1999 FORD TAURUS Recalls (7)

Campaign:
98V198000 on 08/27/1998
Component:
Seat belts:front:anchorage
Manufactured:
07/30/1998 - 08/06/1998
Affected:
7,000
Defect:
Vehicle description: passenger vehicles equipped with manual seat tracks. the front seat belt buckle attaching stud may have been improperly heat treated. this heat treatment may have resulted in cracks developing in the stud.
Consequence:
If the stud is cracked, in the event of a vehicle crash, the occupant may not be properly restrained, increasing the risk of personal injury.
Correction:
Dealers will replace the seat belt buckle mounting bracket and stud assembly.
Notes:
Owner notification began september 4, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
98V204000 on 09/08/1998
Component:
Vehicle speed control
Manufactured:
08/02/1998 - 08/09/1998
Affected:
6,000
Defect:
Vehicle description: passenger vehicles. a dash insulator retainer clip was not fully assembled to the accelerator cable dash fitting. the clip can disengage from the accelerator cable and fall into the accelerator pedal arm pivot area.
Consequence:
If this condition occurs, the engine may not fully return to idle. also, the insulator may not stay in the intended location and could interfere with the accelerator cable.
Correction:
Dealers will inspect these vehicles to ensure proper installation of the accelerator cable clip, and re-install if needed.
Notes:
Owner notification is expected to begin september 21, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
98V288000 on 11/09/1998
Component:
Power train:automatic transmission:cooling unit and lines
Manufactured:
08/02/1998 - 09/16/1998
Affected:
1,800
Defect:
Vehicle description: passenger vehicles equpped with the "california" emissions package. an incorrect transmission oil cooler line was installed. the line contacts the anti-lock braking system module support bracket and over time, can wear and develop a leak.
Consequence:
Transmission fluid leakage onto the exhaust manifold or catalytic converter can result in a fire.
Correction:
Dealers will install the appropriate transmission oil cooler line.
Notes:
Owner notification began november 25, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V250000 on 09/27/1999
Component:
Seat belts:front:anchorage
Manufactured:
07/25/1999 - 08/12/1999
Affected:
25,306
Defect:
Vehicle description: passenger vehicles. the seat belt retractor may have a pin shaft in the switchable elr/alr mechanism that is incorrectly formed. in some circumstances, the switching mechanism could become nonfunctional, preventing the seat belt webbing from being extracted from the retractor. it is also possible that malfunction of the mechanism could prevent the belt from being switched into the alr mode. the elr mechanism is not affected by this condition.
Consequence:
If the mechanism malfunctions and does not allow the webbing to be extracted, the lap and shoulder belt could not be worn by a vehicle occupant. in the event that the mechanism does not allow the alr mode to be engaged, the operator may be unable to properly install a child seat in that seating position.
Correction:
Dealers will inspect the lap and shoulder belt assemblies. assemblies with julian date codes of 200 through 223 are suspect and will be replaced.
Notes:
Ford recallno. 99s26. owner notification began october 11, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V332000 on 07/14/2004
Component:
Suspension:front:springs:coil springs
Manufactured:
03/27/1998 - 08/12/2001
Affected:
899,060
Defect:
On certain passenger vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia, the front coil springs could fracture due to corrosion associated with salt used on the roadways during the winter. a fractured spring could move past the spring seat and contact a front tire.
Consequence:
If this occurs, the tire may rupture resulting in a rapid air loss, which could result in a crash.
