2000 CHEVROLET SILVERADO Recalls (20)

Campaign:
00V055000 on 02/28/2000
Component:
Service brakes, hydraulic:antilock
Manufactured:
07/31/1999 - 08/30/1999
Affected:
10,674
Defect:
Vehicle description: light duty pickup trucks equipped with 4-wheel disc brakes. some of these vehicles have an antilock brake system (abs) motor containing an out-of-specification spring clip. this clip could allow the motor bearing to become misaligned. if misalignment occurs, eventually the abs would be non-functional.
Consequence:
The base brakes would remain fully functional, but the dynamic rear proportioning (drp) system, which optimizes front to rear brake balance, would become inoperative.
Correction:
Dealers will replace the brake pressure module valve assembly.
Notes:
Gm recall no. 00013.owner notification began march 27, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00X001000 on 08/23/2000
Component:
Service brakes, hydraulic:foundation components:disc:caliper
Affected:
777,873
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1/2 ton light duty pickup trucks. on certain trucks, failure to follow the service procedure set forth in the service manual for removal of the front brake caliper can result in movement of the front brake hose relative to its knuckle mounting bracket. if this movement results in increased length between the bracket and the banjo fitting that attaches to the brake caliper, it is possible for the brake hose to come in contact with the wheel rim.
Consequence:
This contact with the wheel rim could, in time, cause the brake hose to become worn to the point that brake fluid leakage could occur. if this occurred, loss of front brakes is possible.
Correction:
Dealers will attach a notice label to the front brake hoses stating that the calipers must be supported when removed.
Notes:
Gm has decided to conduct a service program to install a label on the hose with warning and recommendations to support the brake calipers when removing them.owners can contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782, concerning this program.
Campaign:
00V345000 on 10/29/2000
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Manufactured:
01/31/1999 - 06/29/2000
Affected:
1,383,922
Defect:
Vehicle description: light duty pickup trucks and sport utility vehicles. some of these vehicles have a clearance condition between the front right-hand brake pipe and the body cross sill that could decrease to the point of allowing contact during the life of the vehicle. if contact occurs and the brake pipe becomes damaged, in half of the brake system there can be a loss of brake fluid and pressure. the brake warning lamp will be activated when the brake fluid level reaches the indicator limit.
Consequence:
During braking, the pedal will be lower than normal and stopping distances will be longer. if this occurs when stopping distance is limited, a crash could occur.
Correction:
Dealers will inspect the front right-hand brake pipe for wear. if there are signs of wear, this section of the brake pipe will be replaced with a new designed brake pipe section. if there are not signs of wear on the brake pipe, the dealer will install a spacer clip to ensure sufficient clearance between the brake pipe and the body cross sill.
Notes:
Owner notification began february 5, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02V178000 on 07/21/2002
Component:
Air bags:frontal:sensor/control module
Manufactured:
01/31/1999 - 02/27/2000
Affected:
525,254
Defect:
On certain pickup and utility trucks, some of these vehicles have an air bag sensing diagnostic module (sdm) which contains an anomaly that could result in the driver and passenger's air bag failing to deploy during certain frontal crashes.
Consequence:
In a vehicle crash, front seat occupants may receive more severe injuries.
Correction:
Dealers will recalibrate the sdm on the affected vehicles. owner notification began august 28, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Notes:
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V129000 on 03/21/2004
Component:
Structure:body:tailgate:hinge and attachments
Manufactured:
09/30/1999 - 07/30/2000
Affected:
3,662,211
Defect:
On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Consequence:
Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
Correction:
Dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Notes:
Gm recall no. 04007.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04E022000 on 03/29/2004
Component:
Equipment
Affected:
8,000
Defect:
Aftermarket pickup truck over-the-rail bedliners manufactured for installation on 1999-2004 chevrolet silverado and gmc sierra pickup trucks. the toggle wing assembly used to attach the bedliner to the truck bed is not engaging fully in the stake pocket of the pickup truck.
Consequence:
The bedliner can become detached from the pickup while it is motion, possibly endangering following motorists or pedestrians.
Correction:
Durakon will issue a press release in attempt to notify customers that could have purchased the defective bedliner. if you purchased either a durakon allstar of patriot overrail bedliner since august 1, 2003, for 1999 to 2004 chevrolet silverado or gmc sierra trucks, or purchased one of these pickup trucks with either brand bedliner already installed, you should return to an authorized durakon dealer so that the bedliner can be inspected and, if necessary, repaired with a newly designed toggle wing fastening system, or if required, replaced with a new bedliner free of charge. please call the durakon hotline at 1-800-933-4200 to find the nearest authorized durakon dealer.
Notes:
This recall only pertains to aftermarket overrail bedliners and has no relation to any original equipment installed on chevrolet silverado and gmc sierra pickup trucks by general motors.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V005000 on 01/09/2005
Component:
Power train:driveline:driveshaft
Manufactured:
04/30/1999 - 10/30/1999
Affected:
98,221
Defect:
Some pickup trucks, vans, and sport utility vehicles equipped with a hydraulic pump driveshaft that can fracture, resulting in immediate loss of hydraulic power steering assist. on certain vehicles equipped with hydro-boost power brakes, the same condition can result in loss of power assist for braking after the reserve pressure is depleted.
Consequence:
An inoperative pump can cause increased steering effort, and in hydro-boost equipped vehicles also increased braking effort, but does not completely eliminate the ability to steer or slow the vehicle.
Correction:
Dealers will replace the hydraulic pump. the campaign began on february 14, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm campaign no. 05001.this action is deemed a safety improvement campaign and is not being conducted under the safety act.the company has informed nhtsa that it will provide the modifications described above free of charge.
