2000 FORD EXCURSION Recalls (6)
- Campaign:
- 01V075000 on 03/20/2001
- Component:
- Exterior lighting:headlights:switch
- Manufactured:
- 10/07/1999 - 12/05/1999
- Affected:
- 74,000
- Defect:
- Vehicle description: passenger and sport utility vehicles. due to the use of incorrect material by a supplier, the headlamp switch knob can fracture and separate from the headlamp switch.
- Consequence:
- This would cause difficulty for the driver to activate the headlamps, which could affect driver visibility, increasing the risk of a crash.
- Correction:
- Dealers will replace the headlamp switch knob. owner notification began april 9, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V258000 on 08/22/2001
- Component:
- Visibility:windshield wiper/washer:motor
- Affected:
- 1,083,000
- Defect:
- Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. a switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. these vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.
- Consequence:
- Loss of visibility while driving increases the risk of a crash.
- Correction:
- Dealers will inspect the date code on the wiper motor. motors built with the suspect time frame will have the wiper motor gear case cover replaced. owner notification began august 20, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06V286000 on 08/01/2006
- Component:
- Vehicle speed control
- Affected:
- 1,200,000
- Defect:
- On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
- Consequence:
- Overheating could result in smoke or burn and an underhood fire.
- Correction:
- Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on august 7, 2006. owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07V553000 on 12/04/2007
- Component:
- Engine and engine cooling:engine:diesel
- Affected:
- 1,176,000
- Defect:
- On certain heavy duty trucks equipped with 7.3l diesel engines, the camshaft position sensor located on the engine of the vehicle may function intermittently, possibly resulting in an engine stall.
- Consequence:
- In the event of an engine stall, a crash could result without warning.
- Correction:
- Dealers will inspect the sensor and replace it with an improved camshaft position sensor free of charge. the recall began on december 29, 2007. owners may contact ford at 1-866-436-7332.
- Notes:
- Ford recall no. 07s57.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07E106000 on 12/18/2007
- Component:
- Wheels:cap/cover/hub
- Affected:
- 130,000
- Defect:
- Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. the inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
- Consequence:
- Wheel separation can result in a vehicle crash.
- Correction:
- Federal-mogul will notify customers and will replace the hub assembly free of charge. the recall began on february 7, 2008. owners can contact federal-mogul toll-free at 877-489-6659.
- Notes:
- This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09V399000 on 10/12/2009
- Component:
- Vehicle speed control
- Manufactured:
- 03/24/1999 - 10/31/2002
- Affected:
- 4,500,000
- Defect:
- Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
- Consequence:
- A vehicle fire could occur with or without the engine running.
- Correction:
- Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
- Notes:
- Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2000 FORD EXCURSION TSBs (220)
- Bulletin:
- 9913138
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Information on replacing and removing the generic electronic module (gem). *tt
- Bulletin:
- 998446
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Some vehicles built before 11/99 may exhibit incorrectly set generic electronic module (gem) diagnostic trouble codes (dtc). *tt
- Bulletin:
- 99B19
- Component:
- 980000 unknown or other
- Summary:
- Recall / service program information regarding special parts ordering - 99b19-s1 kit code aa. *tt
- Bulletin:
- 99B19
- Component:
- 121200 exterior lighting:headlights:switch
- Summary:
- Owner notification program for headlamp switch replacement. *tt
- Bulletin:
- 992111
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service procedure for orange service tagged 4t100 transmissions. *tt
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99224
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Subject regarding front wipers operating while switch is in off position. *tt
- Bulletin:
- 99243
- Component:
- 126200 exterior lighting:turn signal:switch
- Summary:
- On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
- Bulletin:
- 6905
- Component:
- 110000 electrical system
- Summary:
- Information on removing and / or replacing the generic electronic module (gem). *tt
- Bulletin:
- 6989
- Component:
- 980000 unknown or other
- Summary:
- Information on repairing paint chips on interior trim. *tt
- Bulletin:
- 7115
- Component:
- 350000 equipment
- Summary:
- Information regarding servicing pats w/new generation star tool. *mjs
- Bulletin:
- 13173
- Component:
- 980000 unknown or other
- Summary:
- Information regarding repairing paint chips on interior trim. *mjs
- Bulletin:
- 13230
- Component:
- 350000 equipment
- Summary:
- Information regarding servicing pats w/new generation star tool. *mjs
- Bulletin:
- 13247
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Information regarding rear 1/4 glass adhesive. *mjs
- Bulletin:
- 13255
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information regarding vehicle pulling left during hard braking. *mjs
- Bulletin:
- 13272
- Component:
- 020000 suspension
- Summary:
- some vehcles may exhibit a vibration at speeds above 40 mph. *tt
- Bulletin:
- 7129
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Some vehicles built between 08/03/1999 may exhibit an adhesive failure at the rear 1/4 glass. *tt
- Bulletin:
- 7153
- Component:
- 020000 suspension
- Summary:
- Exhibiting a vibration at speeds above 40 mph. *tt
- Bulletin:
- 13247
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Exhibiting an adhesive failure between the hinge and / or rear clevis and the rear quarter glass surface. *tt
- Bulletin:
- 13353
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject regarding poor / no air conditioner performance. *tt
- Bulletin:
- 13022
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Some vehicles built before 11/1999 may exhibit incorrectly set generic electronic module (gem) diagnostic trouble codes (dtc). *tt
- Bulletin:
- 7342
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles with auxiliary air conditioner may exhibit poor / no air conditioner cooling. *tt
- Bulletin:
- 7421
- Component:
- 020000 suspension
- Summary:
- Exhibiting a popping noise from the front suspension or passenger side floor pan. *tt
- Bulletin:
- 7432
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Some vehicles may exhibit brake vibration or shudder while braking. *tt
- Bulletin:
- 7456
- Component:
- 021000 suspension:front
- Summary:
- Some vehicles may exhibit a pull to the left condition while braking. *tt
- Bulletin:
- 7488
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some customers may comment about the climate control system defaulting to defrost mode and / or no air distribution control. *tt
- Bulletin:
- 7543
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Some vehicles equipped with the 6.8l v-10 engine and california emissions may exhibit an exhaust flutter noise. this noise may also be described as an engine miss or exhaust leak. *tt
- Bulletin:
- 7546
- Component:
- 980000 unknown or other
- Summary:
- Information regarding location of door keypad code. *tt
- Bulletin:
- 13443
- Component:
- 021000 suspension:front
- Summary:
- Experiencing a popping noise from the front suspension or passenger side floor pan. *tt
- Bulletin:
- 13476
- Component:
- 021000 suspension:front
- Summary:
- Some vehicles may exhibit a pull to the left while braking condition. *tt
- Bulletin:
- 13548
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Information on the idle kicker feature, which under conditions will automatically elevate the idle speed after 130 seconds of idling at cold temperatures. *tt
- Bulletin:
- 13566
- Component:
- 980000 unknown or other
- Summary:
- There have been some inquiries as to whether certain vehicles can be used for snowplowing. this bulletin states that under no circumstance should a snowplow be attached to certain vehicles. *tt
- Bulletin:
- 7859
- Component:
- 204000 wheels:cap/cover/hub
- Summary:
- Vehicle equiped with either manual or electronic shift 4x4 system may exhibit a vibration or a ratcheting noise from the front of the vehicle. another symptom may be described as front hublocks not releasing.
- Bulletin:
- 7863
- Component:
- 034510 service brakes, hydraulic:foundation components:disc:caliper
- Summary:
- The driver's side rear brake caliper will be relocated behind the rear axle. in addition, these vehicles will no longer have a caliper shield on the drivers side of the rear axle.
- Bulletin:
- 7884
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- The vehicle equipped with 5.4l or 6.8l gas engines may exhibit an overheating condition during predelivery inspection. this may be caused by a low coolant level.
- Bulletin:
- 7887
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- The vehicle may exhibit a yellowish stain on the rear tailgate below the rear windshield wiper.
- Bulletin:
- 7888
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- The vehicle may exhibit a yellowish stain on the dutch rear doors under the wiper arm assembly. this condition could be caused by a chemical reaction between the washer fluid and 4 of the tubes used in the rear washer system.
