1999 FORD F-250 Recalls (19)

Campaign:
98V116000 on 06/01/1998
Component:
Steering:gear box (other than rack and pinion)
Manufactured:
09/02/1997 - 05/18/1998
Affected:
90,000
Defect:
Vehicle description: medium duty trucks and chassis-cabs. one or more of the four rivets on the lower steering shaft flex coupling may not have been crimped during the sub-assembly process.
Consequence:
If a rivet is not crimped, the flex joint can rotate on the shaft and there would be a reduction in or loss of steering control.
Correction:
Dealers will inspect the lower steering shaft rivets and replace any shafts with uncrimped rivets.
Notes:
Owner notification began may 26, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
98V192000 on 08/26/1998
Component:
Vehicle speed control:cables
Manufactured:
06/07/1998 - 08/04/1998
Affected:
1,500
Defect:
Vehicle description: light duty pickup trucks. a speed control cable may not have fully seated into the accelerator bracket at time of installation. if the cable is not fully seated into this bracket, the cable could separate from the bracket.
Consequence:
A loose cable can result in the throttle not fully returning to idle and cause an increase in stopping distance.
Correction:
Dealers will add a retaining clip to the speed control cable fitting at the accelerator bracket.
Notes:
Ford is notifying dealers on or about august 11, 1998.these vehicles have not yet been released for sale to the public.
Campaign:
98V194000 on 08/27/1998
Component:
Fuel system, gasoline:fuel injection system
Manufactured:
03/22/1998 - 08/03/1998
Affected:
1,700
Defect:
Vehicle description: light duty pickup trucks. the fuel pressure regulator o-ring may have been damaged when the fuel pressure regulator was installed in the engine fuel rail. if the o-ring is damaged, fuel vapor or leakage could occur.
Consequence:
If an ignition source is present, a fire could result.
Correction:
Dealers will replace the fuel pressure regulator.
Notes:
No owner notification is required at this time.all vehicles are still in dealer's possession.
Campaign:
98V303000 on 12/01/1998
Component:
Air bags:frontal:sensor/control module
Manufactured:
09/24/1998 - 09/24/1998
Affected:
20
Defect:
Vehicle description: light duty trucks. the cast tow hooks changes the crash pulse of the vehicle in frontal barrier impacts and the air bag sensor was not calibrated to this new crash pulse which may cause the air bags to deploy in lower speed impacts than design intent.
Consequence:
Unexpected air bag deployment can result in personal injury.
Correction:
Dealers will replace the cast tow hooks with forged hooks.
Notes:
Owner notification is expected to begin january 3, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V062001 on 03/30/1999
Component:
Vehicle speed control
Manufactured:
03/01/1998 - 03/03/1999
Affected:
898,739
Defect:
Vehicle description: certain 1997-1999 rhd explorer equipped with 4.0l ohv/sohc engines and cruise control built from may 29, 1996 through march 4, 1999; 1998-1999 explorer/mountaineers equipped with 4.0l ohv/sohc or 5.0l engines or 1998-1999 rangers equipped with 2.5l, 3.0l ffv/efi or 4.0l engines and cruise control built from january 5, 1998 through march 4, 1999; 1998-1999 mustangs equipped with 3.8l, 4.6l 2-valve or 4-valve engines and cruise control built from march 2, 1998 through march 4, 1999; 1999 f250/f350/f450/f550 (over 8,500 lbs.) trucks equipped with 5.4l or 6.8l engines and cruise control built from march 2, 1998 through march 4, 1999; and 1999 f-53 stripped chassis equipped with 5.4l or 6.8l engines and cruise control built from march 2, 1998 through march 4, 1999. a cruise control cable can interfere with the speed control servo pulley and not allow the throttle to return to idle when disengaging the cruise control.
Consequence:
If the cruise control is used and this condition is present, a stuck throttle could result, which could potentially result in a crash.
Correction:
Dealers will replace the cruise control cables. at the present time, the replacement cables are not available. customers are being advised not to use the cruise control system until a replacement can be made.
Notes:
A pre-release warning letter that identified an interim fix until the parts for the permanent fix became available was mailed to owners beginning march 27, 1999.a second owner notification, identifying the permanent fix was mailed to owners beginning may 24, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V093001 on 04/28/1999
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
12/31/1997 - 03/30/1999
Affected:
293,650
Defect:
Vehicle description: gasoline and diesel engine pickup trucks equipped with 6" and 8" beds manufactured from january 5, 1998 through march 21, 1999, do not not fully satisfy the post crash test static rollover requirements of fmvss no. 301, "fuel system integrity." six attachment bolts (m12 bolts) may have been damaged during the 30 mph front barrier test allowing the bolts to shift or become detached, resulting in fuel spillage.
Consequence:
Fuel leakage in the presence of an ignition source could result in a fire.
Correction:
Dealers will augment the box-to-chassis attachment by installing box-to-chassis retaining cables.