Campaign:
05V161000 on 04/21/2005
Component:
Parking brake
Manufactured:
01/31/1999 - 07/30/2000
Affected:
90,242
Defect:
On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Consequence:
If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
Correction:
Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 05042.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
05V379000 on 08/28/2005
Component:
Service brakes, hydraulic:antilock
Manufactured:
01/31/1999 - 07/30/2000
Affected:
1,353,718
Defect:
Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. this condition is more likely to occur in environmentally corrosive areas. this recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
Consequence:
This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
Correction:
Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. the recall began september 22, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 05068. gm revised the involved vehicles by amending the original 573 report on october 4, 2005. gm revised the original 573 report on december 16, 2005, to include additional states and vehicle population.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06V066000 on 03/07/2006
Component:
Structure:body:tailgate:hinge and attachments
Manufactured:
01/31/1999 - 10/30/1999
Affected:
805,368
Defect:
Certain pickup trucks have galvanized-braided-steel tailgate support cables used to support the tailgate in the full open (horizontal) position. over time these cables can corrode and fracture when loads are applied to them.
Consequence:
If one cable fractures, the remaining cable may retain the tailgate in a horizontal position. if both cables fracture, the tailgate would drop and strike the top surface of the rear bumper. if anyone is sitting or standing on the horizontal surface of the tailgate when both cables fractured, they could fall and be injured. on vehicles without a bumper, the tailgate may drop to a lower position.
Correction:
Dealers will replace the galvanized support cables with stainless steel support cables. in addition, dealers are to inspect the tailgate hinge and replace it, if necessary. the recall is expected to begin during april 2006. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Notes:
Gm recall no. 06019.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E042000 on 05/21/2006
Component:
Exterior lighting:headlights
Affected:
15,974
Defect:
Certain eagle eyes replacement headlamps, model nos. gm159-b001l and gm159-b001r, sold for use on 1999-2002 chevrolet silverado model vehicles. the headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
The headlamps have decreased lighting visibility which could result in a vehicle crash.
Correction:
Sabry lee will notify owners and issue full credit. the recall began on may 10, 2006. owners may contact sabry lee at 1-866-467-2279.
Notes:
This recall only pertains to aftermarket eagle eyes headlamp assemblies and has no relation to any original equipment installed on chevrolet silverado vehicles manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E057000 on 06/22/2006
Component:
Exterior lighting:headlights
Affected:
12,861
Defect:
Certain maxzone headlight assemblies, depo brand, p/nos. 332-1182l-as and 332-1182r-as, sold for use as aftermarket equipment for 1999-2000 chevrolet silverados. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Maxzone will notify owners and offer for reimbursement any noncompliant headlights. the recall began on july 10, 2006. owners may contact maxzone at 909-822-3288.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E060000 on 06/28/2006
Component:
Exterior lighting
Affected:
87,745
Defect:
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Correction:
Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
Notes:
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E075000 on 08/27/2006
Component:
Exterior lighting:headlights
Affected:
17,268
Defect:
Certain guide replacement headlamps, p/nos. 16526133 and 16526134, manufactured from january 1 to july 11, 2006, sold for use on my 1999-2002 chevrolet silverado pickup trucks. the headlamp fail to comply with the photometry requirement of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Too much light in certain points of the headlamp could create a distraction, possibly resulting in a vehicle crash.
Correction:
Guide corporation will notify owners and replace the headlamps free of charge. the recall began on august 31, 2006. owners may contact guide at 248-874-0355.
Notes:
This recall only pertains to aftermarket guide headlamps and has no relation to any original equipment installed on chevrolet silverado vehicles manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E106000 on 12/18/2007
Component:
Wheels:cap/cover/hub
Affected:
130,000
Defect:
Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between january 23, 2006, and december 20, 2007, sold for light duty and medium duty trucks. the inboard retention nut used to maintain hub bearing assembly can loosen resulting in an abs light indication, noise, and/or wheel separation.
Consequence:
Wheel separation can result in a vehicle crash.
Correction:
Federal-mogul will notify customers and will replace the hub assembly free of charge. the recall began on february 7, 2008. owners can contact federal-mogul toll-free at 877-489-6659.
