1999 FORD EXPEDITION Recalls (9)

Campaign:
98V296000 on 11/23/1998
Component:
Service brakes, hydraulic:pedals and linkages
Affected:
4,000
Defect:
Vehicle description: sport utility vehicles. these vehicles may have a missing or partially installed retainer clip that holds the master cylinder push rod to the brake pedal arm.
Consequence:
Increased brake stopping distance can occur, increasing the risk of a crash.
Correction:
Dealers will inspect these vehicles to see if the retainer clip was installed, and repair, if necessary.
Notes:
Owner notification began december 30, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
98V312000 on 12/13/1998
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:
07/31/1998 - 08/23/1998
Affected:
305
Defect:
Vehicle description: sport utility vehicles. the fuel line assemblies may have been damaged by the supplier during manufacturing, allowing leakage.
Consequence:
Fuel leakage in the presence of an ignition source can result in a fire.
Correction:
Dealers will inspect these vehicles and, if necessary, replace the front and rear fuel line assemblies.
Notes:
Owner notification is expected to begin january 3, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V099000 on 04/29/1999
Component:
Wheels:lugs/nuts/bolts
Manufactured:
06/30/1998 - 04/11/1999
Affected:
53,784
Defect:
Vehicle description: sport utility vehicles equipped with four-wheel-drive (4x4), 17" chrome steel wheels. the clamp load can be lost on the wheel lugs due to insufficient wheel contact area with the hub. in some cases, the contact area can deform, resulting in a loss of lug nut torque.
Consequence:
Loss of lug nut torque can cause vibration or separation of a wheel and tire from the vehicle.
Correction:
Dealers will re-torque the wheel lugs to proper specifications and also install a label that specifies that the wheel lugs be torqued to 110 lb-ft any time the wheel is removed.
Notes:
Owner notification began may 7, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V073000 on 03/12/2000
Component:
Trailer hitches
Manufactured:
07/21/1996 - 12/08/1999
Affected:
565,800
Defect:
Vehicle description: multi-purpose vehicles. the trailer hitch assembly to the frame attaching bolts could lose the clamp load.
Consequence:
The trailer hitch could then separate from the vehicle.
Correction:
Dealers will replace the trailer hitch mounting bolts and nut plates.
Notes:
Owner notification began may 15, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01X001000 on 05/21/2001
Component:
Tires:tread/belt
Affected:
13,000,000
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. ford is replacing these tires to prevent possible premature tire failure. vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
Consequence:
Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
Correction:
The replacement/reimbursement program for this campaign expired on march 31, 2002. however, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
Campaign:
05V388000 on 09/06/2005
Component:
Vehicle speed control
Affected:
4,500,000
Defect:
On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
Consequence:
A fire at the switch could occur.
Correction:
By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E056000 on 06/22/2006
Component:
Fuel system, gasoline
Affected:
58,640
Defect:
Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence:
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Correction:
Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
Notes:
This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E060000 on 06/28/2006
Component:
Exterior lighting
Affected:
87,745
Defect:
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Correction:
Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
Notes:
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E067000 on 07/31/2006
Component:
Exterior lighting:headlights
Affected:
19,413
Defect:
Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Maxzone will notify owners and offer reimbursement for any noncompliant headlights. the recall began on july 28, 2006. owners may contact maxzone at 909-822-3288.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1999 FORD EXPEDITION TSBs (293)

Bulletin:
98254
Component:
021230 suspension:front:springs:air suspension system
Summary:
Some vehicles equipped with air suspension may exhibit an intermittent check suspension lamp on and diagnostic trouble code (dtc) c1770 and/or c1845 illuminated. *yc
Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
982521
Component:
063000 engine and engine cooling:exhaust system
Summary:
Concerns of breakage of the exhaust system between the muffler and tailpipe may occur on some vehicles. *yc
Bulletin:
984802
Component:
136000 visibility:windshield wiper/washer
Summary:
When installing a rear wiper arm on some vehicles, be sure to follow the procedure in the 1999 workshop manual section 501-16-92. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982019
Component:
221600 seats:front assembly:power adjust
Summary:
Concerns with the power seat control button ( knob ) may detach from the switch actuator. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
99411
Component:
030000 service brakes, hydraulic
Summary:
Vehicles experiencing increased brake pedal effort and / or false abs cycling at low speeds, or abs lamp illumination. *tt
Bulletin:
9946
Component:
103000 power train:automatic transmission
Summary:
Concerns with transmission fluid leaking at radiator. *tt
Bulletin:
5374
Component:
103700 power train:automatic transmission:torque converter
Summary:
Vehicle exhibiting diagnostic trouble code p1744 (torque converter clutch slippage). *tt
Bulletin:
5745
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with a dual media (am / fm / cassette / cd) or am / fm cassette radio may exhibit an intermittent or inoperative rear speaker. *tt
Bulletin:
5856
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on diagnosing passive anti-theft system (pats) issues. *tt
Bulletin:
12546
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Subject on new higher effort steering gears. *tt
Bulletin:
12572
Component:
105100 power train:driveline:universal joint
Summary:
Vehicles may exhibit a high speed driveline vibration. *tt
Bulletin:
12591
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles equipped with the 5.4l engine, 4r100 transmission an auxiliary transmission oil cooler may exhibit a coastdown moaning noise. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99128
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a whistling noise while driving with a/c in the off position at speeds above 64 km/h (40 mph). *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99108
Component:
183000 vehicle speed control:cables
Summary:
Experiencing vibration in the accelerator pedal on some vehicles. *tt
Bulletin:
991313
Component:
036000 service brakes, hydraulic:antilock
Summary:
Subject regarding anti-lock brake lamp illumination, increased break pedal effort and / or false anti-lock brake system (abs) cycling at low speeds. *tt
Bulletin:
9946
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Concerns with transmission fluid leaking at the radiator. *tt
Bulletin:
6304
Component:
105500 power train:driveline:differential unit
Summary:
Some vehicles may experience a driveline clunk / jerk during tip-in. *tt
Bulletin:
6315
Component:
036000 service brakes, hydraulic:antilock
Summary:
Vehicles may exhibit an anti-lock brake system (abs) indicator lamp with no diagnostic trouble code (dtc) detected. *tt
Bulletin:
6317
Component:
010000 steering
Summary:
New service steering gear. *tt
Bulletin:
6407
Component:
136000 visibility:windshield wiper/washer
Summary:
Exhibiting front windshield wiper activation without command. *tt
Bulletin:
12826
Component:
136000 visibility:windshield wiper/washer
Summary:
Experiencing front wipers activation without command. *tt
Bulletin:
12905
Component:
106000 power train:axle assembly
Summary:
Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
Bulletin:
12911
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit activation of front wipers without command. *tt
Bulletin:
996034
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a engine knock at cold start-up. *tt
Bulletin:
996037
Component:
020000 suspension
Summary:
Subject regarding alignment information. *tt
Bulletin:
996042
Component:
135000 visibility:rearview mirrors/devices
Summary:
Information on using 1999 procedures manual for side mirror replacement. *tt
Bulletin:
996113
Component:
105000 power train:driveline
Summary:
Experiencing front differential noise. *tt
Bulletin:
996139
Component:
105000 power train:driveline
Summary:
Concerns with front differential noise. *tt
Bulletin:
9912778
Component:
010000 steering
Summary:
Information regarding new service steering gear. *tt
Bulletin:
9912789
Component:
105000 power train:driveline
Summary:
Experiencing a driveline clunk / jerk during tip-in. *tt
Bulletin:
98-4802
Component:
137000 visibility:rear window wiper/washer
Summary:
Information on procedures to follow when installing a rear wiper arm. *tt
Bulletin:
983315
Component:
102000 power train:manual transmission
Summary:
The 4r100 transmission will have an orange "prior to repair" tag on the fluid pan. *tt
Bulletin:
99164
Component:
116000 electrical system:ignition
Summary:
Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
Bulletin:
99143
Component:
105500 power train:driveline:differential unit
Summary:
Some 4x4 vehicles built with center disconnect front axles may exhibit a moaning noise from the front differential while operating in 4x2 mode. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
99157
Component:
020000 suspension
Summary:
Some vehicles may exhibit vibration, shimmy and body boom at speeds above 72 km/h (45 mph). *tt
Bulletin:
996780
Component:
133000 visibility:power window devices and controls
Summary:
This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal / weatherstrip molding area. *tt
Bulletin:
996805
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Some vehicles may exhibit an exterior rear view mirror with a slight flutter / shake. *tt
Bulletin:
996869
Component:
115000 electrical system:fuses and circuit breakers
Summary:
This online bulletin mentions that vehicles built on or after 6/25/99 no longer are equipped with a mega fuse bracket cover (xl34-14a099-f). the mega fuse bracket is located on the passenger side of the cowl, under the hood. *tt
Bulletin:
996876
Component:
162200 structure:body:bumpers
Summary:
Information pertaining to conditions with red staining (spots) on the front bumper wing ends. *tt
Bulletin:
9913138
Component:
116200 electrical system:ignition:module
Summary:
Information on replacing and removing the generic electronic module (gem). *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99224
Component:
136000 visibility:windshield wiper/washer
Summary:
Subject regarding front wipers operating while switch is in off position. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
99186
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
991812
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Vehicles built through 1/10/1999 may exhibit vibration felt through the accelerator pedal. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99197
Component:
980000 unknown or other
