872
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Noise concern coming from the lower engine splash shield that covers the crank pulley. the condition is caused by tie down chains being mispositioned during vehicle transport.
Bulletin:
7873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
An intermittent increase in the radio volume during park to reverse neutral to drive, and abrupt drive to park shift lever movements. this can only happen on automatic transmission vehicles with the automatic volume control (avc) feature o
Bulletin:
8216
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
A stall or run rough condition while slowing to a stop on some vehicles equipped with 2.0l zetec 4v engine and wth manual transmission only. *tt
Bulletin:
7928
Component:
010000 steering
Summary:
The vehicle may exhibit a mil on and dtc p1518.
Bulletin:
13841
Component:
131000 visibility:windshield
Summary:
Subject regarding request for feedback on windshield. *tt
Bulletin:
13842
Component:
021000 suspension:front
Summary:
Exhibiting a steering pull / drift left or right. *tt
Bulletin:
7953
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
All vehicles with securilock (parts) do not use the same type of ignition key. different pats keys exist for different vehicles.
Bulletin:
7968
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
The following consistent driveability symptoms: hard starting, rough running, spark knock, missing, and staling after startup.
Bulletin:
13869
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp on with one or more diagnostic trouble codes c1145, c1234, c1155, c1233, c1165, c1235, c1175, c1236, or a false activation of the 4wabs. *tt
Bulletin:
13915
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 2.0l 2v spi engines only may exhibit a hot soak restart stall or hesitation upon restart after short hot soak (15-30 minutes). *tt
Bulletin:
8224
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a hot soak restart stall or hesitation upon restart after short hot soak (15-30 minutes). *tt
Bulletin:
8284
Component:
162000 structure:body
Summary:
Concerns with water entering the front right passenger floor pan through the air handling case. *tt
Bulletin:
13740
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information regarding the service replacement of the pcm. *mjs
Bulletin:
8324
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
A condition may exist where the ignition key is difficult to turn. *tt
Bulletin:
8326
Component:
141000 air bags:frontal
Summary:
Subject regarding air bag simulator. *tt
Bulletin:
8327
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Engineering is investigating vehicles that may exhibit front or rear brake noise. *tt
Bulletin:
13751
Component:
036000 service brakes, hydraulic:antilock
Summary:
Information on diagnostic assistance required for a 2000 focus anti-lock brake concern. *mjs
Bulletin:
8328
Component:
980000 unknown or other
Summary:
Information update on programming the remote keyless entry (rke) transmitters. *tt
Bulletin:
13771
Component:
110000 electrical system
Summary:
Some vehicles equipped with 2.0l spi may exhibit a mil on and dtc p1518. *mjs
Bulletin:
13782
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit one or more of the following consistent driveability symptoms: hard starting, rough running, spark knock, missing, and stalling after startup. *mjs
Bulletin:
13785
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information regarding the servicing diagnosis which has led to the replacement of the powertrain control module (pcm). *mjs
Bulletin:
13810
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 2.0l spi 2v engine only, may exhibit a hot soak restart stall or hesitation upon restart after short hot soak (15-30 minutes). *mjs
Bulletin:
8408
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Engineering is interested in customer concerns related to audio systems to accurately identify audio component or systems issues. *tt
Bulletin:
8452
Component:
980000 unknown or other
Summary:
Some vehicles built 02/23/00 to 04/07/00 may exhibit a dtc b1427 that will not clear from the central timer module (ctm). *tt
Bulletin:
00E09
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject on the demonstration/delivery hold,: emission recall 00e09. mjs
Bulletin:
0066
