1999 ISUZU RODEO Recalls (5)

Campaign:
00V058000 on 03/09/2000
Component:
Suspension:rear
Manufactured:
06/30/1998 - 10/30/1999
Affected:
213,736
Defect:
Vehicle description: sport utility vehicles. paint was applied unevenly on the rear axles, resulting in insufficient paint hardness. should this occur on the surface that contacts the rear axle lower link bracket bolt head and/or nut, the nut may loosen.
Consequence:
The bolt could detach fully, causing separation of the lower link from the rear axle, increasing the risk of loss of vehicle control.
Correction:
Dealers will replace the rear axle lower link joint nut and bolt.
Notes:
Owner notification is expected to begin during march 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070, ext. 343.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V121001 on 05/01/2000
Component:
Structure:body
Manufactured:
06/30/1998 - 10/30/1999
Affected:
45,252
Defect:
Vehicle description: sport utility vehicles. these vehicles fail to comply with the performance requirements of fmvss no. 201, "occupant protection in interior impact."
Consequence:
In the event of a crash, personal injury could occur.
Correction:
Dealers will modify the interior of your vehicle.
Notes:
Owner notification began august 10, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070, ext. 343. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01I002000 on 06/04/2001
Component:
Engine and engine cooling:engine
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-2000 rodeo (ue) and amigo (ua) models equipped with 2.2l 4-cylinder engines. the timing belt could break before the recommended scheduled maintenance.
Consequence:
This condition could cause the engine to crank but will not start or the engine could stall while driving and will not restart.
Correction:
Dealer will inspect the vehicle to determine the condition of the timing belt and tensioner. the dealer will replace the timing belt. depending on the condition or model of the timing belt tensioner, the tensioner may also be replaced. isuzu has decided to conduct a service campaign to replace the timing belt. owner notification began june 22, 2001. owners can contact isuzu at 1-800-643-4070, ext. 426, concerning this program.
Campaign:
02I002000 on 06/04/2002
Component:
Service brakes, hydraulic:antilock
Affected:
161,927
Defect:
On certain sport utility vehicles that are equipped with an anti-lock braking system (abs), the vehicles can experience extended stopping distances in certain types of braking events.
Consequence:
Extended stopping distance could result, increasing the risk of a crash.
Correction:
Dealers will provide a replacement computer algorithm for the abs that is based on the algorithm used in isuzu's my 2000 and 2001 vehicles, which have not had the problem. this campaign will be conducted in phases, with the my 1998 2wd vehicles covered first, since they have experienced the most problems. owner notification began march 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
10V436000 on 09/22/2010
Component:
Suspension:rear
Affected:
149,992
Defect:
Isuzu is recalling certain model year 1998-2002 isuzu rodeo and model year 2002 isuzu axiom vehicles, and honda is recalling certain 1998-2002 honda passport vehicles, that were originally sold, or are currently registered, in the states of maine, new hampshire, vermont, massachusetts, rhode island, connecticut, new york, new jersey, pennsylvania, delaware, maryland, the district of columbia, west virginia, ohio, indiana, michigan, illinois, wisconsin, minnesota, iowa, missouri, and kentucky. vehicles that have experienced sustained exposure to highly corrosive materials used in some jurisdictions for road deicing purposes may experience excessive corrosion in the vicinity of the forward mounting point bracket for the left or right rear suspension lower link prior to the time that such corrosion would normally be expected.
Consequence:
Excessive corrosion may result in the left or right rear suspension lower link bracket becoming detached from the frame, which can affect vehicle handling and potentially cause a crash.
