1999 MERCURY MOUNTAINEER Recalls (9)

Campaign:
99V062001 on 03/30/1999
Component:
Vehicle speed control
Manufactured:
01/04/1998 - 03/03/1999
Affected:
898,739
Defect:
Vehicle description: certain 1997-1999 rhd explorer equipped with 4.0l ohv/sohc engines and cruise control built from may 29, 1996 through march 4, 1999; 1998-1999 explorer/mountaineers equipped with 4.0l ohv/sohc or 5.0l engines or 1998-1999 rangers equipped with 2.5l, 3.0l ffv/efi or 4.0l engines and cruise control built from january 5, 1998 through march 4, 1999; 1998-1999 mustangs equipped with 3.8l, 4.6l 2-valve or 4-valve engines and cruise control built from march 2, 1998 through march 4, 1999; 1999 f250/f350/f450/f550 (over 8,500 lbs.) trucks equipped with 5.4l or 6.8l engines and cruise control built from march 2, 1998 through march 4, 1999; and 1999 f-53 stripped chassis equipped with 5.4l or 6.8l engines and cruise control built from march 2, 1998 through march 4, 1999. a cruise control cable can interfere with the speed control servo pulley and not allow the throttle to return to idle when disengaging the cruise control.
Consequence:
If the cruise control is used and this condition is present, a stuck throttle could result, which could potentially result in a crash.
Correction:
Dealers will replace the cruise control cables. at the present time, the replacement cables are not available. customers are being advised not to use the cruise control system until a replacement can be made.
Notes:
A pre-release warning letter that identified an interim fix until the parts for the permanent fix became available was mailed to owners beginning march 27, 1999.a second owner notification, identifying the permanent fix was mailed to owners beginning may 24, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V123000 on 05/19/1999
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Manufactured:
04/15/1999 - 05/02/1999
Affected:
15,681
Defect:
Vehicle description: sport utility vehicles. the right front brake line to the hydraulic control unit (hcu) connection could separate causing the line to leak when the brake pedal is applied.
Consequence:
This could result in a loss of brake pressure to the front wheels, increasing the stopping distance.
Correction:
Dealers will replace the flare nut on the brake line.
Notes:
Owner notification began may 17, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V164000 on 06/29/1999
Component:
Latches/locks/linkages:hood:latch
Manufactured:
04/24/1997 - 05/16/1999
Affected:
854,288
Defect:
Vehicle description: sport utility vehicles. the secondary hood latch may corrode at the latch pivot and stick in the open position.
Consequence:
If this occurs and the primary hood latch is either not engaged or is released, a hood fly-up could occur.
Correction:
Dealers will install a secondary hood latch with components that are coated prior to assembly for improved latch pivot corrosion protection.
Notes:
Owner notification began july 14, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V072000 on 03/12/2000
Component:
Electrical system:fuses and circuit breakers
Manufactured:
09/13/1998 - 09/11/1999
Affected:
208,903
Defect:
Vehicle description: multi-purpose vehicles equipped with 4.0l engines and all-time 4-wheel drive (a4wd) powertrains. the generic electronic module (gem) could experience a condition referred to as "lock-up" in which the gem controlled electronic functions (e.g., front windshield wipers, interior lights, 4x4 system, etc.) could not be turned on or, in some cases if the function is on, could not be turned off.
Consequence:
An inoperative windshield wiper system could affect driver visibility, increasing the risk of a crash.
Correction:
Dealers will install a resistor in the gem circuit.
Notes:
Owner notification began april 15, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00T005000 on 08/09/2000
Component:
Tires:tread/belt
Affected:
14,400,000
Defect:
Tire description: firestone wilderness at, size p235/75r15, produced at the decatur, illinois tire plant and all firestone radial atx and radial atx ii tires, size p235/75r15. operation of these tires at low inflation pressures, high speed, and in hot weather, can contribute to separation of the tire tread.
Consequence:
If the tread separates from the tire, the driver can lose control of the vehicle, possibly resulting in a crash causing injury or death.
Correction:
The replacement/reimbursement program for this campaign expired on august 29, 2001. however, customers should contact firestone customer service at 1-800-465-1904 for possible assistance.
Campaign:
03V280000 on 08/06/2003
Component:
Vehicle speed control:cables
Manufactured:
03/04/1999 - 12/23/2000
Affected:
448,005
Defect:
On certain sport utility vehicles equipped with speed control and 4.0l sohc engines, if the strand cover on the speed control cable becomes flared at the end, the speed control cable may bind when the speed control is activated.
Consequence:
The throttle return spring force may not be sufficient to overcome the binding condition when the speed control is disengaged. braking function would be maintained though stopping distances may be increased.
Correction:
Dealers will inspect the speed control cable and, if necessary, replace it. owner notification began august 29, 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s03.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V281000 on 08/06/2003
Component:
Seats:front assembly:recliner
Manufactured:
05/12/1997 - 12/23/2000
Affected:
1,552,880
Defect:
On certain sport utility vehicles equipped with high back seats, the upper bolt on the driver's side high back seat, that attaches the seat recliner mechanism to the seat back frame, could fracture. if the bolt fractures and does not jam in the seat back frame, the seat back may recline until it makes contact with an object behind the seat, such as the second row seat cushion.
Consequence:
The driver could potentially lose contact with the steering wheel or foot pedals during such an event, increasing the risk of a crash.
Correction:
Dealers will replace the driver seat upper bolt with a metal spacer and bolt. in addition, seats with tubular back frames will have the fully threaded lower recliner bolt replaced with a partially threaded bolt. owner notification began on august 29, 2003. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s04.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E056000 on 06/22/2006
Component:
Fuel system, gasoline
Affected:
58,640
Defect:
Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence:
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Correction:
Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
Notes:
This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
06/15/1998 - 09/26/2000
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

1999 MERCURY MOUNTAINEER TSBs (341)

Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
982511
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tips on composite fuel rail. *yc
Bulletin:
982515
Component:
220000 seats
Summary:
Conditions with the front seat back lever bent. *yc
Bulletin:
98211
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a noise and vibration during idle.