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a panel/defrost door fluttering noise when the climate control system is in full cool, blower on high speed and 1 to 2 clicks above panel/floor mode. *mjs
Bulletin:
0067
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
A whistling noise from the heater plenum near the blower motor resistor. *mjs
Bulletin:
13953
Component:
162000 structure:body
Summary:
Some vehicles may exhibit water entering the front right passenger floor pan through the air handling case. *tt
Bulletin:
13968
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Concerns with a hard to turn ignition key. *tt
Bulletin:
14007
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Engineering is interested in customer concerns related to audio systems to accurately identify audio component or systems issues. *tt
Bulletin:
14026
Component:
980000 unknown or other
Summary:
Some vehicles built 02/23/00 to 04/07/00 may exhibit a diagnostic trouble code b1427 that will not clear from the central timer module (ctm). *tt
Bulletin:
8284
Component:
162000 structure:body
Summary:
Concerns with water entering the front right passenger floor pan throught he air handling case. **mr
Bulletin:
8483
Component:
162300 structure:body:door
Summary:
Information regarding door applique loose. **mr
Bulletin:
8494
Component:
020000 suspension
Summary:
Some vehicles may exhibit a noise from the front struts due to normal suspension travel at full rebound (extension) while driving over speed bumps. **mr
Bulletin:
8550
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles may exhibit transmission fluid weeping from the cooler line fittings at the transmission. **mr
Bulletin:
8563
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit erratic door locks or door locks that lock themselves. **mr
Bulletin:
8574
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a noise from the rear brakes. **mr
Bulletin:
14049
Component:
021000 suspension:front
Summary:
Some vehicles may exhibit a noise from the front struts due to normal suspension travel at full rebound (extension) while driving over speed bumps. **mr
Bulletin:
14066
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles equipped with the fn automatic transaxle may exhibit transmission fluid weeping from the cooler line fittings at the transmission. **mr
Bulletin:
14078
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit noise from the rear brakes. **mr
Bulletin:
14075
Component:
162300 structure:body:door
Summary:
Erratic door locks or door locks that lock themselves. **mr
Bulletin:
14040
Component:
160000 structure
Summary:
Some vehicles may exhibit door appliques that are loose or do not fit flush with the door. *tt
Bulletin:
14195
Component:
980000 unknown or other
Summary:
Subject regarding remote keyless entry (rke) programming procedure. *tt
Bulletin:
14221
Component:
150000 seat belts
Summary:
Subject regarding running change on the drivers side seat belt. *tt
Bulletin:
14183
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vechiles equipped with 4500n cassette radios may exhibit a condition where the radio comes back on after the ignition is turned off while playing cassettes. *tt
Bulletin:
14188
Component:
162300 structure:body:door
Summary:
Exhibiting door locks that cycle erratically when activated. *tt
Bulletin:
14204
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some vehicles may exhibit a clutch pedal that bleeds by slowly with the pedal applied for an extended period of time. *tt
Bulletin:
14219
Component:
204000 wheels:cap/cover/hub
Summary:
Some vehicles may exhibit plastic wheel covers that are distored near the lug nut and outer edge area on vehicles equipped with steel wheels. *tt
Bulletin:
6712
Component:
980000 unknown or other
Summary:
Subject regarding bonus edsr award points for ford focus reports. *tt
Bulletin:
13081
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 4500n (cassette) or 4600n (cd) radios may exibit intermittent and / or inoperative speakers. *tt
Bulletin:
13156
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a squeak / rattle in the instrument panel, poor radio fit in instrument panel or excessive compact disc (cd) skipping. *tt
Bulletin:
13164
Component:
111000 electrical system:battery
Summary:
Subject regarding batter disconnect connector action. *tt
Bulletin:
7287
Component:
980000 unknown or other
Summary:
Subject regarding assembly contact phone line for product concerns. *tt
Bulletin:
13295
