1999 FORD WINDSTAR Recalls (13)

Campaign:
99V147000 on 06/15/1999
Component:
Service brakes, hydraulic:foundation components:master cylinder
Manufactured:
06/15/1996 - 05/30/1999
Affected:
789,723
Defect:
Vehicle description: minivans. the brake fluid master cylinder is recessed and oriented in the engine compartment so that the brake fluid warning statement embossed on both the top of the filler cap and the side of the reservoir body are not entirely visible by direct view. these vehicles may not fully comply with requirements of fmvss no. 135, "passenger car brake systems."
Correction:
Owners will be provided with new labels and installation instructions.
Notes:
Owner notification began june 16, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99I001000 on 07/20/1999
Component:
Structure:body
Affected:
15,900
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: minivans. the overhead console rear retaining bracket can develop cracks and separate, allowing the overhead console to become loose and possibly fall down.
Consequence:
If the console does fall down, it could distract the driver or possibly strike a front seat occupant.
Correction:
Dealers will install a redesigned retaining bracket in the same location as the original retaining bracket.
Notes:
Ford has decided to conduct a service program to replace the overhead console retaining bracket.owners can contact ford at 1-800-392-3673, concerning this program.
Campaign:
00V351000 on 10/30/2000
Component:
Electrical system:wiring:interior/under dash
Manufactured:
02/17/1999 - 01/31/2000
Affected:
180,000
Defect:
Vehicle description: minivans built with instrument clusters without the message center, fail to comply with the requirements of standard no. 118, "power-operated window, partition, and roof panel systems." the power windows may be operable after the ignition has been turned to the "off" position and the front doors are opened.
Consequence:
The standard requires that power operated windows may be closed only when the key is in the "on," "start," or "accessory" positions, or during the interval between the time the key is turned off, and the opening of either of the vehicle's front doors.
Correction:
Dealers will reconfigure the vehicle front end electronic module.
Notes:
Owner notification began january 24, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V261000 on 08/26/2001
Component:
Visibility:windshield wiper/washer:motor
Manufactured:
04/15/1998 - 06/01/2001
Affected:
598,256
Defect:
Vehicle description: mini vans. contaminants such as water, salt, and windshield washer solution can enter the wiper motor cover assembly through pinholes on the exterior of the cover that are used in the molding process. in addition, on certain of the vehicles built between february and august 2000, a switch located in the plastic cover of the wiper motor gear case could malfunction and overheat. either of these conditions could potentially result in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, smoke, or ignition of the plastic cover material. contaminant entry could also result in unintended wiper motor operation.
Consequence:
Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. loss of visibility while driving increases the risk of a crash.
Correction:
Dealers will install a new wiper cover with improved sealing and water resistance. owner notification begain august 27, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V262000 on 08/26/2001
Component:
Equipment:air conditioner
Manufactured:
04/15/1998 - 12/16/2000
Affected:
413,245
Defect:
Vehicle description: mini vans equipped with auxiliary rear air-conditioning. if the auxiliary air-conditioning blower motor stops turning while in the medium-low blower speed setting, there is the potential that the resistor may become hot and smoke.
Consequence:
The motor could potentially catch on fire.
Correction:
Dealers will install a jumper wire that will ensure that the medium-low blower speed setting is protected by the thermal limiter. owner notification began augsut 27, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E056000 on 06/22/2006
Component:
Fuel system, gasoline
Affected:
58,640
Defect:
Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence:
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Correction:
Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
Notes:
This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09V399000 on 10/12/2009
Component:
Vehicle speed control
Manufactured:
06/15/1995 - 10/23/2002
Affected:
4,500,000
Defect:
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
Consequence:
A vehicle fire could occur with or without the engine running.
Correction:
Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
Notes:
Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V385000 on 08/25/2010
Component:
Suspension:rear:axle:non-powered axle assembly
Manufactured:
08/31/2007 - 07/02/2003
Affected:
492,650
Defect:
Ford is recalling certain model year 1998-2003 windstar vehicles manufactured from september 1, 1997 through february 28, 2003 and currently registered or originally sold in connecticut, delaware, district of columbia, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, and wisconsin. after many years of vehicle service in these areas, corrosion can weaken the rear axle, making it susceptible to torsional stress. corrosion and stress can lead to cracks which if undetected can propagate and result in a complete fracture of the axle.
Consequence:
A fractured axle can affect vehicle handling and increase the risk of a crash.
Correction:
As parts become available, dealers will inspect and if necessary install the rear axle reinforcement brackets free of charge. this service will be performed free of charge. the safety recall began on october 20, 2010. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall no. is 10s13.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V030000 on 01/25/2011
Component:
Structure: frame and members:underbody shields
Affected:
425,288
Defect:
Ford is recalling certain model year 1999-2003 windstar vehicles originally sold in or currently registered in the states of connecticut, delaware, the district of columbia, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, utah, vermont, west virginia, and wisconsin. a separation of a front lower control arm rear attaching bracket may result in a lower control arm separation. a separation of both front subframe rear body mounts may result in separation of the steering intermediate shaft.
Consequence:
This could result in reduced steering control increasing the risk of a crash.
Correction:
Dealers will inspect both front lower control arm rear attaching brackets, and both body mount attachments at the rear of the front subframe, and make the necessary repairs free of charge. if repairs cannot be made to a vehicle, ford will offer to repurchase the vehicle. the safety recall is expected to begin on or before february 21, 2011. owners may contact ford at 1-866-436-7332.
Notes:
Ford's safety recall no. 11s16.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V193000 on 05/02/2012
Component:
Power train:axle assembly
Manufactured:
08/31/1997 - 07/02/2003
Affected:
27,000
Defect:
Ford is recalling certain model year 1998-2003 windstar vehicles manufactured from september 1, 1997, through july 3, 2003, and currently registered or originally sold in virginia. over time, corrosion can weaken the rear axle making it susceptible to torsional stress. corrosion and stress can lead to cracks which, if undetected, can increase and result in a complete fracture of the axle.
Consequence:
A fractured axle can affect vehicle handling and increase the risk of a crash.