Notes:
This recall only pertains to replacement national, carquest wheel hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors or ford.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

2000 CHEVROLET SILVERADO TSBs (266)

Bulletin:
99063
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding mismachined engine crankshaft on trucks equipped with 4.3l v6 engines. *tt
Bulletin:
99063A
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding mismachined engine crankshaft - inspect engine / replace engine, if required. *tt
Bulletin:
99063A
Component:
061000 engine and engine cooling:engine
Summary:
A condition with a mismachined engine crankshaft - inspect engine / replace if required. *tt
Bulletin:
990730024
Component:
106000 power train:axle assembly
Summary:
A condition with driveline vibration / growl noise. *tt
Bulletin:
990604049
Component:
180000 vehicle speed control
Summary:
Some customers may comment of a wide open throttle 1-2 double bump and / or harsh upshift. *tt
Bulletin:
000864003
Component:
162300 structure:body:door
Summary:
Some owners may comment on a rattle noise when closing either of the front doors. this noise may be more noticeable when the window is in the down position. *tt
Bulletin:
000604006
Component:
980000 unknown or other
Summary:
Some customers may comment about the service engine soon lamp being illuminated with no other driveability concerns noticed on vehicles built prior to the vin breakpoints mentioned in this bulletin. *tt
Bulletin:
990308002A
Component:
021000 suspension:front
Summary:
Front suspension coil spring noise. *tt
Bulletin:
000604007
Component:
180000 vehicle speed control
Summary:
Some customers may comment on a higher than expected accelerator pedal effort from the idle position, c/k series pick ups (silverado and sierra). *mjs
Bulletin:
000604024
Component:
980000 unknown or other
Summary:
Some drivers may comment about the service engine soon lamp illuminating. the powertrain control module may have stored a diagnostic trouble code p0300, engine misfire detected. *tt
Bulletin:
000850014
Component:
220000 seats
Summary:
Some customers may comment that the driver's bucket seatback moves forward about 25 to 38 mm (1 to 1-1/2 inches) during moderate to heavy braking. *tt
Bulletin:
061100
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may comment on a hesitation, sag or a stumble on initial acceleration after the first startup of the day. *tt
Bulletin:
00024
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding customer satisfaction campaign - front brake hose abrasion. *tt
Bulletin:
181000
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Engineering is investigating harsh one-two shift on the 4l60e automatic transmission. this investigation is focused on harsh one-two shifts on 2000 model year silverado and sierra equipped with 4l60e automatic transmission. *t
Bulletin:
021000
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding customer complaint of whistle and wind rush or flutter type noise. *tt
Bulletin:
000603009
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment on a lean hesitation, sag or stumble condition present during light to moderate throttle accelerations. *tt
Bulletin:
00093
Component:
030000 service brakes, hydraulic
Summary:
Subject pertaining to front brake pipe contact with body cross sill. *jb
Bulletin:
00093
Component:
030000 service brakes, hydraulic
Summary:
Exhibiting front brake pipe contact with body cross sill. *jb
Bulletin:
00093
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding a clearance condition between the front right-hand brake pipe and the body cross sill. *jb
Bulletin:
080101
Component:
138000 visibility:defroster/defogger system
Summary:
Some customer may comment that the windows do not defrost on a timely basis. *tt
Bulletin:
111200
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may complain that their full-size pickup trucks may be hard to start or intermittently does not start. *tt
Bulletin:
020201
Component:
121000 exterior lighting:headlights
Summary:
This is a product update vme that involves certain pick-up trucks. as indicated in service bulletin number 00-08-42-010, relative to the daytime running lights being inoperative, the replacement bulb is now available. *tt
Bulletin:
180900
Component:
050000 parking brake
Summary:
Brief information concerning parking brake shoe adjustment. *tt
Bulletin:
210900
Component:
010000 steering
Summary:
Subject regarding power steering system noise that requires replacement of the rack and pinion assembly on two-wheel drive models. *tt
Bulletin:
000603009A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit lean hesitation, sag or stumble when coolant temperature is between -6 and +20 degrees celsius. *tt
Bulletin:
000604007B
Component:
182000 vehicle speed control:linkages
Summary:
Experiencing increased accelerator pedal effort. *tt
Bulletin:
050301
Component:
150000 seat belts
Summary:
The seatbelt replacement parts do not match or are unable to latch to the existing belt. *tt
Bulletin:
990421003B
Component:
105500 power train:driveline:differential unit
Summary:
Some owners may comment on a slipping type condition at the front wheels while the vehicle is in four wheel drive (4wd). *tt
Bulletin:
010526001
Component:
050000 parking brake
Summary:
Low effort parking brake apply system. *tt
Bulletin:
000864016
Component:
162300 structure:body:door
Summary:
Customer comments that the 3rd or 4th door is hard to close when cold. *tt
Bulletin:
010856002
Component:
980000 unknown or other
Summary:
Some customers may have concerns with the security lamp illuminating while driving; the security lamp may be on or off; the engine cranks but will not start and the security lamp is flashing; and / or the engine starts then stalls and the s
Bulletin:
230701
Component:
162000 structure:body
Summary:
Some customers may comment that the center console latch may stick or will not open. *tt
Bulletin:
010940001
Component:
150000 seat belts
Summary:
Information regarding replacement of front seat belt retractor and buckle usage. *tt
Bulletin:
010940001
Component:
151300 seat belts:front:retractor
Summary:
Information regarding replacement of the front seat belt retractor and buckle usage. *tt
Bulletin:
000310008
Component:
020000 suspension
Summary:
Some customers may comment that they are unable to lower the spare tire. *tt
Bulletin:
010866005
Component:
162000 structure:body
Summary:
Information regarding new pickup box reinforcement kits which are available for customers who may want to install a cross toolbox, side box, or a ladder rack system as an accessory. *tt