Component:
980000 unknown or other
Summary:
Information on programming remote keyless entry (rke) transmitters. *tt
Bulletin:
13318
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some customers may report a concern of radio volume going up and down on its own while driving or flucftating by itself. *tt
Bulletin:
13319
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a radio that is intermittently inoperative. *tt
Bulletin:
13355
Component:
353600 equipment:air conditioner
Summary:
Information regarding a/c peanut o-ring color. *tt
Bulletin:
13358
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
On some vehicles equipped with automatic transmission, the ignition key may be difficult to remove in park position. *tt
Bulletin:
13359
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with automatic transaxle may exhibit a harsh transmission engagement with possible malfunction indicator lamp on and diagnostic trouble code po705. *tt
Bulletin:
13383
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Subject regarding excessive power steering noise and fluid foaming inthe reservoir on initial engine start-up. *tt
Bulletin:
13451
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit gauges that sweep especially after starting the engine. a guage sweep when starting the engine is caused by the instrument cluster resetting itself when cluster supply voltage drops below 6 volts. *tt
Bulletin:
13453
Component:
100000 power train
Summary:
Some vehicles may exhibit a speedometer indicator needle that sticks on 140 mph (220 kph). *tt
Bulletin:
13454
Component:
180000 vehicle speed control
Summary:
Subject regarding the speed control switch voltage readings - service tip. *tt
Bulletin:
13457
Component:
160000 structure
Summary:
Some vehicles may exhibit a noise condition described as flutter, tapping, lapping or ticking coming from the outboard edges of the instrument panel, inner dash panel, insulator front wheeliner or exterior front suspension noise. *t
Bulletin:
13459
Component:
020000 suspension
Summary:
Experiencing a noise from the front struts due to normal suspension travel at full rebound while driving over speed bumps. *tt
Bulletin:
13460
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Experiencing front brake groan / grunt noise which is characterized by a groaning / grunting sound emitted by the front brakes when the driver reduces foot pressure on the brake pedal while the vehicle is stopped. *tt
Bulletin:
13461
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Experiencing a squeal noise from the rear brakes. *tt
Bulletin:
13463
Component:
204000 wheels:cap/cover/hub
Summary:
Information regarding the 5-spoke wheel center cap. *tt
Bulletin:
13468
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 2.0l engine may exhibit a timing belt shredding or timing belt striking the front cover. *tt
Bulletin:
13497
Component:
015000 steering:hydraulic power assist system
Summary:
Subject regarding the power steering pulley. *tt
Bulletin:
13504
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a fuel gauge that always indicates empty even after filling the fuel tank. *tt
Bulletin:
13511
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a check engine lamp on with diagnostic trouble codes p1516, p1518, p1519 or p1520 for the integrated manifold runner control (imrc) assembly. *tt
Bulletin:
13516
Component:
162700 structure:body:trunk lid
Summary:
Some vehicles may exhibit a deck lid that is difficult to close. *tt
Bulletin:
13521
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding key programming information. *tt
Bulletin:
Component:
200000 wheels
Summary:
Subject regarding steel wheel cover installation. *tt
Bulletin:
14496
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on service replacement modules requiring programming. *tt
Bulletin:
14492
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a slight engine vibration at idle, most noticeable when engaged in reverse. *tt
Bulletin:
14493
Component:
220000 seats
Summary:
Some vehicles may exhibit front or rear seat seams that are splitting / improper sew or thread that may be fraying. *tt
Bulletin:
14497
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit the charging system indicator illuminated at times or constantly. the check engine lamp may also be illuminated with diagnostic trouble codes p1244, p1245 or p1246 (generator load input high / low / failed).