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982019
Component:
221600 seats:front assembly:power adjust
Summary:
Concerns with the power seat control button ( knob ) may detach from the switch actuator. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9946
Component:
103000 power train:automatic transmission
Summary:
Concerns with transmission fluid leaking at radiator. *tt
Bulletin:
5506
Component:
106000 power train:axle assembly
Summary:
Vehicle may exhibit a high pitched squeal / whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt
Bulletin:
5652
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Complaints that the in-dash cd stops operating when hot. *tt
Bulletin:
5705
Component:
116200 electrical system:ignition:module
Summary:
Vehicle exhibiting multiple generic electronic module (gem) related symptoms. *tt
Bulletin:
5744
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a miss / rough idle with the malfunction indicator light on and diagnostic trouble code p0340 in self test. *tt
Bulletin:
5799
Component:
136000 visibility:windshield wiper/washer
Summary:
Complaints that the rear wiper blade flips over. *tt
Bulletin:
5814
Component:
103000 power train:automatic transmission
Summary:
Service tips for checking transmission fluid level. *tt
Bulletin:
5845
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with limited slip / traction-lock rear axles may exhibit a chatter noise while turning. *tt
Bulletin:
5915
Component:
020000 suspension
Summary:
Experiencing vibration at highway speeds due to tire / wheel imbalance. *tt
Bulletin:
5934
Component:
136000 visibility:windshield wiper/washer
Summary:
Complaints that the front wipers activate without command. *tt
Bulletin:
12551
Component:
183000 vehicle speed control:cables
Summary:
Vehicle exhibiting a vibration or buzz felt through the accelerator pedal or front floorboard area. *tt
Bulletin:
12553
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding higher base idle strategy. *tt
Bulletin:
12554
Component:
190000 tires
Summary:
Subject regarding revolutions per mile tire size data. *tt
Bulletin:
12573
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information regarding the audio system selective lighting feature. *tt
Bulletin:
12577
Component:
133000 visibility:power window devices and controls
Summary:
Vehicle may exhibit a squeaking noise from the door(s) power window glass during operation. *tt
Bulletin:
12580
Component:
133000 visibility:power window devices and controls
Summary:
Vehicles may exhibit various noises from the power window regulator during operation. *tt
Bulletin:
12585
Component:
353600 equipment:air conditioner
Summary:
Information on repairing climate control system interior odor. *tt
Bulletin:
12610
Component:
036000 service brakes, hydraulic:antilock
Summary:
Information on replacing a four wheel anti-lock brakes (4wabs) hydraulic control unit (huc). *tt
Bulletin:
99S09
Component:
182000 vehicle speed control:linkages
Summary:
Recall information regarding speed control cable replacement. *tt
Bulletin:
9988
Component:
353600 equipment:air conditioner
Summary:
Concerns or erratic or insufficient temperature control. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
9998
Component:
020000 suspension
Summary:
Experiencing drift / pull to the right conditons. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
9946
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Concerns with transmission fluid leaking at the radiator. *tt
Bulletin:
6295
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Vehicles may exhibit a front accessory drive (fead) belt noise. *tt
Bulletin:
6307
Component:
110000 electrical system
Summary:
Concerns with multiple generic electronic module (gem) (i.e., inoperative one touch down, chime, 4x4 shift motor, etc). *tt
Bulletin:
6309
Component:
138000 visibility:defroster/defogger system
Summary:
Exhibiting a lack of heat and / or a malfunction indicator lamp (mil) lamp on with diagnostic trouble code (dtc) p0125. *tt
Bulletin:
6407
Component:
136000 visibility:windshield wiper/washer
Summary:
Exhibiting front windshield wiper activation without command. *tt
Bulletin:
6429
Component:
162000 structure:body
Summary:
Information on refilling tissues for the center console facial tissue compartment. *tt
Bulletin:
6458
Component:
103000 power train:automatic transmission
Summary:
Some vehicles with 4r44e / 5r55e transmissions may exhibit slipping shifts, delayed or no engagements. *tt
Bulletin:
6462
Component:
070000 fuel system, gasoline
Summary:
Conditions on hard start due to fuel system pressure bleed down. *tt
Bulletin:
12824
Component:
110000 electrical system
Summary:
Concerns with multiple generic electronic module (gem) functional concerns (i.e., inoperative one touch down, chime, 4x4 shift motor, etc.) *tt
Bulletin:
12826
Component:
136000 visibility:windshield wiper/washer
Summary:
Experiencing front wipers activation without command. *tt
Bulletin:
12902
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Vehicles may exhibit an anti-lock brake system (abs) light on with diagnostic trouble code (dtc) b1676. *tt
Bulletin:
12903
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with oil leak of the engine block at the oil pressure switch boss. tt
Bulletin:
12905
Component:
106000 power train:axle assembly
Summary:
Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
Bulletin:
12909
Component:
136000 visibility:windshield wiper/washer
Summary:
Customers may complain of front windshield wiper activation without command. *tt
Bulletin:
995157
Component:
190000 tires
Summary:
Information on maintaining tire pressure. *tt
Bulletin:
996084
Component:
140000 air bags
Summary:
Exhibiting air bag lamp on with diagnostic trouble code (dtc) b1994 and / or b1998. *tt
Bulletin:
9912785
Component:
116200 electrical system:ignition:module
Summary:
Some vehicles may exhibit multiple generic electronic module (gem) functional concerns. *tt
Bulletin:
991610
Component:
103000 power train:automatic transmission
Summary:
Concerns with slipping transmission shifts and / or delayed or no transmission engagements may occur on some vehicles. *tt
Bulletin:
99142
Component:
980000 unknown or other
Summary:
Vehicles with a4wd transmission and 4.0l engine may have the 4x4 indicator lamps flashing. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
99156
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a burning odor or smoke, and / or rustling noise occuring when the blower motor is running if leaves or foreign material enters the blower case. *tt
Bulletin:
996769
Component:
980000 unknown or other
Summary:
Concerns with vehicles equipped with 4.0l sohc engine exhibiting the malfunction indicator lamp (mil) 'on' and diagnostic trouble code (dtc) p0161 stored. *tt
Bulletin:
996777
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Exhibiting a power steering fluid leak from the steering gear boot(s). *tt
Bulletin:
996784
Component:
020000 suspension
Summary:
Engineering is currently investigating vehicles with a4wd exhibiting a vibration / moan at highway speeds. *tt
Bulletin:
996796
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Some vehicles may exhibit a condition with fuse #18 in the fuse junction panel intermittently going open. *tt
Bulletin:
996804
Component:
135000 visibility:rearview mirrors/devices
Summary:
Concerns with outside passenger or driver side mirror slightly fulttering / shaking at highway speeds. *tt
Bulletin:
996836
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Subject regarding vehicles exhibiting an abs lamp on with diagnostic trouble code (dtc) b1676 in self test. *tt
Bulletin:
996843
Component:
353600 equipment:air conditioner
Summary:
Information pertaining to vehicles equipped with manual a/c controls built between 7/26/99 through 8/5/99 may have a/c control knobs that have been scuffed, scratched or damaged on the outer surfaces during assembly. *tt
Bulletin:
996868
Component:
162300 structure:body:door
Summary:
Information on vehicles exhibiting a "no 2-step unlock" or a false diagnostic trouble code b1834 (door unlock disarm output - cir) stored in memory. *tt
Bulletin:
996874
Component:
061000 engine and engine cooling:engine
Summary:
Subject pertaining to the sbds relative cam timing test which has been temporarily removed from use on some vehicles due to noise concerns. *tt
Bulletin:
996887
Component:
020000 suspension
Summary:
Some 4.0l vehicles with a4wd may exhibit a vibration / pulsation at 0-45 mph on dry pavement under light to moderate acceleration. *tt
Bulletin:
9912703
Component:
133000 visibility:power window devices and controls
Summary:
Customer may complain that the power window(s) may become inoperative. *tt
Bulletin:
9912942
Component:
126200 exterior lighting:turn signal:switch
Summary:
Concerns with uncommanded front wiper function activating without command. *tt
Bulletin:
9913035
Component:
182000 vehicle speed control:linkages
Summary:
Vehicles may experience a no start condition when parked on an incline with the vehicle in a nose down position and less than 1/4 tank of fuel. *tt
Bulletin:
9913072
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Vehicles may exhibit an outside passenger or driver side mirror slight flutter / shake at highway speeds. *tt
Bulletin:
9913094
Component:
061000 engine and engine cooling:engine
Summary:
Concerns with 4.0l sohc engines equipped vehicles exhibiting an oil leak from the oil pressure switch boss of the engine block. *tt
Bulletin:
9913130
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
Customers may perceive a condition in which the brake pedal is slow to return after it is applied on vehicles built prior to 5/18/99. *tt
Bulletin:
9913138
Component:
116200 electrical system:ignition:module
Summary:
Information on replacing and removing the generic electronic module (gem). *tt
Bulletin:
99203
Component:
162200 structure:body:bumpers
Summary:
Information on replacing the front bumper bracket. *tt
Bulletin:
99206
Component:
353600 equipment:air conditioner
Summary:
Concerns with burning odor or smoke, and / or rustling noise while blower motor is on. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99223
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
A no start condition when vehicle is parked on an incline with the vehicle in a nose down position and less than 1/4 tank of fuel may occur. *tt
Bulletin:
99228
Component:
162000 structure:body
Summary:
Experiencing water leak into the vehicle through the moonroof opening. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
99186
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
991813
Component:
100000 power train
Summary:
Experiencing an inoperative or inaccurate odometer / speedometer readings. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99197
Component:
980000 unknown or other
Summary:
Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99243
Component:
126200 exterior lighting:turn signal:switch
Summary:
On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
Bulletin:
6901
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
A condition in which the brake pedal is slow to return after it is applied on vehicles built prior to 5/18/1999. *tt
Bulletin:
6905
Component:
110000 electrical system
Summary:
Information on removing and / or replacing the generic electronic module (gem). *tt
Bulletin:
6915
Component:
350000 equipment
Summary:
Subject regarding the abs module active command modes features of the ngs software version 16.1 is not functioning. *tt
Bulletin:
6937
Component:
020000 suspension
Summary:
Concerns with squeak -type noise from the rear while driving or going over bumps. *tt
Bulletin:
6980
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit the check engine light on with diagnostic trouble code po420. *tt
Bulletin:
6986
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding 4.0l sohc camshaft bolt torque. *tt
Bulletin:
6987
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit engine noise(cam chain noise). *tt
Bulletin:
6992
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit a whine noise from the rear axle during various drive modes at highway speeds. *tt
Bulletin:
6993
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding 4.0l sohc engine repair procedure update. *tt
Bulletin:
6997
Component:
061000 engine and engine cooling:engine
Summary:
Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
Bulletin:
7005
Component:
022000 suspension:rear
Summary:
Information regarding rear axle whine at highway speeds. *mjs
Bulletin:
7075
Component:
353000 equipment:electrical
Summary:
Information regarding radio lights and display flicker/flash with headlights on. *mjs
Bulletin:
7079
Component:
220000 seats
Summary:
Information regarding seat that will not move forward. *mjs
Bulletin:
7083
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Information regarding neutral tow kit availability. *mjs
Bulletin:
7084
Component:
353600 equipment:air conditioner
Summary:
Subject on manual a/c system-blower works in high setting only. *mjs
Bulletin:
13170
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding 4.0 l sohc camshaft bolt torque. *mjs
Bulletin:
13171
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding 4.0l sohc engine noise (cam chain noise). *mjs
Bulletin:
13172
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding sohc engine noise (cam chain noise). *mjs
Bulletin:
13176
Component:
106000 power train:axle assembly
Summary:
Information regarding rear axle whine at highway speeds. *mjs
Bulletin:
13177
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding 4.0l sohc engine repair procedure update. *mjs
Bulletin:
13181
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart (continued). *mjs
Bulletin:
13193
Component:
022000 suspension:rear
Summary:
Information regarding rear axle whine at highway speeds. *mjs
Bulletin:
13213
Component:
330000 interior lighting
Summary:
Information regarding radio lights and display flicker/flash with headlights on. *mjs
Bulletin:
13218
