1999 MERCURY MYSTIQUE Recalls (4)

Campaign:
99V060000 on 03/24/1999
Component:
Electrical system:ignition:switch
Manufactured:
01/03/1999 - 01/13/1999
Affected:
4,569
Defect:
Vehicle description: passenger vehicles built with automatic transmissions which utilize a park/lock solenoid. it is possible to rotate the ignition key to the lock position and remove the key without the shift lever and transmission being in park. these vehicles do not comply with the requirements of fmvss no. 114, "theft protection."
Consequence:
This could result in a crash and possible personal injury.
Correction:
Dealers will inspect these vehicles. vehicles that have units with ignition keys removable in gear positions other than park, will have the steering column replaced.
Notes:
Owner notification began march 26, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V075000 on 03/13/2000
Component:
Service brakes, hydraulic:foundation components
Manufactured:
08/01/1998 - 02/28/2000
Affected:
436,200
Defect:
Vehicle description: passenger vehicles not equipped with the anti-lock braking system (abs). a pressure conscious reducing valve (pcrv) in the rear brakes may be subject to corrosion and result in malfunction, when operated in areas that use salt compounds on the roadway for de-icing or dust control.
Consequence:
If both pcrv's malfunction, vehicle handling could be adversely affected during braking as a result of the rear wheels locking, increasing the risk of a crash.
Correction:
Dealers will install improved pcrv's in the rear brake system. this recall was expanded in september 2000 to include 1999 and 2000 ford contour, mercury mystique and cougar vehicles.
Notes:
Owner notification began april 3, 2000 for the 1996-1998 model vehicles and on october 11, 2000, for the 1999-2000 model vehicles.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E022000 on 03/12/2006
Component:
Service brakes, hydraulic
Affected:
7,440
Defect:
Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.
Consequence:
Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
Correction:
Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.
Notes:
This recall only pertains to aftermarket napa, raybestos, ac delco, aimco, carquest, and bendix brake hydraulic master cylinders and has no relation to any original equipment installed on daimlerchrysler or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E033000 on 04/16/2008
Component:
Suspension
Affected:
6,903
Defect:
Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between november 9, 2007 and march 26, 2008, which may have been packaged with incorrect nuts. the part numbers packaged with incorrect nuts are: k7147, k7329, k8683, and 104353. these parts were made for use on the various vehicles listed above.
Consequence:
The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. if the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. this may result in loss of vehicle control, possibly resulting in a vehicle crash.
Correction:
Federal mogul will notify owners and replace the parts free of charge. the recall began on may 22, 2008. owners can contact federal mogul at 877-489-6659.
Notes:
This recall only pertains to aftermarket ball joint assemblies and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1999 MERCURY MYSTIQUE TSBs (170)

Bulletin:
982511
Component:
980000 unknown or other
Summary:
Information on performing diagnosis or programming keys on some 1998 vehicles. *yc
Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
982510
Component:
062000 engine and engine cooling:cooling system
Summary:
Information regarding revised water pump replacement procedure. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982311
Component:
106000 power train:axle assembly
Summary:
Minimal clearance of the cd4e transaxle to subframe makes transaxle installation and removal more difficult. *yc
Bulletin:
98242
Component:
106000 power train:axle assembly
Summary:
Powertrain control module (pcm) reprogramming information when replacing transaxle. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9949
Component:
116200 electrical system:ignition:module
Summary:
Conditions with diagnostic trouble code (dtc) p0460 stored in continuous memory without any driveability concerns. *tt
Bulletin:
99B06
Component:
062000 engine and engine cooling:cooling system
Summary:
Concerns with coolant leaks under severe operating conditions. *tt
Bulletin:
5795
Component:
011000 steering:wheel and handle bar
Summary:
Information on service replacement of the steering column gap hider. *tt
Bulletin:
5823
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with a cd4e transaxle may exhibit a transmission no forward engagement. *tt
Bulletin:
5849
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a left air conditioning panel register discharge temperature that is warmer than the center and / or right vents. *tt
Bulletin:
12498
Component:
011000 steering:wheel and handle bar
Summary:
Subject on steering column gap hider service replacement. *tt
Bulletin:
12552
Component:
980000 unknown or other
Summary:
Information update on programming key fobs. *tt
Bulletin:
12597
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Information on installing fuses at pre-delivery. *tt
Bulletin:
12598
Component:
106000 power train:axle assembly
Summary:
Information regarding two cd4e transaxles added to ford quality renewal (fqr) program. *tt
Bulletin:
9989
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a groaning noise from the front brakes during city driving. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99105
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a malfunction indicator lamp on and diagnostic trouble codes p1381 and / or p1383 stored in memory. the vehicle may also have a rough idle or reduced power condition, and / or may stall at an idle. *tt
Bulletin:
99137
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit a no forward engagement. *tt
Bulletin:
99138
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
A rough idle, stalling at an idle, reduced power and / or malfunction indicator lamp (mil) with diagnostic trouble codes (dtcs) p1381 and p1383 may be stored im memory on some vehicles. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6457
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may have a slight engine rpm flare on a 2-3 upshift at altitude. *tt
Bulletin:
12846
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Subject on installing fuses at pdi (pre-delivery inspection). *tt
Bulletin:
12880
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing slight engine rpm flare on a 2-3 upshift at altitude. *tt
Bulletin:
12888
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Concerns with fuel filler door not closing properly. *tt
Bulletin:
12896
Component:
162000 structure:body
Summary:
Concerns with glovebox squeak and rattle. *tt
Bulletin:
996041
Component:
102000 power train:manual transmission
Summary:
Vehicles may exhibit a hard to shift condition in cold weather. *tt
Bulletin:
99172
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit higher than expected engine rpm increase during a 2-3 upshift. *tt
Bulletin:
99175
Component:
106000 power train:axle assembly
Summary:
Some vehicles may have no forward engagement movement occurring although reverse engagement may be possible due to overdrive / reverse ring gear assembly causing a wobble and side loading of the forward clutch snap ring retainer. *tt
Bulletin:
99178
Component:
114200 electrical system:wiring:interior/under dash
Summary:
On some vehicles, a diagnostic trouble code (dtc) p0325 (knock sensor circuit malfunction) may appear during koer, but further testing determines the knock sensor to be satisfactory. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
99148
Component:
106000 power train:axle assembly
Summary:
Some 2.5l vehicles equipped with mtx-75 transaxle may not move. this may be caused by the differential gear failing. *tt
Bulletin:
9913136
Component:
185000 vehicle speed control:cruise control
Summary:
Concerns with vehciles equipped with 2.0l engines built from 5/3/99 to 7/26/99 exhibiting a hestation / stumble or rough running. *tt
Bulletin:
9913137
Component:
113000 electrical system:starter assembly
Summary:
Concerns with 2.5l engine equipped vehicles and cd4e transaxle exhibiting a starter grinding noise and / or lack of starter drive engagement. *tt
Bulletin:
9913139
Component:
141000 air bags:frontal
Summary:
Some vehicles may experience a "buzz" or "rattle" type noise from the right side area of the instrument panel at the passenger air bag above the glove box. *tt
Bulletin:
99204
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
A condition with fuel filler door unable to close completely. *tt
Bulletin:
99215
Component:
162300 structure:body:door
Summary:
Subject regarding vehicles that have water leaking onto front floor from door panel area. *tt
Bulletin:
99217
Component:
980000 unknown or other
Summary:
Subject regarding the check engine light may illuminate with one or more ignition coil diagnostic trouble codes that may include p0351, p0352 and / or po0353 with no associated coil on plug issues. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99237
Component:
063000 engine and engine cooling:exhaust system
Summary:
Objectionable exhaust, sulfur, or rotten egg odor aggressive driving on vehicles with 2.5l engine and cd4e transaxle. *tt
Bulletin:
99248
Component:
330000 interior lighting
Summary:
Concerns with the interior lamp staying on. *tt
Bulletin:
99249
Component:
103000 power train:automatic transmission
Summary:
This bulletin addresses an issue with the automatic transmission fluid seeping from the vent, resulting in fluid collecting on the main control assembly. *tt
Bulletin:
6904
Component:
180000 vehicle speed control