Notes:
Owner notification began august 30, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V219000 on 08/16/1999
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
01/04/1998 - 05/24/1999
Affected:
245,300
Defect:
Vehicle description: gasoline and diesel engine pickup trucks equipped with 8 foot beds, do not fully satisfy the requirements of fmvss no. 301, "fuel system integrity." the fuel tank front strap isolator may not be properly positioned which could result in the strap cutting the tank during a 30 mph front barrier test, resulting in fuel spillage.
Consequence:
During the subsequent static rollover test, fuel spillage exceeded the specified rate, increasing the risk of a fire.
Correction:
Dealers will reposition the front strap isolator.
Notes:
Owner notification began december 1, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V311000 on 11/07/1999
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
01/04/1998 - 07/17/1999
Affected:
107,540
Defect:
Vehicle description: pickup trucks equipped with gasoline engines and 8 foot boxes, may not fully satisfy the requirements of fmvss no. 301, "fuel system integrity." in a 30 mph frontal barrier crash test, a fuel tank vapor recovery valve separated internally. during the subsequent static rollover test, fuel spillage exceeded the specified rate.
Consequence:
Fuel leakage, in the presence of an ignition source, could result in a fire.
Correction:
Dealers will install a stop plate assembly on the vehicle frame to prevent recovery valve contact with a frame crossmember during the impact sequence.
Notes:
Ford recall no. 99s32.owner notification is expected to begin during november/december 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V284000 on 09/21/2000
Component:
Equipment:other:labels
Manufactured:
03/30/1998 - 09/19/2000
Affected:
4,500
Defect:
Vehicle description: bi-fuel cng pickup trucks and bi-fuel cng vans, modified by cfi control systems, inc., fail to conform to the requirements of fmvss no. 303, "fuel system integrity of compressed natural gas vehicles." the label affixed to the fuel filler door by the vehicle modifier contains the inspection date and expiration date of the cng tank. however, it does not contain the statement "see instructions on the fuel container for inspection and service life."
Consequence:
These vehicles do not comply with the requirements.
Correction:
Owners will be provided a label with the required statement, along with instructions for affixing the label at the fuel filler door. owner notification began november 2, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V093002 on 10/09/2000
Component:
Fuel system, gasoline:storage:tank assembly:mounting
Manufactured:
01/04/1998 - 06/03/1999
Affected:
102,700
Defect:
Vehicle description: pickup trucks equipped with 6" beds manufactured from january 5, 1998 through june 4, 1999, do not not fully satisfy the post crash test static rollover requirements of fmvss no. 301, "fuel system integrity." contact between the fuel tank and a fuel tank locator bracket during a front barrier impact test resulted in a cut in the tank, resulting in fuel leakage.
Consequence:
Fuel leakage in the presence of an ignition source could result in a fire.
Correction:
Dealers will replace the fuel tank locator bracket with a similar bracket whose design has been revised to incorporate more rounded surfaces where contact with the tank occurs.
Notes:
Owner notification began august 30, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02V068000 on 03/24/2002
Component:
Parking brake:conventional:mechanical:linkage and cable
Manufactured:
01/02/1998 - 09/29/1998
Affected:
51,846
Defect:
On certain pickup trucks equipped with manual transmissions, failure of the front parking brake cable input button could result in failure of the parking brake system to hold the vehicle stationary.
Consequence:
This could result in unintended vehicle movement and a vehicle crash.
Correction:
Dealers will replace the front parking brake cable and the controller and verify the performance of the parking brake system. owner notification began april 5, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
05V388000 on 09/06/2005
Component:
Vehicle speed control
Affected:
4,500,000
Defect:
On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
Consequence:
A fire at the switch could occur.
Correction:
By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E052000 on 06/11/2006
Component:
Exterior lighting:headlights
Affected:
14,616
Defect:
Certain eagle eyes headlamps, p/nos. fr208-b101r, fr208-b101l, fr208-b001r, and fr208-b001l, sold for use as replacement equipment for the passenger vehicles listed above. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabry lee will notify owners and offer full credit for any noncompliant headlamp. the recall is expected to begin on june 14, 2006. owners may contact sabry lee account executive at 1-866-467-2279.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E067000 on 07/31/2006
Component:
Exterior lighting:headlights
Affected:
19,413
Defect:
Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Maxzone will notify owners and offer reimbursement for any noncompliant headlights. the recall began on july 28, 2006. owners may contact maxzone at 909-822-3288.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06V286000 on 08/01/2006
Component:
Vehicle speed control
Affected:
1,200,000
Defect:
On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
Consequence:
Overheating could result in smoke or burn and an underhood fire.
Correction:
Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on august 7, 2006. owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
07E066000 on 08/28/2007
Component:
Equipment:electrical
Affected:
175
Defect:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
Correction:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Notes:
This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V385000 on 07/31/2011
Component:
Fuel system, gasoline:storage:tank assembly:mounting
Manufactured:
06/19/1995 - 08/03/2004
Affected:
1,100,000
Defect:
Ford is recalling certain 1997 through 2003 model year ford f-150, 2004 model year ford f-150 heritage, 1997 through 1999 model year f-250 less than 8,500 lbs. gross vehicle weight rating (gvwr), and 2002 and 2003 lincoln blackwood vehicles manufactured from june 20, 1995, through august 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.