Correction:
Ford will notify owners, and dealers will inspect and install rear axle reinforcement brackets, or replace the axles, as necessary. this service will be performed free of charge. the recall began on june 19, 2012. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall campaign number is 10s13.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
12V194000 on 05/02/2012
Component:
Suspension:front:control arm
Affected:
23,000
Defect:
Ford is recalling certain model year 1999-2003 windstar vehicles originally sold in or currently registered in the state of virginia. corrosion-related fractures of the front lower control arm rear attaching brackets and body mount attachments may occur.
Consequence:
A separation of a front lower control arm rear attaching bracket may result in a lower control arm separation. a separation of both front subframe rear body mounts may result in separation of the steering intermediate shaft. either condition could result in significant loss of steering control, increasing the risk of a crash.
Correction:
Dealers will inspect both front lower control arm rear attaching brackets and both body mount attachments at the rear of the front subframe and make the necessary repairs free of charge. the recall began on june 18, 2012. owners may contact ford at 1-866-436-7332.
Notes:
Ford's recall campaign number is 11s16.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
12V195000 on 05/02/2012
Component:
Suspension:rear:axle:non-powered axle assembly
Affected:
9,192
Defect:
Ford is recalling certain model year 1998-2003 windstar vehicles manufactured from september 1, 1997, through july 3, 2003, registered in puerto rico. due to increased stresses caused by high cycles of torsional loading, specific to this market, the rear axle can crack.
Consequence:
A fractured axle may result in a loss of vehicle control, increasing the risk of a crash.
Correction:
Ford will notify owners, and dealers will inspect and install a reinforcement bracket on the rear axle or replace the axles, as necessary. this service will be provided free of charge. the recall began on june 1, 2012. owners may contact the ford motor company customer relationship center at 1-866-436-7332.
Notes:
Ford's safety recall campaign number is 12s30.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
15V608000 on 09/28/2015
Component:
Suspension:rear:axle:non-powered axle assembly
Manufactured:
09/01/1997 - 07/02/2003
Affected:
283,413
Defect:
Ford motor company (ford) is recalling certain model year 1998-2003 windstar vehicles manufactured september 2, 1997, to july 3, 2003. the affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. the incorrect bracket installations may limit the effectiveness of the service repair for nhtsa recalls 10v-385, 12v-193, and 12v-195.
Consequence:
If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.
Correction:
Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. if a bracket is found to have been misinstalled, the rear axle will be replaced. these repairs will be performed free of charge. the began on october 21, 2015. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 15s27.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1999 FORD WINDSTAR TSBs (324)

Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
98218
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Experiencing inability to retrieve data from vehicle module. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982317
Component:
162000 structure:body
Summary:
Product changes for 1999 windstar. *yc
Bulletin:
98241
Component:
012200 steering:column locking:anti-theft device
Summary:
Diagnostic service tips on passive anti theft system ( pats ). *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
99410
Component:
342000 communications:back up alarm
Summary:
Concerns of false activation of the reverse sensing system (rss). *tt
Bulletin:
5787
Component:
133000 visibility:power window devices and controls
Summary:
Concerns with rear speakers that cut-out intermittently. *tt
Bulletin:
5805
Component:
162300 structure:body:door
Summary:
Concerns with the front door power locks that ratchet during operation. *tt
Bulletin:
5806
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit concerns of no reverse or intermittent reverse engagement. *tt
Bulletin:
5818
Component:
980000 unknown or other
Summary:
Information on diagnosing a lamp outage indicator. *tt
Bulletin:
5846
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This bulletin contains specific clock set procedure for vehicles equipped with the base radio option (am / fm stereo - no cassette or cd). *tt
Bulletin:
5854
Component:
090000 fuel system, other
Summary:
Some vehicles built prior to 02/15/99 may exhibit a fuel gauge indicator that remains in the same position (does not update) or registers below e (empty after filling the tank. *tt
Bulletin:
5857
Component:
061000 engine and engine cooling:engine
Summary:
Vehicle exhibiting no reverse or intermittent no reverse engagement during extreme cold temperatures. *tt
Bulletin:
12503
Component:
162300 structure:body:door
Summary:
Information on front door power lock(s) which ratchet during operation. *tt
Bulletin:
12504
Component:
102000 power train:manual transmission
Summary:
Vehicles built before march 1999 may exhibit concern of no reverse or intermittent reverse engagement. *tt
Bulletin:
12578
Component:
116200 electrical system:ignition:module
Summary:
Information pertaining to configurable electronic modules reminder. *tt
Bulletin:
12589
Component:
190000 tires
Summary:
Information on wheel and tire size and its effect on vehicle speed. *tt
Bulletin:
12606
Component:
162500 structure:body:tailgate
Summary:
Experiencing rattle / chuck noise from liftgate area due to lubricant that has been applied to the liftgate wedges. *tt
Bulletin:
12607
Component:
116200 electrical system:ignition:module
Summary:
Information and tips on diagnosing the front electronic module (fem) and rear electronic module (rem). *tt
Bulletin:
12617
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Experiencing rattle noise within the upper intake manifold. *tt
Bulletin:
12620
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Vehicle may exhibit beeping sound from instrument panel when driving at / over a speed of 75 mph. *tt
Bulletin:
99B11
Component:
162000 structure:body
Summary:
Subject regarding vehicle component upgrade. *tt
Bulletin:
9984
Component:
022000 suspension:rear
Summary:
Experiencing squeakng / rattling noise coming from left and / or right rear of vehicle caused b the parking brake cable or retaining spring rubbing against the body. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
991213
Component:
980000 unknown or other
Summary:
Information regarding the transmission control indicator lamp (tcil) illuminated with diagnostic trouble codes (dtcs) p0715 and p0717 stored in memory. *tt
Bulletin:
99135
Component:
980000 unknown or other
Summary:
Information on resetting the engine oil change interval schedule using the message center commands on some vehicles. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6352
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject pertaining to a whistle noise from engine area. *tt
Bulletin:
6375