- Bulletin:
- 8098
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Information regarding operation of heated side mirrors. *tt
- Bulletin:
- 0022
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles may experience particle contaminants, from prior transmissiion concerns or excess wear, may be trapped in the transmission fluid cooling system if not properly flushed. *mjs
- Bulletin:
- 8120
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles equipped with electronic shift on the fly transfer case may exhibit one or more of the following conditions: front hubs will not unlock / lock with mode switch, noise from the front axle while driving in 2 wheel drive mode,
- Bulletin:
- 8121
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Subject regarding transfer case shift relay location. *tt
- Bulletin:
- 8167
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem. *tt
- Bulletin:
- 0038
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
- Bulletin:
- 7921
- Component:
- 021700 suspension:front:hub
- Summary:
- A slow release of the hubs, at times, which may be regarded a not normal by the operator. slow release of the hublocks is not considered abnormal for this system.
- Bulletin:
- 8207
- Component:
- 106200 power train:axle assembly:axle shaft
- Summary:
- Some vehicles equipped with 10.50-inch ring gear, full-floating rear axles may exhibit a leak at the outboard end of the axle shaft(s). *tt
- Bulletin:
- 7958
- Component:
- 353600 equipment:air conditioner
- Summary:
- The vehicle exhibit shif on the fly engagement/disengagement issues or heater/ac only blowing out of the defrost mode. these conditions may be caused by the vacuum pump.
- Bulletin:
- 7967
- Component:
- 111000 electrical system:battery
- Summary:
- A dead battery and circuit board concerns during predelivery inspection.
- Bulletin:
- 13854
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Subject pertaining to the operation of heated side mirrors. *tt
- Bulletin:
- 13859
- Component:
- 107000 power train:axle hubs
- Summary:
- Some vehicles equipped with electronic shift on the fly transfer case may exhibit front hubs that will not unlock / lock with mode switch; noise from the front axle while in 2 wheel drive mode, air conditioning switching to defrost when shi
- Bulletin:
- 13860
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Recent reports indicate difficulty locating the electronic shift on the fly transfer case relays for certain vehicles. *tt
- Bulletin:
- 13876
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem. *tt
- Bulletin:
- 8245
- Component:
- 036400 service brakes, hydraulic:antilock:abs warning light
- Summary:
- Some may exhibit an anti-lock brake lamp illuminted and a b1845 stored. *tt
- Bulletin:
- 8268
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on performing air conditioner system recharge service. *tt
- Bulletin:
- 13742
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may equipped with 7.3l diesel engine, operating in cold conditions may exhibit a gradual loss of power at cruise. *mjs
- Bulletin:
- 8375
- Component:
- 353000 equipment:electrical
- Summary:
- Subject regarding the accuracy of the average fuel economy and fuel range. *tt
- Bulletin:
- 8376
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Some vehicles equipped with rear anti-lock brakes may exhibit diagnostic trouble codes c1113 / c1115 / c1185. *tt
- Bulletin:
- 8379
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- A technical assistance helpline has been established to help with diagnostics and / or mechanical concerns with the new venture transfer case on certain vehicles. *tt
- Bulletin:
- 13654
- Component:
- 107000 power train:axle hubs
- Summary:
- Some vehicles may exhibit a slow release of the hubs, at times, which may be regarded as not normal by the operator. *mjs
- Bulletin:
- 13764
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Some vehicles built between 8/14/99 and 11/16/99 may exhibit shift on the fly engagement/disengagement issues or heater/ac only blowing out of the defrost mode. *mjs
- Bulletin:
- 13779
- Component:
- 110000 electrical system
- Summary:
- Some vehicles built between 10/24/99 and 11/8/99 equipped with 7.3l powerstroke engine that have california emissions certified, may exhibit a dead battery and circuit board concerns during predelivery inspection. *mjs
- Bulletin:
- 8432
- Component:
- 138130 visibility:defroster/defogger system:windshield:controls/wiring
- Summary:
- Some vehicles equipped with manual temperature control may exhibit a temperature control knob that falls off. *tt
- Bulletin:
- 13942
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information used when performing the air conditioner system recharge service on certain vehicles. *tt
- Bulletin:
- 13964
- Component:
- 980000 unknown or other
- Summary:
- Information regarding change to the location of the ashtray. *tt
- Bulletin:
- 13989
- Component:
- 353000 equipment:electrical
- Summary:
- Information regarding the accuracy of the average fuel economy and fuel range displayed by the overhead trip computer. *tt
- Bulletin:
- 13990
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Some vehicles equipped with rear anti-lock brakes may exhibit diagnostic trouble codes c1113 / c1115 / c1185. *tt
- Bulletin:
- 13927
- Component:
- 036400 service brakes, hydraulic:antilock:abs warning light
- Summary:
- Some vehicles may exhibit an anti-lock brake lamp illuminated and a b1845 stored. *tt
- Bulletin:
- 14020
- Component:
- 138130 visibility:defroster/defogger system:windshield:controls/wiring
- Summary:
- Concerns with the manual temperature control knob falling off. *tt
- Bulletin:
- 14032
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Some vehicles with 7.3l dit engines may exhibit loose bolts on the turbo housing. *tt
- Bulletin:
- 0086
- Component:
- 107000 power train:axle hubs
- Summary:
- The 4x4 system, particularly the front locking hubs. *mr
- Bulletin:
- 8313
- Component:
- 980000 unknown or other
- Summary:
- Information regarding ashtray relocation. **mr
- Bulletin:
- 8465
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Informtion regarding turbo bolts coming loose. **mr
- Bulletin:
- 8487
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Information regarding transfer case hall effect encoder tips. **mr
- Bulletin:
- 14043
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Information regarding transfer case hall effect encoder tips. **mr
- Bulletin:
- 14044
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit fuse #19 blown, overdrive cancel light (ocil) flashing and and instrument cluster gauges inoperative. **mr
- Bulletin:
- 14186
- Component:
- 190000 tires
- Summary:
- Information on vehicles exhibiting a harsh ride condition due to improperly adjusted tire pressures. *tt
- Bulletin:
- 14179
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Some vehicles equipped with the reverse park aid feature (rpa) may exhibit a rpa that emits solid tone immediately after reverse is engaged. *tt
- Bulletin:
- 14184
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 7.3 dit engine may exhibit engine roughness, misses, buck / jerk, hesitation / stumble, surge, lack of power, various idle symptoms, malfunction indicator lamp on, etc. *tt
- Bulletin:
- 13306
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a vibration at speeds above 40 mph. *tt
- Bulletin:
- 13456
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Some vehicles may exhibit brake vibration or shudder while braking. engineering has released new brake pad which is equipped with a v-spring. *tt
- Bulletin:
- 13500
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles with 7.3l engines may exhibit an inoperative vacuum pump. *tt
- Bulletin:
- 13519
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with the 6.8l v-10 engine and california emissions may exhibit an engine miss or exhaust flutter noise. *tt
- Bulletin:
- 13525
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the location of the keypad code. *tt
- Bulletin:
- 14453
- Component:
- 102000 power train:manual transmission
- Summary:
- Some vehicles equipped with 4r100 transmission were built with and without the #8 thrust washer. *tt
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 00254
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an engine buck, surge, or jerk (also known as hitching / hesitation) while the speed control is active through all engine temperatures. *tt
- Bulletin:
- 00261
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
- Bulletin:
- 14606
- Component:
- 107000 power train:axle hubs
- Summary:
- Front locking hubs. *jb
- Bulletin:
- 14569
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a noise coming from the rear of the vehicle when traveling over bumps. *tt
- Bulletin:
- 0113
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Some vehicles equipped with 5.4l or 6.8l engine built through 9/10/2000 may exhibit a miss sound from the exhaust. this may be cuased by the design of the exhaust y-pipe which can cause a miss like sound known as impingement. *
- Bulletin:
- 0116
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may produce a malfunction indicator lamp illuminated, rough idle, a check engine light, and diagnostic trouble codes (dtcs) p0350 - p0360 stored in memory. *tt
- Bulletin:
- 00215
- Component:
- 342000 communications:back up alarm
- Summary:
- Concerns with reverse park aid false activation. *jb
- Bulletin:
- 00221
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with powerstroke diesel engines after serial number 0896812 (engine build date), may exhibit a noise above the normal sound of the diesel combustion.*jb
- Bulletin:
- 00183
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Concerns with the intake manifold leaking or weeping coolant from passenger side gasket at right rear corner of head-to-manifold joint. *jb
- Bulletin:
- 14348
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Concerns with a turbo hoot condition. *jb
- Bulletin:
- 14349
- Component:
- 022000 suspension:rear
- Summary:
- A clunk / popping noise from front sway bar area. *jb
- Bulletin:
- 14350
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Vehicles may experience front shaft seal leakage. *jb