Bulletin:
010856002A
Component:
110000 electrical system
Summary:
Some vehicles may exhibit a security lamp illuminated on the instrument panel, engine stall, no start condition, and diagnostic trouble code b2960. *tt
Bulletin:
010101
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Some vehicles may experience repeat fuel pump failures. *slc
Bulletin:
200801
Component:
103000 power train:automatic transmission
Summary:
Information regarding revised transmission calibration to address driveline growl or prop shaft ring noise. *jg
Bulletin:
300701
Component:
160000 structure
Summary:
Information regarding frontal wind noise condition. *yh
Bulletin:
060801
Component:
162300 structure:body:door
Summary:
Some vehicles may experience a sqeaking sound coming from the front doors while opening and closing. *slc
Bulletin:
070801
Component:
980000 unknown or other
Summary:
Information regarding pick-up box reinforcment kits, for when adding toolboxes or ladder racks. *slc
Bulletin:
160801
Component:
162300 structure:body:door
Summary:
Subject regarding new door check link. *jg
Bulletin:
270901
Component:
020000 suspension
Summary:
Some vehicles equipped with 4-wheel drive extended cab and short bed may experience a bump or clunk on stop or acceleration. *slc
Bulletin:
010864014
Component:
162300 structure:body:door
Summary:
Subject on door manual lock lever disengages from door trim panel. *yh
Bulletin:
010864015
Component:
162300 structure:body:door
Summary:
Information regarding front and rear side access door noise. *yh
Bulletin:
000850014A
Component:
221600 seats:front assembly:power adjust
Summary:
Information regarding driver's power bucket seatback experiencing movement during braking. *yh
Bulletin:
010417004A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Clunk, bump or squawk when vehicle comes to a complete stop or acceleration from complete stop. *yh update. *tt
Bulletin:
010730036
Component:
102000 power train:manual transmission
Summary:
Service engine soon lamp illuminated, incorrect transmission shifts, poor performance of engine, transmission slipping. *yh
Bulletin:
251001
Component:
102000 power train:manual transmission
Summary:
Some extended cab short bed vehicles with four-wheel drive may exhibit a bump or clunk on stop or acceleration from a stop. *tt
Bulletin:
011101
Component:
102000 power train:manual transmission
Summary:
This message covers trucks with four-wheel drive extended cab short bed with a bump or clunk on stop or acceleration in reference to bulletin number 01-04-17-004. *tt
Bulletin:
131101
Component:
102000 power train:manual transmission
Summary:
Information on 4-wheel drive extended cab, short bed vehicles with 4-wheel drive extended cab, short bed with a bump or clunk on stop or acceleration. *tt
Bulletin:
010864015
Component:
162310 structure:body:door:hinge and attachments
Summary:
Subject regarding front and rear side door access door noise (replace door check link). *jg
Bulletin:
010864014
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Subject regarding door manual lock lever disengages from door trim panel (repair lock lever) *jg
Bulletin:
010139007
Component:
138000 visibility:defroster/defogger system
Summary:
A condition may exist where the customer cannot control the hvac system modes and / or the temperature. *tt
Bulletin:
010139007
Component:
138000 visibility:defroster/defogger system
Summary:
Subject regarding loss of hvac system mode and/or temperature control. *tt
Bulletin:
000235003G
Component:
010000 steering
Summary:
Concerns that clunk noise can be heard coming from under the hood also felt in the steering wheel. *tt updated *eh gm administrative message. *tt
Bulletin:
010730038
Component:
103000 power train:automatic transmission
Summary:
Some customers may comment that the service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt
Bulletin:
020417001
Component:
103000 power train:automatic transmission
Summary:
Some owners of c1500 series extended cab pickup models may comment on a vibration/launch shudder when accelerating from a stop. *tt
Bulletin:
171201
Component:
010000 steering
Summary:
Subject regarding steering shaft clunk condition. *tt
Bulletin:
201201
Component:
010000 steering
Summary:
Subject regarding steering clunk noise. *tt
Bulletin:
220102
Component:
100000 power train
Summary:
Some four-wheel drive extended cab short bed models may exhibit a bump/clunk on stop or acceleration. *tt
Bulletin:
180202
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Customers may comment about a brake squeak or a noise, particularly after a cold soak and on the first brake application. *tt
Bulletin:
020090002
Component:
100000 power train
Summary:
Subject regarding lubrication of propeller shaft double cardan cv type u-joint centering ball and seat.*nlm
Bulletin:
020604023
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment on a mild to severe engine ping (spark knock) during acceleration and / or illuminated malfunction indicator lamp with diagnostic trouble code p0332 set. *tt
Bulletin:
020605003
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust moan or vibration at low vehicle speeds between 900-1200 rpm under load. *tt
Bulletin:
02-06-04-037
Component:
061000 engine and engine cooling:engine
Summary:
Some customers whose vehicles are operated in dusty type environments, such as farming or mining off-road type applications, may comment about the illumination of the instrument panel ses light, with diagnostic trouble code p0446 set. *tt
Bulletin:
020604023A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment on a mild to severe engine ping (commonly referred to as spark knock) usually worse during acceleration and / or an illuminated malfunction indicator lamp. *tt
Bulletin:
010601029B
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may comment on higher than expected engine oil consumption. *tt
Bulletin:
010866005B
Component:
980000 unknown or other
Summary:
Subject regarding availability of pickup box reinforcement kits for toolbox / rear window barrier / ladder rack applications. *tt
Bulletin:
010866014A
Component:
162000 structure:body
Summary:
Pickup box sheet metal fracture / damage with aftermarket accessories installed. *tt
Bulletin:
010864014A
Component:
162300 structure:body:door
Summary:
Some customers may comment that the manual lock lever comes loose from the door trim panel. *tt
Bulletin:
020525002
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Subject regarding revised wheel speed sensor replacement procedure. *tt
Bulletin:
020417001A