Correction:
Dealers will install protective spring shields. in addition, ford is extending the warranty coverage of the front coil springs in all other states, for fracture only, up to 10 years of service or 150,000 miles, whichever occurs first. if the vehicle has already accumulated more than 150,000 miles, this coverage will last until july 31, 2005. if either front coil spring fractures, dealers will replace both front springs at no charge to the owner. an interim notice was sent to owners on august 2, 2004. parts are now available for the 2000-2001 my vehicles and owners were sent a letter on january 10, 2005, advising them to bring in their vehicles for repair parts are expected to be available for the 1999 my vehicles by the end of february 2005 and owners of these vehicles will be notified then. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 04s17.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1999 FORD TAURUS TSBs (176)

Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
984647
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Some vehicles will be delivered with covers over the front brake rotors. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98241
Component:
012200 steering:column locking:anti-theft device
Summary:
Diagnostic service tips on passive anti theft system ( pats ). *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
5706
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Conditions on slow fuel fill or fuel gauge comes off full too quickly. *tt
Bulletin:
5806
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit concerns of no reverse or intermittent reverse engagement. *tt
Bulletin:
5857
Component:
061000 engine and engine cooling:engine
Summary:
Vehicle exhibiting no reverse or intermittent no reverse engagement during extreme cold temperatures. *tt
Bulletin:
5897
Component:
017500 steering:linkages:tie rod assembly
Summary:
Experiencing a squeaking and / or popping noise from the front outer tire rods. *tt
Bulletin:
5898
Component:
133000 visibility:power window devices and controls
Summary:
Subject regarding accessory delay - owner guide information. *tt
Bulletin:
12504
Component:
102000 power train:manual transmission
Summary:
Vehicles built before march 1999 may exhibit concern of no reverse or intermittent reverse engagement. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99125
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information pertaining to lack of engine braking with diagnostic trouble code (dtc) p1138 present during key on engine running (koer). *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6318
Component:
180000 vehicle speed control
Summary:
Information regarding inoperable speed control. *tt
Bulletin:
6469
Component:
136000 visibility:windshield wiper/washer
Summary:
Conditions with windshield wiper operating without command. *tt
Bulletin:
996039
Component:
131000 visibility:windshield
Summary:
Experiencing windnoise / water leak from windshield. *tt
Bulletin:
996040
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Subject regarding electronic crash sensor (ecs) module location. *tt
Bulletin:
996123
Component:
103300 power train:automatic transmission:gear position indication (prndl)
Summary:
Concerns with buzz or vibration with the gear selector in park. *tt
Bulletin:
996170
Component:
116100 electrical system:ignition:switch
Summary:
Conditions with stiff ignition switch lock cylinder. *tt
Bulletin:
9912779
Component:
180000 vehicle speed control
Summary:
Subject pertaining to an inoperable speed control. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
99151
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Concerns with slow fuel fill at or above 3/4 of a tank / fuel fill nozzle clicks off, slow fuel fill below 3/4 of a tank / continuous fill nozzel clicks off, fuel gauge does not update after fuel fill, and the low fuel light illuminates wit
Bulletin:
996735
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with the ax4s transaxle may exhibit a harsh 3-2 downshift when coasting around a corner and then stepping into the throttle to accelerate away from the corner. *tt
Bulletin:
996783
Component:
220000 seats
Summary:
Concerns with the seats splitting at the seams; leather or fabric blemishes and / or loose or poor fit seating trim. *tt
Bulletin:
996874
Component:
061000 engine and engine cooling:engine
Summary:
Subject pertaining to the sbds relative cam timing test which has been temporarily removed from use on some vehicles due to noise concerns. *tt
Bulletin:
996882
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on diagnosing a no crank starting condition on vehicles equipped with the passive anti-theft system (pats). *tt
Bulletin:
996883
Component:
116000 electrical system:ignition
Summary:
Information on arranging a dealer visit for vehicles exhibiting diagnostic trouble codes (dtc) p0351 / p0356 (ignition coil a-f primary / secondary circuit). *tt
Bulletin:
9912683
Component:
162000 structure:body
Summary:
This bulletin mentions that vehicles built on or after march 26, 1999 will no longer be equipped with rock guard paint coating on the rocker panels. *tt
Bulletin:
9912692
Component:
116100 electrical system:ignition:switch
Summary:
Engineering is investigating conditions of a hard to turn ignition key / stiff ignition switch lock cylinder. *tt
Bulletin:
9912693
Component:
330000 interior lighting
Summary:
Engineering is investigating concerns with wagons exhibiting a left rear door ajar warning indicator lamp "on". *tt
Bulletin:
9913140
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with ax4s transaxle may exhibit any or all of the following symptoms: dtc p0734, flashing tcil, "no 3-4 shift" or an overdrive band wear concern. *tt
Bulletin:
99E06
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Emissions recall for vehicles with a powertrain control module (pcm) previously programmed with a california service calibration - pcm recalibration. *tt
Bulletin:
99202
Component:
106000 power train:axle assembly
Summary:
This bulletin mentions that some vehicles with an ax4s or ax4n transaxles have a new redesigned park system in the transaxle. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99224
Component:
136000 visibility:windshield wiper/washer
Summary:
Subject regarding front wipers operating while switch is in off position. *tt
Bulletin:
99183
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information on revised oil pan gasket replacement procedure. *tt
Bulletin:
99184
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with ax4s transaxle, may exhibit a harsh 2-3 downshift may occur when coasting around a corner and then accelerating. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99243
Component:
126200 exterior lighting:turn signal:switch
Summary:
On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
Bulletin:
6908
Component:
106000 power train:axle assembly
Summary:
Some vehicles with ax4s transaxle may exhibit a diagnostic trouble code p0734, flashing tcil, no3-4 shift or an overdrive band wear concern. *tt
Bulletin:
6918
Component:
106000 power train:axle assembly
Summary:
Information on the redesigned park system in vehicles with ax4s transaxles. *tt
Bulletin:
6997
Component:
061000 engine and engine cooling:engine
Summary:
Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
Bulletin:
13180
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
Bulletin:
13250
Component:
180000 vehicle speed control
Summary:
Information regarding slight vibration upon acceleration. *mjs
Bulletin:
13253
Component:
136000 visibility:windshield wiper/washer
Summary:
(continued from 13251 and 13252) uncommanded front wiper function. *mjs
Bulletin:
7249
Component:
353600 equipment:air conditioner
Summary:
Information on using peanut style a/c fittings. *tt
Bulletin:
7306
Component:
162000 structure:body
Summary:
Service tip for vehicles built 11/1/1997 - 2/15/1999 with single illuminated vanity mirror sun visors only, may exhibit a broken sunvisor stowage bracket. *tt
Bulletin:
98159
Component:
106000 power train:axle assembly
Summary:
Transaxle , prior to repair, orange tag special service instructions was not installed. ak
Bulletin:
13347
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Subject regarding inoperative blower motor. *tt
Bulletin:
98164
Component:
162000 structure:body
Summary:
A transeal coating is on the front and rear bumpers. this coating must be removed before delivery to the customer. yd
Bulletin:
6576
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information regarding engine oil leak diagnosis. *tt
Bulletin:
6579
Component:
980000 unknown or other
Summary:
Information diagnosing vehicles that may exhibit a malfunction indicator lamp on with diagnostic trouble code p1309 stored in memory. *tt
Bulletin:
6612
Component:
020000 suspension
Summary:
Some vehicles may exhibit front suspension noise due to front strut, front sway bar links or symptoms such as premature rear brake pad wear due to seized rear brake calipers or slides. *tt
Bulletin:
6646
Component:
180000 vehicle speed control
Summary:
Some vehicles with 3.0l 4-valve engines built between 12/17/97 and 6/30/99 may exhibit a hard start / long crank or a rough idle after a cold start. *tt
Bulletin:
13019
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with 3.0l 2-valve engines, built prior to 4/12/1999 may exhibit spark knock. *tt
Bulletin:
13472
Component:
141100 air bags:frontal:sensor/control module
Summary:
For vehicles that require configuration of the electronic crash sensor moudle to settings other than the preset settings, the configuration instructions were omitted from the shop manual. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
7855
Component:
980000 unknown or other
Summary:
Vehicles may exhibit intermittent instrument control panel (icp) illumination.
Bulletin:
8199
Component:
021100 suspension:front:stabilizer bar
Summary:
Some vehicles may exhibit a rattling or clunking noise from the front end (front stabilizer link) under normal driving conditions.
