1999 FORD ECONOLINE Recalls (7)
- Campaign:
- 98V257000 on 10/14/1998
- Component:
- Power train:manual transmission
- Manufactured:
- 08/12/1998 - 08/23/1998
- Affected:
- 350
- Defect:
- Vehicle description: pickup trucks built with single rear wheels and equipped with 3.55:1 and 3.73:1 axle ratio. these vehicles were built with incorrect speedometer driven gears, resulting in a lower speedometer reading than the actual vehicle speed being driven.
- Consequence:
- This can result in the vehicle being driven at an unsafe or illegal speed should the driver not realize that his vehicle road speed is greater than the speedometer indication.
- Correction:
- Dealers will install the correct speedometer gear.
- Notes:
- Owner notification began february 26, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V046000 on 03/16/1999
- Component:
- Latches/locks/linkages:doors:latch
- Manufactured:
- 01/28/1999 - 02/16/1999
- Affected:
- 2,893
- Defect:
- Vehicle description: utility vans equipped with the "60/40" hinged side cargo doors. the strikers for the 60/40 door single latch system were found to contain stress cracks at the striker wire lower stake joint. strikers with stress cracks may not meet the requirements of fmvss no. 206, "door locks and door retention components."
- Consequence:
- In the event of a crash, the door strikers may not hold the door, increasing the risk of personal injury or property damage.
- Correction:
- Dealers will replace the door striker.
- Notes:
- Owner notification began april 7, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V115000 on 05/01/2000
- Component:
- Wheels:lugs/nuts/bolts
- Manufactured:
- 08/16/1998 - 12/22/1999
- Affected:
- 3,300
- Defect:
- Vehicle description: cutaways and stripped chassis with single rear wheels. the lug nuts can potentially bottom out on a shoulder on the studs.
- Consequence:
- If this occurs, there can be an inadequate clamp load to attach the wheel to the axle, resulting in noise, damage to the wheel and hub, or in extreme cases, loss of a rear wheel while the vehicle is being driven.
- Correction:
- Dealers will replace the rear wheel attaching studs.
- Notes:
- Owner notification began may 15, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V284000 on 09/21/2000
- Component:
- Equipment:other:labels
- Manufactured:
- 03/30/1998 - 09/19/2000
- Affected:
- 4,500
- Defect:
- Vehicle description: bi-fuel cng pickup trucks and bi-fuel cng vans, modified by cfi control systems, inc., fail to conform to the requirements of fmvss no. 303, "fuel system integrity of compressed natural gas vehicles." the label affixed to the fuel filler door by the vehicle modifier contains the inspection date and expiration date of the cng tank. however, it does not contain the statement "see instructions on the fuel container for inspection and service life."
- Consequence:
- These vehicles do not comply with the requirements.
- Correction:
- Owners will be provided a label with the required statement, along with instructions for affixing the label at the fuel filler door. owner notification began november 2, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 08V051000 on 02/03/2008
- Component:
- Vehicle speed control:cruise control
- Manufactured:
- 09/02/1991 - 09/14/2003
- Affected:
- 225,000
- Defect:
- Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
- Consequence:
- As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
- Correction:
- Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
- Notes:
- Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1999 FORD ECONOLINE TSBs (145)
- Bulletin:
- 98259
- Component:
- 980000 unknown or other
- Summary:
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
- Bulletin:
- 982010
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
- Bulletin:
- 982019
- Component:
- 221600 seats:front assembly:power adjust
- Summary:
- Concerns with the power seat control button ( knob ) may detach from the switch actuator. *yc
- Bulletin:
- 982310
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Mass air flow (maf)- sensor contamination- service tip. *ak
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
- Bulletin:
- 9943
- Component:
- 100000 power train
- Summary:
- Information regarding reprogramming powertrain control modules (pcms). *tt
- Bulletin:
- 5892
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding techinical hotline assistance for bi-fuel vehicles with gfi alternate fuel systems. *tt
- Bulletin:
- 12593
- Component:
- 161000 structure:frame and members
- Summary:
- Concerns with cracks on the right rear side of the #1 frame crossmember. *tt
- Bulletin:
- 98S28
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Information on new part numbers for instrument clusters. *tt
- Bulletin:
- 99816
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
- Bulletin:
- 9997
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Some vehicles may exhibit a "squeaking" or "moaning" noise from the steering column while turning. *tt
- Bulletin:
- 99129
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
- Bulletin:
- 99132