Component:
103000 power train:automatic transmission
Summary:
Concerns with launch shudder / vibration on acceleration. *tt
Bulletin:
020421004
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some customers may comment on the service 4wd indicator illuminating with diagnostic trouble code b2725 set. *tt
Bulletin:
020421005
Component:
100000 power train
Summary:
Some vehicles will not move when 4-wheel drive is requested, noise, shudder, poor performance, transmission / transfer case slips, transmission will not upshift, slips in 4-wheel drive. *tt
Bulletin:
020730024A
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
Bulletin:
040902
Component:
011000 steering:wheel and handle bar
Summary:
Some 2500 hd and 1500 hd crew cab models may exhibit a steering column rattle or noise especially during low speed parking lot turning maneuvers. *tt
Bulletin:
050602
Component:
162810 structure:body:hood:hinge and attachments
Summary:
Some customers may comment about hood hinge wind noise . *tt
Bulletin:
030602
Component:
070000 fuel system, gasoline
Summary:
Some vehicles may display a diagnostic trouble code of p0446 (evap canister vent). *tt
Bulletin:
150702
Component:
140000 air bags
Summary:
Subject regarding an upcoming recall involving reflashing the airbag sensing and diagnostic moudle (sdm). *tt
Bulletin:
020601029
Component:
061000 engine and engine cooling:engine
Summary:
Needle bearings found in oil pan. *tt
Bulletin:
020849007
Component:
162000 structure:body
Summary:
Center console lid hard to open or close. *tt
Bulletin:
020522004B
Component:
030000 service brakes, hydraulic
Summary:
Trailer brakes applied when headlights / park lamps are on, brake controller illumination. *tt
Bulletin:
020526002
Component:
050000 parking brake
Summary:
Scraping noise from rear of vehicle. *tt
Bulletin:
990089015B
Component:
980000 unknown or other
Summary:
Light service support vehicle (lssv). *tt
Bulletin:
020605005A
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Exhaust / muffler heat shield rattle, popping noise under vehicle. *tt
Bulletin:
020604054A
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Increased accelerator pedal effort. *tt
Bulletin:
000235003B
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
030310001
Component:
020000 suspension
Summary:
Tire slowly goes flat and/or excessive wheel vibration caused by bead splits (replace wheels with new heavy duty rim version) *tt *ar updated 4/11/08. *nj
Bulletin:
020421005A
Component:
100000 power train
Summary:
Slips in 4-wheel drive, noise, vibration, leaks, hot odor. *tt
Bulletin:
020604054B
Component:
061000 engine and engine cooling:engine
Summary:
Increased accelerator pedal effort, idle instability. *tt
Bulletin:
020605003A
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust moan/vibration. *tt
Bulletin:
000523005B
Component:
030000 service brakes, hydraulic
Summary:
Right rear inner brake pad wear. various modles including the 2004 silverado and sierra. *tt
Bulletin:
030604030
Component:
061000 engine and engine cooling:engine
Summary:
Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
030421004
Component:
100000 power train
Summary:
Design change of rear output shaft and oil pump replacement parts. *tt
Bulletin:
000842010A
Component:
120000 exterior lighting
Summary:
Daytime running lamp (drl) bulb replacement. *tt
Bulletin:
030308002
Component:
020000 suspension
Summary:
Rattle/squeak from front of vehicle. *tt *ar
Bulletin:
020605003C
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust moan/vibration. *tt update. *tt
Bulletin:
030844011
Component:
162000 structure:body
Summary:
Tweeter speaker rattle in front side door(s), tweeter speaker falls out of position. *tt
Bulletin:
071503
Component:
162000 structure:body
Summary:
Revised requirements for installing the running board. *tt
Bulletin:
00347A
Component:
022144 suspension:rear:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:
Rear spring slap or clunk noise. *tt
Bulletin:
00634A
Component:
061000 engine and engine cooling:engine
Summary:
Gen iii engine noise after hot soak restart. *tt
Bulletin:
01409
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
The nvg 136 all wheel drive (awd) transfer case and the 236 and 246 nvg selectable transfer case shudder on turns. *tt
Bulletin:
01410
Component:
100000 power train
Summary:
Poor performance from a stop in 2wd, auto or 4wd hi. 2003, 2003 cadillac ext also included. *tt
Bulletin:
00149C
Component:
110000 electrical system
Summary:
Malfunction indicator lamp on with a p0300 set and a misfire. various models including the 1996-1999 p32 and the 1996-2002 gmc c/k truck. *tt
Bulletin:
030601024A
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise in engine. *tt
Bulletin:
030525007
Component:
036000 service brakes, hydraulic:antilock
Summary:
Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
Bulletin:
990089015C
Component:
980000 unknown or other
Summary:
Light service support vehicle lssv (formerly commercial utility cargo vehicle - cucv ii and iii) service. *tt
Bulletin:
030601023
Component:
061000 engine and engine cooling:engine
Summary:
Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt
Bulletin:
030601024
Component:
061000 engine and engine cooling:engine
Summary:
Rattle noise in engine. *tt
Bulletin:
990421003C
Component:
105500 power train:driveline:differential unit
Summary:
Front wheels slipping with vehicle in four wheel drive. *tt
Bulletin:
01470
Component:
180000 vehicle speed control
Summary:
Erratic idle, idle surge, rough run, or near stall. *tt
Bulletin:
000235003C
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
030604060
Component:
061000 engine and engine cooling:engine
Summary:
Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt
Bulletin:
030234001A
Component:
017500 steering:linkages:tie rod assembly
Summary:
Inner tie rod released for service. *tt
Bulletin:
010730038B
Component:
103000 power train:automatic transmission
Summary:
The service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt
Bulletin:
030309002
Component:
020000 suspension
Summary:
Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
Bulletin:
01555
Component:
020000 suspension
Summary:
D height specification missing from si. sit bulletin 1410632. *tt
Bulletin:
01570
Component:
022000 suspension:rear
Summary:
Spring slap noise from the rear of the gmt 400 series truck. *mn
Bulletin:
00149D
Component:
110000 electrical system
Summary:
Malfunction indicator lamp on with a p0300 set and a misfire. various models including 1996 - 1999 p32 models. sit bulletin 1416475. *tt
Bulletin:
00969A