Bulletin:
7927
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Revised engine oil indicator (dipstick) graphics. the full level is between the min an max. if the oil reading is between the markings the level is acceptable, do not add oil. if the oil level is below the min mark add enough lil to rais
Bulletin:
8242
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some vehicles built before november, 1999 may exhibit transmission fluid at the bell housing area. *tt
Bulletin:
8310
Component:
106000 power train:axle assembly
Summary:
Ax4s transaxle - rear lube and differential lube insulator kit. *tt
Bulletin:
8316
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with compact disc changer may exhibit a 6 disc cd changer that is not ejecting the magazine or is not responding to command from the radio.
Bulletin:
13770
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles with 3.0l 2-valve vulcan engine have revised engine oil indicator (dipstick) graphics. *mjs
Bulletin:
13802
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent loss of instrument control panel (icp) illumination. *mjs
Bulletin:
13961
Component:
106000 power train:axle assembly
Summary:
Information regarding the ax4s transaxle - rear lube and differential lube tube insulator kit. *tt
Bulletin:
0061
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Issue of a perceived lack of engine braking and malfunction indicator lamp (mil) illuminated with a false diagnostic trouble code (dtc) p1138 stored in memory may occur on some vehicles . *mjs
Bulletin:
13924
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some vehicles built before november 1999 may exhibit transmission fluid at the bell housing area. *tt
Bulletin:
12066
Component:
180000 vehicle speed control
Summary:
Some vehicles were calibrated with increased air flow at closed throttle to prevent tip-in bumps, a result may be reduced deceleration feel and less engine rpm reduction at closed throttle with the vehicle moving. *mjs
Bulletin:
12079
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles may exhibit a buzz or rattle condition on a cold start or during a low rpm stead speed. *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
12163
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit a slight vibration during acceleration only. *mjs
Bulletin:
985083
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Some vehicles (3.0l 4 valve only) may exhibit a catalytic converter buzz or rattle condition on a cold start or during a low rpm steady speed. *tt
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
8016
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit an intermittent loss of integrated control panel (icp) illumination. **mr**
Bulletin:
8242
Component:
101200 power train:clutch assembly:bell housing
Summary:
Some vehicles may exhibit transmission fluid at the bell housing area. **mr
Bulletin:
8310
Component:
106000 power train:axle assembly
Summary:
Rear lube and differential tube insulator kit. **mr
Bulletin:
8583
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit dtc p1518 and / or p1519, related to intake manifold runner control (imrc). *mr
Bulletin:
14087
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Some vehicles may exhibit diagnostic trouble code p1518 and/or p1519, related to intake manifold runner control (imrc). **mr
Bulletin:
14220
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with an ax4n transaxle may exhibit a shudder during a 3-4 shift. *tt
Bulletin:
6171
Component:
162300 structure:body:door
Summary:
Concerns with left rear door ajar warning indicator on wagons only. *tt
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6228
Component:
980000 unknown or other
Summary:
Information regarding wiring change on the liftgate door ajar indicator. *tt
Bulletin:
6283
Component:
350000 equipment
Summary:
Important information on removing rear tie down brackets during pre-delivery. *tt
Bulletin:
6219
Component:
015100 steering:hydraulic power assist:pump
Summary:
Some vehicles may exhibit steering noise / reservoir fluid swirling / reservoir fluid overflow. *tt
Bulletin:
6730
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject pertaining to vehicles with 3.0l 2-valve engines, built prior to 4/12/99 may exhibit spark knock. *tt
Bulletin:
6158
Component:
162000 structure:body
Summary:
Subject regarding vehicles built on or after march 26, 1999 will no longer be eqquiped with rock guard paint coating on the rocker panels. *tt
Bulletin:
6219
Component:
015100 steering:hydraulic power assist:pump
Summary:
Some 3.0l 4-valve duratec engines only may exhibit steering noise / reservoir fluid swirling / reservoir fluid overflow. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12712
Component:
015100 steering:hydraulic power assist:pump
Summary:
Some 3.0l 4-valve duratec engines may exhibit steering noise / reservoir fluid swirling / reservoir fluid overflow. *tt
Bulletin:
12718
Component:
114000 electrical system:wiring
Summary:
All wagons built on or after 12/19/98 now have the liftgate door ajar wiring connected into the left rear door ajar circuit. *tt
Bulletin:
12784
Component:
350000 equipment
Summary:
Information on removing rear tie down brackets during pdi as required. *tt