Component:
220000 seats
Summary:
Information regarding seat that willl not move forward. *mjs
Bulletin:
13222
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Information regarding neutral tow kit available. *mjs
Bulletin:
13223
Component:
353600 equipment:air conditioner
Summary:
Information regarding manual a/c system- blower works in high setting only. *mjs
Bulletin:
13251
Component:
136000 visibility:windshield wiper/washer
Summary:
Information regarding uncommanded front wiper function (continued on 13252 and 13253). *mjs
Bulletin:
13252
Component:
136000 visibility:windshield wiper/washer
Summary:
Continued from 13251, uncommanded front wiper function . *mjs
Bulletin:
13260
Component:
061000 engine and engine cooling:engine
Summary:
Service tips information provided to assist when servicing vehicles with short block assembly. *tt
Bulletin:
13263
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a pop / creak noise from the right a pillar / upper door hinge area while driving. *tt
Bulletin:
7138
Component:
061000 engine and engine cooling:engine
Summary:
Service tip information when servicing the 4.0l sohc short block assembly. *tt
Bulletin:
7142
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a pop / creak noise from the right a pillar / upper door hinge area while driving. *tt
Bulletin:
7207
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
7238
Component:
136000 visibility:windshield wiper/washer
Summary:
A condition with the rear wiper blade on vehicles built through 1/22/1999 may flip over when run through soft cloth style car washes. *tt
Bulletin:
7241
Component:
106000 power train:axle assembly
Summary:
Vehicles equipped with 5.0l engines and 3.73:1 ratio / 8.8 inch ring gear rear axles may exhibit a whine noise during various drive modes at speeds between 45 to 65 mph. *tt
Bulletin:
7247
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit a fuse #18 open / power door locks cycling uncommanded. *tt
Bulletin:
7248
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles equipped with 4.0l sohc engine may exhibit a slight hesitation on acceleration during engine warm up. *tt
Bulletin:
7270
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.0l sohc engines may exhibit a vibration / moan / boom at idle. *tt
Bulletin:
7316
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some vehicles may exhibit an oil leak from the front axle pinion seal. *tt
Bulletin:
13337
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles built prior to 9/15/99 may exhibit front windshield wiper activation without command. *tt
Bulletin:
13340
Component:
980000 unknown or other
Summary:
Exhibiting a miss / rough idle with the malfunction indicator light (mil) on and dtc p0340 in self test. *tt
Bulletin:
13350
Component:
020000 suspension
Summary:
Some vehicles with a4wd built prior to 9/13/99 may exhibit a vibration / pulsation at 0 - 45 mph. *tt
Bulletin:
13352
Component:
116200 electrical system:ignition:module
Summary:
Vehicles with automatic 4 wheel drive may exhibit multiple generic electronic module (gem) functional concerns. *tt
Bulletin:
13388
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Vehicles equipped the neutral tow feature, be aware that when the neutral tow feature is enabled and the customer places the vehicle into the neutral mode, the neutral tow indicator will go out when the gem goes to sleep. *tt
Bulletin:
13412
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
Bulletin:
13414
Component:
138000 visibility:defroster/defogger system
Summary:
Exhibiting a lack of heat, exhaust sulphur smell and / or malfunction indicator lamp on with diagnostic trouble code p0125. *tt
Bulletin:
13415
Component:
022110 suspension:rear:springs:coil springs
Summary:
Exhibiting a squeak type noise from the rear stabilizer bar while driving, especially when going over bumps. *tt
Bulletin:
13426
Component:
020000 suspension
Summary:
Exhibiting very light steering vibration / shimmy / nibble at engine idle or low speeds. *tt
Bulletin:
6514
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit an abs lamp on with diagnostic trouble code b1676 in self test. *tt
Bulletin:
6515
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 4.0l sohc engines may exhibit an oil leak from the oil pressure switch boss of the engine block. *tt
Bulletin:
6536
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit front windshield wiper activation without command. *tt
Bulletin:
6638
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Experiencing a vibration or buzz felt through the accelerator pedal which is most noticeable during acceleration under 2000 rpms. *tt
Bulletin:
6643
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles with 4.0l ohv engines built after 6/10/99 at louisville assembly plant or after 6/14/99 at st. louis assembly plant may exhibit a higher than normal base idle speed of 1400-1600 rpm when the vehicle is initially received from
Bulletin:
6692
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit no / low air conditioner performance at high ambient temperatures and prolonged idle. *tt
Bulletin:
12916
Component:
110000 electrical system
Summary:
Some vehicles with automatic 4 wheel drive may exhibit multiple generic electronic module functional concerns (i.e. inoperative one touch down, chime, 4x4 shift motor, etc). *tt
Bulletin:
12947
Component:
020000 suspension
Summary:
Some vehicles may exhibit a high pitched squeal or whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt
Bulletin:
13004
Component:
020000 suspension
Summary:
Some 4.0l vehicles with a4wd may exhibit a vibration / pulsation felt from the driveline in the steering wheel and floorpan on acceleration / light tip-in at 25-35 mph when in 4 auto mode. *tt
Bulletin:
13026
Component:
182000 vehicle speed control:linkages
Summary:
Some vehicles may exhibit a hard start condition due to fuel system pressure bleed down. *tt
Bulletin:
7322
Component:
138000 visibility:defroster/defogger system
Summary:
Some vehicles built between 12/1/1998 and 8/31/1999 equipped with 5.0l engine may exhibit a lack of heat, exhaust sulphur smell and / or malfunction indicator lamp on with diagnostic trouble code p0125. *tt
Bulletin:
7353
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
Bulletin:
7360
Component:
021100 suspension:front:stabilizer bar
Summary:
Some vehicles may exhibit a squeak noise from the rear while driving, especially when going bumps. *tt
Bulletin:
7418
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a popping, snapping or ticking noise from the right a pillar / upper door hinge area while driving. *tt
Bulletin:
7440
Component:
180000 vehicle speed control
Summary:
This bulletin states that whenever the clean air tube retaining clamps are removed for any repair, procedures must be followed to insure proper clearance between the throttle cam and the clean air tube retaining clamp bolt. *tt
Bulletin:
7468
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a vibration / groan on acceleration or take off.
