1999 MAZDA 626 Recalls (4)
- Campaign:
- 00V074000 on 03/12/2000
- Component:
- Service brakes, hydraulic:foundation components:master cylinder
- Manufactured:
- 01/31/1999 - 01/30/2000
- Affected:
- 71,000
- Defect:
- Vehicle description: passenger vehicles. certain reservoir tank caps on the brake master cylinder were produced with a worn out die and lack ventilation holes. as a result, the pressure in the reservoir tank can drop gradually as the brake pad or shoe wears and ambient temperature drops. also, the pressure could reach a point that the brake caliper and drum cylinder are pulled back by the vacuum in the reservoir tank when the vehicle is parked for a long time.
- Consequence:
- This condition could cause reduced brake efficiency, increasing the risk of a crash.
- Correction:
- Dealers will inspect the reservoir cap and replace it, if necessary.
- Notes:
- Owner notification began april 21, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mazda at 1-800-222-5500.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V134000 on 05/09/2000
- Component:
- Engine and engine cooling:engine
- Manufactured:
- 08/21/1997 - 08/27/1998
- Affected:
- 31,000
- Defect:
- Vehicle description: passenger vehicles. an external spring in the timing belt tensioner could break.
- Consequence:
- The broken spring may get caught in the timing belt, resulting possible engine stalling.
- Correction:
- Dealers will check the tensioner installed and replace it if the vehicle is equipped with the affected tensioner.
- Notes:
- Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mazda at 1-000-222-5500.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05E065000 on 10/05/2005
- Component:
- Fuel system, gasoline
- Affected:
- 42,962
- Defect:
- Certain spx filtran fuel filters with a 45-degree angle inlet tube, model 800f350-s1, sold as replacement filters for 1993-1997 ford probe,1993-2001 mazda 626 and mx-6, and 1983-1994 loyal, 3-door coupe, hatchback, sedan, wagon, brat, dl, gl, gl-10, rx, xt, and xt6 passenger vehicles with efi or turbo engines. these filters are packaged as wix, napa, and carquest brand fuel filters. certain spx filtran fuel filters with a 90-degree angle inlet tube, model 800f300-s2, sold as replacement filters for 19983-1994 subaru vehicles with efi or turbo engines. these filters are packaged as wix, napa, and carquest brand fuel filters. fuel may leak from the filter due to non-conforming brazing welds where the inlet tube is connected to the filter can.
- Consequence:
- In the presence of an ignition source, a vehicle fire can occur.
- Correction:
- Spx will notify its customers and provide a full refund. the recall began september 27, 2005. owners may contact mr. chris greeson at 704-869-3733 or contact the wix information hotline at 800-949-6698.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty:1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1999 MAZDA 626 TSBs (59)
- Bulletin:
- 00598
- Component:
- 150000 seat belts
- Summary:
- Information regarding seat belt extenders. *yc
- Bulletin:
- 00299
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Customer may complain of inoperative, binding during operation, or noisy sunroof. *tt
- Bulletin:
- 00199
- Component:
- 140000 air bags
- Summary:
- Information on service parts availability - low power air bag components. *tt
- Bulletin:
- 00299
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Customer may complain of inoperative, binding, or noisy sunroof. *tt
- Bulletin:
- 00199
- Component:
- 140000 air bags
- Summary:
- Vehicles produced after 1yvgf22**w5772066 were produced with low power air bag systems. *tt
- Bulletin:
- 00999
- Component:
- 980000 unknown or other
- Summary:
- Concerns with malfunction indicator lamp on with diagnostic trouble codes p1132 and / or p1131. *tt
- Bulletin:
- 01199
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Vehicles with fs 4-cylinder engines may experience coolant leak at accessory block heater. *tt
- Bulletin:
- 010699
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Some vehicles may produce a squeaking noise when power window is operated up or down. *tt
- Bulletin:
- 00999
- Component:
- 162700 structure:body:trunk lid
- Summary:
- Information describing how the trunk lid on some vehicles may be hard to close. *tt
- Bulletin:
- 01599
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding piston standardization for vehicles within certain vin ranges. *tt