Consequence:
As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. either scenario may result in a fuel leak presenting a fire hazard.
Correction:
Ford will notify owners and instruct them to take their vehicles to a ford or lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. early in this campaign, if replacement straps are not available, dealers may install a cable support under the strap as an interim repair or a steel reinforcement over the existing strap as a permanent repair. any repairs will be performed free of charge. the safety recall began on september 16, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. ford's recall campaign number is 11s21
Notes:
Ford's recall campaign number is 11s21.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1999 FORD F-250 TSBs (244)

Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
982452
Component:
353600 equipment:air conditioner
Summary:
Information on the effect on vehicles when removing the a/c compressor. *yc
Bulletin:
982463
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
A temporary technicla assistance hotline has been established to help with diagnostics and / or mechanical concerns with the new venture transfer case on some vehicles. *yc
Bulletin:
982541
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with the 7.3l dit have a strategy that includes a cold weather idle kicker feature which, under certain conditions will automatically elevate the idle speed after 130 seconds of idling at cold temperatures. *yc
Bulletin:
982693
Component:
220000 seats
Summary:
Customers have expressed concerns involving the rear seat back operation when trying to use the load floor option. *yc
Bulletin:
982721
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may experience a popping / squeaking noise in the steering column while turning. *yc
Bulletin:
982740
Component:
061000 engine and engine cooling:engine
Summary:
Concerns with high pressure oil pumps are not serviceable. *yc
Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9942
Component:
035000 service brakes, hydraulic:fluid
Summary:
Customer may complain of brake fluid leaking at the left rear wheel. *tt
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
99411
Component:
030000 service brakes, hydraulic
Summary:
Vehicles experiencing increased brake pedal effort and / or false abs cycling at low speeds, or abs lamp illumination. *tt
Bulletin:
9946
Component:
103000 power train:automatic transmission
Summary:
Concerns with transmission fluid leaking at radiator. *tt
Bulletin:
5856
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on diagnosing passive anti-theft system (pats) issues. *tt
Bulletin:
5901
Component:
116200 electrical system:ignition:module
Summary:
Service tips for identifying injector driver module (idm) failure with diagnostic trouble code p1298. *tt
Bulletin:
5955
Component:
105500 power train:driveline:differential unit
Summary:
Subject regarding front differential noise investigation. *tt
Bulletin:
12591
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles equipped with the 5.4l engine, 4r100 transmission an auxiliary transmission oil cooler may exhibit a coastdown moaning noise. *tt
Bulletin:
12601
Component:
162000 structure:body
Summary:
Experiencing whistling noise coming from the front of the vehicle at highway speeds. *tt
Bulletin:
12611
Component:
021000 suspension:front
Summary:
Subject regarding adjustment to the front end alighment settings to address tire-wear or vehicle directional sensitivity concerns. *tt
Bulletin:
98130
Component:
103000 power train:automatic transmission
Summary:
Service procedure for orange service tagged transmissions. *tt
Bulletin:
99S09
Component:
182000 vehicle speed control:linkages
Summary:
Recall information regarding speed control cable replacement. *tt
Bulletin:
99812
Component:
162000 structure:body
Summary:
Concerns with the storage bin inside the console may fall down inside the console basecd on some vehicles. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99128
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a whistling noise while driving with a/c in the off position at speeds above 64 km/h (40 mph). *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99136
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Concerns with premature wear of the inner rear pad. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
991313
Component:
036000 service brakes, hydraulic:antilock
Summary:
Subject regarding anti-lock brake lamp illumination, increased break pedal effort and / or false anti-lock brake system (abs) cycling at low speeds. *tt
Bulletin:
9946
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Concerns with transmission fluid leaking at the radiator. *tt
Bulletin:
98B32
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding installation of rear brake shields. *tt
Bulletin:
6315
Component:
036000 service brakes, hydraulic:antilock
Summary:
Vehicles may exhibit an anti-lock brake system (abs) indicator lamp with no diagnostic trouble code (dtc) detected. *tt
Bulletin:
6407
Component:
136000 visibility:windshield wiper/washer
Summary:
Exhibiting front windshield wiper activation without command. *tt
Bulletin:
6477
Component:
022141 suspension:rear:springs:leaf spring assembly:leaf
Summary:
Subject regarding rear spring rattle. *tt
Bulletin:
12826
Component:
136000 visibility:windshield wiper/washer
Summary:
Experiencing front wipers activation without command. *tt
Bulletin:
12905
Component:
106000 power train:axle assembly
Summary:
Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
Bulletin:
12911
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit activation of front wipers without command. *tt
Bulletin:
996034
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a engine knock at cold start-up. *tt
Bulletin:
996042
Component:
135000 visibility:rearview mirrors/devices
Summary:
Information on using 1999 procedures manual for side mirror replacement. *tt
Bulletin:
996113
Component:
105000 power train:driveline
Summary:
Experiencing front differential noise. *tt
Bulletin:
996128
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding right rear brake concerns under investigation. *tt
Bulletin:
996139
Component:
105000 power train:driveline
Summary:
Concerns with front differential noise. *tt
Bulletin:
98-4764
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a vibration or shudder from take off under moderate to hard accelerationl. *tt
Bulletin:
983315
Component:
102000 power train:manual transmission
Summary:
The 4r100 transmission will have an orange "prior to repair" tag on the fluid pan. *tt
Bulletin:
983316
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some customer may complain of a ticking noise on initial cold start-up in park position and neutral position. *tt
Bulletin:
983317
Component:
190000 tires
Summary:
Information on tire pressure. *tt
Bulletin:
9811264
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with ticking noise on initial cold start-up in park and neutral position. *tt
Bulletin:
99164
Component:
116000 electrical system:ignition
Summary:
Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
Bulletin:
99143
Component:
105500 power train:driveline:differential unit
Summary:
Some 4x4 vehicles built with center disconnect front axles may exhibit a moaning noise from the front differential while operating in 4x2 mode. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
996747
Component:
110000 electrical system
Summary:
Some vehicles equipped with either the trailer towing package or chassis cab may exhibit various trailer related electrical conditions. instructions on installing the trailer towing relays and fuses are provided in the trailer towing kit.