Bulletin:
7470
Component:
021230 suspension:front:springs:air suspension system
Summary:
Some vehicles equipped with rear load leveling system may exhibit an air suspension light on with diagnostic trouble code c1726 in self test. *tt
Bulletin:
7494
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
All vehicles with electronic shift on the fly transfer cases will display contact plate pids opposite of what the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
Bulletin:
7536
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit the left front power window inoperative. *tt
Bulletin:
13435
Component:
162310 structure:body:door:hinge and attachments
Summary:
Experiencing a popping, snapping or ticking noise from the right a-pillar / upper door hinge area whle driving. *tt
Bulletin:
13440
Component:
015000 steering:hydraulic power assist system
Summary:
Experiencing very light steering vibration / shimmy / nibble at engine idle or low speeds (parking lot type maneuvers). *tt
Bulletin:
13482
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a vibration / groan on acceleration or take-off due to the rear transmission mount being twisted and allowing a ground out condition to occur. *tt
Bulletin:
13483
Component:
021230 suspension:front:springs:air suspension system
Summary:
Some vehicles equipped with rear load leveling system may exhibit an air suspension light on with diagnostic trouble code c1726 in self test. *tt
Bulletin:
13504
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Concerns with vehicles exhibiting an oil leak from the front axle pinion seal. engineering is currently addressing this issue through the high milage / time-in-service concern resolution process. *tt
Bulletin:
13527
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.0l sohc engines may exhibit an overheat condition that may be attributed to the thermostat. engineering is currently investigating this issue and is looking for thermostats and coolants samples from these
Bulletin:
13545
Component:
182000 vehicle speed control:linkages
Summary:
Some vehicles equipped with 4.0l ohv or 4.0l sohc engines may exhibit various driveability symptoms due to injector(s) contamination. *tt
Bulletin:
13563
Component:
140000 air bags
Summary:
Some vehicles may exhibit an air bag lamp on with side air bag diagnostic trouble codes b1994 and b1998 in self test. engineering has released a robust overlay harness to install on vehicles that come in for this issue. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
8037
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration at highway speeds. engineering is currently investigating this issue and is looking for vehicles that have been into dealerships more than once for the concern. *tt
Bulletin:
8090
Component:
020000 suspension
Summary:
For vehicles exhibiting a vibration at highway speeds, engineering is currently investigating this issue and is looking for vehicles that have been into the dealership more than once for the concern. *tt
Bulletin:
8119
Component:
330000 interior lighting
Summary:
Some vehicles equipped with 5.0l engine and all wheel drive (awd) transfer case may exhibit a condition of 4x4 indicators flashing and multiple gem diagnostic trouble codes. *tt
Bulletin:
8149
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Subject regarding neutral tow inoperative after gem replacement. *tt
Bulletin:
8164
Component:
350000 equipment
Summary:
Information on 5r55e - 4r55e - 4r44e pump alignment tools. *tt
Bulletin:
8200
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Some vehicles with 4.0l sohc engine and built prior to 9/21/99 may exhibit a vibration or buzz felt through the accelerator pedal which is most noticeable during acceleration under 2000 rpms. *tt
Bulletin:
13843
Component:
020000 suspension
Summary:
Engineering is currently investigating concerns with vehicles exhibiting a vibration at highway speeds. *tt
Bulletin:
13857
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 5.0l engines and all wheel drive (awd) transfer case may exhibit a condition of 4x4 indicators flashing and multiple gem diagnostic trouble codes. *tt
Bulletin:
13723
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some all wheel drive vehicles may experience a low speed whining noise from the transfer case. *mjs
Bulletin:
8420
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles built through 11/22/99 and equipped with 4.0l sohc engine may exhibit various driveability conditions that lead to idle air control (iac) valve replacement. *tt
Bulletin:
14010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles built through 11/22/99 and equipped with 4.0l sohc engine may exhibit various driveability conditions that lead to idle air control (iac) valve replacement. *tt
Bulletin:
12080
Component:
353600 equipment:air conditioner
Summary:
Information regarding the right rear a/c compressor mounting bolt that was deleted from production for some models *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
985088
Component:
353600 equipment:air conditioner
Summary:
Right rear air conditioner compressor mountng bolt was deleted from production for the 1999 3.ol ef1/4 ranger & 4.0l explorer/mountaineer vehicles. *tt ohv
Bulletin:
985133
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with a dual media (am/fm/cass/cd) radio may exhibit an audio concern of no display or graphics. *tt
Bulletin:
985148
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 5.0l engines may exhibit an upper engine tapping noise on cold start. *tt
Bulletin:
985157
Component:
190000 tires
Summary:
Information on setting the tire inflation pressure for 1991 through 1999 model year vehicles in the pre-delivery process and during maintenance intervals. *tt
Bulletin:
5190
Component:
350000 equipment
Summary:
On some vehicles built between 9/14/98 and 10/28/98, the rear liftgate applique lettering may be difficult to read. new appliques have now been released which incorporate chrome lettering to enhance the visibility of the brand name.