Component:
061000 engine and engine cooling:engine
Summary:
Engine whistle noise. *tt
Bulletin:
00822B
Component:
100000 power train
Summary:
No 2nd, no 4th and no reverse. to include 2004 light duty automobiles and trucks equipped with 4l60e or 4l65e automatic transmission. *tt
Bulletin:
01484
Component:
061000 engine and engine cooling:engine
Summary:
Gen iii replacement flywheel bolt holes larger than original part. the bolt holes for the crank shaft in the replacement flywheel are larger than the holes in the original part. sit bulletin 1400596. *tt
Bulletin:
3259C
Component:
103000 power train:automatic transmission
Summary:
4l80e, 4l85e whine noise in first and second gear. *tt
Bulletin:
030310006
Component:
020000 suspension
Summary:
Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin:
030730056
Component:
103000 power train:automatic transmission
Summary:
4l60-e automatic transmission oil pump first and second design identification. *tt
Bulletin:
030605008B
Component:
063000 engine and engine cooling:exhaust system
Summary:
Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt
Bulletin:
020526001B
Component:
040000 service brakes, air
Summary:
Rear parking brake shoe retaining spring clip service kit for drum-in-hat (dih) equipped vehicles. *tt update. *tt
Bulletin:
01698
Component:
131000 visibility:windshield
Summary:
Windshield reveal molding flutering. service vme. sit bulletin 1450940. *tt
Bulletin:
01712
Component:
021000 suspension:front
Summary:
Left front of vehicle sits low. sit bulletin 1454860. *tt
Bulletin:
10012003
Component:
062000 engine and engine cooling:cooling system
Summary:
Blueheat coolant heater thermo top c. webasto. *mr
Bulletin:
01848
Component:
198000 tires:temporary/emergency spare tire
Summary:
Spare tire flexible tool availability. *mr
Bulletin:
01634
Component:
010000 steering
Summary:
Intermediate steering shaft service kit. service vme. *tt
Bulletin:
01599
Component:
100000 power train
Summary:
4l60e, 4l65e forward and low reverse waved steel clutch plate appearance change. *tt
Bulletin:
01634A
Component:
010000 steering
Summary:
Supplement to 00-02-35-003d - clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin:
01222A
Component:
107000 power train:axle hubs
Summary:
Repeat rear axle hub seal leak. *tt
Bulletin:
01119A
Component:
061000 engine and engine cooling:engine
Summary:
Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt
Bulletin:
00700A
Component:
061000 engine and engine cooling:engine
Summary:
4.3l l35 engine wide open throttle diagnostic trouble code (dtc) p0335, p0336, p0339. *tt *mj
Bulletin:
00632
Component:
110000 electrical system
Summary:
4.3l l35 engine-diagnostic trouble code p0300 but no misfire can felt. *mj
Bulletin:
00677
Component:
980000 unknown or other
Summary:
Snow plow prep package information - service vme. *mj
Bulletin:
01225
Component:
060000 engine and engine cooling
Summary:
Engine coolant leak at intake gasket. * mj
Bulletin:
02053
Component:
030000 service brakes, hydraulic
Summary:
Information on resurfacing the park brake portion of the rear brake rotor. *tt
Bulletin:
02072
Component:
110000 electrical system
Summary:
Supplement to 02029 update calibration will not complete programming. *tt
Bulletin:
02076
Component:
198000 tires:temporary/emergency spare tire
Summary:
Recent shipment of flexible spare tire hoist tool. service vme. *tt
Bulletin:
02086
Component:
100000 power train
Summary:
4l60e, 4l65e intermittent neutral from a stop or steady speed. *tt
Bulletin:
990730016A
Component:
100000 power train
Summary:
Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan. *tt
Bulletin:
01353
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire due to injector fretting corrosion. *tt
Bulletin:
040495001
Component:
105300 power train:driveline:driveshaft
Summary:
Revised wheel drive shaft nut torque specification. *tt
Bulletin:
040525002B
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
Bulletin:
3015
Component:
061000 engine and engine cooling:engine
Summary:
6.0l lq4 vin u engine restriction. *tt
Bulletin:
3025
Component:
220000 seats
Summary:
Repairing cloth seats with napped fabric. *mj
Bulletin:
3028
Component:
022000 suspension:rear
Summary:
Replacement tailgate cables bind at shoulder bolt. *mj
Bulletin:
3002
Component:
100000 power train
Summary:
4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
Bulletin:
3012B
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
The nvg 136 all wheel drive (awd) transfer case and the 236 and 246 nvg selectable transfer cases operating in the auto mode may exhibit a condition of a vibration/shudder during low speed turns such as a parking lot maneuver, up to approxi
Bulletin:
3009A
Component:
020000 suspension
Summary:
Suspension vibration or frame beaming at 40 -60 mph. *mj
Bulletin:
00313
Component:
020000 suspension
Summary:
Squeak or creak noise from underbody over bumps. *mj
Bulletin:
3001
Component:
106000 power train:axle assembly
Summary:
The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
Bulletin:
3000A
Component:
022000 suspension:rear
Summary:
Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin:
3045
Component:
200000 wheels
Summary:
Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
Bulletin:
3046A
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Fuel gauge fluctuation in park or neutral. *tt
Bulletin:
3050
Component:
110000 electrical system
Summary:
Campaign 02029 update - calibration will not complete programming. *tt 3050a update dated 01/01/04 replaced. *sc
Bulletin:
3047
Component:
103000 power train:automatic transmission
Summary:
Harsh tcc apply and or a diagnostic trouble code p1870. 4l80e automatic transmission. *tt
Bulletin:
10222002
Component:
132000 visibility:glass, side/rear
Summary:
Rear quarter glass service replacement kits may have deformed sealing striped when initially removed from their packaging causing dealers to reorder. *tt
Bulletin:
3086
Component:
353600 equipment:air conditioner
Summary:
Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
Bulletin:
3073
Component:
185000 vehicle speed control:cruise control
Summary:
Downhill cruise control surge. *tt
Bulletin:
3038
Component:
061000 engine and engine cooling:engine
Summary:
Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt
Bulletin:
3054
Component:
100000 power train
Summary:
Replacement flexplate may have larger bolt holes than the original flexplate. *tt
Bulletin:
3055
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
Bulletin:
3128
Component:
160000 structure
Summary:
All full size trucks pick up box sheet metal fracture/damage with aftermarket accessories installed. *sc