- Bulletin:
- 14356
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Concerns with rear brake noise. *jb
- Bulletin:
- 14365
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
- Bulletin:
- 0125
- Component:
- 151600 seat belts:front:warning light/devices
- Summary:
- Seat belt warning system - belt reminder function, operation and service tips. *tt
- Bulletin:
- 0132
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit stiff steering, wandering, or poor returnability after turns. *tt
- Bulletin:
- 14652
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Some vehicles may exhibit higher than normal steering efforts when the vehicles is at a very low speed or stopped with the brakes applied. *tt
- Bulletin:
- 14658
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4r100 transmission and 7.3l engine or with 4r100 6.8l may exhibit engine stall after transmission engagement into reverse and a tip in backout of the throttle. *tt
- Bulletin:
- 0162
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
- Bulletin:
- 14840
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- A slight purge of grease from the front hub bearing unit that may be noted between the hub unit and the inboard rotor flange. *tt
- Bulletin:
- 0144
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Fuel quality and moisture in certain diesel fuels may cause some vehicles to exhibit a no start, gradual loss of power, or a rough idle condition due to fuel gelling during extreme cold weather operation. *tt
- Bulletin:
- 0147
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
- Bulletin:
- 0149
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Front brake pad or caliper rattle when going over bumps. *tt
- Bulletin:
- 14743
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Information on rear axle pinion seal part usage. *tt
- Bulletin:
- 14753
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Some vehicles equipped with a 7.3l dit engine may exhibit loose turbo bolts on the turbo housing. *tt
- Bulletin:
- 0195
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- A condition may exist with lack of power under a load, at cruise or on acceleration may occur on some vehicles built before 11/25/2000 equipped with the 7.3l dit engine. this may be caused by a collapsed air filter element or defective ai
- Bulletin:
- 14907
- Component:
- 980000 unknown or other
- Summary:
- Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
- Bulletin:
- 13993
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Subject regarding diagnostics and / or mechanical concerns regarding the new venuture transfer case. *tt
- Bulletin:
- 14032
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Some vehicles with 7.3l dit engines may exhibit loose turbo bolts on the turbo housing. typical symptoms of loose bolts include lack of power and an oil leak. *tt
- Bulletin:
- 14160
- Component:
- 980000 unknown or other
- Summary:
- A condition may exist where the malfunction indicator lamp is on with diagnostic trouble code p0340 (camshaft position (cmp) sensor a circuit) stored, accompanied with a driveability concern. *tt
- Bulletin:
- 14179
- Component:
- 161000 structure:frame and members
- Summary:
- Some vehicles equipped with the reverse park aid feature (rpa) may exhibit a rpa that emits a solid tone immediately after reverse is engaged. *tt
- Bulletin:
- 14184
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 7.3l dit engine may exhibit an engine that runs rough, misses, buck / jerk, hesitate / stumble, surge, lacks power, various idle symptoms, malfunction indicator lamp on. *tt
- Bulletin:
- 14244
- Component:
- 020000 suspension
- Summary:
- Some 4x4 vehicles may exhibit a pop / clunk noise during turns, turning onto uneven surfaces or when driving over bumps. engineering has determined that this may be caused by an under torqued upper front sway bar bolt which attaches the u
- Bulletin:
- 14350
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Information on vehicles exhibiting a water pump shaft seal leak. *tt
- Bulletin:
- 14356
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Some super duty f series vehicles may exhibit a brake squeal / squeak from the rear brakes. *tt
- Bulletin:
- 14434
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a buck or jerk (also known as hitching) during highway driving at speeds 40 mph or greater with the cruise control engaged. *tt
- Bulletin:
- 14453
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with 4r100 transmission were built with and without the #8 thrust washer. *tt
- Bulletin:
- 15022
- Component:
- 036400 service brakes, hydraulic:antilock:abs warning light
- Summary:
- Concerns that the anti-lock brake system (abs) lamp is on with diagnostic trouble codes c1230, c1229, or c1237. *tt
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
- Bulletin:
- 15172
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may exhibita coolant leak from the water pump weep hole. *yh
- Bulletin:
- 01181
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Brake shift interlock.*jb