Summary:
Exhibiting a hesitation / stumble or rough running on vehiles with 2.0l engines built from 5/3/1999 to 7/26/1999. *tt
Bulletin:
6906
Component:
113000 electrical system:starter assembly
Summary:
Exhibiting a starter grinding noise and / or lack of starter drive engagement. *tt
Bulletin:
6907
Component:
980000 unknown or other
Summary:
Exhibiting a buzz or rattle type noise from the right side area of the instrument panel. *tt
Bulletin:
13209
Component:
022000 suspension:rear
Summary:
Information regarding rear spring creak/squeak. *mjs
Bulletin:
7132
Component:
020000 suspension
Summary:
Vehicles may exhibit a creaking or squeaking type noise from the rear suspension. *tt
Bulletin:
7249
Component:
353600 equipment:air conditioner
Summary:
Information on using peanut style a/c fittings. *tt
Bulletin:
7311
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles with cd4e automatic transacle may exhibit an objectionable sulfur or rotten egg odor from the exhaust following aggressive driving. *tt
Bulletin:
13336
Component:
350000 equipment
Summary:
Information on activating octane adjust function with ngs/sbds. *tt
Bulletin:
13364
Component:
020000 suspension
Summary:
Customer may comment on vibration at 60 - 70 mph at cruise. *tt
Bulletin:
13386
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on investigating hard start / no start conditions accompanied by overfueling in ambients below 32f/0c, on vehicles with vct equipped 2.0l zetec engines. *tt
Bulletin:
98164
Component:
162000 structure:body
Summary:
A transeal coating is on the front and rear bumpers. this coating must be removed before delivery to the customer. yd
Bulletin:
6501
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
Some vehicles built between 7/1/98 and 12/31/98 may exhibit a fuel filler door not closing properly. *tt
Bulletin:
6509
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a glovebox squeaking or rattle noise as the vehicle is driven over bumps. *tt
Bulletin:
6546
Component:
350000 equipment
Summary:
Some vehicles may exhibit a concern in activating the octane adjust feature when using the module reconfiguration method. *tt
Bulletin:
6555
Component:
022000 suspension:rear
Summary:
Some vehicles may exhibit a creaking or squeaking type noise from the rear suspension. *tt
Bulletin:
6576
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information regarding engine oil leak diagnosis. *tt
Bulletin:
11725
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a knocking or clunking sound during rapid acceleration / deceleration as when letting off and putting your foot down on the accelerator quickly. *tt
Bulletin:
12917
Component:
182000 vehicle speed control:linkages
Summary:
Some vehicles may exhibit a concern in activating the octaine adjust feature when using the module reconfiguration method. *tt
Bulletin:
7344
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration at 60-70 mph. *tt
Bulletin:
7349
Component:
105000 power train:driveline
Summary:
Some vehicles equipped with 2.5l engine and cd4e transmission may exhibit a driveline rattle or clunking type noise during tip-in or transmission gear engagement. *tt
Bulletin:
7430
Component:
180000 vehicle speed control
Summary:
Information regarding speed control switch voltage readings - service tip. *tt
Bulletin:
7451
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 2.0l engine may exhibit a timing belt shredding or timing belt striking the front cover. *tt
Bulletin:
13542
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Experiencing an intermittentnoise described as a buzz or rattle from the center of the instrument panel or behind the cluster area. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
8054
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with a 2.5l engine and built after may 5, 1999 may exhibit an intermittent hard / no start, rough idle or hesitation after a hot soak of approximately 30 minutes. *tt
Bulletin:
0019
Component:
106000 power train:axle assembly
Summary:
Information regarding several internal changes that have been implemented on the mrx-75 transaxle to improve shift efforts. *mjs
Bulletin:
8128
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may experience a hoot noise from the idle idle air bypass solenoid on deceleration, usually in cold ambient temperatures. the idle speed may also remain slightly higher or lower than desired when this noise is present.
Bulletin:
0037
Component:
980000 unknown or other
Summary:
Vehicle may experience the malfunction inciator lamp (mil) illumination with diagnostic trouble codes (dtcs). *mjs
Bulletin:
0041
Component:
138000 visibility:defroster/defogger system
Summary:
Vehicle may experience fluttering noise heard from heater plenum area vehicles built from 11/2/1998 through 12/22/1998. *mjs
Bulletin:
7923
Component:
101000 power train:clutch assembly
Summary:
Clutch will not engage after service.