Bulletin:
996780
Component:
133000 visibility:power window devices and controls
Summary:
This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal / weatherstrip molding area. *tt
Bulletin:
996804
Component:
135000 visibility:rearview mirrors/devices
Summary:
Concerns with outside passenger or driver side mirror slightly fulttering / shaking at highway speeds. *tt
Bulletin:
996870
Component:
980000 unknown or other
Summary:
This online service bulletin mentions that late built regular cabs will not offer a tool box tray located behind the seat, the tool box tray is discontinued and is no longer available as an option. *tt
Bulletin:
996871
Component:
110000 electrical system
Summary:
Vehicles built after 7/31/99 will no longer be equipped with a shield covering the starter relay and c120 / c172 electrical connectors located on the passenger side of the engine compartment. *tt
Bulletin:
996875
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Engineering is investigating all brake concerns on vehicles exhibiting brake noise. *tt
Bulletin:
9913030
Component:
110000 electrical system
Summary:
Some vehicles equipped with either the trailer towing package or chassis cab may exhibit various trailer related electrical conditions such as: backup lights inoperative, trailer battery feed inoperative or electric brake power inoperative
Bulletin:
9913072
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Vehicles may exhibit an outside passenger or driver side mirror slight flutter / shake at highway speeds. *tt
Bulletin:
9913127
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Information on diagnosing 7.3l dit vehicles built prior to 4/1/99 exhibiting a turbocharger noise, exhaust noise, or oil / soot presence on rear of engine or turbocharger. *tt
Bulletin:
98B32
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding owner notification program for installation of rear brake shield(s). *tt
Bulletin:
99213
Component:
162300 structure:body:door
Summary:
A condition with the auto-lock functions not operation properly on vehicles built from 6/3/1999 through 6/8/1999. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99224
Component:
136000 visibility:windshield wiper/washer
Summary:
Subject regarding front wipers operating while switch is in off position. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99197
Component:
980000 unknown or other
Summary:
Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99243
Component:
126200 exterior lighting:turn signal:switch
Summary:
On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
Bulletin:
6914
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit a diagnostic trouble code b1845 (ignition tamper switch failure) when retrieving diagnostic trouble codes from the remote anti-theft personality (rap) module. *tt
Bulletin:
6917
Component:
160000 structure
Summary:
Some trucks may exhibit a loose / detached gimp moulding at the rear window. *tt
Bulletin:
7022
Component:
162000 structure:body
Summary:
Information regarding outward dents in pickup box wheel wells. *mjs
Bulletin:
13203
Component:
162000 structure:body
Summary:
Information regarding outward dents in pickup box wheel wells. *mjs
Bulletin:
13238
Component:
162300 structure:body:door
Summary:
Information regarding vehicles that exhibit cracks in the door sheet metal. *mjs
Bulletin:
13253
Component:
136000 visibility:windshield wiper/washer
Summary:
(continued from 13251 and 13252) uncommanded front wiper function. *mjs
Bulletin:
13384
Component:
036000 service brakes, hydraulic:antilock
Summary:
Exhibiting abs codes of b2141 or b2477 following replacement of a gem module. *tt
Bulletin:
13412
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
Bulletin:
13010
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles equipped with the 5.4l engine, 4r100 transmission and an auxiliary transmission oil cooler may exhibit a coastdown moan concern. *tt
Bulletin:
7353
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
Bulletin:
13470
Component:
021000 suspension:front
Summary:
Some vehicles may require adjustment to the front end alignment settings to address tire-wear or vehicle directional sensitivity concerns. *tt
Bulletin:
13479
Component:
162300 structure:body:door
Summary:
Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt
Bulletin:
13550
Component:
162000 structure:body
Summary:
Some vehicles may exhibit dents on the wheel well sheet metal of the pcik-up box area when used in off-road applications. *tt
Bulletin:
0014
Component:
161000 structure:frame and members
Summary:
Vehicles may experience inner fender well- dented or dinged from stones being thrown into wheelwell. *mjs
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
7821
Component:
162700 structure:body:trunk lid
Summary:
Cracks in the door sheet metal at the lower rear of the window opening near the belt molding.