Bulletin:
00B59
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Owner notification program for certain vehicles built with 5-speed manual transaxles - clutch master cylinder and pedal return spring replacement. *tt
Bulletin:
14527
Component:
980000 unknown or other
Summary:
Information on the availability of the mtx-75 transmission shift aligner tool. *tt
Bulletin:
14512
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit radio inoperative / radio intermittent operation. *tt
Bulletin:
14629
Component:
162300 structure:body:door
Summary:
Subject regarding autolock enable/disable procedure. *jb
Bulletin:
14553
Component:
116000 electrical system:ignition
Summary:
Exhibiting difficulty turning ignition lock cylinder. *jb
Bulletin:
14572
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 2.0l spi engine may exhibit a check engine light on and diagnostic trouble code p0301, p0302, p0303, and p0304 (misfire cyl). *tt
Bulletin:
14616
Component:
162300 structure:body:door
Summary:
Some vehicles built before 8/31/2000 may exhibit a squeak noise from the door check strap area while opening / closing. *tt
Bulletin:
00T04
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles that were built with powertrain control module (pcm) calibration strategy features may cause the vehicle to experience a run rough and / or stall condition when slowing to a stop. *jb
Bulletin:
14368
Component:
182000 vehicle speed control:linkages
Summary:
Concerns with cruise control cable. *jb
Bulletin:
14381
Component:
106200 power train:axle assembly:axle shaft
Summary:
A halfshaft bearing noise (whine / moan, whistling, humming, drumming or rattling) from the drivetrain which appears to be emanating from the transmission. *jb
Bulletin:
14387
Component:
350000 equipment
Summary:
Information on subwoofer inoperative. *jb
Bulletin:
14686
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Information on using correct drill bits when performing safety recall 00s31 (left rear wheel retention - redundant wheel retention cap). *tt
Bulletin:
14694
Component:
032200 service brakes, hydraulic:switches:brake warning
Summary:
Some vehicles may exhibit a red and / or amber brake warning lamp(s) on without setting a diagnostic trouble code(s) (dtc's). *tt
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
01B73
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Owner notification program informing onwers that ford and sony electronics have determined that under sustained maximum volume conditions, the subwoofer speaker in the sony audio system may become damaged, resulting in reduced audio system
Bulletin:
14842
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Information on the removal / installation of fuel line from fuel pump module. *tt
Bulletin:
14799
Component:
162300 structure:body:door
Summary:
Some 2000 - 2001 vehicles may exhibit an intermittent self-activation of the power door locks. *tt
Bulletin:
14846
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with 2.0l spi engine only, may exhibita burning oil smell noted from outside or from within the passenger compartment. *tt
Bulletin:
01413
Component:
980000 unknown or other
Summary:
Malfunction indicator lamp (mil) illuminated and diagnostic trouble codes (dtcs) p0300 through p0304 stored in memory some vehicles equipped with the 2.0l spi engine. *tt
Bulletin:
14744
Component:
980000 unknown or other
Summary:
Subject regarding printed service manual pinpoint tests incorrect. *tt
Bulletin:
14747
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a check engine light on with diagnostic trouble code p1233, p1235, p1237 (fuel pump driver module). *tt
Bulletin:
14752
Component:
116000 electrical system:ignition
Summary:
Exhibiting an ignition key that is difficult to remove from the ignition lock cylinder intermittently, but will rotate. *tt
Bulletin:
00B59
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Owner notification program regarding certain 2000 model year vehicles built with 5-speed manual transaxles - clutch master cylinder and pedal return spring replacement. *tt
Bulletin:
14875
Component:
102000 power train:manual transmission
Summary:
Some vehices equipped with mtx-75 manual transaxle may exhibit a gear rattle in neutral / neutral gear rollover noise. *tt
Bulletin:
13869
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp on with on eor more diagnostic trouble code c1145, c1234, c1155, c1233, c1165, c1235, c1175, c1236, or a false activation of the 4wabs. *tt
Bulletin:
13882