Bulletin:
12533
Component:
101000 power train:clutch assembly
Summary:
Concerns with the reverse clutch lip seals becoming ripped / torn during reverse engagement resulting in no reverse or intermittent no reverse engagement during extreme cold temperatures. *tt
Bulletin:
12569
Component:
355200 equipment:other:owners/service/other manual
Summary:
The owners guide for certain vehicles incorrectly states that the accessory delay feature will provide for radio and power window operation for up to 10 minutes after the ignition is turned off or until a front door is opened. *tt
Bulletin:
12570
Component:
017500 steering:linkages:tie rod assembly
Summary:
Some vehicles may exhibit front outer tie rods squeak and / or pop noise over bumps and / or turning. *tt
Bulletin:
13055
Component:
220000 seats
Summary:
Subject regarding front seat trim investigation. *tt
Bulletin:
13101
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding the sbds relative cam timing test. *tt
Bulletin:
13109
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with the passive anti-theft system (pats) may exhibit a no crank starting condition. *tt
Bulletin:
13111
Component:
110000 electrical system
Summary:
Some vehicles may exhibit diagnostic trouble codes p0351 / p0356 (ignition coil a-f primary / secondary circuit). *tt
Bulletin:
13151
Component:
106000 power train:axle assembly
Summary:
Subject regarding a redesigned park system in ax4s and ax4n transaxle. *tt
Bulletin:
12874
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may intermittently exhibit a self activated single wipe of the front windshield wipers. *tt
Bulletin:
7196
Component:
102000 power train:manual transmission
Summary:
Effective october 15, 1999, the ax4s and ax4n transmission assembly for the certain vehicles are available as a ford quality renewal (fqr) assembly. *tt
Bulletin:
13381
Component:
162000 structure:body
Summary:
Subject regarding service tip for sun visor bracket breakage. *tt
Bulletin:
4647
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Important pre-delivery information regarding some vehicles delivered with covers over the front brake rotors. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
11764
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding vehicles which will be delivered with covers over the front brake rotors. *tt
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5304
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Information on front disc brake rotor protectors currently being installed on certain vehicles. *tt
Bulletin:
5367
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit inoperable speed control. *tt
Bulletin:
12284
Component:
100000 power train
Summary:
Some vehicle s may exhbit inoperable spped control. *tt
Bulletin:
00B51
Component:
106000 power train:axle assembly
Summary:
Owner notification program regarding all vehicles built with ax4s transmission - rear lube tube and bracket replacement. *tt
Bulletin:
00263
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit a power window that will not operate downward because it's stuck / bound to the weathership header. *tt
Bulletin:
14584
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding flex fuel vechicle oil and fuel recommendations. *jb
Bulletin:
00203
Component:
980000 unknown or other
Summary:
A separation between layers of the instrument panel.*jb
Bulletin:
00191
Component:
980000 unknown or other
Summary:
Some vehicles may experience a separation between layers of the instrument panel. *jb
Bulletin:
00B51
Component:
106000 power train:axle assembly
Summary:
Subject pertaining to rear lube tube and bracket replacement. *jb
Bulletin:
14355
Component:
061000 engine and engine cooling:engine
Summary:
Information pertaining to duratec oil pan investigation. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14856
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles equpped with 3.0l 2v vulcan or 4v duratec engine may exhibit an exhaust rust-thru, weld fatigue condition between the two toeboard catalysts where a tie-in bracket is welded to the formed inlet pipe of the rear bank toeboard c
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
13802
Component:
330000 interior lighting
Summary:
Some vehicles may exhibit an intermittent loss of integrated control panel (icp) illumination. audio and climate controls continue to operate during the icp's loss of illumination condition. this may be caused by a faulty internal ribbo
Bulletin:
14220
Component:
106000 power train:axle assembly
Summary:
Information used to service ax4n transaxle equipped vehicles exhibiting shudder during 3-4 shift. *tt
Bulletin:
14355
Component:
061000 engine and engine cooling:engine
Summary:
Exhibiting an oil leak from the engine oil pan. *tt
Bulletin:
15059
Component:
106000 power train:axle assembly
Summary:
Concerns with vehicles equipped with a ax4n / 4f50n transaxle exhibiting a shudder during a 3-4 shift. *tt
Bulletin:
01116
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit cooling system conditions such contaminated / corroded coolant; leaking / discolored coolant overflow bottles; vibration from engine; leaking heater core; coolant overflow; high temperature gauge readings, etc.