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a traction control warning lamp being illuminated. *tt
Bulletin:
6406
Component:
070000 fuel system, gasoline
Summary:
Information regarding the average fuel economy (afe) feature accuracy - reset procedure. *tt
Bulletin:
6407
Component:
136000 visibility:windshield wiper/washer
Summary:
Exhibiting front windshield wiper activation without command. *tt
Bulletin:
12826
Component:
136000 visibility:windshield wiper/washer
Summary:
Experiencing front wipers activation without command. *tt
Bulletin:
12832
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Exhibiting a traction control warning lamp being illuminated. *tt
Bulletin:
12885
Component:
131000 visibility:windshield
Summary:
Information pertaining to the left side front door glass demister. *tt
Bulletin:
12891
Component:
341000 communications:horn assembly
Summary:
Conditions with horn that requires high effort to operate. *tt
Bulletin:
12911
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit activation of front wipers without command. *tt
Bulletin:
996106
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some reports indicate that the oil reset procedure listed in the owners guide may be difficult to follow. *tt
Bulletin:
996126
Component:
162000 structure:body
Summary:
Conditions with liftgate popping noise. *tt
Bulletin:
9912780
Component:
980000 unknown or other
Summary:
Some vehicles may display a compass direction that is 180 degrees off. *tt
Bulletin:
99173
Component:
353000 equipment:electrical
Summary:
Concerns with message center on the instrument panel displaying a false traction control error message. *tt
Bulletin:
99176
Component:
353600 equipment:air conditioner
Summary:
On some vehicles, the driver side window may be slow to defog. *tt
Bulletin:
99177
Component:
342000 communications:back up alarm
Summary:
Some customers may complain that the reverse park aid system may sound an audible warning tone when the vehicle is in reverse even though there are no objects behind the vehicles. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
996735
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with the ax4s transaxle may exhibit a harsh 3-2 downshift when coasting around a corner and then stepping into the throttle to accelerate away from the corner. *tt
Bulletin:
996742
Component:
133000 visibility:power window devices and controls
Summary:
Some vehciles may exhibit a popping noise when the power sliding door reaches the closed position, caused by the door striker adjustment and the door seal. *tt
Bulletin:
996797
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This online bulletin contains information of vehicles exhibiting a poor or no radio reception at pre-delivery inspection. *tt
Bulletin:
996841
Component:
980000 unknown or other
Summary:
This online service bulletin contains procedures to reset the oil change interval message 'change oil soon' indicator in the message center. *tt
Bulletin:
996842
Component:
980000 unknown or other
Summary:
Concerns with snapping or popping noise from the instrument panel lower center bin area. *tt
Bulletin:
9913028
Component:
133000 visibility:power window devices and controls
Summary:
Customers may complain of popping noise when the power sliding door reaches the closed position. *tt
Bulletin:
9913073
Component:
353600 equipment:air conditioner
Summary:
Climate control is investigating concerns of broken and / or binding blend doors. *tt
Bulletin:
9913140
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with ax4s transaxle may exhibit any or all of the following symptoms: dtc p0734, flashing tcil, "no 3-4 shift" or an overdrive band wear concern. *tt
Bulletin:
99202
Component:
106000 power train:axle assembly
Summary:
This bulletin mentions that some vehicles with an ax4s or ax4n transaxles have a new redesigned park system in the transaxle. *tt
Bulletin:
99216
Component:
980000 unknown or other
Summary:
The a-pillar trim may become warped as a result of stress from the expansion and contraction of the material due to temperature changes. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99224
Component:
136000 visibility:windshield wiper/washer
Summary:
Subject regarding front wipers operating while switch is in off position. *tt
Bulletin:
99B14
Component:
162300 structure:body:door
Summary:
Owner notification program regarding vehicles without inboard front seat-mounted armrests but stated otherwise on the window sticker and in sales literature. *tt
Bulletin:
99183
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information on revised oil pan gasket replacement procedure. *tt
Bulletin:
99184
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with ax4s transaxle, may exhibit a harsh 2-3 downshift may occur when coasting around a corner and then accelerating. *tt
Bulletin:
99191
Component:
980000 unknown or other
Summary:
Some vehicles built through 4/27/1999 may exhibit a transmission control indicator lamp illuminated with diagnostic trouble codes p0715 and p0717 stored in memory. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99243
Component:
126200 exterior lighting:turn signal:switch
Summary:
On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
Bulletin:
6908
Component:
106000 power train:axle assembly
Summary:
Some vehicles with ax4s transaxle may exhibit a diagnostic trouble code p0734, flashing tcil, no3-4 shift or an overdrive band wear concern. *tt
Bulletin:
6918
Component:
106000 power train:axle assembly
Summary:
Information on the redesigned park system in vehicles with ax4s transaxles. *tt
Bulletin:
6996
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding a change in the torque values of the engine front cover water pump bolts. *tt
Bulletin:
6997
Component:
061000 engine and engine cooling:engine
Summary:
Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
Bulletin:
7016
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Information regarding instrument cluster technical assistance. *mjs
Bulletin:
7018
Component:
022000 suspension:rear
Summary:
Information regarding squeak/rattle right rear exterior of vehicle. *mjs
Bulletin:
7106
Component:
980000 unknown or other
Summary:
Information regarding the winners of the edsr of the month quality awards for the month of august. *mjs
Bulletin:
13167
Component:
980000 unknown or other
Summary:
Information regarding compass direction indicated is 180 degress off. *mjs
Bulletin:
13180
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
Bulletin:
13181
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart (continued). *mjs
Bulletin:
13186
Component:
060000 engine and engine cooling
Summary:
Information regarding front cover & water pump bolts-torque valve revision/3.8-4.2l. *mjs
Bulletin:
13198
Component:
022000 suspension:rear
Summary:
Information regarding squeak/rattle right rear exterior of vehicle. *mjs
Bulletin:
13253
Component:
136000 visibility:windshield wiper/washer
Summary:
(continued from 13251 and 13252) uncommanded front wiper function. *mjs
Bulletin:
13256
Component:
204000 wheels:cap/cover/hub
Summary:
Information regarding starbusrt wheel caps loose/rattle. *mjs
Bulletin:
13257
Component:
110000 electrical system
Summary:
Information regarding configurable electronic modules reminder. *mjs
Bulletin:
7134
Component:
204000 wheels:cap/cover/hub