Bulletin:
0083
Component:
022000 suspension:rear
Summary:
Some vehicles equipped with a 5.0l engine may exhibit a rubbing noise during right hand turns from the rear of the vehicle. **mr
Bulletin:
8164
Component:
980000 unknown or other
Summary:
Information regarding pump alignment tools. **mr
Bulletin:
8493
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may experience an oil leak at the rear crankshaft area after service. **mr
Bulletin:
8512
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr
Bulletin:
14048
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may experience an oil leak at the rear crankshaft area after service. **mr
Bulletin:
14056
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr
Bulletin:
14061
Component:
980000 unknown or other
Summary:
Some vehicles may come in for a malfunction indicator lamp (mil) on with diagnostic trouble code p0171 and/or p0174 in self test. **mr
Bulletin:
14090
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start / no start condition when attempting to start the vehicle. *tt
Bulletin:
14198
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a squeak noise from the front lower door hinge(s) when opening or closing the doors. *tt
Bulletin:
99-6184
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit slipping shifts, delayed or no enggements. *tt
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6202
Component:
133000 visibility:power window devices and controls
Summary:
Addressing customers concern of inoperative power windows. *tt
Bulletin:
6203
Component:
070000 fuel system, gasoline
Summary:
Some vehicles may exhibit a no start condition when parked on an incline with the vehicle in a nose down position and less than 1/4 tank of fuel. *tt
Bulletin:
6225
Component:
355100 equipment:other:labels
Summary:
Information regarding vin numbers being active 5/11/1999. *tt
Bulletin:
12755
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Some vehicles built before 1/1/1999 equipped with 5.0l engine may exhibit a front accessory drive (fead) belt noise. *tt
Bulletin:
12760
Component:
138000 visibility:defroster/defogger system
Summary:
Concerns with lack of heat and / or malfunction indicator lamp (mil) on with diagnostic trouble code (dtc) p0125. *tt
Bulletin:
6699
Component:
020000 suspension
Summary:
Some vehicles with a4wd may exhibit a vibration / pulsation felt from the driveline in the steering wheel and floorpan on acceleration / light tip-in at 25-35 mph when in 4 auto mode. *tt
Bulletin:
6729
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with vehicles that exhibit a hard start / long crank condition due to a fuel system pressure bleed down. *tt
Bulletin:
6035
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles equipped with teves four wheel anti-lock brakes (4wabs) may exhibit a yellow anti-lock brake lamp illuminated with no diagnostic trouble codes in memory. *tt
Bulletin:
12843
Component:
106000 power train:axle assembly
Summary:
Some 4x4 vehicles may exhibit a high pitched squeal or whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt
Bulletin:
6844
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles with automatic 4 wheel drive (a4wd) may exhibit multiple generic electronic module (gem) function concerns such as inoperative on touch down, chime, 4x4 shift motor, etc. *tt
Bulletin:
13261
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tips when servicing a 4.0l sohc short block assembly. *tt
Bulletin:
12703
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit a concern with the power window(s) becoming inoperative. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12710
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Some vehicles may exhibit a no start condition when parked on an incline with the vehicle in a noise down position and less than 1/4 tank of fuel. *tt
Bulletin:
6032
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit a high pitched squeal or whistle type noise from the front end at speeds from 10 mph to 40 mph. *tt
Bulletin:
12512
Component:
102000 power train:manual transmission
Summary:
Brief information on checking transmission fluid level. *t
Bulletin:
12518
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Concerns with the in-dash cd stops operating when hot / radio display reads cd too hot. *tt
Bulletin:
12521
Component:
106000 power train:axle assembly
Summary:
Vehicles with limited slip / traction-lok rear axles may exhibit a chatter noise while turning. *tt
Bulletin:
12558
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration at highway speeds due to tire/wheel imbalance. *tt
Bulletin:
12582
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit front windshield wiper activation without command. *tt
Bulletin:
12619
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a higher than normal base idle speed of 1400 - 1600 rpm when the vehicle is initially received from the assembly plant. *tt
Bulletin:
13039
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 4.0l sohc engine may exhibit a condition of the malfunction indicator lamp (mil) on and diagnostic trouble code (dtc) p0161. *tt
Bulletin:
13049
Component:
014200 steering:rack and pinion:rack
Summary:
Exhibiting a power steering fluid leak from the steering gear boot(s). *tt
Bulletin:
13056
Component:
020000 suspension
Summary:
Some vehicles with a4wd may exhibit a vibration / moan at highway speeds. *tt
Bulletin:
13062
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Some vehicles may exhibit a condition with fuse #18 in the fuse junction panel intermittently going open. *tt
Bulletin:
13074
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit an abs lamp on with diagnostic trouble code b1676 in self test. *tt
Bulletin:
13084
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Information on damaged, scratched, scuffed manual a/c control knobs. *tt
Bulletin:
13091
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles with automatic 4 wheel drive (a4wd) may exhibit multiple generic electronic module (gem) functional concerns (i.e., inoperative one touch down, chime, 4x4 shift motor, etc.). *tt
Bulletin:
13097
Component:
110000 electrical system
Summary:
Some vehicles may exhibit no 2-step unlock or a false diagnostic trouble code b1834 (door unlock disarm output - cir) generated by the gem. *tt
Bulletin:
13101
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding the sbds relative cam timing test. *tt
Bulletin:
13102
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit front windshield wiper activation without command. *tt
Bulletin:
13112
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Vibration on light to moderate acceleration at 0 - 45 mph on a4wd vehicles. *tt
Bulletin:
13147
Component:
350000 equipment
Summary:
Subject regarding the abs module active command modes feature of ngs software version 16.1. *tt
Bulletin:
13166
Component:
020000 suspension
Summary:
Some vehicles may exhibit a squeak noise from the rear while driving, especially when going over bumps. *tt
Bulletin:
12852
Component:
162000 structure:body
Summary:
Use kleenex brand juniors or li'l travelers to refill tissues for certain vehicles with the high series center console facial tissue compartment. *tt
Bulletin:
12867
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 4r44e or 5r55e transmission may exhibit slipping shifts, delayed or no engagements. *tt
Bulletin:
12871
Component:
070000 fuel system, gasoline
Summary:
Some vehicles may exhibit a hard start / long crank condition due to fuel system pressure bleed down. *tt
Bulletin:
13290
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
13300
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with 4.0l sohc engines may exhibit a vibration / moan / boom at idle. *tt
Bulletin:
13310
Component:
136000 visibility:windshield wiper/washer
Summary:
The rear wiper blade on some vehicles built through 1/22/99 may flip over when run through soft cloth style car washes. *tt
Bulletin:
13315
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with 5.0l engines and 3.73:1 ratio / 8.8 inch ring gear rear axles may exhibit a whine noise during various drive modes at speeds between 45 to 65 mph. *tt
Bulletin:
13333
