1999 LINCOLN TOWN CAR Recalls (6)

Campaign:
98V322000 on 12/17/1998
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
03/14/1996 - 12/17/1998
Affected:
175,000
Defect:
Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
Consequence:
If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
Correction:
Dealers will replace the lower control arm ball joints (2).
Notes:
Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V157002 on 06/15/2000
Component:
Seat belts:front:anchorage
Affected:
1,129
Defect:
Vehicle description: passenger vehicles using aftermarket front passenger side seat belt assemblies that were sold by ford parts departments from january 1, through june 13, 2000. these seat belt assemblies fail to comply with the requirements of fmvss no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. h 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.
Consequence:
In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.
Correction:
Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.
Notes:
Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V157001 on 06/15/2000
Component:
Seat belts:front:anchorage
Affected:
1,167
Defect:
Vehicle description: passenger vehicles using aftermarket driver's seat belt assemblies that were sold by ford parts departments from january 1, through june 13, 2000. these seat belt assemblies fail to comply with the requirements of fmvss no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. h 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.
Consequence:
In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.
Correction:
Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.
Notes:
Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V200000 on 07/19/2000
Component:
Equipment:mechanical:jacks
Manufactured:
06/09/1997 - 06/13/2000
Affected:
875,000
Defect:
Vehicle description: passenger vehicles. these vehicles have jacking instructions which, if followed, could cause the vehicle operator to place the jack on a frame weld when attempting to raise a rear wheel. if the vehicle is jacked up with the jack placed on the frame weld and if the vehicle is free to roll (wheels not blocked or chocked), the jack could yield and the vehicle may drop suddenly.
Consequence:
If this occurs and any portion of the operator's body is under the vehicle, the potential for personal injury exists.
Correction:
Owners will be provided with a revised jack instruction and stowage card and jack warning label, as well as a supplement to the owner guide.
Notes:
Owner notification began august 3, 2000.owners who do not receive the free instructions and label within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V356000 on 12/14/2000
Component:
Tires
Manufactured:
09/18/1997 - 09/25/2000
Affected:
10,000
Defect:
Vehicle description: certain limousines stretched over 60 inches fail to comply with the requirements of fmvss no. 109, "new pneumatic tires," and no. 110, "tire selection and rims."
Consequence:
The vehicle weight could exceed the maximum load rating for the tire, increasing the risk of premature tire wear or blowout.
Correction:
Dealers will replace all 5 tires (including the spare tire) with michelin tires (225/70r16 107t reinforced white sidewall) with a sufficiently higher load rating. owner notification began january 10, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-248-0186.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
15E082000 on 10/05/2015
Component:
Steering
Affected:
1,767
Defect:
Dorman products, inc. (dorman) is recalling certain model dorman steering shafts, part number 425-359, solutions steering shafts, part number 7-0359, and oe solutions steering shafts, part number 425-359, manufactured april 17, 2014, to september 28, 2015. these aftermarket replacement steering shafts are sold for use in 1995-2002 ford crown victoria, mercury grand marquis, and lincoln town car vehicles. these steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Consequence:
If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Correction:
Dorman will notify owners, and dealers will replace the steering shaft, free of charge. the recall began on october 28, 2015. owners may contact dorman customer service at 1-800-523-2492, option 5.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1999 LINCOLN TOWN CAR TSBs (157)

Bulletin:
98219
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
The rear air springs may dislodge limousine vehicles. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98219
Component:
022132 suspension:rear:springs:air suspension system:springs/bags
Summary:
Dislodgment of rear air spring from axle spring seat during acceleration or full suspension travel conditions on some limousine vehicles that are operated at or near maximum loads. *ak
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9947
Component:
061000 engine and engine cooling:engine
Summary:
Engine experiencing roughness at idle due to exhaust system resonance. *tt
Bulletin:
9948
Component:
220000 seats
Summary:
Concerns with the trim cover on back of front seats becoming dislodged. *tt
Bulletin:
5896
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Information pertaining to cluster concerns. *tt
Bulletin:
12579
Component:
133000 visibility:power window devices and controls
Summary:
Information regarding drivers door modules (ddm) incorrectly replaced when diagnosing passive anti-theft system (pats) / battery related no start conditions. *tt
Bulletin:
12609
Component:
110000 electrical system
Summary:
Information regarding pinpint test / 4wabs diagnostic trouble code b1676 (battery voltage) - update. *tt
Bulletin:
12615
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Subject regarding fuel tank clunk. *tt
Bulletin:
99B09
Component:
022000 suspension:rear
Summary:
Vehicles may develop cosmetic cracks in the frame of the rear upper control arm access opening. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6400
Component:
353600 equipment:air conditioner
Summary:
Vehicles may dispense hot air from side demister ducts in all climate control operating modes. *tt
Bulletin:
996078
Component:
162700 structure:body:trunk lid
Summary:
Subject pertaining to inoperative trunk release. *tt
Bulletin:
98-4828
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject pertaining to the service manual not having a pinpoint test for "degraded am reception or continuous seek in am" in the diagnosis and testing portion of the audio chapter. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
996748
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit the following concerns immediately after starting the vehicle: the speedometer will not display vehicle speed, the odometer display is all dashes, the message center display for distance to empty or average spe
Bulletin:
996799
Component:
353600 equipment:air conditioner
Summary:
Concerns with vehicles built from job #1 through 4/1/1999 exhibiting poor a/c performance and / or a pop / click noise in mas a/c. *tt
Bulletin:
99219
Component:
017000 steering:linkages
Summary:
This bulletin mentions that the workshop manuals do not contain a procedure for inspecting the pitman arm ball joint for wear. *tt
Bulletin:
992110
Component:
162300 structure:body:door
Summary:
Information on both front doors not staying open. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99197
Component:
980000 unknown or other
Summary:
Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
992310
Component:
353600 equipment:air conditioner
Summary:
Vehicles built through 4/16/1998 may exhibit improper, erratic, or no temperature control or poor a/c performance and / or a popping / clicking noise in max a/c on vehicles built thorugh 4/1/1999. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99247
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles equipped with factory moonroofs and built through 9/20/1999 may experience a booming noise while driving with the moonroof open. *tt
Bulletin:
7021
Component:
141100 air bags:frontal:sensor/control module
Summary:
Information regarding air bag lamp flashing. *mjs
Bulletin:
13202
Component:
140000 air bags
Summary:
Information regarding air bag lamp flashing. *mjs
Bulletin:
13268
Component:
060000 engine and engine cooling
Summary:
Some vehicles, built before august 31, 1999, electronic automatic temperature control (eatc) may display the outside temperature valve lower than the actual outisde temperature when operated under certain weather and low medium driving spee
Bulletin:
7145
Component:
353600 equipment:air conditioner
Summary:
Vehicles built before august 31, 1999 have an electronic automatic temperature control (eatc) that displays the outside temperature value lower than the actual outside temperature when operated under certain weather and low / medium driving
Bulletin:
7207
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
7249
Component:
353600 equipment:air conditioner
Summary:
Information on using peanut style a/c fittings. *tt
Bulletin:
7307
Component:
034000 service brakes, hydraulic:foundation components
Summary:
A condition may exist of a squeal / squeak from the front brakes. *tt
Bulletin:
7312
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles equipped with factory installed moonroof may exhibit a booming or buffeting noise while traveling at speeds greater than 40 mph when the moonroof is open. *tt
Bulletin:
13330
Component:
353600 equipment:air conditioner
Summary:
Subject regarding hot air from side demister ducts. *tt
Bulletin:
98164
Component:
162000 structure:body
Summary:
A transeal coating is on the front and rear bumpers. this coating must be removed before delivery to the customer. yd
Bulletin:
13025
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
0031
Component:
353600 equipment:air conditioner
Summary:
Vehicles may experience the a/c blower motor inoperative. *mjs
Bulletin:
0032
Component:
353600 equipment:air conditioner
Summary:
Vehicles may experience air conditioning inaccurate ambient temperature displayed- vehicles equipped with eatc- continental and ls built through 10/15/99, all others built through 8/31/99. *mjs
Bulletin:
8136
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Subject pertaining to heated backglass repair processes. *tt
Bulletin:
8157
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit slow moving front power windows. *tt
Bulletin:
13868
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Information regarding heated backglass repair processes. *tt
Bulletin:
8269
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding passive anti-theft system (pats) installation caution: wires may break. *tt
Bulletin:
8300
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
8382
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit a miss, buck / jerk, surge in the ignition coil / spark plug boot. *tt
Bulletin:
0062
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit idle di[ after a tip-in/tip-out maneuver, spark knock/detonation on acceleration or light load. *mjs
Bulletin:
13942
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Concerns that the passive anti-theft system (pats) transceiver wiring may be broken due to improper wire routing and / or a misplacement of the connector near the base of the steering column. *tt
Bulletin:
12068
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles will not start with a programmed passive anti-theft (pats) key for 20 seconds after an attempt to start with a non-programmed pats key. *mjs
Bulletin:
985017
Component:
021000 suspension:front
Summary:
Experiencing a grunt or squeak noise from the front suspension when turning the steering to full lock, to the left or the right. *tt
Bulletin:
12072
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Vehicle may appear to sit high in the rear when the ignition is first turned on during the first 200 miles (320 km) of vehicle operation. *mjs
Bulletin:
12120
Component:
100000 power train
Summary:
Some vehicles with 4r70w transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the vent area of the transmission. *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
985090
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a customer concern of loud ping / crackle from exhaust system during cool down. *tt
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
985096
Component:
020000 suspension
Summary:
Some vehicles may appear to sit high in the rear when the ignition is first turned on during the first 200 miles (320 km) of vehicle operation. *tt
Bulletin:
985107
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Certain vehicles will not start with a programmed passive anti-theft (pats) key for 20 seconds after an attempt to start with a non-programmed pats key. *tt
Bulletin:
8269
Component:
012200 steering:column locking:anti-theft device
Summary:
Information regarding passive anti-theft system (pats) transceiver wiring may be broken due to improper wire routing and / or a misplacement of the connector near the base of the steering column. **mr
Bulletin:
8300
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang / popping noise heard from the exhaust system during cool-down. **mr
Bulletin:
14181
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Concerns with fuel tank thump. *tt
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6218
Component:
022000 suspension:rear
Summary:
Conditions with cosmetic cracks in the frame at the rear upper control arm access opening. *tt
Bulletin:
6329
Component:
138000 visibility:defroster/defogger system
Summary:
This bulletin addresses two design changes made to enhance the windshield and side window defog / defrost performance. *tt
Bulletin:
12743
Component:
980000 unknown or other
Summary:
Exhibiting malfunction indicator lamp (mil) with diagnostic trouble codes (dtc(s) po351 and / or p0356 (coil primary circuit malfunction). *tt
Bulletin:
6728
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
6035
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles equipped with teves four wheel anti-lock brakes (4wabs) may exhibit a yellow anti-lock brake lamp illuminated with no diagnostic trouble codes in memory. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12714
Component:
161000 structure:frame and members
Summary:
Some vehicles may develop cosmetic cracks in the frame at the rear upper control arm access opening when operated under severe duty conditions. *tt
Bulletin:
12557
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit various cluster concerns such as illumination of the check traction assist lamp, speedometer reads o; digital odometer reads all dashes; message center display for dte / gte reads for loss of speed single to the he
Bulletin:
13031
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding junt-in-time pcm reprogram. *tt
Bulletin:
13065
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit poor a/c performance and / or a pop / click noise in max a/c. *tt
Bulletin:
12816
Component:
353600 equipment:air conditioner
Summary:
Concerns with hot air from side demister ducts. *tt
Bulletin:
13290
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
13355
Component:
353600 equipment:air conditioner
Summary:
Information regarding a/c peanut o-ring color. *tt
Bulletin:
13382
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a squeal / squeak from the front brakes during light brake applications. *tt
Bulletin:
13400
Component:
134000 visibility:sun roof assembly
Summary:
Some cars equipped with factory installed moonroof may exhibit a booming or buffeting noise while traveling at speeds greater than 40 mph when the moonroof is open. *tt
Bulletin:
13448
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit engine oil that has a milky appearance at predelivery inspection due to condensation in the crankcase. *tt
Bulletin:
4656
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise from exhaust system nvh damper on the left hand damper only. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4708
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may have a concern of intermittent instrument cluster gauges inoperative. *tt
Bulletin:
4715
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a customer concern of loud ping / crackle from the exhaust system during cool down. *tt
Bulletin:
11774
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise from the exhaust system nvh damper on the left hand damper only. *tt
Bulletin:
11816
Component:
980000 unknown or other
Summary:
Some vehicles may have a concern of intermittent instrument cluster gauges inoperative. *tt
Bulletin:
5107
Component:
980000 unknown or other
Summary:
Some vehicles will not start with a programmed passive anti-theft (pats) key for 20 seconds after an attempt to start with a non-programmed pats key. the pats will not recognize a programmed pats key until the system resets. *t
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5235
Component:
980000 unknown or other
Summary:
Information on the keyless entry keypad. *tt
Bulletin:
5387
Component:
980000 unknown or other
Summary:
Information on programming on valet key and spare keys. *tt
Bulletin:
12223
Component:
162300 structure:body:door
Summary:
For all vehicles with drivers door module concerns that require a module replacement, the technician must call for approval before removing and / or replacing. *tt
Bulletin:
12224
Component:
221600 seats:front assembly:power adjust
Summary:
For all vehicles with drivers seat module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12230
Component:
036000 service brakes, hydraulic:antilock
Summary:
All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12232
Component:
133000 visibility:power window devices and controls
Summary:
Information used when servicing power door lock or power window issues. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00B60
Component:
020000 suspension
Summary:
On some vehicles the rear suspension upper control arm brackets on the frame may develop minor cracks when subjected to severe duty service. *jb