Bulletin:
3147
Component:
060000 engine and engine cooling
Summary:
Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc
Bulletin:
3121
Component:
060000 engine and engine cooling
Summary:
Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
Bulletin:
3119
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Engineering investigation - catalytic converter replacement. *sc
Bulletin:
3168
Component:
110000 electrical system
Summary:
Traction off lamp being illuminated. supplement to tsb: 03-05-25-002. *tc
Bulletin:
3047
Component:
103000 power train:automatic transmission
Summary:
00-01 4l80-e automatic transmission may experience a harsh tcc apply and/or diagnostic trouble code p1870 or p074. *tc
Bulletin:
3107
Component:
060000 engine and engine cooling
Summary:
P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
Bulletin:
3156
Component:
100000 power train
Summary:
261 transfer case drivelines growl 1100-1200 rpm. *tt
Bulletin:
3056
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
Bulletin:
3081
Component:
061000 engine and engine cooling:engine
Summary:
Service engine soon light and p0300 when towing, cruising uphill or on hard acceleration. *tt
Bulletin:
04007A
Component:
162500 structure:body:tailgate
Summary:
Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
Bulletin:
040523001A
Component:
030000 service brakes, hydraulic
Summary:
Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
Bulletin:
040864003
Component:
133000 visibility:power window devices and controls
Summary:
Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
Bulletin:
040138010
Component:
353600 equipment:air conditioner
Summary:
Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
Bulletin:
000235003E
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in steering wheel. this bulletin replaces previous bulletin 00-02-35-003e. *tt
Bulletin:
3232
Component:
060000 engine and engine cooling
Summary:
Misfire at idle cold and possible p0171 and or p0174. *eh
Bulletin:
3227
Component:
162500 structure:body:tailgate
Summary:
Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
Bulletin:
000235003
Component:
010000 steering
Summary:
Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
Bulletin:
040850011
Component:
150000 seat belts
Summary:
Repairing napped seat fabric. *eh
Bulletin:
040523005
Component:
030000 service brakes, hydraulic
Summary:
Availability of rear wheel mud flaps to reduce debris build-up on rear brake calipers and/or rear wheels. *tt
Bulletin:
040604040
Component:
061000 engine and engine cooling:engine
Summary:
Idle instability, low or rough idle with electronic throttle control. *tt
Bulletin:
030310002
Component:
190000 tires
Summary:
Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
Bulletin:
030310006D
Component:
190000 tires
Summary:
20 inch wheels and tires available through gmspo. *eh *tt
Bulletin:
040139007
Component:
353600 equipment:air conditioner
Summary:
Loss of heating ventilation air conditioning. system mode and or temperature control. *eh
Bulletin:
040848003
Component:
131000 visibility:windshield
Summary:
Windrush around windshield. *tt
Bulletin:
030236002
Component:
010000 steering
Summary:
Revised steering wheel position sensor or steering shaft lower bearing replacement procedure and steering wheel position sensor centering procedure. *eh
Bulletin:
040310002
Component:
020000 suspension
Summary:
New flexible spare tire hoist tool available to assist in lowering/removing spare tire. *tt
Bulletin:
040603002
Component:
060000 engine and engine cooling
Summary:
Diagnostic information for intermittent vehicle no crank dead battery. *eh
Bulletin:
01292004
Component:
133000 visibility:power window devices and controls
Summary:
Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
Bulletin:
05062004
Component:
355200 equipment:other:owners/service/other manual
Summary:
Flexible spare tire hoist tool. *eh
Bulletin:
3300C
Component:
341000 communications:horn assembly
Summary:
Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
Bulletin:
3373
Component:
140000 air bags
Summary:
Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
Bulletin:
3386
Component:
015000 steering:hydraulic power assist system
Summary:
Lack of steering assist or shudder during parking lot type maneuvers. *tt
Bulletin:
3300
Component:
105000 power train:driveline
Summary:
4wd models with noise, vibration on dry pavement. *eh
Bulletin:
05001
Component:
015000 steering:hydraulic power assist system
Summary:
Hydraulic pump driveshaft that can fracture resulting in an immediate loss of hydraulic power steering assist. message to chevrolet and gmc dealers about upcoming customer satisfaction program 05001. *tt
Bulletin:
3464
Component:
162310 structure:body:door:hinge and attachments
Summary:
Door hinge replacement kit. *tt
Bulletin:
3349
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
4wd inoperative and diagnostic trouble code (dtc) u1026 atc fuse open. *tt
Bulletin:
3232
Component:
061000 engine and engine cooling:engine
Summary:
1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
Bulletin:
020307002
Component:
020000 suspension
Summary:
Revised front caster and camber adjustment procedure. original not yet received. *tt
Bulletin:
3364
Component:
106000 power train:axle assembly
Summary:
Rear axle retainer button breakage. *eh
Bulletin:
040604088
Component:
060000 engine and engine cooling
Summary:
Replacement of connector when replacing fuel tank module/fuel pump module. *tt
Bulletin:
050864007
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Outside rearview mirror housings come loose from base. *tt
Bulletin:
510
Component:
220000 seats
Summary:
Repairing napped fabric-seats may have been upholstered in napped fabrics with dorchester on the bolster and honeycomb on the insert. *sc
Bulletin:
3526
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
Bulletin:
3389
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Four wheel drive inoperative and the 4wd service light will illuminate. diagnosis may reveal that the atc fuse could be open, possible dtc c0308, or various u codes may be set. the encoder motor may also be shorted or the tccm may be dama
Bulletin:
05068
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Product safety recall regarding front wheel speed sensor corrosion. *tt
Bulletin:
3267
Component:
061000 engine and engine cooling:engine
Summary:
Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc
Bulletin:
3325
Component:
090000 fuel system, other
Summary:
Supplement to bulletin 99-06-04-047a for fuel system cleaning. *tt