Bulletin:
7816
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit interior lights, power windows and / or inoperative running board lights for a short period of time in the morning. *tt
Bulletin:
8163
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with 4.6l, or 6.8l engines may exhibit a roller finger follower coming off during engine cranking in cold temperatures below zero degrees f. a one-time noise from the engine may be heard, followed by rough running / misses
Bulletin:
0038
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
Bulletin:
8207
Component:
106200 power train:axle assembly:axle shaft
Summary:
Some vehicles equipped with 10.50-inch ring gear, full-floating rear axles may exhibit a leak at the outboard end of the axle shaft(s). *tt
Bulletin:
13838
Component:
131000 visibility:windshield
Summary:
Concerns with vehicles exhibiting a windshield creak / squeak. *tt
Bulletin:
8021
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a crackling/popping noise from the exhaust, vehicles built between 11/1/97 and 12/8/99. *mjs
Bulletin:
13737
Component:
980000 unknown or other
Summary:
All vehicles may exhibit an inoperative or inaccurate speedometer, 4x4 light inoperative and/or dtc p1635 after a pcm has been replaced. *mjs
Bulletin:
13745
Component:
100000 power train
Summary:
Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
Bulletin:
13806
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles built between 11/1/97 and 12/8/99 may exhibit a crackling/popping noise from the exhaust. *mjs
Bulletin:
00611
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs
Bulletin:
14031
Component:
980000 unknown or other
Summary:
Concerns with erratic remote entry functions. *tt
Bulletin:
9805014
Component:
980000 unknown or other
Summary:
Exhibiting a check engine light on and possible diagnostic trouble codes p0715, p0716, p0717, p0718, p1901 (turbine shaft speed - tss codes) or p0720, p0721, p0722, p1900 (output shaft speed - oss codes). *tt
Bulletin:
9805015
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Brief information stating that certain vehicles are equipped with a new hybrid electronic instrument cluster (hec). *tt
Bulletin:
12086
Component:
100000 power train
Summary:
Some vehicles may exhibit an inoperative speedometer and dtc p1635 after a pcm has been replaced. *mjs
Bulletin:
985028
Component:
110000 electrical system
Summary:
Information regarding a new service part released for the license plate light circuit which will reduce the cose of repairs. *tt
Bulletin:
12104
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code dtc 1728 in memory. *mjs
Bulletin:
12112
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some vehicles with the 5.4 l engine may exhibit difficulty engaging into and out of 4 x 4 low, while cold. *mjs
Bulletin:
12120
Component:
100000 power train
Summary:
Some vehicles with 4r70w transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the vent area of the transmission. *mjs
Bulletin:
12139
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs
Bulletin:
12144
Component:
980000 unknown or other
Summary:
Information regarding the 1999 scheduled maintenance guide for any light truck, sport utility or van equipped with a 4r100 transmission normal maintenance schedule, is not correct. *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
985055
Component:
101200 power train:clutch assembly:bell housing
Summary:
Condition described as noise from bellhousing area. *tt
Bulletin:
985080
Component:
100000 power train
Summary:
Certain vehicles may exhibit an inoperative speedometer and diagnostic trouble code p1635 after a pecm has been replaced. *tt
Bulletin:
985141
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code 1728 in memory. *tt
Bulletin:
985167
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with the 5.4l engine may exhibit difficulty engaging into and out of 4x4 low, while cold. *tt
Bulletin:
980312
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Excessive white smoke. verify glow plug operation by performing glow plug system operation check on the hard start/no start diagnostic sheet. *tt
Bulletin:
0087
Component:
110000 electrical system
Summary:
Concerns with courtesy, glove compartment, underhood, running board lamps; power windows; radio; and rear wiper all inoperative in the morning or after vehicle is left unattended for 45 minutes. *mr
Bulletin:
8021
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhibiting a crackling / popping noise from the exhaust. **mr
Bulletin:
8464
Component:
980000 unknown or other
Summary:
Information regarding erractic remote entry functions-new gem released. **mr
Bulletin:
8582
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit a delayed operation / inoperative instrument cluster with koeo or koer. **mr
Bulletin:
14043
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Information regarding transfer case hall effect encoder tips. **mr
Bulletin:
11508
Component:
160000 structure
Summary:
This bulletin states that when removing the a/c compressor on certain vehicles, the rear most attaching bolt interferes with the chassis cross member. *tt
Bulletin:
14086
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Exhibiting a delayed operation / inoperative instrument cluster with koeo or koer. *tt
Bulletin:
14191
Component:
100000 power train
Summary:
Some vehicles equipped with a manual transfer case may exhbit an inoperative speedometer. *tt
Bulletin:
98-4719
Component:
102400 power train:manual transmission:lubricant
Summary:
Repeat message revised will have to reconfigure gem with service card if vehicle equipped with manual transmission.