Bulletin:
13866
Component:
185000 vehicle speed control:cruise control
Summary:
Experiencing a hoot noise from the idle idle air bypass solenoid on deceleration, usually in cold ambient temperatures. *tt
Bulletin:
8299
Component:
022000 suspension:rear
Summary:
Some vehicles may exhibit a creaking or squeaking type noise from the rear suspension occurring over bumps during low speed maneuvers only. *tt
Bulletin:
8334
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 2.5 engine and built after may 25, 1999 may exhibit an intermittent hard / no start, rough idle or hesitation after a hot soak of approximately 30 minutes. *tt
Bulletin:
13761
Component:
101000 power train:clutch assembly
Summary:
Some vehicles equipped with 2.0l engines may exhibit symptoms of clutch slippage or no clutch engagement after performinb repairs to the clutch system. *mjs
Bulletin:
13830
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 2.5l engine and built after may 5, 1999 may exhibit an intermittent hard/no start, rough idle or hesitation after a hot soak of approxinately 30 minutes. *mjs
Bulletin:
12119
Component:
103000 power train:automatic transmission
Summary:
Some vehicles transmissions may exhibit a transmission fluid leak. *mjs
Bulletin:
12122
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information regarding the diagnosis and service to the integrated passive anti-theft system (ipats). *mjs
Bulletin:
12135
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a concern where the malfunction indicator lamp (mil) is illuminate with dtcs in the memory. *mjs
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
985104
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles may exhibit a concern with unable to program passive anti-theft system (pats) keys. *tt
Bulletin:
985136
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles with cd4e transmission may exhibit a transmission fluid leak. *tt
Bulletin:
985154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on diagnosing and servicing the integrated passive anti-theft system (ipats). *tt
Bulletin:
985184
Component:
980000 unknown or other
Summary:
Vehicles may exhibit a concern where the malfunction indicator lamp (mil) is illuminated with one or more diagnostic trouble codes: p0117, p0122, p0141, p0174-p0175, p0300-p0306, p0320, p0340, p0350-p0360, p0385, p1504-p1507, and p1518-p15
Bulletin:
8299
Component:
022000 suspension:rear
Summary:
Some vehicles may exhibit a creaking noise or squeaking type noise from the rear suspension. **mr
Bulletin:
8571
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a rough idle or hesitation after a hot soak of approximately 30 minutes. **mr
Bulletin:
14077
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a rough idle or hesitation after a hot soak at approximately 30 minutes. **mr
Bulletin:
6201
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Experiencing a front brake groan during city driving. *tt
Bulletin:
6243
Component:
162700 structure:body:trunk lid
Summary:
Online service information pertaining to various decklid release issues. *tt
Bulletin:
6707
Component:
350000 equipment
Summary:
Concerns with activating the octane adjust function with ngs or sbds. *tt
Bulletin:
12707
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a front brake groan. *tt
Bulletin:
12726
Component:
162700 structure:body:trunk lid
Summary:
Information regarding decklid release issues. *tt
Bulletin:
5963
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Information on installing fuses at pre-delivery. *tt
Bulletin:
12519
Component:
106000 power train:axle assembly
Summary:
Cd4e transaxle may exhibit a no forward drive concern. *tt
Bulletin:
12525
Component:
353600 equipment:air conditioner
Summary:
Concerns with the left air conditioning panel register discharge temperature that is warmer than the center and / or right vents. *tt
Bulletin:
13034
Component:
980000 unknown or other
Summary:
Exepriencing an intermittent malfunction indicator lamp on with diagnostic trouble codes p0351, p0352, and / or p0353. *tt
Bulletin:
12866
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with slight engine rpm flare on a 2-3 upshift at altitude. *tt
Bulletin:
13355
Component:
353600 equipment:air conditioner
Summary:
Information regarding a/c peanut o-ring color. *tt
Bulletin:
13399
Component:
182000 vehicle speed control:linkages
Summary:
Some vehicles with cd4e automatic transaxle, may exhibit an objectionable sulfur or rotten egg odor from the exhaust following aggressive driving, such as full-throttle acceleration. *tt
Bulletin:
13454
Component:
180000 vehicle speed control
Summary:
Subject regarding the speed control switch voltage readings - service tip. *tt
Bulletin:
13468
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 2.0l engine may exhibit a timing belt shredding or timing belt striking the front cover. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4674
Component:
102000 power train:manual transmission
Summary:
Some vehicles with cd4e transmission may exhibit a condition of no crank / no start in park. vehicle will crank and start in neutral. *tt
Bulletin:
4712
Component:
140000 air bags
Summary:
Information on air bag restraint system changes. *tt
Bulletin:
11791
Component:
102000 power train:manual transmission
Summary:
Some vehicles with cd4e transmission may exhibit a condition of no crank / no start in park. vehicle will crank and start in neutral. *tt
Bulletin:
11820
Component:
140000 air bags
Summary:
Subject regarding air bag restrain system changes. *tt
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5350
Component:
150000 seat belts
Summary:
Information used when servicing the restraint control module (rcm). *tt
Bulletin:
5375
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Brief information regarding the new single point crash sensing system. *tt
Bulletin:
12267
Component:
150000 seat belts
Summary:
Information on servicing the restraint control module (rcm) with the new generation star tester (ngs) and software version 14.0. *tt