- Bulletin:
- 012113
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
- Bulletin:
- 01205
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
- Bulletin:
- 0214
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
- Bulletin:
- 15525
- Component:
- 034510 service brakes, hydraulic:foundation components:disc:caliper
- Summary:
- Information regarding a rattle noise originating from the front brake caliper.*yd
- Bulletin:
- 15566
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a tacky surface on the instrument panel (ip). *tt
- Bulletin:
- 15578
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Some vehicles may exhibit an anti-lock brake system (abs) light on, b2141/b2477, and/or an inaccurate speedometer. *tt
- Bulletin:
- 15579
- Component:
- 034510 service brakes, hydraulic:foundation components:disc:caliper
- Summary:
- Some vehicles may exhibit caliper pin rattle noise originating from the front brake calipers. *tt
- Bulletin:
- 15328
- Component:
- 034510 service brakes, hydraulic:foundation components:disc:caliper
- Summary:
- Concerns with rattle noise originating from the front brake calipers. *tt
- Bulletin:
- 15355
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Some vehicles equipped with 7.3l di engine may exhibit false diagnostic trouble codes p1105, p1106 (upper and lower alternator faults). *tt
- Bulletin:
- 15446
- Component:
- 010000 steering
- Summary:
- Some vehicles may exhibit increased steering efforts at very low speeds or when stopped with the brakes applied. *tt
- Bulletin:
- 15397
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may exhibit a condition of oil contamination in cooling system. *tt
- Bulletin:
- 01246
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
- Bulletin:
- 15661
- Component:
- 034510 service brakes, hydraulic:foundation components:disc:caliper
- Summary:
- Concerns with rattle noises coming from front brake calipers. *tt
- Bulletin:
- 0245
- Component:
- 111000 electrical system:battery
- Summary:
- Information regarding discharged battery charging service tips and guidelines. *tt
- Bulletin:
- 15686
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Concerns of diagnostic trouble code p1280 retrived fromthe power train control module (pcm). *tt
- Bulletin:
- 15757
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Subject regarding vehicles exhibiting cold start rolling idle. *tt
- Bulletin:
- 15780
- Component:
- 100000 power train
- Summary:
- Some vehicles may exhibit a front or rear pinion seal leak. *tt
- Bulletin:
- 15871
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Some vehicles may exhibit interference and / or static in the land-mobile radio. *tt
- Bulletin:
- 15882
- Component:
- 162000 structure:body
- Summary:
- Subject regarding roof rack scratches paint on roof panel. *tt
- Bulletin:
- 15888
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a fead belt squeal. *tt
- Bulletin:
- 15891
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Subject regarding rear brake bleed screw location on 1999 - 2002 models. *tt
- Bulletin:
- 15902
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Some vehicles may exhibit lack of power steering assist. *tt
- Bulletin:
- 16697
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Exhaust air rush noise and lower power. *tt *jb
- Bulletin:
- 16597
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Coolant leak due to a broken lower radiator hose clamp. *tt
- Bulletin:
- 16662
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Lack of power, smoke, or oil leaks around the charge air cooler (cac). 1999-2003 super duty/excursion vehicles equipped with 7.3 or 6.0 ford navistar diesel engine. *tt
- Bulletin:
- 16921
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Coolant leak due to broken radiator hose clamp. 1999-2003 models. *tt
- Bulletin:
- 16924
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Slight purge of grease from the hub bearing unit. this grease may be noted between the hub unit and the inboard rotor flange and on the inboard side of the bearing. 1999-2003 models. *tt
- Bulletin:
- 16925
- Component:
- 107000 power train:axle hubs
- Summary:
- No engagement or disengagement of hub locks after replacement or service. to include 2000-2003 excursions. *tt
- Bulletin:
- 03112
- Component:
- 020000 suspension
- Summary:
- On-vehicle front integrated hub/bearing rocking end-play measurement. including 2003 and 2004 super duty f series. *tt
- Bulletin:
- 0398
- Component:
- 090000 fuel system, other
- Summary:
- Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
- Bulletin:
- 03911
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Rough idle and/or hesitation when acclerating on certain super duty vehicles equipped with a 5.4l or 6.8l engine. *tt
- Bulletin:
- 03143
- Component:
- 021700 suspension:front:hub
- Summary:
- Front hubs will not engage or disengage properly. *tt
- Bulletin:
- 03144
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
- Bulletin:
- 03148
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
- Bulletin:
- 03149