Bulletin:
99B09
Component:
020000 suspension
Summary:
Subject pertaining to cosmetic cracks in frame at the rear upper control arm access opening when subjected to severe duty operating conditions. *jb
Bulletin:
0111
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, the engine mounts may not exhibit satisfactory durability under severe operating conditions that may be encountered by police, taxi or limo / livery vehicles such as extended idling at high ambient temperatures. *
Bulletin:
00142
Component:
100000 power train
Summary:
Inoperative or inaccurate speedometer, 4x4 lamp illuminated and / or diagnostic trouble codes (dtcs) p1635 or p1639 present after a powertrain control module (pcm) or instrument cluster replacement. *jb
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
00214
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding revised engine mounts for severe duty vehicles. *jb
Bulletin:
99B09
Component:
161000 structure:frame and members
Summary:
Owner notification program 99b09 supplement #2 for certain commercial vehicle frame service. *tt
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14862
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Information on replacing fuel tank strap bolts. *tt
Bulletin:
14821
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 4.6l romeo engine may exhibit an oil leak from the cylinder head gasket area. *tt
Bulletin:
14844
Component:
110000 electrical system
Summary:
Some vehicles may exhibit various intermittent / constant electrical system conditions. *tt
Bulletin:
14864
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding certain vehicles with 4.6l romeo engines exhibiting an oil leak from the cylinder head gasket area. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
01M02
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Owner notification program regarding additional coverage on certain 4.6l sohc intake manifolds. some of the composite intake manifolds may develop fatigue cracks at the coolant crossover duct. *tt
Bulletin:
01M02
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Some of the composite intake manifolds used on 4.6l sohc engines may develop fatigue cracks at the coolant crossover duct. this condition could result in engine coolant leakage which, if not serviced, may cause engine overheating. compl
Bulletin:
14918
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
Bulletin:
14907
Component:
980000 unknown or other
Summary:
Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
Bulletin:
14181
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles built up to december of 1999 may exhibit a clunk noise from the rear of the vehicle when driving over speed bumps. this may be caused by the fill-limiting valve inside the fuel tank. *tt
Bulletin:
14310
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an incorrect p1729 (4x4 low switch) diagnostic trouble code (dtc) in continues memory. *tt
Bulletin:
01137
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15158
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a fead belt jump-off toss. *yh
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
012110
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
012114
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
0222
Component:
060000 engine and engine cooling
Summary:
Some vehicles may exhibit an intake manifold crossover (first runner) coolant seepage condition. *tt
Bulletin:
02136
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
On some vehicles, the brake shift interlock may be inoperative, now allowing the operator to move the shift lever from the park position. stop lamp operation may also be affected. *tt
Bulletin:
0258
Component:
100000 power train
Summary:
Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
15889
Component:
353600 equipment:air conditioner
Summary:
Some vehicles equipped with the electronic automatic temperature control (eatc) will not cycle the ai conditioner compressor when the floor mode is selected. *tt
Bulletin:
15908
Component:
140000 air bags
Summary:
Air bag lamp illuminated with diagnostic trouble code b1994 or b1998 passenger side air bag resistance high. *tt
Bulletin:
16877
Component:
133000 visibility:power window devices and controls
Summary:
Front door glass that moves slowly or binds - glass stops 1/2 way down. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
17730
Component:
110000 electrical system
Summary:
Dashes displayed instead of an odometer reading - no communication with the anti-lock brake system (abs) module. *tt
Bulletin:
17871
Component:
116000 electrical system:ignition
Summary:
Multiple driveability concerns under acceleration caused by ignition coil. *tt
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
16380
Component:
061000 engine and engine cooling:engine
Summary:
Service cylinder head gasket for 4.6l applications. *tt
Bulletin:
17810
Component:
103000 power train:automatic transmission
Summary:
Transmission failure where there is a large amount of metal or debris in the pan. *tt
Bulletin:
17828
Component:
110000 electrical system
Summary:
Various intermittent/constant electrical concerns. *tt
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
0531
Component:
162000 structure:body
Summary:
Customer satisfaction program 05b31 - information only. a possibility that during a high speed / high energy rear collision, certain components have an increased risk of puncturing the fuel tank on vehicles with limo prep package limo pack
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
05N04
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Extended coverage program 05n04 - extended coverage for composite intake manifold. this program is being provided as a settlement to a class action lawsuit. the terms of the settlement extend the coverage of the all-composite intake manif
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
CSP 08B04
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe

Home | Privacy