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may exhibit a freeze of the pid data during four wheel anti-lock brake (4wabs) activation. this is a normal condition since the 4wabs module does not provide data link communication during 4wabs activation. *tt
Bulletin:
13915
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 2.0l 2v spi engines only, may exhibit a hot soak restart stall or hesitation upon restart after short hot soak (15 - 30 minutes). winter grade fuel may compound the severity of the condition. the condition ma
Bulletin:
13968
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit difficulty turning ignition key. this may be caused by the ignition lock cylinder (ilc). *tt
Bulletin:
14091
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit a yellow four wheel anti-lock brake (4wabs) lamp on after system service and after clearing diagnostic trouble code (dtc). *tt
Bulletin:
14122
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit door locks that cycle erratically when activated. *tt
Bulletin:
14204
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some vehicles built through april 2000 may exhibit a clutch pedal that bleeds by slowly with the pedal applied for an extended period of time. *tt
Bulletin:
14221
Component:
150000 seat belts
Summary:
Some vehicles built after 02/05/2000 have the drivers side seat belt pretensioner located on the seat belt retractor in the b-pillar, not on the receiver / buckle. *tt
Bulletin:
14262
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Information on inpsection of fuse #63. *tt
Bulletin:
13841
Component:
131000 visibility:windshield
Summary:
Information on the replacement of a broken / cracked windshield. *tt
Bulletin:
15051
Component:
185000 vehicle speed control:cruise control
Summary:
Exhibiting higher than normal idle speed, runs rough at idle and / or diagnostic trouble code p0171. *tt
Bulletin:
15052
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Some vehicles may exhibit a rear brake squeal noise due to the composition of the lining material. *tt
Bulletin:
15064
Component:
103000 power train:automatic transmission
Summary:
Exhibiting a shifter difficult to shift out of park. *tt
Bulletin:
15077
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
A condition may exist with intermittent stall / hesitation or lack of power. *tt
Bulletin:
15092
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit an ignition key that is difficult to remove from the ignition lock cylinder intermittently, but will rotate freely. *tt
Bulletin:
15102
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with 2.0l zetec engine and mtx-75 manual transaxle may exhibit a gear rattle or neutral gear roll over noise from the transaxle at idle, in neutral, with the clutch pedal up (engaged). *tt
Bulletin:
14994
Component:
020000 suspension
Summary:
Some wagons built through 05/02/2001 may exhibit a clunking noise from the rear over bumps. *tt
Bulletin:
15012
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Some vehicles may have front brake pad linings that exhibit an unacceptable rate of wear. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01163
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles equipped with a 2.0l zetec engine may exhibit a hesitation/surge at cruise or light tip-in, long crank after hot soak, or rough idle when cold. *slc
Bulletin:
15162
Component:
190000 tires
Summary:
Some vehicles may exhibit premature tire wear. *yh
Bulletin:
15163
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an oil smell in passenger compartment. *yh
Bulletin:
15125
Component:
162000 structure:body
Summary:
Information regarding body side molding replacement. *slc
Bulletin:
15184
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit inoperative power door locks due to fuse 63 failure. *et
Bulletin:
15274
Component:
110000 electrical system
Summary:
Subject regarding ck ground connections. *jg
Bulletin:
15275
Component:
190000 tires
Summary:
Subject regarding premature tire wear. *jg
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15509
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Some vehicles may exhibit an exterior mirror that is loose or shakes when driving. *tt
Bulletin:
15514
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an engine vibration at idle, most noticeable when engaged in reverse. *tt
Bulletin:
15527
Component:
162300 structure:body:door
Summary:
Information regarding diagnostic trouble code b1300, power door lock circuit failure.*yd
Bulletin:
15558
Component:
110000 electrical system
Summary:
Information regarding diagnostic trouble code b2496 (panic feature does not operate correctly). *yh
Bulletin:
15298
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a fuel gauge that reads empty when the tank is full. *tt