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a malfunction indicator lamp (mil) illuminated with a false diagnostic trouble code (dtc) p1298 (injector drive module (idm) failure). *tt
- Bulletin:
- 99139
- Component:
- 125000 exterior lighting:brake lights
- Summary:
- Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
- Bulletin:
- 6360
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Concerns with fluid leaks at the transmission extension housing area. *tt
- Bulletin:
- 6383
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Subject regarding transmission exhibiting a fluid leak at the extension housing area. *tt
- Bulletin:
- 6417
- Component:
- 020000 suspension
- Summary:
- Addressing tire balance hints. *tt
- Bulletin:
- 6461
- Component:
- 010000 steering
- Summary:
- Concerns of a clunk felt / heard in the steering wheel. *t
- Bulletin:
- 12890
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Brief information on removing the fuel tank solenoid valve thread. *tt
- Bulletin:
- 12915
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Customer may complain of a clunk felt / heard in the steering wheel. *tt
- Bulletin:
- 996034
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing a engine knock at cold start-up. *tt
- Bulletin:
- 983180
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on the new 4r100 transmission. *tt
- Bulletin:
- 983315
- Component:
- 102000 power train:manual transmission
- Summary:
- The 4r100 transmission will have an orange "prior to repair" tag on the fluid pan. *tt
- Bulletin:
- 99164
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
- Bulletin:
- 991612
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on vehicles exhibiting a hard / no / slow starting condition. *tt
- Bulletin:
- 99141
- Component:
- 021500 suspension:front:control arm
- Summary:
- Subject regarding a high number of ball joints being replaced as the result of routine inspections or of complaints of tire wear and loose feelings in the steering system. *tt
- Bulletin:
- 99147
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
- Bulletin:
- 99141
- Component:
- 010000 steering
- Summary:
- Complaints of tire wear and loose feelings in the steering system. *tt
- Bulletin:
- 991411
- Component:
- 161000 structure:frame and members
- Summary:
- Some vehicles may exhibit a crack on the right rear side of the #1 crossmember resulting in a creaking noise while turning the wheel or driving over uneven surfaces. *tt
- Bulletin:
- 996701
- Component:
- 980000 unknown or other
- Summary:
- Vehicles with 5.4l engines and 9vza-ah or 9vza-bl calibrations may set a mil light with a diagnostic trouble code of p1406 (dpfe downstream hose off or plugged). *tt
- Bulletin:
- 996835
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on diagnosing vehicles with 4r100 transmissions exhibiting turbine shaft speed (tss) sensor diagnostic trouble codes p0715 / 0717 / 0718. *tt
- Bulletin:
- 996889
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on 7.3l dit vehicles exhibiting an intermittent engine knock which may be perceived as a rod knock. *tt
- Bulletin:
- 996890
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Some vehicles with an illuminated air bag lamp may have modified seat configurations which may have been changed by modifiers or the customer. *tt
- Bulletin:
- 9913121
- Component:
- 980000 unknown or other
- Summary:
- Engineering is currently investigating conditions with 4.6l equipped vehicles exhibiting a mil and diagnostic trouble codes p0350 - p0354. *tt
- Bulletin:
- 99E03
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Emission recall for vehicles that were built with a fuel filler-valve which could leak while the vehicle is being operated which can exceed evaporative emissions standards. *tt
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99185
- Component:
- 980000 unknown or other
- Summary:
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
- Bulletin:
- 99186
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit an intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
- Bulletin:
- 991811
- Component:
- 162000 structure:body
- Summary:
- Subject regarding front passenger side stepwell cover not flush. *tt
- Bulletin:
- 99192
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- On some vehicles without cruise control, the engine may idle at the normal engine rpm but lacks the cold engine idle kicker function to raise the engine rpm similar to those vehicles equipped with cruise control. *tt
- Bulletin:
- 99194
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 99197
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
- Bulletin:
- 99236
- Component:
- 102000 power train:manual transmission
- Summary:
- Subject regarding 4r100 transmission flexplate replacement for vehicles with 7.3l diesel engine. *tt
- Bulletin:
- 992311
- Component:
- 980000 unknown or other
- Summary:
- Experiencing intermittent or low range of the remote keyless entry (rke) system. *tt
- Bulletin:
- 99242
- Component:
- 162300 structure:body:door
- Summary:
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
- Bulletin:
- 6902
- Component:
- 980000 unknown or other
- Summary:
- Vehicles equipped with 4.6l engines may exhibit a malfunction indicator lamp and diagnostic trouble codes p0350 - p0354 for the coil system. *tt
- Bulletin:
- 6910
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicles built after 5/19/1999 with the 7.3l dit with a engine serial # greater than 1039780 now have a filter screen added to the high pressure oil reservoir. *tt
- Bulletin:
- 6999
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding e40d / 4r100 transmission fluid cooler flow test specification. *tt
- Bulletin:
- 13180
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
- Bulletin:
- 13187
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding e40d/4r100 transmission fluid cooler flow test specification. *mjs
- Bulletin:
- 13215
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information regarding fuel cackle. *mjs
- Bulletin:
- 13254
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information regarding fuel cackle. *mjs
- Bulletin:
- 7133
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit fuel cackle in warm weather and / or in a high altitude area. *tt
- Bulletin:
- 7239
- Component:
- 980000 unknown or other
- Summary:
- Vehicles equipped with 4.6l engine built march 1, 1999 or later may exhibit a check engine light with a diagnostic trouble code (dtc) of p0351 to p0354. *tt
- Bulletin:
- 7263
- Component:
- 034400 service brakes, hydraulic:foundation components:drum
- Summary:
- Some vehicles with rear brake drums may exhibit brake squeal noise. *tt
- Bulletin:
- 7310
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Some vehicles without front brake dust shields may exhibit premature wear of the front wheel bearings due to damaged inner wheel bearing seals. *tt
- Bulletin:
- 13367
- Component:
- 034430 service brakes, hydraulic:foundation components:drum:drum
- Summary:
- Some vehicles with rear brake drums may exhibit brake squeal noise. *tt
- Bulletin:
- 6383
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Some vehicles equipped with 5.4l and 4r70w transmision may exhibit a fluid leak at the extension housing area. *tt
- Bulletin:
- 6505
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Brief information on removing the fuel tank solenoid valve on natural gas vehicles. *tt
- Bulletin:
- 6538
- Component:
- 010000 steering
- Summary:
- Some vehicles built before april 1, 1999 may have a customer concern of a clunk felt / heard in the steering wheel. *tt
- Bulletin:
- 6581
- Component:
- 022000 suspension:rear
- Summary:
- Some vehicles equipped with either dana 80 or s135 axle may exhibit fluid leakage from the axle vent tube due to fluid overfill. *tt
- Bulletin:
- 6585
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles equipped with 7.3l dit diesel engines may develop a cracked flexplate. *tt
- Bulletin:
- 13009
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with 5.4l engines and 9vza-ah or 9vza-bl calibrations may set a malfunction indicator light on with a diagnostic trouble code of p1406 (dpfe downstream hose off or plugged). *tt
- Bulletin:
- 7475
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles equipped with 73l dit engine may exhibit a rough engine idle. *tt
- Bulletin:
- 13488
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles equipped with 7.3l dit engine may exhibit a rough engine idle. *tt
- Bulletin:
- 0015
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding the new transmission cooler flusher- service tip. *mjs
- Bulletin:
- 8046
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on reprogramming the pcm with the latest calibration. *tt
- Bulletin:
- 7895
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Without front brake dust shields may exhibit premature wear of the front wheel bearings due to damaged inner wheel bearing seals.
- Bulletin:
- 0022
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles may experience particle contaminants, from prior transmissiion concerns or excess wear, may be trapped in the transmission fluid cooling system if not properly flushed. *mjs
- Bulletin:
- 0038
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
- Bulletin:
- 8260
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Some vehicles may exhibit a-pillar sheet metal cracks around front door hinges; front door skin separates and door inner sheet metal cracked around front hinges; or front doors open too far and extend into the front fenders. *tt
- Bulletin:
- 13763
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Vehicles without front dust shields may exhibit premature wear of the front wheel bearings due to damaged inner wheel bearing seals. *mjs
- Bulletin:
- 13820
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information regarding (not) to reprogram a pcm with the latest calibration on a pre-december 1998 build date. *mjs
- Bulletin:
- 0068
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicles may exhibit a hesitation on acceleration just off idle and or misfire concers may be present on some vehicles accompanied with a malfunction indicator lamp (mil) illuminated and diagnostic trouble codes (dtcs).