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Some vehicles may exhibit fuse #18 in the fuse junction panel intermittently going open. *tt
Bulletin:
13334
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.0l sohc engine may exhibit a hesitation on acceleration during engine warm up. *tt
Bulletin:
13335
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.0l sohc engines may exhibit a slight hesitation on acceleration during engine warm up. *tt
Bulletin:
13404
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some 4x4 vehicles may exhibit an oil leak from the front axle pinion seal. *tt
Bulletin:
13465
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding clean air tube retaining clamps / throttle body cam. *tt
Bulletin:
13505
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
Bulletin:
13512
Component:
133000 visibility:power window devices and controls
Summary:
A condition may exist where the left front power window is inoperative. *tt
Bulletin:
13581
Component:
141100 air bags:frontal:sensor/control module
Summary:
Some vehicles may exhibit an air bag lamp on with side air bag diagnostic trouble codes b1994 and / or b1998 in self test. *tt
Bulletin:
6582
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit front windshield wiper activation without command. *tt
Bulletin:
12997
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit no / low a/c performance at high ambient temperatures and prolonged idle. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
5133
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with a dual media (am / fm cass / cd) radio may exhibit an audio concern of no display or graphics. *tt
Bulletin:
5242
Component:
012200 steering:column locking:anti-theft device
Summary:
Some vehicles built from 11/12/98 until 11/19/98 equipped with keyless entry and passive anti-theft system (pats) may exhibit the alarm operating prematurely. *tt
Bulletin:
5249
Component:
020000 suspension
Summary:
Information on vehicles exhibiting steering wheel shimmy, vibration or grunt on slow speed turns. *tt
Bulletin:
5297
Component:
133000 visibility:power window devices and controls
Summary:
Information on vehicles equipped with an optional travel / note digital voice memo recorder. *tt
Bulletin:
5373
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a water leak concern from the moonroof. *tt
Bulletin:
12197
Component:
012200 steering:column locking:anti-theft device
Summary:
Some vehicles built from 11/12/98 until 11/19/98 equipped with keyless entry and pats may exhibit the alarm operating prematurely. *tt
Bulletin:
12212
Component:
133000 visibility:power window devices and controls
Summary:
Information on vehicles equipped with an optional travel / note digital voice memo recorder. *tt
Bulletin:
12216
Component:
036000 service brakes, hydraulic:antilock
Summary:
This bulletin mentions that for all vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12227
Component:
110000 electrical system
Summary:
For all vehicles with generic electronic module (gem) concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12289
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a water leak concern from the moonroof. *tt
Bulletin:
9987
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit harsh downshift from 3rd to 1st gear while stopping; hesitation after acceleration from stop; and / or lack of power after acceleration from stop. *tt
Bulletin:
00M12
Component:
061000 engine and engine cooling:engine
Summary:
Ford motor company is providing additional coverage for the 4.0l sohc camshaft chain tensioner and lower intake manifold gasket. *tt
Bulletin:
00243
Component:
181000 vehicle speed control:accelerator pedal
Summary:
On some vehicles, the accelerator pedal bracket may become loose or separated from the dash panel. this may be caused by repeated excessive force on the accelerator pedal, resulting in cracking of the dash panel sheet metal at the acceler
Bulletin:
14451
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 5.0l engine may exhibit a malfunction indicator light (mil) on with possible diagnostic trouble codes p0351, p0352, p0353 and / or p0354 in self test with no driveability concerns present. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
14489
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built through 01/1999 and equipped with a 5.0l engine may exhibit a cold start or hot engine deceleration noise coming from the #5 cylinder. *tt
Bulletin:
00M12
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding owner notification suppllemental program for vehicles equipped with 4.0l sohc engines - camshaft chain tensioner and lower intake manifold gasket additional coverage. *tt
Bulletin:
14554
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 4r70w transmission may exhibit the tcil on with diagnostic trouble code p0741 (torque converter clutch system performance or stuck off) in continuous memory. *jb
Bulletin:
14560
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles may experience start up timing chain noise. *jb
Bulletin:
14583
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Concerns with broken thermostats on engines. *jb
Bulletin:
14586
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some 4.0l vehicles with a4wd built prior to 9/13/99 may exhibit a vibration / pulsation at 0-45 mph on dry pavement under light to moderate acceleration in 4 auto mode which may characteristic with the control trac 4x4 system. *jb
Bulletin:
14617
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Subject pertaining to broken thermostat. *jb
Bulletin:
01110
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Air bag lamp on with diagnostic trouble codes b1994 and / or b1998 stored in memory. *tt
Bulletin:
00L09
Component:
355100 equipment:other:labels
Summary:
Subject pertaining to supplemental tire inflation label. *jb
Bulletin:
00201
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Some vehicles may exhibit hesitation on acceleration or while turning. *jb
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
14345
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit the oil pressure gauge registering low or no oil pressure usually on initial strt-up after several hours of cold soak. *jb
Bulletin:
14371
Component:
020000 suspension
Summary:
Subject regarding pop / creak noise from the rear underbody while driving. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
0186
Component:
106000 power train:axle assembly
Summary:
On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt
Bulletin:
14819
Component:
106000 power train:axle assembly
Summary:
Some 4x4 vehicles may exhibit a fluid leak from the front axle vent tube. *tt
Bulletin:
14847
Component:
106000 power train:axle assembly
Summary:
Concerns with vehicles exhbit fluid leakage from the front axle vent tube. *tt
Bulletin:
14868
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc engine may exhibit a primary chain rattle noise (sometimes described as a spark knock-type noise). *tt
Bulletin:
01411
Component:
106000 power train:axle assembly
Summary:
High-pitched front axle squeal or whistle type noise from the front of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt
Bulletin:
0154
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) accompanied by a diagnostic trouble code (dtc) p0741 and in some cases p1728. *tt
Bulletin:
14907
Component:
980000 unknown or other
Summary:
Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
Bulletin:
13725
Component:
103000 power train:automatic transmission
Summary:
Some vehicles with a4wd may exhibit a vibration / moan at highway speeds. *tt
Bulletin:
13752
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
Some 4x4 vehicles may exhibit an oil leak from the front axle pinion seal. *tt
Bulletin:
13879
Component:
110000 electrical system
Summary:
Information on replacing a gem module on 4x4 vehicles equipped with 4.0l sohc, ohv and the neutral tow kit. *tt
Bulletin:
14451
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 5.0l engine may exhibit a malfunction indicator light (mil) on with possible diagnostic trouble codes (dtc) p0351, p0352, p0353 and / or p0354 in self test with no driveability concerns present.