Summary:
Some vehicles built from 5/20/98 to 12/31/98 equipped with starburst type wheel covers may exhibit a loose wheel cap or rattle noise from the wheel caps. *tt
Bulletin:
7135
Component:
110000 electrical system
Summary:
Subject regarding configurable electronic modules reminder. *tt
Bulletin:
7211
Component:
162500 structure:body:tailgate
Summary:
Exhibiting a rattle noise from the liftgate area. *tt
Bulletin:
7266
Component:
020000 suspension
Summary:
Vehicles may exhibit a slight vibration under light acceleration at or near 1400 - 1600 rpm. *tt
Bulletin:
7309
Component:
204000 wheels:cap/cover/hub
Summary:
Subject regarding starburst type wheel caps that rattle or appear loose. *tt
Bulletin:
7318
Component:
116100 electrical system:ignition:switch
Summary:
Exhibiting headlamps that turn on and a blower motor that will operate with the ignition switch in the off position. *tt
Bulletin:
7320
Component:
046200 service brakes, air:antilock:interconnecting assembly(wiring)
Summary:
Subject regarding the trailer tow electric brake connector location. *tt
Bulletin:
13329
Component:
133000 visibility:power window devices and controls
Summary:
Information on disabling the autolock feature on some vehicles. *tt
Bulletin:
13421
Component:
330000 interior lighting
Summary:
Subject pertaining to vehicles equipped with heated outside mirrors exhibiting interior lights that illuminate when the rear defrost button is activated. *tt
Bulletin:
6497
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Exhibiting driver front door glass that seems slow to clear / defog. engineering is developing a new side window demister vent due for release by august 15, 1999. *tt
Bulletin:
6502
Component:
341000 communications:horn assembly
Summary:
Some customers may comment that the horn requires higher than normal effort to operate. *tt
Bulletin:
6618
Component:
353600 equipment:air conditioner
Summary:
Exhibiting poor air conditioner performance and / or pressure relief valve releasing refrigerant. *tt
Bulletin:
6647
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting engine spark knock on heavy acceleration with 87 octane fuel. *tt
Bulletin:
6663
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit an intermittent loss of sound / cut-out of the rear speaker(s) during turns or driving over bumps. *tt
Bulletin:
13014
Component:
162000 structure:body
Summary:
Brief information regarding paint quality issues. *tt
Bulletin:
13017
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit an inoperative speed control that will not engage at times or at all times. *tt
Bulletin:
13024
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with the ax4s transaxle may exhibit a harsh 3-2 downshift when coasting around a corner and then stepping into the throttle to accelerate away from the corner. *tt
Bulletin:
7364
Component:
330000 interior lighting
Summary:
Some vehicles equipped with heated outside mirrors may exhibit interior lights that illuminate when the rear defrost button is activated. *tt
Bulletin:
7542
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customers may experience a hum / moan from the underhood area with the engine running on vehicles equipped with 3.8l engines. *tt
Bulletin:
13466
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a check engine light on and diagnostic trouble codes p0750, p0760, and / or an open fuse #10 (located in the fuse junction panel inside the vehicle) and fuse #20 (located in the battery junction box under the hood)
Bulletin:
13554
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Concerns with dust entering into auxiliary air conditioner air distribution. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
8036
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Some fleet customers may want to disable the child lock feature on the sliding doors and prevent it from being accidently re-activated. *tt
Bulletin:
7866
Component:
100000 power train
Summary:
The vehicle may exhibit a dtc p0720 and p0722; output shaft speed (oss) sensor concerns.
Bulletin:
8053
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit a diagnostic trouble code of p0720, p0722; output shaft speed sensor (oss). *tt
Bulletin:
8119
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may exhibit a power steering grunt noise or shudder on slow turns. *tt
Bulletin:
8133
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit a center storage bin door that binds when attempting to open or close the door. *tt
Bulletin:
0044
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Vehicle may experience the fuel pump handle that may shut off while filling vehicle before tank is full. *mjs
Bulletin:
8233
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 3.8l engine may exhibit a slight spark knock on heavy acceleration with 87 octane fuel. *tt
Bulletin:
13858
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may exhibit a power steering grunt noise or shudder on slow turns. engineering is investigating. *tt
Bulletin:
13867
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit a center storage bin door that binds when attempting to open or close the door. *tt
Bulletin:
7989
Component:
133000 visibility:power window devices and controls
Summary:
Power sliding door concern.
Bulletin:
8119
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may exhibit a power steering grunt noise or shudder on slow turns. engineering is investigating. *tt
Bulletin:
8233
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles equipped with 3.8l engine may exhibit a slight spark knock on heavy acceleration with 87 octane fuel. *tt
Bulletin:
8242
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some vehicles built before november, 1999 may exhibit transmission fluid at the bell housing area. *tt
Bulletin:
8261
Component:
111000 electrical system:battery
Summary:
Experiencing a discharged battery after extended parking (> 30 days). *tt
Bulletin:
8310
Component:
106000 power train:axle assembly
Summary:
Ax4s transaxle - rear lube and differential lube insulator kit. *tt
Bulletin:
8321
Component:
103700 power train:automatic transmission:torque converter
Summary:
Some vehicles, 3.8l engine, may exhibit a drone (audible noise) and a tactile vibration in the steering wheel (higher frequency buzz) at 1350-1400 rpm (40-45 mph) under a light load with the torque converter locked in 3rd or o/d. *tt
Bulletin:
8325
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles built from 1/31/00 may exhibit an unable to reprogram the pcm or unable to clear the pcm vid (vehicle identification) block condition, or unable to reprogram the pcm or unable to clear pcm vid block on vehicles where the icm (
Bulletin:
8348
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit door glass that may bind or trvel slowly up / down. *tt
Bulletin:
13792
Component:
133000 visibility:power window devices and controls
Summary:
Vehicles may exhibit a power sliding door concern and servicing. *mjs
Bulletin:
13812
Component:
133000 visibility:power window devices and controls
Summary:
Information on how to disable the child lock feature. *mjs
Bulletin:
13941
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with the rear seat entertainment system may exhibit an inoperative condition when vehicle cabin temperature is very low, then is rapidly heated, or the humidity is very high within the vehicle. *tt