Summary:
Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99243
Component:
126200 exterior lighting:turn signal:switch
Summary:
On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
Bulletin:
6905
Component:
110000 electrical system
Summary:
Information on removing and / or replacing the generic electronic module (gem). *tt
Bulletin:
6930
Component:
020000 suspension
Summary:
Subject regarding vehicles with four wheel air suspension may require a ride height adjustment procedure performed before setting alignment. *tt
Bulletin:
6999
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding e40d / 4r100 transmission fluid cooler flow test specification. *tt
Bulletin:
7100
Component:
103000 power train:automatic transmission
Summary:
Information regarding transmission trouble codes. *mjs
Bulletin:
7106
Component:
980000 unknown or other
Summary:
Information regarding the winners of the edsr of the month quality awards for the month of august. *mjs
Bulletin:
13187
Component:
103000 power train:automatic transmission
Summary:
Information regarding e40d/4r100 transmission fluid cooler flow test specification. *mjs
Bulletin:
13253
Component:
136000 visibility:windshield wiper/washer
Summary:
(continued from 13251 and 13252) uncommanded front wiper function. *mjs
Bulletin:
13275
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Subject regarding vehicles exhibiting a shudder / vibration under acceleration in a straight line from a stop. *tt
Bulletin:
13285
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing engine knock at initial cold startup. *tt
Bulletin:
7155
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles equipped with windsor engines only may exhibit an engine knock at initial cold startup. *tt
Bulletin:
7157
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some 4x4s may exhibit a shudder / vibration under acceleration in a straight line from a stop. *tt
Bulletin:
7204
Component:
353000 equipment:electrical
Summary:
Production change was put into effect that discontinued the instantaneous fuel economy display. *tt
Bulletin:
7207
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
7321
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting a hesitation / stumble after initial vehicle start-up during accelerator tip-in, with a cold engine. *tt
Bulletin:
13287
Component:
353000 equipment:electrical
Summary:
A production change was put into effect that discontinued the instantaneous fuel economy display. *tt
Bulletin:
13322
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an engine knock at initial cold startup. *tt
Bulletin:
13376
Component:
980000 unknown or other
Summary:
Exhibiting an inaccurate compass readings if not set at pre-delivery inspection (pdi). *tt
Bulletin:
6350
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with engines produced by windsor engine plant may exhibit an engine knock at initial cold startup. *tt
Bulletin:
6553
Component:
353600 equipment:air conditioner
Summary:
Information regarding ambient temperture display strategy. *tt
Bulletin:
6556
Component:
136000 visibility:windshield wiper/washer
Summary:
Exhibiting jerky or uneven windshield wiper arm movement. *tt
Bulletin:
6557
Component:
980000 unknown or other
Summary:
Information regarding the revised towing specifications. *tt
Bulletin:
6686
Component:
353600 equipment:air conditioner
Summary:
Subject regarding air conditioner vacuum reservoir / check valve location. *tt
Bulletin:
13010
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Some vehicles equipped with the 5.4l engine, 4r100 transmission and an auxiliary transmission oil cooler may exhibit a coastdown moan concern. *tt
Bulletin:
7353
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
7823
Component:
021230 suspension:front:springs:air suspension system
Summary:
Expedition and navigators equipped with four wheel air suspension may require a ride height adjustment procedure be performed, before setting alignment. when adjusting ride height reference the 1990 expedition and navigator workshop manual
Bulletin:
7816
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit interior lights, power windows and / or inoperative running board lights for a short period of time in the morning. *tt
Bulletin:
8051
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit a front washer operating without command. *tt
Bulletin:
8093
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles built 7/1998 to 6/1999 equipped with a 4.6 / 5.4l windsor built engine may exhibit an oil leak from the cylinder head gasket area. *tt
Bulletin:
7896
Component:
160000 structure
Summary:
Servicing trailer hitch.
Bulletin:
0018
Component:
353600 equipment:air conditioner
Summary:
Vehicles equipped with electronic automatic temperature control (eatc) , may exerience the blower motor staying on high after desired temperature is reached and/ or the system does not maintain set temperature. *mjs
Bulletin:
0032
Component:
353600 equipment:air conditioner
Summary:
Vehicles may experience air conditioning inaccurate ambient temperature displayed- vehicles equipped with eatc- continental and ls built through 10/15/99, all others built through 8/31/99. *mjs
Bulletin:
8163
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with 4.6l, or 6.8l engines may exhibit a roller finger follower coming off during engine cranking in cold temperatures below zero degrees f. a one-time noise from the engine may be heard, followed by rough running / misses
Bulletin:
0038
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
Bulletin:
7929
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Diagnostic information for compact disc player problems.