Bulletin:
15301
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Some vehicles may exhibit a rear brake squeal noise. *tt
Bulletin:
15302
Component:
021000 suspension:front
Summary:
Some vehicles may exhibit a grinding/crunching noise from the front strut area. *tt
Bulletin:
15317
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit gauges that sweep condition. *tt
Bulletin:
15327
Component:
020000 suspension
Summary:
Concerns with premature even tire wear. *tt
Bulletin:
15339
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a fuel gauge that reads empty when the tank is full. *tt
Bulletin:
15343
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with oil smell in passenger compartment. *tt
Bulletin:
012101
Component:
121000 exterior lighting:headlights
Summary:
Concerns with headlamp moisture/condensation in lens assembly. *tt
Bulletin:
01B85
Component:
021600 suspension:front:wheel bearing
Summary:
Customer satisfaction program regarding replacement of corroded rear wheel bearings. *tt
Bulletin:
15419
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an engine vibration at idle, most noticeable when engaged in reverse. *tt
Bulletin:
15421
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit a difficult to turn, unable to remove, or sticking ignition key. *tt
Bulletin:
15443
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Front brake noise which may be due to premature front brake wear. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
01254
Component:
106000 power train:axle assembly
Summary:
Concerns with delayed shifts after final drive gearset ratio change or transaxle replacement. *tt
Bulletin:
01B85
Component:
023000 suspension:multiple axle
Summary:
Customer satisfaction program 01b85 regarding replacement of the rear wheel bearings which may experience surface corrosion. *tt
Bulletin:
15639
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit engine vibration at idle in drive, neutral and reverse. *tt
Bulletin:
15657
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a transmission fluid leak. *tt
Bulletin:
0258
Component:
100000 power train
Summary:
Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
0291
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 2.0l spi engine may exhibit a malfunction indicator lamp (mil) illuminated and diagnostic trouble codes (dtc) p0300 through p0304 stored. *tt
Bulletin:
16089
Component:
162700 structure:body:trunk lid
Summary:
Some wagons may exhibit the liftgate not staying in the fully upright position in cold climates. *tt
Bulletin:
16098
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Some vehicles may exhibit a vertical crack in the outside mirror glass with no visible signs of impact, especially during cold ambient temperatures. *tt
Bulletin:
16157
Component:
980000 unknown or other
Summary:
Some vehicles equipped with an automatic transaxle and 2.0l zetec engine may exhibit a malfunction indicator lamp illuminated with diagnostic trouble code p0122, throttle position circuit low input. *tt
Bulletin:
16032
Component:
012200 steering:column locking:anti-theft device
Summary:
Information on north american built vehicles which were not equipped with a perimeter / active anti-theft alarm system. *tt
Bulletin:
16043
Component:
190000 tires
Summary:
Some vehicles with 15 inch firestone tires may exhibit signs of diagonal wear or cupping on the rear tires. *tt
Bulletin:
15710
Component:
110000 electrical system
Summary:
Information on vehicles with programmable modules. *tt
Bulletin:
15712
Component:
151300 seat belts:front:retractor
Summary:
Some vehicles may exhibit a locked rear seat belt retractor after moving the rear seat from the fold down position to the seating position. *tt
Bulletin:
15728
Component:
162300 structure:body:door
Summary:
Exhibiting inoperative power door locks due to fuse 63 failure. *tt
Bulletin:
15762
Component:
190000 tires
Summary:
Some vehicles equipped with 15 inch firestone tires may exhibit signs of diagonal wear or cupping of the rear tires. *tt
Bulletin:
15819
Component:
190000 tires
Summary:
Some vehicles equipped with 15 inch firestone tires may exhibit signs of diagnonal wear or cupping on the rear tires. *tt
Bulletin:
15828
Component:
116200 electrical system:ignition:module
Summary:
Some vehicles may exhibit diagnostic trouble code b1213, b1342, b1601, b2431. *tt
Bulletin:
020901
Component:
110000 electrical system
Summary:
Rough idle, low power and / or stall at idle, a malfunction indicator lamp illuminated and diagnostic trouble codes p0300 through p0304 stored in memory. *tt
Bulletin:
15896