Bulletin:
13961
Component:
106000 power train:axle assembly
Summary:
Information regarding the ax4s transaxle - rear lube and differential lube tube insulator kit. *tt
Bulletin:
13826
Component:
105300 power train:driveline:driveshaft
Summary:
Some vehicles may exhibit a dtc of po720,po722, output shaft speed sensor (oss). *mjs
Bulletin:
13982
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit door glass that may bind or travel slowly up / down. *tt
Bulletin:
13924
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some vehicles built before november 1999 may exhibit transmission fluid at the bell housing area. *tt
Bulletin:
13935
Component:
111000 electrical system:battery
Summary:
Some vehicles may exhibit a discharged battery after extended parking (> 30 days). *tt
Bulletin:
13957
Component:
103700 power train:automatic transmission:torque converter
Summary:
Some vehicles may exhibit a drone (audible noise) and a tactile vibration in the steering wheel (higher frequency buzz) at 1350 - 1400 rpm (40-45 mph) under a light load with the torque converter locked in 3rd or o/d. *tt
Bulletin:
13969
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Vehicles built from 01/31/00 may exhibit an unable to reprogram the pcm or unable to clear the pcm vid (vehicle identification) block conition, or unable to reprogram the pcm or unable to clear pcm vid block on vehicles where the icm (instr
Bulletin:
12084
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some reports indicate that the message center oil change reset instruction in the owners guide may be difficult to follow. *mjs
Bulletin:
12096
Component:
103000 power train:automatic transmission
Summary:
Sine vehicles may exhibit a harsh 3-2 transmission downshift immediately after cold engine drive away and before the engine has fully warmed up. *mjs
Bulletin:
12117
Component:
110000 electrical system
Summary:
Some vehicles may exhibit various electrical concerns caused by the tire jack pinching wires to the rear electronic module (rem). *mjs
Bulletin:
12141
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit engine compartment noise heard in passenger compartment. *mjs
Bulletin:
985086
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a customer concern described as an air conditioner hiss noise. *tt
Bulletin:
12173
Component:
330000 interior lighting
Summary:
Some vehicles may exhibit a condition of interior/courtesy lamps on at all times. *mjs
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
12181
Component:
162300 structure:body:door
Summary:
Information for all 1999 windstar vehicles equipped with autolock, it is currently not possible to disable/enable the feature if desired. *mjs
Bulletin:
985098
Component:
160000 structure
Summary:
Certain vehicles will arrive at dealership with small black plastic spacer clips installed between the rear backglass and the exterior body. *tt
Bulletin:
985100
Component:
355200 equipment:other:owners/service/other manual
Summary:
Reports indicate that the message center oil change reset instructions in the owners guide may be difficult to follow. *tt
Bulletin:
985109
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a harsh 3-2 transmission downshift immediately after cold engine durive away and before the engine has fully warmed up. *tt
Bulletin:
985155
Component:
110000 electrical system
Summary:
Some vehicles may exhibit various electrical concerns caused by the tire jack pinching wires to the rear electronic module (rem). *tt
Bulletin:
5186
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine compartment noise heard in passenger compartment. *tt
Bulletin:
8242
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some vehicles may exhibit transmission fluid at the bell housing area. **mr
Bulletin:
8310
Component:
106000 power train:axle assembly
Summary:
Rear lube and differential tube insulator kit. **mr
Bulletin:
8532
Component:
980000 unknown or other
Summary:
Information regarding malfunction indicator lights p0171 / p0174. **mr
Bulletin:
14060
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit mil illumination with diagnostic trouble codes p0171/p0174. **mr
Bulletin:
14182
Component:
133000 visibility:power window devices and controls
Summary:
Some may exhibit door glass that is slow to travel upward. *tt
Bulletin:
14211
Component:
015000 steering:hydraulic power assist system
Summary:
Exhibiting a power steering grunt noise or shudder on slow turns. *tt
Bulletin:
14213
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with vehicles exhibiting a slight spark knock on heavy acceleration with 87 octane fuel. *tt
Bulletin:
14222
Component:
161000 structure:frame and members
Summary:
Concerns with subframe clunk on acceleration / deceleration from front of vehicle. *tt
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6200
Component:
162300 structure:body:door
Summary:
Exhibiting concerns of a squeak / creak at the left side sliding door. *tt
Bulletin:
6250
Component:
980000 unknown or other
Summary:
Information regarding transmission control indicator lamp (tcil) flashing and diagnostic trouble code (dtc) p0715 or p0717. *tt
Bulletin:
6252
Component:
353600 equipment:air conditioner
Summary:
Addressing concerns with a grind / grunt noise from a/c compressor durign initial engine start-up. *tt
Bulletin:
12768
Component:
353600 equipment:air conditioner
Summary:
Experiencing a grunt / grind noise for a/c compressor during 1st start. *tt
Bulletin:
6708
Component:
160000 structure
Summary:
This online automotive service information addresses paint concerns identified by customers or during pdi. *tt
Bulletin:
6726
Component:
180000 vehicle speed control
Summary:
Information on diagnosing an inoperative speed control that will not engage at times or at all times. *tt
Bulletin:
6319
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a compass that will display an inaccurate direction. *tt
Bulletin:
99149
Component:
110000 electrical system
Summary:
Service tip information regarding module configuration. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12706
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit a squeak / creak / rattle at the left (driver) side sliding door at the b pillar. *tt
Bulletin:
12728
Component:
353600 equipment:air conditioner
Summary:
Concerns with air conditioner grunt / grind noise on 1st start. *tt
Bulletin:
12731
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a transmission control indicator lamp (tcil) flashing and diagnostic trouble code (dtc) p0715 or p0717. *tt
Bulletin:
12516
Component:
120000 exterior lighting
Summary:
Information used when diagnosing a lamp outage indication. *tt
Bulletin:
12522
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
The owners guide does not contain a specific clock set procedure for vehicles equipped with the base radio option (am / fm stereo - no cassette or cd). *tt
Bulletin:
12533
Component:
101000 power train:clutch assembly
Summary:
Concerns with the reverse clutch lip seals becoming ripped / torn during reverse engagement resulting in no reverse or intermittent no reverse engagement during extreme cold temperatures. *tt
Bulletin:
12536