Correction:
Dealers will inspect the rear suspension lower link bracket area. for vehicles in which little or no corrosion is found, the area will be treated with an anti-corrosive compound. for vehicles in which corrosion has damaged the rear suspension lower link bracket and affected its connection to the vehicle frame, a reinforcement bracket will be installed. in the rare event the corrosion is so severe that the reinforcement bracket remedy would not be appropriate, a repurchase offer will be extended to the vehicle's owner. all inspections and remedies will be provided free of charge for vehicles that are 10 years old or less. for vehicles older than 10 years, isuzu will offer a free remedy, but only if the vehicle is presented to an isuzu service facility, or honda dealer (as applicable), dealer within 12 months of when owner notifications were issued. the safety recall began on december 10, 2010. isuzu owners may contact isuzu at 1-800-255-6727. honda owners may contact honda at 1-800-999-1009.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1999 ISUZU RODEO TSBs (47)

Bulletin:
9802L003
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
Information on the accelerator pedal pad replacement service campaign. *yc
Bulletin:
SB9907S001
Component:
106100 power train:axle assembly:banjo housing
Summary:
A condition may exist where evidence of leaking differential lubricant on the exterior surface of the rear axle housing, and rear brake dust shield. *tt
Bulletin:
SB9914S007
Component:
220000 seats
Summary:
Information regarding the availability of the child seat tether anchor kit. *tt
Bulletin:
SB9908S001
Component:
190000 tires
Summary:
Information on tire pressure - workshop manual revisions. *tt
Bulletin:
SB9909S002
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Subject regarding 2wd rear drum brake adjustment procedure. *tt
Bulletin:
SB0008S001
Component:
020000 suspension
Summary:
Some vehicles may demonstrate a body vibration at highway speeds. *tt
Bulletin:
SB0003S001
Component:
185000 vehicle speed control:cruise control
Summary:
Some owerns may comment on erratic / unstable idle at start-up. *tt
Bulletin:
SB0002S001
Component:
070000 fuel system, gasoline
Summary:
A condition may exist where the p1441 evaporative emission code. *tt
Bulletin:
SB0004S002
Component:
136000 visibility:windshield wiper/washer
Summary:
Some owners may comment on windshield washer fluid leak. *tt
Bulletin:
SB0005S002
Component:
103700 power train:automatic transmission:torque converter
Summary:
Certain vehicles equipped with automatic transmission (serial number 5504006 - 5570892) may exhibit the malfunction indicator lamp on and tech-ii indicates the presence of torque converter (diagnostic trouble code 1870) on. *tt
Bulletin:
SB0001S005
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing intermittent rough idle and / or the malfunction indicator lamp is on with diagnostic trouble codes p0171, p0174, or p1171. *tt
Bulletin:
SB0004S001
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Some vehicles may exhibit one or more abs diagnostic trouble codes such as: rear speed sensor open or shorted; speed sensor missing; wheel speed input abnormality. *tt
Bulletin:
SB0002S002
Component:
063000 engine and engine cooling:exhaust system
Summary:
Service information regarding all affected vehicles with the p1441 evaporative emission code that has been diagnosed with no fault found from the appropriate flow chart in the driveability and emissions manual. *tt
Bulletin:
SB0001S003
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
On some vehicles within vin y4300787 / 74400051, the engine mounts may not isolat engine vibration. *tt
Bulletin:
IB0006S001
Component:
020000 suspension
Summary:
Subject regarding alignment specification change. *tt
Bulletin:
SB0008S003
Component:
200000 wheels
Summary:
Some vehicles built prior to vin breakpiont y4329627 may demonstrate a rear wheel vibration at highway speeds. *tt
Bulletin:
IB00S009
Component:
132000 visibility:glass, side/rear
Summary:
Some aftermarket tint installers may scratch the heating element (defroster lines) or etch the glass (start of the break area) during installation, from affixing aftermarket film tint material to the tailgate glass. *tt
Bulletin:
IB00S007
Component:
980000 unknown or other
Summary:
On suv vehicles with automatic transmissions, some remote starter installations may cause the malfunction indicator light to set and store p0705. american isuzu motors does not sell remote starter kits and does not recommend any particula
Bulletin:
IB00S005
Component:
061000 engine and engine cooling:engine
Summary:
This information bulletin outlines the proper steps to index the camshafts with the crankshaft for vehicles equipped with direct attack dohc 3.2l / 3.5l v6 engine. in the event that camshaft timing has been disrupted, due to timing belt b
Bulletin:
SB0010S001
Component:
020000 suspension
Summary:
Some owners of vehicles within vin 8x4351792 may exhibit steering wheel vibration or shimmy during vehicle operation at medium to high speed. a steering nibble may be felt in the steering wheel when driving on smooth roads at highway spee
Bulletin:
SB0008S002
Component:
020000 suspension
Summary:
Some vehicles may demonstrate a body vibration at highway speeds. *tt
Bulletin:
IB0012S003
Component:
353600 equipment:air conditioner
Summary:
Information bulletin regarding rodeo and amigo / rodeo sport hvac operation update for vehicles with factory installed air conditioning only. *tt
Bulletin:
IB0004S005
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin provides information on the p1640 and p1650 output drive codes which refer to output driver circuit conditions related to the pcm. *tt
Bulletin:
IB0004S008
Component:
980000 unknown or other
Summary:
Some vehicles may randomly set a pcm code p0502 in a deceleration mode usually with 0% throttle. the malfunction indicator light will only set after the fault has been detected for two consecutive key cycles. *tt
Bulletin:
IB0004S009
Component:
110000 electrical system
Summary:
Some vehicles that have recently had the engine replaced with a long block will set code p1336 for tooth error correction. *tt
Bulletin:
IB0104S002
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding p0337 crankshaft position sensor circuit low input correction. *tt
Bulletin:
IB0110S001
Component:
010000 steering
Summary:
Information regarding sector shaft alignment on the steering rack assembly. *tt
Bulletin:
SB0108S001
Component:
020000 suspension
Summary:
Some vehicles built prior to vin breakpoint 14330722 equipped with oem p215 / 235 15 inch and p225 / 245 16 inch tires may exhibit a steering wheel vibration / shimmy (nibble) or body vibration through the steering wheel or floorboard respe
Bulletin:
SB0111S006
Component:
200000 wheels
Summary:
Some vehicles built prior to vin breakpoint 14327313 may experience mud flap interference causing a rubbing sound when making a turn. *tt
Bulletin:
IB0101S002
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding hec engine timing belt scrapping. *tt
Bulletin:
IB0109S001
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Subject regarding drum brake adjustment procedure. *tt
Bulletin:
SB0105S001
Component:
103000 power train:automatic transmission
Summary:
Some v6 models with transmission serial numbers 4754596 - 5831756 may experience leakage in the area of overfill plug and oil drain plug. *tt
Bulletin:
SB0109S001
Component:
036000 service brakes, hydraulic:antilock
Summary:
Technical service information regarding the electronic hydraulic control unit (abs pump runs). *tt
Bulletin:
0211S002
Component:
162000 structure:body
Summary:
Rear storage compartment lid lock knob broken. *jg
Bulletin:
0204S003
Component:
100000 power train
Summary:
Replacement odometer programing. *jg
Bulletin:
0205S003
Component:
103000 power train:automatic transmission
Summary:
Transmission indicator light may be on and diagnostic trouble code p1870 is set in the pcm (powertrain control module). *tt
Bulletin:
0309S001C
Component:
046100 service brakes, air:antilock:control unit/module
Summary:
Abs (anti-lock brake system), coil integrated module replacement safety improvement campaign. *tt
Bulletin:
0305S001
Component:
103000 power train:automatic transmission
Summary:
Transmission indicator light may be on and diagnostic trouble code p1870 is set in the powertrain control module (pcm). *tt
Bulletin:
0301S002
Component:
061000 engine and engine cooling:engine
Summary:
Throttle body mounting bolt torque specifications. *tt
Bulletin:
0309S001B
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Abs (anti-lock brake system), coil integrated module replacement safety improvement campaign. *tt
Bulletin:
0309S001C
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Abs (anti-locking brake) system, coil integrated module replacement safety improvement campaign 02i-002 phase 3 of a 4 phase release. *tt
Bulletin:
0309S001C
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Abs (anti-locking brake) system, coil integrated module replacement phase 3 announcement. *tt
Bulletin:
0211S004
Component:
350000 equipment
Summary:
Rear beverage holder swing arm loose. *tt
Bulletin:
0208S001
Component:
190000 tires
Summary:
Termination of tire replacement program. *tt
Bulletin:
0505004
Component:
100000 power train
Summary:
Shift lock solenoid removal and replacement procedures. *tt 2002-2004 isuzu axiom (up), 198-2004 rodeo (ue) and 1998-2004 rodeo sport. update *sc
Bulletin:
0709002
Component:
045300 service brakes, air:disc:rotor
Summary:
Rear brake rotors. *kb
Bulletin:
PIP3720D
Component:
106000 power train:axle assembly
Summary:
This preliminary information communication provides information to the technician with the axel setup information from american axle manufacturing. technician should be advised that the maximum pinion shim to be used or stacked behind the p

Home | Privacy