Bulletin:
3455
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Supplement to 04094 front wheel speed sensor corrosion. *tt
Bulletin:
3424
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Electronic transfer case unable to complete shift. *tt
Bulletin:
050310005
Component:
200000 wheels
Summary:
Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
Bulletin:
050850012
Component:
220000 seats
Summary:
Unwanted/loose seat movement. *tt
Bulletin:
3777
Component:
110000 electrical system
Summary:
Fuel and temperature gauge inoperative, low fuel and battery light on, prndl inoperative. *tt
Bulletin:
3782
Component:
122000 exterior lighting:fog lights
Summary:
Fog lamps inoperative. *tt
Bulletin:
3170E
Component:
121000 exterior lighting:headlights
Summary:
Ipc, interior lights and/or headlamps flicker. *ak fb2
Bulletin:
3691B
Component:
061000 engine and engine cooling:engine
Summary:
Generation iii v8 engine piston repairs. *tt
Bulletin:
3340
Component:
021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary:
Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
Bulletin:
3009
Component:
020000 suspension
Summary:
Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe
Bulletin:
4231
Component:
061000 engine and engine cooling:engine
Summary:
Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
Bulletin:
3300
Component:
341000 communications:horn assembly
Summary:
Horn inoperative at times. *kb
Bulletin:
070232001
Component:
010000 steering
Summary:
Reduced steering effort (diagnose/replace steering wheel position sensor). *kb
Bulletin:
4030
Component:
106000 power train:axle assembly
Summary:
New design front axle side bearing adjusters. *kb
Bulletin:
040525002
Component:
046400 service brakes, air:antilock:abs warning light
Summary:
Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
Bulletin:
PIP4054A
Component:
022000 suspension:rear
Summary:
Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin:
000235003N
Component:
012000 steering:column
Summary:
Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin:
08-089
Component:
353000 equipment:electrical
Summary:
Buick\cadillac\chevrolet\gmc\hummer\oldsmobile\pontiac\saab\saturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin:
PIT-3046E
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin:
PIT-4722
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
Bulletin:
08-089B
Component:
355200 equipment:other:owners/service/other manual
Summary:
Buick\chevrolet\gmc service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. csc letter was received. *pe
Bulletin:
08089-B
Component:
110000 electrical system
Summary:
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin:
SB-10-02-33-001
Component:
010000 steering
Summary:
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin:
PIP-4138K
Component:
060000 engine and engine cooling
Summary:
Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin:
09-09-40-001A
Component:
150000 seat belts
Summary:
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin:
10-00-89-017C
Component:
980000 unknown or other
Summary:
Gm: information on fixing multiple situations right the first time. *rm
Bulletin:
PI-0011A
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
Bulletin:
SB-10-08-50-003B
Component:
221300 seats:front assembly:head restraint
Summary:
General motors: information provided by bulletin for all 2012 and prior general motor trucks and passenger vehicles regarding the adjustable comfort and custom upholstery of the driver and the passenger head restraint. *pe
Bulletin:
SB-13-05-22-001
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Chevrolet/gmc/cadillac: anytime hydraulic brake pipes assembly need replacing, pre-formed and pre-flared brake pipes are available, except rear axle crossover pipe. model 1999-2007 silverado, sierra, 2000-2006 escalade models, avalanche,
Bulletin:
06-03-09-004H
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.
Bulletin:
PIT3227J
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
03-08-46-004R
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on part restriction and ordering process information for onstar vehicle communication interface modules (vcim) (gmna only)
Bulletin:
PIT3237G
Component:
131000 visibility:windshield
Summary:
This preliminary information communication provides information to the technician about the percentage of uv protection or tint offered by the windshield or side glass. technician should be advised windshield reduces uv rays down to 4% or l
Bulletin:
PIP5072
Component:
101000 power train:clutch assembly
Summary:
This preliminary information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. technician will inspect the 3-4 clutches and the forward clutch
Bulletin:
PIT3665C
Component:
030000 brakes (pws)
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT3271F
Component:
190000 tires
Summary:
This preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed fo
Bulletin:
PIP3259J
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. technician should compare the noise to a like vehicle. technician will nee
Bulletin:
PIP4138L
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
Bulletin:
PIT3665E
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIT3227M
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. technician should not replace any parts for this concern. please communicate to the customer
Bulletin:
15-08-44-001B
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
15-08-44-001A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This informational bulletin provides information on a gm of canada onstar® cellular communication upgrade.
Bulletin:
05-06-04-035E
Component:
090000 fuel system, other
Summary:
This informational bulletin provides dealership personnel with information on flexible fuel vehicles (ffvs) and the usage of e85 fuel in gm vehicles.
Bulletin:
15-08-73-001
Component:
353000 equipment:electrical
Summary:
This informational bulletin provides information on communication with onstar® module after canadian cellular upgrade.
Bulletin:
PIC4310K
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC3278F
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. technician will need to determine what type of call the cu
Bulletin:
PIT5264C
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that are travelling from canada to the united states. while in the united states they are unable to receive turn-by-turn directions. due to the
Bulletin:
PIC5953A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIC4310L
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech

Home | Privacy