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a fuel gauge indicator that remains in the same position or registers below e after filling the tank. *tt
Bulletin:
12584
Component:
090000 fuel system, other
Summary:
Some vehicles may exhibit a fuel gauge indicator that remains in the same position or registers below e after filling the tank. *tt
Bulletin:
13063
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing poor or no radio reception at pre-delivery inspection. *tt
Bulletin:
13082
Component:
980000 unknown or other
Summary:
Subject regarding oil change reset procedure. *tt
Bulletin:
13083
Component:
980000 unknown or other
Summary:
Experiening a snap / pop noise fromt he lower center instrument panel lower center bin area. *tt
Bulletin:
13151
Component:
106000 power train:axle assembly
Summary:
Subject regarding a redesigned park system in ax4s and ax4n transaxle. *tt
Bulletin:
12817
Component:
353000 equipment:electrical
Summary:
Some customers may inquire about the average fuel economy feature operating strategy in vehicles equipped with the message center display option. *tt
Bulletin:
7196
Component:
102000 power train:manual transmission
Summary:
Effective october 15, 1999, the ax4s and ax4n transmission assembly for the certain vehicles are available as a ford quality renewal (fqr) assembly. *tt
Bulletin:
13294
Component:
162500 structure:body:tailgate
Summary:
Some vehicles may exhibit a rattle noise from the liftgate area. *tt
Bulletin:
13375
Component:
180000 vehicle speed control
Summary:
Subject regarding vibration / buzz at light throttle load. *tt
Bulletin:
13396
Component:
204000 wheels:cap/cover/hub
Summary:
Some vehicles equipped with starburst type wheel caps may exhibit wheel caps that rattle or appear loose. *tt
Bulletin:
13406
Component:
110000 electrical system
Summary:
Some vehicles may exhibit headlamps that turn on and a blower motor that will operate with the ignition switch in the off position. *tt
Bulletin:
13408
Component:
046200 service brakes, air:antilock:interconnecting assembly(wiring)
Summary:
Subject regarding trailer tow electric brake connector. *tt
Bulletin:
13518
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 3.8l engine may exhibit a hum / moan from the underhood area with the engine running. *tt
Bulletin:
12986
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent loss of sound / cut-out of the rear speaker(s) during turns or driving over bumps. *tt
Bulletin:
4607
Component:
162000 structure:body
Summary:
Subject regarding paint quality issues. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
12800
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a high pitched squeal / whistle noise from the engine area. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5209
Component:
330000 interior lighting
Summary:
Interior / courtesy lamps on at all times. this may be caused by a wiring concern. *tt
Bulletin:
5232
Component:
162300 structure:body:door
Summary:
Information on vehicles equipped with the autolock. *tt
Bulletin:
5245
Component:
350000 equipment
Summary:
Information used when using the new generation star tester (ngs) to diagnose electrical concerns on all body styles and engine sizes. *tt
Bulletin:
5246
Component:
133000 visibility:power window devices and controls
Summary:
Information on customer preference features such as automatic locks, smart locks, illuminated entry, and horn chirp. *tt
Bulletin:
5273
Component:
131000 visibility:windshield
Summary:
Some vehicles built before 11/24/98 may exhibit a slight pucker at the top rear corner of the door glass flock run. *tt
Bulletin:
5354
Component:
350000 equipment
Summary:
For some cargo vans the throw-in panel kit cannot be properly installed when using current published instruction sheets included with the kit. *tt
Bulletin:
5355
Component:
980000 unknown or other
Summary:
Some vehicles equipped with dual power sliding doors may exhibit a concern of difficult to operate remote entry transmitter (key fob) buttons. *tt
Bulletin:
5372
Component:
020000 suspension
Summary:
Experiencing a vibration at 60 - 70 mph, felt in the steering wheel or floor. *tt
Bulletin:
12200
Component:
110000 electrical system
Summary:
This bulletin states that when using the new generation star tester (ngs) to diagnose electrical concerns on all body styles and engine sizes, the front electronics module (fem) is identified as a generic electronics module (gem).
Bulletin:
12201
Component:
133000 visibility:power window devices and controls
Summary:
Information on customer preference features such as automatic locks, smart locks, illuminated entry, and horn chirp. *tt
Bulletin:
12203
Component:
131000 visibility:windshield
Summary:
Some vehicles built before 11/24/98 may exhibit a slight pucker at the top rear corner of the door glass flock run. *tt
Bulletin:
12228
Component:
110000 electrical system
Summary:
For all vehicles with front-end electronic module (fem) and rear-end electronic modules (rem) concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *t
Bulletin:
12230
Component:
036000 service brakes, hydraulic:antilock
Summary:
All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12270
Component:
980000 unknown or other
Summary:
Information on the throw-in panel kit installation using current published instruction sheets included with the kit. *tt
Bulletin:
12271
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles equipped with dual power sliding doors may exhibit a concern of difficult to operate remote entry transmitter (key fob) buttons. *tt
Bulletin:
12288
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration at 60 - 70 mph, felt in the steering wheel or floor. *tt
Bulletin:
00B51
Component:
106000 power train:axle assembly
Summary:
Owner notification program regarding all vehicles built with ax4s transmission - rear lube tube and bracket replacement. *tt
Bulletin:
00255
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 3.0l 2-valve engine may exhibit a spark knock condition on heavy acceleration with 87 octane gasoline. *tt
Bulletin:
14522
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may continue to exhibit a power steering grunt noise after replacing the yf2z-3a719-aa power steering hose per special service message 1421, and after performing bleed procedures. *tt
Bulletin:
14580
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing o/d off lamp and diagnostic trouble code p0720, p0722 after installing a remanufactured transaxle. *jb
Bulletin:
14603
Component:
014000 steering:rack and pinion
Summary:
Information on vehicles exhibiting power steering and pinion leak. *jb
Bulletin:
00218
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on spark knock on acceleration on vehicles equipped with 3.8l engine. *jb
Bulletin:
002110
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration condition at 72 km/h (45 mph) and above. *jb
Bulletin:
00223
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 3.0l engine may exhibit a spark knock condition on heavy acceleration with 87 octane gasoline. *jb
Bulletin:
00B51
Component:
106000 power train:axle assembly
Summary:
Subject pertaining to rear lube tube and bracket replacement. *jb
Bulletin:
14353
Component:
980000 unknown or other
Summary:
Information on malfunction indicator lamp illuminated and / or diagnostic trouble code's po171 & po174. *jb