Bulletin:
13838
Component:
131000 visibility:windshield
Summary:
Concerns with vehicles exhibiting a windshield creak / squeak. *tt
Bulletin:
13846
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles built 7/1998 to 6/1999 equipped with a 4.6 / 5.4l windsor built engines may exhibit an oil leak from the cylinder head gasket area. *tt
Bulletin:
8021
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a crackling/popping noise from the exhaust, vehicles built between 11/1/97 and 12/8/99. *mjs
Bulletin:
13711
Component:
210000 trailer hitches
Summary:
Subject regarding the servicing of trailer hitches on vehicles. *mjs
Bulletin:
13712
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information regarding vehicles that experience the radios that display no dj-no disc or cd will not eject. *mjs
Bulletin:
13725
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration/moan at highway speeds. *mjs
Bulletin:
13737
Component:
980000 unknown or other
Summary:
All vehicles may exhibit an inoperative or inaccurate speedometer, 4x4 light inoperative and/or dtc p1635 after a pcm has been replaced. *mjs
Bulletin:
13745
Component:
100000 power train
Summary:
Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
Bulletin:
8367
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some vehicles equipped with a4wd may exhibit a driveline pulsaton / shudder vibration under low speed acceleration in a straight line. *tt
Bulletin:
13757
Component:
106000 power train:axle assembly
Summary:
Vehicles equipped with limited slip/traction-lok rear axles may exhibit a chatter noise while turning. *mjs
Bulletin:
13773
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information for compact disc player problems, radio may display no dj- no dusc or cd will not eject. *mjs
Bulletin:
13744
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a body boom while driving highway speeds. *mjs
Bulletin:
13806
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles built between 11/1/97 and 12/8/99 may exhibit a crackling/popping noise from the exhaust. *mjs
Bulletin:
13825
Component:
136000 visibility:windshield wiper/washer
Summary:
Some vehicles may exhibit a front washer operating without command. *mjs
Bulletin:
14031
Component:
980000 unknown or other
Summary:
Concerns with erratic remote entry functions. *tt
Bulletin:
9812061
Component:
980000 unknown or other
Summary:
Vehicles with ohv/sohc, 5.0l 4.6l, 5.4l may exhibit a (mil) on with evap system dtc's p1450,po455,po466. the december sbds release will included new automated static leak test for dianosing these concerns. *mjs
Bulletin:
9805014
Component:
980000 unknown or other
Summary:
Exhibiting a check engine light on and possible diagnostic trouble codes p0715, p0716, p0717, p0718, p1901 (turbine shaft speed - tss codes) or p0720, p0721, p0722, p1900 (output shaft speed - oss codes). *tt
Bulletin:
9805015
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Brief information stating that certain vehicles are equipped with a new hybrid electronic instrument cluster (hec). *tt
Bulletin:
985023
Component:
980000 unknown or other
Summary:
This bulletin mentions that the instructions for the operation of the keyless entry system for certain vehicles were omitted from the owners guide. *tt
Bulletin:
12086
Component:
100000 power train
Summary:
Some vehicles may exhibit an inoperative speedometer and dtc p1635 after a pcm has been replaced. *mjs
Bulletin:
12104
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code dtc 1728 in memory. *mjs
Bulletin:
12112
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some vehicles with the 5.4 l engine may exhibit difficulty engaging into and out of 4 x 4 low, while cold. *mjs
Bulletin:
12120
Component:
100000 power train
Summary:
Some vehicles with 4r70w transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the vent area of the transmission. *mjs
Bulletin:
12134
Component:
100000 power train
Summary:
Information regarding vehicles models of the 4r100 that are added to the fqr (ford quality renewal) assembly program. *mjs
Bulletin:
12139
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs
Bulletin:
12144
Component:
980000 unknown or other
Summary:
Information regarding the 1999 scheduled maintenance guide for any light truck, sport utility or van equipped with a 4r100 transmission normal maintenance schedule, is not correct. *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
985080
Component:
100000 power train
Summary:
Certain vehicles may exhibit an inoperative speedometer and diagnostic trouble code p1635 after a pecm has been replaced. *tt
Bulletin:
12182
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may require the keep alive memory (kam) to be reset during various diagnostic and repair procedures. *mjs
Bulletin:
985141
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code 1728 in memory. *tt
Bulletin:
985167
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with the 5.4l engine may exhibit difficulty engaging into and out of 4x4 low, while cold. *tt
Bulletin:
985183
Component:
980000 unknown or other
Summary:
Effective november 2, 1998 certain vehicles of the 4r100 are added to the fqr (ford quality renewal) assembly program. *tt
Bulletin:
00B40
Component:
126200 exterior lighting:turn signal:switch
Summary:
Information regarding multifunction switch replacement. **mr
Bulletin:
0084
Component:
022000 suspension:rear
Summary:
Concerns with a chattering noise from the rear axle heard when turning or cornerning. **mr