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Some vehicles may exhibit front brake pad linings that exhibit an unacceptable rate of wear. *tt
Bulletin:
15917
Component:
020000 suspension
Summary:
Concerns with front suspension creak, crunch noise while turning at slow speeds. *tt
Bulletin:
03M02
Component:
021210 suspension:front:springs:coil springs
Summary:
Additional coverage for front coil springs. *tt
Bulletin:
03M02
Component:
021210 suspension:front:springs:coil springs
Summary:
Additional coverage for front coil springs - supplement #1. *tt supplement #2. *tt
Bulletin:
0331
Component:
341000 communications:horn assembly
Summary:
Inoperative horn condition. *tt
Bulletin:
16594
Component:
100000 power train
Summary:
Noise from the right halfshaft support bearing. engineering is investigating via the quicker service fix process. *tt
Bulletin:
030301
Component:
110000 electrical system
Summary:
Electrical - horn inoperative - vehicles equipped with 2.0l engine only. *tt
Bulletin:
16878
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant leak from a cracked coolant degas bottle. engineering is investigating. *tt
Bulletin:
16881
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light on and diagnostic trouble code p0460 (fuel level sensor circuit malfunction) - service tips. *tt
Bulletin:
16888
Component:
162000 structure:body
Summary:
Squeak and rattle condition from the instrument panel. *tt
Bulletin:
16912
Component:
022000 suspension:rear
Summary:
Clunking noise from the rear over bumps. *tt
Bulletin:
16746
Component:
061000 engine and engine cooling:engine
Summary:
Higher than normal idle speed, runs rough at idle and/or diagnostic trouble code (dtc) p0171. *tt
Bulletin:
16778
Component:
021000 suspension:front
Summary:
Front end creaking, crunching noise at low speeds while turning. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
17059
Component:
162800 structure:body:hood
Summary:
Hood release cable breaking/binding in cold weather. *tt
Bulletin:
03152
Component:
110000 electrical system
Summary:
Diagnostic trouble codes (dtc) p0402 and/or p0403 or runs rough in wet weather conditions. *tt
Bulletin:
03153
Component:
020000 suspension
Summary:
Front end creaking, crunching, grinding and or rattling noise from the front suspension while driving at slow speeds and/or while turning. *tt
Bulletin:
031511
Component:
106000 power train:axle assembly
Summary:
Intermediate axle shaft bearing replacement. *tt
Bulletin:
03135
Component:
020000 suspension
Summary:
Rear tire inner edge wear. 2004 model included. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16939
Component:
022000 suspension:rear
Summary:
Clunking noise from the rear of the vehicle over bumps. *tt
Bulletin:
16956
Component:
106200 power train:axle assembly:axle shaft
Summary:
Noise from right halfshaft support bearing. *tt
Bulletin:
16970
Component:
100000 power train
Summary:
Harsh transmission engagement with possible malfunction indicator lamp (mil) and diagnostic trouble code (dtc) p0705 (tr circuit failure). *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03182
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Water in climate control heater blower motor case, which can be associated with an inoperable heater blower motor resister, blower motor, or a blown blower motor fuse. *tt
Bulletin:
03202
Component:
020000 suspension
Summary:
Front end creaking, crunching, grinding and/or rattling noise from the front suspension while driving at slow speeds and/or while turning. *tt *mj
Bulletin:
17278
Component:
030000 service brakes, hydraulic
Summary:
Excessive front brake pad wear, front brake creep/groan noise, front brake dust and/or rotor wear. *tt
Bulletin:
17282
Component:
110000 electrical system
Summary:
Harsh transmission engagement with possible malfunction indicator lamp (mil) on and diagnostic trouble code (dtc) p0705 (tr circuit failure). *tt
Bulletin:
17298
Component:
022000 suspension:rear
Summary:
Rear shock noise from the rear of the vehicle over bumps. *tt
Bulletin:
17302
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Vehicles not equipped with anti-lock brake system (abs) may have the red brake light and amber abs light on after hybrid electronc cluster (hec - instrument cluster) replacement. *tt
Bulletin:
03N01
Component:
072000 fuel system, gasoline:delivery
Summary:
Stalling, engine hesitation, loss of power, surging, and other similar symptoms as a result of contamination of the fuel pump filters. extended coverage program 03n01. supplement #1. fuel delivery module - new design. *tt supplemen
Bulletin:
17505
Component:
061000 engine and engine cooling:engine