Bulletin:
14391
Component:
020000 suspension
Summary:
Exhibiting vibration above 45 mph - service kit available. *jb
Bulletin:
14656
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Some vehicles may exhibit rear drum brakes that drag or will not release properly when operated in wet conditions and / or below freezing temperatures. *tt
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14797
Component:
131000 visibility:windshield
Summary:
Some vehicles may exhibit fogging of the front and side windows. *tt
Bulletin:
14867
Component:
100000 power train
Summary:
Subject regarding speedometer calibration tolerance specifications. *tt
Bulletin:
14855
Component:
220000 seats
Summary:
Some vehicles equipped with the highback front seats (without side air bags) may exhibit a twisted seat back frame. *tt
Bulletin:
0145
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles equpped with a 3.8l engine may exhibit a power steering grunt noise while turning. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
0156
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
Some vehicles may exhibit a power steering fluid leak from the end seals of the steering rack and pinion. *tt
Bulletin:
14773
Component:
103700 power train:automatic transmission:torque converter
Summary:
Information on indexing orange dot on torque converter to flexplate. *tt
Bulletin:
14918
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
Bulletin:
13812
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Some fleet customers may want to disable the child lock feature on the sliding doors and prevent it from being accidently re-activated. *tt
Bulletin:
13858
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may exhibit a power steering grunt noise or shudder on slow turns. engineering is investigating. *tt
Bulletin:
14182
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may exhibit door glass that is slow to travel upward. this may be caused by the glass not positioned level in the guide channel. *tt
Bulletin:
14211
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may exhibit a power steering grunt noise or shudder on slow turns. a new power steering line has been released that will minimize the condition. *tt
Bulletin:
14229
Component:
110000 electrical system
Summary:
Some vehicles may exhibit battery voltage low, will not reach full charge, alternator charges at a reduced voltage. *tt
Bulletin:
14330
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may have slight spark knock on heavy accel with 87 octaine fuel. hot weather and lower octane fuel may exaggerate condition. *tt
Bulletin:
14391
Component:
020000 suspension
Summary:
Experiencing a vibration condition at 45 mph and above, noticed after replacing, rotating or servicing wheel and tire assemblies. *tt
Bulletin:
13922
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 3.8l engine may exhibit a slight spark knock on heavy acceleration with 87 octane fuel. *tt
Bulletin:
15039
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a continuous rattling noise when the a/c compressor is engaged. *tt
Bulletin:
15066
Component:
022000 suspension:rear
Summary:
Some vehicles may exhibit a rough ride and / or a rear suspension noise. *tt
Bulletin:
01124
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, engine oil may continue to leak from the engine oil pan gasket area after an engine oil pan gasket repair has been performed. *tt
Bulletin:
14967
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles may exhibit intermittent uncommanded activation of the perimemter anti-theft system. *tt
Bulletin:
15021
Component:
330000 interior lighting
Summary:
Some vehicles may exhibit an inoperative / flickering dome light, light staying on all the time, coming on by itself, or inoperative with any door ajar inputs to the dome light. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15194
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Some vehicles may exhibit a discharged battery after extended parking, over 30 days, if so, pull power drain full fuse number 6. *yd
Bulletin:
011701
Component:
980000 unknown or other
Summary:
Information regarding replacement application chart. *et
Bulletin:
01171
Component:
106000 power train:axle assembly
Summary:
Transaxle - ax4s - replacement application chart - windstar vehicles only. *nlm
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15213
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an engine noise that sounds like a connecting-rod knock or lifter noise. *tt
Bulletin:
15214
Component:
020000 suspension
Summary:
Some vehicles may exhibit a condition of the rough ride or rear suspension noise. *tt
Bulletin:
00T07
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information regarding powertrain control module reprograming. *yh
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15522
Component:
070000 fuel system, gasoline
Summary:
Subject regarding driveability diagnostic trouble code lean codes p0171/p0174. *yd
Bulletin:
15288
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles may exhibit transmission fluid leaking at the quick connect for the transmission cooler lines. *tt
Bulletin:
15289
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a malfunction indicator lamp on, no start or erratic transaxle shift condition. *tt
Bulletin:
15303
Component:
137200 visibility:rear window wiper/washer:motor
Summary:
Some vehicles may exhibit an inoperative rear wiper motor condition. *tt
Bulletin:
15350
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Exhibiting instrument panel beeping sound, trac-control off lamp on, and code b2477 stored in the instrument cluster module. *tt
Bulletin:
15370
Component:
100000 power train
Summary:
Some vehicles may exhibit a groan/buzz/vibration when the gear selector is in park. *tt
Bulletin:
15373
Component:
980000 unknown or other
Summary:
Some vehicles may run rough at cruise or momentarily after stopping, a check engine light,and p030x codes. *tt
Bulletin:
15392
Component:
100000 power train
Summary:
Some vehicles may exhibit a park pullout clunk noise when shifting from park to another gear position. *tt
Bulletin:
15440
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles may exhibit intermittent uncommanded activation of the perimeter anti-theft system. *tt
Bulletin:
15385
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Some vehicles may exhibit a front brake lining click or rattle noise while driving over bumps or rough roads. *tt
Bulletin:
15438
Component:
330000 interior lighting
Summary:
Some vehicles may exhibit inoperative/flickering dome lamp, lamp staying on all the time, coming on by itself, or inoperative with any door ajar inputs to the dome lamp. *tt
Bulletin:
15439
Component:
110000 electrical system
Summary:
Concerns with the headlamps that turn on and a blower motor that will operate with the ignition switch in the off position. *tt
Bulletin:
15451
Component:
137200 visibility:rear window wiper/washer:motor
Summary:
Some vehicles may exhibit an inoperative rear wiper motor condition. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15460
Component:
100000 power train
Summary:
Concerns with inaccurate speedometer reading. *tt
Bulletin:
15621