Bulletin:
98-4720
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Low clutch pedal engagement 7.3l dit. *ak
Bulletin:
98-4730
Component:
036000 service brakes, hydraulic:antilock
Summary:
Repeat message , revised concerning abs light on and 4 wabs codes set. *ak
Bulletin:
99-6189
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding abs electronic module now available for service. *t
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
99-6197
Component:
162000 structure:body
Summary:
Information to technicians regarding objectionable windnoise identified during pre-delivery. *tt
Bulletin:
6232
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the coil resulting in engine misfire with diagnostic trouble code p0304 and / or rough idle. *tt
Bulletin:
6287
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may experience an idle vibration. *tt
Bulletin:
6293
Component:
160000 structure
Summary:
Subject regarding cowl leaf screen change. *tt
Bulletin:
12750
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vhicles may exhibit an anti-lock brake system (abs) indicator lamp with no diagnostic trouble codes (dtc). *tt
Bulletin:
12776
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may exhibit an anti-lock brake system (abs) indicator lamp on with no diagnostic trouble codes (dtc) detected. *tt
Bulletin:
6702
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles equipped with the 5.4l engine, 4r100 transmission and an auxiliary transmission oil cooler may exhibit a coastdown moan concern. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12708
Component:
160000 structure
Summary:
Subject regarding vehicles exhibiting windnoise at pre-delivery. *tt
Bulletin:
12720
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the flexible rubber coolant hose. *tt
Bulletin:
12738
Component:
161000 structure:frame and members
Summary:
Some vehicles may exhibit a idle vibration.
Bulletin:
12753
Component:
160000 structure
Summary:
Subject regarding cowl leaf screen change. *tt
Bulletin:
12562
Component:
110000 electrical system
Summary:
Some vehicles may exhibit diagnostic trouble code p1298. *tt
Bulletin:
12574
Component:
090000 fuel system, other
Summary:
Some owners may report slow fuel gauge response time during re-fueling. *tt
Bulletin:
12590
Component:
105500 power train:driveline:differential unit
Summary:
Some 4x4 vehicles may exhibit a moan noise from the front differential when the vehicle is operating in 4x2 mode and goes away when operating in 4x4 mode. *tt
Bulletin:
13054
Component:
131000 visibility:windshield
Summary:
Experiencing windnoise at the top of the door glass seal / weatherstrip molding area. *tt
Bulletin:
13060
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding vehicles exhibiting rear brake grab and shoe wear. *tt
Bulletin:
13099
Component:
980000 unknown or other
Summary:
Brief information regarding the discontinued tool box. *tt
Bulletin:
13100
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding discontinue of the engine compartment beauty shield. *tt
Bulletin:
13106
Component:
162200 structure:body:bumpers
Summary:
On some vehicles the front bumpers may exhibit red staining (spots) on the bumer wing ends. *tt
Bulletin:
13146
Component:
116100 electrical system:ignition:switch
Summary:
Subject regaring the ignition tamper switch. *tt
Bulletin:
13149
Component:
160000 structure
Summary:
Subject regarding a loose / detached gimp moulding at the rear window. *tt
Bulletin:
6489
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Some vehicles built with 3-leaf or 4-leaf rear springs may exhibit a rear spring rattle. *tt
Bulletin:
12879
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Subject regarding rear spring clip kits for vehicles exhibiting a rear spring rattle. *tt
Bulletin:
12882
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Subject regarding the availability of rear spring clip kits for vehicles exhibiting rear spring rattle. *tt
Bulletin:
13505
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
Bulletin:
9877
Component:
135000 visibility:rearview mirrors/devices
Summary:
Procedures for trailer tow mirror glass replacement. *yc
Bulletin:
4637
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Anti-skid brake system (abs) light on and 4wabs codes set. *tt
Bulletin:
4660
Component:
111000 electrical system:battery
Summary:
Subject regarding the nagative battery terminal cover on some vehicles. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4981
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt
Bulletin:
5141
Component:
103000 power train:automatic transmission
Summary:
Some vehicles with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code (dtc) 1728 in memory.dtc 1728 is defined as internal transmission element slippage. this splippage can occur anywhere in the transmission includ
Bulletin:
5233
Component:
133000 visibility:power window devices and controls
Summary:
Information on the alive memory (dam) feature during various diagnostic and repair procedures. *tt
Bulletin:
5257
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on vehicles exhibiting cold engine knock. *tt
Bulletin:
5262
Component:
136000 visibility:windshield wiper/washer
Summary:
Information on diagnosticing erratic windshield wiper operation. *tt
Bulletin:
5267
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding misfire codes on all engines. *tt
Bulletin:
5349
Component:
100000 power train
Summary:
Subject regarding technical assistance for speedometer accuracy concerns. *tt
Bulletin:
12248
Component:
103000 power train:automatic transmission
Summary:
Some heavy duty and super duty vehicles may exhibit various transmission concerns, including stall on transmission engagement and / or a buzz noise on engagement. *tt
Bulletin:
12253
Component:
350000 equipment
Summary:
Effective january 4, 1999 certain vehicles built with throw-in-mats will be built with the deltar clip attachment as a means of attachment to the floor. *tt