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A loss of power, oil leaks around the turbo, and/or excessive exhaust noise from the turbo. *tt
- Bulletin:
- 031410
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Turbo pedestal seal oil leak around the exhaust back pressure (ebp) actuator. 2003 super duty f series included. *tt
- Bulletin:
- 03181
- Component:
- 110000 electrical system
- Summary:
- Remote keyless entry (rke) - service tips. *tt
- Bulletin:
- 03192
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Leak oil around the exhaust backpressure actuator (ebp) - 7.3l diesel turbocharger pedestals. *tt
- Bulletin:
- 031910
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Brake pull. 4x4 f-250/350 and excursion vehicles only. *tt
- Bulletin:
- 032136
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Glow plug control module on 7.3l diesel vehicles with california emissions - service tip. *tt
- Bulletin:
- 032138
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles equipped with 7.3l dit engine built after engine serial number 896812 may have a injection control pressure (icp) oil aeration reading that is higher than the specification. *tt
- Bulletin:
- 032139
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 7.3l powerstroke diesel engine with engine serial number 661894 through 1311240 may exhibit a knock noise above the normal sound of the diesel combustion. this bulletin also replaces 01146. *tt
- Bulletin:
- 032140
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine buck, surge or jerk (also known as hitching/hesitation) while the speed control is active through all engine temperatures. *tt
- Bulletin:
- 032141
- Component:
- 090000 fuel system, other
- Summary:
- Fuel quality and moisture in certain diesel fuels may cause some vehicles to exhibit a no start, gradual loss of power, or a rough idle condition due to fuel gelling during extreme cold weather operation. *tt
- Bulletin:
- 032142
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A lack of power under a load, at cruise or on acceleration may occur on some vehicles built before 11/25/2000 equipped with the 7.3l dit engine. *tt
- Bulletin:
- 032145
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- External oil leak diagnosis for 7.3l dit engines. various models including 2003 super duty f series. *tt
- Bulletin:
- 032146
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine oil pan corrosion on vehicles equipped with the 7.3l diesel engine. various models including 2003 super duty f series. *tt
- Bulletin:
- 032149
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A loss of power, oil leaks around the turbo, and/or excessive exhaust noise from the turbo. *tt
- Bulletin:
- 032150
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- High pressure oil pump leak on vehicles equipped with 7.3l diesel engine. *tt
- Bulletin:
- 032151
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some 7.3l diesel turbocharger pedestals may leak oil around the exhaust back pressure actuator (ebp). *tt this article supersedes tsb 03-21-51 dated 10/30/2003. *tt
- Bulletin:
- 14248
- Component:
- 060000 engine and engine cooling
- Summary:
- Film of oil/dust at the charge air cooler (cac) hose connections. *tt
- Bulletin:
- 16258
- Component:
- 110000 electrical system
- Summary:
- Vehicles equipped with a 7.3l engine (after serial number 0661894) - under valve cover (uvc) harness retainer clip released for service. includes 2003 econoline, super duty, f650/750 and excursion. *tt
- Bulletin:
- 16480
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code (dtc) p0340, possible false code. various models including 1994-1996 ford excursion. *tt
- Bulletin:
- 16589
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Gradual loss of power at cruise. ford special service message. various models including 2003 super duty f series. *tt
- Bulletin:
- 16859
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Some vehicles built after 12/7/1998 equipped with a 7.3l dit engine may exhibit a hoot or howling noise from the turbocharger. 2003 super duty f series also included. *tt
- Bulletin:
- 03203
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
- Bulletin:
- 03205
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- No start/repeat starter failure or a sticking/binding ignition lock cylinder, starter staying engaged at start up. also includes 2003 super duty f series. *tt
- Bulletin:
- 16515
- Component:
- 010000 steering
- Summary:
- Oil leak at high pressure pump fittings and/or plug. this includes super duty f-series. oasis. *tt
- Bulletin:
- 16589
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Gradual loss of power at cruise. use fuel additive to prevent his condition. all super duty f-series 1999-2003 included. oasis *tt
- Bulletin:
- 14
- Component:
- 190000 tires
- Summary:
- Firestone tire safety campaign. firestone steeltex radial a/t lt265/75r16 lr d owl and bsw tires. tire inspection and replacement. *mr
- Bulletin:
- 17467
- Component:
- 080000 fuel system, diesel
- Summary:
- Engine or fuel system concerns when using fuel with greater than 5% biodiesel concentration. *tt