Bulletin:
0087
Component:
110000 electrical system
Summary:
Concerns with courtesy, glove compartment, underhood, running board lamps; power windows; radio; and rear wiper all inoperative in the morning or after vehicle is left unattended for 45 minutes. *mr
Bulletin:
8021
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhibiting a crackling / popping noise from the exhaust. **mr
Bulletin:
8464
Component:
980000 unknown or other
Summary:
Information regarding erractic remote entry functions-new gem released. **mr
Bulletin:
8582
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit a delayed operation / inoperative instrument cluster with koeo or koer. **mr
Bulletin:
14086
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Exhibiting a delayed operation / inoperative instrument cluster with koeo or koer. *tt
Bulletin:
14197
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Some vehicles may exhibit a slow fuel fill condition. *tt
Bulletin:
99-6189
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding abs electronic module now available for service. *t
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6232
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the coil resulting in engine misfire with diagnostic trouble code p0304 and / or rough idle. *tt
Bulletin:
6282
Component:
980000 unknown or other
Summary:
Information on setting compass module at pre-delivery. *tt
Bulletin:
6287
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may experience an idle vibration. *tt
Bulletin:
6293
Component:
160000 structure
Summary:
Subject regarding cowl leaf screen change. *tt
Bulletin:
12743
Component:
980000 unknown or other
Summary:
Exhibiting malfunction indicator lamp (mil) with diagnostic trouble codes (dtc(s) po351 and / or p0356 (coil primary circuit malfunction). *tt
Bulletin:
12750
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vhicles may exhibit an anti-lock brake system (abs) indicator lamp with no diagnostic trouble codes (dtc). *tt
Bulletin:
12757
Component:
105500 power train:driveline:differential unit
Summary:
Some vehicles built after 2/1/1999 equipped with 5.4l-2v engines and 4r100 transmissions may exhibit a driveline clunk / jerk during tip-in from closed throttle at vehicle speeds above 43 mph in 4th gear gear and normal transmission operati
Bulletin:
12776
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may exhibit an anti-lock brake system (abs) indicator lamp on with no diagnostic trouble codes (dtc) detected. *tt
Bulletin:
6702
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles equipped with the 5.4l engine, 4r100 transmission and an auxiliary transmission oil cooler may exhibit a coastdown moan concern. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12720
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the flexible rubber coolant hose. *tt
Bulletin:
12738
Component:
161000 structure:frame and members
Summary:
Some vehicles may exhibit a idle vibration.
Bulletin:
12747
Component:
350000 equipment
Summary:
Some vehicles may exhibit inaccurate compass readings if not set at pre-delivery inspection (pdi). *tt
Bulletin:
12753
Component:
160000 structure
Summary:
Subject regarding cowl leaf screen change. *tt
Bulletin:
12574
Component:
090000 fuel system, other
Summary:
Some owners may report slow fuel gauge response time during re-fueling. *tt
Bulletin:
13054
Component:
131000 visibility:windshield
Summary:
Experiencing windnoise at the top of the door glass seal / weatherstrip molding area. *tt
Bulletin:
13071
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Brief information describing exterior rear view mirror diagnosis. *tt
Bulletin:
13098
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Subject regarding mega fuse bracket cover. *tt
Bulletin:
13106
Component:
162200 structure:body:bumpers
Summary:
On some vehicles the front bumpers may exhibit red staining (spots) on the bumer wing ends. *tt
Bulletin:
13158
Component:
020000 suspension
Summary:
Some vehicles equipped with four wheel air suspension may require a ride height adjustment procedure be performed before setting alignment. *tt
Bulletin:
13290
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
13331
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with engines produced by windsor engine plant may exhibit an engine knock at initial cold startup. *tt
Bulletin:
13409
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 4.6l engine may exhibit a hesitation / stumble after initial vehicle start-up during accelerator tip-in, with a cold engine. *tt
Bulletin:
13505
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
Bulletin:
12994
Component:
353600 equipment:air conditioner
Summary:
Subject regarding a/c vacuum reservoir / check valve location for the air conditioning system. *tt
Bulletin:
4660
Component:
111000 electrical system:battery
Summary:
Subject regarding the nagative battery terminal cover on some vehicles. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
12797
Component:
106000 power train:axle assembly
Summary:
Addressing concerns of a low speed (under 35 mph) clicking noise caused by a cage nut rocking on the cotter pin for the front axle half shaft spindle. *tt
Bulletin:
12798
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with engines produced by windsor engine plant may exhibit an engine knock at initial cold startup. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4802
Component:
136000 visibility:windshield wiper/washer
Summary:
Rear wiper arm installation. *tt
Bulletin:
4981
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt
Bulletin:
5141
Component:
103000 power train:automatic transmission
Summary:
Some vehicles with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code (dtc) 1728 in memory.dtc 1728 is defined as internal transmission element slippage. this splippage can occur anywhere in the transmission includ
Bulletin:
5233
Component:
133000 visibility:power window devices and controls
Summary:
Information on the alive memory (dam) feature during various diagnostic and repair procedures. *tt
Bulletin:
5243
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Information on vehicles with the 5.4l engine exhibiting difficulty engaging into and out of 4x4 low. *tt
Bulletin:
5257
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on vehicles exhibiting cold engine knock. *tt
Bulletin:
5291
Component:
135000 visibility:rearview mirrors/devices
Summary:
Information on vehicles equipped with signal mirrors. *tt
Bulletin:
5370
Component:
137000 visibility:rear window wiper/washer
Summary:
Some vehicles may exhibit a rear wiper that does not function properly (jammed). *tt
Bulletin:
5374
Component:
103700 power train:automatic transmission:torque converter
Summary:
Some vehicles equipped with 4r100 transmission may exhibit a diagnostic trouble code (dtc) p1744 (torque converter clutch slippage detected). *tt
Bulletin:
12198
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some vehicles with the 5.4l engine may exhibit difficulty engaging into and out of 4x4 low, while cold. *tt
Bulletin:
12216
Component:
036000 service brakes, hydraulic:antilock
Summary:
This bulletin mentions that for all vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12227
Component:
110000 electrical system
Summary:
For all vehicles with generic electronic module (gem) concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12234
Component:
135000 visibility:rearview mirrors/devices
Summary:
Information on vehicles equipped with signal mirrors. *tt
Bulletin:
12266
Component:
100000 power train
Summary:
Some vehicles may require technical assistance for speedometer accuracy concerns. *tt
Bulletin:
12266
Component:
100000 power train
Summary:
Some vehicles may require technical assistance for speedometer accuracy concerns. *tt
Bulletin:
12282
Component:
137000 visibility:rear window wiper/washer
Summary:
Some vehicles may exhibit a rear wiper that does not function properly (jammed). *tt
Bulletin:
12290
Component:
103700 power train:automatic transmission:torque converter
Summary:
Some vehicles equipped with 4r100 transmission may exhibit a diagnostic trouble code p1744 (torque converter clutch slippage detected). *tt
Bulletin:
985185
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Cold start engine noise
Bulletin:
14456
Component:
162000 structure:body
Summary:
Information on squeak and rattle noise conditions. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00261
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
Bulletin:
14609
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding high idle and/or check engine light condition. *jb
Bulletin:
14627
Component:
353600 equipment:air conditioner
Summary:
Conditions on climate control system air flows through defrost only. *jb
Bulletin:
00142
Component:
100000 power train
Summary:
Inoperative or inaccurate speedometer, 4x4 lamp illuminated and / or diagnostic trouble codes (dtcs) p1635 or p1639 present after a powertrain control module (pcm) or instrument cluster replacement. *jb
Bulletin:
00201
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Some vehicles may exhibit hesitation on acceleration or while turning. *jb
Bulletin:
00192
Component:
110000 electrical system
Summary:
Some vehicles may exhibit an inoperative courtesy, glove compartment, underhood, running board lamps, power windows, radio and rear wiper in the morning or after vehicle is left unattended for 45 minutes. *jb
Bulletin:
00189
Component:
135000 visibility:rearview mirrors/devices
Summary:
Concerns with the signal mirror reflective surface deteriorating over time, developing dark spots due to chrome plating delamination. *jb
Bulletin:
14359
Component:
021230 suspension:front:springs:air suspension system
Summary:
Subject pertaining to air suspension leaks. *jb
Bulletin:
14365
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
Bulletin:
14372
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on idle vibration or engine droan on acceleration. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14821
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 4.6l romeo engine may exhibit an oil leak from the cylinder head gasket area. *tt
Bulletin:
14864
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding certain vehicles with 4.6l romeo engines exhibiting an oil leak from the cylinder head gasket area. *tt
Bulletin:
0142
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit the engine oil sending unit contacting the oil drip shield attached to the front axle. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
14918
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
Bulletin:
14905
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles may exhibit amber anti-lock brake system (abs) lamp on with undefined diagnostic trouble codes (dtcs) stored. *tt
Bulletin:
14907
Component:
980000 unknown or other
Summary:
Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
Bulletin:
13737
Component:
100000 power train
Summary:
Inoperative or inaccurate speedometer as well as 4x4 light inoperative and / or diagnostic trouble code p1635 and / or p1639 after a powertrain control module (pcm) has been replaced. *tt
Bulletin:
13846
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles built 7/1998 to 6/1999 equipped with a 4.6 / 5.4l winsor built engines may exhibit an oil leak from the cylinder heat gasket area. *tt
Bulletin:
14160
Component:
980000 unknown or other
Summary:
A condition may exist where the malfunction indicator lamp is on with diagnostic trouble code p0340 (camshaft position (cmp) sensor a circuit) stored, accompanied with a driveability concern. *tt
Bulletin:
14233
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equpped with a 5.4l or 6.8l engine may exhibit a rolling / rough idle. *tt
Bulletin:
01137
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
Bulletin:
01141
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some vehicles may exhibit inadvertent 4x4 hi or low shift events, 4x4 and / or low range indicator flashing or solid or vehicle stuck in 4l after uncommanded shift. *tt
Bulletin:
01122
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
On some vehicles there may be an oil leak from the right hand head gasket at the rear of the block / head joint. *tt
Bulletin:
01128
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a check suspension lamp on with diagnostic trouble codes b2140 or c2140 even after the air suspension switch in the upper rh kick panel has been turned on. *tt
Bulletin:
15011
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Exhibiting an uncommanded shift wheel low during low speed maneuvering. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15122
Component:
161000 structure:frame and members
Summary:
Some vehicles may exhibit a vibration at idle and/or engine droaning noise on acceleration from a stop. *slc
Bulletin:
15123
Component:
105000 power train:driveline
Summary:
Some vehicles may exhibit a driveline vibration at speeds between 60-70 mph. *slc
Bulletin:
15152
Component:
330000 interior lighting
Summary:
Some vehicles may exhibit courtesy rail lamps above the 2nd row seats that do not operate properly or cause a battery draw. *et
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15219
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a condition where all the guages inthe instrument cluster will sweep at initial start up. *tt
Bulletin:
15225
Component:
201000 wheels:rim
Summary:
Some vehicles may exhibit a difficult to remove wheel rim condition. *tt
Bulletin:
15259
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with the lower power in high ambient temepratures. *tt
Bulletin:
012110
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt
Bulletin:
012112
Component:
180000 vehicle speed control
Summary:
A condition may exist, where throttle sticking may occur on a few vehicles in very cold ambient temperatures afte operating at steady speed or extended idle for a period of time. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
01B77
Component:
190000 tires
Summary:
Owner notification program supplement 7 revised information - regarding replacement of wilderness at tires. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15504
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit driveabilty conditions and/or check engine lamp illuminated with a diagnostic trouble code p0455 (gross leak detected). *tt
Bulletin:
15517
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding exaggerated engine braking on deceleration. *yd
Bulletin:
15526
Component:
120000 exterior lighting
Summary:
Subject regarding inoperative running board lights.*yd
Bulletin:
15528
Component:
021230 suspension:front:springs:air suspension system
Summary:
Subject regarding air suspension compressor quality. *yd
Bulletin:
15549
Component:
133000 visibility:power window devices and controls
Summary:
Information regarding pop/thump noise from power window. *yh
Bulletin:
15319
Component:
105500 power train:driveline:differential unit
Summary:
Some vehicles built before june 8, 2000 and equipped with a4wd may exhibit a high-speed moan or driveline pulsation/shudder. *tt
Bulletin:
15326
Component:
021000 suspension:front
Summary:
Some vehicles may exhibit a pop/clunk/click noise from the front suspension when making low speed turns in either forward or reverse. *tt
Bulletin:
15362
Component:
021230 suspension:front:springs:air suspension system
Summary:
Some vehicles may exhibit air suspension malfunction. *tt
Bulletin:
15407
Component:
021000 suspension:front
Summary:
Concerns with a pop/clunk/click noise coming from the front suspension when making low-speed turns in forward or reverse gears. *tt
Bulletin:
15431
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting lack of power condition when vehicle is operated in ambient temperatures. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
15480
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Some vehicles may exhibit a slow fuel fill condition and/or premature shutoff of the gas pump when the vehicle is being re-fueled. *tt
Bulletin:
15502
Component:
021000 suspension:front
Summary:
Concerns with pop/clunk/click noise from the front suspension when making low-speed turns in forward or reverse gears. *tt
Bulletin:
15605