- Bulletin:
- 00610
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Information on the 7.3l dit engines, rotunda tool has issued an injector performance analyzer that may now be pruchased as an effective aid in helping to resolve rough idle concerns. *mjs
- Bulletin:
- 00611
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs
- Bulletin:
- 13934
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Some vehicles may exhibit a-pillar sheet metal cracks around front door hinges; front door skin separates and door inner sheet metal cracked around front hinges; or front doors open too far and extend into the front fenders. *tt
- Bulletin:
- 00510
- Component:
- 020000 suspension
- Summary:
- Customers may be concerned that vehicle looks like it dogtracks, due to a unique feature of the vehicle that combine to create an optical illusion of dogtracking, a condition which the rear axle is not square to the chassis. *mjs
- Bulletin:
- 12070
- Component:
- 021000 suspension:front
- Summary:
- Vehicles that are loaded to the upper end of fvw, with the majority of the load between the axles, may exhibit inner edge tire wear due to incorrect alignment. *mjs
- Bulletin:
- 985035
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Some vehicles (built after 1/5/98) and all vehicles equipped with 7.3l diesel engine and 4r100 transmission may exhibit a rattle / scrapping noise in the converter housing area of the case. *tt
- Bulletin:
- 12104
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code dtc 1728 in memory. *mjs
- Bulletin:
- 12123
- Component:
- 021000 suspension:front
- Summary:
- Vehicles may exhibit a steering pull to the right or left, due to incorrect front end alignment settings. *mjs
- Bulletin:
- 12139
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs
- Bulletin:
- 12162
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 6.8l engines, may exhibit a customer concern or engine roar or engine noise for the first few minutes of operation after a cold start. *mjs
- Bulletin:
- 12187
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a hard to diagnose squeak/rattle noise concern. *mjs
- Bulletin:
- 985102
- Component:
- 021000 suspension:front
- Summary:
- Some vehicles that are loaded to the upper end of gvw, with the majority of the load between the axles, may exhibit inner edge tire wear due to incorrect alignment. *tt
- Bulletin:
- 985141
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code 1728 in memory. *tt
- Bulletin:
- 985153
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a steering pull to the right or left. *tt
- Bulletin:
- 14184
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 7.3 dit engine may exhibit engine roughness, misses, buck / jerk, hesitation / stumble, surge, lack of power, various idle symptoms, malfunction indicator lamp on, etc. *tt
- Bulletin:
- 6290
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Information regarding the improved radiator support. *tt
- Bulletin:
- 12741
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Some vehicles under severe duty cycles may exhibit cracks on the lower radiator support. *tt
- Bulletin:
- 13077
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on diagnosing turbine shaft speed (tss) sensor diagnostic trouble codes p0715 / p0717 / and p0718. *tt
- Bulletin:
- 13114
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject regarding medium trucks equipped with 7.3l dit exhibiting fuel cackle. *tt
- Bulletin:
- 13116
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some medium trucks equipped with 7.3l dit may exhibit an intermittent engine knock perceived to be fuel cackle. *tt
- Bulletin:
- 13117
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Some vehicles with an illuminated air bag lamp may have modified seat configurations. *tt
- Bulletin:
- 12835
- Component:
- 190000 tires
- Summary:
- Subject regarding tire balance hint. *tt
- Bulletin:
- 12870
- Component:
- 010000 steering
- Summary:
- Some customers may comment on a clunk felt / heard in the steering wheel. *tt
- Bulletin:
- 13311
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles equipped with 4.6l engines may exhibit a check engine light with a diagnostic trouble code of p0351 to p0354. *tt
- Bulletin:
- 13317
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 7.3l dit diesel engine may exhibit fuel cackle in warm weather and / or in a high altitude area. *tt
- Bulletin:
- 13398
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Some vehicles without front brake dust shields may exhibit premature wear of the front wheel bearings due to damaged inner wheel bearing seals. *tt
- Bulletin:
- 99-8-15
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding door trim panel replacement - service tip. *tt
- Bulletin:
- 99111
- Component:
- 980000 unknown or other
- Summary:
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
- Bulletin:
- 991210
- Component:
- 980000 unknown or other
- Summary:
- Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
- Bulletin:
- 99152
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on the new flush and fill tool available through rotunda. *tt
- Bulletin:
- 4981
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt
- Bulletin:
- 5141
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code (dtc) 1728 in memory.dtc 1728 is defined as internal transmission element slippage. this splippage can occur anywhere in the transmission includ
- Bulletin:
- 5225
- Component:
- 162000 structure:body
- Summary:
- Information on vehicles exhibiting a hard to diagnose squeak / rattle noise concern. *tt
- Bulletin:
- 5257
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on vehicles exhibiting cold engine knock. *tt
- Bulletin:
- 12230
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
- Bulletin:
- 00L05
- Component:
- 355100 equipment:other:labels
- Summary:
- This service action requires the replacement of two emission control labels. *tt
- Bulletin:
- 00239
- Component:
- 110000 electrical system
- Summary:
- A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 00261
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
- Bulletin:
- 00221
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with powerstroke diesel engines after serial number 0896812 (engine build date), may exhibit a noise above the normal sound of the diesel combustion.*jb
- Bulletin:
- 00154
- Component:
- 106000 power train:axle assembly
- Summary:
- Information on rear axle whine-vehicles equipped with dana 80 axles-5.4l/6.8l and 7.3l. *jb
- Bulletin:
- 00154
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles with dana 80 rear axles may exhibit an excessive amount of axle whine noise. *jb
- Bulletin:
- 14365
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
- Bulletin:
- 0147
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
- Bulletin:
- 13820
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on reprogramming a pcm with the latest calibration on certain vehicles equipped with a 7.3l diesel engine. a new calibration was recently released to provide improved mil diagnostic and to correct a 4r100 transmission surge at
- Bulletin:
- 14160
- Component:
- 980000 unknown or other
- Summary:
- A condition may exist where the malfunction indicator lamp is on with diagnostic trouble code p0340 (camshaft position (cmp) sensor a circuit) stored, accompanied with a driveability concern. *tt
- Bulletin:
- 14184
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 7.3l dit engine may exhibit an engine that runs rough, misses, buck / jerk, hesitate / stumble, surge, lacks power, various idle symptoms, malfunction indicator lamp on. *tt
- Bulletin:
- 14310
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit an incorrect p1729 (4x4 low switch) diagnostic trouble code (dtc) in continues memory. *tt
- Bulletin:
- 01146
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some super duty f series and other vehicles equipped with a powerstroke diesel engine may exhibit a noise above the normal sound of the diesel combustion. this noise may sound like a rod knock, but it is intermittent and it increases i
- Bulletin:
- 011406
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with a powerstroke diesel engine may exhibit a noise above the normal sound of the diesel combustion. *tt
- Bulletin:
- 01119
- Component:
- 161000 structure:frame and members
- Summary:
- Some vehicles with high odometer reading or severe service may exhibit a creaking noise when turning wheel or driving over uneven surfaces on vehicles produce before 2/6/2001. *tt
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 15271
- Component:
- 091110 fuel system, other:storage:tank assembly:filling/charging
- Summary:
- Dedicated cng regulator bowl kit available. *jg
- Bulletin:
- 15686
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Concerns of diagnostic trouble code p1280 retrived fromthe power train control module (pcm). *tt
- Bulletin:
- 15871
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Some vehicles may exhibit interference and / or static in the land-mobile radio. *tt
- Bulletin:
- 16683
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- False failure of the vapor management valve (vmv). *tt *jb
- Bulletin:
- 16697
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Exhaust air rush noise and lower power. *tt *jb
- Bulletin:
- 16916
- Component:
- 110000 electrical system
- Summary:
- Repeated blown fuses for rear in vehicle circuits with inoperative rear brake or tail lamps. *tt
- Bulletin:
- 03148
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
- Bulletin:
- 032132
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles equipped with aftermarket modifications may exhibit a crank but no start or a hard start/long crank condition. *tt
- Bulletin:
- 032134
- Component:
- 110000 electrical system
- Summary:
- The malfunction indicator lamp (mil) may illuminate with a false diagnostic trouble code (dtc) p1298 (injector drive module (idm) failure). *tt
- Bulletin:
- 032137
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- For 7.3l dit engines, rotunda tool has issued an injector performance analyzer that may now be purchased as an effective aid in helping to resolve rough idle concerns. *tt
- Bulletin:
- 032138
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles equipped with 7.3l dit engine built after engine serial number 896812 may have a injection control pressure (icp) oil aeration reading that is higher than the specification. *tt
- Bulletin:
- 13621
- Component:
- 110000 electrical system
- Summary:
- Improvements to malfunction indicator lamp (mil) diagnostics. *tt
- Bulletin:
- 16258
- Component:
- 110000 electrical system
- Summary:
- Vehicles equipped with a 7.3l engine (after serial number 0661894) - under valve cover (uvc) harness retainer clip released for service. includes 2003 econoline, super duty, f650/750 and excursion. *tt
- Bulletin:
- 16480
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code (dtc) p0340, possible false code. various models including 1994-1996 ford excursion. *tt
- Bulletin:
- 17467
- Component:
- 080000 fuel system, diesel
- Summary:
- Engine or fuel system concerns when using fuel with greater than 5% biodiesel concentration. *tt
- Bulletin:
- 04E10
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Emission recall 04e10: compressed natural gas (cng) vehicles - fitting connector replacement. *mj
- Bulletin:
- 17385
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Air bag lamp illuminated. *tt
- Bulletin:
- 17406
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low power, poor fuel economy, fuel gelling cold, excessive white smoke cold, or hard start. *mj this oasis updates previous oasis dated 12/01/03. *tt
Home | Privacy