- Bulletin:
- 17603
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Air bag light on with diagnostic trouble code (dtc) b1871 or b1935 following ecs/rcm replacement. *tt
- Bulletin:
- 17554
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil/dust film at cac connections. *mj
- Bulletin:
- 17571
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) on with diagnostic trouble codes p0603 (powertrain control module keep alive memory error) or p0605 ( powertrain control module read only memory error). *tt
- Bulletin:
- 17316
- Component:
- 090000 fuel system, other
- Summary:
- Fuel signal to instrument cluster service tip. *tt
- Bulletin:
- 0471
- Component:
- 110000 electrical system
- Summary:
- Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
- Bulletin:
- 04116
- Component:
- 107000 power train:axle hubs
- Summary:
- Front hubs not engaging, not staying engaged and/or unlocking. *tt
- Bulletin:
- 17406
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low power, poor fuel economy, fuel gelling cold, excessive white smoke cold, or hard start. *mj this oasis updates previous oasis dated 12/01/03. *tt
- Bulletin:
- 02227
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
- Bulletin:
- 17829
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Transfer case shift issues on vehicles with an electronic shift on the fly (esof) transfer case. *tt
- Bulletin:
- 02176
- Component:
- 032100 service brakes, hydraulic:switches:brake light
- Summary:
- Lamp-brake-invadvertent disabling of brake shift interlock. *mj
- Bulletin:
- 02194
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Driveability-no start/repeat starter failure-repeat starter replacement. electrical-sticking or binding ignition lock cylinder between start and run. engine-starting-starter staying engaged at start up. *mj
- Bulletin:
- 16187
- Component:
- 162000 structure:body
- Summary:
- Roof paint scratching from luggage rack crossbars. *mj
- Bulletin:
- 031501
- Component:
- 138130 visibility:defroster/defogger system:windshield:controls/wiring
- Summary:
- Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
- Bulletin:
- 18217
- Component:
- 090000 fuel system, other
- Summary:
- Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
- Bulletin:
- 18223
- Component:
- 033100 service brakes, hydraulic:power assist:vacuum
- Summary:
- Vacuum pump inoperative or runs continuously - climate control defaults to defrost. oasis. to also include 2005 super duty f-series, excursion, and f650/750. *tt
- Bulletin:
- 041514
- Component:
- 138130 visibility:defroster/defogger system:windshield:controls/wiring
- Summary:
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
- Bulletin:
- 031404
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
- Bulletin:
- 04168
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vacum pump inoperative or runs continuosly - climate control default to defrost. *ar
- Bulletin:
- 02208
- Component:
- 353600 equipment:air conditioner
- Summary:
- Climate control a/c service tech tips. *eh
- Bulletin:
- 04185
- Component:
- 107000 power train:axle hubs
- Summary:
- Front hubs not engaging, not staying engaged and/or unlocking. *tt
- Bulletin:
- 02219
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Adding additional bulbs to turn indicator or hazard flasher circuits - service tips. *tt
- Bulletin:
- 04174
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt
- Bulletin:
- 18376
- Component:
- 103000 power train:automatic transmission
- Summary:
- A cold weather reverse engagement stall. *tt
- Bulletin:
- 04189
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
- Bulletin:
- 042421
- Component:
- 151300 seat belts:front:retractor
- Summary:
- Safety belt retraction speed. *tt
- Bulletin:
- 05417
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
- Bulletin:
- 04262
- Component:
- 342000 communications:back up alarm
- Summary:
- False parking aid warnings. *tt update. *tt
- Bulletin:
- 05174
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vacuum pump inoperative or runs continuously - climate control defaults to defrost mode. *tt
- Bulletin:
- 041601
- Component:
- 060000 engine and engine cooling
- Summary:
- Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
- Bulletin:
- 19015
- Component:
- 090000 fuel system, other
- Summary:
- Fuel conditioner. low power, poor fuel economy, fuel gelling in cold weather, excessive white smoke on cold start, hard start, or coking of components exposed to exhaust. *tt
- Bulletin:
- 06N05
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Customer satisfaction program 06n05. certain vehicles extended warranty - headlamp switch knob may fracture or fall off the headlamp switch. *tt headlamp knob switch - service tip. *tt
- Bulletin:
- 071110
- Component:
- 040000 service brakes, air
- Summary:
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
- Bulletin:
- DOR-B8H4Z-11
- Component:
- 010000 steering
- Summary:
- This sku is a front upper ball joint. the customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. excessive friction in the ball joint assembly ma
Home | Privacy