Summary:
Runs rough and/or malfunction indicator lamp (mil) on condition with diagnostic trouble codes (dtcs) p402 and/or p0403 (egr flow excessive detected/egr control circuit) in wet weather or in a car wash. *tt
Bulletin:
17515
Component:
126200 exterior lighting:turn signal:switch
Summary:
Automatic turn signal cancellation inoperative. *tt
Bulletin:
17591
Component:
020000 suspension
Summary:
Diagonal wear or cupping on the rear tires. *tt
Bulletin:
17536
Component:
061000 engine and engine cooling:engine
Summary:
Belt squeal. *mj
Bulletin:
17028
Component:
100000 power train
Summary:
3-4 shift flare/neutral - service tip. *tt
Bulletin:
17697
Component:
102000 power train:manual transmission
Summary:
Gear rattle or gear rollover noise from the transaxle at idle, in neutral, with the clutch pedal up (engaged). *tt
Bulletin:
16404
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Unable to communicate with/reprogram powertrain control module (pcm). *mj
Bulletin:
16408
Component:
061000 engine and engine cooling:engine
Summary:
Spi engine - oil leak - contract request. *mj
Bulletin:
16429
Component:
100000 power train
Summary:
Noise (whine/moan, whistling, humming, drumming or rattling) from the drivetrain which appears to be emanating from the transmission. *tt
Bulletin:
16436
Component:
162700 structure:body:trunk lid
Summary:
High decklid closing effort. *mj
Bulletin:
0455
Component:
126000 exterior lighting:turn signal
Summary:
Turn signal cancel concern. *tt
Bulletin:
17804
Component:
102000 power train:manual transmission
Summary:
Grinding when shifting into third gear. *tt
Bulletin:
02182
Component:
116000 electrical system:ignition
Summary:
Trim-ignition lock cylinder difficult to turn, unable to remove sticking ignition key-ignition lock cylinder removal procedure. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
17918
Component:
180000 vehicle speed control
Summary:
Inoperative speed control system. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
05310
Component:
150000 seat belts
Summary:
Safety belt web stop button service. *eh
Bulletin:
18425
Component:
060000 engine and engine cooling
Summary:
No crank on start charging system warning indicator on driveability concerns and or malfunction indicator lamp on. *eh
Bulletin:
18413
Component:
116000 electrical system:ignition
Summary:
Unable to remove ignition key - service tip. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
04174
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
Bulletin:
18379
Component:
110000 electrical system
Summary:
Brake and anti-lock brake system lights on after hec (hybrid electronic cluster) replacement. *tt
Bulletin:
04215
Component:
102000 power train:manual transmission
Summary:
Difficulty changing gears - unable to engage gears. *tt
Bulletin:
18273
Component:
353600 equipment:air conditioner
Summary:
A/c condenastion leak. *eh
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042410
Component:
061000 engine and engine cooling:engine
Summary:
Engine vibration at idle. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
18321
Component:
103000 power train:automatic transmission
Summary:
Harsh transmission engagement and or dtc p0705. *eh
Bulletin:
18463
Component:
106000 power train:axle assembly
Summary:
Vent leak. *eh
Bulletin:
18477
Component:
103000 power train:automatic transmission
Summary:
Harsh transmission engagement and or dtc p0705. *eh
Bulletin:
18581
Component:
110000 electrical system
Summary:
Erratic instrument cluster gauges and/or warning indicators - service tip. *tt
Bulletin:
04147
Component:
114000 electrical system:wiring
Summary:
Service wiring harness replacement guidelines - service tips. *tt
Bulletin:
05105
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Rear brake squeal. *tt
Bulletin:
19016
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Replace timing belt idler pulley during 2.0l zetec engine cylinder head replacement - service tip. *tt
Bulletin:
CSP-08B01
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe
Bulletin:
TSB-14-0148
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Ford: on some vehicles, operating for an extended time in high corrosion area, a safety recall 05s27 was issued, where rear door latches experience corrosion in pawl pivot area preventing proper engagement of pawl into catch. model 2000-0
Bulletin:
TSB-14-0162
Component:
162300 structure:body:door
Summary:
Ford: rear door latches are experiencing corrosion in pawl pivot area that prevent proper engagement of pawl into catch, when operated in areas causing high corrosion. model 2000-05 focus. *pe

Home | Privacy