Bulletin:
12265
Component:
102000 power train:manual transmission
Summary:
Some vehicles equipped with m50d r2 mazda 5 speed manual transmission may exhibit a gear shift rattle condition in third gear. *tt
Bulletin:
12266
Component:
100000 power train
Summary:
Some vehicles may require technical assistance for speedometer accuracy concerns. *tt
Bulletin:
12266
Component:
100000 power train
Summary:
Some vehicles may require technical assistance for speedometer accuracy concerns. *tt
Bulletin:
985185
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Cold start engine noise
Bulletin:
98L20
Component:
980000 unknown or other
Summary:
Special field action regarding revised waranty information. *tt
Bulletin:
00232
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an intermittent hesitation or buck while driving in any fuel mode (lpg, cng or gasoline). *tt
Bulletin:
00238
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a no crank / no start condition in temperatures below 12 degrees c (10 degrees f). *tt
Bulletin:
00239
Component:
110000 electrical system
Summary:
A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
Bulletin:
14455
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak from the front or rear cylinder head oil supply rail end plugs. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00E12
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Emmission recall on certain vehicles equipped with 7.3l diesel and california warm weather calibration - pcm reprogram. *tt
Bulletin:
00261
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
Bulletin:
01111
Component:
160000 structure
Summary:
Some vehicles may exhibit a water leak around the rear (sliding) window. *tt
Bulletin:
00142
Component:
100000 power train
Summary:
Inoperative or inaccurate speedometer, 4x4 lamp illuminated and / or diagnostic trouble codes (dtcs) p1635 or p1639 present after a powertrain control module (pcm) or instrument cluster replacement. *jb
Bulletin:
00L07
Component:
355100 equipment:other:labels
Summary:
This bulletin involves fuel door label application / replacement. *jb
Bulletin:
00192
Component:
110000 electrical system
Summary:
Some vehicles may exhibit an inoperative courtesy, glove compartment, underhood, running board lamps, power windows, radio and rear wiper in the morning or after vehicle is left unattended for 45 minutes. *jb
Bulletin:
00189
Component:
135000 visibility:rearview mirrors/devices
Summary:
Concerns with the signal mirror reflective surface deteriorating over time, developing dark spots due to chrome plating delamination. *jb
Bulletin:
14356
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Concerns with rear brake noise. *jb
Bulletin:
14365
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
0182
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some bi-fuel vehicles may exhibit a no start condition. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
0193
Component:
106100 power train:axle assembly:banjo housing
Summary:
A condition may exist where a driveline vibration and / or a transmission fluid leak from the extension housing seal area may occur on some vehicles. this may be caused by the extension housing bushing or seal walking / spinning out due t
Bulletin:
14918
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
Bulletin:
14942
Component:
980000 unknown or other
Summary:
Some vehilces equipped with 4.6l romeo engine and manual transmission only, may exhibit a check engine light on and diagnostic trouble coe p0172 / p0175 stored in memory with possible driveabltility conditions such as hesitation / stumble.
Bulletin:
13737
Component:
100000 power train
Summary:
Inoperative or inaccurate speedometer as well as 4x4 light inoperative and / or diagnostic trouble code p1635 and / or p1639 after a powertrain control module (pcm) has been replaced. *tt
Bulletin:
14160
Component:
980000 unknown or other
Summary:
A condition may exist where the malfunction indicator lamp is on with diagnostic trouble code p0340 (camshaft position (cmp) sensor a circuit) stored, accompanied with a driveability concern. *tt
Bulletin:
14356
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Some super duty f series vehicles may exhibit a brake squeal / squeak from the rear brakes. *tt
Bulletin:
01136
Component:
070000 fuel system, gasoline
Summary:
Subject regarding overview of bi-fuel cng vehicle parameter identification data (pid), inputs and outputs as a diagnostic aid for bi-fuel vehicles. *tt
Bulletin:
01137
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
Bulletin:
01141
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some vehicles may exhibit inadvertent 4x4 hi or low shift events, 4x4 and / or low range indicator flashing or solid or vehicle stuck in 4l after uncommanded shift. *tt
Bulletin:
15068
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles equipped with a 4.6l engine and 5 speed manual transmission may exhibit a slight hesitation on light tip-in acceleration and a malfunction indicator lamp on with diagnostic trouble codes p0172 and p0175. *tt
Bulletin:
15101
Component:
100000 power train
Summary:
Some vehicles equipped with a 4.6l engine a 5 speed manual transmission may exhibit a slight hesitation on light tip-in acceleration and a malfunction indicator lamp on with diagnostic trouble code p0172 and p0175. *tt
Bulletin:
01122
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
On some vehicles there may be an oil leak from the right hand head gasket at the rear of the block / head joint. *tt
Bulletin:
14990
Component:
162300 structure:body:door
Summary:
Concerns that some trucks may exhibit a loose / detached rear window halo trim gimp moulding. *tt
Bulletin:
01151
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles equipped with a 4.6l engine and m5od 5 speed manual transmissions may exhibit hesitation on acceleration and a check engine light illumination with diagnostic trouble codes 90172 and 90175. *slc