Bulletin:
14489
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built through 01/1999, equipped with a 5.0l engine may exhibit a cold start or hot engine deceleration noise coming from the #5 cylinder. *tt
Bulletin:
01137
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
Bulletin:
9987
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit harsh downshift from 3rd to 1st gear while stopping, hesitation after acceleration from stop and / or lack of power after acceleration from stop on vehicles with 4.0l or 5.0l engines. *tt
Bulletin:
01114
Component:
106000 power train:axle assembly
Summary:
Some 4x4 vehicles may exhibit a high-pitched squeal or whistle type noise from the front axle area of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15119
Component:
126200 exterior lighting:turn signal:switch
Summary:
Information regarding multifunction switch part number clarification. *slc
Bulletin:
15168
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit an intermittent high frequency brake squeal noise. *yh
Bulletin:
15155
Component:
136000 visibility:windshield wiper/washer
Summary:
On some vehicles the rear wiper arm fails to clean back glass. *et
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15249
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with high brake pedal force to stop after rotor machining. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
01B77
Component:
190000 tires
Summary:
Owner notification program supplement 7 revised information - regarding replacement of wilderness at tires. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15532
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Information on vehicles exhibitng fuel line damage due to pinching/squeezing of the fuel return line. *tt
Bulletin:
15563
Component:
980000 unknown or other
Summary:
Information regarding malfunction indicator light illuminating with diagnostic trouble code p0300/p0301.*yh
Bulletin:
15567
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built before april 23, 2001 may exhibit a hard start/long crank after sitting for an hour or more. *tt
Bulletin:
15406
Component:
137000 visibility:rear window wiper/washer
Summary:
Concerns with rear wipers that do not sufficiently clean the back glass. *tt
Bulletin:
15422
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank condition after sitting for an hour or more. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15470
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with spark knock noise or chain rattle noise between 2000-3000 rpm, during cold engine operation only. *tt
Bulletin:
15496
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles built before april 23, 2001 may exhibit a hard start/long crank after sitting for an hour or more due to fuel system contamination. *tt
Bulletin:
0232
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 4.0l sohc engine may exhibit a check engine light on with diagnostic trouble codes p0300 (random misfire) or p0301. *tt
Bulletin:
02138
Component:
102000 power train:manual transmission
Summary:
Low line pressure reading at wide open throttle (wot), slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set on vehicles built before 12/1/2001. *tt
Bulletin:
0276
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on diagnosing engine rattle noise from primary chain drive area between 2000-3000 rpm on cold engine operation only. *tt
Bulletin:
0242
Component:
106000 power train:axle assembly
Summary:
Certain vehicles with 4x4 or all-wheel drive may have a fluid leak from the front axle vent tube. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
16114
Component:
140000 air bags
Summary:
Some vehicles may exhibit repeat service for air bag lamp on with diagnostic trouble code b1994 (driver side air bag circuit resistance high) and / or b1998 (passenger side air bag circuit resistance high). *tt
Bulletin:
16040
Component:
010000 steering
Summary:
Experiencing a clicking / popping noise from the upper steering column area when turning the steering wheel. *tt
Bulletin:
15692
Component:
020000 suspension
Summary:
Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps. *tt
Bulletin:
15887
Component:
100000 power train
Summary:
Some vehicles may exhibit a no 1-2 upshift, no 2-3 upshift, a no engine braking condition in manual 1 or diagnostic trouble code p0732 (gear 2 incorrect ratio) or p0733 (gear 3 incorrect ratio). *tt
Bulletin:
15910
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with brake vibration, roughness and / or grinding noise, and excessive brake rotor corrosion. *tt
Bulletin:
0281
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0 sohc (single over-head cam) engine may exhibit a primary timing chain rattle noise. *tt
Bulletin:
0282
Component:
100000 power train
Summary:
Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings while in drive, no 2nd gear, no 3rd gear, no engine braking in manual 1st and slipping shifts and / or delayed engagements. *tt
Bulletin:
0285
Component:
353600 equipment:air conditioner
Summary:
On some vehicles, the electronic automatic temperature control (eatc) blows cold air from the floor ducts on vehicles produced before 9/30/2000 only. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
0358
Component:
106000 power train:axle assembly
Summary:
Fluid may leak out of the front axle vent tube. *tt *jb
Bulletin:
16735
Component:
022000 suspension:rear
Summary:
Various noise issues from the rear leaf springs while driving. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16935
Component:
100000 power train
Summary:
An uncommanded shift to 4x4 low. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03199
Component:
061000 engine and engine cooling:engine
Summary:
Rattle/buzz sound from under the vehicle on 4.0l single overhead cam (sohc) engines. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
0471
Component:
110000 electrical system
Summary:
Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
02221
Component:
061000 engine and engine cooling:engine
Summary:
Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
030508
Component:
106000 power train:axle assembly
Summary:
Front axle leaks fluid from vent tube - vehicles equipped with 4x4 or awd. *tt

Home | Privacy