1999 GEM NEV Recall

Campaign:

06V222000 on 06/20/2006

Component:

Electrical system

Manufactured:

12/31/1998 - 03/30/2004

Affected:

27,350

Defect:

On certain 2 and 4 passenger, short and long bed low speed vehicles, the 12 volt output from the auxiliary card circuit board (a dc voltage to dc voltage converter) may become inoperative and result in loss of headlamp, tail lamp and turn signal lamp functions.

Consequence:

A loss of headlamps could impair a driver's visibility, increasing the risk of a crash. if there is a loss of tail lamp or turn signal lamp function, a following driver may not know when the brakes have been applied or that the vehicle in front is turning, a rear-end crash could occur without prior warning.

Correction:

Dealers will replace the auxiliary cards, install a splash/spray protection, and adjust the dash seal free of charge. the recall began on september 11, 2006. owners may contact global electric at 888-871-4367.

Notes:

Gemcar recall no. 002.customers can also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

1999 GEM NEV TSB

Bulletin:

97A2001

Component:

162300 structure:body:door

Summary:

Gem: installation of the riv nut as a replacement to the rubber well nut for the framed canvas door option. in the event of part failure, the rubber well nut will need to be replaced. *pe

Home | Privacy