Bulletin:
15157
Component:
021100 suspension:front:stabilizer bar
Summary:
Some vehicles may exhibit repeat noise concerns with the front stability bar end links. *yh
Bulletin:
15113
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Some vehicles may exhibit a fuel fill valve sealing condition. *yd
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15260
Component:
113000 electrical system:starter assembly
Summary:
Concerns with corroded positive starter cable. *tt
Bulletin:
012110
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt
Bulletin:
012112
Component:
180000 vehicle speed control
Summary:
A condition may exist, where throttle sticking may occur on a few vehicles in very cold ambient temperatures afte operating at steady speed or extended idle for a period of time. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
15570
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit various driveability conditions including lacks power, hesitates, hard to start, and/or malfunction indicator lamp (mil) illuminated and produce possible diagnostic trouble codes p0103, p0172 and p0175. *tt
Bulletin:
15292
Component:
100000 power train
Summary:
Some super duty f series equipped with pto capable transmissions may exhibit a failure to go t high idle upon pto engagement. *tt
Bulletin:
01017
Component:
010000 steering
Summary:
Subject regarding 198196 bolt-on steering stops service group, all models 0307, hr0307a and hr1000a. *slc
Bulletin:
02E17
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Subject regarding heater hose to fuel rail flex line inspection. *jg
Bulletin:
02106
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some bi-fuel lpg vehicles (with coolant lock off) may exhibit a no start condition. *tt
Bulletin:
15711
Component:
102000 power train:manual transmission
Summary:
Some vehicles equipped with a 5-speed mazda r2 manual transmission may exhibit a high effort condition when shifting any gear. *tt
Bulletin:
15742
Component:
070000 fuel system, gasoline
Summary:
Information on vehicles exhibiting a perceived poor fuel range / economy, and or a faulty fuel gauge. *tt
Bulletin:
0342
Component:
090000 fuel system, other
Summary:
Possible fuel leak may occur at the fuel fill valve, on some dedicated cng vehicles. *tt *jb
Bulletin:
030402
Component:
090000 fuel system, other
Summary:
On some dedicated cng vehicles, a possible fuel leak may occur at the fuel fill valve. revised service parts. *tt
Bulletin:
16915
Component:
100000 power train
Summary:
Excessive drive-away shudder or vibration under moderate to heavy acceleration from a stop. *tt
Bulletin:
03104
Component:
061000 engine and engine cooling:engine
Summary:
Bi-fuel lpg vehicles (with coolant lock off) may exhibit a no start condition. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
17009
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) illumination with no hard fault. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
17307
Component:
162300 structure:body:door
Summary:
Squeaking noise coming from the upper door seal when driving over bumps. f250 model includes 1999-2004 super duty f-series. *tt
Bulletin:
16515
Component:
010000 steering
Summary:
Oil leak at high pressure pump fittings and/or plug. this includes super duty f-series. oasis. *tt
Bulletin:
16589
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Gradual loss of power at cruise. use fuel additive to prevent his condition. all super duty f-series 1999-2003 included. oasis *tt
Bulletin:
17603
Component:
141100 air bags:frontal:sensor/control module
Summary:
Air bag light on with diagnostic trouble code (dtc) b1871 or b1935 following ecs/rcm replacement. *tt
Bulletin:
17554
Component:
061000 engine and engine cooling:engine
Summary:
Oil/dust film at cac connections. *mj
Bulletin:
02227
Component:
061000 engine and engine cooling:engine
Summary:
Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
Bulletin:
16403
Component:
061000 engine and engine cooling:engine
Summary:
Engine-light tick or rattle type noise from engine after cold start. *mj
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02193
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Driveability-idle-high idle speeds-throttle sticks after steady state driving in extreme cold ambient temperatures-vehicles built through 12/31/01 equipped with 4.6l engine. *mj
Bulletin:
04L19
Component:
017500 steering:linkages:tie rod assembly
Summary:
Customer maintenance reminder - literature program 04l19 - tie rod inspection procedure. *tt
Bulletin:
18223
Component:
033100 service brakes, hydraulic:power assist:vacuum
Summary:
Vacuum pump inoperative or runs continuously - climate control defaults to defrost. oasis. to also include 2005 super duty f-series, excursion, and f650/750. *tt
Bulletin:
18406
Component:
162000 structure:body
Summary:
Service tips before arc welding on the frame or body of a unit. *tt
Bulletin:
18376
Component:
103000 power train:automatic transmission
Summary:
A cold weather reverse engagement stall. *tt
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
04236
Component:
020000 suspension
Summary:
Vehicle lean sag when observed from rear of vehicle. *eh
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
05417
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
TSB-14-0147
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln: safety recall issued due to one or both fuel tank straps fracturing due to being in high corrosion areas for an extended period and dislodging fuel tank. model 1997-99 f250, 1997-03 f150, 2004 f150 heritage, 2002-2003 blackw
Bulletin:
TSB-14-0164
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln: safety recall regarding high corrosion areas for operating, for an extended time, vehicles where both or one strap of fuel tank can fracture, after contacting ground. model 1997-99 f250 ld, 1997-03 f150, 2004 f150 heritage,

Home | Privacy