Bulletin:
12291
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Brief information regarding vehicles equipped with the new single point crash sensing system. *tt
Bulletin:
00252
Component:
063000 engine and engine cooling:exhaust system
Summary:
On some vehicles, an objectionable exhaust, sulfur, or rotten egg odor following aggressive driving, such as full-throttle acceleration may occur. *tt
Bulletin:
14596
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhibiting one or multiple studs break on exhaust flanges. *jb
Bulletin:
0114
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a spark knock or pre-ignition condition on vehicles with an automatic or manual transmission during steady cruise driving or under light acceleration. *tt
Bulletin:
00S03
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Safety recall pertaining to brake pressure control reducing valve replacement. *jb
Bulletin:
00182
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit no forward gear ranges due to the misalignment of the forward / coast clutch cylinder snap ring with respect to the legs of the forward clutch piston. *jb
Bulletin:
00186
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles may experience no start condition when the wiper switch is in the intermittent or low-speed setting during vehicle start-up. *jb
Bulletin:
14355
Component:
061000 engine and engine cooling:engine
Summary:
Information pertaining to duratec oil pan investigation. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14836
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles equipped with cd4e transaxle, (does not apply to mtx) may exhibit a power steering grunt / moan type noise when returning from a right turn. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
14775
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
Some vehicles equipped with daytime running lamps (drl) may exhibit the high beam indicator in the instrument cluster flashing when the daytime running lamps are on. *tt
Bulletin:
14877
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some vehicles may illuminate the malfunction indicator lamp or run rough after the catalyst is removed and / or replaced. this may be due to vacuum leaks as a result of tolerance stackup within the exhaust / egr / intake system.
Bulletin:
15065
Component:
138000 visibility:defroster/defogger system
Summary:
Some vehicles may exhibit a/c discharge air temperatures differences of greater than 10 degrees f from registers on left side of dash than on right. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01B78
Component:
980000 unknown or other
Summary:
Some vehicles may experience warpage of the instrument panel cover at the front edge of the instument panel cover near the windshield, above the instrument cluster and around the glove compartment. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15241
Component:
021600 suspension:front:wheel bearing
Summary:
Some vehicles may exhibit a noise that appears to come from the front wheel bearings. *tt
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15241
Component:
021600 suspension:front:wheel bearing
Summary:
Some vehicles may exhibit a noise that appears to come from the front wheel bearings. *tt
Bulletin:
15390
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some vehicles may exhibit a check engine light and/or egr diagnostic trouble codes 332, p0401, p1407 (lackof egr flow). *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
01B78
Component:
980000 unknown or other
Summary:
Owner notification program 01b78 supplement #1 regarding instrument panel cover warpage. *tt
Bulletin:
0224
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with the cd4e transaxle may exhibit harsh and delayed 1-2/2-3 upshifts after transaxle or turbine shaft speed sensor replacement, possible diagnostic trouble codes 628, 642, 645, 646, 647, 648, p0731, p0732, p0734, p0
Bulletin:
15636
Component:
120000 exterior lighting
Summary:
Concern with headlamps and/or instrument panel lamps dimming slightly at idle. *tt
Bulletin:
01B78
Component:
980000 unknown or other
Summary:
Subject regarding instrument panel cover warpage. *jg
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
16028
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 2.5l engine may exhibit multiple misfire diagnostic trouble codes with no driveability concerns noted. *tt
Bulletin:
15828
Component:
116200 electrical system:ignition:module
Summary:
Some vehicles may exhibit diagnostic trouble code b1213, b1342, b1601, b2431. *tt
Bulletin:
15830
Component:
111000 electrical system:battery
Summary:
Battery lamp on, however the charging system is functioning properly. *tt
Bulletin:
0346
Component:
160000 structure
Summary:
Instrument panel warpage repair. *tt *jb
Bulletin:
16880
Component:
110000 electrical system
Summary:
Inoperative shift interlock solenoid or repeat instrument interface module failure. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
031514
Component:
061000 engine and engine cooling:engine
Summary:
The malfunction indicator lamp (mil) may be illuminated and diagnostic trouble codes (dtcs) p1380, p1381, p1383, and/or p0340 may be stored in memory. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
17174
Component:
063000 engine and engine cooling:exhaust system
Summary:
Malfunction indicator lamp on and diagnostic trouble codes p0171/p0174 or p1072/p0175 stored in memory or as hard faults. hesitation, lack of power or runs rough condition. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
04104
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble code p0420 and/or p0430/ 2.5l engine only. *tt
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
022001
Component:
353000 equipment:electrical
Summary:
Replacement speaker installation tips. *tt
Bulletin:
041814
Component:
012000 steering:column
Summary:
Steering column shipped without crush pad - reuse original crush pad if not damaged. *tt
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt

Home | Privacy