- Bulletin:
- 00199
- Component:
- 034400 service brakes, hydraulic:foundation components:drum
- Summary:
- Vehicles with vins lower than 1yvgf22c*x5875297 may experience rear brake squeal noise (drum brakes). *tt
- Bulletin:
- 01399
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding the malfunction indicator lamp (mil) coming on with diagnostic trouble codes (dtc) p1131 / p1132 and no driveability concerns. *tt
- Bulletin:
- 01299
- Component:
- 162000 structure:body
- Summary:
- Subject regarding paint damage - iron particles / industrial fallout / acid rain. *tt
- Bulletin:
- 00199R
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Customer may complain of inoperative, noisy or binding sunroof. *tt
- Bulletin:
- 01399R
- Component:
- 980000 unknown or other
- Summary:
- Concerns with the malfunction indicator lamp (mil) coming on with diagnostic trouble code (dtc) p1132 and / p1131. *tt
- Bulletin:
- 00300
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject regarding air conditioner accumulator replacement criteria when repairing the air conditioner system. *tt
- Bulletin:
- 00300R
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an engine knock noise that can be heard outside the vehicle at approximately 800 - 1400 rpm after the engine reaches operating temperature. *tt
- Bulletin:
- 00400R
- Component:
- 022000 suspension:rear
- Summary:
- Some vehicles may experience a tapping noise which can be heard coming from the rear of the vehicle within the first 10 minutes after a cold start. *tt
- Bulletin:
- 000401
- Component:
- 010000 steering
- Summary:
- Information on diagnosing steering squeak noise. *tt
- Bulletin:
- 00800
- Component:
- 341000 communications:horn assembly
- Summary:
- Some vehicles may exhibit the horn(s) being inoperative or staying on all the time. *tt
- Bulletin:
- 01500
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some 4-cylinder vehicles with vins lower than 1yv gf22c4 15202676 may exhibit a rough idle / hesitation during acceleration with malfunction indicator lamp on. *tt
- Bulletin:
- 01600
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Subject regarding inspection procedure - water pump leak. *tt
- Bulletin:
- 00400
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Some vehicles may exhibit a tapping noise which can be heard coming from the rear of the vehicle within the first 10 minutes after a cold start. this concern may be caused by the operation of the cdcv (canister drain cut valve) solenoid d
- Bulletin:
- 00300
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an engine knock noise that can be heard outside the vehicle at approximately 800 - 1400 rpm after the engine reaches operating temperature. *tt
- Bulletin:
- 0100402
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject regarding diagnostic information of oxygen sensor, catalyst efficiency and fuel system monitors. *slc
- Bulletin:
- 0901801
- Component:
- 980000 unknown or other
- Summary:
- Subject on service information for keyless entry system. *slc
- Bulletin:
- Component:
- 980000 unknown or other
- Summary:
- Information on fuel injector(s) replacement guidelines. *slc
- Bulletin:
- 0500502
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit an od off light flashing with diagnostic trouble code p1783 stored in memory after driving at highway speeds for extended periods. *slc
- Bulletin:
- 0700402
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject regarding air conditioning musty / mildew odor. *tt
- Bulletin:
- 0400502
- Component:
- 103000 power train:automatic transmission
- Summary:
- Inadvertent disabling of brake shift interlock. *tt
- Bulletin:
- 0900403
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Rear window defroster grid line repair procedure. *tt
- Bulletin:
- 0902604
- Component:
- 353000 equipment:electrical
- Summary:
- Speedometer replacement procedure. *tt
- Bulletin:
- 0102504
- Component:
- 111000 electrical system:battery
- Summary:
- Battery test procedure requirements. *tt
- Bulletin:
- 00204
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Evaporative emmissions and reciver adapters. *eh
- Bulletin:
- 06012004
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Programmable module installation. ( 2004 mazda b series) *jb
- Bulletin:
- 0800306
- Component:
- 140000 air bags
- Summary:
- Non genuine accessories affect air bag operation. *kb
- Bulletin:
- 00307
- Component:
- 980000 unknown or other