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit driveability conditions and / or check engine lamp illuminated with a diagnostic trouble p0455 (gross leak detected). *tt
Bulletin:
15648
Component:
070000 fuel system, gasoline
Summary:
Some vehicles may exhibit a slow fuel fill condition and/or premature shutoff of the gas pump when the vehicle is being refueled. *tt
Bulletin:
15651
Component:
021230 suspension:front:springs:air suspension system
Summary:
Some vehicles equipped with air suspension may exhibit an air leak and/or overnight bleed down of the air suspension. *tt
Bulletin:
15652
Component:
353600 equipment:air conditioner
Summary:
Concerns with climate control system air discharged through the defroster ducts only, regardless of setting. *tt
Bulletin:
0258
Component:
100000 power train
Summary:
Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
02108
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 5.4l 2v engine may exhibit a whistling noise fromthe formed nylon tube inthe idle-air bypass flow circuit. *tt
Bulletin:
16015
Component:
021230 suspension:front:springs:air suspension system
Summary:
Some vehicles with air suspension may exhibit an initial or repeat compressor dryer failure. *tt
Bulletin:
16033
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some vehicles with electronic shift-on-the fly may exhibit an inadvertent 4x4 low engagement while driving. *tt
Bulletin:
15692
Component:
020000 suspension
Summary:
Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps. *tt
Bulletin:
15708
Component:
200000 wheels
Summary:
Some vehicles may exhibit wheels that seize to the hubs and are difficult to remove during service. *tt
Bulletin:
15727
Component:
190000 tires
Summary:
Some 4x2 vehicles equipped with p275/60/r17 continental general tires may exhibit a highway speed tire vibration. *tt
Bulletin:
15749
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 4 wheel drive may exhibit a notchy or sticking feeling in slow speed turns with no effect on steering efforts or assist while in the automatic 4x4 position. *tt
Bulletin:
15794
Component:
190000 tires
Summary:
Some 4x2 vehicles equipped with p275/60/r17 continental-general tires may exhibit a highway speed tire vibration. *tt
Bulletin:
15851
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some 5.4l windsor power improved engines may exhibit a slight oil leak or weep at the cylinder head to block joint. *tt
Bulletin:
15897
Component:
105500 power train:driveline:differential unit
Summary:
Subject regarding driveline angle-related vibration at various speeds and load conditions. *tt
Bulletin:
15939
Component:
162000 structure:body
Summary:
Concerns with speed body boom. *tt
Bulletin:
03610
Component:
017500 steering:linkages:tie rod assembly
Summary:
Tie rod end inspection procedure. canada vehicles only. *tt *jb
Bulletin:
16683
Component:
061000 engine and engine cooling:engine
Summary:
False failure of the vapor management valve (vmv). *tt *jb
Bulletin:
16797
Component:
110000 electrical system
Summary:
Vehicles with keyless entry pad may exhibit dead battery, no start, interior lamp/headlamp self-activation, or inoperative keyless entry pad. *tt
Bulletin:
030709
Component:
020000 suspension
Summary:
Repeat air suspension compressor drier failures. *tt
Bulletin:
0392
Component:
021230 suspension:front:springs:air suspension system
Summary:
Repeat air suspension compressor drier failures. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
0399
Component:
010000 steering
Summary:
Tie rod end inspection procedure. *tt
Bulletin:
031513
Component:
017500 steering:linkages:tie rod assembly
Summary:
Tie rod end inspection procedure. *tt
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
17459
Component:
330000 interior lighting
Summary:
Courtesy rail lamps do not operate correctly or cause a battery draw. *tt
Bulletin:
17320
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Broken exhaust manifold studs. *tt
Bulletin:
17448
Component:
061000 engine and engine cooling:engine
Summary:
Remote oil filter adaptor replacement - new service part. *tt
Bulletin:
02227
Component:
061000 engine and engine cooling:engine
Summary:
Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
Bulletin:
16403
Component:
061000 engine and engine cooling:engine
Summary:
Engine-light tick or rattle type noise from engine after cold start. *mj
Bulletin:
0454
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Air suspension compressor noise. *tt
Bulletin:
0457
Component:
130000 visibility
Summary:
Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02193
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Driveability-idle-high idle speeds-throttle sticks after steady state driving in extreme cold ambient temperatures-vehicles built through 12/31/01 equipped with 4.6l engine. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
04L19
Component:
017500 steering:linkages:tie rod assembly
Summary:
Customer maintenance reminder - literature program 04l19 - tie rod inspection procedure. *tt
Bulletin:
041514
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
05417
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
Bulletin:
0554
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Use of stainless steel exhaust studs in service for 5.4l 2v engine. *tt
Bulletin:
050618
Component:
022000 suspension:rear
Summary:
Rear axle noise repair. *sc
Bulletin:
05618
Component:
106000 power train:axle assembly
Summary:
Rear axle noise repair. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe

Home | Privacy