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles with the rear seat entertainment system may exhibit an inoperative condition. *tt
Bulletin:
02152
Component:
020000 suspension
Summary:
Some vehicles may exhibit a popping / grinding noise from the front of the vehicle when going over bumps or making turns. *tt
Bulletin:
02132
Component:
020000 suspension
Summary:
Grunt / popping noise coming from the front suspension at speeds below 20 mph when turning. *tt
Bulletin:
02139
Component:
111000 electrical system:battery
Summary:
Battery drain service tips. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
16097
Component:
220000 seats
Summary:
Some vehicles may exhibit a front seat back frame(s) bending. *tt
Bulletin:
15682
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Exhibiting intermittent anti-skid brake system and / or red brake lamp on at times while driving. *tt
Bulletin:
15710
Component:
110000 electrical system
Summary:
Information on vehicles with programmable modules. *tt
Bulletin:
15719
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Some vehicles may exhibit rear drum brakes that drag or will not release properly when operated in wet conditions and / or below freezing temperatures. *tt
Bulletin:
15740
Component:
116200 electrical system:ignition:module
Summary:
Some vehicles equipped with a 3.8l engine may exhibit lean diagnostic trouble code p0171 / p0174. *tt
Bulletin:
15822
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Some vehicles may exhibit a squeal noise from the front brakes when stopping. *tt
Bulletin:
15855
Component:
020000 suspension
Summary:
Some vehicles may exhibit a condition of popping or grinding noise originating from the front end of the vehicle. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
0347
Component:
110000 electrical system
Summary:
Check engine light on and lean diagnostic trouble code (dtc's) p0171/p0174 stored. *tt *jb
Bulletin:
16678
Component:
100000 power train
Summary:
Ax4s transaxle may exhibit no reverse engagement condition. *tt *jb
Bulletin:
16720
Component:
162300 structure:body:door
Summary:
Power sliding door conditions. *tt *jb
Bulletin:
0338
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light on and lean diagnostic trouble codes (dtc's) p0171/p0174 (system too lean bank 1 or 2) stored in memory. *tt
Bulletin:
16611
Component:
221600 seats:front assembly:power adjust
Summary:
Power seat that moves in a arc rather than straight forward or back. *tt
Bulletin:
16920
Component:
980000 unknown or other
Summary:
Lean diagnostic trouble codes p0171/p0174 stored. new service isolator bolt assembly released for service. *tt
Bulletin:
03123
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter clutch not engaging when commanded and/or diagnostic trouble codes p0741 or p1744 stored in memory. models from 1996 to 2003. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03161
Component:
061000 engine and engine cooling:engine
Summary:
Check engine light on and lean diagnostic trouble codes (dtc's) p0171/p0174 (system too lean bank 1 or 2) stored in memory. *tt
Bulletin:
17016
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
Front caliper seepage in extreme cold temperatures. *tt
Bulletin:
17056
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp (mil) on / no start / erratic shifting. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16987
Component:
030000 service brakes, hydraulic
Summary:
Slight amount of fluid residue on the outside of the rear wheel cylinder dust boot on vehicles with rear drum brakes. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
17277
Component:
110000 electrical system
Summary:
Beeping sound from the instrument panel when driving at/over 75 mph, traction control off indicator illuminate when vehicle is not equipped with traction control, and/or diagnostic trouble code b2477 (module configuration failure) stored in
Bulletin:
17525
Component:
160000 structure
Summary:
Windshield cowl panel grille (leaf screen) breaking at the grille opening. *tt
Bulletin:
02184
Component:
162300 structure:body:door
Summary:
Power sliding door operation and diagnostic service tips. *tt
Bulletin:
17585
Component:
110000 electrical system
Summary:
Trailer tow electric brake switch/module connector may be difficult to locate in the vehicle and for certain 1999-2001 vehicles, the location is not clearly identified in the wiring diagram manual. *tt
Bulletin:
030104
Component:
162900 structure:body:roof and pillars
Summary:
Crease in the headliner above the left a-pillar. *tt
Bulletin:
17358
Component:
100000 power train
Summary:
Groan/buzz/vibration when the gear selector is in park with the vehicle parked on an incline. *tt this bulletin updates previous bulletin 17358, dated 11/01/2003 to include 2005 models. *tt
Bulletin:
0471
Component:
110000 electrical system
Summary:
Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt
Bulletin:
17744
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering noise. *tt
Bulletin:
03242
Component:
114000 electrical system:wiring
Summary:
Trailer tow service kit - service tip. *tt
Bulletin:
02221
Component:
061000 engine and engine cooling:engine
Summary:
Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
Bulletin:
16382
Component:
021100 suspension:front:stabilizer bar
Summary:
Clunk/squeak from the front stabilizer bar area (qsf). *tt
Bulletin:
16423
Component:
162000 structure:body
Summary:
Servicing body side molding or cladding / contact request. *mj
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
04192
Component:
061000 engine and engine cooling:engine
Summary:
Spark knock on acceleration - vehicles equipped with 3.8l engine only. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
2214
Component:
162000 structure:body
Summary:
Roof ditch material cracking. this includes 1997-2003 f-150 and 2002 blackwood models. *eh service tip. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
04262
Component:
342000 communications:back up alarm
Summary:
False parking aid warnings. *tt update. *tt
Bulletin:
CSP-08B01
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe
Bulletin:
TSB-14-0145
Component:
021530 suspension:front:control arm:lower arm
Summary:
Ford: a safety recall has been issued on minivans where lower control arm (lca) of front subframe attaching rear flange or rear body mount can separate due to corrosion. model 1999-2003 windstar. *pe
Bulletin:
TSB-14-0146
Component:
022510 suspension:rear:axle:spindle
Summary:
Ford: on some minivans, rear axle will fracture, in high corrosion area, after operating for an extended time period, and vehicle handling ability will be affected. model 1998-2003 windstar. *pe
Bulletin:
TSB-14-0167
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Ford: safety recall concerning rear axle fracturing if vehicle is operated in high corrosion areas for and extended period. model 1998-03 windstar. *pe
Bulletin:
TSB-14-0168
Component:
021530 suspension:front:control arm:lower arm
Summary:
Ford: safety recall on front subframe lower control arm (lca) rear attaching flange or rear body mount that can separate from subframe if vehicle is operated, for extended period, in high corrosion areas. model 1999-03 windstar.
Bulletin:
CSP-15-N-02
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary:
Summary to be provided on a future date.

Home | Privacy