- Summary:
- Availability of non-required tools. *kb
- Bulletin:
- SB-09-005-13
- Component:
- 350000 equipment
- Summary:
- Mazda: on some vehicles, to avoid potential interference of foot placed on pedals, information is provided regarding proper use, and placement, of driver's floor mat. various models and model years. *pe
- Bulletin:
- 00-004/12
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 00-001-13-2748
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 02-001-13-2752
- Component:
- 350000 equipment
- Summary:
- Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
- Bulletin:
- 09-005-13-2781
- Component:
- 350000 equipment
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any poten-tial interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with
- Bulletin:
- 00-001-13-2748A
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 07-002-13-2842
- Component:
- 353600 equipment:air conditioner
- Summary:
- A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/c evaporator/cooling unit which is
- Bulletin:
- 00-004-12-2741
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 00-002-14-2936
- Component:
- 350000 equipment
- Summary:
- Mazda north american operations received many requests from our dealers asking us to approve additional on-car brake lathes as an option for mnao authorized equipment. due to your feedback and after evaluating a few on-car brake lathes, we
- Bulletin:
- 09-027-14-2935
- Component:
- 356000 equipment adaptive
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
- Bulletin:
- 09-034-14-2956
- Component:
- 356000 equipment adaptive
- Summary:
- In accordance with federal regulations, follow the procedure listed below when replacing a speedometer.note:'mazda vehicles are manufactured with tamper-proof speedometers.'when a speedometer is replaced, the new speedometer will read zero
- Bulletin:
- 09-035-17-3080
- Component:
- 117000 digital instrument panel
- Summary:
- In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer?s responsibility to co
- Bulletin:
- 00-001-18-3446
- Component:
- 350000 equipment
- Summary:
- Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
- Bulletin:
- 09-014-18-3443
- Component:
- 160000 structure
- Summary:
- When encountering a vehicle with paint damage, refer to the "mazda pocket paint guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
- Bulletin:
- 09-019-18-3450
- Component:
- 356000 equipment adaptive
- Summary:
- This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. the following are possible causes of floor mat interference, which can be avoided with p
- Bulletin:
- 01-008-18-3451
- Component:
- 111000 electrical system:battery
- Summary:
- This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. for new vehicles in sto
- Bulletin:
- 01-009-18-3452
- Component:
- 111000 electrical system:battery
- Summary:
- The mazda gr8-1291 is required for all warranty battery testing. if the mazda gr8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. use the following test procedures in this service bulletin to test
- Bulletin:
- 02-006-18-3449
- Component:
- 021300 suspension:front:shock absorber
- Summary:
- Some customers may complain of signs of oil on the struts or shock absorbers. in most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. follow th
- Bulletin:
- 07-002-18-3432
- Component:
- 353600 equipment:air conditioner
- Summary:
- A musty/mildew type odor may come from the vents when the air conditioning (a/c) system is operating. it is most noticeable when the a/c is first turned on. this odor is the result of mold growth in the a/cevaporator/cooling unit which is c
- Bulletin:
- 00-003-18-3480
- Component:
- 030000 brakes (pws)
- Summary:
- Mazda north american operations has approved an additional on-car brake lathe as an option for mnaoauthorized equipment. the pro-cut on-car brake lathe has been added to the mnao authorizedequipment program.note: accu-turn is still an appro
- Bulletin:
- 09-034-18-3430
- Component:
- 180000 vehicle speed control
- Summary:
- In accordance with federal regulations, follow the procedure listed below when replacing a speedometer. note: tampering with a motor vehicle odometer is strictly prohibited by federal, and state laws. it is the dealer's responsibility to co
- Bulletin:
- 01-016-18-3522
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. the odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. sulfur smell is not a
Home | Privacy