Bulletin:
01124
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, engine oil may continue to leak from the engine oil pan gasket area after an engine oil pan gasket repair has been performed. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15370
Component:
100000 power train
Summary:
Some vehicles may exhibit a groan/buzz/vibration when the gear selector is in park. *tt
Bulletin:
15392
Component:
100000 power train
Summary:
Some vehicles may exhibit a park pullout clunk noise when shifting from park to another gear position. *tt
Bulletin:
15390
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some vehicles may exhibit a check engine light and/or egr diagnostic trouble codes 332, p0401, p1407 (lackof egr flow). *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
02153
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 3.0l 4v duratec engine may exhibit a malfunction indicator lamp illuminated with a diagnostic trouble code p1518, intake manifold runner control. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
02107
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt
Bulletin:
15820
Component:
100000 power train
Summary:
Some vehicles equipped with an ax4n/4f50n transaxle may exhibit a shudder during a 3-4 shift. *tt
Bulletin:
15879
Component:
061000 engine and engine cooling:engine
Summary:
Some sho vehicles may exhibit a ticking noise originating from the valve cover area. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
16678
Component:
100000 power train
Summary:
Ax4s transaxle may exhibit no reverse engagement condition. *tt *jb
Bulletin:
03123
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter clutch not engaging when commanded and/or diagnostic trouble codes p0741 or p1744 stored in memory. models from 1996 to 2003. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03141
Component:
061000 engine and engine cooling:engine
Summary:
In vehicle loctite service procedure for camshaft tube and gear. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
17358
Component:
100000 power train
Summary:
Groan/buzz/vibration when the gear selector is in park with the vehicle parked on an incline. *tt this bulletin updates previous bulletin 17358, dated 11/01/2003 to include 2005 models. *tt
Bulletin:
02221
Component:
061000 engine and engine cooling:engine
Summary:
Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
Bulletin:
02236
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Erratic operation of the cool/warm function of the temperature control system - repair procedure for stratification (secondary) temperature blend door. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02183
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust system y-pipe crack at the noise vibration harness bracket. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
04M04
Component:
021210 suspension:front:springs:coil springs
Summary:
Front coil spring extended warranty coverage. customer satisfaction program 04m04.
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
16315
Component:
162000 structure:body
Summary:
Headliner grab handles loosen. *tt
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
18614
Component:
060000 engine and engine cooling
Summary:
Surge, idle roll, rough idle only when the engine cooling fans are operating. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
CSP-08B01
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe
Bulletin:
TSB-14-0149
Component:
021210 suspension:front:springs:coil springs
Summary:
Mercury/ford: front coil springs can fracture, after operating, for an extended period of time, in high corrosion areas, move move past spring seat and contact rupture front tire, resulting rapid air loss. model 1999-2001 taurus, sable.
Bulletin:
TSB-14-0165
Component:
021210 suspension:front:springs:coil springs
Summary:
Mercury/ford: safety recall regarding front coil springs can fracture on vehicles operating for extended periods in high corrosion areas. model 1999-01 taurus, sable. *pe

Home | Privacy